Ford Cvpi wheel problems

WHEELS

AIR LEAKS OUT THE BACK WHEEL EVERY DAY AFTER FILL UP GAS IT SMELLS LIKE GAS INSIDE CAR.

NHTSA complaint #10606666 — an unverified report by a vehicle owner.

WHEELS

I JUST READ ABOUT THE STEERING COLUMN RECALL ON THE CROWN VIC, CVPI, AND GRAND MARQUIS 2005-2011 AND I AM NOT SURE WHY THE 2003-2004 MODELS ARE NOT INCLUDED. THEY HAVE THE SAME ISSUES DESCRIBED IN THIS RECALL. I HAD MY 2003 CVPI IN THE SHOP LESS THAN A MONTH AGO DUE TO SOME STEERING ISSUES I'M HAVING (A LOT OF NOISE DURING DRIVING AND WHILE TURNING) AND THE OUTCOME WAS THAT MY CAR NEEDS A STEERING COLUMN FLEX COUPLER (SHAFT, LOWER) AND THE LOWER BALL JOINT (CONTROL ARM) ALSO NEEDS REPLACED DUE TO EXCESSIVE CORROSION. SO AGAIN, I'M ASKING WHY IT'S NOT PART OF THE RECALL? ALSO, I'M HAVING THE SAME ISSUES WITH MY TIRES THAT A LOT OF OTHER CVPI OWNERS ARE HAVING CONCERNING THE CRACKS IN THE RIMS. MY TIRES ONLY HAVE A FEW THOUSAND MILES ON THEM AND I'M HAVING TO PUT AIR IN THE PASSENGER REAR TIRE ABOUT ONCE A WEEK DUE TO LOSS OF AIR PRESSURE. (I'M LOSING ABOUT 20 PSI A WEEK ON AVERAGE). THE TIRES HAVE BEEN CHECKED AND ARE FINE.

NHTSA complaint #10538503 — an unverified report by a vehicle owner.

WHEELS

I HAVE STEEL WHEELS ON MY 2003 CROWN VIC I RECEIVED A RECALL NOTICE FROM FORD MOTOR COMPANY STATING THAT MY WHEELS WERE PART OF A SAFETY RECALL, THE WHEELS ARE PRONE TO WELDS BREAKING AND RUSTING MAKING THEM LOOSE AIR AND IMPOSSIBLE TO BALANCE WHY STEERING WHEEL SHAKES I HAVE HAD DIFFERENT TIRES AND MULTIPLE SHOPS BALANCE THE WHEELS THEY ARE NOT ABLE TO, ALSO THEY LOOSE AIR ALL THE TIME. I CONTACTED FORD ABOUT THIS ISSUES WHERE I WAS TOLD BECAUSE I AM NOT A POLICE DEPARTMENT THEY WILL NOT BE ABLE TO HONOR THE RECALL, THEY SAY ITS ONLY FOR CARS IN POLICE USE. IM CONCERNED AS THESES WHEELS HAVE BEEN USED BY THE PRIOR OWNER AKA A POLICE FORCE MAKING THE CARS WHEELS UNSAFE FOR ME FOR WANTS ME TO PAY TO GET NEW WHEELS AT A COST OF OVER 500 DOLLARS I JUST WANT THEM TO HONOR THE RECALL AS THE WHEELS ARE CERTAINLY UNSAFE.

NHTSA complaint #10447434 — an unverified report by a vehicle owner.

WHEELS

MY CAR IS A 2003 FORD CROWN VICTORIA (FORMER POLICE VEHICLE). THERE IS A SAFETY RECALL ON IT, # 07S48 FOR THE 16" STEEL WHEEL REPLACEMENT. I HAVE RECEIVED 3 NOTICES FROM FORD ON IT. WHEN I WENT TO 2 DIFFERENT DEALERS THEY TOLD ME IT ISN'T COVERED BECAUSE IT IS NO LONGER OWNED BY A POLICE DEPARTMENT. THEY CAN NOT TELL ME WHAT THE DIFFERENCE IS WHETHER A COP IS DRIVING IT OR ME. I AM AN OFFICER AND I DO NOT BELIEVE I DRIVE MY PERSONAL CAR ANY DIFFERENTLY THEN WHILE AT WORK. I FEEL VIBRATION IN MY WHEEL AT HIGH SPEEDS, WHICH I WAS TOLD IS A RESULT OF THIS RECALL.

NHTSA complaint #10340628 — an unverified report by a vehicle owner.

WHEELS

TL* THE CONTACT OWNS A 2005 FORD CVPI. SINCE PURCHASING THE VEHICLE THE CONTACT NOTICED THAT THE WHEELS ON THE VEHICLE HAD BEGUN TO SHOW SIGNS OF RUST. THE CONTACT CALLED THE DEALERSHIP REGARDING NHTSA RECALL #07V079000 COMPONENT: WHEELS AND WAS INFORMED THAT THE RECALL DID NOT APPLY TO HIS VEHICLES VIN NUMBER. THE VEHICLE HAD NOT BEEN DIAGNOSED BY THE DEALERSHIP AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 172000.

NHTSA complaint #10318607 — an unverified report by a vehicle owner.

WHEELS

LINGERING PROBLEM WITH 2005 FORD CROWN VICTORIA POLICE INTERCEPTOR WITH SUSPECTED CRACKED WHEELS. VEHICLE HAS ALL SYMPTOMOLOGY VEHICLE WAS MANUFACTURED FOR THE 2005 MY IN 08/2004. NHTSA CAMPAIGN ID NUMBER: 07V079000 . FORD REFUSES TO ADDRESS THE PROBLEM.

NHTSA complaint #10303278 — an unverified report by a vehicle owner.

WHEELS

LINGERING PROBLEM WITH 2004 FORD CROWN VICTORIA POLICE INTERCEPTOR WHEELS WITH SUSPECTED CRACKS. MEETS ALL SYMPTOMOLOGY. FORD REFUSES TO ADDRESS THE PROBLEM.

NHTSA complaint #10303276 — an unverified report by a vehicle owner.

WHEELS

TL*THE CONTACT OWNS A 2004 FORD CVPI. THE CONTACT STATED THAT THE WHEELS CRACKED IN THE RIM NEAR THE WELD LINE, WHICH CONNECTS THE RIM TO THE DISK. HE HAD TO PLACE AIR IN HIS TIRES WEEKLY BECAUSE THE FAILURE CAUSED THE TIRES TO DEFLATE. THE MANUFACTURER STATED THAT THEY WOULD NOT HONOR THE RECALL BECAUSE THE VEHICLE WAS NO LONGER REGISTERED TO THE POLICE DEPARTMENT. NHTSA CAMPAIGN ID NUMBER 07V079000 (WHEELS) AND FORD RECALL NUMBER 07S48 WERE REFERENCED. THE FAILURE MILEAGE WAS 67,000.

NHTSA complaint #10270222 — an unverified report by a vehicle owner.

WHEELS:RIM

TL*THE CONTACT OWNS A 2004 FORD CVPI. THE CONTACT RECEIVED A RECALL NOTICE, WHICH STATED THAT THE RIMS NEEDED TO BE REPLACED ON HIS VEHICLE. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THEY WOULD NOT REPLACE THE RIMS SINCE THE RECALL ONLY PERTAINED TO POLICE VEHICLES. THE CONTACT WANTED TO KNOW THE DIFFERENCE BETWEEN HIM OWNING THE VEHICLE AND THE POLICE DEPARTMENT. THE VIN AND NHTSA CAMPAIGN ID NUMBER WERE UNKNOWN. THE FAILURE MILEAGE WAS 89,000.

NHTSA complaint #10262425 — an unverified report by a vehicle owner.

WHEELS

TL*THE CONTACT OWNS A 2003 FORD CVPI. THE CONTACT PURCHASED A POLICE VEHICLE THREE WEEKS AGO AND FOUND A FEW OUTSANDING RECALLS WHILE ATTEMPTING TO INSTALL DIFFERENT PARTS ON THE VEHICLE. HE CALLED THE FORD MANUFACTURER AND WAS INFORMED THAT THE RECALL REPAIRS HAD NOT BEEN PREVIOUSLY PERFORMED. THEY FURTHER STATED THAT SINCE THE VEHICLE WAS NOT BEING USED AS A POLICE VEHICLE ANYMORE, THEY DID NOT HAVE TO HONOR THE RECALLS AND REPAIR IT FOR FREE. THE NHTSA CAMPAIGN ID NUMBERS IN REFERENCE WERE 02I003000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY), 03V279000 (WHEELS), 05V206000 (ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH), AND 04V328000 (SUSPENSION:REAR). THE FAILURE MILEAGE WAS 128,000. 4/01/09 *NJ UPDATED 04/06/09.

NHTSA complaint #10260911 — an unverified report by a vehicle owner.

WHEELS

TL*THE CONTACT OWNS A 2004 FORD CVPI. THE CONTACT RECEIVED A RECALL NOTICE IN NOVEMBER OF 2007 FOR NHTSA CAMPAIGN ID NUMBER 07V079000 (WHEELS). THE CONTACT CALLED THE DEALER TO SCHEDULE A REPAIR APPOINTMENT AND WAS INFORMED THAT THE RECALL APPLIED ONLY TO ACTIVE POLICE VEHICLES. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 57,000.

NHTSA complaint #10212321 — an unverified report by a vehicle owner.

WHEELS:RIM

2005 FORD CVPI - OUR MUNICIPAL POLICE AGENCY OWNS A FLEET OF APPROXIMATELY 150 CVPI'S THAT HAVE RUSTING RIMS. THE PROBLEM BEGINS WITH THE FINISH SEEMINGLY DISAPPEARING WITH CLEAN METAL VISIBLE THAT EVENTUALLY RUSTS OVER. THE LOCAL DEALER REPORTS NO RECALLS ASSOCIATED WITH THIS PROBLEM. WAS CURIOUS TO KNOW IF THIS IS A COMMON OCCURRENCE AND WHAT SAFETY ISSUE THIS MAY POSE IF THE RIMS CONTINUE TO RUST?

NHTSA complaint #10205540 — an unverified report by a vehicle owner.

WHEELS:RIM

SO I BUY A CVPI POLICE INTERCEPTOR WITH OVER 117K MILES OF POLICE DUTY USE THAT HAS A SAFETY RECALL 07S48 REGARDING THE WHEELS AND IT CANNOT BE PERFORMED BECAUSE THE VEHICLE IS CURRENTLY NO LONGER IN POLICE DUTY USE. I HAVE WORKED AT AUTOMOTIVE DEALERSHIPS FOR OVER FIFTEEN YEARS AND NEVER IN MY LIFE HEARD OF A SAFETY RECALL ON A VEHICLE THAT ONLY APPLIES TO WHO IS BEHIND THE WHEEL.

NHTSA complaint #10199832 — an unverified report by a vehicle owner.

WHEELS

TL*THE CONTACT OWNS A 2004 FORD CROWN VICTORIA. THE MECHANIC AT THE SERVICE STATION INFORMED THE CONTACT OF SAFETY RECALL NUMBER 07S48 REGARDING HIS WHEELS. THE DEALER STATED THAT THE VEHICLE WAS NO LONGER USED FOR POLICE PURSUITS, THEREFORE, THE RECALL DID NOT APPLY TO HIS VEHICLE. HE ALSO STATED THAT THE STEERING COLUMN SHAKES INTERMITTENTLY. THE CURRENT MILEAGE WAS 102,000 AND FAILURE MILEAGE WAS 101,000. UPDATED 01-11-08. *KB THE CONSUMER STATED AIR LEAKED FROM THE TIRES. UPDATED 12/12/07.

NHTSA complaint #10198202 — an unverified report by a vehicle owner.

WHEELS

FORD RECALL REGARDING CROWN VICTORIA POLICE CARS BECAUSE OF CRACKS THAT CAN DEVELOP IN POLICE CRUISER WHEELS. I'M A PA STATE CONSTABLE (LAW ENFORCEMENT OFFICER) AND UPON PURCHASING A RETIRED PA STATE POLICE VEHICLE THE WHEELS ON MY VEHICLE ARE CRACKING AND FORD MOTOR CO. EMPLOYEE KEVIN EMPLOYEE #61151 ADVISED THERE IS NOTHING THEY CAN DO AT THIS TIME.

NHTSA complaint #10197034 — an unverified report by a vehicle owner.

WHEELS:RIM

POLICE OFFICER ON A TRAFFIC STOP. LEFT REAR TIRE SUDDENLY WENT FLAT WHILE STOPPED. FLAT TIRE CHANGED BY LOCAL SERVICE STATION ROADSIDE ASSISTANCE. WHEEL/TIRE TAKEN TO PUBLIC WORKS GARAGE FOR REPAIR. EXAMINATION OF WHEEL/TIRE BY MECHANIC FINDS A CRACK IN STEEL WHEEL. FURTHER EXAMINATION OF WHEEL WITH TIRE REMOVED REVEALS CRACK IS 17" LONG AND APPROXIMATELY 1/8" WIDE ALONG WELD AREA. CRACKED WHEEL IS STILL IN THE POSSESSION OF THE VERNON HILLS PUBLIC WORKS DEPARTMENT.

NHTSA complaint #10165733 — an unverified report by a vehicle owner.

WHEELS

I OWN A 2003 FORD CROWN VICTORIA POLICE INTERCEPTOR WHICH FALLS INTO THE EXTENDED WARRANTY COVERAGE FOR MANUFACTURER DATE TIME FRAME LISTED IN RECALL 03V279000. DESPITE THE FACT THAT THREE OF THE FOUR RIMS ON MY CAR HAVE DEVELOPED THE CRACKS AND AIR LOSS LISTED IN THE RECALL, FORD CLAIMS MY VEHICLE IS NOT COVERED. FORD AGREES MY VEHICLE WAS MANUFACTURED IN THE TIME FRAME THAT SHOULD BE COVERED BY THE EXTENDED WARRANTY, BUT CLAIMS MY VIN NUMBER IS NOT INCLUDED IN THE COVERAGE. I HAVE HAD TO REPLACE THE THREE DEFECTIVELY MANUFACTURED RIMS AT MY COST JUST TO BE ABLE TO DRIVE THE CAR. I HAVE THE THREE RIMS STORED FOR INSPECTION/RETURN TO FORD.

NHTSA complaint #10158234 — an unverified report by a vehicle owner.

WHEELS:RIM

LT RR TIRE SLOWLY LOSES AIR. CF WHEEL.

NHTSA complaint #10153286 — an unverified report by a vehicle owner.

WHEELS

THE CAR WAS FOUND IN THE LOT WITH A FLAT RT FR TIRE. UPON INSPECTION, THE WHEEL WAS FOUND TO BE CRACKED. CRACK EXTENDED ALONG WELD AND THEN DEVIATED OFF THE WELD INTO THE AREA NORMALY COVERED BY THE TIRE'S BEAD. "AA" WHEEL STAMPING.

NHTSA complaint #10149354 — an unverified report by a vehicle owner.

WHEELS:RIM

VEHICLE HAD A FLAT TIRE IN THE PARKING LOT. THE TIRE/WHEEL WAS INSPECTED AND THE WHEEL WAS FOUND TO HAVE A CRACK. "CF" WHEEL STAMPING

NHTSA complaint #10149021 — an unverified report by a vehicle owner.