76 of the
466 complaints filed about the Ford Maverick
are about the electrical system —
16% of everything owners reported.
The worst model year for it is 2022.
The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11758093 — an unverified report by a vehicle owner.
I was driving with some gravel in the back and the trailer sway control came on causing it to brake and almost lose control on the interstate in front of a semi. This. Vehicle has never had a trailer attached and the nothing in the trailer plug and that still came on.
NHTSA complaint #11757941 — an unverified report by a vehicle owner.
A year ago while driving on the interstate, my Ford Maverick suddenly threw a "Stop Safely Now" alert. I was able to turn the ignition off and back on to safely exit the highway. The alert came back once I made it to a parking lot and stuck around for a while. I was able to get it started and drove to a Ford dealership that told me it was just a software update. The same issue happened 2 more times before I made it to my destination after leaving the dealership, showing that it actually wasn't caused by a missed software update. Returning from my trip it happened 4th time. Afterward, the issue seemed to go away. Now a year later I got in the Maverick to leave work and the alert came back. I was not able to get it started and will attempt to get it over to a Ford dealership tomorrow to be seen for what seems to be the same issue, only worse if it still is not starting in the morning.
NHTSA complaint #11746575 — an unverified report by a vehicle owner.
Description On your vehicle, the instrument panel ip upper section may detach from the passenger air bag chute doors during air bag deployment. The airbag is expected to otherwise deploy in position and restrain the occupant as designed. Safety Risk In the event of a crash in which the vehicle deploys the passenger airbag, a part of the ip upper section may detach and strike a vehicle occupant, increasing the risk of injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to replace the ip upper section free of charge. Next Steps Contact your dealer for more information to schedule the free service.
NHTSA complaint #11744344 — an unverified report by a vehicle owner.
My 2023 Ford Maverick Hybrid experienced repeated 12V battery discharge and “Deep Sleep” events associated with Recall 24C01 and SSM 53801. The vehicle repeatedly discharged the 12V battery while parked under normal conditions. In January 2026, after approximately two weeks parked in freezing temperatures, the battery experienced a complete discharge and the vehicle required multiple jump-starts to remain operational. Ford dealer records later confirmed that the corrective action associated with SSM 53801 had not been applied prior to the failure event despite prior complaints and service visits. The repeated discharge events resulted in failure of both: the original factory battery, and a replacement AGM battery installed at owner expense. This condition created repeated stranded events and loss of vehicle reliability. I am submitting this complaint because the issue appears directly related to documented parasitic drain conditions already acknowledged by Ford in Recall 24C01 and SSM 53801, and because the failure condition persisted before corrective action was finally applied.
NHTSA complaint #11737841 — an unverified report by a vehicle owner.
I was trying to turn and the wheel kept kicking back the other direction. About a week prior to this as I was driving down the road all of a sudden the wheel threw me across a median and into incoming traffic almost causing multiple accidents. I have a video of it but it won’t allow me to upload it. [XXX] However this link should play it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11737585 — an unverified report by a vehicle owner.
When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shouldn’t be any reason for this be happening loss of power loss of electrical display and distribution finally I just had to replace the battery on my own because they refused to accept responsibility 4-6 months later a recall for the batteries was issued. The axles on the truck are not sufficient and they are not taking care of it properly! I would also like to report that they cut so many corners on the Maverick that the tailgate just drops no shock absorber nothing just slams on the bumper very dangerous! & They also chose to leave many open” holes” where mud rocks , leaves etc get into the front quarter panels from the hood area at the corner of windshield . So this wet material gets trapped in there n I’m sure will eventually affect the structural integrity of the panel - maybe rust through! Same thing happens with the tailgate fills with debris from bed , rear wheel wells also have a whole. I just wish ford would go back to how Henry Ford ran the company ! Help NHTSA
NHTSA complaint #11736807 — an unverified report by a vehicle owner.
"Powertrain System Fault" was given from App, "service engine soon" on dash along with check engine light and "wrench". Dealership said Hybrid battery needs replaced. Dealership said "We don't know what the battery issue will effect if it does go bad." Corporate says "wear and tear item after 36000 miles or 3 years". I have also had to replace the 12V battery this year. I do not see how both batteries can "go bad" within 4 years of manufacturing... Online says truck could go into limp mode with no warning. Truck is available for inspection upon request. If truck will go into limp mode with no warning, could cause many safety issues. Problem initially occurred 3 days ago. Dealership cleared codes and has not happened again. Vehicle has only been inspected by dealership Only issue with electrical before EV battery was the 12V battery that went bad and had to be replaced. Went to start up the truck one afternoon (had been driving all day before this) and the lights on the dash popped on and the "Service Engine Soon" popped up and beeped. Drove it home that Saturday and did not drive it until dropped it off at dealership Monday morning. There must be something electrically causing problems since I just replaced my 12V battery about 6 months ago and now the EV battery is "bad". I've never heard of a Ford 12V battery not lasting at least 8 years. Multiple people I know have original 12V batteries in vehicles 2018 and older... Batteries should not be considered a "wear and tear item" batteries should be covered under their own warranties. Having basically no warranty on batteries poses a severe health risk with the disposal and creation of the old and new batteries.
NHTSA complaint #11732652 — an unverified report by a vehicle owner.
When the battery voltage suddenly drops the vehicle loses its power steering making slow speed turns extremely difficult. This poses a serious risk of the inability to control the direction of the vehicle and this makes a crash extremely probable.
NHTSA complaint #11732082 — an unverified report by a vehicle owner.
The passenger side floor is soaking wet every time it rains. Google says this is a defect with the windshield cowl, which other owners say is a common problem. Our safety is at risk with potential for mold, rust, and water intrusion into the electrical system. The truck is going to the dealership on Monday to have this issue addressed. It has been reproduced every time it rains. It has not been inspected by anyone other than myself. There were no warnings or alerts. We've noticed the wet carpet a couple times and researched the problem.
NHTSA complaint #11728937 — an unverified report by a vehicle owner.
The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the brake lights and turn signals failed to function as intended. In addition, the message “Brake Light Failure” was displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure, and the contact was informed that the parts were not available to repair the vehicle. The contact received notification of NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, parts were unavailable for the recall repair. The contact's husband purchased and replaced the light bulbs lights. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that there was no assistance available. The failure mileage was approximately 50,000.
NHTSA complaint #11726645 — an unverified report by a vehicle owner.
I am reporting a recurring safety-critical failure. On two separate occasions, the vehicle has experienced a total electrical and mechanical shutdown while in operation. During these events, the 12V power system fails completely, turning off all instrumentation and, most critically, the electronic power brake assist. This results in a 'hard pedal' condition where the vehicle is nearly impossible to stop without extreme physical force. The first instance occurred at road speeds, forcing an emergency maneuver into a turning lane to avoid traffic. The second instance occurred while reversing, causing the vehicle to lose all braking and propulsion and roll into a busy road resulting in a near-miss collision. The vehicle is currently unsafe to drive as the shutdowns are intermittent and occur without warning.
NHTSA complaint #11726612 — an unverified report by a vehicle owner.
Per a video posted on LinkedIn on March 20, 2026 by Chris Hackney, a Fountainhead Logistics Class 8 tractor displaying a Texas License plate on the front bumper & equipped with the Kodiak Robotics "Kodiak Driver" autonomous system was pulling three 40' belly dump trailers used to transport frac sand on an unknown public roadway in the West Texas Permian Basin in violation of Texas State law which prohibits triple trailers on public roadways. I can't confirm that the movement of the triple trailers shown in the video actually occurred on a public roadway vs a private lease road in the oil & natural gas fields where Fountainhead Logistics operates. I request NHTSA reach out to Fountainhead Logistics &/or Kodiak Robotics to confirm if such alleged illegal movement was made on a public roadway.
NHTSA complaint #11726022 — an unverified report by a vehicle owner.
My 2022 Ford Maverick Hybrid experienced a complete electrical system failure at approximately 15,933 miles, resulting in a no-start condition. The failure involved the vehicle’s electrical distribution system. An authorized Ford dealership (Autos Vega Ford) diagnosed that voltage was not reaching the Body Control Module (BCM) due to a fault in the battery cable and wiring system. The repair required replacement of the 12V battery, high-voltage battery cables, and wiring components. The failure was confirmed by the dealership (Autos Vega Ford) and required multiple jump starts, but the vehicle would not consistently restart after being turned off. There were no prior warning indicators before the failure. The issue occurred suddenly without warning. This failure created a safety risk because the vehicle could not be started or operated. If this failure occurred in an unsafe or remote location, it could leave occupants stranded and unable to move the vehicle. Service records are available through the authorized dealership (Autos Vega Ford). This appears to be a premature electrical system failure at low mileage involving critical components such as battery cables and wiring. Similar issues involving electrical systems, battery defects, and wiring faults have been reported in Ford Maverick Hybrid vehicles. The vehicle became inoperable without warning and required towing/assistance to reach a repair facility. A sudden no-start condition in a hybrid vehicle can create hazardous situations if it occurs in traffic, at intersections, or in remote areas where assistance is not immediately available.
NHTSA complaint #11725172 — an unverified report by a vehicle owner.
I was driving and the vehicle stopped like it was in neutral. I started rolling backwards into a vehicle. He honked and I slammed on breaks. I put flashers on. Waited a bit. Turned off and on and it started. I drove home and called service dept
NHTSA complaint #11724339 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was informed by another driver that the trailer brake lights were not illuminated while the vehicle was stopped. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,700. The VIN was not available.
NHTSA complaint #11721686 — an unverified report by a vehicle owner.
When driving at normal speed, my truck completely shut down with no warning. The instrument panel went dark and the engine shut off. I do not believe I was able to steer, though I think the brakes allowed me to slow the vehicle to a stop. I was near an intersection, so I was lucky to not have been hit from the rear or run in to traffic in front of me. The vehicle was unresponsive and would not turn back on. I was stuck blocking 1 lane of traffic for an hour because the vehicle could not be steered or taken out of gear to push it to the side of the road. I inspected the battery connection and nothing seemed out of place or degraded while trying to get the car out of the road. Highway Patrol also looked, but only was able to offer a tow truck as a solution. My truck has been at the dealer service for almost 2 days awaiting inspection at this point so I have no additional information on what caused this dangerous situation. There had been no indication prior, the truck had started and run normally and all scheduled services had been carried out by the dealer up to this point.
NHTSA complaint #11720345 — an unverified report by a vehicle owner.
Hybrid Ford Maverick electrical system began to go into a save battery mode -no interior lights, only driver side door operated, and other system failures. Dealer replaced battery under warranty and general recall for this issue. A few months later same characteristics started showing up -interior lights not working, only driver's side door operational, etc. This time the warranty had expired and the dealer, along with Ford Motor, told me any repairs would be at my expense, 100%. I feel problem was never resolved, even with replacement battery. Ford and dealer should address this problem. I'm sure I'm not the only one with this battery and electrical issue. After all, there was a full recall for the battery failure. Having no interior lights, unable to enter except driver's side, and other manifestations are inherently unsafe.
NHTSA complaint #11719477 — an unverified report by a vehicle owner.
I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.
NHTSA complaint #11718278 — an unverified report by a vehicle owner.