30 of the 267 complaints about the 2007 Ford Expedition are about the engine — 11% of everything reported for this model year. Half of the failures with a mileage on record happened before 91,500 miles.
30
Complaints
1
Crashes
1
Fires
1
Injuries
Filed with NHTSA, in their own words.
ENGINE
Unknown about what causes the issue but was Told it was manufacturers fault not mine. Insurance adjuster came out as well and said that my full coverage won’t cover anything at this point and told me as well to go contact the manufacturers to see what the option are available
NHTSA complaint #11457934 — an unverified report by a vehicle owner.
ENGINE
I HAVE TO REPLACE SPARK PLUGS EVERY WEEK. THE ENGINE EITHER KEEPS MAKING THE PLUGS FOUL OUT, OR IT BURNS THE TIP RIGHT OFF THE ENGINE. I'M STARTING TO SEE FROM THE COMPLAINTS THIS IS A COMMON ISSUE. I DON'T FEEL SAFE DRIVING THE VEHICLE WITH MY 6 KIDS BECAUSE OF HOW BAD IT KEEPS MISSING AND TRYING TO DIE. I CHANGE PLUGS THEN DRIVES WELL FOR ABOUT A WEEK.
NHTSA complaint #11395668 — an unverified report by a vehicle owner.
ENGINE
ENGINE STARTED MAKING NOISE. PULLED IT A PART AND FOUND THE COMMON 5.4 LITER PROBLEM. THE CAM LOBS WAS EATEN UP ROLLER HAD FROZEN UP AND EATEN CAM UP AND TAPET HAS WENT BAD ALSO. VECH WAS IN USE WHEN THIS STARTED.
NHTSA complaint #11389043 — an unverified report by a vehicle owner.
ENGINE
I HAVE A 2007 FORD EXPEDITION WILL START UP IN THE MORNING AND BE FINE UNTIL IT WARMS UP THEN IT WILL STALL OUT IN THE MIDDLE OF THE ROAD OR AT STOP SIGHS OR LIGHTS THESE MOTORS ARE KNOW TO HAVE PROBLEMS FROM FACTORY IT IS MY ONLY CAR I HAVE TO GO TO COLLEGE I NEED HELP RESOLVING THIS ISSUE
NHTSA complaint #11353270 — an unverified report by a vehicle owner.
ENGINE
CAR HAS ALWAYS BUCKED AND TRUCK AND TRIED TO CATCH UP TO IT SELF. NOW I HAVE A TICKING SOUND COMING FROM UNDER MY HOOD. TICKING STAYS THE SAME RUNNING LOW RPM OR AT A HIGHER RPM.
NHTSA complaint #11338692 — an unverified report by a vehicle owner.
ENGINE
DELEVOPED A TICKING NOISE TIMING CHAINS WERE REPLACED ALL ROCKERS AND LIFTERS ARE IN GOOD SHAPE THE TRUCK LOOSES POWER IT STARTS UP ROUGH AT ABOUT 1800 RPM YOU CAN HEAR THE TICKING LOUD PAST 2000 RPM THE TICKING GOES AWAY I HAVE RECENTLY BEEN NOTIFIED THAT THESE ENGINES HAVE CAM PHASER PROBLEMS IT RECENTLY DEVELOPED A P0022 CODE WHICH IS INT CAM POSITION TIMING OVER RET BANK 2 I HAVE REPLACED THE VVT SELONOIDS AND STILL HAS THE SAME PROBLEM VEHICLE LOST POWER ON HIGHWAY SPEED DROPPED FROM 70 AND WOULD NOT GO PAST 30 VERY UNSAFE INCEDENT ON THE INTERSTATE
NHTSA complaint #11279320 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED AND THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD AND TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A SENSOR NEXT TO THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHILE DRIVING 60 MPH, THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 219,935.
NHTSA complaint #11089724 — an unverified report by a vehicle owner.
ENGINE
THE ENGINE HAS CAUSED THE VEHICLE TO HAVE COMPLETE LOSS OF POWER. IT IS STALLING OUT AND WILL NOT DRIVE AT ALL.
NHTSA complaint #11073305 — an unverified report by a vehicle owner.
ENGINE
MY TRUCK WAS PURCHASED NEW AND I HAVE RECENTLY HAD MORE FUEL GAS WASTE QUICKLY IN THE PAST YEAR. I RECENTLY HAD THE FUEL LINE CHANGED IN JUNE 2017 BECAUSE A SPARK PLUG BURNT OUT AND CAUSED IT TO HAVE A LEAK THAT WAS DANGEROUSLY CLOSE TO THE GAS TANK. I HAVE 123K MILES ON IT AND THE CHECK ENGINE LINE COMES ON EVERY TIME AFTER HALF A GAS TANK IS DONE. I HAD THE TRUCK DRIVING AND IT SHUTS OFF ON ITS OWN. SOMETIMES IT WILL HAVE A STRONG SHAKING OF THE MOTOR OR NO WARNING AT ALL WHILE DRIVING ON THE ROAD. I'M VERY CONCERNED BECAUSE WE THOUGHT IT WAS THE CAMSHAFT WHICH IS WHAT THE ERROR CODE POPS UP AND THE SPARK PLUGS AND COILS HAVE BEEN REPLACED. EVERY THING ELSE HAS BEEN MAINTAINED BUT I'M STILL HAVE THE ENGINE AND FUEL PROBLEM. THE GAS GOES SO FAST AND THIS IS A V8 WHERE I USUALLY DRIVE A 6 MILE TO WORK NOW SAYS IT HAS BEEN A 40 MILE DRIVE. DON'T KNOW WHAT ELSE TO DO AND MAY TAKE IT BACK TO TRADE FOR ANOTHER VEHICLE BRAND. I HAD TO PARK THE TRUCK AFTER IT SHUT OFF ON ME AGAIN ON A SIDE STREET BEFORE GETTING ON THE HIGHWAY.
NHTSA complaint #11065695 — an unverified report by a vehicle owner.
ENGINE
I HAVE THE 5.4 ENGINE IN MY 2007 FORD EXPEDITION WITH ONLY 70,000 MILES WHICH I PURCHASED IN 2007. I AM NOW EXPERIENCING CAM SENSOR PROBLEMS, THROTTLE BODY PROBLEMS AND NEED MAJOR REPAIRS. I HAVE VISITED MANY SITES AND UNDERSTAND THAT FORD HAS BEEN SUED BECAUSE OF COMPLAINTS WITH THIS PARTICULAR ENGINE AND NOTHING CAME FROM THIS SUIT. THIS STARTED AROUND 2-3 WEEKS AGO, I HAD BEEN TRAVELING FOR 2-1/2 HOURS AND JUST PULLED OFF THE HIGHWAY TO ENTER INTO MY HOUSING PLAN, WHEN MY CAR LOST RPMS, BECAME VERY ROUGH, AND THEN STALLED. WHEN THE VEHICLE IS ON OPEN IT ROAD IT RIDES GREAT UNTIL YOU SLOW DOWN AND THE RPM FALLS, THEN IT STUMBLES AND STALLS. I HAD AT THE DEALERSHIP A COUPLE OF TIMES, BUT UNTIL CHECK ENGINE LIGHT CAME ON, I COULD NOT GET IT DIAGNOSED. OVER THE WEEKEND THE CHECK ENGINE LIGHT FINALLY LITE AND AS I STATED IT IS THE CAM POSITION SENORS AND STATES THAT THE SYSTEMS TOO RICH. I TALKED WITH A FORD REP TODAY AND THIS WILL BE ABOUT A $2000 REPAIR BILL, BUT UNTIL I CAN GET IT TO THEM AND THEY PLACE ON THEIR COMPUTER, THEY CANNOT GIVE ME THEIR FINAL ESTIMATE IF IT CAN BE REPAIRED OR I NEED A NEW ENGINE. I HAVE MANY MISGIVINGS ABOUT THIS SINCE ALL THAT I HAVE READ ON THE INTERNET ABOUT ALL THE PROBLEMS WITH THIS PARTICULAR ENGINE. FORD SHOULD BE HELD ACCOUNTABLE FOR A FAULTY ENGINE, AND BUYERS SHOULD BE MADE AWARE OF THIS PROBLEM ESPECIALLY WHEN THEY ARE BUYING A USED VEHICLE FROM A FORD DEALERSHIP WHO IS DEFINITELY AWARE OF THIS PROBLEM.
NHTSA complaint #11055238 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING, THE CONTACT STATED THAT THE OUTSIDE TEMPERATURE GAUGE DISPLAYED 106 DEGREES. THE CONTACT STATED THAT THE PASSENGER SIDE FLOOR BOARD WAS EXTREMELY HOT TO THE TOUCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THERE WAS NO HEAT SHIELD COVERING THE CATALYTIC CONVERTERS. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 122,700.
NHTSA complaint #11005151 — an unverified report by a vehicle owner.
ENGINE
2007 FORD EXPEDITION. CONSUMER WRITES IN REGARDS TO ENGINE LOCKING ISSUE. *LD THE CONSUMER STATED THE VEHICLE STOPPED ON A BUSY HIGHWAY WITHOUT ANY WARNING. THE VEHICLE HAD LESS THAN 125,000 MILES ON IT. THE CONSUMER STATED THAT DOOR HANDLES WERE PEELING AND CUTTING THE OWNER. THE HANDLES WERE REPAIRED UNDER WARRANTY BUT, THE FAILURE RECURRED. UPDATED 04/10/2017
NHTSA complaint #10970190 — an unverified report by a vehicle owner.
ENGINE
I HAVE HAD A LOT OF ISSUES WITH THE IGNITION COILS WITH THE VEHICLE, I HAVE HAD TO REPLACE ALL THE COILS 3 TIMES AND THE PROBLEM CONTINUES COMING BACK, DEALERSHIP RECOMMENDED REPLACING THE ENGINE WHICH WE DID AND IT DID NOT FIX THE ISSUE, HAVING TO TAKE IT TO THE SHOP FOR A 4TH TIME TO GET THEM ALL REPLACED. POWER FRONT SEAT HAVE HAD ISSUES AS WELL, REPAIRED THE DRIVER SIDE POWER SEAT AND NOW NEED TO REPLACE THE PASSENGER FRONT SETA, CANNOT BE REPAIRED, BOTH FRONT SEATS HAVE BEEN AN ISSUE.
NHTSA complaint #10789536 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A STRONG FUEL ODOR COMING FROM THE FRONT PASSENGER SIDE. WHILE DRIVING THE VEHICLE, THE CONTACT NOTICED THE SMELL OF FUEL IN THE VEHICLE AND THE FUEL MILES PER GALLON DROPPED. AFTER FURTHER INSPECTION OF THE ENGINE, THE CONTACT NOTICED THAT FUEL WAS LEAKING FROM THE FUEL RAIL ON THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 97,500. ..UPDATED 02/01/16 *BF
NHTSA complaint #10788671 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, AN ABNORMAL NOISE WAS HEARD FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CAM PHASER FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.
NHTSA complaint #10779682 — an unverified report by a vehicle owner.
ENGINE
THE FIRST OCCURRENCE WAS THE TRANSMISSION SLIPPING ON ACCELERATION AND STOPPING OR GOING UP HILL. ITS BEEN TO OUR FORD DEALER WHERE WE PURCHASED IT AND AT FIRST THEY FELT IT AND SAID THEY FIXED IT BUT NOW EVERYTIME I TAKE IT IN FOR THAT OR THE AC BLOWER GOING OFF AND ON THEY SAY THEY DON'T FEEL OR SEE ANYTHING IT GOTTEN RIDICULOUS. IN THE FREEWAY I-10 ME AND MY SON WERE TRYING TO ACCELERATE ON AND ALMOST GOT HIT BY A SEMI TRUCK THE VEHICLE WOULD NOT GO FAST ENOUGH. I WONT BOTHER WITH THE DEALERSHIP HERE IN TOWN THEY DON'T CARE. IT HAS HAPPENED MANY TIMES AND NOW THE AIR BAG LIGHT GOES OFF AND ON IN TEMPERATURE CHANGE IT SEEMS LIKE. OUR DEALER FIXED THE DOOR HANDLE BUT NOW ANY RAIN THE INSIDE OF OUR DOOR FILLS WITH WATER AND THEY SAY ITS NOT THERE FAULT AND WONT FIX THAT EITHER. VERY DISAPPOINTED WITH FORD. SPOKE TO THEM ABOUT THE AIR BAG AND THEY ALSO SAY THEY WONT FIX. WE HAVE HAD NOTHING BUT PROBLEMS WITH THIS 40000 SUV VERY DANGEROUS TO DRIVE AND ITS SUPPOSE TO BE A FAMILY VEHICLE....RIGHT WE GET NO UPDATE OR RECALLS INFO AND OUR DEALERSHIP IS THE WORST I'VE EVER DEALT WITH
NHTSA complaint #10750218 — an unverified report by a vehicle owner.
ENGINE
2007 FORD EXPEDITION. BEGAN TO SPIT AND SPUTTER GOING 45MPH. ENGINE LIGHT CAME ON. TOOK TO AUTO SHOP FOR REPAIR. COST WAS $1,100 TO REPLACE 8 SPARK PLUGS AND WIRES. FORD USED A DEFECTIVE SPARK PLUG IN THIS VEHICLE. THE PLUG BREAKS OFF IN THE ENGINE WHEN REMOVING THEM. FORD KNEW OF THE ISSUE AND DID NOTHING ABOUT IT. THIS ISSUE WITH THESE PLUGS BEGAN IN EARLY 2000'S. FORD SHOULD HAVE RECALLED THESE PLUGS LONG AGO. THERE ARE MANY CLASS ACTION LAWSUITS ONGOING RELATED DIRECTLY TO THE FAULTY SPARK PLUG. IF I HAD KNOW ABOUT THE PLUGS BEFORE I BOUGHT THE TRUCK, I WOULD HAVE HAD FORD REPLACE THEM BEFORE I EVEN DROVE IT.
NHTSA complaint #10683769 — an unverified report by a vehicle owner.
ENGINE
MILLIONS OF.COMPLAINTS ON. INTERNET ABOUT THIS VEHICLE AND ITS BACKFIRING ENGINE AND CONSTANTLY REPLACING SPARK PLUGS. CR THROTTLES.ALOT NO MATTER HOW MANY TIMES FIXED. PULLS NO MATTER WHAT PROBLEM YOU FIX THE NEXT ONE EMERGE. TYPICAL VEHICLE PROBLEMS FOR THESES OWNERS. SO MUCH MONEY.
NHTSA complaint #10620993 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA complaint #10538075 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
WHILE DRIVING ON THE INTERSTATE OR FWY AT ABOUT 55-60 MPH - I START TO INCREASE IN SPEED, WHILE GOING WITH THE FLOW OF TRAFFIC MY EXPEDITION EDDIE BAUER MODEL SPURTS/HESITATES/LOSES POWER "BUT NEVER CUTS OFF" EVERY TIME BEFORE THE SPEED INCREASES. WE TOOK IT TO THE FORD DEALER SEVERAL TIMES AN THEY ARE UNABLE TO DETERMINE WHAT IS WRONG WITH THE VEHICLE. THE FORD DEALER TOLD US THEY CAN'T DO NOT ABOUT IT UNTIL THE ENGINE LIGHT COMES ON. WE SUGGESTED TO THE FORD DEALER THAT IT MAYBE THE FUEL FILTER OR O2 SENSOR BUT THEY TOLD US THIS MODEL VEHICLE DOES NOT HAVE A FUEL FILTER AND OUR O2 SENSORS ARE GOOD. MY ISSUE IS WHY SHOULD I HAVE TO WAIT TILL THE VEHICLE BREAKS DOWN WHEN IT DOES THIS ALL THE TIME.
NHTSA complaint #10522630 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE SPARK PLUGS DETACHED FROM THE VEHICLE AND HAD TO BE REMOVED BY THE DEALER USING A SPECIAL TOOL. THE CONTACT STATED THAT THE SPARK PLUGS HAD BECOME STUCK. THE FAILURE AND THE CURRENT MILEAGE WAS 130,000.
NHTSA complaint #10462510 — an unverified report by a vehicle owner.
ENGINE
I WENT TO PICK MY SON UP FROM DRIVERS ED AND WE WERE LEAVING THE PARKING LOT AND THE VEHICLE DIED. I WAITED A LITTLE AND THEN RESTARTED IT AND IT STARTED BUT IT WAS ROUGH. I THEN CONTINUED TO DRIVE MY WAY BACK HOME AND IT WAS DRIVING ROUGH AND NO LIGHTS CAME ON INDICATING I HAD A PROBLEM. I WAS DRIVING DOWN THE ROAD AND IT DIED AGAIN SO I HAD TO JUST LET IT COAST TO GET OFF THE STREET. LUCKILY I WAS ABLE TO COAST INTO DELON AND SON'S SECOND DRIVEWAY (REPAIR SHOP). I WAITED FOR THEM TO COME HELP AND WHEN THE REPAIR MAN CAME OUT HE WAS ABLE TO START IT AND TOLD ME HE WAS GOING TO RUN SOME TEST ON IT TO SEE WHAT WOULD HAVE CAUSED IT. AFTER 2HRS HE CAME AND SAID THAT IT INDICATED IT WAS THE FUEL PUMP, BUT THAT IT SHOWED IT FIXED ITSELF SO HE WANTED TO TEST DRIVE IT BEFORE I WOULD GO HOME......WELL NOT EVEN TWO MINUTES AFTER HE LEFT HIS COWORKER CAME IN AND SAID THAT HE JUST BROKE DOWN IN MY VEHICLE. SO HE BUMPED UNDER THE TANK AND IT STARTED BACK UP. SO THIS TO HIM INDICATED THAT IT WAS FOR SURE THE FUEL PUMP. I LEFT IT FOR THEM TO FIX IT AND WHEN IT WAS DONE HE CALLED ME AND TOLD ME THAT.....I WAS VERY LUCKY THAT IT DIDN'T EXPLODE BECAUSE THE WIRES WERE MELTED ON THE FUEL PUMP AND HE HIMSELF SAID THAT HE WAS LUCKY SINCE HE TEST DROVE IT AS WELL. I DOUBT FORD WOULD PAY FOR THIS FUEL PUMP FAILURE IT SEEMS TO BE A COMMON PROBLEM WHEN YOU LOOK ON-LINE. MY TOTAL BILL FOR THIS WAS $790.00 OUCH :( CONSIDERING WE ARE IN THE PROCESS OF ADOPTING A CHILD.
NHTSA complaint #10462179 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
DEALER WANTS $800 TO CHANGE SPARK PLUGS AS THEY WILL BREAK OFF IN ENGINE. BECAUSE A DIS SIMILAR METAL WAS USED. EXHAUST MANIFOLD BOLTS BREAK AND CAUSE LOUD EXHAUST LEAK AT THE REAR OF THE EXHAUST MANIFOLD DEALER WANTS $850 TO FIX.
NHTSA complaint #10452155 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
THE VEHICLE BEGAN TO IDLE REAL ROUGH TO THE POINT OF BOUNCING IN AN UNCONTROLLED MANNER. A KNOCKING NOISE STARTED COMING FROM THE ENGINE. WHEN YOU TRIED TO INCREASE SPEED TWO CYLINDERS MISSED. WHEN THE VEHICLE WAS MANUFACTURED INCORRECTLY, IT CAUSED THE OIL TO BE DISTRIBUTED UNEVENLY THROUGH THE ENGINE AND THE ENGINE TO HEAT UNEVENLY. THIS STARVATION OF OIL OVER TIME TO THE ENGINE ALLOWED FOR METAL TO SHRED AND CONTAMINATE THE ENGINE AND THE ENGINE HAS TO BE REPLACED IN A 5 YEAR OLD CAR. IF THE ENGINE IS NOT REPLACED THE CONDITIONS WOULD CONTINUE TO INTENSIFY AND THE OUTCOME IS UNKNOWN. AFTER INVESTIGATION INTO THE PROBLEM I LEARNED THAT FORD HAD SENT OUT A TECHNICAL ADVISORY BULLETIN TO HELP SERVICE DEPARTMENTS IDENTIFY THE PROBLEM SO OBVIOUSLY THIS IS NOT A ONE TIME BASED FAILURE.
NHTSA complaint #10449448 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
THE 5.4L ENGINE HAS A TAPPING NOISE COMING FROM THE TOP HALF OF THE MOTOR ON THE PASSENGER SIDE. IT OCCURS WHEN THE ENGINE IS IDLING AT A STAND STILL. IT HAPPENS RANDOMLY. HAVE BEEN SPEAKING WITH FORD WARRANTY AND DEALERS TRYING TO GET FIXED AND BECAUSE IT IS INTERMITTENT THEY DO NOT WANT TO WORK ON. WE HAVE TAKEN TO 2 DEALERS A TOTAL OF 3 TIMES AND SPOKEN WITH FORD WARRANTY AND THEY REFUSE TO PAY TO HAVE THE MOTOR OPENED UP AND LOOKED AT.
NHTSA complaint #10379730 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
I PURCHASED A 2007 FORD EXPEDITION WITH A 5.4 TRITON ENGINE IN FEBRUARY 2008 THAT WAS STILL UNDER WARRANTY. THE CAR STARTED HERE LATELY TO MISFIRE AND JUMP AND STALL. I PURCHASED SPARK PLUGS AS I DO WITH ALL MY VEHICLES. UPON REMOVAL OF THE ORIGINAL PLUGS THEY BREAK OFF IN THE MOTOR OR THE HEAD WHICH THEN COST LOTS MORE MONEY TO REPLACE. UPON SPEAKING TO AND RESEARCHING ON THE INTERNET THIS PLUG DESIGN IS A FLAW WITH ALL THE ENGINES THAT FORD HAS DESIGNED. EVERY PERSON WHO HAS HAD TO REPLACE THESE PLUGS HAS ENCOUNTERED THIS AWFUL AND COSTLY FLAW WHICH FORD SHOULD BE ACCOUNTABLE FOR. AS I WILL AS WELL AS MANY CONTINUE TO PAY FOR THE POOR WORKMANSHIP AND DESIGN THAT FORD SHOULD BE LIABLE FOR. IN THESE DAY AND TIMES AND WITH THE WIDE VARIETIES OF MASS COMMUNICATIONS, I WILL NEVER AND ENCOURAGE MY FRIENDS TO NEVER BUY A FORD VEHICLE AGAIN. I HAVE FOUR KIDS AND THIS IS A COST THAT WE CANNOT STAND FOR. I WILL GO TO THE HOUSTON TEXAS MEDIA WITH THIS AS WELL. AS I AM SURE IN THE HOUSTON AREA MANY MANY MANY CONSUMERS HAVE THESE SAME ISSUES.
NHTSA complaint #10347923 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING 40 MPH, THE CONTACT NOTICED FLAMES COMING FROM THE HOOD OF THE VEHICLE. HE PULLED THE VEHICLE OVER AND IT STALLED AND LOST COMPLETE POWER. THE CONTACT THEN PROCEEDED TO REMOVE ALL THE PASSENGERS, INCLUDING TWO CHILDREN FROM THE REAR SEAT. WITHIN FIVE MINUTES, THE DRIVER'S SIDE WAS COMPLETELY ENGULFED IN FLAMES. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A COLLISION CENTER. AFTER SPEAKING WITH THE MAINTENANCE MANAGER, FORD STATED THAT SINCE THE FIRE ORIGINATED IN THE REAR OF THE VEHICLE, THEY WOULD NOT TAKE RESPONSIBILITY FOR THE FIRE. THE FIRE REPORT CLEARLY STATED THAT THE FLAMES ORIGINATED FROM THE HOOD OF THE VEHICLE. THE VEHICLE IS CURRENTLY AT THE COLLISION CENTER. THE CURRENT AND FAILURE MILEAGES WERE 12,000.
NHTSA complaint #10232697 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DECELERATING AT 5 MPH, THE ENGINE REVVED WHEN THE BRAKE PEDAL WAS DEPRESSED. AS A RESULT, THE CONTACT REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 1,000.
NHTSA complaint #10204652 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE SHIFTS ROUGHLY AND MAKES A LOUD SOUND WHEN SHIFTING FROM FIRST TO SECOND GEAR OR ACCELERATING FROM A STOP AT 15 MPH. THE VEHICLE HAS BEEN TO THE DEALER NUMEROUS TIMES. INITIALLY, THE FAILURE WAS DIAGNOSED AS THE THROTTLE CABLE. THE SECOND TIME, THE DEALER STATED THAT NOTHING WAS WRONG WITH THE VEHICLE. THE THIRD TIME, THE VEHICLE MADE A POPPING NOISE AND THE REAR AXLES WERE REPLACED. THE FOURTH TIME, THE DEALER STATED THAT THE CAUSE OF FAILURE WAS THE TRANSMISSION. THEY DEALER WOULD TEMPORARILY REPAIR THE VEHICLE, BUT THE FAILURE WOULD RECUR DAYS LATER. THE FAILURE HAS STILL NOT BEEN CORRECTED. THE FAILURE MILEAGE WAS 2,800 AND CURRENT MILEAGE WAS 14,300.
NHTSA complaint #10201122 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
I HAD PURCHASED A 2007 FORD EXPEDITION EL AND HAVE HAD MULTIPLE PROBLEMS WITH BEING ABLE TO GO IN REVERSE WHILE FACING DOWN ON ANY KIND OF GRADE. I ALSO HAVE PROBLEMS WITH THE VEHICLE ACCELARATION WHILE COMING FROM A STOP INTO TRAFFICE. MYSELF ALONG WITH MY TWO SMALL CHILDREN WILL NO LONGER DRIVE THE VEHICLE. WE WERE VERY CLOSE TO BEING HIT TWICE BECAUSE OF THE DEFECT IN THIS FORD VEHICLE. I HAD SUBMITTED FOR LEMON LAW AND SO FAR I HAVE NOT RECEIVED MY ANSWER FROM ARBITRATION. I CAN TELL YOU THAT FORD IS COVERING THIS UP BECAUSE I KNOW OF SERVERAL PERSONS AND BUSINESSES THAT HAVE THE SAME ISSUES AND FORD STATED THAT THERE ARE NO ISSUES. WHILE ON THE PHONE WITH THE FORD REPRESENTATIVE IN THE ARBITRATION THEY ONLY SHOWED A FEW VISITS TO THE DEALERSHIP AND TOLD ME THAT THE ONES THAT I RECEIVED FROM THE DEALERSHIP WERE FALSE. WHAT A CROCK. I WILL MAKE A COMPLAINT EVERYWHERE THAT I CAN BEFORE THIS VEHICLE KILLS SOMEONE. AT THIS POINT I WENT AND BOUGHT ANOTHER VEHICLE AND AM STUCK PAYING FOR TWO NOW THAT THE ONE JUST SITS AND WE REFUSE TO DRIVE IT. MY CHILDREN ARE AFRAID TO EVEN DRIVE IN IT BECAUSE IT ACTUALLY GOES IN FORWARD WHILE IN REVERSE ALSO.
NHTSA complaint #10194764 — an unverified report by a vehicle owner.