72 of the
2,368 complaints about the 2013 Ford Fusion are about the
braking system — 3% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
60,726 miles.
While driving home from work. I heard a pop and seen smoke coming from my tire. I pulled over and seen fire behind the wheel. After looking it over the emergency parking brake motor that attaches to the brake caliper was blown apart. The pistons in the caliper pushed so hard against the brake pad that it was bent to a 90 degree angle. Had to replace pads, rotors, and calipers in both sides.
NHTSA complaint #11748680 — an unverified report by a vehicle owner.
Ashville, OH
SERVICE BRAKES
Brakes went out while driving. Brake fluid reservoir is full.
NHTSA complaint #11729166 — an unverified report by a vehicle owner.
Sedalla, MO
SERVICE BRAKES
See attached document for complaint.
NHTSA complaint #11728778 — an unverified report by a vehicle owner.
Forney, TXCrash
SERVICE BRAKES
I was on the highway and a car came in front of me, When I tried to stop the brake was hard and wouldn’t stop! It veered me into the wall and totaled my car. My brakes stiffed up and didn’t stop which cause me to crash.
NHTSA complaint #11688782 — an unverified report by a vehicle owner.
Greenwich, CT
SERVICE BRAKES
Right Front wheel speed Sensor replaced and problem continues due to pigtail coming from wiring harness that connects to top portion of wheel speed sensor Water enters the connector and short circuits the ABS system causing the car to disable ABS,Traction Control and Power steering all light illuminated as well
NHTSA complaint #11658776 — an unverified report by a vehicle owner.
Huntsville, AL
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer scheduled an appointment, but the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11631239 — an unverified report by a vehicle owner.
Albuquerque, NM
SERVICE BRAKES
I received a recall notice for my 2013 Ford Fusion. The Recall was 23S12- Multi Vehicle Front Brake Jounce Hose Leaks. I contacted Ford about the repairs for this recall and was told that the repairs would take 1.3 hours because the brake lines needed to be bled as part of the repair. When I contacted my local Ford dealership about getting the repairs, I was told I would have to leave my vehicle for at least 2 days if I wanted the repairs done. No loaner vehicle has been offered. I cannot be without my car for 2 days. How am I to get the repair work done?
NHTSA complaint #11623231 — an unverified report by a vehicle owner.
at 171,000 milesChesterfield, MI
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact stated that while starting the vehicle, the check engine, ABS, air bags, PCM, and several other unknown warning lights illuminated. The "Engine Coolant Over Temperature" message was displayed. The vehicle was taken to an independent mechanic and the dealer, where it was diagnosed with a coolant leak, but the contact was unaware of what needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Numbers: 12V551000 (Engine and Engine Cooling) and 17V209000 (Engine and Engine Cooling); however, the VIN was not included in the recalls. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 171,000.
NHTSA complaint #11596957 — an unverified report by a vehicle owner.
Wichita, KS
SERVICE BRAKES
Complete computer system is not working, won’t show me how many miles i have, won’t blow out any air. My windows won’t roll down. This happens at least 10 times a year. I put it in drive and it went BACKWARDS as i pressed on the gas pedal and the brake locked up. So i turned it on and off and SAME thing happened.
NHTSA complaint #11588612 — an unverified report by a vehicle owner.
Shepherdsville, KY
SERVICE BRAKES
Power steering assist light appears and you lose power steering which is hard to turn the wheel at all. I’ve had it looked in to and they say it’s a steering problem for years in them models
NHTSA complaint #11578761 — an unverified report by a vehicle owner.
Jamaica Plain, MA
SERVICE BRAKES
Safety Recall 23S12/NHTSA Recall 23V162 - Brake Fluid Leak Took my car in for recall fix. Was told they could not perform the fix for the following reasons: 1) First said it was because I had aftermarket winter tires and rims on it. Told them that once I change to my all-season tires and original rims in 2 weeks can I bring it back, they told me no. 2) Then said it was because the car has 133k miles on it, so said it was too old to work on, and up to dealer discretion (Stoneham Ford, Stoneham, MA) 3) Then said the car has rust underneath so can't work on it. It was just a myriad of excuses as to why they couldn't perform. They said to try another dealer.
NHTSA complaint #11576895 — an unverified report by a vehicle owner.
Des Moines, IA
SERVICE BRAKES
I am receiving warning lights regarding my electronic parking brakes. I took my car to a Ford dealership in Ankeny for a recall on my front brake lines to be fixed and mentioned this to the maintenance dept. They couldn't do anything without putting my car on a scanner (or whatever they do) because, being a widow I did not have the $100 they charge. Thus I am still driving my car with the warning lights on. I hope it is safe for me to drive it.
NHTSA complaint #11551776 — an unverified report by a vehicle owner.
Hudson, NHCrash
SERVICE BRAKES, HYDRAULIC
The contact's employee owned a 2013 Ford Fusion. The contact stated that while the employee was driving at an undisclosed speed, the brake pedal was depressed and went to the floorboard. No warning light was illuminated. The brakes failed to stop the vehicle immediately, causing the employees' vehicle to rear-end another vehicle. No injuries were sustained, and no medical attention was received. A police report was filed. The vehicle was towed to the tow yard, where it was deemed totaled by the insurance company. The employee later received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown.
NHTSA complaint #11533209 — an unverified report by a vehicle owner.
Huntsville, AL
SERVICE BRAKES
Ford send me out a letter about the brake fluid recall on April 2023.i am still waiting for my car to be fixed,I have called them,it is taking to long.
NHTSA complaint #11532295 — an unverified report by a vehicle owner.
Spanish Fork, UT
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact received notifications of NHTSA Campaign Numbers: 17V209000 (Engine and Engine Cooling) and 23V162000 (Service Brakes, Hydraulic) however, the parts to do the recall repair were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11523854 — an unverified report by a vehicle owner.
Cullman, AL
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brake, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11523204 — an unverified report by a vehicle owner.
Grand Rapids, MI
SERVICE BRAKES
I’ve received a letter in March regarding this safety recalls and I not been contacted by the manufacturer for any remedy. I have not had this vehicle for a full six months. Now the break fluids leaks, there’s an issue with a gasket, and I cannot longer drive vehicle due to the smell of something burning. The recall states it’s an increasing risk of a crash. I have to search for transportation to and from work because I refuse to cause harm to myself or others. Safety Risk IF THE BRAKE FLUID LEAKS, YOUR VEHICLE MAY EXPERIENCE AN INCREASE IN BRAKE PEDAL TRAVEL TOGETHER WITH A REDUCTION IN THE RATE OF DECELERATION OVER TIME, INCREASING THE RISK OF A CRASH. Ford should provide another vehicle as a loaner until this issue has been resolved.
NHTSA complaint #11522779 — an unverified report by a vehicle owner.
at 63,000 milesNashville, TN
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact stated while driving at various speeds and depressing the brake pedal, the brake pedal went to the floor. The contact stated that while driving 65 MPH and depressing the brake pedal, the failure reoccurred. The vehicle jerked and failed to respond. The contact exited the highway and continuously depressed the brake pedal, but the brake pedal failed to respond and continuously went to the floor. The contact was able to drive to the residence. The contact stated upon pulling into the driveway, the messages "Brake Fluid Low" and "No Brake Fluid" were displayed. The contact stated that upon towing the vehicle to the dealer, she noticed a trail of brake fluid in the driveway. The contact had received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer diagnosed the vehicle and determined that the failure was related to the recall and informed the contact that she would be charged a repair fee because the recall parts were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 63,000. VIN tool confirms parts not available.
NHTSA complaint #11520587 — an unverified report by a vehicle owner.
Topeka, KS
SERVICE BRAKES
The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 40 MPH, the brake pedal was depressed; however, the vehicle failed to slow down as needed. The contact observed a grinding sound while the brake pedal was depressed. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the brake pads needed to be replaced. The vehicle was repaired; however, the failure reoccurred several times. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulics) however, the part to do the recall repair was unavailable. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11519804 — an unverified report by a vehicle owner.
Topeka, KS
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 40 MPH, the brake pedal was depressed; however, the vehicle failed to slow down as needed. The contact observed a grinding sound while the brake pedal was depressed. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the brake pads needed to be replaced. The vehicle was repaired; however, the failure reoccurred several times. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulics) however, the part to do the recall repair was unavailable. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11519804 — an unverified report by a vehicle owner.
Columbus, GA
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that while coming to a complete stop, the brakes made an abnormal sound. The traction control system warning light was illuminated. Additionally, the contact stated while driving over a bump, a message indicating that Traction Control Unavailable was displayed. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.
NHTSA complaint #11519051 — an unverified report by a vehicle owner.
at 144,206 milesAsbury Park, NJ
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 10 MPH and depressing the brake pedal, the vehicle inadvertently accelerated. The contact veered into a parking lot where the contact pumped the brake pedal until the vehicle stopped. There was no warning light illuminated. The contact observed a moist patch underneath the front of the vehicle after moving the vehicle. The contact also stated that the windows failed to operate after the power window button was depressed. Additionally, the A/C unit was inoperable. The vehicle was taken to a dealer several times to be diagnosed; however, the mechanic was unable to determine the cause of the failure. The system was reset. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11518604 — an unverified report by a vehicle owner.
at 173,000 milesSaint Martinville, LACrash1 injured
SERVICE BRAKES, HYDRAULIC
The contact owned a 2013 Ford Fusion. The contact stated that while driving at 70 mph, the brake pedal was depressed and the pedal remained floored. The vehicle collided with a parked vehicle and then the vehicle was stopped in a ditch. The air bags deployed. The contact sustained right shoulder injuries and received medical attention. There was a police report taken. The vehicle was towed to a salvage lot where it was deemed destroyed. The contact administered brake fluid to the engine compartment approximately ten minutes before the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 173,000.
NHTSA complaint #11518220 — an unverified report by a vehicle owner.
at 157,281 milesMiddletown, MD
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 25 MPH, the vehicle started jerking. The vehicle was pulled over to the side of the road and inspected. The coolant temperature and check engine warning lights were illuminated. The vehicle was towed to an independent mechanic where it was diagnosed, and an unknown hose was replaced. The vehicle was repaired. On another occasion, while attempting to start the vehicle, the vehicle failed to start. The contact stated that the lights in the vehicle were illuminated; however, the vehicle failed to start. The contact became aware that there was antifreeze on the ground underneath the vehicle. The coolant temperature and check engine warning lights were illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 157,281.
NHTSA complaint #11518014 — an unverified report by a vehicle owner.
Suffolk, VA
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulics) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact stated that the husband was driving approximately 25 mph and attempting to come to a stop when the brakes suddenly failed. The brake pedal had floored causing the driver to activate the emergency brake to come to a complete stop. There were no warning lights. The vehicle was towed to the dealer who confirmed that the failure was related to the recall. The manufacturer was not made aware of the issue. The approximate failure mileage was unknown. VIN tool confirms parts are not available.
NHTSA complaint #11517795 — an unverified report by a vehicle owner.
Memphis, TN
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The contact drove the vehicle to a dealer who stated that they would replace front brake flexible hoses only when they failed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11517955 — an unverified report by a vehicle owner.
Waterford, CT
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Services Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11517047 — an unverified report by a vehicle owner.
at 61,452 milesSwanton, OHCrash
SERVICE BRAKES, HYDRAULIC
The contact owns a 2013 Ford Fusion. The contact stated while driving approximately 15 MPH and slowing for a traffic light she depressed the brake pedal, the vehicle did not slow and she crashed into the rear end of the vehicle in front of her. The contact stated no warning light was illuminated. The damage was mild and both vehicles were able to drive away, there were no injuries. The police were on the scene, however, the contact is not sure if a report had been written. The contact had taken the vehicle to an independent mechanic prior to the crash, where it was diagnosed and determined that the rotors and brakes in both the front and rear of the vehicle needed to be replaced. The vehicle had been repaired. The contact stated that she was hearing an abnormal squealing noise when she depresses the brake pedal. The manufacturer had been informed of the failure. The failure mileage was 61,452.
NHTSA complaint #11517081 — an unverified report by a vehicle owner.
at 151,363 milesCharleston, WVCrash1 injured
SERVICE BRAKES, HYDRAULIC
The contact owned a 2013 Ford Fusion. The contact stated that while his daughter was driving at approximately 30-40 MPH, another vehicle driving in the opposite direction made an illegal turn. The contact's daughter depressed the brake pedal to avoid colliding with the other vehicle; however, the brakes failed to engage, and the contact's vehicle crashed into the other vehicle. No warning lights were illuminated. The air bags did not deploy upon impact. The contact's daughter suffered injuries to her head, neck, and back and was transported by ambulance to the hospital. A police report was filed. The vehicle was towed to a tow yard, where it was deemed totaled by the insurance company. The contact later received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic). The manufacturer was not made aware of the failure. The failure mileage was 151,363.
NHTSA complaint #11517109 — an unverified report by a vehicle owner.
Tonawanda, NY
SERVICE BRAKES
When hitting brakes my car pulls to the right , it happens occasionally not often
NHTSA complaint #11515061 — an unverified report by a vehicle owner.