2003 Ford Explorer transmission problems

POWER TRAIN

2003 FORD EXPLORER. CONSUMER WRITES IN REGARD TO DEFECTIVE THROTTLE IN MODEL VEHICLE. *AS

NHTSA complaint #11180771 — an unverified report by a vehicle owner.

POWER TRAIN

SHIFT LEVER BROKE OFF INSIDE STEERING COLUMN OF MY WIFE'S EXPLORER WHEN CHANGING FROM PARK TO DRIVE TO EXIT FROM A BOAT LAUNCH RAMP WITH NO BOAT ON THE TRAILER. VEHICLE WAS TOWED ON A FLATBED WRECKER TO MY GARAGE. BROKEN ELEMENT ( SEE PHOTOS) WAS NOT REPLACEABLE BY ITSELF. STEERING COLUMN HAD TO BE REPLACED. THIS WAS NOT NORMAL WEAR AND TEAR, BUT RATHER A FAULTY /WEAK COMPONENT THAT REPRESENTS A DANGER. I HAVE NOTED REPORTS OF IDENTICAL INCIDENTS ONLINE. THUS FAR, NEITHER THE DEALER NOR FORD NATIONAL "CUSTOMER SERVICE" IS PREPARED TO REIMBURSE.

NHTSA complaint #11021498 — an unverified report by a vehicle owner.

POWER TRAIN

TRANSMISSION SHIFTS HARD AND CLUNKS, IS NOT SAFE TO DRIVE. THE ESTIMATE REPAIR IS AROUND $ 3,400. WILL NEVER BUY A FORD AGAIN.

NHTSA complaint #10984485 — an unverified report by a vehicle owner.

POWER TRAIN

"TAKATA RECALL"I BROUGHT THE TRUCK AND THE AIRBAG LIGHT WAS FLASHING 4X4 LIGHTS FLASHING ALSO, SMELLING OIL COMING FROM THE DEFERENTIAL ON THE BACK AXLE. NOW, THE TRANSMISSION STARTED SLIPPING AND HE CHANGED A PART . THEN, THE TRANSMISSION STARTED TO SLIP AGAIN. ALSO,I WANTED TO SWITCH TO ANOTHER VEHICLE BUT HE DECLINED IT . HE SAID " HE PUT TO MUCH WORK INTO THE TRUCK AND ALL THE PARTS ARE NEW IN WHICH ONLY THE TIRES AND MUFFLER WAS REVOLVED ".

NHTSA complaint #10895806 — an unverified report by a vehicle owner.

POWER TRAIN

MY TRANSMISSION LIGHT HAS BEEN COMING ON. I WAS ONLY AT 117K MILES WHEN IT HAPPENED. THAT'S TO SOON FOR A TRANSMISSION TO BE ACTING UP ESPECIALLY SINCE IT'S ANEW ONE ACCORDING TO CARFAX THIS IS THE SECOND TRANSMISSION FOR MY EXPLORER. THE FIRST ONE WAS PUT IN ONLY AT 3 YEARS OLD. IT WILL SOMETIMES JERK INTO REVERSE OR TAKE A SECOND TO GO INTO DRIVE WHEN I SWITCH GEARS. MY OVERDRIVE LIGHT ALSO FLASHES WHICH I ASSUME MEANS MY OVERDRIVE NO LONGER WORKS. THE LIGHT ONLY COMES ON AFTER DRIVING OVER 40 MPH. SO IF I'M ON THE HIGHWAY I CAN'T GO THE SPEED LIMIT BECAUSE I DON'T WANT THIS LIGHT COMING ON. I TOOK IT TO A TRANSMISSION SHOP IT NEEDS A TORQUE CONVERTER AND A REBUILD. I CONTACTED FORD AND THEY WON'T DO ANYTHING ABOUT IT. THEY TOLD ME TO BUY A NEW CAR. WHEN I GO UP HILLS MY EXPLORER ALSO HAS TROUBLE EVEN THOUGH IT SHOULDN'T. I ALSO NEED A NEW SOLENOID PACK.

NHTSA complaint #10885760 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE DRIVING HOME FROM WORK THIS EVENING THE O/D OFF LIGHT BEGAN STEADILY BLINKING AND THE TRANSMISSION TOOK WAY TOO LONG TO SHIFT (RPM ALMOST RED LINE) AND WOULDN'T SHIFT INTO 5TH GEAR. I WAS DRIVING ON A CITY STREET AND FIRST NOTICED THE TRUCK NOT SHIFTING AND WITHIN 3 MINUTES OF DRIVING THE O/D OFF LIGHT BEGAN FLASHING. IF YOU TURN THE TRUCK OFF THEN BACK ON THE O/D OFF LIGHT TURNS OFF BUT THE TRUCK STILL WON'T SHIFT CORRECTLY AND THE LIGHT STARTS TO BLINK AGAIN. MY TRUCK ONLY HAS 133,000 MILES. I GOOGLED THIS PROBLEM AND DISCOVERED THAT THE VAST MAJORITY OF 2003 FORD EXPLORER OWNERS HAVE THIS SAME PROBLEM.

NHTSA complaint #10852423 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE DRIVING HOME FROM WORK THIS EVENING THE O/D OFF LIGHT BEGAN STEADILY BLINKING AND THE TRANSMISSION TOOK WAY TOO LONG TO SHIFT (RPM ALMOST RED LINE) AND WOULDN'T SHIFT INTO 5TH GEAR. I WAS DRIVING ON A CITY STREET AND FIRST NOTICED THE TRUCK NOT SHIFTING AND WITHIN 3 MINUTES OF DRIVING THE O/D OFF LIGHT BEGAN FLASHING. IF YOU TURN THE TRUCK OFF THEN BACK ON THE O/D OFF LIGHT TURNS OFF BUT THE TRUCK STILL WON'T SHIFT CORRECTLY AND THE LIGHT STARTS TO BLINK AGAIN. MY TRUCK ONLY HAS 133,000 MILES. I GOOGLED THIS PROBLEM AND DISCOVERED THAT THE VAST MAJORITY OF 2003 FORD EXPLORER OWNERS HAVE THIS SAME PROBLEM.

NHTSA complaint #10838090 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING ON AN INCLINE AT AN UNKNOWN SPEED, THE VEHICLE FAILED TO ACCELERATE AND THE OVERDRIVE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SOLENOID PACK AND THE OXYGEN SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT ALSO MENTIONED THAT THE CHECK TRANSMISSION AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

NHTSA complaint #10820980 — an unverified report by a vehicle owner.

POWER TRAIN

I BOUGHT MY FORD EXPLORER XLT BACK IN JUNE OF 2015. SINCE THEN I REPLACED MY OXYGEN SENSOR DO TO A FAULT IN THE SYSTEM AND MELTING BACK IN AUG. 20015. THE SUV WOULDN'T START BECAUSE OF IT AND HAD TO BE TOWED. SINCE I PURCHASED AND HAD REPLACED THE OXYGEN SENSOR BY A FORD DEALER, I NOTICED THE SUV HAVING POWER FAILURE EVEN FROM A COMPLETE STOP AND NOW THE OVER DRIVE OFF LIGHT FLASHES; THIS STARTED IN THE BEGINNING OF NOV. 2015 I NOTICED THAT THERE IS OVER 2755 COMPLAINTS OF TRANSMISSION PROBLEMS AND FAILURES EXACTLY THE SAME AS MINE, BUT NOT ONE RECALL. THIS IS A ISSUE WITH THE SUV THEMSELVES AND NOT OWNER ERROR. I HAVE CHILDREN AND DON'T WANT TO END UP STRANDED IN THE STREET OR SIDE OF THE HIGHWAY DUE TO TRANSMISSION FAILURE. THERE HAS TO BE SOMETHING CAUSING THE TRANSMISSION TO BREAK DOWN OR FAIL AND I REFUSE TO BE THE THE BLAME NOR PAY THOUSANDS TO FORD DEALERSHIP TO FIX A FLAW IN THERE OWN SUV. A RECALL NEEDS TO BE MADE FOR THIS PROBLEM AND IT IS CLEARLY A MANUFACTURE FLAW.

NHTSA complaint #10808552 — an unverified report by a vehicle owner.

POWER TRAIN

1. TRANSMISSION DOES NOT LET YOU ACCELARATE. PRESSURE BUILDS UP WHILE YOU ARE PRESSING ON THE GAS PEDAL AND IT DOESN'T INCREASE YOUR SPEED UNTIL 10 SECONDS OR SO OF PRESSING THE GAS PEDAL, AND THAN IT EXPLODES AND YOU ARE THRUST BACK WITH THE ACCELERATION. VERY DANGEROUS WHEN YOU ARE TRYING TO CHANGE LANES OR ARE ENTERING THE HIGHWAY. LACK OF ACCELERATION HAS ALMOST GOT US INTO A FEW ACCIDENTS. 2. SENSORS ARE NOT FUNCTIONING, CONSTANTLY TELLING ME THAT THE DOORS ARE OPEN. I DON'T KNOW WHEN A DOOR IS ACTUALLY OPEN OR NOT. 3. THE REAR HATCH IS CRACKED AND I'M AFRAID IT DOESN'T PROVIDE ENOUGH STABLE PRORECTECTION FOR THE REAR GLASS TO BE HELD IN PLACE PROPERPLY.

NHTSA complaint #10794609 — an unverified report by a vehicle owner.

POWER TRAIN

MY 2003 FORD EXPLORER XLS IS HAVING ISSUES WITH THE AUTOMATIC TRANSMISSION. WHEN I ACCELERATE FROM A STOPPED POSITION, THE TRANSMISSION STALLS, SLIPS AND DELAYS WHEN IT SHIFTS INTO THE NEXT GEAR. AS I SEARCHED FOR ISSUES WITH THE TRANSMISSION I FOUND 100'S OF COMPLAINTS REGARDING THIS MATTER. FROM WHAT I HAVE FOUND, THE TRANSMISSION IS A DESIGN FLAW

NHTSA complaint #10788981 — an unverified report by a vehicle owner.

POWER TRAIN

WE HAVE RECURRING WHEEL BEARING AND HUB ASSEMBLY ISSUE. THE TIMING I PUT ON THE FORM MAY BE OFF A BIT BUT NOT MUCH. ITS ALL LIKE A RECURRING FORD EXPLORER NIGHTMARE AT THIS POINT! WE HAVE REPLACED BEARINGS, HIB ASSEMBLY, TIE ROD, THEN REAR END WENT UP ( AND SHOULDN'T HAVE)/NOW AGAIN, ANOTHER BEARING AND WHEEL SENSOR. THE TRUCK CUTS OUT WHEN AT A SLOWER SPEED. I LOST STEERING A FEW MONTHS AGO WHILE DRIVING AND WHEN I TRY TO PUT IT IN GEAR, SOMETIMES IT WON'T MOVE.I HAVE CALLED FORD, NHTSB AND NO ONE IS WILLING TO MAKE FORD RECALL THESE ISSUES AND FORD WON'T DO THE RIGHT THING KNOWING IT'S AN ONGOING PROBLEM WITH A LOT OF FORDS! PLEASE SOMEONE HELP! I HAVE MULTIPLE SCLEROSIS AND A HEART ISSUE. I NEED A SAFE RELIABLE CAR AND CAN'T AFFORD TO GET ANOTHER ONE. SOMEONE, PLEASE DO THE RIGHT THING HERE! I KNOW ITS AN OLDER MODEL AND I QUESTION IF THIS IS WHY THE RECALL ISN'T HAPPENING.IDK BUT THIS ISN'T RIGHT. THE TRUCK IS SITTING OUT FRONT NEEDING AN ADDITIONAL $700 OF WORK . AFTER REAR END, TIE ROD, BEARINGS, BRAKES IN THE PAST SEVERAL MONTHS, WE HAVE NO WAY TO FIX THIS LEMON. ALWAYS BEEN FORD BUT IF THEY OR A GOVERNING AGENCY DOESN'T HELP.. NEVER A FORD AGAIN. LOOK AT ALL THE COMPLAINTS FOR THE SAME THING!!!! SHAMEFUL.

NHTSA complaint #10786962 — an unverified report by a vehicle owner.

POWER TRAIN

TRANSMISSION FAILURE, A COMMON OCCURRENCE IN THESE VEHICLES

NHTSA complaint #10779233 — an unverified report by a vehicle owner.

POWER TRAIN

I PURCHASED MY 03 FORD EXPLORER BACK IN 2/15. IT LOOKED LIKE I PURCHASED A VERY VERY GOOD USED VEHICLE. EVERYTHING HAS BEEN FINE WITH IT UP UNTIL 2 WEEKS AGO. MY DOOR AJAR LIGHT KEEPS COMING ON WHEN EVERYTHING IS CLOSED, THE OD LIGHT IS BLINKING NON STOP AND THE TRUNK WINDOW OPENS BY ITSELF WHEN I AM DRIVING. WHEN IM DRIVING IT FEELS LIKE THE CAR IS TRYING TO "CATCH UP". LIKE IT KNOWS I'M TRYING TO DO A CERTAIN SPEED BUT ITS WAY BELOW AND AFTER A MIN. OR SO, THEN IT WILL GO THE CORRECT SPEED. I HAD IT HOOKED UP TO A DIAGNOSTIC TOOL AND ITS GIVING ME THE CODE OF P7032 (SOMETHING LIKE THAT). SOMETHING ABOUT 2ND GEAR OF TRANS? IVE BEEN TOLD THAT THIS IS A KNOWN ISSUE WITH THIS MAKE, MODEL AND YEAR.. IVE ALSO READY 100S OF REVIEWS AND COMPLAINTS ON THESE ISSUES. WHAT I DON'T SEEM TO UNDERSTAND IS WHY ISN'T FORD DOING ANYTHING ABOUT THIS???? IF YOU ARE A MANUFACTURER AND SEE ALL THESE COMPLAINTS AND REVIEWS (WHICH I'M SURE THEY DO) THEN WHY AREN'T THESE VEHICLES GETTING RECALLED? I'M NOT RICH IN ANY WAY FASHION OR FORM. I'M A SINGLE MOTHER OF 4 WHO WORKS FULL TIME AND RECEIVES NO GOV'T ASSISTANCE. IF I WOULD HAVE KNOWN THAT THIS IS A "KNOWN" ISSUE I WOULD NEVER HAVE SPENT MY HARD EARNED MONEY.... DOES ANYONE KNOW IF ANYTHING IS BEING DONE ABOUT THIS??

NHTSA complaint #10764011 — an unverified report by a vehicle owner.

POWER TRAIN

BEING THAT I AM DISABLED, I'M AFFRAID THAT WHEN THE TRANSMISSION FINALLY GOES COMPLETELY OUT, I'LL BE STRANED SOMEWHERE OR THE SUV WILL CAUSE A WRECK AND HURT/KILL ME OR SOMEONE ELSE. THERE HAVE BEEN THOUSANDS OF COMPLAINTS ABOUT THE TRANSMISSION ON THIS EXPLORER THAT A RECALL SHOULD HAVE BEEN SENT OUT. I CAN NOT AFFORED THE REPAIR COST OR THE COST OF ANOTHER SUV/CAR, PLEASE HELP!

NHTSA complaint #10749638 — an unverified report by a vehicle owner.

POWER TRAIN

THE O/D OFF LIGHT & CHECK TRANSMISSION LIGHTS WENT ON, THEN VEHICLE WOULDN'T SHIFT PROPERLY AND BECAME INOPERABLE.

NHTSA complaint #10735475 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 45 MPH, THE TRANSMISSION EXPERIENCED DIFFICULTY SHIFTING FROM FIRST INTO SECOND GEAR. WHEN IT SHIFTED, AN ABNORMAL SOUND WAS HEARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REBUILT OR REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 152,000.

NHTSA complaint #10731726 — an unverified report by a vehicle owner.

POWER TRAIN

WAS LEAVING GAS STATION, SHIFTED FROM PARK TO DRIVE, SHIFT LEVER BROKE OFF INTO MY HAND. OBVIOUSLY A DEFECT, AS I HAVE OVER 2 MILLION MILES UNDER MY BELT, DRIVEN NUMEROUS CARS & TRUCKS, AND HAVE NEVER HAD THIS HAPPEN BEFORE IN OVER 40 YEARS OF DRIVING, BOTH PERSONALLY AND PROFESSIONALLY. I SEE THERE ARE HUNDREDS OF SIMILAR COMPLAINTS FOR THIS, WHY IS THERE NO RECALL??

NHTSA complaint #10703385 — an unverified report by a vehicle owner.

POWER TRAIN

FOR YEARS FORD HAS HAD A POORLY DESIGNED HYDRAULIC MANUAL CLUTCH SYSTEM . OFTEN IMPOSSIBLE TO SHIFT AT RED LIGHT OR WHILE DRIVING AND HAD MANY NEAR REAR END COLLISIONS DUE TO NOT BEING ABLE TO CONTINUE SHIFTING AND MAINTAINING SPEED. FOR OVER A DECADE THE POORLY DESIGNED SYSTEM GETS AIR BOUND RENDERING THE CLUTCH USELESS . THIS IS CAUSED BECAUSE THE HYDRAULIC LINE HAS LOW AND HIGH SPOTS AND AIR BECOMES TRAPPED IN THE HIGH SPOTS AND RESULTS IN LOSS OF CLUTCH OPERATION . THE ENTIRE SYSTEM MUST BE REMOVED AND ELONGATED TO ALLOW AIR TO BE RELEASED FROM SYSTEM . NO BLEEDER VALVE AT MASTER CYLINDER FOR ONE THING . THERE IS A BLEEDER VALVE AT THE SLAVE CYLINDER BUT BECAUSE THE LINE HAS MANY TWIST AND TURNS WITH HIGH SPOTS BLEEDING DOES NOT ELIMINATE AIR TRAPPED IN HIGH SPOTS . THIS IS A WELL KNOW PROBLEM AND A DANGEROUS ONE . FORD COULD CARE LESS . ITS ABOUT TIME FORD ANSWERS AND MODIFIES THIS FAULT . YOU NEED ONLY GO ONLINE AND ENTER FORD RANGER HARD SHIFTING PROBLEMS AND YOU WILL SEE IT IS COMMON PLACE PROBLEM . OF COURSE AFTER THE 36 K WARRANTY THIS BECOMES A COMMON PROBLEM AND FORD TURNS THERE CHEEK . I CANT TELL YOU HOW FRUSTRATING TO BE AT A RED LIGHT AND UNABLE TO SHIFT ALONG WITH NOT BEING ABLE TO SHIFT AT HIGH SPEEDS WITH CARS RUNNING UP YOUR REAR . PLEASE ADDRESS THIS BEFORE LIFE IS LOST . THANK YOU . I URGE ALL RANGER OWNERS TO GET ON BOARD.

NHTSA complaint #10676444 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE FAILED TO ACCELERATE AND THE TRANSMISSION MALFUNCTIONED WHILE IN THIRD GEAR. ALSO, WHILE DRIVING UP HILLS, THE FAILURE RECURRED AND THE OVERDRIVE AND CHECK ENGINE SENSOR LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 94,000.

NHTSA complaint #10658978 — an unverified report by a vehicle owner.

POWER TRAIN

THE PROBLEM WHEN YOU DRIVING ON THE HIGHWAY AROUND 65 MPH YOU FEEL THE TRUCK HESITATING, SINCE THIS TRUCK DID NOT COME WITH DIP STICK TO CHECK THE TRANSMISSION FLUID, IT IS HARD TO CHECK UNLESS YOU TAKE IT TO A TECH OR STOP ON THE MIDDLE OF THE ROAD TO CHECK IT UNDERNEATH THE TRUCK RUNNING TRANS FOR THE FLUID TO DRIP, IT IS REALLY STUPID YOU CAN BE RUN OVER BY A CAR OR CAUSE AN ACCIDENT, IT SEEMS LIKE THE MANUFACTURES ARE GETTING STUPID, IN A EMERGENCY AND YOU ARE IN THE HIGHWAY CROSSING THE STATE LINE HOW CAN YOU CHECK THE FLUID ON TRANSMISSION, IT NEED IMMEDIATE ATTENTION TO ADD THE DIP STICK PRETTY PRONTO, IT NEED THE FORD COMPANY TO TAKE RESPONSIBILITY TO ADD THE DIP STICK, I SUBMITTED SEVERAL REPORTS TO THEM THEY DON'T CARE AT ALL.

NHTSA complaint #10652585 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 30 MPH, THE VEHICLE JERKED AND QUICKLY SHIFTED INTO SECOND GEAR. THE CHECK ENGINE INDICATOR WAS ILLUMINATED AND THE OVERDRIVE WARNING INDICATOR WAS FLASHING. THE REPAIR SHOP STATED THAT THE TRANSMISSION NEEDED TO BE OVERHAULED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 163,300. UPDATED 9/12/14*CN UPDATED 09/23/14

NHTSA complaint #10620647 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE HAD THREE INCIDENTS WITH MY 2003 FORD EXPLORER. THE FIRST INCIDENT INVOLVED THE SUSPENSION ( SWAY BARS SNAPPED, TIRES HAD TO BE REPAIRED). SECOND INCIDENT WAS THE TRANSFER CASE AND A WIGGLING DRIVE SHAFT ALONG WITH REAR WHEEL BEARINGS ( PARTS DEEMED DEFECTIVE BY MECHANICS) , AND EMERGENCY BRAKES THAT SNAPPED OFF IN MY MECHANICS HANDS BECAUSE THEY WERE RUSTY. NOW IT IS TRANSMISSION WORK FOR A POSSIBLE FAULTY SENSOR. FORD NEEDS TO RECALLS BEFORE SOMEONE IS KILLED DUE TO CATASROPHIC EQUIPMENT FAILURE! IVE CALLED THEM EVERY TIME AND THEY ARE AWARE OF THE ISSUES BUT REFUSE TO DO ANYTHING OTHER THEN DOCUMENT THEM AND SAY HAVE A NICE DAY!

NHTSA complaint #10616754 — an unverified report by a vehicle owner.

POWER TRAIN

THE TRANSMISSION LIGHT, 4'4 AND THE OD LIGHT CAME ON. IT DOES SHIFT GEAR FROM 1 TO 2 UNTIL 3000 RPM.

NHTSA complaint #10614702 — an unverified report by a vehicle owner.

POWER TRAIN

TRANSMISSION OD LIGHT FLASHING, SLAMMING INTO GEAR WHILE SHIFTING. WE HAD THE PAN DROPPED AND FOUND PIECES OF THE GEARS INSIDE... NEED A TOTAL REBUILD OR NEW TRANSMISSION. AFTER READING ALL OF THE PROBLEMS WITH THIS YEAR AND MODEL I BELIEVE FORD NEEDS TO MAKE SOME KIND OF RECALL....

NHTSA complaint #10608900 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY DECELERATED DOWN TO APPROXIMATELY 45 MPH AND THE OVER DRIVE WARNING SENSOR LIGHT ILLUMINATED. ALSO, THE CONTACT INDICATED THAT DURING THE INCIDENT THE VEHICLE FAILED TO SHIFT INTO GEAR. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 156,000.

NHTSA complaint #10609074 — an unverified report by a vehicle owner.

POWER TRAIN

MY SON PURCHASED THIS EXPLORER BRAND NEW AND I BOUGHT IT FROM HIM FOUR YEARS AGO AND I LOVE THIS AS IT IS THE BEST DESIGN IN THE SUV'S, AND I CAN NOT AFFORD A NEW VEHICLE AS I AM NO YOUNG GAL ANY MORE. WE HAVE MAINTAINED IT FAITHFULLY AND HAVE HAD NO SERIOUS PROBLEMS WITH IT AND IS AT 145000. I WAS DRIVING TO WORK GOING 55 MPH AND THE O/D LIGHT COMES ON AND I PUSH THE BUTTON AND IT WOULD NOT GO OFF. I PULLED OVER AND TRIED THE BUTTON A FEW TIMES-NOTHING. I SHUT IT OFF, TURNED IT BACK ON-NO LIGHT WAS ON-PROCEEDED DOWN THE HIGHWAY AND THE LIGHT TURNS BACK ON AND IT WILL NOT SHIFT AND IS STRAINING SHIFT. I TOOK IT IN TO JIFFY LUBE TO GO AHEAD AND GET ANOTHER OIL CHANGE AND LET THEM CHECK THE TRANSMISSION FLUID AND THEY SAID THAT THEY COULD NOT ACCESS IT TO CHECK THE FLUID-THEY SUGGESTED A TRANSMISSION FLUSH AT $200-WHY CAN'T THEY ACCESS IT? WOULDN'T A DIP STICK SAVE A LOT OF TROUBLE? AS I LOOK AT ALL THE COMPLAINTS ABOUT THE TRANSMISSION TROUBLES IN THE EXPLORERS, I AM VERY SHOCKED. PLEASE CAN YOU HELP ME OUT HERE AS I CANNOT AFFORD HIGH MAINTENANCE BILLS THAT WOULD BE CHARGED THROUGH A DEALER. JUST TELL ME IF THERE IS A SIMPLE SOLUTION TO FIXING IT SO THAT MY BROTHER MAY REPAIR IT AND GET IT BACK ON THE ROAD. ONE RESPONSE IS AS SUCH: AFTER TALKING TO 2 FORD REPS TODAY, AND TURNED DOWN FLAT FOR HELP, I HAVE DECIDE ITS NOW A QUEST.... FORD STATED THEY DIDN'T HAVE ENOUGH COMPLAINTS FOR THE NHTSA TO OPEN UP AN INVESTIGATION TO POSSIBLY ORDER A RECALL...... SOOOO, FOR ALL THOSE THAT HAVE ISSUES, CALL FORD AND ALSO MAKE A COMPLAINT ON THE NHTSA SITE WWW.NHTSA.GOV OR CALL THEM AT 1-800-424-9393. MY FAMILY IS A FORD FAMILY AND WE CURRENTLY HAVE 5 FORDS IN OUR HOUSEHOLD, A MUSTANG, FORD F150, FORD FOCUS, EXPEDITION, AND THE EXPLORER THAT IS HAVING ISSUES. THIS ISN'T INCLUDING EXTENDED FAMILY. FORD IS ABOUT TO LOSE FUTURE BUSINESS....

NHTSA complaint #10605052 — an unverified report by a vehicle owner.

POWER TRAIN

TRANSMISSION FAILURE.

NHTSA complaint #10597049 — an unverified report by a vehicle owner.

POWER TRAIN

TRUCK JERKS WHEN TRYING TO PICK UP SPEED PICKS UP SPEED VERY SLOW SOMETIMES DOESN'T WANT TO GO IN DRIVE.

NHTSA complaint #10595393 — an unverified report by a vehicle owner.