The contact owns a 2023 KIA Carnival. The contact received notification of NHTSA Campaign Number: 26V320000 (ENGINE AND ENGINE COOLING) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11741634 — an unverified report by a vehicle owner.
We have been having persistent safety issues with this vehicle. The issues have ranged from unsecured gas cap to loss of power. We’ve also had severe transmission issues where the car will not shift out of first gear. This happened on the Garden State Parkway and nearly caused an accident as the car wasn’t able to go above 27 mph safely.
NHTSA complaint #11740593 — an unverified report by a vehicle owner.
For the third time the 2025 KIA Carnival Prestige I own lost power while driving on the interstate! Without warning, the vehicle would no longer respond to the accelerator pedal. No matter what I did I could not get the vehicle to accelerate past 35 mph. The minimum speed limit on the interstate is 45 mph. I had to immediately engage my hazard lights and make my way over to the shoulder of the road from the passing lane. This was a dangerous situation for me and my family and others on the highway. Warning lights came on, check engine light, charging system, and a maintenance service message. Driving in Sport mode, Smart mode, nor Econo mode could change the negative situation. This took place multiple times during the final leg of my last trip to [XXX] , extending for over 120 miles. This is a very unsafe, unreliable vehicle, that should never be driven on public roadways… especially not highways nor interstates. Three negatively, traumatic experiences is ENOUGH!!! I’m DONE!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11740406 — an unverified report by a vehicle owner.
I am reporting a safety defect involving my 2023 Kia Carnival SX Prestige. On June 6, 2025, I brought the vehicle to Yonkers Kia Service Center because of a strong gasoline odor. The dealership told me the fuel tank was swollen and that the vehicle was unsafe to drive. The vehicle remained at the dealership from June 6, 2025 through October 17, 2025. Kia later indicated that the fuel tank, canister, and vent valve had been replaced. When the vehicle was returned to me on October 17, 2025, it still smelled like gas. Within 24–48 hours, the same or related safety issues returned, including strong fuel odor, loss of engine power, check engine light, abnormal fuel consumption, and later a visible fuel leak, which I documented on video. Because the vehicle did not feel safe, I stopped driving it on October 19, 2025. In March 2026, the vehicle was towed back to Kia for renewed diagnosis. Kia later reported that one fuel injector was leaking and performed additional repairs. My VIN now shows open unrepaired Recall SC368 / NHTSA Recall 26V232. That recall states that the high-pressure cross-over fuel pipe nuts may loosen over time, resulting in a fuel leak and fire risk. The recall warning signs include fuel smell and/or check engine light, which directly overlap with the exact symptoms I repeatedly experienced and reported. I am reporting that this vehicle had repeat fuel-related safety failures, a prior extended repair attempt that did not resolve the issue, and was previously returned to me in what I believe was an unsafe condition.
NHTSA complaint #11734511 — an unverified report by a vehicle owner.
Carnival was working fine then, without warning, I was unable to accelerate. Had entered highway and reached a maximum speed around 30 mph in a 55 mph zone. Pedal fully depressed and zero acceleration, dashboard read "check hybrid system, stop safely". Tried changing driving modes to no effect. Lots of cars speeding past as I pulled to the side to restart the vehicle, then it worked again without issue. Happened one other time, similar circumstances and results.
NHTSA complaint #11734666 — an unverified report by a vehicle owner.
Our 2024 Carnival has had a recurring engine oil leak that has required the vehicle to be left at the dealership 4 times for the same issue. Each time we get the van back the repair lasts about 1-3 weeks (depending on how often it's driven). Oil continues to leak from the engine area, creating risk of engine damage or a potential fire hazard if oil contacts hot components. The issue has not been resolved despite repeated repair attempts under warranty. The Carnival has 38,092 miles on it, and has been in the repair shop over 4 times. The 1st time it was put in the shop the van has 34,420 miles on it. Each time it has been left at the dealership for 9 - 17 days while the repairs were made. We have brought it to the same dealership each time and they have been very sympathetic and helpful. Not only does this issue cause the risks mentioned above, but it has ruined the concrete in my garage as well as added oil to the roadway which could cause an accident. I have all the repair orders from the first 3 repairs that I will attach. However I do not have thee current one because the vehicle is currently being repaired for the 4th time and I haven't received the finalized repair order documents. I can update this claim once the repairs are completed. I will be contacting Kia tomorrow and wanted to have a claim number started.
NHTSA complaint #11734153 — an unverified report by a vehicle owner.
I was on the on-ramp getting on the highway and whenever I started to increase speed and try to get over into the next lane, I noticed the car all of a sudden jumped a little bit and then it started consistently jumping in the check engine light was flashing, and I couldn’t keep the car over what ended up being 50 mph anytime I tried to go over 50 mph. The car jumped in was shaking pretty pretty aggressively I was able to finally make it to a gas station at the very next highway stop and after I shut the car off and turn it back on it seems like it was OK, but I’m still very scared to drive it. I then took it to the dealership to have them check for any store or pending codes because after we had stopped and turned the car back on it no longer had the check engine light on, and the dealership was not able to locate any stored codes in the system to see what it happened nor were they able to replicate the issue that we had found. Is a rec out on my vehicle, but no remedy is available and notices will not be sent for another month and a half at this point I am extremely uncomfortable driving my vehicle as I have young children and anything with a fire hazard is not safe.
NHTSA complaint #11733125 — an unverified report by a vehicle owner.
On the motor, when off for more than a certain time prolonged, when is a cold start motor make a noise like it doesn’t have oil in it since new I let the dealer know but they say it’s normal and I don’t believe so. Also, the transmission have a problem since New it shifted weird sometimes, and the dealer says it’s normal
NHTSA complaint #11733144 — an unverified report by a vehicle owner.
Engine light turns on every couple months. The Kia either stops accelerating and goes into “limp mode” or gives code for misfiring cylinders. Took to dealership several times, they did nothing but reset battery so light goes off. Unsafe when driving my family around and has turned into an unreliable vehicle. SO frustrating for a new vehicle to have these issues.
NHTSA complaint #11729561 — an unverified report by a vehicle owner.
My Kia vehicle has an ongoing engine oil leak that has not been properly repaired under warranty. The vehicle was taken to an authorized Kia dealership for diagnosis and repair of the oil leak. I was informed by the dealership that Kia engineers indicated that in similar situations the typical resolution is engine replacement. However, in my case, the dealership was instructed to attempt sealing the oil pan instead of replacing the engine. I was advised that if this repair did not resolve the issue, I could bring the vehicle back for further service. Unfortunately, the oil warning light has now returned on the dashboard, indicating the issue persists and the repair attempt was not successful. An unresolved engine oil leak presents a serious safety concern because loss of engine oil can lead to engine damage, stalling, or failure while driving. This creates a risk of unsafe driving conditions, especially when transporting passengers. My family relies on this vehicle for daily transportation, and the continued presence of the warning light makes the vehicle unreliable and concerning from a safety standpoint. In addition, the dealership has not provided a suitable loaner or rental vehicle large enough to accommodate my family while the vehicle is undergoing repair. This has created significant hardship as we do not currently have reliable transportation. The manufacturer should correct this defect properly and ensure the vehicle is safe to operate rather than attempt temporary or experimental repairs that do not resolve the root cause. The persistence of the oil leak after warranty repair raises concerns about the reliability and safety of the engine. I am submitting this complaint to document a potential engine defect that may pose a safety risk if engine oil loss leads to engine failure while the vehicle is in operation.
NHTSA complaint #11728723 — an unverified report by a vehicle owner.
"Continuous engine oil leak for 12 months. After 4 failed repair attempts, the dealer used liquid sealer instead of a gasket. This is a deceptive repair that creates a severe fire hazard. The leak is still active today, March 2026."
NHTSA complaint #11727626 — an unverified report by a vehicle owner.
When accelerating, the car feels stuck to gear up. After 2 seconds of loud revving, it would switch and have a prominent jerk motion that it finally switched gears. There have been times the car wouldn't go past 30 mph, stuck at the gear making a loud noise. This is dangerous! There's absolutely no way I can get on the freeway never getting past 30ish mph. I checked recalls for this vehicle and there isn't any. No warning lights in the dash.
NHTSA complaint #11726379 — an unverified report by a vehicle owner.
My engine smells like fire and fuel my can will not start or do anything. There was smoke coming out of it. The van has had several issues since buying it. Now it’s completely disabled I heard a popping noise as I was driving and then it died and has not started since.
NHTSA complaint #11723675 — an unverified report by a vehicle owner.
Out of nowhere, we started our vehicle that was no more than a year old, and all of the emergency alert indicators on the dash came on. All of the warning lights in the dash. The power steering went out and would go from very stiff to very loose. the car would shutter and then drive normal for a few min and then slow way down without warning. Again, all dash warning lights and alarms would go off. This first appeared on [XXX], we took to the Kia service on Nov. 17, 2025, and it was been in the shop with no repair since that day and todays date is Jan, 12, 2026. As of today they still do not know what is wrong with the vehicle and have no end in sight. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11710508 — an unverified report by a vehicle owner.
TL;DR : Vehicle engages limp home mode without any notification to the driver that it is in limp home mode and doesn’t generate any codes for technicians to identify why the vehicle went into limp home mode. During oil changes, a significant amount of residual oil remains in the engine. When the lube tech fills the oil using the recommended amount, engine is actually over full of oil as indicated on the dip stick. The vehile will start and run fine for a while. Later however, an oil pressure sensor will detect the over full status and put the car into limp home mode. No check engine light, no oil light, no indicator saying it’s in limp home mode, and when the service tech investigates, no code thrown for the issue. A manual checking of the dip stick will reveal the oil is over full. The fix is to drain oil to normal levels as shown on the dipstick. It isn’t a defect considering that it’s reasonable to expect a vehicle to be operated with the correct amount of oil. A future software update for the oil sensor to throw a code for the tech would be appropriate.
NHTSA complaint #11710347 — an unverified report by a vehicle owner.
I am unsure as for what is wrong with my car the dealership keeps saying its running rich and there is a recall on several 2022 Kia Carnivals that say it could be a faulty fuel rail tube. They have also said my map sensor is failing. My check engine light appeared a few days ago and has since been cleared and hasn't came back on, however it is just a matter of time. My children ride in this car as it is my daily driver and I have extremely head headaches. The dealership inspected the car and stated it did not smell like fuel however it definitely does.
NHTSA complaint #11709607 — an unverified report by a vehicle owner.
The contact owns a 2024 Kia Carnival. The contact stated that while driving at various speeds, an abnormal gas odor would emit through the vehicle's ventilation system. The contact notified a local dealer, and an appointment was made to have the vehicle serviced. The vehicle was inspected, and the contact was informed that there was likely bacteria growing inside the vehicle, which caused the odor. The contact disputed this claim and recommended that the air filters be replaced; the contact paid for the repair. Despite the repair, the contact stated that the fuel odor had become a chemical odor, and the vehicle was taken back to the dealer. The dealer confirmed that they had smelled a fuel odor inside the vehicle and informed the contact that she had overfilled her fuel tank with gas. While the contact also disputed this claim, the dealer later concluded that the dipstick inside the oil pan was not properly sealed, and the dealer repaired the defect. Despite the dealer's claims and repairs, the fuel odor had become stronger. The contact stated that the odor had become so severe that she went to the emergency room to be treated for nausea and lightheadedness. The contact was given medication for her symptoms. The manufacturer was notified of the failure, and the contact was given a case number. The vehicle had yet to be repaired. The failure mileage was unknown.
NHTSA complaint #11700277 — an unverified report by a vehicle owner.
I live in Alabama. Temperature here is 34 degrees so far in the morning. My check engine light is on. I have taken it in and had diagnostics and they can't find a code or code history. My heat and AC do not work properly if the ambient temperature on the cluster doesn't show up or is not correct. 72 degrees when it's not working right will run you out of the car it's so hot. The cluster currently says it's -15 degrees outside and has the snowflake beside it. I am scheduled bc they are booked out at the dealership to have diagnostics run on 11/14. I don't know if it is wiring, ambient temperature sensor, max air sensor, HVAC module (dealership had previously cleared water out of the module and then replaced the module, initially when they couldn't find the problem they disconnected the battery and reconnected to reset and clear the code). The dealership in Auburn Al has addressed all the issues and done all the services, updates, and trouble shooting. I'm having to run three different temps in the car and crack the windows when I need heat and AC just crack the windows and adjust the three temps again. I feel like I'm just getting a quick fix each time I go instead of the problem being resolved for good. This has been an ongoing issue especially when the temperature changes (seasons) or fluctuates (throughout the day). I've listed below the most recent start date. I would have to contact that dealership to get the exact timeframe that it ALL started.
NHTSA complaint #11697106 — an unverified report by a vehicle owner.
I am submitting this complaint regarding my Kia Carnival. The vehicle has a recurring and dangerous problem where the engine suddenly jumps and, if I continue pressing the gas, it shuts off while driving. This has happened multiple times, including in the middle of the highway, creating a serious safety risk for myself, my passengers, and other drivers. I have taken the vehicle to a Kia dealership on multiple occasions, but they have not been able to identify or repair the issue. I also contacted Kia corporate, obtained a case number, and was told someone would follow up with me. Unfortunately, no one has ever called me back. This is an ongoing and unresolved defect that puts my family and the public in danger. I request that the NHTSA investigate this matter to determine if this is part of a larger safety defect in Kia Carnival vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Kia case number XXX
NHTSA complaint #11690165 — an unverified report by a vehicle owner.