116 of the
2,449 complaints filed about the Ford Ecosport
are about the fuel system —
5% of everything owners reported.
The worst model year for it is 2018.
For a month, every time I put gas in my car whether I filled up or just put half a tank my car will not start for 10-15 minutes. I took it to the ford place and my extended warranty wouldn't cover it. It seems like an evap valve would be covered. I have only had my car 11 months. This is going to cost over $1,000 to fix. It seems like ford should be responsible for the repairs.
NHTSA complaint #11754921 — an unverified report by a vehicle owner.
A young teenage driver faced a terrifying highway emergency when her vehicle suffered an abrupt, dangerous loss of motive power at 70+ MPH on the interstate due to sudden turbocharger failure. Moving at high speeds in heavy traffic, the sudden drop in acceleration left the driver vulnerable to rear-end collisions from oncoming semi-trucks. The vehicle was driven into the shop with a failed turbocharger and a completely contaminated oil ecosystem. The engine block has not seized yet, but all components are highly contaminated. The affected components are preserved and available for federal inspection. The root cause is a completely choked oil pump pick up tube screen. After a week-long standoff where the consumer had to escalate the case to Ford Corporate to force the dealership to drop the oil pan, teardown photos revealed the intake mesh was blanketed and impacted by a thick, suffocating mat of degraded wet belt fibers. This debris choked off oil pressure, proving the dealer fraudulently certified Safety Recall 23S64 as complete while leaving the lethal hazard trapped inside. In addition to this extreme debris, internal Ford OASIS logs admit the technician snapped a tensioner bolt during the recall. They drilled it out but failed to clean the engine, trapping sharp metallic shards that circulated into the oil system, destroying the turbocharger seals and scorching the gaskets. The dealer was given urgent warnings on April 7, 2026, when the driver reported interstate stalling ("limp mode at 70+ mph") and an AutoZone turbo pressure code. The dealer treated this severe safety risk as a low-priority task, failed to check the oil pressure, and released the car. After the forced pan drop in July, Ford Corporate denied coverage for a new long block and turbocharger, instructing the consumer to pay over $8,000 out of pocket for repairs caused entirely by their own botched recall.
NHTSA complaint #11755154 — an unverified report by a vehicle owner.
For 14 months, I attempted to get active recalls fixed on the car at Downtown Sacramento Ford, which claimed to be certified pre-owned per Folsom Lake Ford but had existing recalls and issues when I bought it in March of 2024. My car finally broke down on 07/11/26 and was towed on 07/12/26 to the Elk Grove Ford dealership and "looked at" on 07/13/26. Today is 07/26/26, and I am still in a rental that takes a lot more gas than my regular car. I was told that they fixed the recall, but there is an issue with the turbo boost, and it is covered under warranty. They do not know when they are getting the part, but they are "working on it". I missed 4 days of work just from 07/11/26 to today 07/26/26 ontop of another 20 missed days since purchasing the car due to maintenance and engine issues related to the ongoing recall.
NHTSA complaint #11752911 — an unverified report by a vehicle owner.
On April 3, 2026, this vehicle suffered a sudden, catastrophic mechanical failure as I was driving on US-169, in Kansas City, Mo.,l The engine seized and the fuel line ruptured resulting in an undercarriage fire with small explosions. I had to be physically extracted from the burning vehicle by a Clay County Sheriff’s Deputy, Clay County Sheriff’s Department, Liberty, Missouri (Report #CC2600810). This catastrophic asset and recall remedy failure is the direct result of a recognized federal safety defect (Ford Safety Recall 23S64 / NHTSA Campaign 23V905). The original engine blew from an oil pump failure in October 2024 and was towed to certified Ford dealer Smithville (Mo.) Ford on October 9, 2024 as per the recall. The new engine was not re-installed until May 24, 2025 due to delay in getting parts At the time of the recall reinstallation, the vehicle had 61,556 miles on it. When the fire happened on April 3 of this year, the vehicle had 70, 956 miles . I want to emphasize that Under explicit authorization from Ford Motor Company’s recall interim guidelines, the dealership performed a complete engine assembly swap. Per the official service invoice, this replacement engine was backed by a 3-year or 100,000-mile Ford Powertrain Warranty. At the time of the fire 11 months later, the vehicle had not yet reached 71,000 miles and was fully covered under active factory warranty.
NHTSA complaint #11748321 — an unverified report by a vehicle owner.
My 2020 Ford EcoSport (1.0L EcoBoost) is covered by Recall 23S64 / NHTSA 23V905 (engine oil pump drive belt). The defect causes sudden loss of motive power at highway speed (65+ mph), usually after 40+ minutes of driving, with the powertrain warning light and code P0299 (turbo underboost). Losing power in Los Angeles freeway traffic is the safety hazard. The recall remedy has failed repeatedly. In Oct 2025 the dealer tore down the engine, confirmed the oil pump belt had disintegrated and clogged the oil pickup, and replaced the complete engine (long block) under the recall in Dec 2025. The recall now shows as completed for this vehicle, but since that repair, with under 500 miles driven: (1) the turbocharger failed again and was replaced under warranty in Feb 2026, about 77 miles after the new engine; (2) in Apr 2026 the dealer found a cracked valve cover leaking oil into cylinder 3 (codes P0313, P0299); (3) on May 23, 2026 I picked the car up and the same power-loss condition returned THE SAME DAY - the dealer then found a loose air charge pipe; (4) on Jun 20, 2026 I picked the car up again and it failed THE SAME DAY. Both same-day failures are corroborated by round-trip rideshare receipts. The vehicle has been at the dealer since Jun 20, 2026, and the service advisor has not answered my written requests for diagnosis or coverage for over a week. Before the recall was confirmed, the same defect caused repeated repairs from Jun 2024 on (13 shop visits, 9 to Ford dealers). In Aug 2025 Ford's own technical hotline directed an engine teardown to find the root cause; the dealer advisor declined it. The remedy under Recall 23S64 has not remedied the defect: the recall-replaced engine has failed component by component within 500 miles and the vehicle remains out of service. All components are available for inspection at the dealer. Full repair orders, invoices, and dated records are available on request.
NHTSA complaint #11748099 — an unverified report by a vehicle owner.
Fuel injectors, hand brake when reversing, spuddering when push on gas, windshield crack when cleaning from the inside accidently hit rear view mirror.
NHTSA complaint #11745387 — an unverified report by a vehicle owner.
The contact owns a 2021 Ford EcoSport. The contact stated that while driving at unknown speeds, the vehicle stalled. The vehicle restarted after 20 minutes. The Check Engine warning light was illuminated. The "Charging System Failed" message was displayed. The vehicle was previously taken to the local dealer for NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) recall repair. The vehicle was taken back to the local dealer, where it was diagnosed with needing the EVAP purge system replacement. The vehicle was repaired; however, the Check Engine warning light illuminated while leaving the dealer. The vehicle was taken to the same dealer, who informed the contact that a diagnostic test was needed, and that there was no warranty coverage. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 60,688.
NHTSA complaint #11743015 — an unverified report by a vehicle owner.
Vehicle experienced sudden severe loss of motive power consistent with Ford Safety Recall 23S64 (NHTSA Campaign 23V905000). Prior to repair, the vehicle entered limp mode and could not accelerate beyond approximately 30 to 35 MPH. Low oil pressure warning indicators and check engine light illuminated repeatedly. Engine produced abnormal grinding and strained startup noises. Vehicle also experienced hesitation, shaking, and difficulty maintaining safe roadway speeds. While I was trying stop at a red light the vehicle struggles to brake although the brakes are applied, after coming to a full stop the vehicle shutdowns and would have restart. During operation, vehicle struggled to accelerate in traffic and braking performance became concerning due to severe engine power loss and unstable operation. On multiple occasions, the engine nearly stalled or shut down completely after stopping at intersections. Vehicle was delivered to Ford dealership for Recall 23S64 repair. Dealer completed the recall repair and stated oil pressure had been restored; however, the vehicle continued exhibiting the same severe loss of power and limp mode symptoms after completion of the recall procedure. Dealer later performed additional diagnostics and identified DTC P0087 (Fuel Rail/System Pressure Too Low) and a broken intake camshaft requiring major engine repairs estimated at approximately $9,000. Dealer stated the engine damage was not covered or related under the recall despite the vehicle originally presenting with the same low oil pressure, loss of motive power, and drivability symptoms described in Recall 23S64. Vehicle remains unsafe to operate due to unresolved loss of power and internal engine damage. Concern exists that the recall related oil pressure failure may have caused consequential internal engine damage that was not fully corrected by the recall repair procedure. Problem has been confirmed by authorized Ford dealership inspection and diagnostic testing.
NHTSA complaint #11739634 — an unverified report by a vehicle owner.
After having to have my vehicle towed to & held by the dealership for a total of 3 months altogether over the course of two separate engine rebuilds due to a national recall on faulty oil pump parts, my vehicle's check engine light came on & gave a message that there was an issue with the emissions system. I am now experiencing multiple engine system faults EVERY SINGLE TIME I refuel my vehicle where my engine will not start until after 10+ attempts & now that the weather is hotter, I'm also experiencing engine system faults while driving in town & on the highway where the engine completely shuts down & I lose all power, including steering power, while I'm driving! The system instructs me to put the car in park, turn the key to the off position & restart the vehicle WHILE I'M STILL TRYING TO MANUEVER TO SAFETYWITH ZERO POWER IN THE MIDDLE OF THE ROAD/HIGHWAY! I was almost hit by other vehicles multiple times! This vehicle is my only source of transportation but it is wholly dangerous & totally unsafe to drive!
NHTSA complaint #11739425 — an unverified report by a vehicle owner.
My car has been in and out of the shop since 2024 due to the power train system. As this is an active recall case my car was repaired 5 times. Recently, with the recall part replaced in January 2026, I got my car back and in May 2026 while driving, my car once again loss power. Going from 50 to coasting. After many guarantees that the problem is fixed, I continue to have the same dangerous problems.
NHTSA complaint #11737848 — an unverified report by a vehicle owner.
I had recall 23S64 repaired on 04/39/26 and now my car check engine light is on and is running hot, and shaking causing a safety hazard due to recall not being completed correctly by authorized Ford dealership
NHTSA complaint #11737756 — an unverified report by a vehicle owner.
I am filing a complaint regarding Consumer Portfolio Services (CPS) and the reporting and collection of a repossession deficiency balance related to my 2021 Ford EcoSport, VIN [XXX] and Ford Motor Company. The vehicle was affected by serious safety defects and recall-related issues that endangered my safety and substantially impaired the vehicle’s reliability, usability, and market value. Despite these known defects, CPS is attempting to collect a large deficiency balance following repossession and is reporting the account negatively on my credit report. I dispute the validity and fairness of the alleged deficiency balance because the vehicle’s value was negatively impacted by manufacturer-related defects and safety concerns. I also question whether the vehicle was sold in a commercially reasonable manner and whether the resale value properly accounted for the vehicle’s defective condition. Ford was notified and did nothing to resolve any matter. The vehicle stalled on th interstate in [XXX] while traveling to vacation. Ford has not reimbursed me all of my money. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11737830 — an unverified report by a vehicle owner.
I was on my way home from work approaching a red light coasting to a stop, I tried to slow down then I realized the car was accelerating and I pushed the brakes and pulled into a parking lot by the time I got in the parking lot the car was surging, really trying to takeoff. It went all the way to 5,000 rpm’s while I was in park.
NHTSA complaint #11736528 — an unverified report by a vehicle owner.
So my car is about to be out of warranty and I have called and made two appointments to get my recall taken care of as it is a safety risk for me and my kids. They canceled the first one with no communication and the second appointment they called and said they can’t get the part in so I have to call them in 2 weeks to check. After two weeks I believed my car will be over the 60k mark putting me out of warranty and voiding them to fix any issues that occurred because of this recall.
NHTSA complaint #11734313 — an unverified report by a vehicle owner.
This is now going to be the FOURTH time we are going to have to put a NEW engine in the same exact car. We just replaced the engine barely a year and a half ago.
NHTSA complaint #11734073 — an unverified report by a vehicle owner.
My entire car failed while on the beltway outside of Washington DC. I lost all power and almost got creamed by a truck. I had it towed to the Ford dealership in Falls Church, Virginia. They are telling me that I need an entire new engine and that they cannot provide a loaner car. They want me to put my credit card out and rent a car and then get reimbursed later. This is completely totally unacceptable. I almost died on the beltway and they knew about this recall for two years now, but supposedly don’t have the parts. Something has to be done and immediately.
NHTSA complaint #11731807 — an unverified report by a vehicle owner.
My light engine comes on a few times. First it was the coolant, then the engine light came off. The next is when I was fueling my gas tank. I try to start it, it won’t turn on all the way. Third time it has happen. Went to ford they want to charge almost $900 just to fixed the vehicle. It had a recall in 2020. Bought the car used at Crain in Fayetteville Arkansas. They fix the belt and fuel pump. After they got it fixed I’ve been having the light engine comes on constantly. Now I’m stuck with no vehicle because I don’t feel safe driving it. 12/15/2025 the first engine light came on. For a coolant, then 1/24/2026 light came back on. For another coolant code, they check it and they said my coolant was fine. 3/04/2026 service engine soon alert is on because an issue has been detected with your vehicles’ s emissions system. 3/11/2026 service engine soon alert is on because an issue has been detected with your vehicles’ s emissions system. 3/12/2026 The Engine system has detected a fault. 3/12/2026. Came back on The Engine system has detected a fault. 3/20/2026 Your service engine soon alert is on because an issue has been detected with your vehicles’ s emissions system. I took it the shop on the 3/27/2026 They put a diagnosis on the computer The code came for P0496 EVAP System High Purge Flow 02 Sensor Signal Biased/Stuck Rich - Bank 1, Sensor 1 ABS Anti-lock Brake System U0155-00 Lost Communication With Instrument Panel Cluster They said it wasn’t part of the 80,000 warranty for the federal law. I’ve done research and it came up on the same code I got. So now they want almost $900 dollars with a $250 dollar diagnostic when I’ve already told them we went to auto part to get the code. They had to hook it up again to see if it’s the same code.
NHTSA complaint #11728678 — an unverified report by a vehicle owner.
After fueling, codes P0496 will show and car will not start or struggle to start. Stalling when on freeway and rough idle. My vehicle shut off on the freeway causing me to almost crash and had to stop immediatly. In my investigation, it seems I am not the only one suffering this issue. I am on my 2nd engine replacement from the original recall as well.
NHTSA complaint #11727824 — an unverified report by a vehicle owner.
Incident Date: 12/28/2025 Location: [XXX] Related Recall: 23V905 / 23S64 On December 28, 2025, while driving at highway speeds on [XXX] , my 2020 Ford EcoSport suffered a sudden engine fire. There were no prior dashboard warnings or "Check Engine" lights until the fire began, the vehicle speed started to slow down itself, and I immediately pulled over on the side of the interstate. I turned off the vehicle, and lifted the hood, since I saw smoke, and there was a fire under the hood. I called [XXX] , and the [XXX] /Cobb County Fire Department responded to the scene and inspected the vehicle under the hood. I have video evidence of the fire department on-scene and the emergency inspection of the burning engine. This vehicle is subject to Safety Recall 23V905 (Ford 23S64) for oil pump belt/tensioner failure leading to engine seizure. Crucially, a recall "repair" had been previously performed on this vehicle, yet the engine still suffered a catastrophic thermal event. This indicates either an ineffective remedy or a negligent installation. The vehicle was towed to Hennessy Ford [XXX] ). Their diagnosis confirmed: "COIL PACK BURN AND BURNED THE #2 INJECTOR AND HARNESS AND VALVE COVER." Despite the federal mandate that recall-related failures be handled at no cost, the dealership attempted to charge me over $2,000 for the diagnosis and repairs. Furthermore, Ford Customer Relationship Center (escalated 03/27/2026) has stalled the case by moving it to legal counsel with a 15-day waiting period. I am reporting this as a serious safety defect and a failure of a prior recall remedy. I am requesting a full investigation into the fire and a manufacturer buyback as the vehicle's safety integrity is now compromised. Also, I filed a claim with Ford Customer Relationship Center, here is my case number: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11727714 — an unverified report by a vehicle owner.
In mid-2024, I was notified of a recall (23S64 / 23V905) involving the engine oil pump belt. When I attempted to schedule repairs, I was told parts were not available. I was instructed to watch for loss of oil pressure and speed and to pull over immediately if it occurred. In January 2025, my vehicle lost oil pressure and speed while driving. I pulled over and had it towed. Ford directed me to a dealer, but multiple dealers within 200 miles said parts would not be available until March 2025. I brought my vehicle to a Ford dealer in [XXX] in March 2025. It remained there over 7 months until October 17, 2025. I was told parts were unavailable, and instead of fixing the defect, the engine was replaced with another engine subject to the same recall. Shortly after, the vehicle broke down again due to issues related to the repair. I later received another recall notice and returned the vehicle on February 25, 2026. As of March 23, 2026, the dealer still has my vehicle and cannot complete repairs due to lack of parts. This recall causes sudden loss of oil pressure and engine power, creating a serious safety risk. Ford has not provided a timely or effective remedy. My vehicle has approximately 50,000 miles and has been out of service for extended periods. All repair documentation is in my car that is currently at the dealership. They do not email or text or give digital proof. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11726312 — an unverified report by a vehicle owner.