2017 Chrysler Pacifica Plug-In Hybrid fuel system problems
37 of the
127 complaints about the 2017 Chrysler Pacifica Plug-In Hybrid are about the
fuel system — 29% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
42,223 miles.
F
37
Complaints
0
Crashes
4
Fires
1
Injuries
Exactly what failed
Hybrid Propulsion System
1951.4%
Fuel/Propulsion System
1848.6%
Fuel & Propulsion across every Chrysler Pacifica Plug-In Hybrid year
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V536000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The contact stated that the battery had previously been replaced. The check engine warning light had illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 77,000. VIN tool confirms parts not available.
NHTSA complaint #11615657 — an unverified report by a vehicle owner.
Kildeer, ILFire
FUEL/PROPULSION SYSTEM
The car's lithium batteries caught fire to the point of smoldering. This happened at the end of the charge cycle. The car was parked in our garage and if the fire department did not come to help, the fire could have intensified and burned down our whole house. We are very thankful we caught it so quickly. No warnings or issues were apparent with the vehicle when it was parked and put on the charger.
NHTSA complaint #11558139 — an unverified report by a vehicle owner.
Oakland, CAFire
FUEL/PROPULSION SYSTEM
What component or system failed or malfunctioned, and is it available for inspection upon request? - Internal charging system or vehicle battery pack malfunctioned & caught fire. Vehicle is available for inspection now, but not sure about when it is removed from our property. How was your safety or the safety of others put at risk? - It was a big fire! Close to structures, vehicles & dry foliage – super lucky it didn't spread. Smoke was very noxious and affected our entire neighborhood. Neighbors have reported respiratory irritation since the fire. I now have a cough, burning throat and headaches. Has the problem been reproduced or confirmed by a dealer or independent service center? - There's a burned out van at the end of my driveway... specific instance of this problem does not need confirmation Similar issues are reported on the internet. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Not yet. Chrysler says it'll take 2-3 days for issue to be "escalated". Insurance is sending someone. Fire department HazMat crew verified that the battery pack is now "cold" but toxic chemicals are a public safety hazard. Oakland Fire incident #[XXX]. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - July 2022 the vehicle refused to charge & displayed a "turtle" icon. Took it to the dealer and told of the charging/fire recall. Stopped charging until all the recall parts were available which wasn't until August 2023. After repair, we were told the car was OK & it was safe to resume charging the car. Other details: - The vehicle caught fire while charging, engulfed in flames, had to be extinguished by Fire department, total loss. Car plugged in at ~4:30pm and we heard a "pop" at ~8:20pm. So the battery had reached 100%. Ran out and there was small fire dripping from middle underside of the car– quickly spread & consumed the entire car INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I
NHTSA complaint #11553283 — an unverified report by a vehicle owner.
at 68,849 milesScottsdale, AZ
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica. The contact stated while driving 75 MPH, the check engine warning light was illuminated, and there was a burning odor coming from the A/C vents. The contact veered to the side of the road and noticed that the burning odor was also coming from underneath the hood of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the catalytic converter and oxygen sensors needed to be replaced. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 18V740000 (Hybrid Propulsion System, Engine and Engine Cooling) in 2018. The contact stated that the recall remedy was not effective. The vehicle was taken to the dealer where it was diagnosed; however, the dealer declined to provide diagnostic information to the contact after several attempts. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 68,849.
NHTSA complaint #11501537 — an unverified report by a vehicle owner.
San Leandro, CAFire2 injured
FUEL/PROPULSION SYSTEM
We had the FCA Recall #Z11, NHTSA Recall #22V-077 repaired on this vehicle. One week later, the plug-in hybrid Pacifica was parked in the garage, plugged in but done charging. In the middle of the night, the battery spontaneously combusted. We heard a loud boom sound and found the car smoldering and emitting significant amounts of smoke. The car then burst into flames. The fire department soaked the car with water but it continued to reignite for approximately two hours despite the fire department’s best efforts to extinguish the fire. The car was completely destroyed. It also caused significant chemical smoke damage to our garage and home. As soon as we found it smoking, we rolled it out of the garage, which saved our house from catching on fire. Luckily our children were not in or next to the car at the time the battery combusted. There were no warning signs in the car prior to this incident. The vehicle has been inspected by insurance and is available for further inspection. At least two members of the family experienced adverse health consequences following the smoke exposure.
NHTSA complaint #11496917 — an unverified report by a vehicle owner.
at 39,947 milesPittsburgh, PA
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica. The contact stated while driving 55 MPH, the battery level was low and the warning message stating to plug in the vehicle to charge and to decelerate was illuminated. The vehicle stalled and lost motive power; however, the contact was able to pull over. The contact attempted to restart the vehicle several times. The contact stated that the vehicle started up for several minutes but then stalled. The vehicle was towed to the dealer and the contact was informed that the vehicle needed to be charged for a full day, but no failure was found. The mechanic at the dealer had experienced the vehicle unintendedly accelerating. The dealer stated that the failure would be reported to the manufacturer. The manufacturer was contacted but stated that there was no record of the failure. The failure mileage was 39,947.
NHTSA complaint #11495433 — an unverified report by a vehicle owner.
Chicago, IL
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11485879 — an unverified report by a vehicle owner.
Winston-Salem, NC
FUEL/PROPULSION SYSTEM
Recall Z11 was announced in early February 2022 due to fire risk which prompted Chrysler to issue a recommendation that owners not charge their plug-in hybrid Pacifica Hybrids and to park them outside until the fix was completed. More than six months have passed without subsequent update to resolve this recall, and not only is no part or remedy identified, the underlying cause has yet to be identified. This is after two previous recalls, U94 in October 2018 and W46 in June 2020, which were also announced by Chrysler due to fire risk for the Pacifica Hybrid. Chrysler's guidance of parking the vehicle outside and not plugging it in to charge is unsatisfactory and illogical. The normal operation of the plug-in hybrid system leads to the gasoline engine and regenerative braking charging the high-voltage battery during its "Hybrid Mode" operation even when the vehicle has not been plugged in to charge the high-voltage battery. Based upon other recent fire risk recalls related to vehicles with high-voltage batteries such as the Chevrolet Bolt EV--which has led to numerous manufacturer repurchases and complete battery replacement for all affected models--Chrysler's response is neither timely nor sufficient. It is past time that definitive resolution be provided to owners of vans that have already been affected by two prior fire risk recalls and now have been waiting six months with recommendation to not use the vehicle as designed, marketed, and advertised at the time of sell. Given the unresolved nature of recall Z11, I request action be taken to require manufacturer buybacks of the affected products at this time.
NHTSA complaint #11481107 — an unverified report by a vehicle owner.
Asheville, NC
FUEL/PROPULSION SYSTEM
PHEV Fire risk recall has not been completed in a timely manner. Vehicle is potentially unsafe, Stellantis does not appear to understand the underlying problem or the risk to the consumer. Is our family and home at risk from a fire? When will this be remedied? It's been over 6 months and have had only silence from Stellantis.
NHTSA complaint #11479318 — an unverified report by a vehicle owner.
Discovery Bay, CA
HYBRID PROPULSION SYSTEM
The contact owns a 2018 Chrysler Pacifica. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.
NHTSA complaint #11478742 — an unverified report by a vehicle owner.
West Columbia, SC
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11478164 — an unverified report by a vehicle owner.
Sequim, WA
FUEL/PROPULSION SYSTEM
Recall was issued February 18, 2022. Have not been able to park in garage or plug in charger since recall. Numerous calls and letters and emails have resulted in nothing but sympathy. This recall is definitely not being handled in a timely manner! This idiocy needs to get more attention….quickly!
NHTSA complaint #11477414 — an unverified report by a vehicle owner.
Medford, OR
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11476166 — an unverified report by a vehicle owner.
Ashburn, VA
FUEL/PROPULSION SYSTEM
Received notice about the Z11 recall for potential fire risk earlier this year. It's been over 5 months since the initial recall notice, and Chrysler/Stellantis has not issued any further communication. Vehicle cannot be operated as intended without a solution from the manufacturer. We've waited well-past a reasonable amount of time for some kind of update on a potential fix, and have yet to receive so much as an offer for rental reimbursement (or a buyback, which would be preferred at this point).
NHTSA complaint #11475310 — an unverified report by a vehicle owner.
San Jose, CA
FUEL/PROPULSION SYSTEM
We own a 2018 Chrysler Pacifica Hybrid. The VIN was included in NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, AFTER 5 months, the part to do the recall repair is not yet available. The manufacturer had exceeded a reasonable amount of time for the recall repair. We have not experienced a failure, however we cannot charge the car and are instructed to park it away from other structures and vehicles. The car is almost useless and likely has lost all value. The VIN tool confirms parts not available.
NHTSA complaint #11473925 — an unverified report by a vehicle owner.
at 78,000 milesSedona, AZ
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving approximately 50 MPH, the vehicle stalled. The contact stated that the charging malfunction warning light was illuminated. The contact rested the vehicle for approximately 1 1/2 - 2 hours before being able to restart the vehicle. The contact had not taken the vehicle to the dealer to be diagnosed or repaired. The approximate failure mileage was 78,000. VIN tool confirms parts not available.
NHTSA complaint #11473401 — an unverified report by a vehicle owner.
Knoxville, TN
FUEL/PROPULSION SYSTEM
The Z11 recall is not being handled in a timely manner, and Chrysler is not being forthcoming with a solution.
NHTSA complaint #11472569 — an unverified report by a vehicle owner.
Cazenovia, NY
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica. The contact received a notification for NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11471138 — an unverified report by a vehicle owner.
at 62,000 milesResaca, GA
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact stated that while turning either left or right, the steering wheel seized. The contact stated that the failure was related to NHTSA Campaign Number: 19V348000 (Electrical System) however, the VIN was not included. The contact then received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000. VIN tool confirms parts not available.
NHTSA complaint #11469522 — an unverified report by a vehicle owner.
Pittsburgh, PA
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. The consumer stated the Van will not charge.
NHTSA complaint #11464925 — an unverified report by a vehicle owner.
Portland, OR
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11464765 — an unverified report by a vehicle owner.
South Bend, IN
FUEL/PROPULSION SYSTEM
I received the recall notice for possible fires created by the battery system for propulsion. After two calls to Chrysler and just having had the regular 12 V engine battery replaced at a very expensive cost, still no solution to the recall. The Chrysler dealer who replaced the battery also had no knowledge of when a fix would be available or what it might be. My suspicion is that the fix will be an entirely new propulsion battery. THE CONSUMER REQUESTED INFORMATION ON AN ESTIMATED TIME OF WHEN A REMEDY WOULD BE AVAILABLE.
NHTSA complaint #11464378 — an unverified report by a vehicle owner.
at 98,000 milesCanton, OH
HYBRID PROPULSION SYSTEM
The contact owns a 2018 Chrysler Pacifica. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The vehicle was taken to the local dealer and it was confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms parts not available.
NHTSA complaint #11458999 — an unverified report by a vehicle owner.
Yucaipa, CA
HYBRID PROPULSION SYSTEM
The contact owns a 2018 Chrysler Pacifica. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The dealer was notified of the issue and confirmed that parts were not yet available. The manufacturer had also been notified of the recall and confirmed the same information as the dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11458864 — an unverified report by a vehicle owner.
Jacksonville, FL
HYBRID PROPULSION SYSTEM
The contact owns a 2018 Chrysler Pacifica. The contact received a notification for NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The contact called the local dealer and Jacksonville Chrysler Dodge Jeep Ram Arlington (9600 Atlantic Blvd, Jacksonville, FL 32225) and both confirmed that the part to do the recall repair was not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11457768 — an unverified report by a vehicle owner.
Jacksonville, FL
FUEL/PROPULSION SYSTEM
It has been over a month now and Chrysler has not issued a fix for the latest recall to the PHEV propulsion system. The fact that it could catch fire at any time is concerning and it should be fixed quickly or the owners should be able to receive a loaner. This recall frightens the owners into not wanting to drive the vehicle. Not good.
NHTSA complaint #11457458 — an unverified report by a vehicle owner.
Elma, WA
HYBRID PROPULSION SYSTEM
The contact owns a 2017 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11456787 — an unverified report by a vehicle owner.
North Potomac, MD
HYBRID PROPULSION SYSTEM
The contact owns a 2018 Chrysler Pacifica. The contact received a notification for NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11456624 — an unverified report by a vehicle owner.
Palo Alto, CA
HYBRID PROPULSION SYSTEM
The contact owns a 2018 Chrysler Pacifica. The contact received a notification for NHTSA Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The dealer had been notified contacted and confirmed that parts were not yet available. The manufacturer was made aware of the issue and informed her that they could not offer her a loaner vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available. Consumer is unable to drive the vehicle due to mechanical failure. Car cannot be parked in the carport or near a tree because car can catch fire when off.
NHTSA complaint #11454682 — an unverified report by a vehicle owner.
at 30,689 milesLawrenceville, GA
FUEL/PROPULSION SYSTEM
ON THREE SEPERATE OCCASIONS OVER THE PAST FIVE MONTHS, I HAVE ENCOUNTERED THE SAME ISSUE. WHILE DRIVING BETWEEN 75-80MPH ON THE HIGHWAY WITH 32-44% LIFE ON THE HYBRID BATTERY, THE VEHICLE HAS SHUT OFF THE ENGINE. A MESSAGE COMES UP ON THE CLUSTER THAT I MUST PUT THE VEHICLE IN PARK TO DRIVE. THE ACCELERATOR DOES NOTHING AND POWER STEERING IS LOST. I MUST COAST OFF THE HIGHWAY. ONCE PARKED, THE VEHICLE IS IN A STATE THAT CANNOT BE TURNED ON/OFF. THE VEHICLE START BUTTON SHOWS THAT THE VEHICLE IS ON, BUT THE ENGINE IS STILL OFF. ALL OTHER ELECTRONICS IN CAR LIKE STEREO AND BLUETOOTH WORK AS THE CENTER TOUCHSCREEN REMAINS ACTIVE. TOUCHING THE START BUTTON MAKES THIS FLICKER TO OFF, BUT IT IMMEDIATELY RETURNS TO THIS STATE. MY VEHICLE HAS BEEN AT THE CHRYSLER DEALER TWICE ALREADY AND CURRENTLY IS THERE FOR A THIRD TIME TO RESOLVE THIS ISSUE, BUT THEY HAVE NO SOLUTION. THIS IS DEADLY!
NHTSA complaint #11235056 — an unverified report by a vehicle owner.
Other 2017 Chrysler Pacifica Plug-In Hybrid problems