34 of the 546 complaints filed about the Ford E-450 are about the fuel system — 6% of everything owners reported. The worst model year for it is 2005.
34
Complaints
6%
Share of all complaints
4
Crashes
2
Fires
FUEL/PROPULSION SYSTEM
CP4 fuel pump explodes leaving me and my family stranded on the freeway for over 7 hours, and stuck 1300 miles from home. Dodge has already recalled and repaired there trucks. My truck is 2021 with 50k miles and now I'm expected to pay $15-20k for the damage's
NHTSA complaint #11488695 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
When refueling the gas pump clicks off after a few seconds. Sometimes it doesn't click off but back splashes fuel out the gas filler hole. I have had gas spray back several times, getting all over the RV, the ground, and my clothes. Repair places have said there is nothing they can do because it is a design flaw cause the fill tube is too flat. This seems like a huge fire risk to me.
NHTSA complaint #11483013 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHILE DRIVING STRAIGHT ON A CITY STREET AND AGAIN ON AN INTERSTATE, THE VEHICLE SHUT OFF. A DIAGNOSTIC REPORT DETERMINED THAT THE FUEL PUMP CIRCUIT WIRING HARNESS WAS BAD. THE VEHICLE HAS 23,000.
NHTSA complaint #11377857 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
VEHICLE IN MOTION GOING UP HILL. STALLED OUT BECAUSE OF FUEL FILTER PLUGGED, LOCATED IN FUEL TANK. ALMOST WAS HIT BY SEMI BECAUSE VEHICLE STOPPED RUNNING. JULY 9, 2018. FORD NO LONGER PUTS FILTER IN TANK. MOST FUEL FILTERS ON THIS TYPE OF VEHICLE ARE LOCATED ON FRAME OUTSIDE OF FUEL TANK. ENGINEER'S MISTAKE? REPAIRS HAD TO BE MADE AND CHARGE WAS $1414. CONTACTED FORD COMPLAINT DIV. JULY 20. THEY HAVE NOT REPLIED OR ANSWER MY COMPLAINT. THESE VEHICLES SHOULD HAVE BEEN RECALLED YEARS AGO, HOWEVER SEEMS AS IT HAS GONE UNNOTICED. MECHANIC WHO REPAIRED VEHICLE AGREED THAT IT WAS NOT A GOOD PLACE TO PUT THE FILTER, DO TO OWNERS RELUCTANCE TO CHANGE FILTER ON A REGULAR BASIS, BECAUSE OF THE EXTRA COST TO DROP THE FUEL TANK TO ACCESS THE FUEL FILTER AND PUMP. I AM SURE OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM, BUT IGNORED IT AND HAD THEIR VEHICLE FIXED. AGAIN WITH LOSS OF POWER GOING UP A HILL AND STALLING IN FRONT OF HEAVY TRAFFIC COULD RESULT IN INJURY OR DEATH IF ONE WOULD BE REAR ENDED. AGAIN... FORD HAS NOT CALLED OR WRITTEN WITH AN EXPLANATION OR REPLY. YOUR ATTENTION WOULD BE APPRECIATED. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC
NHTSA complaint #11120629 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
VEHICLE IN MOTION GOING UP HILL. STALLED OUT BECAUSE OF FUEL FILTER PLUGGED, LOCATED IN FUEL TANK. ALMOST WAS HIT BY SEMI BECAUSE VEHICLE STOPPED RUNNING. JULY 9, 2018. FORD NO LONGER PUTS FILTER IN TANK. MOST FUEL FILTERS ON THIS TYPE OF VEHICLE ARE LOCATED ON FRAME OUTSIDE OF FUEL TANK. ENGINEER'S MISTAKE? REPAIRS HAD TO BE MADE AND CHARGE WAS $1414. CONTACTED FORD COMPLAINT DIV. JULY 20. THEY HAVE NOT REPLIED OR ANSWER MY COMPLAINT. THESE VEHICLES SHOULD HAVE BEEN RECALLED YEARS AGO, HOWEVER SEEMS AS IT HAS GONE UNNOTICED. MECHANIC WHO REPAIRED VEHICLE AGREED THAT IT WAS NOT A GOOD PLACE TO PUT THE FILTER, DO TO OWNERS RELUCTANCE TO CHANGE FILTER ON A REGULAR BASIS, BECAUSE OF THE EXTRA COST TO DROP THE FUEL TANK TO ACCESS THE FUEL FILTER AND PUMP. I AM SURE OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM, BUT IGNORED IT AND HAD THEIR VEHICLE FIXED. AGAIN WITH LOSS OF POWER GOING UP A HILL AND STALLING IN FRONT OF HEAVY TRAFFIC COULD RESULT IN INJURY OR DEATH IF ONE WOULD BE REAR ENDED. AGAIN... FORD HAS NOT CALLED OR WRITTEN WITH AN EXPLANATION OR REPLY. YOUR ATTENTION WOULD BE APPRECIATED. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC
NHTSA complaint #11120629 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
PULLED UP TO STOP SIGN. WHEN MAKING RIGHT TURN, ONTO INTERSTATE FRONTAGE ROAD, THROTTLE QUIT WORKING, WRENCH LIGH AND CHECK ENGINE LIGHT CAME ON. COASTED TO SIDE OF ROAD. VEHICLE HAD TO BE TOWED IN TO FORD DEALER. WAS TOLD ELECTRONIC THROTTLE CONTROL SHUT DOWN VEHICLE, AND THROTTLE BODY WOULD HAVE TO BE REPLACED. HAD IT HAPPENED ANOTHER MINUTE LATTER IT WOULD HAVE FAILED IN THE MIDDLE OF AN INTERSTATE HIGHWAY.
NHTSA complaint #10893869 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2014 FORD E-450. WHILE DRIVING 55 MPH, A LOUD HISSING SOUND WAS HEARD FROM THE FRONT PASSENGER SIDE OF THE MOTORHOME AND AN ODOR OF FUEL WAS NOTICED. THE FAILURE RECURRED INTERMITTENTLY. THE MOTORHOME WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PRESSURE RELEASE VALVE FOR THE PROPANE TANK FAILED AND NEEDED TO BE REPLACED. THE MOTORHOME WAS REPAIRED, BUT THE REMEDY FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 2,000.
NHTSA complaint #10885532 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FUEL MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT STATED THAT SHORTLY AFTER THE REPAIR, THE VEHICLE JERKED AND FAILED TO START AS THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS UNABLE TO BE DIAGNOSED OR REPAIRED THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,020.
NHTSA complaint #10764471 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THIS VEHICLE WAS CONVERTED TO AN AMBULANCE BY WHEELD COACH. THE AMBULANCE CAUGHT FIRE AND SPREAD TO THE BUILDING IN WHICH IT WAS PARKED AND UNOCCUPIED. A PARAMEDIC SMELLED SOMETHING COMING FROM THE BAY, AND, WHEN HE WENT TO INVESTIGATE, HE SAW SMOKE AND FIRE DRIPPING FROM UNDERNEATH THE AMBULANCE. AN INVESTIGATOR DETERMINED THAT THE LUG CONNECTION AT THE ALTERNATOR WAS IMPROPERLY INSTALLED BY WHEELED COACH. THE CONNECTION PRODUCED A HIGH RESISTANCE CONNECTION, PRODUCING TEMPERATURES SUFFICIENT TO IGNITE A COMPETENT FUEL SOURCE AND/OR CAUSED THE BATTERY CABLE INSULATION TO FAIL, PRODUCING ELECTRICAL ARCING THAT PROVIDED A COMPETENT IGNITION SOURCE TO CAUSE THE FIRE.
NHTSA complaint #10671038 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WE WERE TRAVELING NORTH TO SOUTH JUST OUTSIDE OF LASVEGAS WHEN A SPARK PLUG BLEW OUT OF THE CYLINDER, WITH THE INJECTOR STILL PUMPING FUEL. IN OUR 31' MOTORHOME WITH A E450 ENGINE. DID WE NOT REALIZE THE SERIOUSNESS OF THE SITUATION THE ENGINE COULD HAVE CAUGHT FIRE AND CAUSED EXTENSIVE DAMAGE AND POSSIBLE INJURY. AS A RESULT THIS COST US $7200.00 AND THE LOSS OF USE OF OUR VEHICLE AND HOME FOR 10 DAYS. WE HAVE ASKED FORD MOTOR COMPANY FOR SOME RENUMERATION TOWARDS THE COST OF REPAIRS BECAUSE AS WE SOON FOUND OUT THERE HAVE BEEN THOUSANDS OF THESE VEHICLES WITH THE SAME PROBLEM. BUT BECAUSE THE VEHICLE WAS OVER 6 YEARS OLD THEY WOULD NOT PROVIDE ASSISTANCE. WE FEEL THAT EVEN IF WE WERE COMPENSATED FOR THE PARTS WOULD BE A FAIR RESPONSE, BECAUSE THIS SITUATION COULD HAVE RESULTED IN A LIABILITY LAWSUIT. WE WOULD APPRECIATE ANY ASSISTANCE YOU CAN PROVIDE US WITH OUR REQUEST TO FORD. THANK YOU,
NHTSA complaint #10650134 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
EMPLOYEES WERE DRIVING TRUCK ON A LEVEL ROAD, AND IT RAPIDLY LOST POWER. THEY STOPPED AND CALLED ME, AND I TOLD THEM TO CHECK A NUMBER OF THINGS. EVERYTHING LOOKED OK. BROUGHT THE VEHICLE TO FORD DEALER, AND WAS INFORMED THAT THE FUEL TANK WAS RUSTED/RUSTING ON THE INSIDE. THEY ADVISED ME THAT THE TANK, SENDING UNIT, AND FUEL PUMP NEEDED TO BE REPLACED, BEFORE THEY COULD SEE IF THE INJECTORS, FUEL LINES, AND TURBO WERE DAMAGED. I CHECKED ON THE INTERNET BEFORE AUTHORIZING THE REPAIRS, AND WAS ASTOUNDED BY THE AMOUNT OF PEOPLE THAT HAD THE SAME EXACT ISSUES. THE TANKS ARE DEFECTIVE, AND DELAMINATE, THEREFORE CLOGGING THE FUEL SYSTEM. THEY REPAIR BILL THAT I WAS QUOTED BEFORE WE EVEN GOT TO THE ENGINE, WAS $3700.00+TAX!!!. THIS IS UNREAL THAT THE NHTSA HAS NOT FORCED A RECALL YET. DOES SOMEONE HAVE TO DIE FIRST? SOME PEOPLE REPORTED REPAIR BILLS OF $11,000+!! I AM A SMALL BUSINESS OWNER. I PAID $45,000.00 FOR THIS VEHICLE, MAINTAINED IT RELIGIOUSLY. THE TRUCK ONLY HAS 66,000 MILES ON IT. THERE HAVE BEEN NUMEROUS COMPLAINTS TO THE NHTSA, AND IT HAS BEEN REPORTED THAT THIS HAS BEEN KNOWN ABOUT FOR SOME TIME. THERE ARE ALSO SOME CLASS ACTION LAWSUITS THAT ARE IN PLACE. I CANNOT AFFORD THIS REPAIR. I WILL GET A PETITION GOING TO ASK THE NHTSA TO RECALL THESE VEHICLES. IF THE NHTSA KNOWS THAT THERE IS A PROBLEM, AND SOMEONE HAS AN ACCIDENT AND KILLS SOMEONE, WOULD THAT NOT HAVE THE NHTSA SHOULDER SOME BLAME? IS THIS ANOTHER COVER UP LIKE THE GENERAL MOTORS IGNITION RECALL? I URGE YOU TO PLEASE RECALL THESE AFFECTED VEHICLES. FORD KNOWS THAT THERE IS A PROBLEM, AND THEY IMMEDIATELY BLAME IT ON FUEL. I HAVE 6 TRUCKS THAT ALL RUN ON DIESEL. THE ONLY ONE THAT HAS THIS PROBLEM IS THIS VEHICLE. I WOULD LIKE SOMEONE FROM THIS AGENCY TO CONTACT ME ASAP. THIS TRUCK IS A MAIN SOURCE OF INCOME FOR ME AND MY EMPLOYEES, AND IT I SITTING AT A DEALER FOR 5 DAYS SO FAR.
NHTSA complaint #10609885 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD E-450. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 40 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS NOT ABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO A DEALER WHERE THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT WAS UNSURE OF WHAT WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V266000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 175.
NHTSA complaint #10509398 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
MY 2011 F450 WITH 60,000 MILES ON IT, WOULD NOT START AFTER JUST RUNNING. IT HAD NEVER GIVEN ANY INDICATIONS OF ANY PROBLEMS PRIOR TO NOT STARTING. THE DEALERSHIP WHERE IT WAS TAKEN WORKED ON IT FOR 9 DAYS HAND IN HAND WITH FORD WARRANTY DEPT AND CAME UP WITH FAILURE OF THE FUEL SYSTEM. ACCORDING TO FORD INSPECTORS, FUEL WAS CONTAMINATED. FUEL PUMP HAD METAL SHAVINGS IN FILTER SYSTEM. FUEL PUMP WAS RUSTED AND HAD NO LUBRICANT. BUMPER TO BUMPER WARRANTY DID NOT COVER THIS. WE ARE OUT OVER $5,000 (DON'T HAVE THE FINAL $$$$$ AMOUNT AT THIS TIME). SYSTEM FAILURE WARNING LIGHTS DID NOT INDICATE A PROBLEM WITH WATER OR OTHER CONTAMINATES IN FUEL LINES. FUEL SYSTEM HAS TO BE FLUSHED TO ELIMINATE METAL SHAVINGS THROUGHOUT FUEL LINES AND INJECTORS. ACCORDING TO THE MECHANIC, ANY DIESEL USED IN FORD DIESEL TRUCKS SHOULD HAVE A RATING OF 20...AND NOT ABOVE (LIKE 25). THE BIGGER THE NUMBER, THE MORE TRASH IN THE DIESEL. ALSO, BIODIESEL IS NOT RECOMMENDED AND CAN BE USED TO VOID THE WARRANTY. LOTS OF LUCK WITH THIS!!!
NHTSA complaint #10479939 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
MY 2011 F450 WITH 60,000 MILES ON IT, WOULD NOT START AFTER JUST RUNNING. IT HAD NEVER GIVEN ANY INDICATIONS OF ANY PROBLEMS PRIOR TO NOT STARTING. THE DEALERSHIP WHERE IT WAS TAKEN WORKED ON IT FOR 9 DAYS HAND IN HAND WITH FORD WARRANTY DEPT AND CAME UP WITH FAILURE OF THE FUEL SYSTEM. ACCORDING TO FORD INSPECTORS, FUEL WAS CONTAMINATED. FUEL PUMP HAD METAL SHAVINGS IN FILTER SYSTEM. FUEL PUMP WAS RUSTED AND HAD NO LUBRICANT. BUMPER TO BUMPER WARRANTY DID NOT COVER THIS. WE ARE OUT OVER $5,000 (DON'T HAVE THE FINAL $$$$$ AMOUNT AT THIS TIME). SYSTEM FAILURE WARNING LIGHTS DID NOT INDICATE A PROBLEM WITH WATER OR OTHER CONTAMINATES IN FUEL LINES. FUEL SYSTEM HAS TO BE FLUSHED TO ELIMINATE METAL SHAVINGS THROUGHOUT FUEL LINES AND INJECTORS. ACCORDING TO THE MECHANIC, ANY DIESEL USED IN FORD DIESEL TRUCKS SHOULD HAVE A RATING OF 20...AND NOT ABOVE (LIKE 25). THE BIGGER THE NUMBER, THE MORE TRASH IN THE DIESEL. ALSO, BIODIESEL IS NOT RECOMMENDED AND CAN BE USED TO VOID THE WARRANTY. LOTS OF LUCK WITH THIS!!!
NHTSA complaint #10479939 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
LEAK IN MOLDED FUEL LINE WHERE LINE CHANGES FROM HOSE TO PIPE. NOT A WEAR ITEM, SAFETY ISSUE. FUEL LINE IS LOCATED OVER EXHAUST MANIFOLD, FUEL LEAK DETECTED BEFORE ADDITIONAL DAMAGE OCCURRED.
NHTSA complaint #10466456 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
PROBLEM: HESITATION ON ACCELERATION, ROUGH IDLES, LOSS OF POWER UPON ACCELERATION. INJECTOR FOUND CLOGGED ON 12-2006. REPLACED TURBO ASSEMBLY AND COLD AIR BOOT ON 12/20/2006. FILED WRITTEN COMPLAINT TO FORD IN APRIL 2006 FOR RECURRING ENGINE ISSUES. FORD NEVER ANSWERED. ON 1/30/09 TRUCK NOT RUNNING AND FORD REPLACED THE TRANSMISSION. ASKED FORD SERVICE TO CHECK ROUGH RUNNING AND ENGINE POWER LOSS BUT COMPUTER SHOWED NO CODES. TOOK TRUCK INTO FORD ON 1/21/20011 FOR BRAKES AND VEHICLE NOT RUNNING PROPERLY EVEN AFTER WARM UP. DIAGNOSIS FROM FORD --- FOUND RUST IN THE FUEL FILTER, WAS TOLD FUEL TANK NEEDED REPLACED AS WELL AS INJECTORS AND INJECTOR PUMP AND FUEL LINES. COST TO REPLACE $5000 OR MORE. WARRANTY RAN OUT NOVEMBER 2010. FORD IS NOW REQUIRING VEHICLE OWNERS TO REPLACE THEIR FUEL TANKS AND ANY ANCILLARY PARTS AT THEIR OWN COST. FORD HAD TO OF KNOWN THAT THERE WAS A PROBLEM WITH THE FUEL TANKS DELAMINATING AFTER 2004. AS A SMALL BUSINESS OWNER IN THIS ECONOMY HAVING TO SPEND EXTRA MONEY ON A PROBLEM THAT COULD AND SHOULD HAVE BEEN TAKEN CARE OF UNDER WARRANTY IS EGREGIOUS. MY VEHICLE CURRENTLY HAS 113,000 MILES AND TO ALREADY HAVE TO REPLACE A TRANSMISSION AND NOW THE FUEL TANK IS INDICATIVE OF A DEFECTIVE VEHICLE. FORD IS NEGLIGENT IN NOT ACKNOWLEDGING A POTENTIALLY DANGEROUS TO LIFE SAFETY PROBLEM.
NHTSA complaint #10380259 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
TL*THE CONTACT OWNS A 2003 FORD E450. THE CONTACT STATED THE VEHICLE WOULD EXHIBIT NUMEROUS ISSUES WHEN DRIVING SUCH AS RUNNING ROUGH, STALLING, HESITATION, FAILURE TO RESTART AND FAILURE TO INITIALLY START. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE HE WAS ADVISED TO HAVE THE VEHICLE INSPECTED BY AN AUTHORIZED DEALER. THE DEALER INFORMED THE CONTACT THAT THE FUEL TANK WOULD NEED REPLACING. THE CONTACT STATED THAT THE FUEL TANK WAS PREVIOUSLY REPLACED. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE MANUFACTURER WOULD OFFER NO ASSISTANCE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 40,000.
NHTSA complaint #10351677 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
WE HAVE A 2006 FORD F-450 THAT WAS PURCHASED IN NOVEMBER 2005. IN OCTOBER 2008 THE "WATER IN FUEL" WARNING LIGHT CAME ON. THE FORD DEALER FOUND NO WATER AND REPLACED A FUEL WATER MODULE AT NO CHARGE. NOW THE TRUCK LOSES POWER WITHOUT NOTICE AND WE ARE TOLD THAT THE COATING ON THE INTERIOR OF FORD DIESEL FUEL TANKS CORRODES AND COLLECTS AS SEDIMENT IN THE FUEL SYSTEM. THE SEDIMENT, COLLECTS AT THE BOTTOM OF THE FUEL TANK AND IS SUCKED INTO THE FUEL SYSTEM. THE TRUCK CANNOT BE DRIVEN SAFELY. FORD CLAIMS THERE IS NO WARRANTY FOR THIS MALFUNCTION.
NHTSA complaint #10335465 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
FOLLOW THIS LINK: HTTP://STEVEWIENCEK.SMUGMUG.COM/PHOTOGRAPHY/FORD-FUEL-TANK/10976330_WP42T#774715040_3CEQC FOR A DESCRIPTION OF WHAT I AND OTHERS HAVE EXPERIENCED WITH THIS FUEL TANK. IT IS UNSAFE, DEFECTIVE AND SHOULD BE RECALLED. 1) LOSS OF POWER 2) OCCURRED EVERY 100 MILES OR LESS 3) COST WAS OVER $5000 TO REPLACE THE FUEL TANK FUEL LINES AND FUEL INJECTORS.
NHTSA complaint #10314532 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 2008 FORD ECONOLINE E450. THE CONTACT STATED THAT HE SMELLED FUEL. HE ALSO CHECKED THE FUEL TANK AND FUEL LINES AND DIDN'T OBSERVED ANY DAMAGE TO THE FUEL TANK. THE DEALER CONFIRMED THAT THERE WAS A BAD SEAM WELD ON THE FUEL TANK. THE FUEL TANK WAS REPLACED ACCORDING TO THE WARRANTY. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS 7921 AND THE FAILURE MILEAGE WAS APPROXIMATELY 7852. UPDATED 12/22/09
NHTSA complaint #10294291 — an unverified report by a vehicle owner.