231 of the
665 complaints about the 2021 Ford Mustang Mach E are about the
driver-assist systems — 35% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
3,800 miles.
D
231
Complaints
4
Crashes
0
Fires
1
Injuries
Exactly what failed
Warnings
8135.1%
Adaptive Cruise Control
7130.7%
Automatic Emergency Braking
3615.6%
Assist
187.8%
Warning
93.9%
Blind Spot Detection
62.6%
Warnings
62.6%
Back Over Prevention
10.4%
Forward Collision Avoidance
10.4%
Camera
10.4%
Driver Assist & Collision Avoidance across every Ford Mustang Mach E year
Vehicle: 2021 Ford Mustang Mach-E VIN: [XXX] Mileage: 56,005 I am filing this complaint to bring to NHTSA's attention a safety concern regarding Ford Motor Company's decision to make the Blue Cruise driver-assistance system available only via a paid subscription beginning January 2027, at a cost of $49.99 per month. Blue Cruise is a hands-free highway driving assistance system — a Level 2 driver-assistance safety technology. The hardware enabling this system was installed in my vehicle at the time of purchase and was represented as a feature of the vehicle. Ford is now moving to disable this safety feature on existing, in-service vehicles unless owners pay an ongoing subscription fee. I respectfully request that NHTSA examine whether a manufacturer's ability to remotely disable or withhold active safety technology on vehicles already in service — technology that was sold as part of the vehicle — raises concerns under federal motor vehicle safety standards. Specifically: 1. Consumers purchased these vehicles with the reasonable expectation that installed safety hardware would remain functional. 2. Ford's decision to monetize this feature post-sale, on vehicles already in service, effectively degrades the safety capability of those vehicles for owners who cannot or will not pay. 3. The precedent this sets — manufacturers using over-the-air software controls to disable safety features for revenue — warrants regulatory attention. I am not alone in this concern. There are thousands of Blue Cruise-equipped Mustang Mach-E, F-150, and Expedition owners facing this same situation. I respectfully ask NHTSA to investigate whether Ford's subscription model for Blue Cruise is consistent with federal vehicle safety obligations, and whether any regulatory guidance is warranted to protect consumers from the post-sale removal of safety technology. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745591 — an unverified report by a vehicle owner.
Merritt, NC
FORWARD COLLISION AVOIDANCE: WARNINGS
Vehicle: 2021 Ford Mustang Mach-E VIN: [XXX] Mileage: 56,005 I am filing this complaint to bring to NHTSA's attention a safety concern regarding Ford Motor Company's decision to make the Blue Cruise driver-assistance system available only via a paid subscription beginning January 2027, at a cost of $49.99 per month. Blue Cruise is a hands-free highway driving assistance system — a Level 2 driver-assistance safety technology. The hardware enabling this system was installed in my vehicle at the time of purchase and was represented as a feature of the vehicle. Ford is now moving to disable this safety feature on existing, in-service vehicles unless owners pay an ongoing subscription fee. I respectfully request that NHTSA examine whether a manufacturer's ability to remotely disable or withhold active safety technology on vehicles already in service — technology that was sold as part of the vehicle — raises concerns under federal motor vehicle safety standards. Specifically: 1. Consumers purchased these vehicles with the reasonable expectation that installed safety hardware would remain functional. 2. Ford's decision to monetize this feature post-sale, on vehicles already in service, effectively degrades the safety capability of those vehicles for owners who cannot or will not pay. 3. The precedent this sets — manufacturers using over-the-air software controls to disable safety features for revenue — warrants regulatory attention. I am not alone in this concern. There are thousands of Blue Cruise-equipped Mustang Mach-E, F-150, and Expedition owners facing this same situation. I respectfully ask NHTSA to investigate whether Ford's subscription model for Blue Cruise is consistent with federal vehicle safety obligations, and whether any regulatory guidance is warranted to protect consumers from the post-sale removal of safety technology. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745591 — an unverified report by a vehicle owner.
Vehicle: 2021 Ford Mustang Mach-E VIN: [XXX] Mileage: 56,005 I am filing this complaint to bring to NHTSA's attention a safety concern regarding Ford Motor Company's decision to make the Blue Cruise driver-assistance system available only via a paid subscription beginning January 2027, at a cost of $49.99 per month. Blue Cruise is a hands-free highway driving assistance system — a Level 2 driver-assistance safety technology. The hardware enabling this system was installed in my vehicle at the time of purchase and was represented as a feature of the vehicle. Ford is now moving to disable this safety feature on existing, in-service vehicles unless owners pay an ongoing subscription fee. I respectfully request that NHTSA examine whether a manufacturer's ability to remotely disable or withhold active safety technology on vehicles already in service — technology that was sold as part of the vehicle — raises concerns under federal motor vehicle safety standards. Specifically: 1. Consumers purchased these vehicles with the reasonable expectation that installed safety hardware would remain functional. 2. Ford's decision to monetize this feature post-sale, on vehicles already in service, effectively degrades the safety capability of those vehicles for owners who cannot or will not pay. 3. The precedent this sets — manufacturers using over-the-air software controls to disable safety features for revenue — warrants regulatory attention. I am not alone in this concern. There are thousands of Blue Cruise-equipped Mustang Mach-E, F-150, and Expedition owners facing this same situation. I respectfully ask NHTSA to investigate whether Ford's subscription model for Blue Cruise is consistent with federal vehicle safety obligations, and whether any regulatory guidance is warranted to protect consumers from the post-sale removal of safety technology. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745591 — an unverified report by a vehicle owner.
Scotts Valley, CA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The front camera system does not function which causes all forward collision safety features to become unavailable, as well as any cruise control or automatic high beam lights. Seems to be a common issues and is related to faulty fiber optic cables.
NHTSA complaint #11744862 — an unverified report by a vehicle owner.
The front camera system does not function which causes all forward collision safety features to become unavailable, as well as any cruise control or automatic high beam lights. Seems to be a common issues and is related to faulty fiber optic cables.
NHTSA complaint #11744862 — an unverified report by a vehicle owner.
Scotts Valley, CA
FORWARD COLLISION AVOIDANCE: WARNINGS
The front camera system does not function which causes all forward collision safety features to become unavailable, as well as any cruise control or automatic high beam lights. Seems to be a common issues and is related to faulty fiber optic cables.
NHTSA complaint #11744862 — an unverified report by a vehicle owner.
Syosset, NY
FORWARD COLLISION AVOIDANCE: WARNINGS
This is a safety issue. The front collision assist is not working. I have returned the car to the Ford Dealer (Biener Ford) several times but the dangerous issue persists. I'm not the only one. There are many complaints listed on the web and the Ford Mach E forum. Ford needs to recall their EV Ford Mach-E vehicles and fix this dangerous safety issue once and for all.
NHTSA complaint #11740320 — an unverified report by a vehicle owner.
Kingman, AZ
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The car gives two messages, "Front Camera Fault Service Required" and "Pre-Collision assist not available." The cruise control does not work, however, the front camera does work. I had the vehicle scan done at the Ford dealer and was told it needs a 7 hour software update, after which it may need cables replaced. I do not understand how software goes bad. I do understand something may have happened to cables but that would not be checked until they had charged me $ 1,400 for a software update. This is a safety issue and, from what I read on the Mach E forum, is not where near unique to my vehicle.
NHTSA complaint #11736423 — an unverified report by a vehicle owner.
Kingman, AZ
FORWARD COLLISION AVOIDANCE: WARNINGS
The car gives two messages, "Front Camera Fault Service Required" and "Pre-Collision assist not available." The cruise control does not work, however, the front camera does work. I had the vehicle scan done at the Ford dealer and was told it needs a 7 hour software update, after which it may need cables replaced. I do not understand how software goes bad. I do understand something may have happened to cables but that would not be checked until they had charged me $ 1,400 for a software update. This is a safety issue and, from what I read on the Mach E forum, is not where near unique to my vehicle.
NHTSA complaint #11736423 — an unverified report by a vehicle owner.
Pleasant Hill, CA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Vehicle: 2021 Ford Mustang Mach-E Component: Image Processing Module A (IPMA) / Front Camera / Forward Collision Avoidance System The IPMA and front camera system have failed, disabling Pre-Collision Assist, AEB, forward collision warning, and adaptive cruise control while driving. The vehicle is available for inspection upon request. Warning messages "Front Camera Fault Service Required" and "Pre-Collision Assist Not Available" first appeared August 24, 2022 and have recurred consistently over nearly four years. No accident, physical damage, or obstruction was present at any occurrence. This failure puts safety at risk by silently disabling AEB and forward collision warning during normal driving — systems a driver may depend on in an emergency braking situation with no advance notice they are unavailable. The problem was confirmed by a Ford dealership in February 2026. Their repair order documents: "RAN IPMA SELF TEST AND FOUND DTC SET U3000-49... HARDWARE TEST FAILED... FOUND TSB RELATED REC REPLACE MODULE." The dealer contacted Ford, who authorized 50% off the module replacement only, characterizing it as a "loyal customer discount" rather than a warranty or goodwill repair. I declined to pay for the fix. NHTSA Campaign 11028164 (superseding TSB 25-2156) covers this exact failure. Ford's own TSB acknowledges the defect and the dealer confirmed it applies to my vehicle, yet owners are being quoted up to $8,000 for a known safety system failure. I'm requesting NHTSA investigate whether this warrants a recall. First occurrence: August 24, 2022 (mileage not recorded) Service visit: February 17-18, 2026 at 80,029 miles Current mileage: 83,988 Attachments: photos of both fault messages, dealer invoice
NHTSA complaint #11734458 — an unverified report by a vehicle owner.
Pleasant Hill, CA
FORWARD COLLISION AVOIDANCE: WARNINGS
Vehicle: 2021 Ford Mustang Mach-E Component: Image Processing Module A (IPMA) / Front Camera / Forward Collision Avoidance System The IPMA and front camera system have failed, disabling Pre-Collision Assist, AEB, forward collision warning, and adaptive cruise control while driving. The vehicle is available for inspection upon request. Warning messages "Front Camera Fault Service Required" and "Pre-Collision Assist Not Available" first appeared August 24, 2022 and have recurred consistently over nearly four years. No accident, physical damage, or obstruction was present at any occurrence. This failure puts safety at risk by silently disabling AEB and forward collision warning during normal driving — systems a driver may depend on in an emergency braking situation with no advance notice they are unavailable. The problem was confirmed by a Ford dealership in February 2026. Their repair order documents: "RAN IPMA SELF TEST AND FOUND DTC SET U3000-49... HARDWARE TEST FAILED... FOUND TSB RELATED REC REPLACE MODULE." The dealer contacted Ford, who authorized 50% off the module replacement only, characterizing it as a "loyal customer discount" rather than a warranty or goodwill repair. I declined to pay for the fix. NHTSA Campaign 11028164 (superseding TSB 25-2156) covers this exact failure. Ford's own TSB acknowledges the defect and the dealer confirmed it applies to my vehicle, yet owners are being quoted up to $8,000 for a known safety system failure. I'm requesting NHTSA investigate whether this warrants a recall. First occurrence: August 24, 2022 (mileage not recorded) Service visit: February 17-18, 2026 at 80,029 miles Current mileage: 83,988 Attachments: photos of both fault messages, dealer invoice
NHTSA complaint #11734458 — an unverified report by a vehicle owner.
Methuen, MA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The front camera has failed and it is available for inspection upon request. The safety of myself and everyone in my car is at risk when the pre-collision assist is not available due to this components failure. Yes, it is a daily occurrence and the camera never stays on for long. A fix was attempted once by a dealer. The component has not been inspected by either of those parties. Only the dealer whom the car was purchased from. Yes, warning messages pop up every time in the car and in the phone app about the issue. They first appeared before car purchase when the dealer fixed it in early February. Then it resumed again in late February/March.
NHTSA complaint #11728154 — an unverified report by a vehicle owner.
Methuen, MA
LANE DEPARTURE: ASSIST
The front camera has failed and it is available for inspection upon request. The safety of myself and everyone in my car is at risk when the pre-collision assist is not available due to this components failure. Yes, it is a daily occurrence and the camera never stays on for long. A fix was attempted once by a dealer. The component has not been inspected by either of those parties. Only the dealer whom the car was purchased from. Yes, warning messages pop up every time in the car and in the phone app about the issue. They first appeared before car purchase when the dealer fixed it in early February. Then it resumed again in late February/March.
NHTSA complaint #11728154 — an unverified report by a vehicle owner.
Methuen, MA
FORWARD COLLISION AVOIDANCE: WARNINGS
The front camera has failed and it is available for inspection upon request. The safety of myself and everyone in my car is at risk when the pre-collision assist is not available due to this components failure. Yes, it is a daily occurrence and the camera never stays on for long. A fix was attempted once by a dealer. The component has not been inspected by either of those parties. Only the dealer whom the car was purchased from. Yes, warning messages pop up every time in the car and in the phone app about the issue. They first appeared before car purchase when the dealer fixed it in early February. Then it resumed again in late February/March.
NHTSA complaint #11728154 — an unverified report by a vehicle owner.
Potomac, MD
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
An error message intermittently pops up on my vehicle that says, "Front Camera Fault", causing collision assistance and adaptive cruise control to suddenly stop working. This is a major safety issue, as a failure of adaptive cruise control while under operation may lead to a risk of an accident. Ford is aware of this issue and has issued TSB 23-2155, but they are treating it like a standard repair and not covering vehicles out of warranty. This should be a safety recall. See here for many others with the same issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11726068 — an unverified report by a vehicle owner.
Potomac, MD
FORWARD COLLISION AVOIDANCE: WARNINGS
An error message intermittently pops up on my vehicle that says, "Front Camera Fault", causing collision assistance and adaptive cruise control to suddenly stop working. This is a major safety issue, as a failure of adaptive cruise control while under operation may lead to a risk of an accident. Ford is aware of this issue and has issued TSB 23-2155, but they are treating it like a standard repair and not covering vehicles out of warranty. This should be a safety recall. See here for many others with the same issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11726068 — an unverified report by a vehicle owner.
Ann Arbor, MI
BACK OVER PREVENTION: WARNINGS
The backup camera and 360 view stopped working, and the reverse break assist is not available when placing the vehicle in reverse. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11706917 — an unverified report by a vehicle owner.
Ann Arbor, MI
FORWARD COLLISION AVOIDANCE: WARNINGS
The backup camera and 360 view stopped working, and the reverse break assist is not available when placing the vehicle in reverse. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11706917 — an unverified report by a vehicle owner.
Ann Arbor, MI
LANE DEPARTURE: BLIND SPOT DETECTION
The backup camera and 360 view stopped working, and the reverse break assist is not available when placing the vehicle in reverse. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11706917 — an unverified report by a vehicle owner.
Anaheim, CA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The car would intermittently give an error saying pre-collision assist not available and now this error is permanent. There is a technical service bulletin for it 23-2155 Lots of people have been complaining about this in the mach e forum https://www.macheforum.com/site/threads/front-camera-fault-pre-collision-assist-not-available-errors.18710/page-69#post-1026803 This causes people to drop out from the automatic driving bluecruise without notice and adaptive cruise control becomes unusable.
NHTSA complaint #11695140 — an unverified report by a vehicle owner.
The car would intermittently give an error saying pre-collision assist not available and now this error is permanent. There is a technical service bulletin for it 23-2155 Lots of people have been complaining about this in the mach e forum https://www.macheforum.com/site/threads/front-camera-fault-pre-collision-assist-not-available-errors.18710/page-69#post-1026803 This causes people to drop out from the automatic driving bluecruise without notice and adaptive cruise control becomes unusable.
NHTSA complaint #11695140 — an unverified report by a vehicle owner.
Wichita, KS 67206, KSCrash
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
There are many reports of the Mustang Mach E "accelerating unexpectedly." This usually happens in parking lots or other situations involving low speed and a rapid turn of the wheel. I know exactly what the problem is, because it happened to me this morning. While parking in my parking garage, my car rapidly accelerated uphill and I only narrowly avoided hitting a wall. Here is why: There are two interconnected problems. The first is that the "cruise control on/off" button is located on the far left of the interior of the steering wheel, which makes it easy to accidentally press when doing a sharp, quick one-handed turn of the wheel (like when parking). When this happens, CC engages while in the act of parking. This is exactly what happened to me. I accidentally hit the button while doing a sharp twist of the wheel, I saw the CC engage, the car rapidly accelerated uphill without my foot on the gas pedal, and I would have hit the wall in front of me if I had been a split-second slower in hitting the brake. The second problem is that there is supposed to be a failsafe for accidentally activating CC at low speed, BUT IT DOESN'T ALWAYS WORK. Page 224 of my manual says "Press the button to activate system. When the system activates, the set speed is equal to whichever is greater, the current vehicle speed, or 15 mph...." This part is true, and this is how the unexpected acceleration to 15mph occurs when parking. But the manual continues: "If the speed is too low, or other conditions are not correct for adaptive cruise control activation, the system enters standby mode. When you are below 15 mph ... adaptive cruise control does not activate unless you are following another vehicle." This is FALSE. This did not work. Clearly the CC mistook the wall in front of me for "following another vehicle." And so, when I accidentally activated CC while parking, it lurched forward UPHILL to 15mph toward a wall a few feet away. Ford needs to move the button and/or fix the failsafe.
NHTSA complaint #11693304 — an unverified report by a vehicle owner.
Westcliffe, CO
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Camera system that allows hands free driving, lane departure warning, collision warning and adaptive cruise control fails and all system offline. Extremely widespread on the 2021 models. Looks to be a cable route to the camera that was installed incorrectly. Went to dealership, they said they see this in almost all of the Mach E vehicles. Usually begins failing when hitting bumps -- system goes in/out. After a while, system drops out completely and all safety systems relying on them fail.
NHTSA complaint #11691351 — an unverified report by a vehicle owner.
Westcliffe, CO
FORWARD COLLISION AVOIDANCE: WARNINGS
Camera system that allows hands free driving, lane departure warning, collision warning and adaptive cruise control fails and all system offline. Extremely widespread on the 2021 models. Looks to be a cable route to the camera that was installed incorrectly. Went to dealership, they said they see this in almost all of the Mach E vehicles. Usually begins failing when hitting bumps -- system goes in/out. After a while, system drops out completely and all safety systems relying on them fail.
NHTSA complaint #11691351 — an unverified report by a vehicle owner.
Westcliffe, CO
LANE DEPARTURE: WARNING
Camera system that allows hands free driving, lane departure warning, collision warning and adaptive cruise control fails and all system offline. Extremely widespread on the 2021 models. Looks to be a cable route to the camera that was installed incorrectly. Went to dealership, they said they see this in almost all of the Mach E vehicles. Usually begins failing when hitting bumps -- system goes in/out. After a while, system drops out completely and all safety systems relying on them fail.
NHTSA complaint #11691351 — an unverified report by a vehicle owner.
Webster, NY
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
When in cruise control, any speed, car suddenly accelerates This happens while driving, or sometimes after stopping and then resuming previous set speed. For example I was driving in cruise control at 38 mph, when the car suddenly sped to 50mph. Or when on a highway, driving at 55mph, the car suddenly accelerated to 70mph. Started about 3 weeks ago.
NHTSA complaint #11689770 — an unverified report by a vehicle owner.
Bremerton, WA
FORWARD COLLISION AVOIDANCE: WARNINGS
Going over any bump in the road greater than 2 inches in heigth causes the following: - Front Camera Fault Service Required message - Pre-collision Assist inoperative - Adaptive cruise control inoperative
NHTSA complaint #11689229 — an unverified report by a vehicle owner.
Bremerton, WA
BACK OVER PREVENTION: WARNINGS
Going over any bump in the road greater than 2 inches in heigth causes the following: - Front Camera Fault Service Required message - Pre-collision Assist inoperative - Adaptive cruise control inoperative
NHTSA complaint #11689229 — an unverified report by a vehicle owner.
Going over any bump in the road greater than 2 inches in heigth causes the following: - Front Camera Fault Service Required message - Pre-collision Assist inoperative - Adaptive cruise control inoperative
NHTSA complaint #11689229 — an unverified report by a vehicle owner.
at 7,500 milesSan Juan Capistrano, CA
BACK OVER PREVENTION
The contact owns a 2021 Ford Mustang March E. The contact stated that while reversing, the back over prevention camera image was frozen, and the driver was unable to view the images behind the vehicle. The vehicle was taken to the local dealer who determined that the back over prevention camera was faulty; however, the VIN was not included in NHTSA Campaign Number: 25V315000 (BACK OVER PREVENTION). The vehicle was not repaired. The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 7,500.
NHTSA complaint #11685672 — an unverified report by a vehicle owner.