132 of the
538 complaints filed about the KIA Carnival
are about the electrical system —
25% of everything owners reported.
The worst model year for it is 2025.
The contact owns a 2025 Kia Carnival. The contact stated that while driving at an undisclosed speed and coming to a complete stop, the vehicle shut off. There was no warning light illuminated. The vehicle was restarted and driven back to the residence. The following day, the vehicle shut off again and was restarted after several attempts. The contact had taken the vehicle to the dealer on several occasions; however, the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 34,967.
NHTSA complaint #11756278 — an unverified report by a vehicle owner.
Incident description: While driving, the vehicle’s dashboard illuminated all warning lights (ABS, traction control, battery, check engine, forward safety system) and the engine revved to approximately 8,000 RPM with unintended rapid acceleration. Driver had to apply hard braking to maintain control and avoid a collision. A nearly identical event occurred approximately one month earlier while driving on the highway, at which point the vehicle suddenly braked hard on its own. The vehicle has been at the dealership for repair a combined 38 days across two visits. The dealer initially attributed the first event to a failed alternator voltage regulator, replaced it, but the same warning codes and behavior returned on the second occasion. Crash/injury: No collision occurred; avoided through evasive braking. Speed: Highway speed (both instances). Incident description: While driving, the vehicle’s dashboard illuminated all warning lights (ABS, traction control, battery, check engine, forward safety system) and the engine revved to approximately 8,000 RPM with unintended rapid acceleration. Driver had to apply hard braking to maintain control and avoid a collision. A nearly identical event occurred approximately one month earlier while driving on the highway, at which point the vehicle suddenly braked hard on its own. The vehicle has been at the dealership for repair a combined 38 days across two visits. The dealer initially attributed the first event to a failed alternator voltage regulator, replaced it, but the same warning codes and behavior returned on the second occasion. Crash/injury: No collision occurred; avoided through evasive braking. Speed: Highway speed (both instances).
NHTSA complaint #11752011 — an unverified report by a vehicle owner.
The contact owns a 2025 Kia Carnival. The contact stated that while parked in a bank drive-thru, the contact's son mentioned that his seat belt was stuck. The contact parked the vehicle in a parking spot and attempted to remove the seat belt; however, the seat belt retracted tightly around his abdomen as the lower half of his body was turning blue, requiring the contact's husband to cut the seat belt. The contact mentioned that it was discovered that all seat belts located in the rear row seats failed. The contact stated that several unknown warning lights were flickering on and off back in April. The vehicle was taken to a dealer, where it was diagnosed that all the third-row rear seat belts had failed and needed to be replaced. The vehicle was repaired by replacing the seat belts. The manufacturer was notified of the failure and informed the contact that the seat belts were replaced and that the vehicle was ready to be picked up. The approximate failure mileage was 46,000.
NHTSA complaint #11748893 — an unverified report by a vehicle owner.
**Vehicle:** 2025 Kia Carnival **Current Mileage:** Approximately 18,000 miles I am reporting a serious and ongoing safety defect involving the center LCD display in my 2025 Kia Carnival. The problem began immediately after the vehicle's first scheduled service at an authorized Kia dealership and has continued ever since. The center LCD screen intermittently flickers and then goes completely blank while I am driving. When this happens, the rearview camera image is also lost while the vehicle is in Reverse, leaving the display completely black and preventing me from seeing behind the vehicle during backing. This creates a significant safety hazard and increases the risk of striking a pedestrian, child, vehicle, or other object. The display failure while driving is also extremely distracting because critical vehicle information and functions become unavailable. I have taken the vehicle to authorized Kia dealerships multiple times for warranty repairs, but the defect remains unresolved. The LCD display has been replaced, yet the problem continues to occur. The dealerships have kept my vehicle for extended periods during several repair attempts without permanently correcting the issue. Service dates include: * September 9, 2025 * March 10, 2026 * March 18, 2026 * June 1, 2026 The issue is intermittent but repeatedly occurs without warning. I transport my family, including infants, in this vehicle, and I am extremely concerned about their safety and the safety of others. Losing the backup camera and display while reversing or driving creates an unacceptable safety risk. I believe this may be a safety-related defect affecting the vehicle's display system. I respectfully request that NHTSA investigate this issue because multiple warranty repair attempts, including replacement of the display, have failed to resolve the defect.
NHTSA complaint #11747231 — an unverified report by a vehicle owner.
We have been having persistent safety issues with this vehicle. The issues have ranged from unsecured gas cap to loss of power. We’ve also had severe transmission issues where the car will not shift out of first gear. This happened on the Garden State Parkway and nearly caused an accident as the car wasn’t able to go above 27 mph safely.
NHTSA complaint #11740593 — an unverified report by a vehicle owner.
For the third time the 2025 KIA Carnival Prestige I own lost power while driving on the interstate! Without warning, the vehicle would no longer respond to the accelerator pedal. No matter what I did I could not get the vehicle to accelerate past 35 mph. The minimum speed limit on the interstate is 45 mph. I had to immediately engage my hazard lights and make my way over to the shoulder of the road from the passing lane. This was a dangerous situation for me and my family and others on the highway. Warning lights came on, check engine light, charging system, and a maintenance service message. Driving in Sport mode, Smart mode, nor Econo mode could change the negative situation. This took place multiple times during the final leg of my last trip to [XXX] , extending for over 120 miles. This is a very unsafe, unreliable vehicle, that should never be driven on public roadways… especially not highways nor interstates. Three negatively, traumatic experiences is ENOUGH!!! I’m DONE!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11740406 — an unverified report by a vehicle owner.
The contact owns a . The contact stated that while parked when the brake was depressed, press start button, when put in reverse, it says gear is selected, the vehicle stayed in neutral. This happens intermittently. The stop button was pressed, all of the instrument panel warning indicators would not illuminate. When pressing p for parking to engage parking, it appeared as if it was in park; however the vehicle unexpectedly reversed. The vehicle was able to be stopped. The vehicle was taken to the dealer where the issue could not be duplicated. The manufacturer was not notified of the issue. The approximate mileage was 2,200.
NHTSA complaint #11739601 — an unverified report by a vehicle owner.
Battery died at under 3,300 miles. After roadside came and jumped the batter, it died again after two days. Jumped again for the second time, when driving the car around it would randomly shut off even when the car is moving at higher speeds on freeway. The shut off would be for just one second and comes back on - everything starts resetting. And goes to user authoriztions notifications. Car shut off three times while driving around.
NHTSA complaint #11738682 — an unverified report by a vehicle owner.
My 2022 Kia Carnival, approximately 80,000 miles, had intermittent dashboard warning lights and grinding brake noise for a few weeks. I brought the vehicle to Tasca Kia White Plains first time on 4/14/26 then again on 5/8/26. The dealership initially could not reproduce the issue, then later suspected an ABS sensor issue and ordered the part. On 5/12/26, before the repair was completed, I was driving downhill with my children in the vehicle when the brakes failed to respond properly. I had to steer off the roadway and go over rocks/boulders to stop the vehicle. At that time, the brakes would not respond normally, and I could not immediately shift the vehicle into Park. Police and towing services were involved. The dealership later replaced an ABS sensor. However, when I reviewed the codes with the service manager, I was told the ABS sensor code did not appear on the date of the brake incident. I was also told that an ABS sensor failure itself would not typically cause hydraulic brake failure. I am concerned that the sensor replacement does not explain the brake failure and that this may involve a brake/ABS/electronic stability control safety issue.
NHTSA complaint #11738446 — an unverified report by a vehicle owner.
The contact owns a 2025 Kia Carnival. The contact’s daughter stated that while driving approximately 10 MPH, the vehicle unexpectedly lost motive power with no warning lights illuminated. The vehicle failed to restart and was towed to the dealer. The dealer informed the contact that the battery solenoid needed to be replaced; however, the vehicle was not diagnosed or repaired. The contact stated that the failure recurred on multiple occasions. The vehicle was taken to the dealer several times. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 4,200.
NHTSA complaint #11737111 — an unverified report by a vehicle owner.
Car Problems Purchased March of 2025 #1 First black out summer 2025-Driving at 10 PM and lost all electric driven items. Headlights turned off as well while driving 70 MPH in the dark Scheduled an appointment to get the car looked over. They said that there was a part that they were waiting on to help with electrical issues. #2 Next black out fall of 2025 Used the update part to see if that would fix the problem #3 February 6th, 2026 Got my oil changed and it blacked out when I left the dealership. Went back to tell them and they documented it. #4 April 14th, 2026
NHTSA complaint #11732059 — an unverified report by a vehicle owner.
The component of the vehicle that malfunction was the front passenger seat. The driver came to a stop at an intersection and the front passenger seat started auto reclining. The seat was reclining into a life, flat position, almost. The driver was concerned because no one was pressing buttons and put the vehicle in park in the seat did not stop auto reclining so the driver turned off the vehicle, but the seat reclined as far as it could into the middle section of the vehicle and encountered the driver’s child in a car seat. The seat reclined onto the child's legs and pinned them down against the car seat and the seat below them. The driver was unable to remove the child from under the seat nor able to physically lift the seat, but the buttons on the front passenger seat on the lower right side, did work in order to lift the seat back into an upright position and unpinned the childs legs. The driver took it and to a dealership to get it looked at and they failed to reproduce the issue. The local dealership did look at the vehicle, but failed to reproduce the issue. There were no warning lights to indicate this was going to occur. The local dealership suggested this was a user error, and that something must have damaged the components of the seat to activate an auto recline, which is still problematic. The dealership said due to the owner unplugging the power to the seat that the issue could not occur again, but they did not solve the mystery or issue of how it actually occurred. The child was restrained in a car seat, and the seat was pushed back in the middle section of the vehicle as far back as it can go. The front seat was still able to auto recline somehow into the child’s car seat and pin them down.
NHTSA complaint #11731853 — an unverified report by a vehicle owner.
Due to soy-insulated wiring used in wiring harnesses, rodents are attracted to the wiring components in the engine bay. Even using deterrents doesn't see to affect them. What started as a simple check engine light for what was assumed to be a faulty sensor turned into a total wiring harness replacement. Without knowing that the wiring provided an added risk to damage from external factors, there was no need to check any of the wiring. If the check engine light didn't come on, it was possible that total power loss to the vehicle could've occurred at any time, due to the various wires damaged by the rodents. We were driving on the freeway at the time when the initial check engine light came on, and a loss of power while going 65 mph could've been devastating to both our family and other drivers on the road at the same time. Insurance confirmed that the cause of the wiring damage was related to the rodents being attracted to the material, and at the dealership there were at least 2 other cars needing full wiring harness replacements due to similar damage from rodents.
NHTSA complaint #11729116 — an unverified report by a vehicle owner.
2026 Kia Carnival MPV Hybrid SX Prestige(Exterior: Astra Blue Interior: Tuscan Umber / Off-Black) purchased December 2025. Two separate safety-related defects have gone unresolved for 31+ cumulative days across two dealer repair visits. DEFECT 1 — INSTRUMENT CLUSTER: Instrument cluster screen goes blank while driving, eliminating speedometer, TPMS, and all warning indicators. First observed February 2026. Dealer visit February 13–17 (4 days): technician said could not replicate. Defect recurred. Kia has since issued a federal safety recall confirming this exact defect — citing FMVSS noncompliance and stating the blank screen increases crash risk due to a software error causing overheat protection mode. Vehicle was at dealer for an active safety recall defect that went undiagnosed during a repair visit. DEFECT 2 — SEAT MODULE: Second-row seat module failed. Vehicle returned to dealer March 5 (still there, 27+ days). Wiring harness replacement attempted approximately March 21 — failed, defect persisted. Kia Engineering formally escalated approximately March 24. Seat module ordered but not yet installed. No resolution or completion date provided. Vehicle has been out of service 31+ cumulative days. Safety recall defect went undetected during prior dealer repair visit. Both defects remain unresolved on a vehicle purchased just 97 days ago.
NHTSA complaint #11728640 — an unverified report by a vehicle owner.
The vehicle (2025 Kia Carnival Hybrid) has suffered from a systemic parasitic 12V battery drain since the first month of ownership. The first occurrence was July 20, 2025, requiring a jump-start from Kia Roadside Assistance. On 02/26/2026, the vehicle was presented at Moritz Kia Alliance for the same issue. The dealer diagnosed the 12V battery as defective (Code R04) and replaced it under warranty. However, the defect persisted. On 03/10/2026, only 12 days later, the vehicle suffered another total electrical failure. I had to utilize Kia Roadside Assistance for a jump-start and drive the vehicle directly to the dealer without turning the engine off to ensure it could be serviced. This marked the second official repair attempt for this recurring defect. The vehicle has remained in dealer possession since March 10 (21 consecutive days). On March 11, only one day after drop-off, the Service Director threatened that the vehicle would be "impounded" after 60 days, despite the vehicle being the subject of an active Texas DMV Lemon Law Case (#26-0012638.CAF). On March 26, a critical safety failure occurred: during a start-up attempt, the Integrated Power Brake (IPB) system malfunctioned, causing the brake pedal to pulsate and physically "kick back" with significant force against my foot. I have serious concerns that this braking failure could occur while in motion, posing an unreasonable risk of high-speed collision, serious injury, or death. No root-cause diagnosis has been made. Furthermore, the main fuse box cover was left off during service, exposing critical electrical components. The vehicle is available for inspection.
NHTSA complaint #11728026 — an unverified report by a vehicle owner.
Driver side passenger back sliding door will not open or close properly. Door will jam and make a loud noise or will not open when trying to open. Took it the dealership 4 times they replaced the motor but the issue continues.
NHTSA complaint #11724831 — an unverified report by a vehicle owner.
Date/time of incident 03-16-2026 18:09-18:17 * Faulting component: Infotainment screen (screen to the right of gauge cluster) * Incident: While backing out of a parking spot and utilizing the cameras to watch my surroundings, the infotainment screen became unresponsive and began flashing between visual noise similar to 'snow' on old broadcast television, primary colored jagged/blocky artifacts, and a black screen. The screen would occasionally revert back to normal imagery but with severely lagging touch response and stuttering screen transitions. This persisted until I pulled over, parked the car, & restarted the vehicle. After restarting the vehicle the infotainment screen flashed: Solid Black -> Solid White -> Solid Red -> Solid Green -> Briefly solid black -> Briefly Solid Green -> Then the infotainment functionality returned to normal operation after a brief stutter. --I have a video of the last portion of this incident that I can share upon request * All camera related safety functionality became unresponsive/unusable during this incident * I've requested an appointment with the local Kia dealership * As this incident just occurred, I have not yet reached out to other parties * No warning lamps or diagnostic warning appeared during or after the incident
NHTSA complaint #11724822 — an unverified report by a vehicle owner.
My engine smells like fire and fuel my can will not start or do anything. There was smoke coming out of it. The van has had several issues since buying it. Now it’s completely disabled I heard a popping noise as I was driving and then it died and has not started since.
NHTSA complaint #11723675 — an unverified report by a vehicle owner.
This new 2026 Vehicle faced multiple issues within a few weeks of purchase as stated below. 1. The instrument display panel or the main display screen of the car stopped working. The screen was completely blank and would not turn on. (confirmed and reproduced by Kia dealer, service order attached) 2. An electric short caused the radio to fail (confirmed and reproduced by Kia dealer, service order attached) 3. The car battery died, rendering the car completely unresponsive. The car had to be towed to the Kia Dealer. (confirmed and reproduced by Kia dealer, service order attached) All of the above 3 issues happened one after the other. The first issue essentially disabled safety features of the vehicle as the display panel that displays rear view camera, camera monitoring system (CMS), etc was not able to display any information. An eventual electric short and a dead battery rendered the vehicle inoperable. The official Kia dealer attempted to diagnose and repair the vehicle. The vehicle was at the dealer service for 15 days. The dealer initially suggested that a part needs to be replaced and is in backorder till May 2026. However subsequently the dealer then claimed that the vehicle is now operating normally and should be taken by the customer. No root cause of the electric short and battery and screen failure was disclosed. Also contrary to what is stated in the service order, the service manager at the dealer verbally suggested that they did not replace the malfunctioning component.
NHTSA complaint #11720576 — an unverified report by a vehicle owner.
The contact owns a 2023 Kia Carnival. The contact stated that during freezing weather, the button was depressed to open the driver's side rear sliding door, and the door automatically opened; however, the motor reached a point of resistance and attempted to close the sliding door. Due to the failure of the cable in the door snapped behind the glass window. The contact manually opened the sliding door and used excessive force to close the door. The vehicle was taken to the dealer, who confirmed that the door cable had snapped. The contact was informed that the vehicle was out of warranty; however, the dealer reached out to the manufacturer for assistance. The manufacturer later agreed to partial assistance with the repair. The contact paid for the remaining cost of the repair. The manufacturer was contacted about the repair and provided a case number. The vehicle was repaired. The failure mileage was 63,476.
NHTSA complaint #11717587 — an unverified report by a vehicle owner.