Ford Explorer Sport Trac body problems

STRUCTURE:BODY

THE FAN BLADES HAD MANY BIG CRACKS IN THE PLASTIC BLADES,THE DRIVER DOOR THE BODY IS CRACKED BY TOP OF DOOR HING BACK DOOR IS THE SAME, THE PAINT IS PEALING AND STARTING TO RUST ON TOP.THE PLASTIC THERMOSTAT CRACKED.

NHTSA complaint #11377168 — an unverified report by a vehicle owner.

STRUCTURE:BODY

WHEN TEMP IS BELOW FREEZING DRIVERS DOOR WILL NOT CLOSE

NHTSA complaint #11300314 — an unverified report by a vehicle owner.

STRUCTURE:BODY

THE BODY OF MY 2004 FORD EXPLORER SPORT TRAC XLT HAS RIVETS ON THE TOP OF THE ROOF THAT HOLD WATER. INSTEAD OF BEING A FLAT SURFACE WHERE RAIN CAN NATURALLY FALL OFF THE TOP OF THE ROOF IT SITS IN THESE RIVETS AND ACCUMULATES RUST. THIS LEADS TO A LOT MORE PROBLEMS.

NHTSA complaint #11299314 — an unverified report by a vehicle owner.

STRUCTURE:BODY

THE FRONT, DRIVER'S SIDE, TIRE CAME APART AND CAUSED CONSIDERABLE DAMAGE TO MY VEHICLE'S BODY AND POSSIBLY OTHER DAMAGES NOT SEEN. I NEED TO TAKE THE VEHICLE TO A MECHANIC FOR AN INSPECTION TO SEE IF THERE ARE OTHER DAMAGES. THE TIRE IS A GOOD YEAR EAGLE RS-A. THE DOT # IS 4B08 DLWR 3701. TIRE SIZE P235/70R16. I WAS DRIVING ON INTERSTATE I-75 WHEN THE TIRE CAME APART. IT WAS TERRIBLY SCARY. I DID NOT REALIZE WHAT HAD HAPPENED AND THOUGHT THE VEHICLE WAS FALLING APART. I PULLED ONTO THE EMERGENCY LANE AND REALIZED THE TIRE HAD COME APART. THE RUBBER COMING OFF THE TIRE CAUSED QUITE A BIT OF BODY DAMAGE. THE VISIBLE DAMAGES INCLUDE DAMAGES TO THE DRIVER'S SIDE HEAD LIGHT, RUBBER RIPPED OUT THE DRIVER'S SIDE BLINKER, MOLDING UNDER THE DRIVER'S DOOR WAS RIPPED OUT, PAINT DAMAGE, TIRE WELL DAMAGE AND LOOSENING OF OTHER MOLDING ON DRIVER'S SIDE. A MECHANIC WILL HAVE TO INSPECT FOR UNSEEN DAMAGES.

NHTSA complaint #11162956 — an unverified report by a vehicle owner.

STRUCTURE:BODY

THE CAB TO FRAME MOUNTING BOLT BUSHINGS, AND STEERING STABILIZER BUSHINGS ARE HAVE AND ARE CRUMBLING. ALL NEED TO BE REPLACED. I FEEL FORD IS AWARE OF THIS PROBLEM AND SHOULD HAVE TO FIX IT. I JUST INHERITED THIS TRUCK AND JUST FOUND OUT ABOUT THIS. THANK YOU.

NHTSA complaint #11033833 — an unverified report by a vehicle owner.

STRUCTURE:BODY

DISCOVERED UNDERNEATH THE BODY WHERE THE BODY AND FRAME MEET FOR THE BODY MOUNT BUSHINGS, THEY HAVE NEARLY DISINTEGRATED ON ALL FOUR BUSHINGS LOCATED UNDER THE DRIVER AND PASSENGER SEATS. THESE BUSHINGS WERE MADE OF SOME INFERIOR FOAM MATERIAL WHEREAS THE REAR BUSHINGS ARE RUBBER AND STILL IN VERY GOOD CONDITION. THE REPAIR FOR THIS DEFECT WILL COST AROUND $600 TO $1,300 AND IF NOT DONE WILL RESULT IN THE CAB FALLING DIRECTLY ONTO THE FRAME THUS CREATING NUMEROUS SAFETY PROBLEMS INCLUDING STRUCTURAL INTEGRITY FAILURE OF THE TRUCK. THIS PROBLEM AFFECTS ALL SPORT TRACS MADE FROM 2001 TO 2005. THE INCLUDED PICS BEGIN WITH THE DRIVER SIDE (DRIVER SEAT) FRONT BUSHING, DRIVER SIDE (REAR SEAT) BUSHING, PASSENGER SIDE (FRONT SEAT) BUSHING, PASSENGER SIDE (REAR SEAT) BUSHING AND FINALLY THE PASSENGER SIDE REAR AND DRIVER SIDE REAR BUSHINGS (BOTH IN EXCELLENT SHAPE AND MADE OF ENTIRELY DIFFERENT MATERIAL) DISCLAIMER: THIS TRUCK HAS NEVER BEEN EXPOSED TO ANY SALT WATER (BEACH) ENVIRONMENT NOR WINTER WEATHER ENVIRONMENT (WHERE SALT WAS USED), OR MUD RIDING OF ANY TIME NOR HAS BEEN DRIVEN THROUGH FLOODED AREAS WHICH COULD LEAD TO THE CONDITION OF THE BUSHINGS. VEHICLE ODOMETER READING IS 125,496.

NHTSA complaint #10920114 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I HAVE HAD 3 TIRE BLOW OUTS IN THE SHORT TIME I HAVE HAD THIS TRUCK DUE TO THE TIRES RUBBING ON A PART OF THE STEERING WHEN MAKING TURNS. ITS RUBS OFF THE MATERIAL OF THE TIRE.....ALSO THE REAR PASSANGER DOOR CAN NOT BE OPENED FROM THE INSIDE AND BEARLY OPENS FROM THE OUTSIDE. I HAVE A YOUNG CHILD MAKING THIS EXTREMELY DANGEROUS. YOUR SITE WANTS ME TO ENTER A DATE... I CAN'T RECALL ALL THREE DATES

NHTSA complaint #10897684 — an unverified report by a vehicle owner.

STRUCTURE:BODY

PEELING PAINT ON MY FORD EXPLORER SPORT TRAC. IT IS PEELING MOSTLY ON THE TOP AND HOOD OF THE TRUCK. I TALKED WITH SOMEONE ON THE FORD WEBSITE BUT THEY SAID THERE ARE NO RECALLS. I TALKED WITH A PAINT AND BODY SHOP AND THEY SAID IT WAS A BAD PAINT JOB. THE ROOF ON MY VEHICLE IS NOW RUSTING AND THE BODY SHOP GUY SAID IT WILL COST OVER 2000$ TO GET IT REPAIRED. THIS VEHICLE WAS PURCHASED IN OKLAHOMA. WE ALSO BOUGHT A COVER FOR THE BACK WHICH HAD A FRAME AROUND THE BED OF THE PICKUP AND WAS HELD TOGETHER BY SOME PLASTIC CLIPS. THE CLIPS BROKE BEFORE IT WAS EVEN A YEAR OLD AND THE DEALER SAID THERE WAS NOTHING THEY COULD DO AND WE WOULD HAVE TO BUY A WHOLE NEW COVER WHICH COST OVER 300$.

NHTSA complaint #10884355 — an unverified report by a vehicle owner.

STRUCTURE:BODY

TL* THE CONTACT OWNS A 2004 FORD EXPLORER SPORT TRAC. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE FRAME WAS RUSTED AND PARTS WERE FRACTURED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME AND THE FRONT AND REAR MOTOR MOUNTS WERE RUSTED AND NEEDED BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED WITH THE FRONT END MOTOR MOUNT. WHILE DRIVING APPROXIMATELY 40 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVER AND PASSENGER SIDE PINION, BARONS, AND SEALS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 78,000. MA 10/23/15

NHTSA complaint #10745048 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I HAVE OWNED THIS TRUCK SINCE 2002. LEFT REAR PASSENGER DOOR HANDLE BROKE (ONE DAY IT WORKED, NEXT DAY IT WAS FLOPPING AND OBVIOUSLY DISCONNECTED). CAN'T OPEN IT FROM THE OUTSIDE OR INSIDE. FRONT DRIVER'S SIDE DOOR HANDLE ALSO FEELING FLOPPY AND LOOSE. CHILD "SAFETY" LATCHES ON BOTH BACK PASSENGER DOORS HAVE NEVER WORKED PROPERLY SO ANYONE SITTING IN THE BACK SEAT HAS TO BE LET OUT BY SOMEONE ON THE OUTSIDE AS THE INSIDE DOOR HANDLE WON'T WORK. ON THE INTERNET, YOU WILL SEE THAT DOOR FAILURES ON THIS MAKE AND MODEL ARE RAMPANT. THIS IS EXTREMELY DANGEROUS. IN AN ACCIDENT, THE DRIVER AND/OR PASSENGERS COULD NOT GET OUT OF THE TRUCK. FIXING THE DOORS IS REALLY DIFFICULT AS W/O BEING ABLE TO OPEN THE DOOR, YOU HAVE TO DISMANTLE THE INTERIOR OF THE TRUCK IN ORDER TO GET TO THE I/S DOOR PANEL. THIS IS NOT A REPAIR A TYPICAL OWNER COULD DO FOR THEMSELVES, EVEN MY MECHANIC DOES NOT WANT TO DO IT. WITH THE LARGE NUMBER OF TRUCK OWNERS COMPLAINING OF THIS DOOR FAILURE PROBLEM ON THE NET AND THE EXTREMELY DANGEROUS POSITION IT PUTS THE DRIVER AND PASSENGERS IN, FORD SHOULD HAVE A RECALL ISSUED. OBVIOUSLY THESE DOOR LATCHES ARE VERY SUSCEPTIBLE TO FAILURE AND CONTINUED TO BE INSTALLED BY FORD FOR YEARS.

NHTSA complaint #10661269 — an unverified report by a vehicle owner.

STRUCTURE:BODY

WHILE DRIVING DOWN THE ROAD I HEARD A POPPING FOLLOWED BY A LOT OF METAL NOISE. THE TRUCK SEAMED SHIFT AROUND. UPON LOOKING UNDER THE TRUCK THE BODY MOUNT UNDER THE PASSENGER SEAT WAS GONE ON BOTH SIDES OF THE FRAME. THE CAB IS NOW SITTING ON THE FRAME AND SOME PARTS AROUND THE PASSENGER FRONT MOUNT ARE CRACKED. CALLED FORD, NOT UNDER WARRANTY OR RECALL. (GOOD ANSWER?) I THINK NOT....TOOK TO LOCAL FORD DEALER IN RI. TOLD HIM WHAT THE PROBLEM WAS AND THAT MY WIFE WANTED TO USE THE SPORT TRAC TO PICK UP OUR 1 YEAR OLD GRANDSON. HE TOLD ME THE TRUCK WAS UNSAFE AND NOT TO DRIVE IT ... SOUND LIKE A MAINTENANCE ISSUE? SOUNDS MORE LIKE A PRODUCT FAILURE. FORD KNOWS. NHTSA KNOWS. WE WHO OWN KNOW. THIS IS NOT ENVIRONMENTAL DUE TO THE FACT THAT I SEE IT IS ALSO HAPPENING IN TEXAS TOO. SO I WILL CALL FORD AGAIN AND DEMAND THE FIX AS MANY TIMES AS IT TAKES TIL MY TRUCK IS FIXED. THE NHTSA NEEDS TO START CALLING THIS WHAT IT IS "FORD"S BAD PRODUCT DECISION AND NOT THE BURDEN OF THE CONSUMER.

NHTSA complaint #10643945 — an unverified report by a vehicle owner.

STRUCTURE:BODY

REAR PASSENGER DOOR CAN'T OPEN FROM INSIDE OR OUTSIDE OF VEHICLE. DIFFICULTY IN REMOVING ANY TYPE OF PASSENGER IN AN EMERGENCY. NOTHING IS LISTED IN OPERATIONS MANUAL. CHILD SAFETY LOCK WAS PRESSED AT TIME SO CHILD COULD NOT OPEN DOOR. SINCE THEN TRIED TO UNLOCK CHILD SAFETY FROM INSIDE AND OUTSIDE AND IT IS IMPOSSIBLE. THERE IS NO WAY TO DO THIS. INVOLVES CHILD SAFETY LOCK WHICH IS BROKEN INSIDE OF DOOR. TRIED TO GET FIXED RECENTLY, BUT SEEMS IMPOSSIBLE WITHOUT DAMAGING DOOR. STILL CANNOT OPEN. HAVE HEARD OTHERS WHO HAVE HAD THIS PROBLEM. HAVE NOT SEEN OR HEARD ANY RECALLS ON THIS ISSUE BUT IT SHOULD BE A FORD ISSUE NOT THE CONSUMER. THIS IS TOO DANGEROUS FOR ANYONE DRIVING IN THAT SEAT SHOULD AN EMERGENCY OCCUR AND THEY NEED TO GET OUT.

NHTSA complaint #10622661 — an unverified report by a vehicle owner.

STRUCTURE:BODY

THE BODY MOUNT INSULATORS DETERIORATED AND THE BODY COULD COME LOOSE FROM THE CHASSIS. FORD WANTS OVER 3000 DOLLARS FOR THIS REPAIR WHICH IS AN OBVIOUS MATERIAL FLAW.

NHTSA complaint #10620689 — an unverified report by a vehicle owner.

STRUCTURE:BODY

WHEN I HAD MY VEHICLE INSPECTED I WAS INFORMED THE BODY MOUNTS WERE ALMOST ALL RUSTED OUT AND THERE IS A DANGER THE BODY COULD COME LOOSE. ITS EASY TO PICTURE WHAT COULD HAPPEN IT THIS OCCURRED IN A 60 MPH CURVE ON INTERSTATE. MECHANICS TELL THIS IS UNHEARD OF IN ANY OTHER VEHICLES EXCEPT FORD EXPLORER SPORT TRACS MODEL YEARS 2001 THRU 2005. IF THIS ISNT A HAZARD I DONT KNOW WHAT IS. ITS EVIDENT THIS PARTS ARE JUNK AND FORD DID NOTHING TO CORRECT IT. STARTING IN 2006 THIS PROBLEM NO LONGER EXISTED.

NHTSA complaint #10606675 — an unverified report by a vehicle owner.

STRUCTURE:BODY

VEHICLE BODY MOUNTS HAVE DRIED OUT AND CRUMBLES WHEN TOUCHED. THIS DETERIORATION CAUSES THE BODY TO RIDE ON TOP OF THE FRAME WHICH COULD EVENTUALLY RESULT IN OTHER VEHICLE DAMAGE AND POSSIBLE SAFETY ISSUES. APPEARS THE PRODUCT WAS MADE OF SUBSTANDARD MATERIAL AND HAS BEEN WORN OUT FOR QUITE A FEW YEARS.

NHTSA complaint #10594100 — an unverified report by a vehicle owner.

STRUCTURE:BODY

THE DOORS DON'T OPEN GOOD AND THE DOOR HANDLES BREAK. WE HAVE HAD FIXED TWICE AND THE PREVIOUS OWNER HAD FIXED ALSO!

NHTSA complaint #10588724 — an unverified report by a vehicle owner.

STRUCTURE:BODY

BOTH REAR DOORS FAILED TO OPEN FROM THE INSIDE AFTER BEING USED ONLY A FEW DOZEN TIMES EACH. THE CAUSE WAS THE INTERIOR DOOR HANDLE (PLASTIC) BROKE INSIDE THE DOOR. THIS IS A BIG SAFETY ISSUE BECAUSE THIS MEANS THAT REAR SEAT PASSENGERS CANNOT EGRESS THE VEHICLE WITHOUT IT BEING OPENED BY SOMEONE ON THE OUTSIDE. THIS IS EVIDENTLY A COMMON PROBLEM WITH MANY FORD VEHICLES USING THIS DOOR HANDLE - THERE SHOULD HAVE BEEN A RECALL ISSUED YEARS AGO.

NHTSA complaint #10577786 — an unverified report by a vehicle owner.

STRUCTURE:BODY

DRIVER SIDE FRONT EXTERIOR DOOR HANDLE HAD BEEN BECOMING MORE DIFFICULT TO OPEN. ON THE LAST PULL TO GET IN, THE DOOR HANDLE BROKE OFF. IF THERE WAS AN EMERGENCY, THERE WOULD BE NO WAY TO OPEN THE DOOR TO REMOVE THE DRIVER.

NHTSA complaint #10559599 — an unverified report by a vehicle owner.

STRUCTURE:BODY

WHILE DRIVING AT 45MPH NOTICED TOO MUCH BODY ROLL AND BOUNCING. INSTALLED NEW SHOCKS AND SWAY BARS AND HAD IT ALIGNED AND IT STILL HAD TOO MUCH BODY ROLL AND BOUNCING. HAD IT UP ON A LIFT AN NOTICED THE BODY BUSHING WERE ALL DETERIORATED AND FALLING APART. GOOGLED THIS ITEM AND FOUND MANY SPORT TRAC OWNERS HAVING THE SAME PROBLEM. IT SEEMS FORD PURCHASED INFERIOR BODY BUSHINGS FROM A VENDOR AND HAS NEVER CORRECTED THIS ISSUE. THE VEHICLE FEELS VERY UNSAFE TO DRIVE! IN ORDER TO CHANGE THESE OUT YOU HAVE TO REMOVE THE INTERIOR OF THE VEHICLE 1ST. THIS IS A VERY EXPENSIVE REPAIR AND IF LEFT UNDONE THE VEHICLE IS UNSAFE TO DRIVE. I HAVE NEVER HEARD OF THIS BEING A MAINTENANCE ITEM ON ANY OTHER VEHICLE.

NHTSA complaint #10544002 — an unverified report by a vehicle owner.