FaultScore
See all results →
All makes Worst years, ranked Problems by part Analysis Problems by model year Recalls in Canada Recall lookup Compare two cars How we grade

Ford Escort recalls

NHTSA has issued 43 recalls covering the Ford Escort. A recall repair is always free, however old the car is.

Check your own car by VIN

Recalls apply to specific build ranges, so a recall listed here may or may not cover your particular vehicle. NHTSA's free VIN lookup is the authority: nhtsa.gov/recalls.

1995 Ford Escort Campaign 06E026000 23 Mar 2006

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

1993 Ford Escort Campaign 06E026000 23 Mar 2006

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

1994 Ford Escort Campaign 06E026000 23 Mar 2006

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

1996 Ford Escort Campaign 06E026000 23 Mar 2006

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

1997 Ford Escort Campaign 04E048000 12 Jul 2004

SEAT BELTS:FRONT

CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.

Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.

Remedy: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2004.

1998 Ford Escort Campaign 04E048000 12 Jul 2004

SEAT BELTS:FRONT

CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.

Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.

Remedy: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2004.

1999 Ford Escort Campaign 04E048000 12 Jul 2004

SEAT BELTS:FRONT

CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.

Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.

Remedy: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2004.

2000 Ford Escort Campaign 04E048000 12 Jul 2004

SEAT BELTS:FRONT

CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.

Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.

Remedy: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2004.

2001 Ford Escort Campaign 04E048000 12 Jul 2004

SEAT BELTS:FRONT

CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.

Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.

Remedy: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2004.

2002 Ford Escort Campaign 04E048000 12 Jul 2004

SEAT BELTS:FRONT

CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.

Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT, WHICH MAY INCREASE THE RISK OF PERSONAL INJURY.

Remedy: TRW WILL NOTIFY THE CUSTOMERS WHO PURCHASED THE REPLACEMENT SEAT BELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2004.

1997 Ford Escort Campaign 02V323000 9 Dec 2002

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

ON CERTAIN PASSENGER VEHICLES, THE INTEGRATED AIR BAG MONITOR (IABM) CAN BE CONTAMINATED WITH WATER OR OTHER LIQUIDS AND COULD EXPERIENCE INTERNAL ELECTRICAL SHORTING.

Risk: THIS MAY, IN TURN, CAUSE THE AIR BAG READINESS LIGHT TO ILLUMINATE AND IN VERY RARE OCCURRENCES, AIR BAG DEPLOYMENT, MELTED WIRING, OR FIRE MAY OCCUR.

Remedy: DEALERS WILL INSTALL THE SHIELD OVER THE IABM AND APPLY NYOGEL GREASE TO THE CONNECTOR. OWNER NOTIFICATION BEGAN FEBRUARY 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

2000 Ford Escort Campaign 00V228001 18 Aug 2000

SEAT BELTS

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

1999 Ford Escort Campaign 99V276000 12 Oct 1999

POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE S/R OPTION. THE S/R OPTION INCLUDES, AMONG OTHER FEATURES, A 5-SPEED MANUAL TRANSMISSION. ON THESE VEHICLES, THE TRANSMISSION SHIFT PATTERN IS NOT DISPLAYED IN THE OCCUPANT COMPARTMENT IN VIEW OF THE DRIVER. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT."

Risk: THE DRIVER MAY NOT BE AWARE OF THE TRANSMISSION POSITION OF THE VEHICLE.

Remedy: OWNERS WILL BE PROVIDED WITH AN ADHESIVE BACKED PLAQUE CONTAINING THE SHIFT PATTERN, ALONG WITH MATERIALS AND INSTRUCTIONS FOR LOCATING AND AFFIXING THE PLAQUE TO THE VEHICLE CENTER CONSOLE, JUST FORWARD OF THE SHIFT LEVER. OWNERS WILL ALSO BE ADVISED THAT THEIR DEALER CAN AFFIX THE PLAQUE IF THEY PREFER.

1995 Ford Escort Campaign 97V145000 3 Sep 1997

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.9L ENGINES, BUILT AT THE HERMOSILLO ASSEMBLY PLANT AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN ARIZONA. CRACKS CAN DEVELOP IN THE FUEL TANK NEAR THE HEAT SHIELD ATTACHMENT RESULTING IN FUEL LEAKAGE IF THE CRACKS GO THROUGH THE FUEL TANK WALL.

Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A VEHICLE FIRE.

Remedy: DEALERS WILL REMOVE THE HEAT SHIELD ATTACHMENTS. THIS WILL NOT AFFECT HEAT SHIELD LOCATION OR FUNCTION, AS THE ATTACHMENTS ARE INTENDED TO KEEP THE SHIELD IN PLACE UNTIL THE FUEL TANK IS INSTALLED IN THE VEHICLE. AFTER INSTALLATION, THE FUEL TANK STRAPS RETAIN THE HEAT SHIELD.

1995 Ford Escort Campaign 97V144000 3 Sep 1997

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.9L ENGINES, BUILT AT THE HERMOSILLO OR WAYNE ASSEMBLY PLANTS AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN NEVADA, FLORIDA, HAWAII, TEXAS, CALIFORNIA, LOUISIANA, GEORGIA, SOUTH CAROLINA, MISSISSIPPI, OKLAHOMA, ALABAMA AND ARKANSAS. CRACKS CAN DEVELOP IN THE FUEL TANK NEAR THE HEAT SHIELD ATTACHMENT RESULTING IN FUEL LEAKAGE IF THE CRACKS GO THROUGH THE FUEL TANK WALL.

Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A VEHICLE FIRE.

Remedy: DEALERS WILL REMOVE THE HEAT SHIELD ATTACHMENTS. THIS WILL NOT AFFECT HEAT SHIELD LOCATION OR FUNCTION, AS THE ATTACHMENTS ARE INTENDED TO KEEP THE SHIELD IN PLACE UNTIL THE FUEL TANK IS INSTALLED IN THE VEHICLE. AFTER INSTALLATION, THE FUEL TANK STRAPS RETAIN THE HEAT SHIELD.

1988 Ford Escort Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1989 Ford Escort Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1990 Ford Escort Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1995 Ford Escort Campaign 94V218000 10 Nov 1994

AIR BAGS:FRONTAL

THE DRIVER SIDE AIR BAG MODULE CAN HAVE AN INADEQUATELY WELDED INFLATOR CANISTER.

Risk: IN THE EVENT OF A COLLISION, THE WELD SEAM CAN SEPARATE, CAUSING THE AIR BAG TO FAIL TO DEPLOY PROPERLY AND HOT GASES TO BE EXPELLED FROM THE BACK OF THE STEERING WHEEL. THIS CAN RESULT IN AN INCREASED RISK OF PERSONAL INJURY FROM THE HOT GASES AND THE AIR BAG FAILURE.

Remedy: DEALERS WILL INSTALL A NEW AIR BAG MODULE.

1994 Ford Escort Campaign 94V218000 10 Nov 1994

AIR BAGS:FRONTAL

THE DRIVER SIDE AIR BAG MODULE CAN HAVE AN INADEQUATELY WELDED INFLATOR CANISTER.

Risk: IN THE EVENT OF A COLLISION, THE WELD SEAM CAN SEPARATE, CAUSING THE AIR BAG TO FAIL TO DEPLOY PROPERLY AND HOT GASES TO BE EXPELLED FROM THE BACK OF THE STEERING WHEEL. THIS CAN RESULT IN AN INCREASED RISK OF PERSONAL INJURY FROM THE HOT GASES AND THE AIR BAG FAILURE.

Remedy: DEALERS WILL INSTALL A NEW AIR BAG MODULE.

1995 Ford Escort Campaign 94V197000 11 Oct 1994

AIR BAGS:FRONTAL

TWO BOLTS THAT ATTACH THE PASSENGER SIDE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM MODULE TO THE INSTRUMENT PANEL ARE MISSING. IN THE EVENT OF A FRONTAL IMPACT, THE MODULE CAN COME OUT OF THE INSTRUMENT PANEL.

Risk: THIS WOULD NOT RESTRAIN THE PASSENGER AND WOULD RESULT IN AN INCREASED RISK OF INJURY.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, INSTALL AND TORQUE TO SPECIFICATION THE MOUNTING BOLTS FOR THE PASSENGER SIDE AIR BAG.

1993 Ford Escort Campaign 94E019000 2 Jun 1994

SUSPENSION:FRONT

THE OFFSET TOE ADJUSTING PIN CAN FRACTURE UNDER CONDITIONS SUCH AS TORSIONAL LOADS, FLEXING MOTION, IMPACT LOADS, AND OVERTORQUING.

Risk: THIS CAN RESULT IN LOSS OF VEHICLE STEERING CONTROL ANDAN ACCIDENT.

Remedy: DANA WILL PAY FOR REPLACEMENT AND LABOR COSTS OF THE ADJUSTMENT PIN WITHOUT CHARGE TO THE INSTALLING FACILITY AND THE VEHICLE OWNER. THESE PINS SHOULD BE REPLACED BY A FORD ORIGINAL EQUIPMENT PIN ASSEMBLY. OWNER OR INSTALLER INQUIRIES CONCERNING THIS RECALL CAMPAIGN SHOULD CONTACT DANA SERVICE CENTER AT 1-800-248-9606.

1991 Ford Escort Campaign 94E019000 2 Jun 1994

SUSPENSION:FRONT

THE OFFSET TOE ADJUSTING PIN CAN FRACTURE UNDER CONDITIONS SUCH AS TORSIONAL LOADS, FLEXING MOTION, IMPACT LOADS, AND OVERTORQUING.

Risk: THIS CAN RESULT IN LOSS OF VEHICLE STEERING CONTROL ANDAN ACCIDENT.

Remedy: DANA WILL PAY FOR REPLACEMENT AND LABOR COSTS OF THE ADJUSTMENT PIN WITHOUT CHARGE TO THE INSTALLING FACILITY AND THE VEHICLE OWNER. THESE PINS SHOULD BE REPLACED BY A FORD ORIGINAL EQUIPMENT PIN ASSEMBLY. OWNER OR INSTALLER INQUIRIES CONCERNING THIS RECALL CAMPAIGN SHOULD CONTACT DANA SERVICE CENTER AT 1-800-248-9606.

1992 Ford Escort Campaign 94E019000 2 Jun 1994

SUSPENSION:FRONT

THE OFFSET TOE ADJUSTING PIN CAN FRACTURE UNDER CONDITIONS SUCH AS TORSIONAL LOADS, FLEXING MOTION, IMPACT LOADS, AND OVERTORQUING.

Risk: THIS CAN RESULT IN LOSS OF VEHICLE STEERING CONTROL ANDAN ACCIDENT.

Remedy: DANA WILL PAY FOR REPLACEMENT AND LABOR COSTS OF THE ADJUSTMENT PIN WITHOUT CHARGE TO THE INSTALLING FACILITY AND THE VEHICLE OWNER. THESE PINS SHOULD BE REPLACED BY A FORD ORIGINAL EQUIPMENT PIN ASSEMBLY. OWNER OR INSTALLER INQUIRIES CONCERNING THIS RECALL CAMPAIGN SHOULD CONTACT DANA SERVICE CENTER AT 1-800-248-9606.

1993 Ford Escort Campaign 94V055000 26 Mar 1994

SEATS

THE LOCK PLATE OF THE DRIVER SIDE INBOARD SEAT TRACK ADJUSTERS WERE MANUFACTURED WITH AN UNAUTHORIZED MODIFICATION TO THE FABRICATION PROCESS WHICH CAUSES THE SEAT NOT TO FULLY ENGAGE IN CERTAIN SEATING POSITIONS NEAR THE MID-POINT OF THE SEAT TRACK TRAVEL.

Risk: IN THE EVENT OF A CRASH THE SEAT CAN MOVE, WHICH WOULD RESULT IN REDUCED OCCUPANT PROTECTION.

Remedy: DEALERS WILL REPLACE THE DRIVER SIDE INBOARD SEAT TRACK.

1991 Ford Escort Campaign 93V057000 15 Apr 1993

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

THE ROLL PINS SECURING THE IGNITION LOCK IN THE STEERING COLUMN HOUSING CAN SEPARATE OR MOVE OUT OF POSITION.

Risk: THE IGNITION LOCK CYLINDER MAY DISENGAGE FROM THESTEERING COLUMN HOUSING WHICH COULD CAUSE THE STEERING COLUMN TO LOCK UP,RESULTING IN LOSS OF VEHICLE CONTROL AND A POSSIBLE ACCIDENT.

Remedy: IF ONE OR BOTH OF THE ROLL PINS ARE MISSING OR NOT FULLY INSERTED, THE IGNITION LOCK HOUSING WILL BE REPLACED, ALONG WITH THE DOOR-LOCKS AND THE LIFTGATE OR DECK-LID LOCKS SO THAT KEY COMPATIBILITY IS MAINTAINED. IF BOTH PINS ARE PRESENT AND FULLY INSERTED, A PLASTIC SNAP-ON SLEEVE WILL BE INSTALLED AS A PRECAUTION TO PREVENT THE ROLL PINS FROM COMING OUT.

1991 Ford Escort Campaign 92V117000 19 Aug 1992

FUEL SYSTEM, GASOLINE

FATIGUE CRACKS CAN DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK.

Risk: SHOULD A CRACK DEVELOP, FUEL VAPOR CAN ESCAPE FROM THETANK WHEN THE TANK IS FULL, AND A SMALL AMOUNT OF FUEL CAN LEAK FROM THE CRACK.FUEL LEAKS CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.

Remedy: INSTALL A NEW FUEL PUMP SENDING ASSEMBLY.

1992 Ford Escort Campaign 92V117000 19 Aug 1992

FUEL SYSTEM, GASOLINE

FATIGUE CRACKS CAN DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK.

Risk: SHOULD A CRACK DEVELOP, FUEL VAPOR CAN ESCAPE FROM THETANK WHEN THE TANK IS FULL, AND A SMALL AMOUNT OF FUEL CAN LEAK FROM THE CRACK.FUEL LEAKS CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.

Remedy: INSTALL A NEW FUEL PUMP SENDING ASSEMBLY.

1992 Ford Escort Campaign 92V103000 13 Jul 1992

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

THE STOP LAMP SWITCHES COULD INTERMITTENTLY MALFUNCTION RESULTING IN THE STOP LAMPS NOT ILLUMINATING WHEN THE BRAKES ARE APPLIED.

Risk: THIS COULD RESULT IN FOLLOWING MOTORISTS NOT BEINGSIGNALED THAT THE VEHICLE IS BRAKING, AND COULD RESULT IN A COLLISION.

Remedy: REPLACE THE FAULTY STOP LAMP SWITCHES.

1991 Ford Escort Campaign 90V076000 17 Apr 1990

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

INTERFERENCE OCCUR BETWEEN BOLT THAT SECURES A FUEL LINE SHIELD TO THE LOWER PORTION OF THE DASH PANEL AND THE ACCELERATOR PEDAL.

Risk: THIS COULD CAUSE THE ACCELERATOR PEDAL TO STICK AT THE WIDE OPEN THROTTLE POSITION AND RESULT IN LOSS OF CONTROL WITH THE RISK OF A VEHICLE ACCIDENT.

Remedy: CUT OFF EXTRA LENGTH OF BOLT THAT PROTRUDES ABOVE SURFACE OF WELD NUT TO PREVENT INTERFERENCE.

1990 Ford Escort Campaign 89V174000 13 Oct 1989

VISIBILITY:WINDSHIELD

SPECIAL PRIMER THAT PROMOTES THE BONDING OF A URETHANE ADHESIVE TO THE GLASS WAS NOT APPLIED TO THE WINDSHIELDS BEFORE INSTALLATION.

Risk: OMISSION OF THE PRIMER COULD CAUSE THE WINDSHIELD NOT TOBE PROPERLY ADHERED TO BODY, AND VEHICLE WOULD NOT COMPLY WITH FMVSS 212.

Remedy: REMOVE AND PROPERLY INSTALL WINDSHIELD USING SPECIAL PRIMER.

1987 Ford Escort Campaign 89V170000 13 Oct 1989

SEATS

THE FORWARD OUTBOARD PEDESTAL OF THE SEAT TRACK OF DRIVER'S SEAT MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE.

Risk: THIS COULD RESULT IN A LIMITED DEGREE OF ROCKING MOTIONOF THE DRIVERS SEAT ASSEMBLY UPON ACCELERATION OR DECELERATION, WHICH COULDCAUSE AN ACCIDENT.

Remedy: INSTALL A REINFORCEMENT ON ALL MODELS AND A NEW SEAT TRACK AS NECESSARY

1986 Ford Escort Campaign 89V170000 13 Oct 1989

SEATS

THE FORWARD OUTBOARD PEDESTAL OF THE SEAT TRACK OF DRIVER'S SEAT MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE.

Risk: THIS COULD RESULT IN A LIMITED DEGREE OF ROCKING MOTIONOF THE DRIVERS SEAT ASSEMBLY UPON ACCELERATION OR DECELERATION, WHICH COULDCAUSE AN ACCIDENT.

Remedy: INSTALL A REINFORCEMENT ON ALL MODELS AND A NEW SEAT TRACK AS NECESSARY

1985 Ford Escort Campaign 89V170000 13 Oct 1989

SEATS

THE FORWARD OUTBOARD PEDESTAL OF THE SEAT TRACK OF DRIVER'S SEAT MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE.

Risk: THIS COULD RESULT IN A LIMITED DEGREE OF ROCKING MOTIONOF THE DRIVERS SEAT ASSEMBLY UPON ACCELERATION OR DECELERATION, WHICH COULDCAUSE AN ACCIDENT.

Remedy: INSTALL A REINFORCEMENT ON ALL MODELS AND A NEW SEAT TRACK AS NECESSARY

1985 Ford Escort Campaign 89V095000 12 Jun 1989

ENGINE AND ENGINE COOLING:ENGINE

EXTERNAL CRACKS ABOVE THE NUMBER 3 CYLINDER (1984 MODELS) OR ROCKER ARM COVER GASKETS SPLITTING (1985 MODELS) COULD ALLOW OIL TO LEAK ONTO THE EXHAUST MANIFOLD.

Risk: ENGINE OIL LEAKING ONTO A HOT EXHAUST MANIFOLD COULDRESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy: REPLACE CRACKED CYLINDER HEADS (1984 MODELS); REPLACE ROCKER ARM COVER GASKETS (1985 MODELS).

1984 Ford Escort Campaign 89V095000 12 Jun 1989

ENGINE AND ENGINE COOLING:ENGINE

EXTERNAL CRACKS ABOVE THE NUMBER 3 CYLINDER (1984 MODELS) OR ROCKER ARM COVER GASKETS SPLITTING (1985 MODELS) COULD ALLOW OIL TO LEAK ONTO THE EXHAUST MANIFOLD.

Risk: ENGINE OIL LEAKING ONTO A HOT EXHAUST MANIFOLD COULDRESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy: REPLACE CRACKED CYLINDER HEADS (1984 MODELS); REPLACE ROCKER ARM COVER GASKETS (1985 MODELS).

1988 Ford Escort Campaign 87V139000 4 Sep 1987

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Risk: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

1987 Ford Escort Campaign 87V139000 4 Sep 1987

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Risk: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

1986 Ford Escort Campaign 87V139000 4 Sep 1987

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Risk: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

1987 Ford Escort Campaign 87V060000 27 Apr 1987

WHEELS:LUGS/NUTS/BOLTS/STUDS

LUG NUTS COULD GALL AND POSSIBLY SEIZE ON THE WHEEL STUDS WITHOUT PROVIDING ADEQUATE CLAMPING LOAD ON THE WHEELS.

Risk: WHEEL STUDS COULD FRACTURE CREATING A RISK OF A WHEELSEPARATING WITH LITTLE FOREWARNING.

Remedy: REPLACE WHEEL LUG NUTS AND IF NECESSARY, REPLACE WHEELS AND WHEEL STUDS.

1985 Ford Escort Campaign 85V054000 1 May 1985

VEHICLE SPEED CONTROL

THE THROTTLE LEVER MAY NOT RETURN TO IDLE POSITION DUE TO MISALIGNMENT OF THE AIR CONDITIONER SHUT OFF SWITCH TO THE THROTTLE LEVER PIN. CONSEQUENCE OF DEFECT: A JAMMED THROTTLE COULD RESULT IN A LOSS OF ACCELERATOR CONTROL, WITHOUT PRIOR WARNING, AND AN ACCIDENT.

Remedy: ADJUST SHUTOFF SWITCH AND ASSURE PROPER ALIGNMENT TO THROTTLE LEVER PIN.

1984 Ford Escort Campaign 84V123000 10 Oct 1984

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

THE BRAKE LINE MAY BE POSITIONED TOO CLOSE TO AN ENGINE BRACKET. NORMAL ENGINE MOVEMENTS MAY CAUSE THE BRACKET TO RUB AGAINST THE BRAKE LINE.

Remedy: THE BRAKE LINE WILL BE INSPECTED AND REROUTED IF NECESSARY.

1984 Ford Escort Campaign 83V134000 20 Dec 1983

SEAT BELTS:FRONT:ANCHORAGE

THE BOLTS THAT ATTACH THE D-SHAPED RING FOR THE SHOULDER BELT ARE INADEQUATELY SUPPORTED BY THE MATERIAL IN WHICH THEY ARE MOUNTED. THE ATTACHMENT DOES NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".

Remedy: DEALERS WILL INSTALL NEW ATTACHING HARDWARE TO IMPROVE THE STRENGTH OF THE MOUNTING.

Ford Escort recalls in Canada

Transport Canada runs its own recall programme. Its campaigns do not always mirror the American ones, so a Canadian owner reading a US-only list is reading about a different car than the one on their driveway.

1997 Ford Escort Recall 2002236 9 Dec 2002 42,109 units in Canada

Airbag

On certain vehicles, the Integrated Air Bag Monitor (IABM) contaminated with water or other liquids may experience internal electrical shorting. This in turn may result in air bag readiness light illumination; however in very rare occurrences, airbag deployment, melted wiring or fire may occur. Correction: Dealer will install a shield over the IABM and nyogel grease to the connector.

2000 Ford Escort Recall 2000227 16 Oct 2000 3,469 units in Canada

Seats And Restraints

Certain vehicles do not comply with the requirements C.M.V.S.S. 209 - Seat Belt Assemblies. The seat belt assemblies may not withstand the force requirements of the standard. In a crash, if the belt buckle fails, there is an increased risk of injury to the occupant. Correction: Belt buckle assemblies will be inspected and replaced if necessary.

1988 Ford Escort Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1989 Ford Escort Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1990 Ford Escort Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1993 Ford Escort Recall 1995031 21 Feb 1995 64,538 units in Canada

Electrical

NOTE: VEHICLES LOCATED IN ONTARIO, QUEBEC AND THE ATLANTIC PROVINCES. THE FUEL PUMP WIRING ASSEMBLY MAY CORRODE DUE TO ROAD SALT, POSSIBLY RESULTING IN AN ELECTRICAL BRIDGE DEVELOPING BETWEEN THE FUEL PUMP ELECTRICAL CIRCUIT AND THE FUEL GAUGE SENDER TERMINALS. THIS COULD CAUSE THE FUEL SENDER GROUND CIRCUIT TO OVERHEAT THE WIRING AND MELT ITS INSULATION PRIOR TO THE OPENING OF THE FUSE IN THE FUEL PUMP POWER CIRCUIT. THIS WOULD CAUSE SMOKE AND ODOUR AND COULD RESULT IN LOSS OF FUEL DELIVERY TO THE ENGINE AND THE ENGINE STOPPING. CORRECTION: A FUSED JUMPER HARNESS WILL BE INSTALLED IN THE FUEL PUMP/SENDER ELECTRICAL CIRCUIT.

1991 Ford Escort Recall 1995031 21 Feb 1995 64,538 units in Canada

Electrical

NOTE: VEHICLES LOCATED IN ONTARIO, QUEBEC AND THE ATLANTIC PROVINCES. THE FUEL PUMP WIRING ASSEMBLY MAY CORRODE DUE TO ROAD SALT, POSSIBLY RESULTING IN AN ELECTRICAL BRIDGE DEVELOPING BETWEEN THE FUEL PUMP ELECTRICAL CIRCUIT AND THE FUEL GAUGE SENDER TERMINALS. THIS COULD CAUSE THE FUEL SENDER GROUND CIRCUIT TO OVERHEAT THE WIRING AND MELT ITS INSULATION PRIOR TO THE OPENING OF THE FUSE IN THE FUEL PUMP POWER CIRCUIT. THIS WOULD CAUSE SMOKE AND ODOUR AND COULD RESULT IN LOSS OF FUEL DELIVERY TO THE ENGINE AND THE ENGINE STOPPING. CORRECTION: A FUSED JUMPER HARNESS WILL BE INSTALLED IN THE FUEL PUMP/SENDER ELECTRICAL CIRCUIT.

1994 Ford Escort Recall 1995031 21 Feb 1995 64,538 units in Canada

Electrical

NOTE: VEHICLES LOCATED IN ONTARIO, QUEBEC AND THE ATLANTIC PROVINCES. THE FUEL PUMP WIRING ASSEMBLY MAY CORRODE DUE TO ROAD SALT, POSSIBLY RESULTING IN AN ELECTRICAL BRIDGE DEVELOPING BETWEEN THE FUEL PUMP ELECTRICAL CIRCUIT AND THE FUEL GAUGE SENDER TERMINALS. THIS COULD CAUSE THE FUEL SENDER GROUND CIRCUIT TO OVERHEAT THE WIRING AND MELT ITS INSULATION PRIOR TO THE OPENING OF THE FUSE IN THE FUEL PUMP POWER CIRCUIT. THIS WOULD CAUSE SMOKE AND ODOUR AND COULD RESULT IN LOSS OF FUEL DELIVERY TO THE ENGINE AND THE ENGINE STOPPING. CORRECTION: A FUSED JUMPER HARNESS WILL BE INSTALLED IN THE FUEL PUMP/SENDER ELECTRICAL CIRCUIT.

1992 Ford Escort Recall 1995031 21 Feb 1995 64,538 units in Canada

Electrical

NOTE: VEHICLES LOCATED IN ONTARIO, QUEBEC AND THE ATLANTIC PROVINCES. THE FUEL PUMP WIRING ASSEMBLY MAY CORRODE DUE TO ROAD SALT, POSSIBLY RESULTING IN AN ELECTRICAL BRIDGE DEVELOPING BETWEEN THE FUEL PUMP ELECTRICAL CIRCUIT AND THE FUEL GAUGE SENDER TERMINALS. THIS COULD CAUSE THE FUEL SENDER GROUND CIRCUIT TO OVERHEAT THE WIRING AND MELT ITS INSULATION PRIOR TO THE OPENING OF THE FUSE IN THE FUEL PUMP POWER CIRCUIT. THIS WOULD CAUSE SMOKE AND ODOUR AND COULD RESULT IN LOSS OF FUEL DELIVERY TO THE ENGINE AND THE ENGINE STOPPING. CORRECTION: A FUSED JUMPER HARNESS WILL BE INSTALLED IN THE FUEL PUMP/SENDER ELECTRICAL CIRCUIT.

1995 Ford Escort Recall 1994171 3 Nov 1994 3,966 units in Canada

Seats And Restraints

THE TWO BOLTS THAT ATTACH THE PASSENGER SIDE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM MODULE TO THE INSTRUMENT PANEL MAY BE MISSING ON SOME VEHICLES. IF THE VEHICLE IS INVOLVED IN A COLLISION, THE MODULE COULD COME OUT OF THE INSTRUMENT PANEL, WHICH COULD POTENTIALLY RESULT IN PERSONAL INJURY. CORRECTION: MOUNTING BOLTS WILL BE INSTALLED AND TORQUED TO PROPER SPECIFICATION.

1989 Ford Escort Recall 1994116 19 Jul 1994 25,316 units in Canada

Emissions

THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. CORRECTION: EXHAUST SYSTEM CATALYST WILL BE REPLACED ON AFFECTED VEHICLES.

1990 Ford Escort Recall 1994116 19 Jul 1994 25,316 units in Canada

Emissions

THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. CORRECTION: EXHAUST SYSTEM CATALYST WILL BE REPLACED ON AFFECTED VEHICLES.

1993 Ford Escort Recall 1994062 25 Mar 1994 253 units in Canada

Seats And Restraints

THE DRIVER SIDE INBOARD SEAT TRACK MAY NOT FULLY ENGAGE THE SEAT ADJUSTER IN CERTAIN SEATING POSITIONS NEAR THE MID-POINT OF THE SEAT TRACK TRAVEL. IF THIS OCCURS, THE SEAT MAY MOVE IN THE EVENT OF A CRASH POSSIBLY RESULTING IN REDUCED OCCUPANT PROTECTION. CORRECTION: DRIVER SIDE INBOARD SEAT TRACK WILL BE REPLACED ON AFFECTED VEHICLES.

1992 Ford Escort Recall 1993171 15 Dec 1993 120 units in Canada

Structure

NOTE: FORD ESCORT MONTREAL 350 ANNIVERSARY EDITION. THE REAR DECK SPOILER MAY HAVE BEEN INSTALLED WITHOUT A VINYL GASKET BETWEEN THE FOOT OF THE SPOILER PEDESTAL AND THE DECK LID SURFACE. THIS COULD ALLOW THE SPOILER TO ROCK ON THE DECK LID CAUSING FATIGUE AND EVENTUAL CRACKING OF THE DECK LID SHEET METAL. LEFT UNATTENDED, THE SPOILER COULD COME FREE OF THE VEHICLE RESULTING IN A ROAD HAZARD. CORRECTION: PEDESTAL MOUNT GASKETS WILL BE INSTALLED, MOUNTING SCREWS WILL BE RETORQUED AND CRACKED TRUNK LID SHEET METAL WILL BE REPAIRED IF NECESSARY.

1988 Ford Escort Recall 1993165 6 Dec 1993 14,444 units in Canada

Emissions

NOTE: VEHICLES EQUIPPED WITH 1.9 LITRE ENGINES. THESE VEHICLES MAY RELEASE CARBON MONOXIDE EXHAUST EMISSIONS WHICH EXCEED THE REQUIREMENTS OF C.M.V.S.S 1103 - EXHAUST EMISSIONS. CORRECTION: EXHAUST SYSTEM CATALYST ASSEMBLY WILL BE REPLACED ON AFFECTED VEHICLES.

1991 Ford Escort Recall 1993078 1 Jun 1993 8,789 units in Canada

Steering

ON VEHICLES WITH MANUAL TRANSMISSION, THE ROLL PINS SECURING THE IGNITION LOCK CYLINDER IN THE STEERING COLUMN HOUSING MAY NOT REMAIN IN PLACE. THIS COULD CAUSE THE IGNITION LOCK CYLINDER TO DISENGAGE FROM THE STEERING COLUMN HOUSING WHICH COULD RESULT IN STEERING COLUMN LOCK-UP AND LOSS OF STEERING CONTROL. CORRECTION: VEHICLES WILL BE INSPECTED AND IF ROLL PINS ARE PRESENT AND FULLY INSERTED, A PLASTIC SNAP-ON SLEEVE WILL BE INSTALLED TO PREVENT THE PINS FROM COMING OUT. IF ONE OR BOTH OR THE ROLL PINS ARE MISSING OR NOT FULLY INSERTED, THE IGNITION LOCK HOUSING ASSEMBLY WILL BE REPLACED (ALONG WITH THE DOOR LOCKS AND THE LIFTGATE/DECK-LID LOCKS SO THAT KEY COMPATIBILITY IS MAINTAINED).

1991 Ford Escort Recall 1993030 9 Mar 1993 31 units in Canada

Lights And Instruments

NOTE: ESCORT PONY AND LX VEHICLES. VEHICLES CORRECTED PRIOR TO DELIVERY TO CUSTOMERS. THESE VEHICLES DID NOT COMPLY WITH C.M.V.S.S 101 - CONTROL LOCATION AND IDENTIFICATION. ODOMETERS CALIBRATED IN MILES RATHER THAN KILOMETRES. CORRECTION: ODOMETERS WILL BE REPLACED WITH ONES CALIBRATED IN KILOMETRES.

1991 Ford Escort Recall 1992121 29 Sep 1992 1,389 units in Canada

Fuel System

FATIGUE CRACKS MAY DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED ON THE TOP OF THE FUEL TANK. THIS WOULD ALLOW FUEL VAPOURS TO ESCAPE FROM THE TANK AND WHEN THE TANK IS 7/8 OR MORE FULL, A SMALL AMOUNT OF LIQUID FUEL MAY LEAK FROM THE CRACK PRESENTING A POTENTIAL FIRE HAZARD. NOTE: FOR ESCORT MODELS ONLY GT AND LXE LINES INVOLVED. CORRECTION: VEHICLES WILL BE INSPECTED AND FUEL PUMP SENDING UNIT ASSEMBLY WILL BE REPLACED WITH ONE OF IMPROVED STRENGTH.

1992 Ford Escort Recall 1992121 29 Sep 1992 1,389 units in Canada

Fuel System

FATIGUE CRACKS MAY DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED ON THE TOP OF THE FUEL TANK. THIS WOULD ALLOW FUEL VAPOURS TO ESCAPE FROM THE TANK AND WHEN THE TANK IS 7/8 OR MORE FULL, A SMALL AMOUNT OF LIQUID FUEL MAY LEAK FROM THE CRACK PRESENTING A POTENTIAL FIRE HAZARD. NOTE: FOR ESCORT MODELS ONLY GT AND LXE LINES INVOLVED. CORRECTION: VEHICLES WILL BE INSPECTED AND FUEL PUMP SENDING UNIT ASSEMBLY WILL BE REPLACED WITH ONE OF IMPROVED STRENGTH.

1992 Ford Escort Recall 1992118 28 Sep 1992 3,858 units in Canada

Brakes

VEHICLES MAY BE EQUIPPED WITH STOP LAMP SWITCHES THAT POTENTIALLY COULD INTERMITTENTLY MALFUNCTION AND RESULT IN THE STOP LAMPS NOT ILLUMINATING WHEN THE BRAKES ARE APPLIED. THIS COULD RESULT IN FOLLOWING MOTORISTS NOT BEING SIGNALED THAT THE VEHICLE IS BRAKING, WHICH COULD RESULT IN AN ACCIDENT. CORRECTION: VEHICLES WILL BE INSPECTED AND STOP LAMP SWITCHES REPLACED IF NECESSARY.

1990 Ford Escort Recall 1992077 30 Jun 1992 464,543 units in Canada

Lights And Instruments

NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAYTIME RUNNING LIGHTS THAT DIM, FLICKER OR GO OFF OR IN SOME INSTANCES MAY REMAIN ON AFTER THE IGNITION IS TURNED OFF. CORRECTION: DAYTIME RUNNING LIGHT MODULE WILL BE REPLACED ON AFFECTED VEHICLES.

1991 Ford Escort Recall 1990062 20 Apr 1990 560 units in Canada

Engine

A BOLT THAT SECURES A FUEL LINE SHIELD TO THE LOWER PORTION OF THE DASH PANEL PROTRUDES THROUGH THE PANEL AND MAY INTERFERE WITH THE ACCELERATOR PEDAL WHEN THE PEDAL IS FULLY DEPRESSED. UNDER CERTAIN CIRCUMSTANCES, THIS COULD RESULT IN THE PEDAL STICKING AT THE WIDE OPEN THROTTLE POSITION. THIS COULD CAUSE POSSIBLE LOSS OF CONTROL AND A VEHICLE CRASH. CORRECTION: BOLT WILL BE CUT OFF FLUSH WITH THE TOP OF THE WELD NUT THROUGH WHICH IT PROTRUDES.

1988 Ford Escort Recall 1989155 6 Nov 1989 87,418 units in Canada

Seats And Restraints

THE FORWARD OUTBOARD PEDESTAL OF THE SEAT TRACK OF THE DRIVER'S SEAT MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE. FRACTURE OF THIS PEDESTAL WOULD PERMIT A LIMITED DEGREE OF ROCKING MOTION OF THE DRIVER'S SEAT ASSEMBLY UPON ACCELERATION OR DECELERATION. BREAKAGE OF THE BRACKET COULD, POTENTIALLY, AFFECT THE DRIVER'S CONTROL OF THE VEHICLE AND RESULT IN AN ACCIDENT. CORRECTION: A REINFORCEMENT WILL BE INSTALLED ON THE SEAT TRACK OR THE SEAT TRACK WILL BE REPLACED IF FRACTURED.

1987 Ford Escort Recall 1989155 6 Nov 1989 87,418 units in Canada

Seats And Restraints

THE FORWARD OUTBOARD PEDESTAL OF THE SEAT TRACK OF THE DRIVER'S SEAT MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE. FRACTURE OF THIS PEDESTAL WOULD PERMIT A LIMITED DEGREE OF ROCKING MOTION OF THE DRIVER'S SEAT ASSEMBLY UPON ACCELERATION OR DECELERATION. BREAKAGE OF THE BRACKET COULD, POTENTIALLY, AFFECT THE DRIVER'S CONTROL OF THE VEHICLE AND RESULT IN AN ACCIDENT. CORRECTION: A REINFORCEMENT WILL BE INSTALLED ON THE SEAT TRACK OR THE SEAT TRACK WILL BE REPLACED IF FRACTURED.

1986 Ford Escort Recall 1989155 6 Nov 1989 87,418 units in Canada

Seats And Restraints

THE FORWARD OUTBOARD PEDESTAL OF THE SEAT TRACK OF THE DRIVER'S SEAT MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE. FRACTURE OF THIS PEDESTAL WOULD PERMIT A LIMITED DEGREE OF ROCKING MOTION OF THE DRIVER'S SEAT ASSEMBLY UPON ACCELERATION OR DECELERATION. BREAKAGE OF THE BRACKET COULD, POTENTIALLY, AFFECT THE DRIVER'S CONTROL OF THE VEHICLE AND RESULT IN AN ACCIDENT. CORRECTION: A REINFORCEMENT WILL BE INSTALLED ON THE SEAT TRACK OR THE SEAT TRACK WILL BE REPLACED IF FRACTURED.

1985 Ford Escort Recall 1989155 6 Nov 1989 87,418 units in Canada

Seats And Restraints

THE FORWARD OUTBOARD PEDESTAL OF THE SEAT TRACK OF THE DRIVER'S SEAT MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE. FRACTURE OF THIS PEDESTAL WOULD PERMIT A LIMITED DEGREE OF ROCKING MOTION OF THE DRIVER'S SEAT ASSEMBLY UPON ACCELERATION OR DECELERATION. BREAKAGE OF THE BRACKET COULD, POTENTIALLY, AFFECT THE DRIVER'S CONTROL OF THE VEHICLE AND RESULT IN AN ACCIDENT. CORRECTION: A REINFORCEMENT WILL BE INSTALLED ON THE SEAT TRACK OR THE SEAT TRACK WILL BE REPLACED IF FRACTURED.

1990 Ford Escort Recall 1989149 26 Oct 1989 177 units in Canada

Visual System

THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 212 - WINDSHIELD MOUNTING. PRIMER NOT APPLIED TO WINDSHIELD BEFORE INSTALLATION.

1987 Ford Escort Recall 1989099 13 Jul 1989 70,606 units in Canada

Emissions

THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. THE CENTRAL FUEL INJECTOR (CFI) MAY OPERATE RICH DURING CERTAIN OPERATING CONDITIONS. CORRECTION: IMPROVED CFI FUEL INJECTORS WILL BE INSTALLED AND IDLE SPEED WILL BE ADJUSTED.

1985 Ford Escort Recall 1989098 13 Jul 1989 36,695 units in Canada

Engine

ON 1984 MODELS, EXTERNAL CRACKS MAY DEVELOP IN THE ENGINE CYLINDER HEADS, WHICH MAY RESULT IN AN OIL LEAK ONTO THE EXHAUST MANIFOLD. ON 1985 MODELS, THE ENGINE ROCKER COVER GASKET MAY SPLIT, WHICH COULD ALLOW OIL TO LEAK ONTO THE EXHAUST MANIFOLD. BOTH THESE CONDITIONS CREATE THE POSSIBILITY OF THE OIL IGNITING CAUSING AN UNDERHOOD FIRE. CORRECTION: ON 1984 MODELS, THE CYLINDER HEADS WILL BE INSPECTED AND REPLACED IF FOUND TO CONTAIN EXTERNAL CRACKS. ON 1985 MODELS, THE ROCKER COVER GASKETS WILL BE INSPECTED AND REPLACED UNLESS THEY ARE OF A LATER DESIGN.

1984 Ford Escort Recall 1989098 13 Jul 1989 36,695 units in Canada

Engine

ON 1984 MODELS, EXTERNAL CRACKS MAY DEVELOP IN THE ENGINE CYLINDER HEADS, WHICH MAY RESULT IN AN OIL LEAK ONTO THE EXHAUST MANIFOLD. ON 1985 MODELS, THE ENGINE ROCKER COVER GASKET MAY SPLIT, WHICH COULD ALLOW OIL TO LEAK ONTO THE EXHAUST MANIFOLD. BOTH THESE CONDITIONS CREATE THE POSSIBILITY OF THE OIL IGNITING CAUSING AN UNDERHOOD FIRE. CORRECTION: ON 1984 MODELS, THE CYLINDER HEADS WILL BE INSPECTED AND REPLACED IF FOUND TO CONTAIN EXTERNAL CRACKS. ON 1985 MODELS, THE ROCKER COVER GASKETS WILL BE INSPECTED AND REPLACED UNLESS THEY ARE OF A LATER DESIGN.

1983 Ford Escort Recall 1988066 17 May 1988 83,870 units in Canada

Seats And Restraints

THE FORWARD SCREW WHICH PROVIDES PART OF THE ATTACHMENT BETWEEN THE DRIVER`S SEAT BACK ASSEMBLY AND THE SEAT CUSHION FRAME COULD FRACTURE AND PERMIT THE DRIVER'S SEAT BACK TO PIVOT REARWARD. SUCH A CONDITION COULD ADVERSELY AFFECT THE DRIVER'S ABILITY TO CONTROL THE VEHICLE AND COULD RESULT IN A VEHICLE CRASH. CORRECTION: NEW DRIVER'S SEAT CUSHION ATTACHMENT SCREWS WILL BE INSTALLED ON AFFECTED VEHICLES.

1984 Ford Escort Recall 1988066 17 May 1988 83,870 units in Canada

Seats And Restraints

THE FORWARD SCREW WHICH PROVIDES PART OF THE ATTACHMENT BETWEEN THE DRIVER`S SEAT BACK ASSEMBLY AND THE SEAT CUSHION FRAME COULD FRACTURE AND PERMIT THE DRIVER'S SEAT BACK TO PIVOT REARWARD. SUCH A CONDITION COULD ADVERSELY AFFECT THE DRIVER'S ABILITY TO CONTROL THE VEHICLE AND COULD RESULT IN A VEHICLE CRASH. CORRECTION: NEW DRIVER'S SEAT CUSHION ATTACHMENT SCREWS WILL BE INSTALLED ON AFFECTED VEHICLES.

1988 Ford Escort Recall 1987098 9 Sep 1987 295,731 units in Canada

Fuel System

ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHER FUEL LINE CONNECTIONS NEAR THE DASH PANELS ON SOME VEHICLES, COULD DISENGAGE DURING VEHICLE USE. SHOULD THIS OCCUR, LOSS OF FUEL WILL RESULT, PROVIDING THE POTENTIAL FOR A VEHICLE FIRE. CORRECTION: COUPLING RETAINER CLIPS WILL BE INSTALLED ON AFFECTED VEHICLES. NOTE: ESCORT VEHICLES ARE EQUIPPED WITH EFI AND CFI. LYNX VEHICLES ARE EQUIPPED WITH CFI ONLY. EFI - ELECTRONIC FUEL INJECTION CFI - CENTRAL FUEL INJECTION

1987 Ford Escort Recall 1987098 9 Sep 1987 295,731 units in Canada

Fuel System

ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHER FUEL LINE CONNECTIONS NEAR THE DASH PANELS ON SOME VEHICLES, COULD DISENGAGE DURING VEHICLE USE. SHOULD THIS OCCUR, LOSS OF FUEL WILL RESULT, PROVIDING THE POTENTIAL FOR A VEHICLE FIRE. CORRECTION: COUPLING RETAINER CLIPS WILL BE INSTALLED ON AFFECTED VEHICLES. NOTE: ESCORT VEHICLES ARE EQUIPPED WITH EFI AND CFI. LYNX VEHICLES ARE EQUIPPED WITH CFI ONLY. EFI - ELECTRONIC FUEL INJECTION CFI - CENTRAL FUEL INJECTION

1986 Ford Escort Recall 1987098 9 Sep 1987 295,731 units in Canada

Fuel System

ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHER FUEL LINE CONNECTIONS NEAR THE DASH PANELS ON SOME VEHICLES, COULD DISENGAGE DURING VEHICLE USE. SHOULD THIS OCCUR, LOSS OF FUEL WILL RESULT, PROVIDING THE POTENTIAL FOR A VEHICLE FIRE. CORRECTION: COUPLING RETAINER CLIPS WILL BE INSTALLED ON AFFECTED VEHICLES. NOTE: ESCORT VEHICLES ARE EQUIPPED WITH EFI AND CFI. LYNX VEHICLES ARE EQUIPPED WITH CFI ONLY. EFI - ELECTRONIC FUEL INJECTION CFI - CENTRAL FUEL INJECTION

1987 Ford Escort Recall 1987047 6 May 1987 53 units in Canada

Suspension

BECAUSE OF THE FRICTIONAL HEAT GENERATED BY THE HIGH SPEED LUG NUT INSTALLATION PROCESS, THERE IS A POTENTIAL FOR THE STAINLESS STEEL NUTS TO GALL AND POSSIBLY SEIZE ON THE WHEEL STUDS WITHOUT PROVIDING ADEQUATE CLAMPING LOAD ON THE WHEELS. THIS COULD CAUSE THE WHEEL STUDS TO FRACTURE IN SERVICE CREATING A RISK OF A WHEEL SEPARATING FROM THE VEHICLE WITH LITTLE FOREWARNING. CORRECTION: WHEEL LUG NUTS WILL BE REPLACED AND IF NECESSARY, WHEELS AND WHEEL STUDS WILL BE REPLACED.

1983 Ford Escort Recall 1985074 14 Jun 1985 43,561 units in Canada

THE REAR SEAT BELT RETRACTORS MAY ALLOW TWISTED WEBBING TO ENTER THE RETRACTOR HOUSING. TWISTED WEBBING MAY WEDGE BETWEEN THE RETRACTOR SPOOL AND HOUSING PRODUCING A JAMMED RETRACTOR CONDITION WHICH INTERFERED WITH WEBBING RETRACTION AND WITHDRAWAL.

1982 Ford Escort Recall 1985074 14 Jun 1985 43,561 units in Canada

THE REAR SEAT BELT RETRACTORS MAY ALLOW TWISTED WEBBING TO ENTER THE RETRACTOR HOUSING. TWISTED WEBBING MAY WEDGE BETWEEN THE RETRACTOR SPOOL AND HOUSING PRODUCING A JAMMED RETRACTOR CONDITION WHICH INTERFERED WITH WEBBING RETRACTION AND WITHDRAWAL.

1985 Ford Escort Recall 1985050 29 Apr 1985 14 units in Canada

VEHICLES WITH 1.9L ENGINE AND AIR CONDITIONING. A PIN LOCATED ON THE THROTTLE LEVER WHICH ACTUATES THE AIR-CONDITIONER SHUT-OFF SWITCH MAY BE SUBJECT TO MISALIGNMENT SUCH THAT THE SWITCH COULD JAM BEHIND THE ACTUATING ARM OF THE SWITCH. IF THIS WERE TO OCCUR, THE THROTTLE LEVER WOULD BE PREVENTED FROM RETURNING TO THE IDLE POSITION AND VEHICLE CONTROL COULD BE ADVERSELY AFFECTED.

1984 Ford Escort Recall 1984124 10 Oct 1984 1,147 units in Canada

VEHICLES MAY HAVE INADEQUATE CLEARANCE BETWEEN THE RIGHT FRONT BRAKE TUBES AND A BRACKET MOUNTED TO THE ENGINE. UNDER CERTAIN CONDITIONS THE BRACKET COULD CONTACT THE METAL BRAKE TUBE AND RESULT IN ABRASION OF THE TUBE WHICH COULD CAUSE A LOSS OF BRAKE FLUID AND A PARTIAL BRAKE LOSS. THIS WOULD RESULT IN INCREASED STOPPING DISTANCES.

1981 Ford Escort Recall 1984087 19 Jul 1984 3,721 units in Canada

ON VEHICLES WITH OPTIONAL FRONT SEAT RECLINERS, THE UPPER SHOULDER SCREW THAT ATTACHES THE DRIVER'S SEAT BACK FRAME TO THE RECLINER MECHANISM MAY BE SUSCEPTIBLE TO FATIGUE FRACTURE. IF FATIGUE FRACTURE OF THE RECLINER UPPER ATTACHMENT SCREW WERE TO OCCUR ON THE DRIVER'S SEAT, THE SEAT BACK COULD ROTATE REARWARD TO A NEAR HORIZONTAL POSITION WITHOUT WARNING POTENTIALLY AFFECTING THE DRIVER'S CONTROL OF THE VEHICLE.

1983 Ford Escort Recall 1984081 28 Jun 1984 57,970 units in Canada

THE FRONT SLEEVE BUSHINGS OF THE COOLING FAN MOTORS ARE SUSCEPTIBLE TO EXCESSIVE CORROSION IN AREAS OF HIGH ROAD SALT USE. THIS MAY INCREASE THE ROTATIONAL FRICTION OF THE FAN MOTOR OR RESULT IN SEIZURE OF THE ARMATURE SHAFT TO THE BUSHING. EITHER CONDITION MAY DRAW CURRENT IN EXCESS OF THAT OF A NORMALLY OPERATING MOTOR BUT LESS THAN REQUIRED TO OPERATE THE FUSE LINK. THIS COULD OVERHEAT THE MOTOR WIRING CIRCUITRY AND POSSIBLY RESULT IN AN UNDERHOOD OR INSTRUMENT PANEL FIRE. VEHICLES AFFECTED: CARS NOT EQUIPPED WITH FACTORY AIR CONDITIONING. QUEBEC AND ATLANTIC PROVINCES ONLY.

1984 Ford Escort Recall 1984081 28 Jun 1984 57,970 units in Canada

THE FRONT SLEEVE BUSHINGS OF THE COOLING FAN MOTORS ARE SUSCEPTIBLE TO EXCESSIVE CORROSION IN AREAS OF HIGH ROAD SALT USE. THIS MAY INCREASE THE ROTATIONAL FRICTION OF THE FAN MOTOR OR RESULT IN SEIZURE OF THE ARMATURE SHAFT TO THE BUSHING. EITHER CONDITION MAY DRAW CURRENT IN EXCESS OF THAT OF A NORMALLY OPERATING MOTOR BUT LESS THAN REQUIRED TO OPERATE THE FUSE LINK. THIS COULD OVERHEAT THE MOTOR WIRING CIRCUITRY AND POSSIBLY RESULT IN AN UNDERHOOD OR INSTRUMENT PANEL FIRE. VEHICLES AFFECTED: CARS NOT EQUIPPED WITH FACTORY AIR CONDITIONING. QUEBEC AND ATLANTIC PROVINCES ONLY.

1983 Ford Escort Recall 1984078 19 Jun 1984 32,541 units in Canada

WHEN SEVERELY LOADED BY A FRONTAL IMPACT, THE SEAT BELT WEBBING MAY CONTACT THE LEADING EDGE OF THE FRONT SEAT-BACK STELL REINFORCEMENT PLATES. THIS MAY CAUSE THE SEAT BELT WEBBING TO BE ABRADED, CUT OR COMPLETELY SEVERED, THEREBY SIGNIFICANTLY INCREASING THE RISK OF SERIOUS PERSONAL INJURIES.

1982 Ford Escort Recall 1984078 19 Jun 1984 32,541 units in Canada

WHEN SEVERELY LOADED BY A FRONTAL IMPACT, THE SEAT BELT WEBBING MAY CONTACT THE LEADING EDGE OF THE FRONT SEAT-BACK STELL REINFORCEMENT PLATES. THIS MAY CAUSE THE SEAT BELT WEBBING TO BE ABRADED, CUT OR COMPLETELY SEVERED, THEREBY SIGNIFICANTLY INCREASING THE RISK OF SERIOUS PERSONAL INJURIES.

1981 Ford Escort Recall 1984078 19 Jun 1984 32,541 units in Canada

WHEN SEVERELY LOADED BY A FRONTAL IMPACT, THE SEAT BELT WEBBING MAY CONTACT THE LEADING EDGE OF THE FRONT SEAT-BACK STELL REINFORCEMENT PLATES. THIS MAY CAUSE THE SEAT BELT WEBBING TO BE ABRADED, CUT OR COMPLETELY SEVERED, THEREBY SIGNIFICANTLY INCREASING THE RISK OF SERIOUS PERSONAL INJURIES.

1982 Ford Escort Recall 1984076 6 Jun 1984 16,741 units in Canada

THESE VEHICLES DO NOT COMPLY WITH CMVSS 1103 - EXHAUST EMISSIONS. VEHICLES AFFECTED: 1.6 L ENGINE AND ATX TRANSMISSIONS

1984 Ford Escort Recall 1983114 17 Dec 1983 37,431 units in Canada

THE UPPER TORSO RESTRAINT D-RING WHICH ATTACHES THE SHOULDER BELT TO THE B PILLAR, UNDER CERTAIN TEST CONDITIONS, SEPARATED FROM ITS ANCHORAGE, AND MAY NOT COMPLY WITH CMVSS 210 - BELT ANCHORAGE.

1983 Ford Escort Recall 1983087 18 Oct 1983 2 units in Canada

SOME OF THE VEHICLES (EQUIPPED WITH 1.6 LITRE ENGINES, CALIBRATION 3-03B-R10) MAY HAVE BEEN BUILT AND SHIPPED WITH EXHAUST AIR SUPPLY AIR CONTROL VALVE HOSES REVERSED. EMISSION LEVELS ARE EXPECTED TO INCREASE, POSSIBLY EXCEEDING THE STANDARDS. bRIVEABILITY SHOULD NOT BE AFFECTED.

1983 Ford Escort Recall 1983068 10 Aug 1983 4,635 units in Canada

THESE VEHICLES MAY NOT COMPLY WITH CMVSS 1103 - EXHAUST EMISSIONS.

1983 Ford Escort Recall 1983060 22 Jun 1983 55,191 units in Canada

TWO DOOR MODELS. FATIGUE CRACKS MAY OCCUR IN THE DOOR LOCK PILLARS AT THE FRONT DOOR LATCH STRIKER REINFORCEMENT ATTACHMENT LOCATIONS. THE FATIGUE CRACKS MAY PROPOGATE TO THE EXTENT THAT THE STRUCTURAL INTEGRITY OF THE DOOR LATCH STRIKER ATTACHMENT MAY BE SIGNIFICANTLY REDUCED CREATING THE POSSIBILITY THAT THE DOOR MAY NOT BE SECURELY RETAINED. THIS CONDITION IS OBSERVABLE BY VISIBLY NOTICEABLE CRACKS ON THE DOOR LOCK PILLAR ADJACENT TO THE STRIKER ASSEMBLIES.

1982 Ford Escort Recall 1983060 22 Jun 1983 55,191 units in Canada

TWO DOOR MODELS. FATIGUE CRACKS MAY OCCUR IN THE DOOR LOCK PILLARS AT THE FRONT DOOR LATCH STRIKER REINFORCEMENT ATTACHMENT LOCATIONS. THE FATIGUE CRACKS MAY PROPOGATE TO THE EXTENT THAT THE STRUCTURAL INTEGRITY OF THE DOOR LATCH STRIKER ATTACHMENT MAY BE SIGNIFICANTLY REDUCED CREATING THE POSSIBILITY THAT THE DOOR MAY NOT BE SECURELY RETAINED. THIS CONDITION IS OBSERVABLE BY VISIBLY NOTICEABLE CRACKS ON THE DOOR LOCK PILLAR ADJACENT TO THE STRIKER ASSEMBLIES.

1981 Ford Escort Recall 1983060 22 Jun 1983 55,191 units in Canada

TWO DOOR MODELS. FATIGUE CRACKS MAY OCCUR IN THE DOOR LOCK PILLARS AT THE FRONT DOOR LATCH STRIKER REINFORCEMENT ATTACHMENT LOCATIONS. THE FATIGUE CRACKS MAY PROPOGATE TO THE EXTENT THAT THE STRUCTURAL INTEGRITY OF THE DOOR LATCH STRIKER ATTACHMENT MAY BE SIGNIFICANTLY REDUCED CREATING THE POSSIBILITY THAT THE DOOR MAY NOT BE SECURELY RETAINED. THIS CONDITION IS OBSERVABLE BY VISIBLY NOTICEABLE CRACKS ON THE DOOR LOCK PILLAR ADJACENT TO THE STRIKER ASSEMBLIES.

1982 Ford Escort Recall 1983015 11 Feb 1983 16,499 units in Canada

STATION WAGONS. THESE VEHICLES MAY NOT COMPLY WITH CMVSS 210 - BELT AHCHORAGES.

1981 Ford Escort Recall 1983015 11 Feb 1983 16,499 units in Canada

STATION WAGONS. THESE VEHICLES MAY NOT COMPLY WITH CMVSS 210 - BELT AHCHORAGES.

1982 Ford Escort Recall 1982045 10 May 1982 1,010 units in Canada

VEHICLES WITH OPTIONAL AIR CONDITIONING. THE AIR CONDITIONER BLOWER MOTOR THERMAL LIMITER MAY NOT OPERATE AS INTENDED WHEN THERE IS A MOTOR BLOCKAGE OR MALFUNCTION. THUS, IF THE BLOWER MOTOR BECOMES JAMMED WHEN THE SYSTEM IS OPERATING IN THE MEDIUM-LOW BLOWER SPEED MODE, THE RESISTOR COILS MAY OVERHEAT CAUSING MELTING AND POSSIBLE IGNITION OF THE POLYPROPLENE EVAPORATOR HOUSING WITH ASSOCIATED VEHICLE DAMAGE.

1981 Ford Escort Recall 1981082 20 Jul 1981 9,600 units in Canada

VEHICLES MAY HAVE AN ELECTRICALLY UNGROUNDED FUEL INLET. AS A RESULT THEY MAY BE SUBJECT TO A STATIC CHARGE ACCUMULATION AT THE FUEL FILLER OPENING, IF A VEHICLE IS REFUELED FROM AN ELECTRICALLY UNGROUNDED DISPENSING NOZZLE. IF AN ARC IS PRODUCED, THIS MAY IGNITE THE MIXTURE OF FUEL VAPOUR AND AIR AT THE FILLER OPENING. IN ADDITION THE ABSENCE OF AN ELECTROSTATIC CHARGE SUFFICIENT TO ARCING WITHIN THE FUEL FILLER PIPE MAY BE GENERATED DURING FUELING.

1981 Ford Escort Recall 1981078 9 Jul 1981 559 units in Canada

VEHICLES EQUIPPED WITH POWER BRAKES. POWER BRAKE BOOSTERS MAY HAVE BEWEN IMPROPERLY ASSEMBLED BY SUPPLIER. MIS-INDEXING OF REAR SHELL OF SOME BOOSTERS RELATIVE TO THE FRONT SHELL MAY HAVE RESULTED IN INADEQUATE CRIMPING OF THE TWO SHELLS. IF BOOSTER WERE TO SEPARATE DURING VEHICLE OPERATION, COMPLETE LOSS OF SERVICE BRAKES WOULD RESULT.

1981 Ford Escort Recall 1981048 10 Apr 1981 460 units in Canada

VEHICLES WITH AUTOMATIC SPEED CONTROL. FUEL MAY MIGRATE THROUGH THE SPEED CONTROL VACUUM LINES INTO THE SPEED CONTROL SERVO ASSEMBLY THIS COULD CAUSE THE VACUUM O-RING TO SHRINK ALLOWING A VACUUM LEAK. THIS LEAK MAY RESULT IN UNINTENDED ACTIVATION OF THE SPEED CONTROL AND COULD CAUSE GRADUAL ACCELERATION OF THE VEHICLE.

1981 Ford Escort Recall 1980144 4 Nov 1980 1,700 units in Canada

METAL FASTENERS USED TO SECURE THE CARPETING TO THE FLOOR PAN MAY HAVE BEEN MILOCATED AND MAY HAVE PENETRATED THE TOP OF THE FUEL TANK. THIS CONDITION MAY ALLOW FUEL LEAKAGE.

Source: Transport Canada Vehicle Recalls Database.