119 of the 1,137 complaints about the 1999 Ford Expedition are about the electrical system — 10% of everything reported for this model year. Half of the failures with a mileage on record happened before 104,321 miles.
119
Complaints
1
Crashes
27
Fires
2
Injuries
Filed with NHTSA, in their own words.
ELECTRICAL SYSTEM
MY CAR HAS BEEN OVER HEATING AND HAVING PROBLEMS SINCE I FIRST BOUGHT IT. I COULD NOT UNDERSTAND WHY I HAVE TO CONTINUE TO KEEP FIXING IT AFTER I JUST BOUGHT IT. SOMEONE TOLD ME TO CHECK IF IT HAD A RECALL AND SURE ENOUGH IT DOES! I CHECKED ON THE DMV WEBSITE TODAY.
NHTSA complaint #11266520 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
BOUGHT A 99 FORD EXPEDITION 5.4 4X4 ABOUT 4 MONTHS AGO. TODAY 1/30/18 WAS DRIVING AND STARTED TO HEAR CLICKING NOISE UNDER DASH THE WINDSHIELD FLUID LIGHT AND 4X4 LIGHT STARTED TO FLASH AS THE SAME TIME AS IT FLASHED I HARD THE CLICKING NOISE THE RADIO THEN TURNED OFF AND THE PASSENGER SIDE WINDOW STOPPED WORKING ALSO FAN BLOWER WILL WORK WITH THE TRUCK IS SHUT OFF. LAST WEEK I HAD SHUT MY FORD EXPO OFF I WENT TO RESTART IT ABOUT A HALF HOUR LATER AND WOULD NOT START BACK UP. THE TRUCK FINILY STARTED ABOUT A HOUR LATER.
NHTSA complaint #11065980 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. AFTER PARKING THE VEHICLE NEAR THE CONTACT'S GARAGE, A FIRE ERUPTED UNDER THE HOOD. THE CONTACT WAS ALERTED TO THE FAILURE DUE TO THE ALARM SOUNDING. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS NOT DIAGNOSED AND REMAINED PARKED AT THE CONTACT'S RESIDENCE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 06E056000 (FUEL SYSTEM, GASOLINE) AND 98V312000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
NHTSA complaint #10903283 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
DOME LIGHTS, RUNNING LIGHTS, DOOR AJAR LAMP, ODOMETER LAMP, DOOR AJAR AUDIBLE ACTIVATING INTERMITTENTLY WHILE IN MOTION ON A STREET OR HIGHWAY. SOMETIMES STAYING ON AFTER VEHICLE IS TURNED OFF. COMING ON AT ANYTIME AFTER VEHICLE IS TURNED OFF AND STATIONARY, CAUSING A DEAD BATTERY LEAVING DRIVER, FAMILY AND OCCUPANTS STRANDED.
NHTSA complaint #10823313 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. THE CONTACT STATED THAT THE HORN ACTIVATED INDEPENDENTLY. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FAILURE WAS DUE TO A FIRE UNDER THE HOOD TOWARD THE DRIVER SIDE OF THE VEHICLE. THE CONTACT STATED THAT SMOKE AND FLAMES WERE EMITTING FROM THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED. HOWEVER, THE FIRE DID NOT EXTINGUISH RESULTING IN THE VEHICLE EXPLODING. THE MANUFACTURER WAS NOT NOTIFIED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES SUSTAINED. THE APPROXIMATE FAILURE MILEAGE WAS 163,000.
NHTSA complaint #10715114 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
APPEARS WHEN IT RAINS, THE VEHICLE WILL NOT START. TOOK SAME TO A LOCAL SHOP THAT SPECIALIZE IN ELECTRICAL SYSTEMS. THEY COULD NOT FIND ANYTHING WRONG AND ADVISED THEY WERE AWARE OF WINDSHIELD LEAKAGE. THEY ADVISED THEY DID NOT SEE ANY EVIDENCE OF LEAKAGE. VEHICLE CAN BE DRIVEN SEVERAL MONTHS WITH NO ISSUES, BUT APPEARS TO OCCUR WHEN THERE IS A HEAVY RAIN. UPON REVIEWING OTHER POST, IT APPEARS THIS IS A LONGER EXISTING PROBLEM WITH THE YEAR AND MAKE VEHICLE.
NHTSA complaint #10692663 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
CHANGED HEATER CORE IN THE FRONT ALONG WITH THE BLEND DOOR HEAT LASTED FOR UP TO 3 DAYS AND GOT NOTHING BUT COLD AIR IN THE FRONT OF MY TRUCK BLOWING OUT STILL HAVE HEAT IN THE BACK THIS IS CRAZY IT IS TO COLD FOR THIS AND I SPENT MY LAST ON FIXING MY HEAT TO ONLY RESULT IN IT GOING BACK OUT THREE DAYS LATER PEOPLE ARE TELLING ME IT MIGHT BE THE HEATER BOX MOTOR I JUST WANT HEAT I'M TIRED OF SHIVERING WHILE I DRIVE .
NHTSA complaint #10669579 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER STATED THAT THE FUSE BOX AND GEM MODULE MULTI-FUNCTION FAILED DUE TO A WATER LEAK FROM THE WINDSHIELD. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 99,084.
NHTSA complaint #10614638 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I HAVE THIS VERY SAME PROBLEM. WHILE VEHICLE IS OFF THE HEATER BLOWERS WILL TURN ON AND RUN BATTERY DOWN. WHILE DRIVING 4X4, WASHER LIGHTS, POWER WINDOWS, RADIO, INTERIOR LIGHTS ALL TURN OFF AND ON. RADIO WORKS WHILE IN PARK BUT, POWERS DOWN WHEN VEHICLE IS PUT IN GEAR. HAVE HAD ISSUES WITH WATER GETTING IN AND RUNNING DOWN DRIVERS SIDE. APPEARS ALOT OF PEOPLE ARE HAVING THE SAME ISSUE. BOUGHT THE VEHICLE IN 2008 JUST STARTED HAVING THESE ISSUES WITHIN THE PAST YEAR STARTED OUT SLOW BUT ARE GETTING WORST AND MORE FREQUENT. NOW MY VEHICLE AFTER JUMP STARTING IT I HEAR A ELECTRICAL NOISE COMING FROM MY STARTER, IT SHUTS THE CAR OFF AND KILLS THE BATTERY. THE CAR WILL ONLY RUN FOR TEN SECONDS OR SO BEFORE IT REPEATS.
NHTSA complaint #10555883 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED WITH THE ENGINE TURNED OFF, THE REAR BRAKE LIGHTS AND INSTRUMENT PANEL BEGAN TO ILLUMINATE. THE CONTACT DISENGAGED THE BATTERY CABLE TO PREVENT THE MALFUNCTION FROM CONTINUING. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 155,000. THE VIN WAS UNAVAILABLE.
NHTSA complaint #10442707 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE RADIO WOULD TURN ON AND OFF WITHOUT THE KEY IN THE IGNITION, THE STARTER TRIES TO START THE VEHICLE WITHOUT THE KEY IN THE IGNITION. WHILE DRIVING DOWN THE ROAD THE INTERIOR LIGHTS FLICKER AND THE HEADLIGHTS WILL TURN ON AND OFF RANDOMLY. AUTOMATIC DOOR LOCKS WILL NOT ALWAYS WORK.
NHTSA complaint #10422502 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 1999 FORD EXPEDITION. THE CONTACT STATED THAT WATER PENETRATED THE VEHICLE CAUSING THE GENERAL ELECTRICAL MODULE, AND FUSE BOX, TO CORRODE. THE VEHICLE STARTED ON ITS OWN AND CAUSED THE RADIO, HEATER, AND ALL OTHER ELECTRICAL FUNCTIONS TO FAIL. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER REPLACED THE ELECTRICAL MODULE AND THE FUSE BOX SEVERAL TIMES. THE WINDSHIELD WAS REPLACED, BUT THE DEALER WASN'T ABLE TO LOCATE DETERMINE WHERE THE WATER PENETRATED THE VEHICLE. THE MANUFACTURER TOOK A REPORT 0478403130 AND ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER. THE FAILURE MILEAGE WAS 30,000. THE CURRENT MILEAGE WAS 135,000. UPDATED 3/8/11 *CN UPDATED 11/28/11
NHTSA complaint #10366869 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
MY 1999 FORD EXPEDITION WENT UP IN FLAMES LAST NIGHT (JUNE 26) IN MY DRIVEWAY. I HAD DRIVEN THE TRUCK HOME, TURNED IT OFF AND WALKED INSIDE TO GO TO BED. APPROXIMATELY FIFTEEN MINUTES LATER, I WAS AWOKEN TO MY CAR HAVING SEVEN FOOT FLAMES COMING FROM THE HOOD. THE FIRE DEPARTMENT WAS CALLED AND WE BEGAN TRYING TO FIGHT THE FIRE. THE TRUCK IS A TOTAL LOSS. I BOUGHT THIS VEHICLE IN MAY OF 2008 AND I UNDERSTAND THAT THERE WAS A RECALL ON THIS VEHICLE. I WAS NEVER NOTIFIED OF ANY RECALL.
NHTSA complaint #10340275 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WHEN IT RAINS MY 1999 FORD EXPEDITION TURNED ON THE LIGHTS ALL BY ITSELF , AND THEN PROCEEDED TO TRY AND CRANK ITSELF WITH NO KEY. RADIO AND AIR COMES ON BY THEMSELVES, CLICKING NOISE UNDER DASH , FOUND SEVERAL COMPLAINTS SAYING THAT IT IS A LEAK IN THE WINDSHIELD CAUSING THE COMPUTER TO GET WET.
NHTSA complaint #10339617 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
OUR BATTERY DIED BECAUSE THE AIR FAN INSIDE THE CAR WOULD NOT SHUT OFF. ONCE I GOT CAR JUMP STARTED NOTICED THAT MANY ELECTRICAL DEVICES WERE EITHER NOT WORKING OR TURNING ON AND OFF BY THEMSELVES. THESE PROBLEMS CONTINUED AFTER I REPLACED BATTERY. I TOOK IT TO THE DEALERSHIP AND WAS TOLD THAT THE WINDSHIELD IN 1999 FORD EXPEDITION LEAKED CAUSING ELECTRICAL SHORTAGES IN MOST ELECTRICAL COMPONENTS IN THE CAR. AND WOULD COST $1000.00 TO FIX AND THE WINDSHIELD WOULD NEED TO BE REPLACED FOR ANOTHER $200.00. AFTER RESEARCHING THIS I HAVE FOUND THAT THIS IS A WELL KNOWN PROBLEM IN THIS MODEL BUT NO RECALL HAS BEEN ESTABLISHED.
NHTSA complaint #10325211 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
UNUSUAL CIRCUMSTANCES SUCH AS WINDOW SWITCH WORKING THE WIPERS, DIGITAL ODOMETER GOING OFF AND ON, BRAKES WORKING THE INTERIOR DOME LIGHTS,BLOWER MOTOR FOR HEATER COMING ON WITHOUT A KEY EVEN IN THE IGNITION,DOOR LOCKS DON'T ENGAGE UNTIL MOVING FOR A MINUTE OR TWO,AFTER BLOWER MOTOR KICKED ON WITHOUT A KEY, TOOK TO SHOP AND THEY SAID WATER HAD GOTTEN IN THE POWER DIST. BOX AND FLOORBOARD HAD MOISTURE ALSO. WILL COST ME OVER 700.00 BUT I CANT AFFORD TO FIX ON MY 600.00 DISABILITY CHECK I GET A MONTH. THANKS FORD!!!
NHTSA complaint #10321758 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
1999 FORD EXPEDITION. SUV HAS BEEN RANDOM ELECTRICAL ANOMALIES OVER THE PAST MONTH FROM TODAY. GAUGES, INTERIOR FANS, AND LIGHTS WOULD STAY ON WHEN THE IGNITION WOULD BEE IN THE OFF POSITION AND KEY REMOVED. UPON INSPECTION FROM A LOCAL FORD DEALERSHIP SERVICE DEPARTMENT, IT HAS BEEN NOTED FROM THEM THAT CORROSION OF THE GENERAL ELECTRICAL MODULE AND FUSE BOX ARE THE CAUSE, MOST LIKELY FROM A WATER LEAK FROM THE FRONT WINDSHIELD. IMPROPER INFORMATION FROM DASH CONSOLES CAN LEAD TO STALLS ON ROADWAYS OR IMPROPER DRIVING DUE TO IMPROPER INFORMATION RECEIVED FROM THE INSTRUMENT PANEL. IN MY CASE, IT IS LIMITED TO BATTERY DRAIN, IMPROPER FUEL READINGS, WINDSHIELD WIPER FAILURE, AND FAILURE TO START. IN THE END IT IS MAINLY A RESEMBLANCE TO ODI COMPLAINT EA05-015.
NHTSA complaint #10288711 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
1999 FORD EXPEDITION WINDSHIELD LEAKS AND SHORTS OUT ELECTRICAL SYSTEM. HAPPENS WHEN UNATTENDED OFTEN AND TURNS ON LIGHTS AND OTHER SYSTEMS SO BATTERY GOES DEAD. HAD FORD DEALER REPAIR ONE YEAR AGO AND PROBLEM HAS RETURNED.
NHTSA complaint #10286268 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
ELECTRICAL SYSTEM MALFUNCTIONING ON 1999 FORD EXPEDITION. LIGHTS, DOOR LOCK, WINDOWS, AIR CONDITIONING, RADIO, FLASHERS, LIGHTS, GAUGES.
NHTSA complaint #10276883 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 1999 FORD EXPEDITION. THE CONTACT STATED THAT SHE PREVIOUSLY EXPERIENCED FAILURES WITH THE BATTERY LOSING POWER AND THE VEHICLE SHUTTING OFF WITHOUT WARNING. THE BATTERY WAS REPLACED THREE TIMES, BUT THE FAILURE WAS NOT CORRECTED. ON MAY 16, 2009, WHILE DRIVING APPROXIMATELY 30 MPH, THE BATTERY LOST POWER AND THE WINDSHIELD WIPER WASHER RELEASED FLUID. WITHIN SECONDS, THE VEHICLE SHUT OFF. THE DEALER STATED THAT THE GEM MODULE WAS CORRODED. THE MANUFACTURER FILED REPORT NUMBER 0481541389 AND STATED THAT THERE WAS NO RECALL; THEREFORE, THEY WOULD NOT ASSIST. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 130,000.
NHTSA complaint #10269116 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WATER LEAKS IN THE WINDSHIELD CAUSING BLOWER MOTOR TO STAY ON AFTER IGNITION IS ON, RANDOMLY TRIES TO START WHEN KEY IS NOT EVEN IN IGNITION, LIGHTS BLINK, COULD CAUSE FIRE.
NHTSA complaint #10259297 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
IT STARTED OFF WITH A BEEPING, THAT HAPPENED ONCE AND A WHILE. I ALSO NOTICED WHEN THE DEFROSTER WAS TURNED ON BLACK DUST LIKE STUFF WOULD BLOW OUT. THEN ONE DAY MY HUSBAND AND I HEARD THE EXPEDITION TRYING TO START. NO KEYS IN THE IGNITION, NO ONE IN THE TRUCK! MY HUSBAND HAD TO DISABLE THE BATTERY TO GET IT TO STOP. WE WERE GOING TO TAKE IT TO THE FORD DEALER,BUT WHEN WE STARTED IT, IT CONTINUED TO TRY AND TURN OVER. THEREFORE MY HUSBAND HAD TO DISCONNECT THE BATTERY AGAIN AND WE HAD TO PAY FOR A TRUCK HAULER TO TAKE IT TO THE FORD DEALER. WHILE AT THE DEALER WE TOLD THEM IT COULDN'T BE STARTED, BECAUSE OF IT TRYING TO TURN OVER, BUT APPARENTLY THEY DID LET IT RUN AND NOW WE HAVE STARTER PROBLEMS. ALSO THEY HAD THE WINDSHIELD SEAL REPLACED, BUT IT STILL LEAKS. WE WILL BE TAKING IT BACK TO THEM TO HAVE THEIR REPAIRS REPAIRED. IT'S A SHAME, I WAS SO PROUD OF MY SUV, NOW I JUST DON'T KNOW.
NHTSA complaint #10240980 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
VEHICLE FIRE OF FORD EXPEDITION - TOTAL LOSS.
NHTSA complaint #10221903 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION:MODULE
CAR ON BOARD COMPUTER HAD TO BE REPLACED.
NHTSA complaint #10218656 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
WINDSHIELD LEAKED INTO FUSE BOX AND GEM MODULE, GROWING A FUNGUS AND NEEDING REPLACEMENT, CREATING ELECTRICAL FUNCTIONS TO TURN ON AND OFF AT WILL WITH THE POTENTIAL OF CAUSING A FIRE.
NHTSA complaint #10218149 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WINDSHIELD LEAKED INTO FUSE BOX AND GEM MODULE, GROWING A FUNGUS AND NEEDING REPLACEMENT, CREATING ELECTRICAL FUNCTIONS TO TURN ON AND OFF AT WILL WITH THE POTENTIAL OF CAUSING A FIRE.
NHTSA complaint #10218149 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
ELECTRICAL SYSTEM HAD INTERMITTENT FAILURES, LIGHTS GOING ON AND OFF, DASH LIGHTS FLASHING, RADIO GOING ON AND OFF, AMMETER FLUCTUATING.
NHTSA complaint #10217975 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
UNWANTED ELECTRICAL ACTIVITY THAT CAN RESULT IN FIRES. RADIO, WIPERS AND HVAC BLOWER TURN ON SPONTANEOUSLY WHEN VEHICLE IGNITION IS OFF. BURNING RUBBER SMELL SOMETIMES.
NHTSA complaint #10214682 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
EVERY TIME IT RAINS. WHEN SUV IS PARKED AND TURNED OFF THE WIPERS COME ON. HEADLAMPS AND FLASHERS GO ON AND OFF. RADIO TURNS ON AND OFF. VEHICLE TRIES TO START ITSELF WITHOUT KEY IN THE IGNITION. BATTERY DISCHARGES.
NHTSA complaint #10210709 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I OWN A 1999 FORD EXPEDITION TRUCK, THIS TRUCK CAUGHT ON FIRE AND BLEW UP TUESDAY OCTOBER 2, 2007 AT APPROXIMATELY 7:02 PM. I HAD JUST FINISHED PARKING THE TRUCK 7 MINUTES PRIOR TO IT CATCHING ON FIRE AND BLOWING UP. THE VEHICLE IS NOW OF NO USE. *TR THE CONSUMER STATED WROTE FORD TWICE ABOUT THE DEFECT BUT FORD INFORMED HIM THERE WAS NOTHING THEY COULD DO DUE TO THE EXTENSIVE DAMAGE ON THE VEHICLE. NEW JERSEY INCIDENT REPORT. UPDATED 11/06/07
NHTSA complaint #10205041 — an unverified report by a vehicle owner.