2016 Hyundai Tucson window and wiper problems

VISIBILITY

The contact owns a 2016 Hyundai Tucson. The contact stated that while the vehicle was parked, the front passenger’s side door failed to unlatch as needed. The front passenger's side window failed to roll up or roll down. The driver's side rear door failed to unlatch or latch as needed. Additionally, the trunk switch failed to operate as needed. The dealer was made aware of the failures but provided no assistance. The contact was informed that the repairs were not covered under recall or warranty. The contact stated that the vehicle was unsafe to operate. The contact feared being locked inside the vehicle and being unable to exit the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

NHTSA complaint #11747133 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

The regulators and motors for the automatic windows have failed. The windows do not remain in the closed position causing the window to slide open. The front passenger window motor failed first and the driver's window failed shortly after. Both regulators and motors were replaced by the dealer in April 2024. The back passenger side window failed in December 2024 and has not been replaced. If needed, the faulty mechanism could be provided for inspection. Failure of the closing mechanism for the windows means they can easily be opened from outside. A malicious person could break into the vehicle simply by sliding the window down. To my knowledge, no one has inspected the regulators or motors. Two other 2016 Hyundai Tucson owners I know have also had their window regulators and motors replaced. There was no warning to the automatic window failure.

NHTSA complaint #11661358 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Front passenger door won’t open Defroster/heat won’t work on drivers side

NHTSA complaint #11624465 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

•Window regulator •Stops windows movement •Our independent service provider •No •No

NHTSA complaint #11606671 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The contact owns a 2016 Hyundai Tucson. The contact stated that on multiple occasions while driving at various speeds, the four windows rolled down independently. The vehicle was taken to an independent mechanic where the front driver’s side window was replaced; however, the three remaining windows failed to operate as needed. Recently, the rear passenger’s side window was locked in place by a mechanic to prevent the persistent failure. The dealer was notified of the failure and the contact was informed that the vehicle was not under recall or warranty. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 60,000.

NHTSA complaint #11583802 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The window regulator cables for all windows have failed multiple times, even after taking it to the dealership and paying to have this defect “fixed” they fail again. Now the only working window is the drivers and I cannot afford to have the other 3 fixed which is a safety hazard if an emergency were to happen. This is a manufacturer defect and there needs to be a recall done.

NHTSA complaint #11567368 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Power window passenger side, stopped working, it is not the motor, you can hear motor running but window does not work.

NHTSA complaint #11557026 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The contact owns a 2016 Hyundai Tucson. The contact stated that while the vehicle was parked, the contact noticed that the window had become inoperable. No warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised that the vehicle be taken to a dealer for the repair. The failure mileage was approximately 68,000.

NHTSA complaint #11549817 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

On 10/24/22 I took my 2016 Hyundai Tucson into dealership Springfield Hyundai 754 Baltimore Pike Springfield PA 19064 for a faulty drivers side window. At that time they advised the issue with the window was 'striped gear' and replaced 'drivers window regulator' under the extended warranty I purchased when I bought the vehicle. At that same time there was also an issue in the left front door latch and it was replaced under 'warranty.' On 03/03/23 the right rear door also had a latch issue and was replaced at that time. About a week ago, my front passenger side window stopped working. It will not go up or down. I returned to the same dealership on 07/27/2023. I was advised that 'found right front window regulator and motor gears are splined. Both parts need to be replaced. Charge is $890.98.' The car's extended warranty has expired and I would need to pay for this out of my pocket. My concern here is what I consider a trend with my vehicle experiencing window issues and it has not even reached 100K miles - in addition to the door latch issues. By the way, I also have a 2017 Hyundai Elantra which has also had to have almost every door latch replaced. After this second window issue popped up, I became curious and searched the internet for 2016 Hyundai Tucson window issues. And to no surprise, there are multiple consumers with complaints reporting the same exact issue as I am, with their windows as well. Based on current trends and concerns with your car manufacturing, parts, missing basic anti-theft tools, cars being stolen, and a plethora of other issues I am confident this issue with my window is at fault of Hyundai's poor production, manufacturing, and quality control. Windows are an emergency exit. In the case of an accident, you need to be able to open the window to exit if it is the only viable option. You can become trapped inside your vehicle if the windows do not work. Window needs to be operable to combat exhaust that may be trapped inside vehicle.

NHTSA complaint #11546617 — an unverified report by a vehicle owner.

VISIBILITY

The contact owns a 2016 Hyundai Tucson. The contact stated that the driver’s and passenger’s side front windows and the passenger’s side rear door window regulators were inoperable. The contact stated that the regulators were making a whining sound but failed to roll up or roll down. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 76,000.

NHTSA complaint #11544165 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Car window regulator failed. window could not be rolled up and occupants subjected to outside weather conditions.

NHTSA complaint #11540250 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Car window regulator failed. window could not be rolled up and occupants subjected to outside weather conditions.

NHTSA complaint #11540252 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Both my front window (driver and passenger side) regulator and motor failed and needed to be replaced within the past 6 months. With both windows, I lowered and then they wouldn't close. Two separate occasions. First was December 2022, and second was July 2023. This is an expensive repair and for a vehicle with only 50,000 miles, I find this unacceptable. I have read multiple complaints for this same issue. Hyundai needs to make this right and reimburse for repair(s). Thank you, Barbara Miller

NHTSA complaint #11537426 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The contact owns a 2016 Hyundai Tucson. The contact stated that all four automatic windows failed to operate as needed. The front driver’s side window started failing and an appointment was scheduled with the dealer to repair the window. While testing the windows in the dealer parking lot after the repair, the front passenger’s side window fractured, and the dealer agreed to cover the cost of the repair free of charge. Over time, the rear windows started to lower independently, and the vehicle was repaired by an independent mechanic. In addition, the contact stated that the vehicle intermittently failed to accelerate while depressing the accelerator pedal. There was no warning light illuminated. The contact stated that the vehicle lunge forward while accelerating. The manufacturer was also notified of the failure. The vehicle was not repaired. The failure mileage was approximately 20,000.

NHTSA complaint #11532800 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

excessive oil consumption. it has been confirmed by valvoline instant oil change center. after an oil change, round 600 miles the oil is to be checked and topped off completely because the reservoir is bone dry. can not make it a complete 3,000 miles until the next oil change. the oil has to be topped off at least 2-3 times until the next oil change. there are no warning lamps, messages, or other symptoms to notify of the problem. it has been inspected by hyundai dealership, whom at someone point replaced the turbo in the limited 1.6L. also, the windshield wiper reservoir decided to stop working. I have to wait until it rains or go through a car wash to clean my windshield. all hoses have been checked and there are no leaks or disconnection of the hose. the windshield wiper fluid will not come out and remains completely full.

NHTSA complaint #11530483 — an unverified report by a vehicle owner.

VISIBILITY

The contact owns a 2016 Hyundai Tucson. The contact stated that when she was near her vehicle, she noticed that the driver's side window was down. The contact stated that she could not roll the window up. The contact stated that over the next month, the other three windows were lowered and could not be rolled up. Additionally, the contact stated that the headlights had failed, and she had them replaced. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the windows mechanism needed to be replaced. The vehicle had been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 53,000.

NHTSA complaint #11524041 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

While running errands in her 2016 Hyundai Tucson my wife rolled down her front driver and passenger side windows. When she encountered rain she attempted to roll both windows up, but the passenger side window would not roll up, causing a dangerous distraction where heavy rain was entering the vehicle while she was driving. Our mechanic inspected this part and said that the gears controlling the window were made of plastic which had been shredded over time and that the motor itself showed signs of corrosion. The vehicle is only 7 years old and has been well maintained, so i can't understand why this part failed so easily. Our mechanic informed us that this is a VERY common issue with Hyundai vehicles and that parts would be hard to come by because of high demand. This issue is available for inspection upon request and has been inspected by a licensed mechanic. There were no dash warnings associated with this issue.

NHTSA complaint #11522025 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Window regulator has broke in all 4 windows

NHTSA complaint #11513143 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

In the past six months, three of the four window regulators on my 2016 Hyundai Tucson stopped working. Recently, one of my windows fell out while driving on the highway. Looks like this is a manufacturing defect as hundreds of complaints have been reported on the internet. The vehicle needs to be recalled as this seems to be a common problem in most 2016 Tucsons and poses significant risks while driving, especially on highways at high speeds. I’ve included some exact complaints for your reference here: https://www.vehiclehistory.com/questions/why-is-my-hyundai-tucson-2016-window-not-working-353123 I hope this problem gets resolved soon. Thank you.

NHTSA complaint #11513263 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

All 4 windows have a failed regulator. It's a plastic gear attached to the window motor. The windows do not stay up/closed. I am afraid they will fall and break while driving. The Hyundai dealership quoted 3,800 to repair them.

NHTSA complaint #11511291 — an unverified report by a vehicle owner.

VISIBILITY:GLASS, SIDE/REAR

Cheap plastic regulator for the driver side window broke and can't roll up my window

NHTSA complaint #11510487 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Driver door power window control fails. Window won't go up or down while the window motor in the door can be heard operating. After the failure it is possible to manually pull the window glass up and down in it's track. The glass moves freely in it's track. The weight of the glass is sufficient to prevent the window from remaining closed, ie the glass drops down into the door if it is not held up. Window must be manually wedged or some how mechanically held in the closed position. This is an obvious theft concern if the vehicle cannot be locked. Problem identified; The power regulator drum is a plastic that deteriorates with time. The splines in the drum strip away and the power motor shaft spins freely in the drum, in both directions.

NHTSA complaint #11507799 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Unable to roll passenger window down using the power control on the driver's door. Took it to a Hyundai dealership for diagnosis and repair. It cost $506.67 to fix, driver front main window switch was replaced.

NHTSA complaint #11504186 — an unverified report by a vehicle owner.

VISIBILITY:GLASS, SIDE/REAR

The automatic windows broke in all 4 windows and I am unable to roll down my windows in the case of an emergency. The dealer confirmed this is an issue. This is a known issue on the 2016 Tucson.

NHTSA complaint #11503283 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The automatic windows broke in all 4 windows and I am unable to roll down my windows in the case of an emergency. The dealer confirmed this is an issue. This is a known issue on the 2016 Tucson.

NHTSA complaint #11503283 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The vechicle was recalled for door locks that failed to work. Within weeks 3 of the automatic windows failed. One of the windows won't stay closed and can be easily opened by anyone simply pressing on the window and pushing it down. Its impossible to lock the vehicle for protection. The other windows won't roll down its impossible to use them to exit the vehicle in an emergency.

NHTSA complaint #11500958 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The windows stop working. Mine has been replaced twice with 15K miles. when you cant roll up your windows it leaves you exposed to be car jacked in a big city, or objects to fly in the car, which could hurt the driver.

NHTSA complaint #11499043 — an unverified report by a vehicle owner.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

This vehicle model (Hyundai Tucson) is prone to breakdowns in power windows, especially front power windows, due to faulty gear in window regulator unit. Online forums are all complaining about this issue and the replacement part (regulator unit with motor) is being sold on Amazon and Ebay, a sure sign of high demand for the part. This is a dangerous safety issue as the first route of escape in an accident when door cannot be opened is the front windows. The cost to replace the part with labor is around $500 per window so many owners will rather live with the potentially dangerous issue without making repairs. There should be a recall issued by Hyundai to repair inoperable windows and to reimburse owners who have already made repairs.

NHTSA complaint #11494381 — an unverified report by a vehicle owner.