2004 Chrysler Sebring engine problems

ENGINE

Driving on [XXX] in Indiana my rpm’s began to accelerate and I hit my breaks and once I got to 30 mph my breaks went out. I looked online and one after another of complaints for exactly this has been posted in rooms. It was towed to our mechanic and hopefully he can figure out why INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11648298 — an unverified report by a vehicle owner.

ENGINE

Random stalling upon deceleration with no warning lights after stalling (as if the engine thinks it is still running). Occurs at low speed. Sometimes the engine will surge when the rpm drops off instead of stalling. I have almost run into other cars when the surging happens. The stalling occurs randomly and is becoming more frequent. A scan of the internet shows many others with same issue. No CEL.

NHTSA complaint #11527525 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2004 Chrysler Sebring. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with smoke coming from underneath the hood. Smoke then entered the cabin of the vehicle. No warning light was illuminated. Additionally, the odometer was inoperable. The contact restarted the vehicle; however, the failure recurred. The contact stated that her daughter had asthma; however, the contact and her two children did not receive medical attention. The dealer was made aware of the failure and informed the contact to tow the vehicle to their location. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was unavailable.

NHTSA complaint #11512130 — an unverified report by a vehicle owner.

ENGINE

I WAS DRIVING DOWN THE ROAD COMING TO A STOP LIGHT WHEN I NOTICED MY CAR HAD JUST TURNED OFF WITHOUT WARNING. LUCKILY THERE WAS A TURN LANE AND THE LIGHT WAS RED SO I DIDN'T CAUSE ANY ACCIDENT. AFTER THAT I TOOK MY CAR TO SEE WHY THE ENGINE LIGHT CAME ON AND THE MECHANIC SAID THE CODE STATED IT HAD TO DO WITH THE OXYGEN SENSOR. I REPLACED THE PART AND THE CAR RAN OK UNTIL ANOTHER TIME I WAS STOPPED AT A LIGHT AND THE CAR TURNED OFF AGAIN. I'VE NOTICED THE ENGINE LIGHT COMES ON AND THEN GOES OFF AFTER A COUPLE OF DAYS. I WAS TOLD I PROBABLY NEED TO REPLACE THE INTAKE MANIFOLD GASKET WHICH I BOUGHT BUT HAVEN'T REPLACED BECAUSE SOMEONE TOLD ME ABOUT THE RECALL OF OTHER SEBRINGS THAT HAD THE SAME PROBLEM. THE CAR WAS RUNNING FINE AND THE ENGINE LIGHT HAD GONE OFF AND THEN IT HAPPENED AGAIN WITH NO WARNING. I LOOKED UP AND SAW THERE HAVE BEEN OTHER SAME COMPLAINTS OF THE ENGINE STALLING AS ONE IS DRIVING. THE CODE GIVEN WAS H07. I AM DISABLED AND CANNOT AFFORD TO TAKE A RISK TO DRIVE DOWN THE ROAD AND THIS HAPPEN AGAIN. PLEASE LET ME KNOW WHERE I SHOULD TAKE MY CAR TO HAVE THE DEFECTIVE PART REPLACED. I AM ALSO HAVING PROBLEMS WITH THE DRIVER SIDE WINDOW COMING OFF TRACK AND GOING THROUGH THE RUBBER AND I AM AFRAID THE WINDOW WILL SHATTER BECAUSE IT WON'T STOP GOING UP. I GREATLY APPRECIATE ANY HELP YOU CAN GIVE. THANK YOU

NHTSA complaint #10749941 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

AIR CONDITIONER STOPS WORKING.

NHTSA complaint #10652889 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2004 CHRYSLER SEBRING. THE CONTACT STATED THAT WHILE TRAVELING 25 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 37,000.

NHTSA complaint #10584886 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2004 CHRYSLER SEBRING. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE ACCELERATED AND STALLED WITHOUT WARNING. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 134,000.

NHTSA complaint #10584658 — an unverified report by a vehicle owner.

ENGINE

MY 2004 CHRYSLER SEBRING LT STALLED OUT ON ME IN THE MIDDLE OF IN INTERSECTION IN A LEFT TURN LANE. COULD NOT GET CAR RESTARTED IMMEDIATELY AND WAS IN HEAVY TRAFFIC. ONCE I HAD RESTARTED THE VEHICLE I MOVED OVER TO THE SHOULDER WHERE IT HAPPENED AGAIN, AND THIS ALSO HAPPENED IN A PARKING LOT. THIS IS DANGEROUS. IF STALL WOULD HAVE HAPPENED 2 SECONDS LATER I WOULD'VE BEEN T-BONED BY A PICKUP TRUCK. UPON STALL THE CAR ENGAGED THE E-BRAKE AND ALSO LIT UP THE FOLLOWING WARNING LIGHTS : ENGAGED EBRAKE, OIL, BATTERY, AND ENGINE.

NHTSA complaint #10577776 — an unverified report by a vehicle owner.

ENGINE

ENGINE SEIZED UP WHILE DRIVING IT. I WAS ON THE PARKWAY AND THIS PUT ME IN A VERY DANGEROUS SITUATION. NO LIGHTS OR WARNING AT ALL....CAR WAS WELL MAINTAINED AND OIL CHANGED EVERY 3,000 MILES. SLUDGE BUILD UP IN ENGINE AND I WAS ADVISED THIS WAS A DEFECT ON THESE ENGINES. I WAS ADVISED BY THE MECHANIC THAT CHANGING THE OIL REGULARLY WOULD NOT OF PREVENTED THE BUILD UP, THIS IS A DEFECT AND IS HAPPENING TO THESE ENGINES.

NHTSA complaint #10566026 — an unverified report by a vehicle owner.

ENGINE

ELECTRICAL AND ENGINE PROBLEMS DEFECTIVE ENGINE CAUSED CAR TO CUT OFF INTERMITTENTLY.

NHTSA complaint #10565809 — an unverified report by a vehicle owner.

ENGINE

I RECENTLY SAW THAT YOU ARE INVESTIGATING CHRYSLERS FOR STALLING WHILE DRIVING. I HAD THIS HAPPEN TO ME ON SEVERAL OCCASIONS IN MY 2004 CHRYSLER SEBRING CONVERTIBLE. I HAVE SINCE SOLD IT. I TOOK IT IN AND REPORTED THIS TO THE DEALER OVER 3 TIMES TO WHICH THEY SAID THEY FOUND NOTHING WRONG. ONCE TIME IT STALLED IN THE MIDDLE OF AN INTERSECTION WHILE THE LIGHT WAS CHANGING. I WAS IN CONSTANT FEAR OF IT STALLING WHILE DRIVING. ANOTHER TIME IT STALLED WHILE I WAS GOING 15 MILES PER HOUR. IT MUST HAVE HAPPENED AT LEAST ONCE A MONTH. IT OFTEN HAPPENED AFTER REFUELING. I CAN PROVIDE YOU WITH THE VIN. I BOTH PURCHASED THE CAR AND TOOK IT HERE WITH COMPLAINTS ON SEVERAL OCCASIONS TO: DADELAND DODGE CHRYSLER JEEPMORE 16501 SOUTH DIXIE HIGHWAY MIAMI, FL 33157 (305) 278-9994

NHTSA complaint #10511895 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2004 CHRYSLER SEBRING. THE CONTACT STATED THAT WHILE TRAVELING 20 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT STATED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS 20,000.

NHTSA complaint #10487996 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

I BOUGHT MY USED TOURING MODEL SEBRING IN MAY OF 2011, AND SINCE THEN IT HAS REPEATEDLY JUMPED OR LEAPED FORWARD WHEN COMING TO A STOP OR IDLING, EVEN WITH MY FOOT ON THE BRAKE. I HAVE ALMOST CAUSED A FEW ACCIDENTS BY RAMMING THE CAR IN FRONT OF ME AT A STOP LIGHT AND SUCH. AS WELL, IT STALLED OUT ON ME WHEN I MADE A COMPLETE STOP ON 10/11/11. I HAVE SEEN MANY, MANY OF THE SAME COMPLAINTS AND WISH I KNEW WHAT THE ISSUE WAS. WILL BE TAKING IT INTO THE REPAIR SHOP TOMORROW.

NHTSA complaint #10429549 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 2004 CHRYSLER SEBRING. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A POPPING NOISE EMITTED FROM THE ENGINE. THE CONTACT INSPECTED THE ENGINE AND NOTICED THAT THE RADIATOR OVERFLOW TANK WAS PUNCTURED AND SPILLING COOLANT OVER THE ENGINE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC, WHERE THE MECHANIC REPLACED THE RADIATOR OVERFLOW TANK AND GASKET FOR THE UPPER INTAKE VALVE. THE FAILURE MILEAGE WAS 73,737.

NHTSA complaint #10427753 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

TL* THE CONTACT OWNS A 2004 CHRYLSER SEBRING. THE CONTACT STATED WHILE DRIVING 25 MPH THE WARNING LIGHT ILLUMINATED INDICATING THE VEHICLE WAS OVERHEATING. THE VEHICLE WAS DRIVEN TO A MECHANIC WHO REPLACED A HEATING ELEMENT. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS CONTACTED AND GAVE HER THE NHTSA NUMBER TO FILE A COMPLAINT BUT OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 86,700. UPDATED 9/13/11 *CN UPDATED 10/28/11

NHTSA complaint #10413706 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 2004 CHRYSLER SEBRING. THE CONTACT WAS ACCELERATING FROM A STOP WHEN THE VEHICLE SUDDENLY STALLED WITHOUT WARNING THE CONTACT THEN COASTED TO THE SIDE OF THE STREET AND TRIED TO RESTART THE VEHICLE BUT TO NO AVAIL. THE VEHICLE WAS THEN TOWED TO A DEALER AND THEY ADVISED HIM THAT HE NEEDED TO REPLACE THE OIL PUMP, THE CAM SHAFT, AND ADDITIONAL VALVES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 131,000.

NHTSA complaint #10394460 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

MY CAR HAS CUT OFF ON ME 4 TIMES IN THE PAST 2 MONTHS. IT SEEMS TO HAPPEN EVERY 2-3 WEEKS, WHEN I COME TO A FULL STOP. ALSO, WHEN MY FOOT IS ON THE BRAKE, THE CAR WILL VIBRATE VIOLENTLY AND THEN LUNGE FORWARD BY A FOOT OR SO. I HAVE ALMOST HIT CARS IN FRONT OF ME BECAUSE OF THIS. THIS HAS HAPPENED 4 TIMES AS WELL. I'VE GOTTEN MY CATALYTIC CONVERTER CHECKED- NO PROBLEM, I'VE GOTTEN RADIATOR AND TRANSMISSION CHECKED- ALL FINE. I'VE HAD AN A/C FLUSH, TRANSMISSION FLUSH, AND AIR INDUCTION/.FUEL SYSTEM CLEANED OUT. EVERYONE SAYS THAT THE CAR IS FINE, AND I'VE HAD HALF A DOZEN MECHANICS CHECK EVERYTHING OUT. NO ONE CAN FIND A PROBLEM. AND A NEW THING HAPPENED, JUST THE OTHER DAY, WHEN I HAD STARTED MY CAR UP FOR THE FIRST TIME IN THE DAY, THE CAR DIDN'T WANT TO SHIFT ABOVE 30 MILES. THE RPMS WERE REALLY HIGH, BUT I WAS AT 30 MPH. THE MECHANICS CAN'T FIND ANYTHING WRONG WITH IT AT ALL. I SAW A POSTING ON ANOTHER WEBSITE WHERE SOMEONE HAD THE SAME PROBLEMS, BUT NO ONE COULD FIND THE PROBLEM. JUNE 23RD IS THE FIRST DAY THAT THESE THINGS STARTED HAPPENING.

NHTSA complaint #10349630 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

THERMOSTAT FAIL 2004 CHRYSLER SEBRING.

NHTSA complaint #10347161 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL*THE CONTACT OWNS A 2004 CHRYSLER SEBRING. WHILE DRIVING APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS PROCEEDING TO MAKE A TURN; SUDDENLY, THE ENGINE STALLED WITHOUT WARNING. THE DRIVER WAS ABLE TO RESTART THE ENGINE AND RESUME OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING; HOWEVER, THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE ALSO INTERMITTENTLY EXHIBITED UNINTENDED ACCELERATION. THE CONTACT HAD CONCERNS OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 90 AND THE CURRENT MILEAGE WAS 30,000.

NHTSA complaint #10283865 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THIS IS MY SECOND COMPLAINT FILED ON THIS WEBSITE. MY CAR HAS BEEN PLACED IN THE REPAIR SHOP AT LEAST 3 TIME FOR THE SAME PROBLEM WITH NO RESOLUTION. CAR STALLED AGAIN ON 2/22/09 AND 2/24/09.

NHTSA complaint #10259635 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

I BOUGHT THE CAR IN AUGUST OF 06'. IT'S AN 04' CHRYSLER SEBRING. THE [XXX] CAR STARTED STALLING AND STOPPING WHEN I CAME TO A STOP. IT DIES ON ME AT LEAST ONCE A DAY NOW. IT FINALLY STOPPED WHILE DRIVING TODAY IN THE MIDDLE OF TRAFFIC ON A HIGHWAY. IT SCARES ME. I READ ON AUTO BEEF (WHICH IS WHERE I FOUND YOU) OF OTHER COMPLAINTS FROM MANY OTHER PEOPLE WITH THE EXACT SAME PROBLEM. THE DEALERSHIPS AND OTHER MECHANICS CANNOT SEEM TO FIND OUT WHAT IT IS. I TOOK MY CAR TO THE DEALERSHIP TODAY AND THEY RAN A TEST AND FOUND NOTHING WRONG WITH IT. THE SAME PROBLEM EVERYONE ELSE IS HAVING. I DON'T GET IT. I DON'T KNOW WHAT ELSE TO DO....PLEASE HELP!!! *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10240836 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

ENGINE CEASED WHILE STOPPED AT STOP LIGHT. VEHICLE HAD TO BE PUSHED OUT OF THE WAY. LATER FOUND ENGINE FAILED DO TO SLUDGE IN THE ENGINE.

NHTSA complaint #10239826 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

BOUGHT A USED 2004 CHRYSLER SEBRING TOURING. NOTICED 1000KMS LATER THAT THE ENGINE SOUNDED ROUGH. SAW THE OIL WAS BLACK. TOOK THE CAR FOR AN OIL CHANGE. CAR WAS FINE FOR AWHILE. ABOUT 1000KM LATER PROBLEMS AROSE. YET ANOTHER OIL CHANGE WAS NEED FOR BLACK OIL. THIS CONTINUED FOR MONTHS. I WAS JUST ABOUT TO MAKE THE SWITCH TO SYNTHETIC OIL WHEN MY CAR GAVE OUT ON ME. MECHANIC SAID HE THOUGHT EXHAUST WAS GETTING INTO THE ENGINE B/C OF POOR INTERNALS, SAID HIS COUSIN HAD THE SAME PROBLEM. P.S. CAR GAVE OUT ON THE 401 THANK GOD IT WAS 1 AM!

NHTSA complaint #10238083 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

I HAVE A 2004 CHRYSLER SEBRING. FOR 1 YEAR BEGINNING IN OCTOBER 2006, I HAD A CHECK ENGINE LIGHT THAT WOULD COME ON AND OFF INTERMITTENTLY. I WAS UNABLE TO BRING IT TO THE DEALER BECAUSE IT WAS OVER THE WARRANTY MILEAGE. I HAVE HAD STALLING PROBLEMS, WHEN I WOULD APPLY THE BRAKES THE CRA WOULD EITHER STALL OR JERK FORWARD. ON JULY 26, 2008, I HAD TO HAVE THE TIE RODS REPLACED. SINCE I HAD THE VEHICLE I ALSO HAD TO HAVE A BEARING REPLACED. I DO A LOT OF HIGHWAY DRIVING, BUT, HAVE HAD VEHICLES IN THE PAST THAT NEVER HAD THESE PROBLEMS. WHEN I HAD THE TIE RODS REPLACED (AT STS), THEY ALSO CHECKED ON THE STALLING. THE ONLY THING THEY WERE ABLE TO FIND WAS "DIRTY THROTTLE PLATES" WHICH DID NOT FIX THE SITUATION. I HAVE DONE A LOT OF RESEARCH ON MY VEHICLE AND DISCOVERED THAT THESE PROBLEMS ARE COMMON WITH MY MODEL, YEAR, AND VIN NUMBER. THIS IS ONE REFERENCE I USED: HTTP://WWW.LEMONLAWCLAIMS.COM/2004_CHRYSLER_SEBRING_AND_ENGINE%20FAILURE.HTM.

NHTSA complaint #10237430 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

I HAD A PROBLEM WITH MY THERMOSTAT OVERHEATING IN 2007. THE CAR WAS ONLY A LITTLE OVER TWO YEARS OLD. I PURCHASED THE CAR BRAND NEW IN 2004 AND STARTED HAVING PROBLEMS WITH IT TWO YEARS LATER. THEN THE ENGINE HAD A TAPPING NOISE IN IT AND THE CAR STARTED GOING DOWN HILL AFTER THAT POINT.

NHTSA complaint #10229794 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

WE TOOK OUR VEHICLE FOR YEARLY INSPECTION AND OUR MECHANIC SAID THAT OUR 2004 CHRYSLER SEBRING, WITH APPROXIMATELY 32,000 MILES HAD A CRACKED RESONATOR CAP. HE HAS ALREADY SEEN ONE SEBRING WITH 29,000 MILES WITH THE SAME PROBLEM AND RECOMMENDED TO US TO CALL THE DEALERSHIP. THE WARRANTY HAD EXPIRED IN JUNE AND THEY SAID THAT IT WOULD NOT BE COVERED.

NHTSA complaint #10209595 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

2004 CHRYSLER SEBRING TOURING SEDAN WITH A 2.7L ENGINE SHUTS OFF WHEN CAR IS DECELERATING. THE CAR STARTED MALFUNCTIONING WITH ABOUT 35,000 MILES ON IT, IT NOW HAS ABOUT 69,000 MILES. THE PROBLEM WAS INTERMITTENT, BUT NOW IT HAPPENS MORE FREQUENTLY. I HAVE HAD IT CHECKED OUT BUT THE TECHNICIAN COULD NOT FIGURE IT OUT NOR ARE THERE ANY CODES ASSOCIATED WITH THE PROBLEM. PLEASE HELP. THANKS, JIMMY L. ATKINS, JR.

NHTSA complaint #10207600 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

2004 CHRYSLER SEBRING STALLS AND JUMPS FORWARD WHEN FOOT IS ON BRAKE. THEN IT CUTS OFF.

NHTSA complaint #10199321 — an unverified report by a vehicle owner.