at 150,000 miles
Mansfield, TX
ENGINE
SPARK PLUGS BLOWING OUT OF THE ENGINE REPEATEDLY WHILE DRIVING
NHTSA complaint #11113230 — an unverified report by a vehicle owner.
1999 Ford Expedition engine problems
279 of the 1,137 complaints about the 1999 Ford Expedition are about the engine — 25% of everything reported for this model year. Half of the failures with a mileage on record happened before 105,000 miles.
279
Complaints
1
Crashes
23
Fires
3
Injuries
Exactly what failed
Engine
115
41.2%
Engine AND Engine Cooling
67
24.0%
Gasoline
48
17.2%
Engine
26
9.3%
Manifold/Header/Muffler/Tail Pipe
7
2.5%
Exhaust System
4
1.4%
Cooling System
4
1.4%
Emission Control
3
1.1%
Hoses/Lines/Piping/Fittings
2
0.7%
Radiator Assembly
1
0.4%
Engine & Cooling across every Ford Expedition year
1997
101
5.0%
1998
146
7.3%
1999
279
13.9%
2000
146
7.3%
2001
140
7.0%
2002
123
6.1%
2003
173
8.6%
2004
55
2.7%
2005
104
5.2%
2006
166
8.3%
2007
30
1.5%
2011
13
0.6%
2012
12
0.6%
2013
12
0.6%
2014
10
0.5%
2015
32
1.6%
2016
40
2.0%
2017
43
2.1%
2018
122
6.1%
2019
139
6.9%
2020
53
2.6%
2021
58
2.9%
2022
10
0.5%
What owners said
Filed with NHTSA, in their own words.
at 200,000 miles
Alabaster, AL
Fire
ENGINE
TL* THE CONTACT OWNED A 1999 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V388000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS REPAIRED. AFTER THE REPAIR, WHILE THE VEHICLE WAS PARKED, IT CAUGHT FIRE UNDERNEATH THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA complaint #10910841 — an unverified report by a vehicle owner.
Kennesaw, GA
Fire
ENGINE
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. AFTER PARKING THE VEHICLE NEAR THE CONTACT'S GARAGE, A FIRE ERUPTED UNDER THE HOOD. THE CONTACT WAS ALERTED TO THE FAILURE DUE TO THE ALARM SOUNDING. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS NOT DIAGNOSED AND REMAINED PARKED AT THE CONTACT'S RESIDENCE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 06E056000 (FUEL SYSTEM, GASOLINE) AND 98V312000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
NHTSA complaint #10903283 — an unverified report by a vehicle owner.
at 199,000 miles
Jefferson, AL
Fire
1 injured
ENGINE
TL* THE CONTACT OWNED A 1999 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY. THE POLICE BELIEVED THAT THE FIRE ORIGINATED ON THE DRIVER SIDE UNDER THE HOOD. A POLICE AND A FIRE REPORT WERE FILED. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH TWO FIRE EXTINGUISHERS AND A HOSE BEFORE THE FIRE DEPARTMENT ARRIVED. A PASSENGER WHO WAS SEATED IN AN UNKNOWN LOCATION SUSTAINED A FRACTURED RIGHT KNEE, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 199,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #10894407 — an unverified report by a vehicle owner.
Walker, LA
ENGINE
I WAS SITTING AT MC DONALDS GETTING FOOD FOR MY SON, WHEN A LOUD POP COME FROM UNDER MY HOOD THEN MY TRUCK STARTED TO SMELL FUNNY. SOME CARS WERE IN FRONT OF ME SO THEY LET ME OUT. I PULLED OFF TO THE SIDE AND CALLED A FEW PEOPLE THAT COULD TELL ME WHAT WAS GOIN ON. A MAN COME AND LOOKED AT IT THAT WORKED ON CARS A CROSSED THE STREET TOLD ME THAT IT BLOWED A SPARK PLUG I NEVER HEARD OF ANYTHING LIKE THAT. IT HAD COME COMPLETELY OUT. THERE WAS OIL ON IT. I HAD TO HAVE IT REDONE SO ANOTHER SPARK PLUG COULD BE PUT IN THERE AND NOW IT HAS DON IT AGAIN. THE SAME ONE NUMBER 2. SPARK PLUG. THIS IS CRAZY I DON'T HAVE THE MONEY TO KEEP FIXIN THIS TRUCK OVER AND OVER. I HAD TO HAVE IT TOWED TO MY HOUSE WHEN IT BLEW THE SPARK PLUG AND I DONO WANT TO GO THOUGH THIS AGAIN. YALL KNOW THAT THIS IS A DEFAULT IN THESES VEHICLES BUT UR NOT DOING ANYTHING ABOUT IT. I HAVE TO USE MY TRUCK TO GO TO THE DOCTORS. AND I CAN'T GO IF IT STAYS BROKE DOWN. YALL NEED TO TAKE CARE OF THIS PROBLEM ....
NHTSA complaint #10882441 — an unverified report by a vehicle owner.
at 138,000 miles
Lagrange, KY
ENGINE
I HAVE HAD 2 DIFFERENT SPARK PLUGS EJECTED FROM THE ENGINE ON 2 SEPARATE OCCASIONS. THE FIRST TIME I TOOK IT IN AND HAD A HELI COIL INSTALLED. I HAVE NOT REPAIRED THE SECOND INSTANCE YET. THERE WAS A 2 YEAR TIME SPAN BETWEEN THE EVENTS. THE FIRST TIME IT HAPPENED I WAS AT LOW SPEED GOING THROUGH TOWN. THE SECOND TIME I WAS ON THE FREEWAY.
NHTSA complaint #10855526 — an unverified report by a vehicle owner.
at 200,000 miles
Arlington, TX
ENGINE
A SPARK PLUG BLOW OUT OF THE ENGINE. I PURCHASED A DORMAN KIT TO REPAIR AND REPLACE THE SPARK PLUG. I AM CONCERNED ABOUT DRIVING THE VEHICLE FAR FROM HOME FOR CONCERN THAT ANOTHER SPARK PLUG MAY BLOW OUT OF THE ENGINE. FORD MOTOR COMPANY SHOULD HAVE MADE THE ISSUE WITH THE ENGINE CYLINDER HEADS NOT HAVING THICK ENOUGH MATERIAL TO HOLD SPARK PLUGS IN THE THREADS A RECALL.
NHTSA complaint #10836565 — an unverified report by a vehicle owner.
at 187,000 miles
Clinton, TN
ENGINE
THE SPARK PLUG BLEW OUT OF THE HEAD WHILE I HAS JUST PULLED OUT ACCELERATING UP A SMALL INCLINE. I WAS GOING THROUGH A MAJOR INTERSECTION WITH MY SON. THERE WAS A STUTTER, THEN KNOCKING SOUND, LESS POWER, AND STRANGE ODOR.
NHTSA complaint #10807975 — an unverified report by a vehicle owner.
at 350,000 miles
Spring Hill, TN
ENGINE
#8 CYLINDER BLEW THE SPARK PLUG OUT OF THE HOLE WHEN THE CAR WAS STARTED
NHTSA complaint #10807099 — an unverified report by a vehicle owner.
at 165,000 miles
Louisville, KY
ENGINE
MY EXPEDITION STARTED ACTING LIKE IT WAS STARVING FOR FUEL MISFIRING LOSS OF POWER AND THERE'S A TICKING SOUND CONING FROM UNDER THE DASH BOARD THE DOOR LOCK UNLOCK THE LIGHTS FLICKER AND HORN BEEPS BY ITS SELF I PARKED IT AND A COUPLE DAYS LATER IT WOULDNT IT TRYING TO CRANK BUT ITS SOUND I DONT BELIEVE BATTERY IS DEAD IF IT WAS THEN LIGHTS WOULDN'T COME ON NOW AND AGAIN ALSO WHEN I USE MY KEY RING LOCK TO LOCK THE DOOR THERE'S A CLUNK CLUCK SOUND I'VE SPENT A LOT OF MONEY TRYING TO FIND OUT WHAT'S WRONG WITH LAMONT THAT'S MY EXPEDITIONS NAME AND NOBODY KNOWS LAST REPAIR SHOP HAD IT 9 DAYS TOTAL ON THE 7TH DAY I CALLED THEM THEY SAID THEY HAD NO IDEA AND ON THE 9TH I WENT IN AND THEY SAID I NEEDED A NEW MOTOR COSTING 2600 AND CHARGING ME 220 TO TELL ME THAT. THE SHOP BEFORE THAT COST ME 350 SAYING THE TRUCK ITSELF WERE THE PLUGS GO IN WAS STRIPPED AND THEY NEEDED A SPECIAL TOOL. ANY HOW I BELIEVE IT WOULD BE A MATTER OF TIME BEFORE THE VEHICLE WILL CATCH ON FIRE. THE VEHICLE IS VERY UNPREDICTABLE AND YOU DONT KNOW WHAT IT WILL DO NEXT IT ALSO DIES WHILE DRIVING IT ..
NHTSA complaint #10744850 — an unverified report by a vehicle owner.
Bartlesville, OK
ENGINE AND ENGINE COOLING
1999 FORD EXPEDITION. CONSUMER WRITES IN REGARDS TO VEHICLE BLOWN SPARK PLUGS. *SMD THE CONSUMER STATED WHILE DRIVING, THE SPARK PLUG BLEW OUT THE CYLINDER#8. *JB UPDATED 09/21/15*LJ THE CONSUMER STATED THE VEHICLE LOST POWER AND EVENTUALLY STALLED. UPDATED 09/24/15
NHTSA complaint #10732116 — an unverified report by a vehicle owner.
at 174,815 miles
Greenville, SC
ENGINE
AFTER PICKING UP LAUNDRY, ON MY WAY TO STAPLES ALL OF THE SUDDEN I HEARD A LOUD POP, THEN A STRONG SMELL OF GAS. I PULLED OVER, TURNED OFF TRUCK. TURNED IT BACK ON THEN HEARD A LOUD POPPING SOUND. GOT THE TRUCK HOME OPENED THE HOOD AND NOTICED SPARK PLUG OUT OF ENGINE ATTACHED TO A DAMAGED COIL. I TRIED TO PUT IN NEW SPARK PLUG BUT IT WOULD NOT SCREW IN, THE THREADS IN CYLINDER HEAD WERE STRIPPED. FOUND OUT IT WOULD COST A LOT OF MONEY TO GET CYLINDER HEAD RETHREADED. WROTE TO FORD CORPORATE THEY ASKED ME FOR VIN NAME AND BASIC INFO. I FOUND OUT THAT THIS IS COMMON IN TRITON ENGINES. IT IS A DESIGNER FLAW IN FORD. FORD KNEW ABOUT IT FOR YEARS NOW. SPARK PLUG BLOWS OUT FOR NO REASON. AFTER SPARK PLUG POPS OUT A STRONG SMELL OF GAS COMES OUT. THIS COULD CAUSE ENGINE TO EXPLODE. THIS HAPPENS IN FORD TRITON ENGINES. THIS IS UNSAFE.
NHTSA complaint #10721283 — an unverified report by a vehicle owner.
at 174,616 miles
Greenville, SC
ENGINE
AFTER PICKING UP MY LAUNDRY, I HEADED TO STAPLES WHILE DRIVING 45 MPH I HEARD A LOUD BOOM AND VERY STRONG SMELL OF GAS SO I PULLED OVER TURNED OFF TRUCK. I STARTED AGAIN AND IT WAS A LOUD POPPING SOUND. I GOT HOME CHECKED TRUCK ENGINE. I NOTICED MY COIL PACK OUT AND SPARK PLUG ATTACHED TO IT. I TRIED TO PUT SPARK PLUG BUT THE THREADS WERE ALL STRIPED. I CHECKED THE INSIDE OF CYLINDER HEAD COULD NOT SEE TRIED TO PUT IN A NEW SPARK PLUG BUT I CAN TURN AND TURN AND THE SPARK PLUG WOULD NOT SCREW IN. THIS IS DANGEROUS BECAUSE WHEN SPARK PLUG BLOWS OUT YOU HAVE ALL THE ODOR OF GAS COMING OUT AND THAT ONE SPARK CAN CAUSE ENGINE TO BLOW UP. I CONTACTED FORD ALL THEY TOOK WAS MY VIN NUMBER AND NAME NEVER HEARD FROM THEM AGAIN.
NHTSA complaint #10721229 — an unverified report by a vehicle owner.
at 143,000 miles
Warminster, PA
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 45 MPH, THE BOLTS FROM THE EXHAUST MANIFOLD RELEASED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE EXHAUST MANIFOLD AND BOLTS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.
NHTSA complaint #10690606 — an unverified report by a vehicle owner.
at 183,000 miles
Severn, MD
ENGINE
AS I WAS ON THE HIGHWAY, THERE WAS A LOUD BLOW OUT AS I WAS GOING 60 MILES PER HOUR. THIS IS THE 4TH TIME THAT I HAVE HAD A PROBLEM WITH THE COILS IN THIS TRUCK AND THIS TIME THE ACTUAL SPARK PLUG BLEW OUT OF THE ENGINE LEAVING A OPEN HOLE THAT COULD IGNITE A FIRE. I HAVE NOW SPENT OVER $3600 ON REPAIRS JUST TO FIND OUT WITH DOING SOME ONLINE RESEARCH THAT FORD KNEW OF THIS PROBLEM FOR YEARS AND HAS BEEN BLAMING THE CONSUMER FOR TIGHTENING THE SPARK PLUGS TO TIGHT AND OTHER BULL THAT THEY COME UP WITH AND NOT TAKING RESPONSIBILITY FOR THE CHEAP ALUMINUM PLUGS AND PLUG WIRES IN THEIR VEHICLE. THIS EFFECT CARS AND TRUCK WITH THIS ENGINE SINCE 1999 AND GOES THROUGH VEHICLES OF 2008. A 9 YEAR PROBLEM AND THE FORD CORPORATION DID NOT DO A RECALL. THIS WILL EFFECT IF I WILL BE BUYING ANOTHER FORD VEHICLE FOR SURE.
NHTSA complaint #10681280 — an unverified report by a vehicle owner.
at 220,000 miles
Bates City, MO
ENGINE
I HAVE HAD SPARK PLUGS BLOW TWICE IN THIS ENGINE WHILE DRIVING ON THE HIGHWAY. THE LAST TIME IN JANUARY 2014 THAT I HAVEN'T HAD THE MONEY TO FIX THIS TIME. AFTER RESEARCHING ON THE INTERNET, I HAVE FOUND THAT THIS IS AN EXTREMELY COMMON PROBLEM WITH THIS PARTICULAR VEHICLE AND FORD HAS DONE NOTHING ABOUT IT EVEN THOUGH THEY KNOW IT IS A COMMON PROBLEM WITH THEIR DESIGN. IT IS A WONDER THAT MORE PEOPLE HAVEN'T GOTTEN HURT FROM THIS PROBLEM WHILE DRIVING ON THE HIGHWAY.
NHTSA complaint #10668917 — an unverified report by a vehicle owner.
at 120,000 miles
Elgin, IL
ENGINE
BLEW OUT 3 SPARK PLUGS ALREADY. NOW I NEED TO GET THE ENGINE FIXED AND SPEND 50% OF THE TRUCKS VALUE, BECAUSE FORD ROLLED OUT A FAULTY DESIGN AND WONT OWN UP. I'VE NEVER HEARD OF THIS BLOW OUT UNTIL I PURCHASED A FORD, AND I'VE OWNED SOO MANY OTHER CARS THAT NEVER EXPERIENCED THIS. THIS NEEDS TO BE RECALLED BY FORD!
NHTSA complaint #10653708 — an unverified report by a vehicle owner.
at 220,000 miles
Sparta, NJ
Crash
Fire
1 injured
ENGINE
SPARK PLUG EJECTED RESULTING IN FIRE. INJURED HAND PUTTING OUT SAID FIRE.
NHTSA complaint #10630447 — an unverified report by a vehicle owner.
at 102,000 miles
Torrington, CT
ENGINE
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 80 MPH, THE POWER STEERING ASSIST FAILED. THE CONTACT ALSO MENTIONED THAT THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AFTER MULTIPLE ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. THE VIN WAS UNAVAILABLE.
NHTSA complaint #10617301 — an unverified report by a vehicle owner.
at 240,000 miles
Houston, TX
Fire
ENGINE
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. THE CONTACT STATED THAT A FIRE ORIGINATED IN THE ENGINE COMPARTMENT, CAUSING THE VEHICLE TO BECOME ENGULFED IN FLAMES. THE FLAMES SPREAD RAPIDLY AND BURNED A PORTION OF THE CONTACT'S HOME. THE FIRE DEPARTMENT WAS CONTACTED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 240,000.
NHTSA complaint #10572742 — an unverified report by a vehicle owner.
at 164,121 miles
Belmond, IA
ENGINE
PULLING OUT OF A CONVENIENCE STORE WE HEARD A FUNNY SOUND AND MADE IT TO A PARKING LOT OF A RESTAURANT. HAD TO CALL THE INSURANCE COMPANY TO BE TOWED HOME. FOUND OUT IT WAS SPARK PLUG THAT HAD BLOWN OUT. IT STRIPPED THE THREADS AND IS NOW GOING TO COST A LOT TO GET IT FIXED, NOT TO MENTION THE TOWING.
NHTSA complaint #10572681 — an unverified report by a vehicle owner.
at 173,500 miles
Wichita, KS
ENGINE
VEHICLE RAN PERFECT DURING THE DAY. STOPPED FOR ABOUT 1 HOUR AROUND 9 PM, WENT TO RESTART THE ENGINE AROUND 10 PM, HEARD A LOUD "POP" FOLLOWED BY VERY LOUD FLAPPING NOISE FROM UNDER THE HOOD AS THE ENGINE CONTINUED TO RUN BUT VERY ROUGH (SOUNDED LIKE "BLAP, BLAP, BLAP......"). ON INVESTIGATION, FOUND #6 SPARK PLUG HAD BEEN BLOWN COMPLETELY OUT LAYING ON THE TOP OF THE MANIFOLD AND THE COIL BROKEN OFF ITS MOUNT. THE SPARK PLUG WAS NOT BROKEN, BUT THE THREADS LOOKED A LITTLE ROUNDED, BUT OTHERWISE OK. TRIED TO REINSTALL THE PLUG, BUT IT NEVER WOULD SEAT AND WHEN PULLED OUT VERTICALLY IT FELT LIKE THE THREADS WERE STRIPPED IN THE HEAD. HAD THE VEHICLE TOWED TO A LOCAL FORD DEALERSHIP IN WICHITA.
NHTSA complaint #10548172 — an unverified report by a vehicle owner.
at 212,000 miles
Fort Lauderdale, FL
ENGINE
THE ODOMETER WAS ROLLED BACK BY THE DEALER FOREMAN MOTORS INC. IN MELBOURNE, FL. THE VEHICLE WAS LISTED FOR SALE BY THEM FOR $3995. CARFAX.COM HAS THE LAST REPORTED MILEAGE AT 241,000 ON JUNE 15, 2012. THE ODOMETER WAS ROLLED BACK TO 212,000. NOW THE ENGINE IS GONE AFTER ONLY DRIVING IT FOR 200 MILES.
NHTSA complaint #10521236 — an unverified report by a vehicle owner.
at 202,333 miles
North Little Rock, AR
ENGINE
I BOUGHT THIS USED 1999 FORD EXPEDITION 5.4L AND NOTICED A KNOCKING FIRST TIME AND SAW THAT THE #3 SPARK PLUG HAD COME UNSCREWED FROM INSIDE, THEN AS I REPLACED IT THE #4 CAME UNSCREWED, RE SCREWED IT BACK IN AND NOW THE OBD II CODES CAME UP THE SPARK PLUG WAS NO LONGER GOOD, AS I HAVE WANTED TO CHANGE THE SPARK PLUGS ALL NEW I AM UNABLE TO SCREW BACK IN A NEW SPARK PLUG IN #4 SPARK PLUG HOLE. I DIDN'T KNOW THAT SPARK PLUGS COULD UNSCREW ON THEIR OWN TILL NOW. I BELIEVE FORD IF THEY KNEW ABOUT THIS PROBLEM IN THE FIRST PLACE THEY SHOULD REPAIR AT THEIR OWN COST FOR SOMETHING THEY KNEW WOULD HAPPEN.
NHTSA complaint #10519828 — an unverified report by a vehicle owner.
at 100,000 miles
Zephyrhills, FL
Fire
ENGINE
PARKED VEHICLE NOT RUNNING NO RECENT WORK DONE TRUCK JUST STARTED ON FIRE,UNDER THE HOOD AROUND THE BRAKE MASTER CYLINDER AREA.VEHICLE HAD THE FORD SAFETY RECALL FOR THE CRUISE CONTROL SWITCH.
NHTSA complaint #10514954 — an unverified report by a vehicle owner.
at 160,000 miles
Decatur, MS
ENGINE
CRANKED THE TRUCK TO DRIVE AND MOTOR BEGAN TO KNOCK AND WHITE SMOKE BEGAN TO POUR OUT. ENGINE LOCKED UP.
NHTSA complaint #10470374 — an unverified report by a vehicle owner.
at 126,000 miles
Coshocton, OH
Fire
ENGINE
TRUCK PARKED, NOT DROVE FOR THREE DAYS, ALARM WENT OFF AND TRUCK BURST INTO FLAMES IN MOTOR AREA, TRUCK TOTAL LOSS, FOUND OUT AFTER FIRE THEY HAD RECALL ON CRUISE CONTROL SWITCH, WOULD'VE BEEN NICE TO KNOW, SO I'M SURE SEVERAL PEOPLE UNAWARE.CAR COMPANY NEED TO REALIZE CARS IS HOW THEY MAKE THERE MONEY AND OUR CARS ARE THE WAY WE PAY THEM.
NHTSA complaint #10465375 — an unverified report by a vehicle owner.
at 123,000 miles
Cleveland, GA
ENGINE
WHILE DRIVING DOWN THE ROAD MAINTAIN STEADY SPEED ON LEVEL ROAD NUMBER 3 SPARKPLUG BLEW OUT BREAKING COIL AND DROPPING SPARKPLUG ON THE ROAD. ORIGINAL SPARKPLUGS HAD NEVER BEEN CHANGED.
NHTSA complaint #10464569 — an unverified report by a vehicle owner.
at 107,899 miles
Cedar Rapids, IA
ENGINE AND ENGINE COOLING
I JUST PURCHASED THIS EXPEDITION AND THE NUMBER 2 SPARK PLUG EJECTED FROM THE ENGINE DESTROYING THE COIL PACK AND STRIPPING THE THREADS. I HAVE READ ALOT ABOUT THIS AND FEEL THAT FORD SHOULD DO SOMETHING ON THIS ISSUE. SO MANY PEOPLE HAVE SPENT SO MUCH MONEY ON A DESIGN FAILURE THAT FORD DOES NOT WANT TO TAKE RESPONSIBILITY FOR. I HAVE OWNED NUMEROUS FORDS AND I AM VERY DISAPPOINTED IN THIS VEHICLE. SINCE I JUST GOT IT I HOPE THIS DON'T HAPPEN AGAIN. IT SHOULD BE RECALLED.
NHTSA complaint #10448328 — an unverified report by a vehicle owner.
at 134,500 miles
Shoreline, WA
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1999 FORD EXPEDITION. THE CONTACT STATED THAT THERE WAS AN ABNORMAL VIBRATION FROM THE MOTOR WHICH WAS STRIPPING THE SPARK PLUGS. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS OPERATING AS DESIGNED AND ALSO ADVISED THAT SHE PURCHASE A SPARK PLUG KIT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, DID NOT OFFER ANY ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 135,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 134,500.
NHTSA complaint #10434094 — an unverified report by a vehicle owner.