117 of the 892 complaints about the 2019 GMC Sierra 1500 are about the braking system — 13% of everything reported for this model year. Half of the failures with a mileage on record happened before 7,997 miles.
117
Complaints
5
Crashes
0
Fires
2
Injuries
Filed with NHTSA, in their own words.
SERVICE BRAKES
I am getting warning signs on the dashboard saying that my brake booster performance has failed and I need to service the brake booster , the brakes are very hard to press, I need longer stopping distances,and traction control and stability control towing harness my speed has been limited to 43 mph and it's saying that the mass air flow system is has low circuit
NHTSA complaint #11735386 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving approximately 5 MPH, the rear wheels locked up. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the brakes needed to be replaced. The vehicle was repaired; however, the failure recurred intermittently. The vehicle was taken to another local dealer, Walker Bros Chevrolet (700 Erie St, Edinboro, PA 16412); for a second opinion, and the transmission and TCM were replaced. The vehicle was repaired; however, the failure reoccurred. Upon further investigation, the contact related the failure to the Customer Satisfaction Program: N192272400; however, the VIN was not included. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 40,000.
NHTSA complaint #11731897 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
The contact's partner owns a 2019 GMC Sierra 1500. The contact stated that upon starting the vehicle, the "Service Brake System" and ABS warning lights illuminated. The brake pedal was depressed to the floorboard, and the message that the vehicle would not exceed 62 MPH was displayed. The vehicle was restarted, and several unknown warning lights were illuminated with a message that the vehicle would not accelerate above 42 MPH. The vehicle was taken to a dealer, where a diagnostic test was performed and the diagnostic test revealed that the brake pipe had seized in the brake master cylinder and that the pipe fitting threads were damaged. The contact was informed that the brake master cylinder and the reservoir seal needed to be replaced. Despite the repair, the dealer stated that the master cylinder and brake line fitting were still defective. After several additional repairs to the brake system, the vehicle was returned to the owner. Upon driving the vehicle, the contact stated that the prior brake warning lights returned on the instrument panel. The vehicle was returned to the dealer and remained with the dealer. Upon investigation, the contact discovered NHTSA Campaign Number: 20V055000 (Service Brakes, Hydraulic); and associated the failure with the recall. The manufacturer was notified of the failure, and the contact was informed that the vehicle was not included in the recall. The contact was then given a case number. The contact was also transferred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was 42,320.
NHTSA complaint #11729002 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the brakes seized. No warning lights were illuminated. The contact parked the vehicle. The contact inspected the vehicle; however, the failure reoccurred. The contact attempted to drive the vehicle several times, but the failure reoccurred. The contact stated that the failure was persistent. Due to the failures, the contact was almost in two crashes. The vehicle was towed to an independent mechanic, where it was diagnosed with a brake module reset. The independent mechanic contacted the dealer and was informed that the brake module needed to be reset. The technician from the dealer installed the software for the brake module reset, and the vehicle was repaired. The vehicle was retrieved, but the failure reoccurred a month later. The vehicle was towed to the dealer, and the contact was informed that the vehicle needed to be inspected by the engineer. The vehicle was not diagnosed or repaired. The contact was advised to continue driving the vehicle. The contact was advised to disable all the safety features. The contact stated that two major crashes were averted and refused to drive the vehicle until it was repaired. The contact stated that the failure was common with the vehicle. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 68,000.
NHTSA complaint #11720355 — an unverified report by a vehicle owner.
SERVICE BRAKES
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at various speeds, the braking system had erroneously activated, causing the vehicle to abruptly stop in the middle of the road. The vehicle was towed to the local dealer, who diagnosed that the failure was caused by an engine malfunction of the number six cylinder. The vehicle was repaired. No further information was available. After retrieving the vehicle, the contact was driving approximately 10 MPH when the failure reoccurred and the braking system erroneously activated, causing the vehicle to abruptly stop. During the incident, the driver's head slammed into the steering wheel, causing a head laceration. No medical treatment was required. The vehicle was towed back to the dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 120,000.
NHTSA complaint #11712899 — an unverified report by a vehicle owner.
SERVICE BRAKES
THE VEHICLE IS AVAILABLE FOR INSPECTION - 35,000 APPROXIMATE MILES WITH A EBCM MODULE REPAIR NEEDED IN ORDER TO REPAIR IT TO A LEVEL THAT MEETS FEDERAL MOTOR VEHICLE SAFETY STANDARDS OF AT MINIMUM S5.3 NO.126 & S5.1 NO. 135 - I BELIEVE THIS VEHICLE SHOULD HAVE BEEN/SHOULD BE INCLUDED IN THE ORIGINAL AND/OR EXPANDED RECALL N192268091. THE VEHICLES ELECTRONIC BRAKE ASSIST IS NOT WORKING CAUSING IT TO BE DISABLED. IT HAS BEEN INSPECTED BY DENNY MENHOLT GMC. WARNING LAMPS/MESSAGE OCCURRED - DIAGNOSED - REPAIR NEEDED TO MAKE THIS VEHICLE SAFE FOR THE DRIVER, PASSENGER(S) AND OTHERS WHEN THE VEHICLE IS OPERATING.
NHTSA complaint #11707766 — an unverified report by a vehicle owner.
SERVICE BRAKES
While driving in my uncongested neighborhood, my brakes totally failed. Dash indicated multiple brake failure warnings. I managed to get my truck stopped and returned home by engaging my low range, four wheel drive. If I had been in on the open road, going down a hill, negotiating a curve, or in traffic a crash would have ocurred, potentially fatality. My vehicle was towed to a GMC dealership. They diagnosed the problem in the electronic braking module with a software update needed. My vehicle Is a 2019, but had only 23,283 miles at the time of the braking failure.
NHTSA complaint #11699412 — an unverified report by a vehicle owner.
PARKING BRAKE
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving on three occasions and stopped, the vehicle started shaking abnormally. The check engine warning light was illuminated, and the message to "Check Parking Brake" was displayed. The contact engaged and disengaged the parking brake. The vehicle was taken to the dealer where it was diagnosed and determined that the lifers and cam shaft needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 74,000.
NHTSA complaint #11682425 — an unverified report by a vehicle owner.
SERVICE BRAKES
Ok I know my vin don't go under the 10 recalls for 2019 gmc sierra limited 1500 rwd, but my truck has the same problem with the brake module has those recalls I feel like gmc might have used different parts for the other recall but used the same brake module for my truck cause I have that same problem has the recall. It's obviously a issue that needs to be look in and my brake module should be fixed by gmc
NHTSA complaint #11661191 — an unverified report by a vehicle owner.
SERVICE BRAKES
This is a second report of an issue that first happened in February 2025, the dealer replaced the battery and called it fixed. On Friday 5-2-2025 I started the vehicle and as I was driving the dash lit up with these warnings: Service Trailer brake system, Service ESC, Brake System Failure 62 mph top speed, Steering assist reduced drive with care, The vehicle steering got stiff and brake pedal went to the floor board with a little braking available if I stood very hard on the brake pedal. I got off to the side of the road, cycled the truck on and off and was able to drive off. It did this three times before I could get it to the dealer the next day, If my daughter was driving I would have expected that two of the three would have resulted in a wreck as she would not have been strong enough to steer or stop the vehicle. The dealer had it three days and replaced the brake master cylinder and called it fixed, I picked the vehicle up and on the way home I stopped for gas, after the gas station the dash displayed: Service brake assist, I turned right around and took it back to the dealer, they checked the code and said the brake assist module was drawing too much current, I picked the vehicle back up three days later, they said they bleed the air out of the brake system and called it fixed. No one wants to ride with me and my daughter is begging me to trade the truck, they call it a death trap waiting to happen. GM says it is all normal issues.
NHTSA complaint #11661258 — an unverified report by a vehicle owner.
SERVICE BRAKES
Ebcm software update errors
NHTSA complaint #11658445 — an unverified report by a vehicle owner.
SERVICE BRAKES
6.2L v8 the same as 2021 to 2024 engine built the same way and im experiencing the same issues and the dealership wont fix it , i would like to get a response if this will be included or should i file a lawsuit and take legal action thank you
NHTSA complaint #11658278 — an unverified report by a vehicle owner.
SERVICE BRAKES
I was traveling north on interstate 95 and approaching my exit ramp. I was initially in the inside lane of travel. I accelerated to merge into the outside lane, between two other vehicles, and then onto the exit ramp. Once on the exit ramp, I let off of the throttle and the engine suddenly shut down. I noticed a message on driver information center instructing me to shift the vehicle into neutral and press "start again". The engine had shut down without any warning whatsoever. I complied with the instructions to no avail. The truck is over half full of fuel. I was within an hour of home after completing an approximately 8 hour, 500 mile, round trip over 2 days of driving. After this event, I connected an OBD2 scanner and the only code found was P25A2 brake system control module. I placed the truck in park and tried repeatedly to start the engine. It would not turn over, crank or start. I had power to all systems and no other codes. I had to have the truck towed from the scene. The truck's performance had previously been flawless during this entire trip and had given me no warning whatsoever of the sudden engine shutdown. This is extremely dangerous and a safety concern.
NHTSA complaint #11645829 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving approximately 20 MPH, the vehicle came to a screeching stop. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the electronic brake control module had short-circuited and there was a miscommunication, which engaged the parking brake and locked up the rear wheels. The vehicle was not repaired. The vehicle was previously taken to the same dealer on two occasions and repaired under NHTSA Campaign Number: 19V889000 (SERVICE BRAKES, HYDRAULIC, SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC); however, the failure recurred. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 7,000.
NHTSA complaint #11643365 — an unverified report by a vehicle owner.
SERVICE BRAKES
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving approximately 20 MPH, the vehicle came to a screeching stop. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the electronic brake control module had short-circuited and there was a miscommunication, which engaged the parking brake and locked up the rear wheels. The vehicle was not repaired. The vehicle was previously taken to the same dealer on two occasions and repaired under NHTSA Campaign Number: 19V889000 (SERVICE BRAKES, HYDRAULIC, SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC); however, the failure recurred. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 7,000.
NHTSA complaint #11643365 — an unverified report by a vehicle owner.
SERVICE BRAKES
Vehicle was having trouble accelerating, like the parking brake was on. Then received a message that the brake system failed, lane assist failed, and I couldn’t drive faster than 43 mph. Then a message about the trailer brake appeared
NHTSA complaint #11643486 — an unverified report by a vehicle owner.
SERVICE BRAKES
On a normal trip to work the dash light lit up then gave me these warnings. Service ESC, Service Trailer brake, Brake system Failure-62 mph top speed, steering assist reduced. Dashboard lights that were on, ABS Check Engine, Brake, Traction Control. When I tried to slow down the power assist was gone on the brakes, I had a little braking when I pushed the pedal all the way to the floor as hard as i could, when I went to turn the wheel was hard to turn. I have had no issues like this before. After I managed to stop and turn off then on the vehicle everything came back expect for a warning to service the trailer brakes and the check engine light was still on. It all cleared after a few more restarts. I got the truck to the dealer 4 days later and they said it was the battery going bad even though I was not having any problem starting the vehicle, I had them replace the battery. I am unsure if the problem is resolved, time will tell. What I am sure of is if my daughter had been driving the truck, she would not have had the strength to get the brakes to work or turn the wheel, she would have had a accident for sure.
NHTSA complaint #11642476 — an unverified report by a vehicle owner.
SERVICE BRAKES
Truck showed check engine light and popup message to Service ESC, vehicle disable traction control. Before being able to have the vehicle scanned for error codes (after sitting parked turned off for a while, all errors cleared. Several days later when turning vehicle on traction control warning light, parking break warning light, and stability control warning light all turned on, service ESC message popped up again, PRNDL position indicator light turned off and vehicle began to have a clicking noise in the steering column when break was pressed. There is a multiple year long thread on this topic on the silveradosierra forum entitled "service-esc-and-service-power-steering" it appears that dealer and GM help are limited and the issue often goes away and recurs.
NHTSA complaint #11617659 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 GMC Sierra 1500. The contact stated while making a left turn, the steering wheel was yanked to the left. The contact stated that the "Service ESC and Power Steering" message was displayed. The vehicle was taken to the residence. On another occasion, the following day while making a right turn, the steering wheel was yanked to the right. Additionally, the contact stated that the steering wheel was firm and difficult to turn. The contact stated that a "Service ESC and Power Steering" message was displayed. The vehicle was steered to the side of the road. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 19V889000 (Service Brakes, Hydraulic, Service Brakes, Electronic Stability Control (ESC). The manufacturer was notified of the failure. The failure mileage was 85,502.
NHTSA complaint #11583826 — an unverified report by a vehicle owner.
SERVICE BRAKES
Complete system failure while driving. Lost control of vehicle, no breaks. Had it brought to dealership. Lifter failure and bent rod, top engine failure which caused everything to malfunction. Vehicle has 88K miles on it. This is a defect. We had taken it in for the ticking problem in the past and they did nothing for us. Everything is documented. We are afraid that bottom half of engine was compromised. Do not feel safe driving this vehicle anymore. I do not want it to blow or lose control of vehicle again. This is a known issue and must be addressed. There was a service bulletin put out for my engine and there is an exact part by part that needs to be replaced, however GM is unwilling to listen to us at this time. Please look into this because this will happen to more and more consumers. This is very scary. What is the cost of a life?
NHTSA complaint #11574417 — an unverified report by a vehicle owner.
SERVICE BRAKES
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 45 MPH, the service brakes were inoperable, and the vehicle experienced phantom braking. The vehicle came to a complete stop on the highway. The vehicle was towed to an independent mechanic however, the failure could not be duplicated. The contact called and made the dealer aware of the failure. The contact stated that the failure was intermittent. Additionally, the speed odometer was inoperable. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 70,000.
NHTSA complaint #11557941 — an unverified report by a vehicle owner.
SERVICE BRAKES
Electrical short on brake booster performance error code c0021 while operating vehicle . Brake pedal became stiff and higher than where I had it . Vehicle making hissing noises and will no longer start due to this error. Safety concern this is not part of a recall list. I nearly crashed. I had to utilize emergency brake.
NHTSA complaint #11555867 — an unverified report by a vehicle owner.
SERVICE BRAKES
I put my truck in break. Service mode to replace the brake pads. I began changing the pads And could not get the piston to retract all the way, I hooked uon a c clamp to retract the piston. In the event i moved the rotor to another spot and the brake service mode turned off and the piston extended. My fingers nearly got caught in the caliper. When put in brake service mode, it should not automatically extend when turning the rotor. Someone will get hurt bad at some point in a swrvice garage or at home when wirking on brakes.
NHTSA complaint #11555831 — an unverified report by a vehicle owner.
SERVICE BRAKES
Question #1- “Service Trailer Brake System”-“Steering Assist is Reduced Drive with Care”-Brake System Failure 43 MPH Top Speed”-“Service ESC” Question #2- I experienced a Complete loss of braking ability, myself, a friend and, a coworker, as well as the properties around me where placed at risk. Question #3 Not yet I am having towed to the dealer today. Question #4 Not yet the vehicle will be towed to the dealer where I purchased it today. Question #5 Not my knowledge I do not recall any warning lights.
NHTSA complaint #11550005 — an unverified report by a vehicle owner.
SERVICE BRAKES
Were driving and vehicle repeatedly suddenly braked in the middle of interstate or highway without any warning. We are so traumatized, and scared of this vehicle. It has happened before. Dealership says there is nothing they can do. This could have caused our life. GMC should be held accountable.
NHTSA complaint #11532538 — an unverified report by a vehicle owner.
SERVICE BRAKES
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 45 MPH, the vehicle started to decelerate independently, and the steering wheel became difficult to turn. The contact stated that several unknown warning lights were illuminated. The contact was able to park the vehicle safely off the highway. The vehicle was not drivable. The contact towed the vehicle first to his residence and then the following day to an independent mechanic and was informed that the Electronic Brake Control Module (EBCM) needed to be replaced. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 19V889000 (Service Brakes, Hydraulic, Service Brakes, Electronic Stability Control) however, the VIN was not included. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 133,000.
NHTSA complaint #11529427 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 45 MPH, the vehicle started to decelerate independently, and the steering wheel became difficult to turn. The contact stated that several unknown warning lights were illuminated. The contact was able to park the vehicle safely off the highway. The vehicle was not drivable. The contact towed the vehicle first to his residence and then the following day to an independent mechanic and was informed that the Electronic Brake Control Module (EBCM) needed to be replaced. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 19V889000 (Service Brakes, Hydraulic, Service Brakes, Electronic Stability Control) however, the VIN was not included. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 133,000.
NHTSA complaint #11529427 — an unverified report by a vehicle owner.
SERVICE BRAKES
driving home at low speed truck would hardly stop took it to dealer-suburban gmc troy mi. received a letter afterwards that brake control module was not repaired properly and needed to return for repair truck showed about 15000 miles on odometer April 2020 and showed 51% brake life on rear brakes-when I asked if brake were worn I was told no and dashboard now read 91% brake life on rear brakes-in March2023 with 28000 miles on the odometer my brake monitor alert came on and when I returned to the dealer I was told that my rear brakes were down to 15% and needed to be replaced. Everyone tells me front brakes should wear out first and rear brakes should last much longer.
NHTSA complaint #11526244 — an unverified report by a vehicle owner.
SERVICE BRAKES
I were driving at low speed and all 4 wheels locked causing the vehicle to suddenly stop without notice. I almost got rear ended. I had to put vehicle in park and turn off and turn back on to get it to move. Again it did the same thing stoping with brakes locking suddenly, almost causing an accident in middle of road. There was no warning at all.
NHTSA complaint #11521625 — an unverified report by a vehicle owner.
SERVICE BRAKES
Was driving around 70 MPH brakes started engaging and disengaging truck felt like engine was missing, brake light luminated and stated to stop vehicle ABS light luminated as I got to the emergency lane I had no brakes pedal went to floor and I came to a stop after coasting and pressing pedal. Once stopped trailer towing light luminated ( I was not towing anything). I exited truck and it was apparent this was a issue with the front brakes as they were smoking. Rotors appear to have marks in them when compared to rear. After about 30 minutes I started truck and there was no indication on dash of a problem had brake pedal. The truck has 50800 miles on it. Contacted dealer (Hendricks Chevy) this morning they said it was not covered and no recalls I discussed brake issues I read on line again they repeated no recalls in system for my truck, but would be glad to look at it in 2 weeks.
NHTSA complaint #11518659 — an unverified report by a vehicle owner.