2016 Ford Focus transmission problems

POWER TRAIN

My duel clutch transmission started acting up took it to a mechanic they said it needed the TCM and Actuators and possibly transmission replaced that they should be recalled tried taking it to Thirnhill Ford because I received a letter for this to be changed and they refused without me paying up front this has been going on with my car for over 2 years its setting in a driveway being paid on and cant even be drove

NHTSA complaint #11757255 — an unverified report by a vehicle owner.

POWER TRAIN

The car would not accelerate when pressing accelerator, they said the clutch assembly malfunctioned, confirmed by documentation. Myself and others had our safety at risk because the car could not be controlled properly while on the road. The car was taken to the dealer and they confirmed the problem. The dealer's service center gave inspection, and confirmed the problem. The warning message did not appear until after the problem put myself and others' safety at risk.

NHTSA complaint #11751981 — an unverified report by a vehicle owner.

POWER TRAIN

Transmission overheated. Transmission fluid leaked but the computer in the car didn't let me know there was a leak. Couldn't move my car into reverse so I had to get a tow to Ford. They said it was a Transmission leak which caused the overheating. But once the car received Transmission fluid the car did not go into reverse. Clutch failed.

NHTSA complaint #11748862 — an unverified report by a vehicle owner.

POWER TRAIN

While driving at highway speed, the transmission slipped, skipping gears. Very difficult to drive care safely. Could not accelerate vehicle safely. Had to stay in right lane with hazard lights on. Basically, using only gears 1, 3 & 5. Later discovered intermittently no reverse. DTC P090C Clutch Actuator B - Circuit Low.

NHTSA complaint #11744217 — an unverified report by a vehicle owner.

POWER TRAIN

When I bought the car it stuttered it ended up being the clutch then my transmission went out The bolt in my engine mount broke and my engine was basically on the ground

NHTSA complaint #11741924 — an unverified report by a vehicle owner.

POWER TRAIN

We bought this vehicle from Carvana in February 2023. Since very early on owning this vehicle, the engine hesitated and stuttered when trying to shift from first to second gear, and would lunge forward slightly. In December 2024, I received a letter from Ford Motor Company about a customer satisfaction program, Campaign 24N07. The letter addressed the symptoms my vehicle exhibited, including engine hesitation, engine running rough, and engine stalling at low speeds, though the check engine light was not on. The letter states that Ford Motor Company provides a one-time replacement of the canister purge valve, given these symptoms and the check engine light being on. When I called all the local Ford dealerships, they refused to do it because the check engine light was not on, and that Ford Motor Company issued this as a customer satisfaction program, rather than a safety recall.Everything that was listed in Campaign 24N07 is MOST DEFINITELY a safety issue, and should not be taken lightly. It is highly concerning that Ford Motor Company didn’t think to consider ENGINE ISSUES a safety recall. The class action lawsuit Vargas et al v. Ford Motor Company had a deadline of November 4, 2020, which was 2 years and 3 months prior to us buying the vehicle, so any vehicles of the affected years and models should have been either repaired, or not allowed to be sold unless the repairs were done by an authorized Ford dealership. This information was not told to us when we bought the vehicle.On May 25, 2026, while driving, the engine fault and steering assist fault warnings came on, as well as the check engine light. When we were able to safely park the car, we discovered the entire power train is non operational. The engine no longer turns over, and we are now having to buy a new car.

NHTSA complaint #11739970 — an unverified report by a vehicle owner.

POWER TRAIN

My car Transmission dual clutch went out in 2024. Car makes a loud winding noise car hesitate when stops Yes,confirmed by dealership and Coleman's transmission. Yes, by the manufacturer. No warning lamps or messages.

NHTSA complaint #11739372 — an unverified report by a vehicle owner.

POWER TRAIN

Transmission is slipping. Dealer reported cluthes going out. This is a known issue with all of these cars.

NHTSA complaint #11736136 — an unverified report by a vehicle owner.

POWER TRAIN

Ford Motor issued two safety recalls regarding this, but has since closed them without providing a safe resolution for consumers. July 8 2019 Ford issued Ford Safety Recall program 19S22 (following 18S32) for stuck open canister purge valve (CPV). This can result in a failure to bleed the vacuum from the gas tank, and deforms the gas tank upon failure. This has been confirmed, reproduced, and recalled by Ford before, but continues to happen nationwide to Ford Focus ST owners as a small subset of their vehicles. A stuck open CPV can result in a number of codes. In my case, I got a P1450, Ford-Specific check engine light on the MIL. This can cause inability to start, along with rough idle and stalling while driving. Ford reports closing these safety recalls and provides no further support for the issue.

NHTSA complaint #11735835 — an unverified report by a vehicle owner.

POWER TRAIN

The powertrain/transmission in my 2016 Ford Focus is malfunctioning. Specifically, the vehicle shudders and hesitates when accelerating in low gears, causing delayed engagement and unpredictable power delivery. This issue occurs at low speeds, such as when entering traffic or moving through intersections, creating a potential safety risk for myself and other drivers. The problem has been officially diagnosed by a Ford dealership as a transmission/clutch issue, with a repair estimate of approximately $3,700. The issue has been reproduced consistently and confirmed by the dealer. No warning lights appeared prior to the malfunction, but the shuddering and hesitation are noticeable during normal driving. The vehicle currently has approximately 26,000 miles, which is very low for transmission failure, and the manufacturer has denied goodwill assistance despite the early and confirmed failure.

NHTSA complaint #11727541 — an unverified report by a vehicle owner.

POWER TRAIN

The car shakes when I turn the car on. I always thought it was normal until they told me it wasn't. Also ive smelled like a burn oil smell... Ive gotten stuck on intersection, guessing its the transmission.. i had to put the car it park and put it drive to see if it moved. When it did moved the whole front car shook while doing the turn. That happened like 2x. Both times I've parked afterwards and I tried to put it in reverse and nothing. It did not reverse. And that was the last of it moving.

NHTSA complaint #11727219 — an unverified report by a vehicle owner.

POWER TRAIN

The transmission in this model is horrible they already have recall for the 1.0L mine of course is the 2.0L its 2016 Ford Focus it has last than 165,000 miles. I already replaced put new transmission in it last year and here I am again transmission is out. And of course no repair shops will touch my car deal this known issues

NHTSA complaint #11726919 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle shuddered unexpectedly. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with dual clutch failure. The contact was informed that the dual clutch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced NHTSA Campaign Number: 18V169000 (Power Train); however, the VIN was not associated with the recall. The failure mileage was approximately 65,000.

NHTSA complaint #11723110 — an unverified report by a vehicle owner.

POWER TRAIN

The vehicle experienced failure of the DPS6 dual-clutch automatic transmission. The transmission began slipping during acceleration, hesitating between gear engagement, and triggering a “Transmission Overheat” warning. Eventually, the vehicle lost the ability to reliably shift between Drive and Reverse and would not consistently engage gears. The vehicle can start and move forward but cannot reliably switch directions within the same ignition cycle. The vehicle is available for inspection. The transmission malfunction created safety concerns due to delayed or failed acceleration when entering traffic. The vehicle hesitated and slipped under throttle input, which could prevent timely acceleration when merging or crossing intersections. Additionally, the inability to reliably shift between Drive and Reverse could create hazardous situations in parking lots or emergency maneuvering scenarios. The sudden transmission overheat warning and gear disengagement could result in loss of power in traffic. The issue has been confirmed by an independent mechanic who diagnosed transmission failure. The vehicle has a known history of prior clutch replacement under similar symptoms. The transmission malfunction is consistent with documented DPS6 transmission failures in 2016 Ford Focus models. The vehicle has been inspected by an independent service center. The manufacturer has not inspected the vehicle. Prior to failure, the vehicle exhibited shuddering during acceleration from a stop, particularly at low speeds. This condition has been intermittently present for several years following a prior clutch replacement. In the days leading up to failure, the vehicle experienced difficulty accelerating and hesitation under throttle. A “Transmission Overheat” warning message appeared while driving. After cooling, the vehicle temporarily resumed operation but subsequently lost reliable gear engagement.

NHTSA complaint #11715985 — an unverified report by a vehicle owner.

POWER TRAIN

Transmission is slipping. Check engine light is on. Code P07A5 (3/3) Permanent Transmission Friction Element B Stuck on.

NHTSA complaint #11713197 — an unverified report by a vehicle owner.

POWER TRAIN

When driving my car all of a sudden it loses power almost like it’s struggling to go but the RPM revs up and makes a loud noise and my car kind of got stuck for a minute and there were cars behind me then it started going but every couple minutes it would do that again rev up really loud even when I barely push the gas and lose power and then go I have no idea why it was doing that I took it to get it looked at, but there was no light on then a light finally came on and it came up with P07A3. Transmission friction element A stuck on. It starts end doing that with no notice. Light came on later after I tried to get it scanned. There seems to be extended warranty satisfaction things offered on vehicles at the same time mine was made. Same vehicle. But my number is not on the vin recall. But it exhibits same symptoms. The ford customer satisfaction program 14m02 covers same issues but my vin is not listed. This is a driving hazard unsafe that I feel is issues from their manufacturing.

NHTSA complaint #11713023 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle unexpectedly stalled with the message "Transmission Overheating" displayed. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that the failure persisted. The manufacturer was not contacted regarding the failure. The failure mileage was 55,000.

NHTSA complaint #11710854 — an unverified report by a vehicle owner.

POWER TRAIN

Fuel purge valve is malfunctioning. Vehicle loses power and is sluggish. Idles very rough and sometimes has a loss of power. My car has been at Ford twice in the last six months and problem still isn't fixed. Complete engine was replaced about a year and a half ago due to recall issue which I don't want happening again. I do not feel safe driving this car. I made an appointment with Ford a month ago for tomorrow for same stalling issue. I went to drop off and explain I wanted the repairs done for the recall to see if that fixed the problem. I filled up my gas tank on Sunday. The car wouldn't start and engine light came on saying engine failure service now. I let it sit for about ten minutes and it hesitantly cranked and engine light went off but accelerates slower with loss of power. It keeps doing this intermittently and sometimes loses power, and struggles when idling. I cut off let sit and then is okay until I pump gas again. I told the service repair person what happened and handed him the key to drop off the vehicle. He said if the light was not on at the time he would not be able to fix it and they couldn't schedule my vehicle for any additional recalls that are greatly needed for the car. It is running terrible. It idles and intermittently loses power while driving. Evan at Ford (Greer) response was to wait until it got bad enough that the engine light came on and stayed on. This was at D&D Ford in Greer, SC. He said it was Ford's policy the light had to be on to replace under recall with no charge. I told him it is unsafe to drive if it gets any worse it could cause an accident. I have two children and his recommendation to wait until it gets worse was appalling. He kept backlashing Ford and stated he doesn't work for Ford he works for D&D and only represents Ford. I said to him he was not representing Ford very well and that it was highly unlikely they would agree with his statements. I asked for documation of this policy--it contradicts what he says.

NHTSA complaint #11710571 — an unverified report by a vehicle owner.

POWER TRAIN

Having fuel problems with this ford se. Adding gas after starting the car it doesn't run right. It misses n doesn't have power. Plus Transmission went out two times again. First time it went out. It was about a year ago. Now the second time [XXX]. First time was about a year ago. It was repaired. Because I had a car warranty from the car dealer ship. Now they won't repair it again. This ford focus Se had the double clutch in it Plus the notorious speed shifter known to go out. These transmissions are known to have problems. But the car place never told me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11707438 — an unverified report by a vehicle owner.

POWER TRAIN

Something wrong with the transmission the one that Ford extended warranty on and my car is a 2016 and Ford extended it 10 years and they said it ended a few months ago as well as the TCM replacement I didn't know about because I just purchased the vehicle a little over a year ago.

NHTSA complaint #11707109 — an unverified report by a vehicle owner.

POWER TRAIN

Lee County was working on the road and were replacing a section of Lazy D Farm Road and there was a section cut out and try to get across the section the transmission over heating light came on

NHTSA complaint #11698730 — an unverified report by a vehicle owner.

POWER TRAIN

The clutch had to be replaced a second time and the engine became disabled while driving due to parts failure and it blowing up. This is all happening with 60,000 miles on the vehicle. My safety came into question with both failures disabling my car while I was driving on the interstate. The clutch was replaced and paid for out of pocket and I have been trying to work with ford about the engine but they have not helped at all. The issues just popped up and failed immediately while driving. This engine failure issue is covered for my vehicle, but my VIN is not covered. The only explanation I have received is that it is because my car is a manual transmission, which has no link to the part that failed on the engine. I was also notified by the ford service manager that my vehicle was made in the exact location and time frame that the recall covers, but my VIN still is not covered. I have received absolutely no help or solution with my vehicles failure and have been without a vehicle for 9 months because of the large price on replacing an entire engine, right after I had to pay for a very expensive clutch replacement.

NHTSA complaint #11694988 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2016 Ford Focus. The contact stated while driving 40 MPH and depressing the accelerator pedal, the vehicle hesitated. The contact also stated that while attempting to start the vehicle, the vehicle failed to respond as intended. Additionally, while driving at an undisclosed speed and attempting to make a left or right turn, the lost motive power. An independent mechanic was contacted, and the vehicle was taken to the independent mechanic to be diagnosed. The mechanic retrieved DTC: P2872 (Clutch "A" Stuck Engaged). The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 14N02 (Extended Warranty Coverage for PCM Reprograming in the Event of ABS Vehicle Speed Signal Related Communication Loss that Disables OBDII System Monitors); however, the VIN was not included in the CSP. The manufacturer was notified of the failure, and informed the contact that the VIN was not under warranty or recall. The failure mileage was 108,000.

NHTSA complaint #11689761 — an unverified report by a vehicle owner.

POWER TRAIN

I was driving the car other all of a sudden died on me and told me to put it in park I put it in park and then turned the key off and tried to restart it. It did not restart and would not turn of kept popping up a warning saying starter system failure. Could not turn my wheel or pit it in neutral to get it out of te middle of the road.

NHTSA complaint #11686601 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2016 Ford Focus. The contact stated that while driving at approximately 60 MPH, the vehicle started losing motive power. The contact heard an abnormal grinding sound coming from under the floorboard. The contact stated that while depressing the accelerator pedal, the vehicle failed to accelerate as intended and was jerking and vibrating abnormally. The contact stated that the failure was more pronounced after the initial failure. The contact stated that later, the check engine warning light illuminated, and the vehicle was difficult to start. The contact stated that the check engine warning light was orange. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the clutch actuators needed to be replaced. The vehicle was repaired. The contact researched online and related the failure to a problem with the dual clutch transmission installed in the vehicle. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 113,000.

NHTSA complaint #11681796 — an unverified report by a vehicle owner.

POWER TRAIN

The car failed to start, it did not recognize it was in park. After trying to start my car with the keys it failed. My safety is put at risk, my car failing to recognize which gear shift it is in causes malfunctions while I am on the road, especially since I drive long distances at high speeds. I had a Master Technician review and preform a diagnostic on my vehicle and the codes formed for this test matched hand in hand with TCM issues under the TSB. After this, I went to the dealership to discuss this issue and the only thing that came of it was informing me that I was not eligible for a recall due to my VIN, even if I have all the symptoms under the TSB for my Ford Focus 2016. Since my car failed to start I was not able to bring it to Ford and have it tested, especially after asking if it is eligible and they insisted that it was not. No warning signs from the dashboard appeared on my vehicle to inform me of this issue. I travelled to meet with family and did not end up using my vehicle for a few days and when I tried to start my car, it would not engage. The only warning sounds I would consider a correlation before the problem would be a clicking from the starter pre-firing when I opened the door, and while the car was off.

NHTSA complaint #11679525 — an unverified report by a vehicle owner.

POWER TRAIN

It is my transmission problem, there is an engine light on and the shifting is very rough and it also jumps gears, i know ford had a recall for this problem i believe it should be under warranty it is the TCM

NHTSA complaint #11679158 — an unverified report by a vehicle owner.

POWER TRAIN

The contact's son owns a 2016 Ford Focus. The contact stated that while at a stop, the vehicle shuddered while depressing the accelerator pedal. There was no warning light illuminated. The contact then stated that while his son was driving at an undisclosed speed, the message "Transmission Hot - Wait 5 Mins" was displayed on the instrument panel. The contact's son followed the instruction; however, the warning light returned soon after restart the vehicle. Due to the failure, the vehicle was towed to the residence. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 137,000.

NHTSA complaint #11678741 — an unverified report by a vehicle owner.

POWER TRAIN

Transmission Control Module failed and i had that replaced. Now the clutch pack failed and had that replaced. Now it says transmission hot and to pull over. All of this has been recalled on 2012 to 2016 but for some reason my car is not and its the same powershift transmission. Im over 4000 dollars into these repairs and still having problems.

NHTSA complaint #11678425 — an unverified report by a vehicle owner.

POWER TRAIN

The transmission is slipping. Research shows it's a known issue. Ford has acknowledged the issue and extended support. My local ford dealership is refusing to fix the issue even though I fall within the extended service mileage. I called 2 transmission shops who refused to work on this specific model due to the dual clutch design and known problems. Attached is a letter I am disseminating requesting proper assistance with this issue.

NHTSA complaint #11677293 — an unverified report by a vehicle owner.