1994 Ford E-350 engine problems

ENGINE AND ENGINE COOLING

WHEN I AM DRIVING MY 1994 E350 DIESEL TRUCK, THERE WILL BE A SUDDEN LOSS OF POWER STEERING AND BRAKES RESULTING IN A LOSS OF ABILITY TO STOP THE TRUCK. FORTUNATELY, I WAS TRAVELING AT A SLOW SPEED WITH PLENTY OF CLEARANCE AHEAD OF ME AND WAS ABLE TO PULL THE TRUCK OFF THE ROAD AND HAVE IT TOWED IN TO A MECHANIC SHOP. SO FAR THE SERPENTINE BELT HAS BEEN REPLACED, A NEW TENSIONER INSTALLED, AND A NEW IDLER PUT IN. UNFORTUNATELY, THE PROBLEM PERSISTS AND IS VERY DANGEROUS. I SEE THAT A RECALL WAS ISSUED # 9610030000 BY NHTSA FOR 1994 FORD ECONOLINE E350 TRUCKS WITH SERPENTINE BELT PROBLEMS AND THAT THE FORD DEALERS HAVE AGREED TO REMEDY THE PROBLEM. WHEN I CALL FORD, THEY SAY THAT MY VIN# IS NOT AMONG THOSE THAT WERE RECALLED. THIS IS THE 3RD TIME I HAVE LOST POWER STEERING AND BRAKES DUE TO A SERPENTINE BELT MALFUNCTION. I BELIEVE THAT MORE VEHICLES MANUFACTURED THAT YEAR SHOULD BE INCLUDED IN THE RECALL.

NHTSA complaint #10280328 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

WHEN I AM DRIVING MY 1994 E350 DIESEL TRUCK, THERE WILL BE A SUDDEN LOSS OF POWER STEERING AND BRAKES RESULTING IN A LOSS OF ABILITY TO STOP THE TRUCK. FORTUNATELY, I WAS TRAVELING AT A SLOW SPEED WITH PLENTY OF CLEARANCE AHEAD OF ME AND WAS ABLE TO PULL THE TRUCK OFF THE ROAD AND HAVE IT TOWED IN TO A MECHANIC SHOP. SO FAR THE SERPENTINE BELT HAS BEEN REPLACED, A NEW TENSIONER INSTALLED, AND A NEW IDLER PUT IN. UNFORTUNATELY, THE PROBLEM PERSISTS AND IS VERY DANGEROUS. I SEE THAT A RECALL WAS ISSUED # 9610030000 BY NHTSA FOR 1994 FORD ECONOLINE E350 TRUCKS WITH SERPENTINE BELT PROBLEMS AND THAT THE FORD DEALERS HAVE AGREED TO REMEDY THE PROBLEM. WHEN I CALL FORD, THEY SAY THAT MY VIN# IS NOT AMONG THOSE THAT WERE RECALLED. THIS IS THE 3RD TIME I HAVE LOST POWER STEERING AND BRAKES DUE TO A SERPENTINE BELT MALFUNCTION. I BELIEVE THAT MORE VEHICLES MANUFACTURED THAT YEAR SHOULD BE INCLUDED IN THE RECALL.

NHTSA complaint #10280328 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

THERE ARE METAL LINES POSITIONED OVER THE LEFT REAR TIRE. THE DEBRIS AND WATER FROM THE ROAD CAUSED THESE METAL LINES TO RUST AND LEAK, CAUSING ANTIFREEZE TO DROP ONTO THE TIRE. THE CONSUMER IS CONCERNED THAT THE ANTIFREEZE COULD CAUSE THE TIRES TO LOSE TRACTION WHILE DRIVING.

NHTSA complaint #10057944 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

EXHAUST MANIFOLD FAILED DUE TO EXCESSIVE HEAT AND THE TYPE OF MATERIAL USED, THE CONSUMER IS REQUESTING THAT THE MANUFACTURER PAY FOR AT LEAST HALF THE BILL FOR THE FAILED COMPONENT. NLM

NHTSA complaint #567176 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

WHEN TRAVELING FAN BELT FELL OFF PULLEY, CAUSING COMPLETE LOSS OF POWER STEERING AND BRAKES. ALSO, TWO YEARS AGO RECALL OMP96B82 WAS ISSUED CONCERNING THE SAME PROBLEM, RECALL REPAIR WORK WAS DONE. HOWEVER, PROBLEM HAS OCCURRED AGAIN. VEHICLE CURRENTLY AT DEALER AWATING REPAIRS. *AK

NHTSA complaint #854890 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

FOLLOWING A RECALL FOR REPLACEMENT OF A PULLEY, DEALER INFORME DOWNER THAT THE VACUUM PUMP LOCKED UP.

NHTSA complaint #809984 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

THE TENSIONER ON THE BUS GOES OUT. THIS IS THE FOURTH TIME. TT

NHTSA complaint #968237 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

FAN BELT SLIPS BADLY/BREAKS.

NHTSA complaint #968237 — an unverified report by a vehicle owner.