427 of the 5,731 complaints filed about the Ford F-250 are about the transmission — 7% of everything owners reported. The worst model year for it is 1999.
427
Complaints
7%
Share of all complaints
18
Crashes
15
Fires
POWER TRAIN:AUTOMATIC TRANSMISSION
See attached document for complaint.
NHTSA complaint #11699381 — an unverified report by a vehicle owner.
POWER TRAIN
See attached document for complaint.
NHTSA complaint #11699381 — an unverified report by a vehicle owner.
POWER TRAIN
I just had to replace the ECM because it fired. after replacing that it still won't start. I've talked to multiple people who have had the same problem.
NHTSA complaint #11675751 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2012 Ford F-250. The contact stated that the vehicle was previously taken to an unknown dealer, where it was diagnosed with engine seizure due to coolant intrusion in the engine. The contact stated that while the dealer was in the process of replacing the engine, the dealer informed the contact that the transmission also needed to be replaced. The dealer replaced the engine and the transmission. The contact stated that while driving at various speeds, the vehicle was bucking and jerking. The gear shift indicator light displayed that the transmission was slipping from drive(D) to neutral(N) and reverse(R). The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission needed to be replaced; however, the part was on back order. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 27,500.
NHTSA complaint #11671757 — an unverified report by a vehicle owner.
POWER TRAIN
Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because I'm having this issue
NHTSA complaint #11653078 — an unverified report by a vehicle owner.
POWER TRAIN
When im in traffic, starting out driving or merging between intersections my truck decides to either hard shift or not shift at all. Several times ive had to lay on my horn in an attempt to warn oncoming vehicles that i have no power and cannot accelerate and several times it has nearly caused an accident. I purchased the truck used and have yet to take it into the dealership to have them inspect the issue though from what i’ve read thus far is that ford calls this problem “normal operation” and has been less than understanding when people attempt to have this obvious defect resolved. There are no warning lights that come on when this happens. I can have my truck inspected by whomever, whenever need be. I will also be returning to the dealer to use my warranty to help deal with this issue. The date this most recently happened causing a near miss was today, though there has been an occasional but recurring situation almost weekly.
NHTSA complaint #11651526 — an unverified report by a vehicle owner.
POWER TRAIN
The tie rod broke while the vehicle was in motion. This caused the vehicle to lose control and crash into another vehicle, causing damage to both vehicles. There was no warning and no sign of any issues. Vehicle has been very well maintained, in fact, it has been in the shop at least once per month for the past year due to a number of mechanical issues unrelated to the tie rod.
NHTSA complaint #11638173 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2014 Ford F-250. The contact stated that while driving at an undisclosed speed hauling a trailer, the exhaust manifold dropped raw fuel into the exhaust and it caught fire. The contact was able to extinguish the fire. The exhaust filter over maximum limit message was displayed. There were no reported injuries, crash , police report or air bag deployment. The fire department was on the scene. The vehicle was towed to the local dealer, where it was diagnosed and determined that cylinder one was down and the engine and transmission needed to be replaced. The mechanic informed the contact that the EPF may be damaged and not work. The vehicle was not repaired. The manufacturer was contacted, who referred to the NHTSA hotline. The failure mileage was approximately 195,000.
NHTSA complaint #11622771 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2014 Ford F-250. The contact stated while driving approximately 65 MPH, the transmission unexpectedly downshifted to 1st gear. The contact stated that the RPM gauge climbed into the "RED" zone and the vehicle almost stalled. The contact stated that the shift indicator on the instrument cluster was flashing and then showed that the vehicle was in 1st gear. The contact stated that the failure was intermittent. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 24V444000 (Power Train). The failure mileage was approximately 188,000.
NHTSA complaint #11611399 — an unverified report by a vehicle owner.
POWER TRAIN
Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road
NHTSA complaint #11606568 — an unverified report by a vehicle owner.
POWER TRAIN
Driving 65 miles per hour on the freeway and front end started shaking and wobbling horrible, could have caused an accident it was sudden and violent. Pulled over to verify tires were okay and they were. Couldn’t drive over 50 MPH without the wobble starting again.
NHTSA complaint #11587635 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2012 Ford F-250. The contact stated that while driving at various speeds over 50 MPH, the vehicle shifted into LIMP Mode. No warning lights were illuminated. The vehicle was taken to a local dealer, where the failures could not be duplicated. The vehicle was not repaired. The contact stated that the failure persisted and that the transmission was slipping while shifting. The contact also stated that prior to entering the vehicle, he noticed a fluid leak underneath. The vehicle was taken back to the dealer, where unknown transmission repairs were completed; however, the failure recurred. The vehicle was then taken to an independent mechanic, where the fuel pressure regulator and heater malfunction failure codes were retrieved, and it was diagnosed that the Diesel Exhaust Fluid (DEF) tank needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 160,100.
NHTSA complaint #11512823 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2012 Ford F-250. The contact stated that while driving at various speeds, the vehicle would shake abnormally without warning. Upon investigation, the contact linked the failure to the death wobble. The contact also stated that the EGR cooler was defective, causing the vehicle to downshift while driving at various speeds. The contact had the EGR cooler repaired by the dealer. The vehicle was not repaired for the death wobble. The manufacturer was not notified of the failure. The approximate failure mileage was 136,700.
NHTSA complaint #11480961 — an unverified report by a vehicle owner.
POWER TRAIN
Very intermittently, when I brake this vehicle to bring it to a stop, the engine will start to rev uncontrollably. I have to practically "stand" on the brake to keep it from charging forward. I have to turn off the truck to stop this high speed revving. After this happened 3 times in 2 months we took it to the dealer to check. There was nothing on the floor that could cause the gas pedal to accelerate. The dealer in Kingwood, WV could not duplicate, and found nothing wrong when inspected. We only use the truck once or twice a month so it is a low use vehicle. For this reason the problem does not occur frequently enough to replicate "on demand". While there was not a crash, it almost revved through an intersection and almost ran into another vehicle. Fortunately I was able to throw it into park (Not Good for the vehicle) and then turn it off.
NHTSA complaint #11477905 — an unverified report by a vehicle owner.
POWER TRAIN
Transmission has a hole in it. Linkage inside broke and caused hole on case. Can’t use item for a core due to this. Happened while driving home from just across town.
NHTSA complaint #11466076 — an unverified report by a vehicle owner.
POWER TRAIN
TL* THE CONTACT OWNS A 2008 FORD F-250. THE CONTACT STATED WHILE DRIVING 20-25 MPH, THE VEHICLE STARTED SHAKING. NO WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO SPITZER FORD (543 W MAPLE ST, HARTVILLE, OH 44632) AND INFORMED THAT THE TRACK BAR, BALL JOINTS, TIE ROD JOINTS AND POSSIBLE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED A CASE. THE MANUFACTURER ALSO INFORMED THE CONTACT THAT HE WOULD BE NOTIFIED IN THE EVENT THERE WAS A RECALL ASSOCIATED WITH THE VIN FOR THE FAILURE EXPERIENCED. IT WAS SUGGESTED THAT AN EXTRA HEAVY DUTY STEERING DAMPER BE INSTALLED ON THE VEHICLE. THE FAILURE MILEAGE WAS 48,048.
NHTSA complaint #11406671 — an unverified report by a vehicle owner.
POWER TRAIN
THE 6.2 ENGINE HAS BROKEN VALVE SPRINGS 3 TIMES NOW. FIRST TWO TIMES WAS ABLE TO JUST REPLACE THE BROKEN VALVE SPRING. THE 3RD TIME IT BROKE A VALVE SPRING IT DROPPED THE VALVE IN THE MOTOR AND PUT HOLE RIGHT THROUGH THE BLOCK AND SEIZED THE MOTOR ALMOST CAUSING ME TO WRECK
NHTSA complaint #11394899 — an unverified report by a vehicle owner.
POWER TRAIN
TL* THE CONTACT OWNS A 2000 FORD F-250. THE CONTACT STATED THAT WHILE ATTEMPTING TO ENTER HIS VEHICLE, THE GEAR SHIFTER INADVERTENTLY SHIFTED INTO REVERSE CAUSING THE DOOR TO KNOCK THE CONTACT DOWN TO THE GROUND WHERE THE CONTACT WAS RAN OVER BY THE VEHICLE. THE CONTACT SUFFERED BROKEN RIBS, TWO FRACTURED VERTEBRAE IN THE NECK, A PARTIALLY SEVERED RIGHT EAR, AND AN UNSTATED INJURY TO HIS LEGS. THE VEHICLE THEN PROCEEDED TO ROLL DOWN A SLIGHT HILL AND CAME TO A STOP AFTER CRASHING INTO A PARKED VEHICLE. MEDICAL ASSISTANCE ARRIVED TO THE SCENE AND THE AMBULANCE TOOK THE CONTACT TO THE HOSPITAL FOR MEDICAL TREATMENT TO HIS INJURIES. THE CONTACT WANTED TO STAY THAT HE WAS ON LIFE SUPPORT FOR TWO WEEKS AND ON A FEEDING TUBE FOR A FEW WEEKS. THERE WAS NO ONE ELSE INJURED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT AND LATER SENT TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 295,000.
NHTSA complaint #11394476 — an unverified report by a vehicle owner.
POWER TRAIN
I WE WERE ON THE HIGHWAY GOING 65 MPH TRUCK STARTED VIOLENTLY SHAKING THIS IS NOT THE FIRST TIME THIS HAS HAPPENED TO US WHILE DRIVING THIS TRUCK. IT HAS ALSO HAPPENED WHILE GOING 30MPH. IT IS VERY SCARY AND FEELS LIKE THE TRUCK IS GOING TO FALL APART. WE JUST BOUGHT THIS TRUCK LESS THAT 60 DAYS AGO AND THIS HAS HAPPENED 5-10 TIMES. WE HAVE ALSO MADE A COMPLAINT THROUGH FORD MOTOR AS TO WHAT WILL BE DONE WITH THIS ISSUE. WE HAD OUR LITTLE GIRL IN THE TRUCK AND SHE BECAME VERY AFRAID OF DRIVING IN THE TRUCK.
NHTSA complaint #11389400 — an unverified report by a vehicle owner.
POWER TRAIN
TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS DISPLAYED ON THE INSTRUMENT PANEL. RECENTLY, THE CONTACT STATED THAT AFTER EXPERIENCING THE FAILURE, THE VEHICLE FAILED TO RESTART. DUE TO THE FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO HIS RESIDENCE. THE CONTACT THEN CALLED AN INDEPENDENT MECHANIC TO HIS HOME WHO INFORMED HIM THAT THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
NHTSA complaint #11387536 — an unverified report by a vehicle owner.