2022 Chrysler Pacifica Plug-In Hybrid fuel system problems

HYBRID PROPULSION SYSTEM

The contact owns a 2022 Chrysler Pacifica Hybrid. The contact stated that while driving at various speeds in Hybrid Mode, the vehicle occasionally failed to accelerate as intended while depressing the accelerator pedal. In addition, the contact stated that the vehicle failed to maintain speed, and gradually decelerated while the accelerator pedal was being depressed. No warning light was illuminated. The contact stated that the vehicle was previously repaired several times by the local dealer. The vehicle was taken to a local dealer and remained with the dealer for further diagnostic tests and repair; however, the cause of the failure remained unknown. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

NHTSA complaint #11645107 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

While driving on the interstate in heavy traffic car displayed "Stop Safely - Vehicle will shut off soon" power was reduced and van started slowing down. Turning the vehicle off and on again cleared the problem. Dealer installed a software update and informed us the issue was corrected. Problem persists, happened again at interstate speeds in traffic. Vehicle is now again in the shop for diagnosis.

NHTSA complaint #11633717 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

As I was driving on the highway, the warning "Stop Safely Vehicle Will Shut Off Soon" with a red turtle icon appeared. The warning indicator light also appeared. The car began to decelerate on its own as I tried to merge across several lanes of highway traffic to get to the shoulder and stop. This first happened on Thursday December 12 (also in a highway scenario). The vehicle was inspected by my dealer from December 16-18. During that time the dealer updated software and replaced drivers side PHEV engine mount. The dealer cites "Bulletin 21-042-24" as guidance for their troubleshooting. The dealer says if the problem returns, the vehicle will "need transmission according to bulletin 21-042-24." I drove the vehicle fine on December 19-20 but the problem returned on Saturday, December 21. So the problem has occurred twice in 9 days.

NHTSA complaint #11631913 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

We purchased a 2022 Pacifica Hybrid in Feb of 2024 that is still under full factory warranty. We had the vehicle serviced once for A/c issues and it's regularly scheduled 30k mile service in April and May. [XXX] our van had a. Catastrophic failure in Texas, where it has remained since June 1st. The deep cycle hybrid battery overheated, making it inoperable. They have replaced the deep cycle hybrid battery twice-those batteries run 15-16k$, plus the additional parts and labor. Stellantis customer service promised rental reimbursement for the 2 vehicles we had to rent to continue our trip to Arizona. Then they declined to reimburse for both. They also stated they would pay for rentals ongoing while our van was in Texas and after we rented a van for two additional weeks, refused to pay for that. We requested a buyback at week 7 and that was denied. Two weeks ago, they stated the van was repaired and it sat in Texas while the dealership argued with Stellantis customer service about who was responsible for returning our van. Finally chrysler agreed to ship it to us and while the area manager was driving the van to the loading point for the shipping company, it had the same catastrophic failure. Chrysler had it towed to a different dealership in Texas and that dealership says they are going to start over and hopefully they can diagnose the issue fully, but they will have to replace the battery for a. 3rd time, totaling 4 batteries in 3 months or 64k$..The vehicle purchase price was 42k$. We purchased extensive extended warranties. We put down 24,500$ in cash and trade. We have since found out that a dealer in New Jersey put this car back on the market after they knew there was something wrong with it and made it someone else's problem. The selling dealership had no way of knowing the vehicle battery would overheat in the summer, as they purchased it from auction in November and sold it to us in Feb. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11608890 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

We were driving on the highway when we got a warning to pull over safely as the vehicle will shut down soon. The accelerator became unresponsive, and the vehicle began losing power. This has happened a number of times and we took it into the dealer who replaced the transmission. However, on various social media sites, it has been reported that this has been happening to many many people. This is an extremely dangerous situation for so many people unaware of the potential. As I understand it, they replace the transmission with a like transmission. The problem is not actually being solved. They are simply offering a short term fix with the potential for it to happen again. It is reported by others that their second transmission has done the same thing. Below is one example of a social media post where others have claimed the same issue. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11606696 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Vehicle shut down. Engine light came on. Confirmed electric inverter was the code. PIM module needs to be replaced.

NHTSA complaint #11606552 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Van lost motive power and screen showed the attached warning message. Waiting on dealership to replace the transmission, but it's backordered with no estimated availability.

NHTSA complaint #11601308 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Driving at Interstate speed, dash message stated to pull over, engine shutting down. Coasted to stop on shoulder. Waited 5 minutes, turned on ignition, check engine light was on. Restarted vehicle, drove ~20 miles and same occurrence. Was able to return home to dealership. The OBD reader said the PCM (Powertrain control Module) had failed. Service Dept. sent info to Chrysler Corp. Service, which stated the transmission was at fault. Car mileage was ~16,500 miles. Under warranty, the transmission is being replaced.

NHTSA complaint #11597804 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Driving on highway and got a message saying "Stop Safely - Vehicle Will Shut Off Soon". Pulled over to the shoulder before the engine stopped once. researched the issue and tried to drive to a dealership. Stayed in right lane and the issue happened a second time with the same message displaying and this time, I actually did lose propulsion, but was able to safely park on the shoulder again.

NHTSA complaint #11584654 — an unverified report by a vehicle owner.

HYBRID PROPULSION SYSTEM

The contact rented a 2022 Chrysler Pacifica Hybrid. The contact stated that while driving at approximately 70 MPH, there was a message that stated the vehicle was going to shut down. The check engine warning light illuminated, and the vehicle stalled. The vehicle was not able to be restarted. The vehicle was pushed to the side of the road. The vehicle was towed to a car rental office. The manufacturer was not notified of the failure. The failure mileage was approximately 35,504. The VIN was not available.

NHTSA complaint #11575969 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I ran into a very dangerous situation last Monday. I was driving on a freeway and car Brokedown, accelarator unresponsive , got "Service charging system" car lost power It was very dangerous and someohow I was able to get into Shoulder lane and with God's grace we survived. After 3 4 minutes I was able to get my car turn off and on and then it drove with minimal speed 12m/hr. So I decided to take it in nearby open parking area and get it towed. This is serious life threatening especially with family.

NHTSA complaint #11571303 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

This letter is for a near fatality while driving my new 2022 Chrysler Pacifica Hybrid on October 30th, 2023. While driving back home on a dark and stormy night with poor visibility on i87 North my 2022 Chrysler Pacifica Hybrid shutdown nearly causing a fatal accident. My 3 kids (ages 4, 5, and 8) were in the car with me. The car blinked power and i lost motor function (no acceleration), the car went from around 70-75 miles per hour to almost 40 forcing me to try and get over to the shoulder. During this stressful process a mac truck nearly ran us off the road traumatizing me and my kids. While on the shoulder I tried everything to get the car back on, after turning off and on the car several times I was able to drive very slowly (max speeds of 1-20 miles per hour) with me pressing the gas pedal at full throttle. I was able to get off the New Palz exit which was 4 miles from the incident and call triple A for a tow truck back to Dutches Dodge. Since the incident, I've been working with FCA and looking for guidance on what can be done for my Family. The process has been very difficult with Dutches Dodge refusing to talk to us. Chrysler failed me with an unsafe car, I feel punished for being a responsible and safe driver. I brought in the car for recall 03A/NHTSA 23v-010 in July which did a software update for an internal transmission wiring connector. Based on the FCA case [XXX], I was told the STAR investigation found fault 21-008-23 which is for the internal transmission wiring connector. The software update does not seem to fix the issue, how many others are at risk? The car was proposed new on 12/13/2023 and had less than 12000 miles on it, all we know is the car needs an entire new transmission and new recall which we were not aware of for a serpentine belt. How can Chrysler assure us that the issue is fixed? Since the incident I have been dealing with post traumatic stress. Apart from having to take time off work and losing motivation I've felt that FCA does INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I

NHTSA complaint #11556032 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Service Charging System error. Car will not charge with level 1 or level 2 charger.

NHTSA complaint #11550940 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

After recall, vehicle continues to suffer from engine shutdown due to electrical fault in transmission wiring harness

NHTSA complaint #11542194 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Loss of motive power on highway, even after manufacture recall software upgrade.

NHTSA complaint #11528119 — an unverified report by a vehicle owner.

HYBRID PROPULSION SYSTEM

The contact owns a 2022 Chrysler Pacifica Hybrid. The contact stated that while driving at approximately 65 MPH, the vehicle lost motive power without warning. The 'Stop Safely, Vehicle Will Shut Off" message was displayed. The vehicle was able to be restarted. The vehicle was taken to a local dealer and was serviced under NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System). The vehicle was repaired; however, the contact stated that while driving at various speeds, the failure reoccurred. The vehicle was then taken to DCH Chrysler Dodge Jeep Ram FIAT Of Temecula (26845 Ynez Rd, Temecula, CA 92591), where it was diagnosed that an unknown software needed to be rebooted. The vehicle was repaired; however, the failure recurred, and the vehicle was taken back to the dealer, where it remained awaiting further diagnosis and repairs. The manufacturer was not made aware of the failure. The failure mileage was 5,930.

NHTSA complaint #11518104 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

During the month of March, 2023, my vehicle completely shut down on two occasions, both of which occurred while traveling at highway speeds. There were dash icons that were lit, including a check engine light, a turtle icon and a message to Pull Over. The shutdown caused me to move quickly to the shoulder of the road, with limited ability to maneuver in a safe manner. These shutdowns occurred after the vehicle had its software updated based on Recall 03A (Loss of Motive Power). Apparently, the update only served to provide a warning on the dash that the engine was about to shut down (which occurred immediately). The dealer has had the vehicle for some time, and the latest update is that they are replacing the vehicle's transmission. It would seem unacceptable if, in fact, a (known?) issue that causes a shutdown was addressed by merely providing a millisecond's notice that the vehicle is going to completely die. This is an extremely unsafe situation, placing the motorist, their passengers and nearby vehicles in danger.

NHTSA complaint #11515212 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

February 23rd: car shut off while getting off the freeway. Would not restart for 5 minutes. Had no acceleration but could still steer. February 23rd: brought car to the dealership, they scanned the car and there was no code. February 26th: car shut off 3 times on the freeway going 70mph. Had to pull over and restart car to be able to accelerate. I had my 2 kids in the car at this time and fear for their safety. March 1st- car shut off on the freeway going 70 mph. Had to pull over carefully again. Turn off the car, open the car door, wait a few minutes, restart. March 3rd- car shut off on the freeway again. Brought car to the dealership again, they asked for me to drop it off on Monday. March 6th- left car at dealership. They said it needs a new transmission and would be a minimum of 30 days to replace it, but most likely longer.

NHTSA complaint #11511675 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Van shutoff on the highway going 60- 65 mph with my wife and two kids under six. Winter time snow plowed road so no available shoulder due to snow mounds. Van quit running during rush hour. Car coasted to a stop and would not restart. Had to be towed. Dealer said it was a known issue. Googled it and there were news articles about the issue. Van gave no warning it was shutting down. Dealer has had the 2022 Chrysler Pacifica plug in hybrid for 30 days in the service shop and still don’t have a fix for it. Opened a case with Chrysler, Case Number 85533496

NHTSA complaint #11509422 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

While driving on the freeway at 60-70 mph, in 20 degree weather at night, the engine suddenly, and without warning, stopped. A dash error message showed instructions to put the car in park and push the start / run button. The van was still traveling at a high rate of speed while the message stayed up and the van had to be carefully maneuvered through traffic, across multiple lanes to the next exit, without the ability to accelerate when needed. Somehow no one was hurt and the vehicle did not get into an accident, but it came to a stop in the middle of the exit ramp, which had a steep uphill grade. The van was unable to be restarted. A Good Samaritan helped push the car to a nearby lot while car was in neutral. It was unable to be started then and two and three days later. The roadside assistance couldn’t be provided until a few days later because the incident occurred at the beginning of the weekend. The vehicle was finally towed to the closest dealership today. The dealership said the software update is available for the recall of potential loss of motive power, which appears to be the issue we experienced. They said it would take 2-3 weeks to look at the vehicle due to their backlog. I called the dealership where we bought it, and they said the same. Also, based on initial research, it seems the software update will only give advance warning when an electrical short is about to cause the engine to stop so the driver can have advanced warning and presumably drive to safety without an accident. Unfortunately, the manufacturer still needs to address the root cause and build a solution to prevent the electrical short from happening in the first place. The situation is troubling and the manufacturer and both dealerships are even stalling in getting us a complimentary loaner vehicle. Also note that we were not instructed to stop driving the vehicle when we found out about the recall prior to the incident. Again the van won’t be fixed for weeks, NHTSA shows no remedy yet

NHTSA complaint #11508248 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I drive on the freeway, and I lost any power with the car, I'm lucky my baby was not in my car on that day. It happened two times and I go to the Mopar service center, they tell me they don't have the part for that, and I ask them what's should I do with that situation, and they said that's a good question, I have no idea, but you can wait for the part and I don't know when the part comes in maybe a week, and maybe few months.

NHTSA complaint #11505578 — an unverified report by a vehicle owner.

HYBRID PROPULSION SYSTEM

The contact owns a 2022 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA complaint #11504361 — an unverified report by a vehicle owner.

HYBRID PROPULSION SYSTEM

The contact owns a 2022 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tools confirm parts not available.

NHTSA complaint #11503716 — an unverified report by a vehicle owner.

HYBRID PROPULSION SYSTEM: INVERTER

The contact owns a 2022 Chrysler Pacifica Hybrid. The contact stated while driving 40 MPH, the vehicle lost motive power and stalled without warning. The contact pulled over on the side of the road and the check engine warning light illuminated. The vehicle was towed to the dealer and the contact was informed that the power inverter module needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 3,100.

NHTSA complaint #11499950 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

We were driving our Chrysler Pacifica hybrid on the highway and it stalled and said put into park and completely turned off. When we pulled over to the side of the road, the car would not start and had to be towed to the dealership. It was very unsafe and not the first time that our car has turned off.

NHTSA complaint #11494519 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Have a 2022 Chrysler Pacifica Pinnacle which we picked up 10/8. This incident occured 11/3, Issue occurred with car under 1000 miles driven. So less than 1 month of ownership. Driving on 4 lane highway during stop and go traffic. Driving approximately 15-20 MPH. Car suddenly loses all forward motive power with engine light and battery light flashing on dashboard. in center dash it was saying "Service Charging System". Luckily, was able to coast to shoulder of highway. Was unable to restart car for 15 minutes, Car kept saying to put into P and until after completely turning the car off by opening the driver side door to simulate leaving the vehicle, and then closing the door. Drove to dealer and car stored DTC P0A45 error code, which they cleared and test drove for 50 miles. They could not reproduce the issue. Losing driving power is very dangerous while driving at any speed! this is a HUGE safety concern for my family with two small children. This needs to be investigated and a cause determined! This is a major accident or even death waiting to happen!

NHTSA complaint #11493551 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Twice now driving on the freeway in my brand new 2022 Plug-in Pacifica with 10K miles— all of a sudden there is a rumble (feels like a down shift) and the vehicle won’t accelerate. The dash message started flashing “Put in P to Start.” However, the car is still on and in “run.” I pulled over, put the vehicle in park, and turned it off. Then I had to push start button several times to unlock the shifter to go to drive again. A check engine light came on. The first time it happened, I finished my trip. Later that day when I had parked the car for a few hours the check engine light went off. The second incident happened a week later. The engine light came on. So I dove to the closest Auto Zone for a code reading. It came back at: P0A43.

NHTSA complaint #11489048 — an unverified report by a vehicle owner.