22 of the 906 complaints about the 2007 Hyundai Sonata are about the body and structure — 2% of everything reported for this model year. Half of the failures with a mileage on record happened before 82,000 miles.
22
Complaints
3
Crashes
0
Fires
1
Injuries
Filed with NHTSA, in their own words.
STRUCTURE:BODY
AIRBAG ON THE PASSAGE SIDE WON'T GO OFF, SEATBELT GET STUCK AT TIME, PAINT PEELING OFF THE BODY BACK ,SIDE AND TOP AND THE WINDOW ON THE PASSAGE SIDE WON'T GO DOWN
NHTSA complaint #11349879 — an unverified report by a vehicle owner.
STRUCTURE:BODY
DOOR HANDLES HAVE ALL FALLEN OFF THE OUTSIDE OF THE CAR
NHTSA complaint #11089200 — an unverified report by a vehicle owner.
STRUCTURE:BODY
REAR PASSENGER SIDE HANDLE FELL OFF, REAR DRIVERS SIDE HANDLE STOPPED WORKING. ELECTRICAL GOES IN AND OUT (I.E. WINDOWS, LOCK AND UNLOCK, CRUISE CONTROL) VEHICLE WAS STATIONARY WHEN HANDLES STOPPED WORKING OR CAME OFF IN HAND ATTEMPTING TO OPEN DOOR. ELECTRICAL HAPPENS WHEN VEHICLE IS ON AND OFF STATIONARY AND IN MOTION.
NHTSA complaint #11062303 — an unverified report by a vehicle owner.
STRUCTURE:BODY
DRIVER DOOR LATCH WEAKENS OVER TIME AND FAILS TO FULLY SEAL. DOOR WILL NOT FULLY STAY FULLY CLOSED. 'DOOR OPEN' CHIME AND LIGHTS WILL GO OFF WHILE DRIVING WHEN GRAVITY AND INERTIA AFFECT THE DOOR. DOOR DOES NOT SWING OPEN WHILE DRIVING BUT IS NONETHELESS A SAFETY ISSUE. THIS PART SHOULD BE CONSIDERED A LIFETIME PART ABLE TO HANDLE MUCH MORE STRESS THAN THE TYPICAL LIFE OF A CAR.
NHTSA complaint #11006086 — an unverified report by a vehicle owner.
STRUCTURE:BODY
ONE MORNING ON MY WAY TO WORK, I PLACED THE KEY IN THE IGNITION SWITCH AND TRIED TO START THE VEHICLE, BUT IT WOULD NOT START. I TURNED THE KEY OVER SEVERAL TIMES AND IT FINALLY STARTED UP. THIS HAPPENED ON SEVERAL DIFFERENT OCCASIONS WHETHER I WAS AT HOME, WORK, OR ANYWHERE IN PUBLIC. I THOUGHT IT WAS THE STARTER BASED ON MY EXPERIENCE WITH OTHER VEHICLES AND I WAS GOING TO HAVE IT REPLACED. THEN I STARTED HAVING ISSUES GETTING INTO THE CAR. I WOULD TRY TO UNLOCK THE DRIVER'S DOOR WITH THE KEY AND IT WOULD NOT UNLOCK THE FIRST TIME. I WOULD HAVE TO UNLOCK IT AGAIN (ESSENTIALLY UNLOCKING ALL OF THE DOORS) AND THEN THEY WOULD LOCK. I ALSO STARTED HAVING ISSUES LOCKING THE CAR DOORS FROM INSIDE THE CAR. I WOULD PRESS THE LOCK SWITCH ON THE DRIVER'S DOOR AND ALL OF THE DOORS WOULD LOCK EXCEPT FOR THE DRIVER'S DOOR. IT ONLY LOCKS IF I MANUALLY PUSH THE LOCK SWITCH. I DECIDED TO RESEARCH THE ISSUE SO I WENT AND READ SOME ONLINE DISCUSSION BOARDS. THERE WERE HUNDREDS OF PEOPLE WHO HAD THE SAME ISSUE AND I FIGURED THAT PERHAPS IT WAS A BAD SENSOR SO I TOOK THE CAR TO A HYUNDAI DEALER. I ASKED THEM TO DIAGNOSE THE PROBLEM AND THEY CAME BACK AND SAID THAT THE ELECTRICAL SYSTEM NEEDED TO BE REPLACED. THEY TOLD ME THAT EVENTUALLY I WOULD NOT BE ABLE TO USE THE KEY AND THAT I MIGHT NOT BE ABLE TO GET IN THE CAR OR START IT AGAIN BECAUSE OF THIS ISSUE. ON A SEPARATE ISSUE, WHENEVER IT RAINS WATER GETS IN THE TRUNK GATE. WHEN I LIFT THE TRUNK GATE UP WATER COMES RUNNING DOWN INTO THE TRUNK. I HAVE HAD TO LIFT IT UP ONE QUARTER, THEN HALF WAY, THEN THREE QUARTERS WAY ALLOWING WATER TO RUN DOWN ALONG THE TRACK AND OUT OF THE TRUNK GATE. IF I AM LUCK ONLY A HANDFUL OF WATER EVER MAKES IT INTO THE TRUNK.
NHTSA complaint #10950155 — an unverified report by a vehicle owner.
STRUCTURE:BODY
HYUNDAI HAS A PROBLEM WITH "SUDDEN UNEXPECTED ACCELERATION" I HAD MY FIRST PROBLEM WITH MY 2005 ELANTRA , AND NOW AGAIN WITH MY 2007 SONATA. THE HYUNDAI DEALERSHIP HERE IN ST. GEORGE UTAH IS NOT DOING ANY THING ABOUT THIS, THE SONATA WAS IN MOTION WHEN THE CAR ACCELERATED ON ITS OWN, THIS HAS TAKEN PLACE MORE THAN ONCE, THE LAST TIME THE CAR WAS STOPPED BY A FENCE...WHAT WILL IT TAKE FOR HYUNDAI TO DO SOMETHING ABUT THIS?
NHTSA complaint #10926678 — an unverified report by a vehicle owner.
STRUCTURE:BODY
LAST WEEK, I HAD TO HAVE THE FOURTH DOOR HANDLE (ALL, NOW) REPLACED BECAUSE THE PLASTIC BREAKS OFF. THE VEHICLE HAS 65455 MILES. THE FIRST HANDLE REPLACED WAS WHEN THE CAR WAS STILL UNDER WARRANTY. THIS DEFECT IS UNACCEPTABLE. THE NHTSA SHOULD FORCE A RECALL NOTICE ON THESE. THE LATEST BROKEN HANDLE WAS ON THE DRIVER SIDE. IN THE EVENT THE CAR WAS SUBMERGED, OR A CHILD OR PET WAS LEFT IN A HOT CAR, A RESCUER WOULD NOT BE ABLE TO OPEN THE DOOR TO RESCUE THOSE INSIDE. THIS IS A SERIOUS SAFETY CONCERN, AND A NEEDLESS EXPENSE FOR VEHICLE OWNERS.
NHTSA complaint #10908469 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE CAR WAS INVOLVED IN AN ACCIDENT IN CITY STREETS OF HIALEAH FLORIDA ON A 4 WAY STOP(MY SON WAS DRIVING) AND WAS DECLARED TOTAL LOSS BY INSURANCE COMPANY NONE OF THE AIRBAGS DEPLOYED. HE HIT MID DRIVERS SIDE OF A A FLAT BED TRUCK AND FRONT OF MY CAR WAS CRUSHED. THANK GOD MY SON IS OK. WITH THE AMOUNT OF DAMAGE ON THE CAR ONE OF THE AIRBAGS SHOULD HAVE DEPLOYED. I HAVE REPORTED THIS INCIDENT TO HYUNDAI AND HAVE NOT RECEIVED ANY COMMENT FROM THEM YET
NHTSA complaint #10817625 — an unverified report by a vehicle owner.
STRUCTURE
TL* THE CONTACT OWNS A 2007 HYUNDAI SONATA. WHILE DRIVING AT AN UNKNOWN SPEED, THE PASSENGER SIDE SUN VISOR BECAME DETACHED AND OBSTRUCTED THE VIEW OF THE DRIVER. AFTER RESETTING THE VISOR IN THE UPWARD POSITION, THE VISOR CONTINUED TO DETACH. THE DEALER STATED THAT THE VISOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 30,000.
NHTSA complaint #10606966 — an unverified report by a vehicle owner.
STRUCTURE:BODY
ON MAY 17TH, 2014 I WAS IN AN ACCIDENT ON INTERSTATE 95 IN BROWARD COUNTY, FL. A DRUNK DRIVER HIT ME ON THE LEFT SIDE OF MY TRUNK THEN HIT THE CEMENT MEDIAN THEN CAME BACK AND HIT ME IN THE MIDDLE OF MY DRIVER SIDE AND BACK DRIVER SIDE DOOR, THEN HIT THE MEDIAN AGAIN CAME BACK TOWARDS MY CAR AND FLIPPED AND HIT THE FRONT LEFT SIDE OF MY VEHICLE. SO BASICALLY THE WHOLE LEFT DRIVER SIDE OF MY CAR IS SMASHED IN. I WAS WEARING MY SEAT BELT WHEN THIS ACCIDENT DID OCCUR. WHAT MY CONCERN IS, I DID SOME RESEARCH AND IT STATES THE NOTABLE FEATURES INCLUDED ON THIS VEHICLE IS SIX AIRBAGS STANDARD. NOT ONE AIRBAG DEPLOYED AND IF I WASN'T WEARING MY SEAT BELT I WOULD HAVE BEEN THROUGH THE FRONT WINDSHIELD AND PROBABLY LOST MY LIFE. MY ENTIRE LEFT SIDE OF MY BODY IS DAMAGED AND THE MORE SEVERE INJURY IS TO MY LEFT LEG AND FOOT. WITH THE EXCEPTION OF MY LEFT BIG TOE, ALL OTHER FOUR TOES HAVE NO FEELING IN THEM AND MY FOOT IS DEFORMED. I DO PLAN ON TAKING THIS ISSUE TO MY ATTORNEY THAT IS HANDLING THE ACCIDENT CASE FOR ME AND HOPEFULLY HYUNDAI HAS A VERY CLEAR EXPLANATION FOR WHY NOT ONE OF THE 6 AIRBAGS DEPLOYED.
NHTSA complaint #10593411 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR
BOTH OUTSIDE DOOR HANDLES BROKE OFF.
NHTSA complaint #10559076 — an unverified report by a vehicle owner.
STRUCTURE
I TOOK THE CAR IN FOR A RECALL ON THE OCS AND THE DEALER FOUND TWO FAULT CODES B1701 AND B1706 INDICATING THAT BOTH PASSENGER AND DRIVERS SIDE BELT PRETENSIONERS RESISTANCE IS TOO HIGH.I SEE THERE ARE MANY 2006 AND 2007 SONATAS WITH A SIMILAR ISSUE. WITH THE NUMBER OF REPEATED COMPLAINTS I THINK THERE SHOULD BE A SAFETY RECALL OR SOME REIMBURSEMENT FOR REPAIRS !!!!!!!!!!!!
NHTSA complaint #10552865 — an unverified report by a vehicle owner.
STRUCTURE:BODY
DRIVER'S SIDE VISOR FELL AND DISTRACTED DRIVER WHO SWERVED. THE VISOR WILL GO UP BUT CONTINUES TO FALL AT ERRATIC TIMES. THE PASSENGER VISOR WILL NOT STAY UP AT ALL. THE MANUFACTURER REFUSES TO FIX THIS PROBLEM.
NHTSA complaint #10549824 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR
THE DOOR HANDLE ON THE OUTER PASSENGER SIDE BROKE LOOSE. NOW THE DOOR CANNOT BE OPEN FROM OUTSIDE. I FIND SO MANY COMPLAINS ON THE WEBSITE FOR THE SIMILAR PROBLEMS.
NHTSA complaint #10549621 — an unverified report by a vehicle owner.
STRUCTURE:BODY
VISOR KEEPS DROPPING DOWN WITHOUT WARNING.
NHTSA complaint #10525380 — an unverified report by a vehicle owner.
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
THE WHEELS ARE SHOWING AN EXTRAORDINARY AMOUNT OF RUST. I HAVE OWNED OVER TWELVE CARS AND HAVE NEVER SEEN RUST ON ANY WHEELS. THIS ONE HAS SHOWN RUST FROM 2009 AND IT HAS GOTTEN WORSE. I AM CONCERNED IF THIS WILL EFFECT THE SAFETY AND STABILITY OF THE WHEEL STRUCTURE. ARE THESE WHEELS CONSTRUCTED WITH THE SAME TYPE OF MATERIALS THAT THE CURRENT INVESTIGATION OF THE 2006- 2008 HYUNDAI SONATA'S BUMPER/STRUCTURAL RUST ISSUES? ARE THE WHEELS ALSO UNDER INVESTIGATION LIKE THE UNDERCARRIAGE?
NHTSA complaint #10508191 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR
I HAVE HAD THREE DOOR HANDLES BREAK OFF OF THIS CAR. THE FIRST WAS 3/12/2012; THE SECOND 3/26/2012; AND THE THIRD WAS 9/4/2012. THE BREAK WAS THE SAME ON THE LAST TWO CAUSE ME NOT TO ACCESS ENTRY. THE HANDLE HAS A DEFECT AT A MOLD POINT THAT SNAPS OFF LEAVING THE HANDLE IN THE HAND OF THE OWNER COMPLETELY DETACHED. THE DEALER AND CORP OFFICES REFUSE TO ASSIST CLAIMING IT IS OUT OF WARRANTY.
NHTSA complaint #10473977 — an unverified report by a vehicle owner.
STRUCTURE
BOTH VISORS ON MY 2007 SONATA DO NOT STAY IN PLACE, I HAVE CONTACTED HYUNDAI AND THEY ARE UNSYMPATHETIC TO MY SITUATION DUE TO THE MILEAGE, 72,000, OUT OF WARRANTY. ALSO, BOTH OF MY REAR DOOR HANDLES HAVE BROKEN. I HAVE TO REACH AROUND TO INSIDE OF DOOR TO OPEN REAR DOOR.
NHTSA complaint #10383386 — an unverified report by a vehicle owner.
STRUCTURE
DOOR HANDLE ON DRIVER'S SIDE INTERIOR STOPPED "CATCHING" WHILE TRYING TO OPEN DOOR. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS VEHICLE. HAVE TO OPEN WINDOW TO OPEN DOOR FROM OUTSIDE. CHEAP, PLASTIC MANUFACTURING. WHAT IF I NEEDED TO GET OUT OF THE CAR DURING AN ACCIDENT. OPENING THE WINDOW OR CLIMBING THROUGH ANOTHER DOOR MAY NOT BE AN OPTION.
NHTSA complaint #10350797 — an unverified report by a vehicle owner.
STRUCTURE
I HAVE A 2007 HYUNDAI SONOTA AND BOTH OF THE SUN VISORS HAVE BROKEN. THEY WILL NOT STAY UP AND OUT OF MY LINE OF VISION WHEN I AM DRIVING. THEY DID NOT BREAK UNTIL A FEW HUNDRED MILES OUT OF WARANTY, AND THE DEALERSHIPS WANT OVER $250 TO FIX THEM WHICH I CANNOT AFFORD. SINCE THEY BLOCK MY SIGHT I FEEL THAT THIS A DANGER THAT NEEDS TO BE LOOKED INTO. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #10345778 — an unverified report by a vehicle owner.
STRUCTURE:BODY
I HAD TAKEN MY 2007 HYUNDAI SONATA TO TOWNE HYUNDAI IN DENVILLE, NJ. THE XM RADIO MYSTERIOUSLY STOPPED WORKING ONE DAY. XM CORPORATION HAD DONE TROUBLESHOOTING WITH THE CAR AND DETERMINED THAT THE SIGNAL WAS REACHING THE CAR AND ADVISED ME TO BRING IT TO HYUNDAI. HYUNDAI NOTED THAT THE TOP BOX FOR THE XM RADIO WHICH IS LOCATED IN A GULLEY IN THE TRUNK BEHIND THE REAR PASSENGER WHEEL HAD RUSTED AND THAT THERE WAS WATER IN MY TRUNK. I WAS PROVIDED WITH A COPY OF A TECHNICAL SERVICE BULLETIN THAT HYUNDAI HAD WRITTEN NOTING THAT "WATER MAY ENTER THE TRUNK THROUGH BODY SEAMS, WELDS, BODY PLUGS" AND THAT ANY SUSPECT WATER ENTRY POINT WOULD NEED TO BE SEALED TO CORRECT FURTHER DAMAGE FROM OCCURRING. THE XM TOP BOX IS COMPLETELY NON-FUNCTIONAL DUE TO THE WATER DAMAGE/EXCESSIVE RUST. HYUNDAI CORPORATION HAS THUS FAR REFUSED TO COVER THE DEFECTIVE BODY SEALS WHICH IS CAUSING FURTHER RUSTING OF THE BODY OF THIS VEHICLE AS WELL AS SAFETY CONCERNS IF THIS VEHICLE WERE EVER IN AN ACCIDENT. HYUNDAI HAS ALSO REFUSED TO COVER ANY REPLACEMENT COSTS RELATING TO THE XM RADIO TOP BOX. HYUNDAI HAS NOT BEEN PROACTIVE IN NOTIFYING CUSTOMERS OF THIS DEFECT AND CONTINUALLY REFUSES TO MAKE GOOD ON ITS 7 YEAR/UNLIMITED MILEAGE ANTI-PERFORATION WARRANTY FOR A DEFECT THEY KNOW EXISTS.
NHTSA complaint #10314798 — an unverified report by a vehicle owner.
STRUCTURE:FRAME AND MEMBERS
I HAD TAKEN MY 2007 HYUNDAI SONATA TO TOWNE HYUNDAI IN DENVILLE, NJ. THE XM RADIO MYSTERIOUSLY STOPPED WORKING ONE DAY. XM CORPORATION HAD DONE TROUBLESHOOTING WITH THE CAR AND DETERMINED THAT THE SIGNAL WAS REACHING THE CAR AND ADVISED ME TO BRING IT TO HYUNDAI. HYUNDAI NOTED THAT THE TOP BOX FOR THE XM RADIO WHICH IS LOCATED IN A GULLEY IN THE TRUNK BEHIND THE REAR PASSENGER WHEEL HAD RUSTED AND THAT THERE WAS WATER IN MY TRUNK. I WAS PROVIDED WITH A COPY OF A TECHNICAL SERVICE BULLETIN THAT HYUNDAI HAD WRITTEN NOTING THAT "WATER MAY ENTER THE TRUNK THROUGH BODY SEAMS, WELDS, BODY PLUGS" AND THAT ANY SUSPECT WATER ENTRY POINT WOULD NEED TO BE SEALED TO CORRECT FURTHER DAMAGE FROM OCCURRING. THE XM TOP BOX IS COMPLETELY NON-FUNCTIONAL DUE TO THE WATER DAMAGE/EXCESSIVE RUST. HYUNDAI CORPORATION HAS THUS FAR REFUSED TO COVER THE DEFECTIVE BODY SEALS WHICH IS CAUSING FURTHER RUSTING OF THE BODY OF THIS VEHICLE AS WELL AS SAFETY CONCERNS IF THIS VEHICLE WERE EVER IN AN ACCIDENT. HYUNDAI HAS ALSO REFUSED TO COVER ANY REPLACEMENT COSTS RELATING TO THE XM RADIO TOP BOX. HYUNDAI HAS NOT BEEN PROACTIVE IN NOTIFYING CUSTOMERS OF THIS DEFECT AND CONTINUALLY REFUSES TO MAKE GOOD ON ITS 7 YEAR/UNLIMITED MILEAGE ANTI-PERFORATION WARRANTY FOR A DEFECT THEY KNOW EXISTS.
NHTSA complaint #10314798 — an unverified report by a vehicle owner.