2023 Ford Maverick transmission problems

POWER TRAIN

When throttling or under load, significant vibration of the car. Possibly CV axle problem.

NHTSA complaint #11740902 — an unverified report by a vehicle owner.

POWER TRAIN

During acceleration from 40-60 miles per hour, there was a pronounced vibration/shudder through the front end of the vehicle. After taking it to the dealership, they advised both front axles would need to be replaced. The catastrophic failure of an axle is likely to cause a car crash. The problem has been identified by Ford Motor Company and also confirmed by the Ford Dealership where I got it fixed. Ford Motor Company issued Customer Satisfaction Program 25N09 On September 17, 2025. My vehicle is a 2023 model year, but produced at the same plant and in the same time frame as the the ones mentioned in 25N09. There were no warning lamps or messages about the problem. The only indication was the heavy vibration a few thousand miles prior to getting it looked at.

NHTSA complaint #11736287 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the steering wheel started shaking, prompting the contact to pull over to the side of the road. The vehicle was pulled over, and a squealing, clicking, and grinding sound started coming from the vehicle. The vehicle was taken to the dealer on three separate occasions and was diagnosed with a CV shaft failure. The manufacturer was not notified of the failure. The approximate failure mileage was 10,000.

NHTSA complaint #11733525 — an unverified report by a vehicle owner.

POWER TRAIN

Vehicle started to have a shake under acceleration. Reported it to multiple dealerships and requested them to specifically observe the CV axles. Finally secured an appointment on 11-24-2025 while vehicle was under factory warranty. Tenvoorde Ford informed me (the owner) that the CV axles were “fine” and a non issue. Shake was still present. Kept driving the vehicle and now, five months later with no factory warranty left on the vehicle, shake still present, and received a second opinion today. CV axle needs replacement. ~68,000 miles on the odometer. I exclusively commute on interstate 94 in central Minnesota, hardly drive in cities. There is no justifiable reason when the vehicle was at the dealership that the CV axle went from being just fine to needing replacement. This is a very common concern with these Ford Mavericks and Ford needs to conduct a recall before people get injured on the public roadways.

NHTSA complaint #11731420 — an unverified report by a vehicle owner.

POWER TRAIN

CV axle fails prematurely, causing vehicle shaking under acceleration, and potentially unsettling vehicle stability at speed. First noticed the shaking at 49K miles. I have not had an opportunity to schedule an appointment with the dealer to have it replaced yet. This is a known issue on these vehicles that Ford has not acknowledged, with many drivers reporting they need the CV axles replaced ever 30k miles or so.

NHTSA complaint #11726541 — an unverified report by a vehicle owner.

POWER TRAIN

CV axles are covered under the Ford Powertrain Warranty. I am experiencing a driveline vibration consistent with axle failure. I would like a warranty diagnosis and documentation explaining why this is not considered a warrantable defect. Dealerships are refusing to evaluate a powertrain warranty issue involving driveline vibration consistent with axle failure. The vehicle exhibits driveline vibration under normal operation. That is not normal function and indicates a defect under warranty terms. Powertrain issues with axles present a safety concern. I see Ford has superseded the original NZ6Z axle part numbers to SZ6Z and now PZ6Z revisions. That indicates a known issue with earlier components. My vehicle is exhibiting the exact failure symptoms—this should be evaluated under powertrain warranty.

NHTSA complaint #11725681 — an unverified report by a vehicle owner.

POWER TRAIN

Vehicle "shakes and vibrates" when accelerating along with odd clicking noises when turning. The sunroof also leaks during car washes.

NHTSA complaint #11717721 — an unverified report by a vehicle owner.

POWER TRAIN

Battery goes into deep sleep truck will not crank this the 3rd time for this truck.

NHTSA complaint #11713200 — an unverified report by a vehicle owner.

POWER TRAIN

I took my vehicle in to have the transmission looked at. The dealership told me that the problem was resolved. While driving down the road the transmission went into park in the middle of a two lane road. When the vehicle came to a complete stop I was stopped in the middle of the lane and the vehicle transmission would not shift out of park. After getting it to another shop where it is currently located I was informed that the transmission needs to be replaced and that this is a problem that they are seeing in several Ford vehicles. I contacted Ford who stated that there are no current recalls for this problem. Obvious safety concerns are not being able to control the vehicle when it shifts to park while driving as well as being stopped in the middle of the roadway where a collision is likely.

NHTSA complaint #11688266 — an unverified report by a vehicle owner.

POWER TRAIN

CV axles failed at 30,000 miles, repaired under warranty. Replaced axles have failed again at 60,000 miles, no warranty. No hard driving, simply highway miles. This seems to be common in these vehicles and need to be recalled for defective parts. This has caused me poor fuel mileage, damage to new tires, instability while driving, and possible unknown damage to transaxle.

NHTSA complaint #11683637 — an unverified report by a vehicle owner.

POWER TRAIN

While driving on the highway at normal speed in normal conditions, I suddenly lost ABS, traction control, downhill assist, hold assist, AdvanceTrac, Cruise control, and a severe reduction of power. The engine went into limp mode and would not rev past 3k RPM. This made driving on the highway very dangerous as I could not keep up speed and risked getting rear-ended. The wrench icon came on, as well as ABS and traction control. Cruise control would not work. Messages appeared stating "Service engine soon", "Service AdvanceTrac", "Downhill assist issue", "Hold assist issue", and a few more I can't recall. Sometimes they go away on its own and the vehicle works fine, sometimes restarting the vehicle clears the issue. The issues will appear randomly, sometimes very soon after starting the car and driving, sometimes 100 miles later.

NHTSA complaint #11671480 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

The contact owns a 2023 Ford Maverick. The contact stated while driving at various speeds and attempting to depress the brake pedal, the brakes made a loud screeching sound and the vehicle surged forward before coming to a complete stop. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was advised that the passenger’s side axle was faulty and needed to be replaced. The vehicle was repaired, however the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 50,000.

NHTSA complaint #11666056 — an unverified report by a vehicle owner.

POWER TRAIN

I bought a pre-owned "Gold Certified" 2023 Ford Maverick from a Ford dealer. The vehicle had around 32,000 or so miles at purchase. Soon after purchase, discovered that while accelerating from around 50-60 mph, the front end of the vehicle started heavily shaking without warning. The vehicle was taken to the Ford dealer who informed us that both front axles needed to be replaced. They informed us that they have seen this issue with other Ford Mavericks. The repairs were covered under warranty, and nobody was injured. This is an unsettling, since I have seen on this website numerous complaints about this same issue. Yet there has not been a TSB or recall to my knowledge.

NHTSA complaint #11660997 — an unverified report by a vehicle owner.

POWER TRAIN

Bad CV axles causing vibration while accelerating.

NHTSA complaint #11652687 — an unverified report by a vehicle owner.

POWER TRAIN

I recently reported my Ford maverick for the failure of the front right CV joint/axle at 22k miles. Well when I picked it up from Ford. They notified me that the front left is also bad. And I'm at 23k miles. These are clearly an issue that's happening everywhere.

NHTSA complaint #11646623 — an unverified report by a vehicle owner.

POWER TRAIN

The cv joint axles are failing. No axles on a new car or truck should EVER fail under 100k miles. Ford maverick axles are failing at under 50k miles. And mine failed at 22k miles. And Ford will only replace 1 at a time. Not only is this a manufacturer defect that can cause accidents or injury but Ford needs to yet again be held accountable. No one pays good money for a factory faulty vehicle.

NHTSA complaint #11645445 — an unverified report by a vehicle owner.

POWER TRAIN

23,450 miles today for an oil change. Both CV are bad. Drivers side is terrible with no parts eta. Passages is leaking grease and about to go as well per the tech. That is not the first I’ve heard of this but at 23,000 miles is insane. This could cause an accident if failing while turning.

NHTSA complaint #11634149 — an unverified report by a vehicle owner.

POWER TRAIN

Traveling 350 miles for work, my Maverick was at 2400 miles when both of my front cv boots were spewing grease all over the underside of the truck, stranding me away from home. The truck would shake violently when accelerating to the point I had to pull over. With all the destruction on the underside of the truck, the local dealer (not preferred) informed me that “they didn’t know who or when” but a missing clamp on one side and a torn boot on the other and denied me from claiming my warranty at 2400 miles. There were no warning lights on the dash at any time.

NHTSA complaint #11592535 — an unverified report by a vehicle owner.