2006 Dodge Sprinter 3500 problems

ELECTRICAL SYSTEM

The contact owns a 2006. Dodge Sprinter 3500. The contact received notification of NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic), and Emissions Recall T21 Reprogram Engine Control Unit however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11579710 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2006. Dodge Sprinter 3500. The contact received notification of NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic), and Emissions Recall T21 Reprogram Engine Control Unit however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11579710 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

2006 DODGE SPRINTER 3500. CONSUMER WRITES IN REGARD TO EGR VALVE FAILURE. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR. THE PARTS WERE UNAVAILABLE.

NHTSA complaint #11484577 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2006 Dodge Sprinter 3500. The contact received a recall notification for NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic) and for an unknown Manufacturer recall for the engine control unit failure however, the dealer informed the contact that the parts for the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and advised the contact that they would assist with locating a dealer who could complete the recall repairs. A case was opened. The contact was awaiting a call back from the manufacturer. The contact had not experienced a failure. Parts distribution disconnect. Consumer stated the recall items were issued sometime early on (2006) and the timeline for repairing the recall items is 2006-Dec 2021. 12 dealers were contacted and none could work on it and consumer still has two recall items pending.

NHTSA complaint #11437315 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2006 Dodge Sprinter 3500. The contact received a recall notification for NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic) and for an unknown Manufacturer recall for the engine control unit failure however, the dealer informed the contact that the parts for the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and advised the contact that they would assist with locating a dealer who could complete the recall repairs. A case was opened. The contact was awaiting a call back from the manufacturer. The contact had not experienced a failure. Parts distribution disconnect. Consumer stated the recall items were issued sometime early on (2006) and the timeline for repairing the recall items is 2006-Dec 2021. 12 dealers were contacted and none could work on it and consumer still has two recall items pending.

NHTSA complaint #11437315 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I HAVE TWO RECALLS THAT NEEDS TO BE DONE BY A DODGE DEALER WHICH I TRIED TWO YEARS AGO WITH NO SUCCESS, THE FIRST ONE IS BRAKE LIGHT RECALL NONE OF THE DODGE DEALERS IN MY AREA UP TO 50 MILES RADIUS WERE ABLE TO FIX THE RECALL. NOW I AM TRYING TO REGISTER MY VEHICLE WITH DMV AND I WAS TOLD ABOUT THE PROOF OF CORRECTION THAT I NEED TO PROVIDE FOR AN EMISSION RECALL. I CALLED MULTIPLE DODGE DEALERS WITH NO SUCCESS TO HAVE IT WORKED ON PLUS I WAS SUGGESTED TO CALL MERCEDES BENZ SINCE IT IS A MERCEDES ENGINEERED VEHICLE AND SINCE ITS A DODGE THEY WON'T DO THE RECALL. NOW I AM STUCK WITH A VEHICLE I CAN GET FIXED AND REGISTERED. THE VEHICLE IS MY WORK VEHICLE AND I CAN'T DO ANY WORK/INCOME BECAUSE IT CAN'T BE REGISTERED.PLEASE ADVICE

NHTSA complaint #11173311 — an unverified report by a vehicle owner.

ENGINE

I HAVE TWO RECALLS THAT NEEDS TO BE DONE BY A DODGE DEALER WHICH I TRIED TWO YEARS AGO WITH NO SUCCESS, THE FIRST ONE IS BRAKE LIGHT RECALL NONE OF THE DODGE DEALERS IN MY AREA UP TO 50 MILES RADIUS WERE ABLE TO FIX THE RECALL. NOW I AM TRYING TO REGISTER MY VEHICLE WITH DMV AND I WAS TOLD ABOUT THE PROOF OF CORRECTION THAT I NEED TO PROVIDE FOR AN EMISSION RECALL. I CALLED MULTIPLE DODGE DEALERS WITH NO SUCCESS TO HAVE IT WORKED ON PLUS I WAS SUGGESTED TO CALL MERCEDES BENZ SINCE IT IS A MERCEDES ENGINEERED VEHICLE AND SINCE ITS A DODGE THEY WON'T DO THE RECALL. NOW I AM STUCK WITH A VEHICLE I CAN GET FIXED AND REGISTERED. THE VEHICLE IS MY WORK VEHICLE AND I CAN'T DO ANY WORK/INCOME BECAUSE IT CAN'T BE REGISTERED.PLEASE ADVICE

NHTSA complaint #11173311 — an unverified report by a vehicle owner.

SERVICE BRAKES

I HAVE TWO RECALLS THAT NEEDS TO BE DONE BY A DODGE DEALER WHICH I TRIED TWO YEARS AGO WITH NO SUCCESS, THE FIRST ONE IS BRAKE LIGHT RECALL NONE OF THE DODGE DEALERS IN MY AREA UP TO 50 MILES RADIUS WERE ABLE TO FIX THE RECALL. NOW I AM TRYING TO REGISTER MY VEHICLE WITH DMV AND I WAS TOLD ABOUT THE PROOF OF CORRECTION THAT I NEED TO PROVIDE FOR AN EMISSION RECALL. I CALLED MULTIPLE DODGE DEALERS WITH NO SUCCESS TO HAVE IT WORKED ON PLUS I WAS SUGGESTED TO CALL MERCEDES BENZ SINCE IT IS A MERCEDES ENGINEERED VEHICLE AND SINCE ITS A DODGE THEY WON'T DO THE RECALL. NOW I AM STUCK WITH A VEHICLE I CAN GET FIXED AND REGISTERED. THE VEHICLE IS MY WORK VEHICLE AND I CAN'T DO ANY WORK/INCOME BECAUSE IT CAN'T BE REGISTERED.PLEASE ADVICE

NHTSA complaint #11173311 — an unverified report by a vehicle owner.

ENGINE

CRANKSHAFT POSITION SENSOR FAULTY, CHECK ENGINE LIGHT COMES ON UPON STARTUP.

NHTSA complaint #11152252 — an unverified report by a vehicle owner.

ENGINE

ENTIRE MERCEDES DIESEL SPRINTER ENGINE FAILED COMPLETELY AND WILL NEED A NEW ENGINE. POSSIBLE CAUSE IS CRACKED PISTON OR STUCK INJECTOR. THIS HAPPENED WHEN DRIVING, SHORTLY AFTER SERPENTINE BELT AND TRANSMISSION LINE WERE REPLACED, VEHICLE WAS JUST SERVICED, INCLUDING NEW BRAKES, MUFFLER, INSPECTION, OIL CHANGE. ONLY 82,000 MILES! COST WILL BE OVER $11,000! THIS IS A WINNEBAGO VIEW AND ALTHOUGH IT IS NOW OLDER (2007) IT HASN'T BEEN DRIVEN THAT MUCH EACH YEAR.

NHTSA complaint #11114523 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2006 DODGE SPRINTER 3500. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THERE WAS A RANDOM FAILURE IN WHICH A LIMP MODE OCCURRED AND CAUSED A DRASTIC REDUCTION IN SPEED. THE VEHICLE WAS COASTED TO MERCEDES-BENZ OF PALM SPRINGS (4095 E PALM CANYON DR, PALM SPRINGS, CA 92264, (760) 328-6525) WHO REPLACED THE EGR AND PROVIDED DIAGNOSTIC TESTING. THE FAILURE CONTINUED TO PROGRESS INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE EGR AND ADDITIONAL PARTS. THE PART WAS REPLACED A THIRD TIME DUE TO THE FAILURE. THE VEHICLE WAS ALSO SERVICED FOR A MANUFACTURER RECALL (T21) AT HILLTOP CHRYSLER JEEP DODGE RAM (3291 AUTO PLAZA DRIVE, RICHMOND, CA 94806, (510) 243-6100). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #11054714 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

SPRINTER IN LOOSING POWER WHEN ITS GOING TO EVEN LITTLE HILL,AFTER THAT WORKS FINE.CHK WITH SHOP TRANS OK. OTHER SITUATION IS AC VENTS GIVING ONLY COLD AIR FROM TOP VENTS AND SIDE VENTS GIVING FULL HEAT LIKE OVER HOT.

NHTSA complaint #11015847 — an unverified report by a vehicle owner.

ENGINE

SPRINTER IN LOOSING POWER WHEN ITS GOING TO EVEN LITTLE HILL,AFTER THAT WORKS FINE.CHK WITH SHOP TRANS OK. OTHER SITUATION IS AC VENTS GIVING ONLY COLD AIR FROM TOP VENTS AND SIDE VENTS GIVING FULL HEAT LIKE OVER HOT.

NHTSA complaint #11015847 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2006 DODGE SPRINTER 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V833000 (SERVICE BRAKES); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA complaint #10966323 — an unverified report by a vehicle owner.

ENGINE

I'M REPLACING THE O2 SENSOR FOR THE SECOND TIME IN THREE YEARS. AFTER RESEARCHING IT SEEMS LIKE A COMMON PROBLEM RELATED TO THE RESONATOR. I AM SURPRISED DODGE OR MERCEDES DOES NOT WANT TO OFFER A SOLUTION ESPECIALLY SINCE THE ENGINE IS OTHERWISE RELIABLE. IT'S A CASE OF A CHEAP PART CAUSING A LOT OF GRIEF (AND SOME SAFETY RISK AS YOU NEVER KNOW WHEN IT WILL GO INTO LIMP MODE.) WITH NO RESPONSE FROM THE MANUFACTURER. THIS MOST RECENT SENSOR REPLACEMENT WILL COST ME $762.00

NHTSA complaint #10783444 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE NEXT TIME OUR HEADLIGHTS FAILED WAS ABOUT 30,000 MILES LATER. THE BRIGHTS STILL WORKED AND ALSO THE RUNNING LIGHTS BUT THE REGULAR HL DID NOT. ON INTERSTATES THIS WAS NOT TOO MUCH TROUBLE BUT I'M SURE WE WERE AN AGGRAVATION TO A FEW DRIVERS COMING OUR WAY. WE WENT TO A DODGE DEALER (CAMPED IN HIS DRIVEWAY) AND ASKED FOR TROUBLESHOOTING THE NEXT MORNING. THEY FOUND NO PROBLEM, BUT AGAIN, THE NEXT NIGHT, WE HAD THE SAME PROBLEM, BEFORE WE GOT HOME TO NW FLORIDA WHERE OUR LOCAL DEALER AGAIN FOUND NO PROBLEM. I THINK THERE IS AN INADEQUATE GROUND TO THE MAIN HEADLIGHT CIRCUIT. THERE ARE SEPARATE FUSES FOR THE HEADLIGHTS, RUNNING LIGHTS AND BRIGHT LIGHTS, ON EACH SIDE OF THE VEHICLE (6 IN ALL). THE FUSES ARE ALL ALRIGHT. WHEN I CHECK THE LIGHTS IN OUR DRIVEWAY THEY SEEM TO WORK FINE NOW....

NHTSA complaint #10486357 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

ENGINE DIES DRIVING AT UNKNOWN TIMES (KEY TURN ON) FOUND TEST OF POWER WINDOWS AT SAME TIME STOP DUE TO NO POWER (12VOLTS) ENGINE CUT IN AND OUT BUT STOPS RUNNING. DEAL NEVER FOUND THE TROUBLE. 1 CLICK (RELAY) TURN KEY TO START (STARTER NEVER TURN) TRUCK MITE START 15 MIN OR NEXT DAY . FOUND BAD MFG ENGINE GROUNDING. ADDED GROUND ENGINE BACK TO GROUND POST FIX THE MISSING GROUND. / 2ND THE MFG TURBO RESONATOR SPLIT MAKING LIMP HOME MODE.

NHTSA complaint #10478681 — an unverified report by a vehicle owner.

ENGINE

ENGINE DIES DRIVING AT UNKNOWN TIMES (KEY TURN ON) FOUND TEST OF POWER WINDOWS AT SAME TIME STOP DUE TO NO POWER (12VOLTS) ENGINE CUT IN AND OUT BUT STOPS RUNNING. DEAL NEVER FOUND THE TROUBLE. 1 CLICK (RELAY) TURN KEY TO START (STARTER NEVER TURN) TRUCK MITE START 15 MIN OR NEXT DAY . FOUND BAD MFG ENGINE GROUNDING. ADDED GROUND ENGINE BACK TO GROUND POST FIX THE MISSING GROUND. / 2ND THE MFG TURBO RESONATOR SPLIT MAKING LIMP HOME MODE.

NHTSA complaint #10478681 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THIS 2006 WINNEBAGO NAVION (ON A SPRINTER 3500 CHASSIS) HAS SUFFERED TWO FAILURES OF THE TURBOCHARGER RESONATOR. WHEN THE FAILURE OCCURS THERE IS AN IMMEDIATE AND ALMOST TOTAL LOSS OF POWER AND THE LOSS OF THE ABILITY TO CLIMB HILLS AS THE VEHICLE GOES INTO "LIMP HOME MODE" WITH A TOP SPEED OF 35 MPG ON LEVEL GROUND. THE VEHICLE IS UNABLE TO KEEP UP WITH OR STAY AHEAD OF, OR GET OUT OF THE WAY OF, OTHER TRAFFIC. THE FIRST FAILURE WAS INITIALLY NOT CORRECTLY DIAGNOSED BY THE DEALER, AND AFTER TWO ADDITIONAL INCIDENTS THE RESONATOR WAS REPLACED UNDER WARRANTY. THE RESONATOR HAS TOTALLY FAILED A SECOND TIME AND THE DEALER HAS REFUSED TO PERFORM THE REPAIR UNDER WARRANTY. I HAVE RESEARCHED THE PROBLEM AND FOUND THAT THIS IS A WELL KNOWN DEFECT WITH THE SPRINTER THAT IS NOT BEING ADDRESSED BY DEALERS OR THE MANUFACTURER. THIS IS THE MOST UNRELIABLE AND UNSAFE VEHICLE I HAVE EVER OWNED OR DRIVEN. I HAVE HAD TO PULL OVER TO THE SIDE, UNABLE TO GET TO A TURNOUT, AND STILL PARTIALLY BLOCKING AN ACTIVE LANE OF HIGH SPEED TRAFFIC. THE VEHICLES SHOULD BE RECALLED AND PROPERLY REPAIRED, OR THE MANUFACTURER SHOULD BUY THEM BACK IF THEY ARE NOT REPAIRABLE.

NHTSA complaint #10430558 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

MY 2006 DODGE SPRINTER 3500 HAS JUST BEEN DIAGNOSED WITH THE TURBO RESONATOR FAILURE THAT WAS EXPECTED. IT WAS EXPECTED BE BECAUSE IT HAS NOW HAPPENED TO ALL THE SPRINTERS I OWN. THE VEHICLE SUFFERS A DRAMATIC LOSS OF POWER AND SPEED WITH NO WARNING. I HAVE ALMOST BEEN HIT FROM BEHIND WHEN THE VAN IS ON AN UPGRADE AND SUDDENLY LOSES POWER AND SPEED. THIS PROBLEM HAS BEEN AROUND AS LONG AS THE SPRINTER HAS BEEN OUT AND NOTHING IS BEING DONE ABOUT IT. IT IS A DANGER TO PUBLIC AND AN EXTREMELY EXPENSIVE REPAIR TO MAKE. AS FAR I AM CONCERNED, IT A FAILURE OF THE GOVERNMENT TO FORCE THE MANUFACTURER TO FIX THE PROBLEM AND REIMBURSE THE PEOPLE WHO HAVE PAID FOR IT IN THE PAST.

NHTSA complaint #10389820 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

WE HAVE HAD THREE VACATIONS THAT HAVE BEEN RUINED DUE TO THE FAILURE OF THE TURBO RESONATOR IN OUR 2006 WINNEBEGO VIEW WITH A 2005 SPRINTER ENGINE. WE HAVE HAD FAILURE GOING OVER THE LOS ANGLES GRAPVINE GRADE, THE NORTHERN CALIFORNIA, 101 CORRIDOR AND JUST THIS PAST WEEK, THE SIERRA MT. RANGE GOING INTO RENO, NV. ON OUR WAY TO YELLOWSTONE. THREE VACATIONS RUINED, THREE TURBO RESONATORS LATER AND LOTS OF MONEY, TIME AND STRESS. NOT SURE WHY WE HAVE NOT RECEIVED A RECALL ON THIS PLASTIC PIECE OF JUNK THAT HAS PUT OUR LIVES IN DANGER???

NHTSA complaint #10355033 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

WE HAVE HAD THREE VACATIONS THAT HAVE BEEN RUINED DUE TO THE FAILURE OF THE TURBO RESONATOR IN OUR 2006 WINNEBEGO VIEW WITH A 2005 SPRINTER ENGINE. WE HAVE HAD FAILURE GOING OVER THE LOS ANGLES GRAPVINE GRADE, THE NORTHERN CALIFORNIA, 101 CORRIDOR AND JUST THIS PAST WEEK, THE SIERRA MT. RANGE GOING INTO RENO, NV. ON OUR WAY TO YELLOWSTONE. THREE VACATIONS RUINED, THREE TURBO RESONATORS LATER AND LOTS OF MONEY, TIME AND STRESS. NOT SURE WHY WE HAVE NOT RECEIVED A RECALL ON THIS PLASTIC PIECE OF JUNK THAT HAS PUT OUR LIVES IN DANGER???

NHTSA complaint #10355033 — an unverified report by a vehicle owner.

POWER TRAIN

2006 DODGE SPRINTER TRUCK. CONSUMER STATES SEVERAL ISSUES WITH VEHICLE LEADING TO BREAK DOWNS *TGW THE DEALER NOTED THE VEHICLE LACKED POWER AND WOULD NOT ACCELERATE PROPERLY. THE VEHICLE WOULD ESPECIALLY LOOSE POWER WHILE DRIVING ON AN INCLINE. ONE YEAR LATER, THE RESONATOR WAS REPLACED. THE VEHICLE BROKE DOWN AGAIN ON MARCH 27, 2009. THE CONSUMER WAS INFORMED THE LOCK WASHER ON THE LUG NUT FOR THE DRIVERS SIDE FRONT TIRE HAD BEEN IMPROPERLY PUT ON THE TIRE. THE BRAKE LIGHT AND TAIL LIGHT BULBS WERE REPLACED. THE EGR VALVE WAS STICKING, THE BATTERY WAS REPLACED, THE TURBO WAS LEAKING OIL IN THE INTAKE TRACK, THE TRANSMISSION ADAPTER PLUG WAS LEAKING, THE CHECK ENGINE LIGHT ILLUMINATED, THE HARMONIC BALANCER AND WATER PUMP WERE REPLACED.

NHTSA complaint #10327422 — an unverified report by a vehicle owner.