2004 Hyundai Tiburon transmission problems

POWER TRAIN

CLUTCH RECALL, POWERTRAIN RECALL, MASTER CYLINDER RECALL, SLAVE CYLINDER RECALL. WHEN DRIVING MY CAR AFTER A WEEK OF PURCHASING THE CAR I PUSHED THE CLUTCH PEDAL TO THE FLOOR TO SHIFT, AND THE PEDAL DID NOT COME BACK UP. AFTER SEVERAL ATTEMPTS TO BRING IT BACK UP TO SHIFT IT FINALLY CAME BACK. WHEN SHIFTING AGAIN THE CAR DIED INSTANTLY, AND AFTER THE CAR WAS OFF I COULD SHIFT TO ANY GEARS. WHEN TURNING THE CAR BACK ON IN NEUTRAL THE CAR TURNED ON, BUT WOULD NOT SHIFT TO FIRST IT WOULD PUSH ITSELF FORWARD AND DIE. TRYING TO START THE CAR IN FIRST WOULD TAKE OFF BUT YOU COULD ONLY PUT IT BACK TO NEUTRAL. AFTER TAKING IT TO SEVERAL MECHANICS I CHANGED THE SLAVE AND MASTER CYLINDER, AND NOTHING HAPPENED. TO MY SURPRISE THE CLUTCH AND DUAL MASS FLYWHEEL, CLUTCH, SHIFT FORK WAS COMPLETELY DESTROYED. THIS IS A COMMON PROBLEM AND THEY WON'T DO ANYTHING ABOUT IT.

NHTSA complaint #11104904 — an unverified report by a vehicle owner.

POWER TRAIN

STEERING WILL NOT STAY IN NO MORE THEN 6 MOUTHS AND ALMOST INSTEAD THEY GO OUT .ON ALIGNMENTS . IT HAS BEEN GOING ON SEENS THIS CAR

NHTSA complaint #10725195 — an unverified report by a vehicle owner.

POWER TRAIN

TL-THE CONTACT OWNS A 2004 HYUNDAI TIBURON. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE FAILED TO SHIFT GEARS. THE VEHICLE WAS TOWED TO THE DEALER, WHO DIAGNOSED THAT THAT THE CLUTCH AND FLY WHEEL FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. DJR

NHTSA complaint #10649925 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

TL*THE CONTACT OWNS A 2004 HYUNDAI TIBURON. THE CONTACT STATED THAT THE CLUTCH WAS SLIPPING WHEN HE ACCELERATED UP TO 3,000 RPMS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER MORE THAN ONCE AND THE CLUTCH WAS REPLACED BUT THE FAILURE CONTINUED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 82,000.

NHTSA complaint #10384303 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

PURCHASED A BRAND NEW 2004 HYUNDAI TIBURON GT AND JUST HAD THE FOURTH POWERTRAIN, CLUTCH, FLYWHEEL, ETC INSTALLED TODAY DUE TO 3 FAILURES IN 90,000 MILES. THE LAST ONE THAT WAS PUT IN WAS IN FEBRUARY 2010 AND FAILED THIS TIME NOVEMBER 26, 2010, NOT EVEN LASTING A FULL YEAR. EACH TIME, I HAVE BEEN GIVEN THE RUN-AROUND AND NO ONE HAS TAKEN TIME TO ISSUE A RECALL OR ANYTHING, EVEN WITH THE HUNDREDS OF SIMILAR COMPLAINTS THAT HAVE BEEN FILED ALREADY. I AM ALMOST OUT OF MY WARRANTY AND AM SCARED THAT I WILL BE OUT THOUSANDS OF DOLLARS WHEN IT FAILS AGAIN. SOMEONE PLEASE HELP!!! THANK YOU!

NHTSA complaint #10368716 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

MY 2004 HYUNDAI TIBURON HAS AN AILING CLUTCH PROBLEM THAT I'VE LEARNED IS VERY COMMON AMONG OTHER OWNERS. THE OTHER MORNING I WAS LEAVING FOR WORK AND AS I BEGAN TO PULL OUT ONTO THE MAIN STREET, MY CAR (WHILE IN GEAR) SLIPPED AND THE RPMS REVVED AS I SAT CROSSING THE TWO LANES OF TRAFFIC! WAS NOT A FUN TIME. THIS IS NOT THE FIRST TIME THE CAR HAS PUT ME INTO A UNCOMFORTABLE SCENARIO. KEEP IN MIND THE CAR HAS 40,000MILES.

NHTSA complaint #10361708 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

JUST GOT THE CAR.. ITS ALREADY SLIPPING THE CLUTCH.. I AM MAD.

NHTSA complaint #10358466 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

2004 ~CLUTCH WENT OUT WITHOUT ANY WARNING 8/10/2010(56961 MILES) CLUTCH WAS INSPECTED ON 6/15/2009 AND WAS IN EXCELLENT CONDITION AT THE TIME OF INSPECTION (49987) AND I PURCHASED THE EXTENDED WARRANTY AT THE TIME OF THE PURCHASE AND TO FIND OUT IT ISN'T COVERED AFTER BEING TOLD THAT IT WAS~ATTENTION 2004 TIBURON OWNERS WHO ARE HAVING THE SAME FLYWHEEL AND CLUTCH ISSUES AS THE 2003 OWNERS. I HAVE MADE CONTACT WITH AN ATTORNEY TO START A CLASS ACTION SUIT. PLEASE CONTACT THEM IF YOU TOO ARE EXPERIENCING THE SAME. TRACY TEIN W/FINKLESTEIN THOMPSON & LOUGHRAN (415) 398-8700 601 MONTGOMERY STREET, SUITE 665 SAN FRANCISO, CALIFORNIA 94111 TOGETHER WE CAN SEE THAT HYUNDAI RIGHTS THEIR WRONG.

NHTSA complaint #10348916 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

TIBURON CLUTCH PROBLEMS.

NHTSA complaint #10343388 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

PURCHASED A TIBURON GT 2004 ON FEB 24 AND ONE MONTH LATER CLUTCH AND FLYWHEEL FAIL.

NHTSA complaint #10267307 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THIS IS CONCERNING A 2004 HYUNDAI TIBURON GT. I HAVE FOUND THIS TO BE A VERY COMMON PROBLEM WITH MANY 03-04 TIBURONS. IN MY CASE, THE CLUTCH AND FLYWHEEL NEEDED TO BE REPLACED AT 49,450 (12/04/06) AND 86,175 (4/21/09) MILES. THE COST FOR EACH REPAIR IS ALMOST $2000. I BOUGHT THIS CAR BECAUSE I COULD NOT AFFORD A MORE COSTLY CAR AND NOW I HAVE TO PAY THESE RIDICULOUS CHARGES FOR FAULTY PARTS. I DON'T UNDERSTAND WHY HYUNDAI HAS NOT DONE ANYTHING ABOUT THIS EPIDEMIC OF A PROBLEM..

NHTSA complaint #10266283 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

PURCHASED A TIBURON GT 2004 ON FEB 22ND AND A MONTH LATER THE CLUTCH AND FLYWHEEL FAIL.... I THINK THOSE CARS COME WITH DEFECTIVE CLUTCHES.

NHTSA complaint #10262809 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE

2004 TIBURON FLY WHEEL AND CLUTCH AND THROW OUT BEARING AND PRESSURE PLATE.

NHTSA complaint #10252580 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

I HAD TO REPLACE MY CLUTCH AT 68,000 MILES.

NHTSA complaint #10251735 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

I HAVE A 2004 HYUNDAI TIBURON GTV6 WITH 6-SPEED MANUAL TRANSMISSION. IN 23RD DECEMBER 2007. MY CAR WAS MAKING AN ODD SMELL. I WAS TOLD BY A MECHANIC IT WAS THE CLUTCH GOING BAD. I CONTACTED HYUNDAI AND WAS TOLD DUE TO NORMAL WEAR AND TEAR THAT IT WAS MY FAULT. AT THIS TIME I HAD 29,500MI ON MY CAR. ON THE 17TH JANUARY 2008 WITH 30,500MI ON MY CAR, THE CLUTCH IS COMPLETELY BAD AND HAS TO BE REPLACED. I NEARLY GOT T-BONED BY A TRUCK DURING NORMAL TRAFFIC BECAUSE MY CLUTCH DISENGAGED AND I STARTED SLOWING DOWN. THE TRUCK STOPPED TO HELP AND I GOT MY CAR HOME AFTERWARDS. HYUNDAI REFUSED TO HONOR THERE 10-YEAR WARRANTY ON THE CAR AND I GOT STUCK PAYING ABOUT $900 ON A NEW CLUTCH AND FLYWHEEL FOR MY CAR.

NHTSA complaint #10215646 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

2004 TIBURON HAD A PROBLEM WITH THE AIR CONDITION, SPEAKERS RATTLE, CIGARETTE LIGHTER AND PROBLEMS WHEN SWITCHING TO FIRST AND REVERSE GEARS. *TS THE SUN ROOF DIDN'T CLOSE PROPERLY. THE AIR BAG LIGHT ILLUMINATED DUE TO A LOOSE CONNECTION UNDER THE SEAT. ONE OF THE TAILLIGHTS WERE OUT.

NHTSA complaint #10174335 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

MY TRANSMISSION REVERSE GEAR FAILED FOR THE SECOND TIME APRIL OF THIS YEAR. THE CLUTCH, FLYWHEEL, PRESSURE PLATE, ETC WAS REPLACED IN MAY OF THIS YEAR (06). IN OCTOBER OF THIS YEAR I HAD MY TRANSMISSION REPLACED (MY THIRD!!) FOR THE REVERSE GEAR FAILURE. WHILE THE SERVICE DEPARTMENT HAD THE TRANNY OUT THEY DISCOVERED THAT MY CLUTCH WAS SHOT, AS WELL AS THE FLYWHEEL. THIS WOULD BE THE THIRD CLUTCH AND FLYWHEEL. THANKS GOODNESS THE CLUTCH WAS STILL UNDER WARRANTY. I HAVE AN 86 BMW WITH 270K MILES AND IT HAS THE SAME DRIVETRAIN!!!

NHTSA complaint #10170585 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

MY TRANSMISSION REVERSE GEAR FAILED FOR THE SECOND TIME APRIL OF THIS YEAR. THE CLUTCH, FLYWHEEL, PRESSURE PLATE, ETC WAS REPLACED IN MAY OF THIS YEAR (06). IN OCTOBER OF THIS YEAR I HAD MY TRANSMISSION REPLACED (MY THIRD!!) FOR THE REVERSE GEAR FAILURE. WHILE THE SERVICE DEPARTMENT HAD THE TRANNY OUT THEY DISCOVERED THAT MY CLUTCH WAS SHOT, AS WELL AS THE FLYWHEEL. THIS WOULD BE THE THIRD CLUTCH AND FLYWHEEL. THANKS GOODNESS THE CLUTCH WAS STILL UNDER WARRANTY. I HAVE AN 86 BMW WITH 270K MILES AND IT HAS THE SAME DRIVETRAIN!!!

NHTSA complaint #10170585 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

MY 2004 HYUNDAI GT CLUTCH WENT AT 39,000 MILES. I AM NOT AN AGGRESSIVE DRIVER AND I HAVE DRIVEN MANUAL TRANSMISSION CARS FOR 10 YEARS NEVER HAVING HAD A CLUTCH PROBLEM BEFORE. THIS IS NOT COVERED BY WARRANTY. IT IS CLEAR TO ME THAT THIS CLUTCH IS A DEFECT. I AM A MECHANIC AND THIS CLUTCH DID NOT FAIL LIKE THEY TYPICALLY DO THERE WAS NO SLIPPING OR INDICATION OF A WEAR ISSUE BEFORE IT FAILED. JUST A RATTLING SOUND FROM WHAT SEEMED TO BE THE THROW OUT BEARING THAT STARTED ABOUT 5 DAYS BEFORE THE FAILURE. THEN IN THE MIDDLE OF A 6 HOUR DRIVE THERE WAS A CLUCK WHEN I SHIFTED FOLLOWED BY A HARD SHIFT AND THEN NO POWER TRANSFER AT ALL. THIS LEFT ME IN A BIND I WAS STRANDED FOR 3 HOURS 4 HOURS FROM HOME SO I HAD TO HAVE IT TOWED TO A DEALER WHERE THEY GAVE ME AN ESTIMATE OF 1200 DOLLARS FOR PARTS AND LABOR ONLY TO FIND OUT WHEN THEY GOT IT APART THAT THE FLYWHEEL HAD ALSO BEEN DAMAGED AND THE NEW PRICE WOULD BE 2100 DOLLARS. FOR THIS KIND OF DAMAGE TO OCCUR IN THIS LITTLE TIME I WOULD HAVE HAD TO BEEN REALLY HOT RODDING IT, AND THAT'S NOT ME. I AM A VERY COMPETENT DRIVER. I HAVE SEEN OTHER COMPLAINTS BOUT THIS ISSUE AND THIS IS A PROBLEM THAT HYUNDAI SHOULD ADDRESS WITH AT LEAST FULL REIMBURSEMENT OF PARTS TOTAL BECAUSE THE PART IS DEFECTIVE.

NHTSA complaint #10170267 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

CLUTCH WAS SLIPPING AT 36,000 MILES, ALREADY HAD CLUTCH AND TRANNY REPLACEMENT AT 15,000. LOST ALL DRIVABLILITY, HP, TORQUE, ETC. HYUNDAI INSISTED $1,000.00 TO REPLACE CLUTCH PLATE, AND BEARING, WITHOUT LOOKING INSIDE ENGINE. AFTER A WEEK, THEY SAID THEY NEEDED $700.00 TO PULL TRANNY TO SEE IF FLYWHEEL IS BAD. BUYING CLUTCH MASTER SERIES 1 TO FIX THE FAULTY PART. DON'T LET THEM REPLACE YOUR PARTS WITH THE STOCK PART! THEIR CLUTCH IS TERRIBLE AND A MAJOR SAFETY ISSUE.

NHTSA complaint #10167922 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

I HAVE AN 04 TIBURON GT V6 SPECIAL EDITION AND IT IS ONLY AT 16000 MILES AND THE CLUTCH IS ALL READY GOING OUT AND I WILL HAVE TO REPLACE IT.

NHTSA complaint #10162785 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

2004 HYUNDAI TIBURON CLUTCH AND TRANSMISSION.

NHTSA complaint #10161122 — an unverified report by a vehicle owner.

POWER TRAIN:MANUAL TRANSMISSION

2004 HYUNDAI TIBURON CLUTCH AND TRANSMISSION.

NHTSA complaint #10161122 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

TOOK MY CAR TO DEALERSHIP FOR THE CLUTCH SLIPPING AND GRINDING ON TWO SEPARATE OCCASIONS, THE GRINDING WAS STOPPED BUT THE SLIPPING WAS STILL A PROBLEM. I WAS TOLD BY SERVICE TO "ADJUST THE WAY I DRIVE." AT 19557 MILES MY CLUTCH WENT OUT COMPLETELY, WHEN I ASKED THE SERVICE ADVISOR WHAT CAUSED THIS HE SAID "IT LOOKS LIKE ITS BEEN SLIPPING FOR A LONG TIME." THE DEALERSHIP INFORMED ME THAT THE REPAIRS WOULD NOT BE COVERED UNDER WARRANTY AS THE CLUTCH PARTS ARE ONLY UNDER WARRANTY FOR 12000 MILES. MY CAR WAS UNDER 12000 MILES BOTH TIMES THE CLUTCH WAS "REPAIRED" BEFORE. NOW I HAVE A REPAIR BILL FOR OVER $2000 THAT I REFUSE TO PAY BECAUSE THEY DIDN'T FIX THE PROBLEM WHEN THEY COULD HAVE, UNDER WARRANTY.

NHTSA complaint #10157939 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

THE CLUTCH ON MY 2004 HYUNDAI TIBURON FAILED AT 32,000 MILES. IT NECESSITATED THE REPLACEMENT OF THE CLUTCH AND FLYWHEEL, AT AN EXPENSE OF ABOUT $2,500.00 THE CLUTCH FAILED ME WHILE I WAS ON THE FREEWAY, 1200 MILES FROM MY HOME.

NHTSA complaint #10156919 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

PURCHASED VEHICLE JAN 04 WITH 10 MILES ON IT. AT AROUND 12K MILES THE CLUTCH BEGAN TO RAPIDLY WEAR. AT 18K MI IT WAS IMPOSSIBLE TO DRIVE. DRIVER HAS NEVER HAD TO REPLACE A CLUTCH BEFORE 140K MI BEFORE. DEALER (UNION NJ) CLAIMED HYUNDAI NOT RESPONSIBLE, SAID WOULD REPAIR REPLACE FOR $1200K (PRICE REDUCTION AS A COURTESY). DRIVER DECIDED THAT NOT TO REPLACE WITH THE SAME CLUTCH BOUGHT A SPEC STAGE 3 AFTERMAKET CLUTCH FOR $480 AND HAD THE DEALER PUT THE CLUTCH IN. AT AROUND 32K MI SUDDENLY THE CLUTCH WENT FROM VERY TIGHT (CATCHING ABOUT 1" - 1.5" OF THE FLOOR TO LOOSE 3"+. CLUTCH SLOWLY STARTED SLIPPING AND WAS REPLACED AT 38K MI BY A DIFFERENT DEALERSHIP (NYACK, NY) CLAIMED THERE WAS A TSB FOR THE ISSUE AND OFFERED TO FIX FOR FREE WITH FACTORY CLUTCH AND NEW FLY WHEEL. FLY WHEEL MUST OF BEEN ROOT CAUSE AS THERE HAS BEE NO MORE INCIDENTS AS OF 80K MI.

NHTSA complaint #10156751 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

I WAS INFORMED A WEEK OR SO AGO THAT MY CLUTCH NEEDED TO BE REPAIRED DUE TO "WEAR & TEAR" ON A 30,000 MILE HYUNDAI TIBURON. I WAS INFORMED THAT THE WARRANTY WOULD NOT COVER IT DUE TO "WEAR & TEAR". I WAS INFORMED BY THE REPAIR CONSULTANT THOUGH THAT THEIR FACILITY HAS BEEN OPEN FOR 9 MONTHS AND MY CAR IS THE 3RD THEY HAVE SEEN WITH LOW MILE TIBURON'S HAVING THE CLUTCH REPAIRED. I CALLED A LOCAL TRANSMISSION REPAIR FACILITY AND THEY INFORMED ME THAT IN DECEMBER OF '05 THEY HAD A HYUNDAI TIBURON WITH 11,000 MILES AND HAD TO REPLACE THE CLUTCH AS WELL.

NHTSA complaint #10156412 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

THE CLUTCH STARTED SLIPPING WITH ONLY 16,500 MILES ON IT. I TOOK IT TO THE DEALER IN JANUARY 2006 TO HAVE THE CLUTCH REPLACED. THEY TOLD ME I WAS AT FAULT DUE TO MY DRIVING HABITS. THEY OFFERED ME A DISCOUNT ON THE PARTS. THE DEALER WAS GOING TO USE EXACT REPLACEMENT PARTS BUT FROM WHAT I FOUND OUT ABOUT THE CLUTCH I PROVIDED ON MY OWN AFTER MARKET PARTS THAT COST $ 478.56 DOLLARS AND THE DEALER CHARGED $870.00 FOR LABOR.

NHTSA complaint #10153959 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

PREMATURE CLUTCH WEAR! ADD ME TO THE LIST! IT LOOKS LIKE I MAY BE ANOTHER ONE OF THE MANY PEOPLE WITH CLUTCH PROBLEMS ON THEIR TIBURON. I JUST BOUGHT MY USED 2004 TIBURON 3 WEEKS AGO. IT HAD 27,000 MILES ON IT AT THE TIME OF PURCHASE. I RECENTLY HAD A PROBLEM STARTING THE CAR SO I BROUGHT IT INTO THE DEALER. THEY INSPECTED THE CAR AND TOLD ME THAT THE CLUTCH WAS WORN AND WAS CATCHING HIGH. THEY ESTIMATE IT IS OVER 60% WORN AT THIS POINT BUT CAN'T TELL FOR SURE UNTIL THEY TEAR IT DOWN. NOW I HAVE DRIVEN CLUTCH FOR MANY YEARS. MY LAST CAR WAS A 98 JETTA WITH 93,000 MILES ON IT AND THE ORIGINAL CLUTCH WITH NO SLIPPAGE. BEFORE THAT I HAD A 91 NISSAN 240SX WITH WELL OVER 130,000 MILES AND THE ORIGINAL CLUTCH. IT IS UNACCEPTABLE FOR THE CLUTCH TO FAIL WITH SUCH LOW MILEAGE. ON TOP OF THIS, THERE ARE HUNDREDS OF COMPLAINTS ON VARIOUS MESSAGE BOARDS ABOUT THIS ISSUE. SOMETHING NEEDS TO BE DONE. IT IS OBVIOUS THAT THERE IS A MECHANICAL PROBLEM GOING ON. IT SIMPLY CAN NOT BE THE DRIVES FAULT IF SO MANY OF THESE CASES HAVE BEEN REPORTED. I AM REALLY HOPING THAT MY CLUTCH LASTS FOR AWHILE, BUT I FEEL AS IF I GOT MYSELF INTO A BAD SITUATION BUYING THIS CAR. I REALLY HOPE THIS SITUATION IS REMEDIED BECAUSE I DO LIKE THE CAR BUT I SIMPLY CAN'T GO THROUGH THE COST OF REPLACING MY CLUTCH EVERY YEAR OR TWO AND SHOULDN'T HAVE TO! I'VE READ THAT THERE IS A CLASS ACTION LAWSUIT PENDING. HOPEFULLY BETWEEN THIS LAWSUIT AND THE NHTSA, A RESOLUTION TO THIS PROBLEM IS REACHED. THIS IS AN UNFAIR AND POTENTIALLY DANGEROUS SITUATION FOR THE AMERICAN CONSUMER THAT NEEDS TO BE RESOLVED SOON!

NHTSA complaint #10154024 — an unverified report by a vehicle owner.