73 of the
742 complaints filed about the Ford Transit Connect
are about the braking system —
10% of everything owners reported.
The worst model year for it is 2019.
Component Affected: Service Brakes / ABS Module / Hydraulic Braking System Description of Safety Defect: There is an active, intermittent, catastrophic failure in the front braking system/ABS module causing the front brakes to completely lock up mid-transit while operating at high speeds (60+ MPH). First Incident (April 24, 2026): During operation on a busy interstate at over 60 MPH, the front braking system experienced a sudden, catastrophic thermal lock-up. This caused violent vehicle shuddering, extreme friction heat, and heavy, thick, acrid smoke. The vehicle was brought to a dealer shop for repair. Second Incident (April 29, 2026): Four days after delivery, the identical catastrophic brake lock-up recurred mid-transit, creating an immediate fire hazard due to friction heat and smoke. An independent repair facility diagnosed the failure and replaced the ABS module. Third Incident (June 4, 2026): The identical component failure recurred while traveling at over 60 MPH on Interstate 694 with a minor child in the vehicle. The front brakes fully locked up mid-transit, creating an immediate risk of a high-speed collision, severe thermal friction, and heavy burning odors, rendering the vehicle entirely un-roadworthy. Current Status: > The vehicle has sat grounded at a repair shop for 30 cumulative days out of 54 days of ownership due to the persistent re-locking of the front hydraulic braking system. The vehicle is unsafe to operate on public roads. No crash or fire occurred, but the failure poses an imminent thermal and collision hazard.
NHTSA complaint #11745074 — an unverified report by a vehicle owner.
Automatic braking system module System went out mid drive and Locked up the front right and back left brakes making vehicle immovable in the middle of the highway. Towed to a dealership where they had to remove and replace ABS module no warning lamps were present. No prior symptoms before failure.
NHTSA complaint #11739612 — an unverified report by a vehicle owner.
The vehicle has only been driven for 24K miles and there was an issue with the ABS Hydraulic Control Unit (HCU) and the recommendation is for it to be completely replaced. Seems ridiculous if the ABS Hydralic Control Unit is meant to last 100k-200k miles.
NHTSA complaint #11735649 — an unverified report by a vehicle owner.
ABS Hydraulic control unit pump malfunction. vehicles brakes locked up on the highway and could of caused an accident. this is a known and common issue with these vans. this type of thing shouldnt happen my vehicle has only has 67,000 miles on it. I have seen other report this issue with less miles than that. vehicle is now having the unit replaced.
NHTSA complaint #11734688 — an unverified report by a vehicle owner.
While traveling on the freeway after approximately 45 minutes of driving at 65 mph, the car suddenly felt like it was down shifting causing it to slow substantially. When I tried to accelerate to avoid cars behind me from hitting me, the car prevented me from speeding up for approximately five seconds. RPM is over 5000 b4 it allowed speed up. This happened on two separate occasions,. The car would not start after the second trip and was towed to a Ford dealer for repair. I was told I needed a new alternator and battery and what I experienced on the freeway was the alternator impacting the transmission. I picked up what I thought was a repaired vehicle, traveled to one of the same places I had gone previously and approximately 45 minutes into my drive, the same event took place with the car. Slowing severely and not allowing me to accelerate to return to freeway speed for approximately five seconds. It was taken back for repairs shortly thereafter. I was told it wasn't the transmission. It was a sensor in the brake system that causes the brakes to be applied just enough to create friction that heats up two of the wheels to such a high temp., the brake pads melted onto the rotors. The master cylinder, pads, rotors, sensors all needed replacement. The car is a 2019, purchased new, out of warranty with only 26,000 miles. Ford has offered to pay part of the repairs but expects me to pay the other portion. This car has been well cared for. Nothing I have done while driving it has caused their sensor to create such a dangerous situation on the freeway. It also started happening before it was driven to the dealership by refusing to move for five seconds every time the car came to a stop. I have read other accounts of the same situation happening to people who own the same model and year. This is a dangerous situation created by Ford's faulty equipment. The car is at Ford dealership waiting to be repaired for the 2nd time.
NHTSA complaint #11732535 — an unverified report by a vehicle owner.
One tire locks up gradually and then completely preventing the vehicle from being driven and causing damage to the other tires. The inability to drive the vehicle on the open road is very dangerous. There are no warning lamps. The vehicle may seem sluggish to accelerate. After towing to a service station, the ABS module failed and this caused damage to the brake master cylinder which had to be replaced.
NHTSA complaint #11713637 — an unverified report by a vehicle owner.
Two tires lock up gradually and then completely preventing the vehicle from being driven and causing damage to the other tires. The inability to drive the vehicle on the open road is very dangerous. There are no warning lamps. The vehicle may seem sluggish to accelerate. After towing to a service station, the ABS module failed and this caused damage to the brakes which had to be replaced.
NHTSA complaint #11713644 — an unverified report by a vehicle owner.
My van began with the brake sticking and it was not only the brake (with my van with only 34,000 miles on it) 2019 year, so I took it to Les Schwab to find out that it was a known default of the years of my van 2012 to 2019 that there have been countless replacement of the defect ABS Pump (costing me 2,000.00 to fix), and finding out that this same problem was where the did a recall on the 2016 Ford Transconnect Vans, but didn't honor other years even though it has been a known issue is many. This should have been a recall for my 2019, I barely even drive it.
NHTSA complaint #11710535 — an unverified report by a vehicle owner.
The right front (passenger side) brake caliper seize closed, pulling the vehicle to the right from uneven braking, and destroying the brake pads and rotor on that corner. Fortunately, this occurred on dry asphalt highway, and control was not entirely lost. The problem was diagnosed by the dealer to be the ABS module. This appears to be a common fault on the Transit Connect van and the Ford Focus Sedan/coupe, which shares the same general platform. This particular van is a 2019 model year, and was purchased new in August of 2020. It had 27,272 miles on it when the module failed in September of 2025, five years. The car’s bumper to bumper warranty expired after three years. The repair cost from the dealership, including consequential repairs to the pads, rotor and fluid, totaled $2,813.65. While there was no actual crash, the affected rotor became heated to a bright orange color.
NHTSA complaint #11695465 — an unverified report by a vehicle owner.
Jerks when accelerating, loses power, hesitates backing up, brake on left front does not release and overheats, right back brake following suit. Took into repair shop for brake service. Quote the inspection "Front passenger caliper seized no flow from house caused caliper to lock up." Was advised after rear right brake was found to be developing the same symptoms to have it towed to dealership for further inspection--risk of brake failure increasing likelihood of crash was cited as reasoning to default to dealership and no longer drive the vehicle.
NHTSA complaint #11694821 — an unverified report by a vehicle owner.
The brakes suddenly locked up while I was driving which could have caused an accident. Luckily it did not cause me to swerve into oncoming traffic and no one was behind me at the time. This was caused by the ABS unit hydraulic control assembly. It was the right front and left rear calipers locking. My vehicle only has 44,401 miles on it. The diagnosis has been confirmed at the dealer. There are other 2016 Ford Transit connect models that have had a safety recall for this specific component, but mine is just outside of the vehicle recall time period by a few months. It was manufactured at the same plant. Additionally, I wanted to add that there were no warning lights, though I noticed a very slight drag when first accelerating (a few days prior) but didn't think much of it. I wondered if I was just imagining things. It wouldn't have been noticeable to someone who wasn't used to driving it. I contacted Ford and they would not provide any assistance other than me having to start a case (in other words, I have to spend $2,100 to get it fixed at the dealer; also I can't get it fixed anywhere else because the dealer has to program it.)
NHTSA complaint #11687689 — an unverified report by a vehicle owner.
Damaged torque converter pump and foreward planetary assy bushings. Jerks when accelerating, loses power, hesitates backing up. Overhaul of torque converter, reseal and reassemble. Hydraulic control unit not working properly and break on left front does not release and overheats. Replaced hydraulic control unit. Airbox loose and damaged. Rattling. Replaced airbox.
NHTSA complaint #11682139 — an unverified report by a vehicle owner.
The brake pedal went down far and there was poor braking. The brake fluid was found to be leaking from the left front brake jounce hose. This was unsafe due to extended braking stop time and less braking ability. I am an ASE certified master technician and I work in a private vehicle fleet repair facility. I did not interview the driver if the BRAKE warning light came on but most likely it did due to brake fluid leaking fast from this line. We also had a failure of this type on a 2019 Ford Transit Connect which is also in our fleet. So it appears Ford has another problem with front brake jounce hose failures.
NHTSA complaint #11673142 — an unverified report by a vehicle owner.
After placing vehicle in Park, vehicle rolled away and destroyed my mailbox. Luckily I was able to stop it inches away from neighbors car. There is a recall for other years, but none for this year. The vehicle has not been inspected by a dealer yet, however, after talking to the dealership service department, it is a common problem and would cost a lot to repair
NHTSA complaint #11649597 — an unverified report by a vehicle owner.
The left front wheel locked up. The dealership first replaced the brake line. When that didn’t repair the problem they said they’d need to replace the ABS Module. The vehicle has less than 30,000 miles. Online it appears that ABS Module failure is a common problem in Ford vehicles with the 2.0 four cylinder engine dating back to 2010.
NHTSA complaint #11641040 — an unverified report by a vehicle owner.
ABS brakes are locked up and only release after a few seconds. I have replaced the driver front caliper and now the passenger front is locking. After a quick search online, I have found several cases of the ABS module malfunctioning on this vehicle requiring a new module and programming. The first time the driver side locked, there were no warning lights and when I arrived home, the rotor was glowing red. Could have caused a fire.
NHTSA complaint #11639972 — an unverified report by a vehicle owner.
1 Transmission: very harsh shift engagements up shift and downshifting. Harsh downshifting while cornering and approaching intersections made me concerned for my safety. Random slipping in mid gears 3,4, or 5, no DTC's for slipping or harsh engagements. Transmission currently has the DTC: P0772 Shift Solenoid E Stuck On. and is not drive able. Vehicle is in my driveway until I determine where to take it. I am concerned why my vehicle Vin isn't listed in the transmission recalls when I'm having the exact same problem as the recalled vehicles. 2 Brakes: February 2024 ABS Unit. When driving on highways at speeds between 45-65mph, when I would release my foot off the gas pedal the vehicle would apply medium pressure to the braking system (without touching the brake pedal). Vehicle was taken to Nazareth Ford, they replaced a front brake hose and cycled the Anti-lock Brake System unit. I drove back on the highway and the same thing happened, brakes applied when letting off the gas pedal, almost causing an accident. I replaced the ABS unit myself and had Nazareth Ford program the software. Problem solved. I still have the old ABS unit available for inspection.
NHTSA complaint #11635748 — an unverified report by a vehicle owner.
1. The 2019 Transit Connect Wagon transmission would buck or jerk when removing my foot from the accelerator when going 60 mph or more. The brake was NOT press at the time of the jerk. 2. When entering the Ford Service Center for the transmission check appointment, the left front brake seized. There was an odor of burning brake pads. 3. After the brake module was replaced and the service center took it for a test drive of the transmission, the technician told me the lighting module needed to be replaced and the vehicle continued to stay at the service center. 4. While still at the service center, they connected the vehicle for a computer reboot/refresh that would take over night. The next morning they informed me that the reboot did not take in the vehicle computer system. 5. The service center called in a regional Ford Technician three times to try to solve the issues without success. 6. We never had possession of the vehicle during this time. It continues to be in possession of the service center and to our knowledge is not repaired. 7. The "service engine" red light NEVER came up on the instrument panel when the incident happened.
NHTSA complaint #11630506 — an unverified report by a vehicle owner.