FaultScore
See all results →
All makes Worst years, ranked Problems by part Analysis Problems by model year Recalls in Canada Recall lookup Compare two cars How we grade

Ford Thunderbird recalls

NHTSA has issued 38 recalls covering the Ford Thunderbird. A recall repair is always free, however old the car is.

Check your own car by VIN

Recalls apply to specific build ranges, so a recall listed here may or may not cover your particular vehicle. NHTSA's free VIN lookup is the authority: nhtsa.gov/recalls.

1993 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1994 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1995 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1996 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1992 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1997 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1990 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1989 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1991 Ford Thunderbird Campaign 09E012000 7 Apr 2009

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

1996 Ford Thunderbird Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1997 Ford Thunderbird Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

2002 Ford Thunderbird Campaign 06E056000 13 Jun 2006

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Risk: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

2005 Ford Thunderbird Campaign 05V113000 18 Mar 2005

FUEL SYSTEM, GASOLINE:STORAGE

ON CERTAIN PASSENGER VEHICLES, THE FUEL TANK MAY HAVE A LOCALIZED THIN WALL SECTION IN THE LOWER HALF OF THE TANK. THE FUEL TANK MAY CRACK CREATING A POTENTIAL FOR A FUEL LEAK AND FUEL ODOR. THE "SERVICE ENGINE SOON" INDICATOR MAY ILLUMINATE.

Risk: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673, LINCOLN AT 1-800-521-4140.

2004 Ford Thunderbird Campaign 04V330000 8 Jul 2004

SEATS:FRONT ASSEMBLY:POWER ADJUST

CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER ADJUSTABLE SEATS MAY HAVE BEEN INADEQUATELY WELDED.

Risk: THE SEAT MAY NOT PERFORM AS INTENDED DURING A CRASH WHICH COULD INCREASE THE RISK OF INJURY.

Remedy: DEALERS WILL REPLACE THE UPPER SUPPORT ASSEMBLY ON THE POWER SEATS. THE RECALL BEGAN ON JULY 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

2002 Ford Thunderbird Campaign 02V169000 14 Jun 2002

SEAT BELTS:FRONT:WEBBING

ON CERTAIN PASSENGER VEHICLES, THE DRIVER'S SIDE SEAT BELT CONTACTED THE SEAT RECLINER DURING A 35 MPH NCAP FULL-FRONTAL BARRIER IMPACT TEST.

Risk: THE EDGE OF THE RECLINER MECHANISM CAUSED A PARTIAL CUT IN THE LAP PORTION OF THE WEBBING. IF THE WEBBING IS CUT, IT INCREASES THE RISK OF INJURY IN A CRASH.

Remedy: DEALERS WILL INSTALL AN INSERT BEHIND THE DRIVER SIDE SEAT LOWER TRIM PANEL. OWNER NOTIFICATION BEGAN JUNE 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

1993 Ford Thunderbird Campaign 99V275000 12 Oct 1999

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.

Risk: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.

1992 Ford Thunderbird Campaign 99V275000 12 Oct 1999

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.

Risk: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.

1993 Ford Thunderbird Campaign 97V159000 22 Sep 1997

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.

Risk: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.

Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.

1992 Ford Thunderbird Campaign 97V159000 22 Sep 1997

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.

Risk: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.

Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.

1993 Ford Thunderbird Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1992 Ford Thunderbird Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1990 Ford Thunderbird Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1989 Ford Thunderbird Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1991 Ford Thunderbird Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1988 Ford Thunderbird Campaign 96V071000 25 Apr 1996

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.

1996 Ford Thunderbird Campaign 96V070000 22 Apr 1996

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

Risk: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.

1996 Ford Thunderbird Campaign 96V007000 16 Jan 1996

EQUIPMENT:APPLIANCE:AIR CONDITIONER

UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.

Risk: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.

1990 Ford Thunderbird Campaign 91V076000 6 May 1991

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.

Risk: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.

Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.

1991 Ford Thunderbird Campaign 91V076000 6 May 1991

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.

Risk: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.

Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.

1991 Ford Thunderbird Campaign 91V048000 18 Mar 1991

POWER TRAIN:AUTOMATIC TRANSMISSION

THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.

Risk: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.

Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.

1990 Ford Thunderbird Campaign 90V026000 12 Feb 1990

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.

Risk: CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.

Remedy: REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.

1989 Ford Thunderbird Campaign 89V081000 19 May 1989

SERVICE BRAKES, AIR:DISC:CALIPER

DUE TO CONTACT BETWEEN THE BRAKE CALIPER OF THE INBOARD FRONT WHEEL AND THE FRONT STABILIZER BAR, THERE MAY BE INCREASED BRAKE PEDAL TRAVEL FOLLOWING LOW SPEED TURNING MANEUVERS.

Risk: THIS COULD CAUSE A REDUCTION IN BRAKE PERFORMANCETHAT COULD RESULT IN AN ACCIDENT.

Remedy: INSTALL ACORN TYPE FRONT SUSPENSION STRUT NUTS TO ELIMINATE STABILIZER BAR TO BRAKE CALIPER CONTACT.

1989 Ford Thunderbird Campaign 89V080000 19 May 1989

SUSPENSION:REAR:SPRINGS

IMPROPERLY HEAT TREATED REAR SUSPENSION KNUCKLES COULD EXPERIENCE HIGH MILEAGE FATIGUE CRACKS AND EVENTUAL FRACTURE.

Risk: THIS COULD RESULT IN REAR SUSPENSION FAILURE AT THEAFFECTED WHEEL WITH AN ADVERSE AFFECT ON CONTROL OF THE CAR, WHICH COULDCAUSE AN ACCIDENT.

Remedy: REPLACE KNUCKLES THAT HAVE THE AFFECTED LOT CODES.

1989 Ford Thunderbird Campaign 88V165000 18 Oct 1988

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

PLASTIC ROLLOVER VALVE MOUNTING PLATE MAY NOT BE PROPERLY SEALED TO THE PLASTIC FUEL TANK.

Risk: FUEL OR VAPOR COULD LEAK, WHICH COULD RESULT IN A VEHICLEFIRE.

Remedy: REPLACE FUEL TANK.

1988 Ford Thunderbird Campaign 88V033000 15 Mar 1988

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

A DESIGN CHANGE TO FACILITATE CHANGEOVER IN REAR AXLE SHAFT FLANGES INADVERTENTLY PRODUCED THE POSSIBILITY FOR INTERFERENCE BETWEEN THE FLANGE AND DISC BRAKE ROTOR.

Risk: THE INTERFERENCE COULD PREVENT PROPER SEATING OF THEROTOR. ALSO AN IMPROPERLY SEATED ROTOR COULD IN TIME RESULT IN A REDUCTION INTHE CLAMPING FORCES OF THE WHEEL STUDS, POSSIBLY LEADING TO FRACTURED STUDSAND REAR WHEEL SEPARATION.

Remedy: INSPECTION OF VEHICLES AND WHERE NECESSARY REPLACE REAR AXLE SHAFTS AND REAR BRAKE ROTORS.

1987 Ford Thunderbird Campaign 87V139000 4 Sep 1987

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Risk: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

1986 Ford Thunderbird Campaign 87V139000 4 Sep 1987

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Risk: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

1984 Ford Thunderbird Campaign 83V134000 20 Dec 1983

SEAT BELTS:FRONT:ANCHORAGE

THE BOLTS THAT ATTACH THE D-SHAPED RING FOR THE SHOULDER BELT ARE INADEQUATELY SUPPORTED BY THE MATERIAL IN WHICH THEY ARE MOUNTED. THE ATTACHMENT DOES NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES".

Remedy: DEALERS WILL INSTALL NEW ATTACHING HARDWARE TO IMPROVE THE STRENGTH OF THE MOUNTING.

Ford Thunderbird recalls in Canada

Transport Canada runs its own recall programme. Its campaigns do not always mirror the American ones, so a Canadian owner reading a US-only list is reading about a different car than the one on their driveway.

2004 Ford Thunderbird Recall 2004237 9 Jul 2004 1,549 units in Canada

Seats And Restraints

On certain vehicles, the power seat track may contain fewer welds than specified between the track recliner bracket and the lower support bracket. This condition may cause a squeak/rattle condition to develop, and possibly result in a loose seat. In the rare circumstance that a vehicle having a seat with insufficient multiple welds is in a collision, the seat may not perform as intended potentially increasing the risk of an injury. Correction: Dealers will replace the upper support assembly on all power seat track assemblies.

2002 Ford Thunderbird Recall 2002111 19 Jun 2002 1,120 units in Canada

Seats And Restraints

On certain vehicles the driver's side seat belt contacted the seat recliner during a 35 mph NCAP full-frontal barrier impact test. The edge of the recliner mechanism caused a partial cut in the lap portion of the webbing. Correction: dealer will install an insert behind the driver side seat lower trim panel.

1993 Ford Thunderbird Recall 1999193 29 Oct 1999 4,154 units in Canada

Electrical

On certain vehicles, the high electrical current flowing through the headlamp switch during simultaneous operation of the headlamps and fog lamps may cause the switches internal bimetal circuit breaker to open due to overheating. Should this occur, the vehicle's headlights may go out for brief intervals (flickering or blinking). Extended cycling of the circuit breaker due to continued overheating can result in longer duration outages. Correction: Dealers will install a headlamp switch which incorporates a circuit breaker of revised design, and a wiring harness connector, if needed.

1992 Ford Thunderbird Recall 1999193 29 Oct 1999 4,154 units in Canada

Electrical

On certain vehicles, the high electrical current flowing through the headlamp switch during simultaneous operation of the headlamps and fog lamps may cause the switches internal bimetal circuit breaker to open due to overheating. Should this occur, the vehicle's headlights may go out for brief intervals (flickering or blinking). Extended cycling of the circuit breaker due to continued overheating can result in longer duration outages. Correction: Dealers will install a headlamp switch which incorporates a circuit breaker of revised design, and a wiring harness connector, if needed.

1993 Ford Thunderbird Recall 1997193 10 Nov 1997 9,271 units in Canada

Fuel System

MOVEMENT OF FUEL LINES, RESULTING FROM NORMAL VEHICLE BODY VIBRATIONS. CAUSES THE NYLON FUEL LINES TO WEAR BY RUBBING AGAINST THE METAL FLOOR PAN. THIS COULD RESULT IN FUEL LEAKAGE WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. CORRECTION: FUEL LINES WILL BE INSPECTED AND REPLACED AS NECESSARY. ALSO, A PLASTIC CONVOLUTE COVERING WILL BE INSTALLED AROUND THE FUEL LINES WHICH WILL PREVENT WEAR THROUGH.

1992 Ford Thunderbird Recall 1997193 10 Nov 1997 9,271 units in Canada

Fuel System

MOVEMENT OF FUEL LINES, RESULTING FROM NORMAL VEHICLE BODY VIBRATIONS. CAUSES THE NYLON FUEL LINES TO WEAR BY RUBBING AGAINST THE METAL FLOOR PAN. THIS COULD RESULT IN FUEL LEAKAGE WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. CORRECTION: FUEL LINES WILL BE INSPECTED AND REPLACED AS NECESSARY. ALSO, A PLASTIC CONVOLUTE COVERING WILL BE INSTALLED AROUND THE FUEL LINES WHICH WILL PREVENT WEAR THROUGH.

1996 Ford Thunderbird Recall 1996071 9 May 1996 3,296 units in Canada

Structure

THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S 206 - DOOR LATCHES, HINGES AND LOCKS. THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1000 POUND TRANSVERSE LOAD AS REQUIRED BY THE STANDARD. CORRECTION: DRIVER DOOR LATCH WILL BE INSPECTED AND, IF NECESSARY, REPLACED.

1996 Ford Thunderbird Recall 1996017 25 Jan 1996 245 units in Canada

Heater And Defroster

THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULE MAY MALFUNCTION AND CAUSE ERRATIC BLOWER OPERATION, HIGH BLOWER OR NO BLOWER REGARDLESS OF CONTROL POSITION. SHOULD THE NO BLOWER CONDITION OCCUR, THE VEHICLE'S DEFROSTER MAY NOT CLEAR THE WINDSHIELD OF FROST/FOG. CORRECTION: DEALERS WILL INSPECT AND IF NECESSARY, REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULE WITH A REVISED DESIGN MODULE.

1993 Ford Thunderbird Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1992 Ford Thunderbird Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1990 Ford Thunderbird Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1989 Ford Thunderbird Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1991 Ford Thunderbird Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1988 Ford Thunderbird Recall 1995212 29 Nov 1995 834,368 units in Canada

Electrical

A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.

1989 Ford Thunderbird Recall 1994162 24 Oct 1994 1,693 units in Canada

Emissions

Certain Cougar XR-7, Tunderbird turbo, and Merkur XR4TI vehicles fail to comply with the requirements of CMVSS 1103 - Exhaust Emissions. Correction: Dealers will replace the exhaust system catalyst and a vacuum delay valve will be installed in the EGC vacuum line.

1988 Ford Thunderbird Recall 1994162 24 Oct 1994 1,693 units in Canada

Emissions

Certain Cougar XR-7, Tunderbird turbo, and Merkur XR4TI vehicles fail to comply with the requirements of CMVSS 1103 - Exhaust Emissions. Correction: Dealers will replace the exhaust system catalyst and a vacuum delay valve will be installed in the EGC vacuum line.

1990 Ford Thunderbird Recall 1994041 28 Feb 1994 318 units in Canada

Emissions

NOTE: THUNDERBIRD SUPER COUPE AND COUGAR XR7 EQUIPPED WITH MANUAL TRANSMISSION AND 3.8 LITRE SUPERCHARGED ENGINE. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. HIGHER THAN ANTICIPATED EXHAUST SYSTEM TEMPERATURES MAY CAUSE DAMAGE TO THE EXHAUST SYSTEM CATALYST THEREBY INCREASING EXHAUST EMISSION LEVELS IN EXCESS OF THE STANDARD. CORRECTION: DEALERS WILL REPLACE EXHAUST SYSTEM CATALYST ASSEMBLY AND POWERTRAIN CONTROL MODULE.

1989 Ford Thunderbird Recall 1992108 4 Sep 1992 10,242 units in Canada

Seats And Restraints

NOTE: THIS RECALL SUPERSEDES RECALL 91066 (91S32). A CABLE IN THE TENSION RELIEVER MECHANISM IN EITHER THE SAFETY BELTS PROVIDED IN THE KITS FOR RECALL 91066 (91S32) OR THE FACTORY INSTALLED FRONT SAFETY BELT ASSEMBLIES MAY BREAK OR BIND CAUSING A MALFUNCTION IN THE RETRACTOR MECHANISM. SHOULD THIS OCCUR, THE FRONT SAFETY BELTS MAY NOT RETRACT AFTER FULL EXTENSION. IN THIS CONDITION, THE BELTED OCCUPANT WILL NOT BE PROPERLY RESTRAINED IF THE VEHICLE IS INVOLVED IN A COLLISION. CORRECTION: DRIVER AND FRONT PASSENGER SAFETY BELT ASSEMBLIES WILL BE REPLACED ON AFFECTED VEHICLES.

1988 Ford Thunderbird Recall 1992098 21 Aug 1992 18,869 units in Canada

Emissions

NOTE: VEHICLES WITH 3.8 LITRE ENGINES. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. THE SUBSTRATE MATERIAL IN THE CATALYSTS MAY RATTLE AND BREAK UP DURING NORMAL USE CAUSING EXHAUST EMISSIONS TO EXCEED THE STANDARD. CORRECTION: VEHICLES WILL BE INSPECTED AND CATALYST WILL BE REPLACED WHERE NECESSARY.

1987 Ford Thunderbird Recall 1992098 21 Aug 1992 18,869 units in Canada

Emissions

NOTE: VEHICLES WITH 3.8 LITRE ENGINES. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. THE SUBSTRATE MATERIAL IN THE CATALYSTS MAY RATTLE AND BREAK UP DURING NORMAL USE CAUSING EXHAUST EMISSIONS TO EXCEED THE STANDARD. CORRECTION: VEHICLES WILL BE INSPECTED AND CATALYST WILL BE REPLACED WHERE NECESSARY.

1986 Ford Thunderbird Recall 1992098 21 Aug 1992 18,869 units in Canada

Emissions

NOTE: VEHICLES WITH 3.8 LITRE ENGINES. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. THE SUBSTRATE MATERIAL IN THE CATALYSTS MAY RATTLE AND BREAK UP DURING NORMAL USE CAUSING EXHAUST EMISSIONS TO EXCEED THE STANDARD. CORRECTION: VEHICLES WILL BE INSPECTED AND CATALYST WILL BE REPLACED WHERE NECESSARY.

1990 Ford Thunderbird Recall 1992077 30 Jun 1992 464,543 units in Canada

Lights And Instruments

NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAYTIME RUNNING LIGHTS THAT DIM, FLICKER OR GO OFF OR IN SOME INSTANCES MAY REMAIN ON AFTER THE IGNITION IS TURNED OFF. CORRECTION: DAYTIME RUNNING LIGHT MODULE WILL BE REPLACED ON AFFECTED VEHICLES.

1989 Ford Thunderbird Recall 1992077 30 Jun 1992 464,543 units in Canada

Lights And Instruments

NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAYTIME RUNNING LIGHTS THAT DIM, FLICKER OR GO OFF OR IN SOME INSTANCES MAY REMAIN ON AFTER THE IGNITION IS TURNED OFF. CORRECTION: DAYTIME RUNNING LIGHT MODULE WILL BE REPLACED ON AFFECTED VEHICLES.

1991 Ford Thunderbird Recall 1992077 30 Jun 1992 464,543 units in Canada

Lights And Instruments

NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAYTIME RUNNING LIGHTS THAT DIM, FLICKER OR GO OFF OR IN SOME INSTANCES MAY REMAIN ON AFTER THE IGNITION IS TURNED OFF. CORRECTION: DAYTIME RUNNING LIGHT MODULE WILL BE REPLACED ON AFFECTED VEHICLES.

1989 Ford Thunderbird Recall 1992036 31 Mar 1992 9,939 units in Canada

Emissions

NOTE: VEHICLES EQUIPPED WITH 3.8 LITRE ENGINES. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S 1105 - EVAPORATIVE EMISSIONS. FUEL VAPOUR HOSE MAY NOT BE CONNECTED AT THE FUEL TANK VAPOUR VALVE. CORRECTION: VEHICLES WILL BE INSPECTED AND FUEL TANK VAPOUR HOSE WILL BE RECONNECTED WHERE NECESSARY.

1990 Ford Thunderbird Recall 1991073 7 May 1991 6,677 units in Canada

Visual System

THE NUTS WHICH HOLD THE WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN ADEQUATELY TIGHTENED AND MAY LOOSEN OR COME OFF. IF THIS HAPPENS, THE WIPER PATTERN MAY SHIFT OR, IN SOME CASES, THE WIPER MAY JAM OF TWO OF THE THREE NUTS HAVE COME OFF. JAMMED WIPERS COULD RESULT IN REDUCED DRIVER VISIBILITY DURING INCLEMENT WEATHER CONDITIONS. CORRECTION: MOUNTING NUTS/STUDS WILL BE INSPECTED FOR LOCTITE AND WILL BE REINSTALLED AND TORQUED WITH LOCTITE IF REQUIRED.

1991 Ford Thunderbird Recall 1991073 7 May 1991 6,677 units in Canada

Visual System

THE NUTS WHICH HOLD THE WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN ADEQUATELY TIGHTENED AND MAY LOOSEN OR COME OFF. IF THIS HAPPENS, THE WIPER PATTERN MAY SHIFT OR, IN SOME CASES, THE WIPER MAY JAM OF TWO OF THE THREE NUTS HAVE COME OFF. JAMMED WIPERS COULD RESULT IN REDUCED DRIVER VISIBILITY DURING INCLEMENT WEATHER CONDITIONS. CORRECTION: MOUNTING NUTS/STUDS WILL BE INSPECTED FOR LOCTITE AND WILL BE REINSTALLED AND TORQUED WITH LOCTITE IF REQUIRED.

1989 Ford Thunderbird Recall 1991066 24 Apr 1991 10,217 units in Canada

Seats And Restraints

NOTE: THIS RECALL SUPERSEDED BY RECALL 92-108. THE FRONT SEAT BELTS MAY NOT RETRACT AFTER EXTENSION DUE TO A BROKEN TENSION ELIMINATOR CABLE WHICH IS TOO LONG AND PRONE TO BREAKAGE. THIS COULD RESULT IN THE SEAT OCCUPANT BEING INADEQUATELY RESTRAINED IN THE EVENT OF A COLLISION. CORRECTION: NEW FRONT SEAT LAP-SHOULDER BELT ASSEMBLIES THAT HAVE A SHORTER TENSION ELIMINATOR CABLE WILL BE INSTALLED ON AFFECTED VEHICLES.

1991 Ford Thunderbird Recall 1991056 27 Mar 1991 391 units in Canada

Powertrain

THE AUTOMATIC OVERDRIVE TRANSMISSIONS ON THESE VEHICLES MAY BE EQUIPPED WITH A PARK ROD ASSEMBLY THAT INCLUDES A PARK CAM WITH INADEQUATE SURFACE HARDNESS. THIS COULD RESULT IN HIGH PARK DISENGAGEMENT FORCES OR IN NO PARK ENGAGEMENT WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION. THIS IN TURN COULD RESULT IN AN UNPOWERED VEHICLE ROLL-AWAY IF THE VEHICLE IS PARKED ON AN INCLINE WITH THE PARKING BRAKE OFF. CORRECTION: PARK ROD ASSEMBLY WILL BE REPLACED ON AFFECTED VEHICLES.

1990 Ford Thunderbird Recall 1990104 5 Jul 1990 300 units in Canada

Emissions

NOTE: VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND 3.8L SUPERCHARGED ENGINE. THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 1101- EMISSION DEVICE. INCORRECT DECALS, VEHICLE EMISSION AND CONTROL INFORMATION.

1989 Ford Thunderbird Recall 1989080 2 Jun 1989 939 units in Canada

Suspension

IMPROPERLY HEAT TREATED REAR SUSPENSION KNUCKLES ON THESE VEHICLES COULD EXPERIENCE HIGH MILEAGE FATIGUE CRACKS AND EVENTUAL FRACTURE. SHOULD A FRACTURE OCCUR, THE REAR SUSPENSION AT THAT WHEEL WOULD NOT REMAIN INTACT AND VEHICLE CONTROL COULD BE ADVERSELY AFFECTED. CORRECTION: VEHICLES WILL BE INSPECTED AND SUSPECT REAR SUSPENSION KNUCKLES WILL BE REPLACED.

1989 Ford Thunderbird Recall 1989079 1 Jun 1989 5,344 units in Canada

Brakes

A FULL-LOCK, LOW SPEED TURNING MANEUVER MAY RESULT IN THE BRAKE CALIPER OF THE INBOARD FRONT WHEEL CONTACTING THE FRONT STABILIZER BAR, CAUSING MOVEMENT OF THE CALIPER PISTON AND DISPLACEMENT OF BRAKE FLUID FROM THE CALIPER BACK TO THE MASTER CYLINDER RESERVOIR. THIS WOULD CAUSE INCREASED BRAKE PEDAL TRAVEL AND REDUCED BRAKE PERFORMANCE ON THE FIRST BRAKE APPLICATION FOLLOWING THE TURN. AFTER ONE BRAKE APPLICATION, THE DISPLACED BRAKE PEDAL TRAVEL AND BRAKE PERFORMANCE IS RESTORED. THE SEQUENCE COULD REPEAT, HOWEVER, FOLLOWING THE NEXT LOW SPEED FULL-LOCK TURNING MANEUVER. CORRECTION: ACORN TYPE FRONT SUSPENSION STRUT NUTS WILL BE INSTALLED WHICH WILL SERVE AS STEERING STOPS AND ELIMINATE THE POTENTIAL FOR STABILIZER BAR TO BRAKE CALIPER CONTACT.

1988 Ford Thunderbird Recall 1988037 16 Mar 1988 8 units in Canada

Suspension

- FORD THUNDERBIRD TURBO COUPE - THE REAR AXLE SHAFT FLANGE MAY INTERFERE WITH THE DISC BRAKE ROTOR THEREBY PREVENTING PROPER SEATING OF THE ROTOR. AN IMPROPERLY SEATED ROTOR COULD IN TIME, RESULT IN REDUCTION OF THE WHEEL STUD CLAMPING FORCES AND COULD LEAD TO FRACTURED STUDS AND REAR WHEEL SEPARATION. CORRECTION: VEHICLES WILL BE INSPECTED AND REAR AXLE SHAFT AND REAR BRAKE ROTORS WILL BE REPLACED WHERE NECESSARY.

1987 Ford Thunderbird Recall 1987098 9 Sep 1987 295,731 units in Canada

Fuel System

ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHER FUEL LINE CONNECTIONS NEAR THE DASH PANELS ON SOME VEHICLES, COULD DISENGAGE DURING VEHICLE USE. SHOULD THIS OCCUR, LOSS OF FUEL WILL RESULT, PROVIDING THE POTENTIAL FOR A VEHICLE FIRE. CORRECTION: COUPLING RETAINER CLIPS WILL BE INSTALLED ON AFFECTED VEHICLES. NOTE: ESCORT VEHICLES ARE EQUIPPED WITH EFI AND CFI. LYNX VEHICLES ARE EQUIPPED WITH CFI ONLY. EFI - ELECTRONIC FUEL INJECTION CFI - CENTRAL FUEL INJECTION

1986 Ford Thunderbird Recall 1987098 9 Sep 1987 295,731 units in Canada

Fuel System

ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHER FUEL LINE CONNECTIONS NEAR THE DASH PANELS ON SOME VEHICLES, COULD DISENGAGE DURING VEHICLE USE. SHOULD THIS OCCUR, LOSS OF FUEL WILL RESULT, PROVIDING THE POTENTIAL FOR A VEHICLE FIRE. CORRECTION: COUPLING RETAINER CLIPS WILL BE INSTALLED ON AFFECTED VEHICLES. NOTE: ESCORT VEHICLES ARE EQUIPPED WITH EFI AND CFI. LYNX VEHICLES ARE EQUIPPED WITH CFI ONLY. EFI - ELECTRONIC FUEL INJECTION CFI - CENTRAL FUEL INJECTION

1985 Ford Thunderbird Recall 1985029 19 Mar 1985 175 units in Canada

VEHICLES MAY HAVE BEEN PRODUCED WITH BRAKE MASTER CYLINDERS THAT HAVE IMPROPERLY ANODIZED INTERNAL SURFACES. THIS COULD CAUSE ACCELERATED WEAR OF A MASTER CYLINDER PISTON SEAL TO THE EXTENT THAT ONE PORTION OF THE SPLIT BRAKE SYSTEM BECOMES INEFFECTIVE. THIS WOULD INCREASE STOPPING DISTANCES AND COULD RESULT IN A VEHICLE CRASH.

1977 Ford Thunderbird Recall 1984082 12 Jul 1984 19,144 units in Canada

THE FLEXIBLE ENGINE COOLING FAN BLADES MAY FATIGUE CRACK AND SEPARATE FROM THE FAN ASSEMBLY. FAN BLADE SEPARATION MAY DAMAGE UNDERHOOD COMPONENTS AND, IF THE HOOD IS OPEN, INJURE PERSONS IN THE VICINITY OF THE VEHICLE. VEHICLES AFFECTED ARE THOSE WITH 302, 351, AND 400 C.I.D. ENGINES WITH AIR CONDITIONING.

1984 Ford Thunderbird Recall 1983114 17 Dec 1983 37,431 units in Canada

THE UPPER TORSO RESTRAINT D-RING WHICH ATTACHES THE SHOULDER BELT TO THE B PILLAR, UNDER CERTAIN TEST CONDITIONS, SEPARATED FROM ITS ANCHORAGE, AND MAY NOT COMPLY WITH CMVSS 210 - BELT ANCHORAGE.

1983 Ford Thunderbird Recall 1983037 7 Apr 1983 15 units in Canada

VEHICLES EQUIPPED WITH 2.3 LITRE TURBO ENGINES. iNADEQUATE CONNECTIONS ON THE FUEL SUPPLY LINES AT THE INLET TO THE PRESSURE RELIEF VALVE AND AT THE CONNECTION OF THE FLEXIBLE SUPPLY LINE TO THE METALLIC FUEL TUBE COULD RESULT IN FUEL LINE SEPARATION. THIS WOULD CAUSE FUEL TO BE PUMPED FROM THE DISENGAGED LINE BY THE ELECTRIC FUEL PUMP. IN THE PRESENCE OF AN IGNITION SOURCE, FUEL SPILLAGE COULD PRESENT THE POTENTIAL FOR FIRE.

1983 Ford Thunderbird Recall 1983014 9 Feb 1983 131 units in Canada

VEHICLES WITH 3.8 LITRE ENGINES. VEHICLES MAY HAVE BEEN PRODUCED WITH INADEQUATELY WELDED FRONT SEAMS ON THE FUEL TANK. A FUEL LEAK COULD DEVELOP AND IN THE PRESENCE OF AN IGNITION SOURCE, PRESENT A POTENTIAL FOR FIRE.

1977 Ford Thunderbird Recall 1980147 6 Nov 1980 22,000 units in Canada

VEHICLES WITH THE 351(WINDSOR) ENGINE AND AIR CONDITIONING HAVE FLEXIBLE FIVE BLADE ENGINE COOLING FANS THAR MAY BE SUBJECT TO HIGH BLADE STRESSES DUE TO RESONANT VIBRATIONS. THIS CAN CAUSE CRACKING OF THE BLADES AND SEPARATION OF FRAGMENTS FROM THE FAN.

1980 Ford Thunderbird Recall 1980021 20 Feb 1980 223 units in Canada

Brakes

VEHICLES MAY HAVE BEEN EQUIPPED WITH REAR AXLE ASSEMBLIES CONTAINING BRAKE ASSEMBLIES INTENDED FOR USE ON 1980 MUSTANG AND CAPRI VEHICLES .THESE VEHICLES MAY NOT COMPLY WITH THE REQUIREMENTS OF CANADA MOTOR VEHICLE SAFETY STANDARD 105 - HYDRAULIC BRAKE SYSTEMS.

1980 Ford Thunderbird Recall 1979182 6 Nov 1979 2,331 units in Canada

Emissions

DURING THE RAILCAR CHAIN-DOWN OPERATION OR DURING IN-TRANSIT RAILCAR MOVEMENT, THE CHAIN COULD INTERFERE WITH AND BREAK THE EVAPORATIVE EMISSION CARBON CANISTER. THESE VEHICLES WOULD THEN NOT COMPLY WITH CANADA MOTOR VEHICLE SAFETY STANDARD 1105 - EVAPORATIVE EMISSIONS.

1979 Ford Thunderbird Recall 1979085 11 May 1979 8,258 units in Canada

SOME BRAKE PUSHROD TO BRAKE PEDAL RETAINING PINS WERE INCORRECTLY HEAT TREATED AND MAY NOT MAINTAIN THE REQUIRED SET WHEN INSTALLED. THE RETAINING PIN MAY FALL OUT ALLOWING A POSSIBLE DISENGAGEMENT OF THE PUSHROD FROM THE BRAKE PEDAL RESULTING IN A LOSS OF SERVICE BRAKES.

1978 Ford Thunderbird Recall 1979068 12 Apr 1979 97,902 units in Canada

THE EVAPORATIVE EMISSION (CARBON CANISTER) FUEL VAPOUR PURGE VALVE MAY BE DISCONNECTED AND COULD ALLOW A SMALL QUANTITY OF FUEL VAPOUR TO BE RELEASED TO THE ATMOSPHERE.

1979 Ford Thunderbird Recall 1978149 22 Dec 1978 1,638 units in Canada

Vehicles equipped with Saginaw type power steering gears. the power steering gears may contain improperly manufactured sector shafts that may fracture possibly resulting in detachment of the pitman arm from the splined portion of the sector shaft. This would result in a loss of steering control.

1978 Ford Thunderbird Recall 1978032 18 May 1978 8,251 units in Canada

VEHICLES EQUIPPED WITH AMERICAN SAFETY CORPORATION FRONT OUTBOARD SEAT BELT ASSEMBLIES. THE SUBJECT SEAT BELT ASSEMBLIES MAY BE EQUIPPED WITH SHOULDER HARNESS RETRACTORS THAT MAY NOT LOCK WHEN THE VEHICLE EXPERIENCES A SUDDEN DECELERATION OR IMPACT THUS LEAVING THE UPPER TORSO OF FRONT SEAT OCCUPANTS UNRESTRAINED.

1978 Ford Thunderbird Recall 1977105 21 Nov 1977 25 units in Canada

VEHICLES EQUIPPED WITH TURBINE SPOKE CAST ALUMINUM WHEELS. THE CAST ALUMINUM WHEELS MAY HAVE BEEN MANUFACTURED WITH LUG NUT COUNTERBORES OF INADEQUATE DEPTH SUCH THAT THE LUG NUT WILL NOT HAVE PROPER THREAD ENGAGEMENT. THIS MAY CAUSE THE LUG NUT TO LOOSEN RESULTING IN WHEEL SEPARATION.

1977 Ford Thunderbird Recall 1977069 29 Sep 1977 318 units in Canada

VEHICLES EQUIPPED WITH TILT STEERING COLUMNS. SOME TILT STEERING COLUMNS CONTAIN TRANSMISSION CONTROL INSERTS (GEAR SELECTOR POINTERS) THAT WERE INTENDED FOR USE IN 1978 MODEL TRUCKS. USE OF THESE INSERTS COULD ALLOW THE ENGINE TO BE STARTED WITH THE SHIFT SELECTOR POSITIONED BETWEEN NEUTRAL (N) AND DRIVE (D) AND THE TRANSMISSION IN DRIVE. THERE IS A POSSIBILITY OF STARTING THE VEHICLE WITH THE TRANSMISSION IN DRIVE CREATING THE POTENTIAL FOR A FRONTAL COLLISION.

1977 Ford Thunderbird Recall 1977068 29 Sep 1977 5,327 units in Canada

Fuel System

Certain vehicles equipped with 351 and 400 cleveland engines. Certain cleveland engines may experience fuel leakage at the rubber hose connecting the fuel inlet tube to the carburetor fuel filter. A fuel leakage in the engine compartment creates the potential for a fire.

Source: Transport Canada Vehicle Recalls Database.