FaultScore

FaultScore report

2020 KIA Niro problems

Owners have filed 53 complaints about the 2020 KIA Niro with NHTSA between 2020 and 2026. The largest single group is the engine & cooling. Across this model's run it ranks 5 of 9 worst.

D

FaultScore 69/100

Higher is worse. Measured against the other years of the KIA Niro.

How this is worked out

The numbers

53

Complaints

4

Crashes reported

4

Fires reported

4

Injuries reported

46,000 mi

Median mileage at failure

Half of reported failures happened before this

44%

Failed under 36,000 miles

Inside a typical bumper-to-bumper warranty

What kind of bad

The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.

Complaint volume 48 vs 50 Severity 100 vs 50 Early failure 76 vs 50
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 48
Against the median year of the KIA Niro. 50 means typical for this model; 100 means roughly double.
Severity — 100
22.6% of these complaints involved a crash, fire, injury or death, against a national rate of 9.7%.
Early failure — 76
44% of failures with a mileage on record happened under 36,000 miles, against a national rate of 29%.

How 2020 compares with every other KIA Niro

Click any bar to open that year's report.

Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade: A B C D F ungraded

What breaks on a 2020 KIA Niro

Every complaint is filed against a part. Follow any row for the complaints about that part alone.

Engine & Cooling 10 18.9%

0 crashes, 1 fires · median 35,729 mi

Other & Unspecified 8 15.1%

0 crashes, 2 fires

Transmission & Drivetrain 8 15.1%

Median failure at 28,750 miles

Driver Assist & Collision Avoidance 7 13.2%

2 crashes, 0 fires · median 62,000 mi

Electrical System 7 13.2%

0 crashes, 1 fires

Brakes 4 7.5%

Median failure at 46,000 miles

Fuel & Propulsion 3 5.7%

Median failure at 110,000 miles

Windows, Mirrors & Wipers 2 3.8%
Airbags 2 3.8%

2 crashes, 0 fires

Stability & Traction Control 1 1.9%

Median failure at 30,000 miles

Seats 1 1.9%

Median failure at 60,000 miles

When it fails

Odometer readings owners gave when they filed. About half of all complaints include one.

Under 1,000 miles 1 11.1%
25,000 – 49,999 miles 4 44.4%
50,000 – 74,999 miles 3 33.3%
100,000 – 149,999 miles 1 11.1%

When owners complained

A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.

Aug 2020 peak 5 Aug 2026

NHTSA investigations into the 2020 KIA Niro

An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.

DP22005 Opened 27 Jan 2023 Closed 7 Aug 2023 ELECTRICAL SYSTEM:PROPULSION SYSTEM

Pedestrian alert sounds

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc...

Recalls on the 2020 KIA Niro

A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.

United States — NHTSA

23V534000

POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:CLUTCHES/BANDS:ACTUATORS/SOLENOIDS

Kia America, Inc. (Kia) is recalling certain 2017-2022 Niro and 2018-2022 Niro Plug-in Hybrid vehicles. Fluid may leak into the printed circuit board inside the hydraulic clutch actuator, which can result in an engine compartment fire.

Risk: A fire increases the risk of injury.

Canada — Transport Canada

Canada runs its own recall programme, and its campaigns do not always mirror the American ones.

Recall 2025345 2,604 units in Canada

Visual System

Issue: On certain vehicles, a problem with the rearview camera could cause the rearview camera image not to display. Canadian regulations require the rearview image to display when the vehicle is reversing. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to replace the rearview camera.

Recall 2025003 2,191 units in Canada

Brakes

Issue: On certain vehicles, water could enter the integrated electronic brake (IEB) and cause it to corrode. If this happens, the IEB motor could fail and cause reduced braking. Note: This service campaign only affects certain Niro EV models. Safety Risk: Reduced braking can cause extended stopping distances and increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to inspect the integrated electronic brake. The dealer will apply silicone to the IEB bolt hole or replace the IEB, as necessary.

Recall 2024549 647,384 units in Canada

Label

Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. Kia has corrected the compliance label for all new vehicles.

Recall 2023423 13,037 units in Canada

Powertrain

Issue: On certain vehicles, fluid could leak onto the printed circuit board for the hydraulic clutch actuator (HCA). If this happens, the circuit board could short circuit. Safety Risk: A short circuit could create the risk of an engine compartment fire while driving. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to inspect the hydraulic clutch actuator (HCA), and replace it if necessary. The technician will also install a new fuse for the HCA to reduce the risk of a fire.

Recall 2022689 428 units in Canada

Electrical

Issue: On certain electric vehicles, the electric power control unit (EPCU) may not be sealed correctly. As a result, coolant could leak inside the EPCU and onto the circuit board. If this happens, the vehicle could suddenly lose power to the wheels. Safety Risk: A sudden loss of power to the wheels may increase the risk of a crash. Corrective Action: Kia will notify owners by mail and instruct you to take your vehicle to a dealership to inspect the EPCU for internal coolant leaks. If a leak is detected, the dealer will replace the EPCU.

Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.

Complaints that involved harm

Reports where the owner recorded a crash, a fire, an injury or a death.

Manchester, NH Fire

ELECTRICAL SYSTEM

2020 Kia Niro was driving fine until one day while driving down the highway at highway speeds (65-70 mph), the car began to lose power and as we switched lanes to get to the side of the highway, the car began to smoke and caught on fire. Our safety was at risk due to the car catching on fire. The problem is unable to be reproduced as the car is a total loss. Vehicle was inspected by police at the scene. There were no warning lights, and the vehicle had been in working condition prior to the incident. The vehicle had a recall that was fixed at our local Kia dealership as soon as a solution was indicated, and the part was located.

NHTSA complaint #11640082 — an unverified report by a vehicle owner.

Manchester, NH Fire

ENGINE

2020 Kia Niro was driving fine until one day while driving down the highway at highway speeds (65-70 mph), the car began to lose power and as we switched lanes to get to the side of the highway, the car began to smoke and caught on fire. Our safety was at risk due to the car catching on fire. The problem is unable to be reproduced as the car is a total loss. Vehicle was inspected by police at the scene. There were no warning lights, and the vehicle had been in working condition prior to the incident. The vehicle had a recall that was fixed at our local Kia dealership as soon as a solution was indicated, and the part was located.

NHTSA complaint #11640082 — an unverified report by a vehicle owner.

Leesburg, VA Crash 1 injured

AIR BAGS

Hi my name is [XXX] I had an accident on a red light, I was on a highway took a ramp for the exit the car who was ahead of me like 30 feet make a right turn and as next on turn I look on my left side then when I turn on the right the car ahead of me stop again so I heat with the right corner of my bumper to the left rear corner of her bumper, both airbags deployed but the one on the bottom cut my leg, because the sewing part and threads were outside, I don't know if that is the way is supposed to be installed, because the airbag on the steering wheel doesn't have the sewing part outside. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11619612 — an unverified report by a vehicle owner.

Leesburg, VA Crash 1 injured

FORWARD COLLISION AVOIDANCE: WARNINGS

Hi my name is [XXX] I had an accident on a red light, I was on a highway took a ramp for the exit the car who was ahead of me like 30 feet make a right turn and as next on turn I look on my left side then when I turn on the right the car ahead of me stop again so I heat with the right corner of my bumper to the left rear corner of her bumper, both airbags deployed but the one on the bottom cut my leg, because the sewing part and threads were outside, I don't know if that is the way is supposed to be installed, because the airbag on the steering wheel doesn't have the sewing part outside. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11619612 — an unverified report by a vehicle owner.

Dallas, TX Fire

UNKNOWN OR OTHER

I have been a Lyft driver for over 2 years, and because of the mileage I put on mile personal vehicle. I had to result to renting a vehicle from Lyft Flex Drive Rental, located at 2214 Century Center Blvd Irving, TX 75062. 0n 05/15/2023 at approximately 8:15 p.m. Right after dropping off passenger, and on my way to pick up another one. The vehicle mentioned hereof suddenly blew up out of no where. My personal property in the vehicle was destroyed , and almost loss my life! However, Lyft is suggesting I pay over a thousand dollars. When it wasn't my fault the car blew up. Moreover, their stagnating me from getting back to work, and not allowing me to rent a car from Lyft Fleet . Because supposedly the car hasn't been totaled out yet. Despite it as been weeks since the incident occurred. I also took my vehicle to Lyft Flex shop for a check up the previous week before the incident occurred. My Please see photos attached! THE INSURANCE COMPANY HANDLING THE MATTER IS LIBERTY MUTUAL CLAIM # 241398210 / Phone Number: 888.638.3564

NHTSA complaint #11523754 — an unverified report by a vehicle owner.

West Orange, NJ Fire

UNKNOWN OR OTHER

I first bought the car brand new from the car dealership and the first problem was a check engine light came on when I bought it. I took it to the car dealership and could not find the problem. I bought the car in December 2020. And off and on the check engine light comes and goes. And they could not find the error. Lastly about two weeks before the car caught on fire. It was service for oil change and a catalytic converter replacement. After that while I was driving on the parkway in New Jersey I heard a loud bang in the engine and I pulled over and I saw a fire starting underneath the engine. The whole car is consumed in fire. The fire department came and put it out.

NHTSA complaint #11492683 — an unverified report by a vehicle owner.

The most recent complaints

In the owners' own words, exactly as filed with NHTSA.

South Burlington, VT

ELECTRICAL SYSTEM

AC not working, recall SA512 is needed, Kia wont cover the cost of replacing electrical components. Thermal Runaway / Fire Risk: The broken compressor prevents the battery thermal management system from cooling the main high-voltage lithium-ion battery package, creating an overheating hazard during driving or DC fast-charging. Sudden Loss of Power (Motive Power): Battery overheating can trigger a sudden "safe mode" or turtle mode, dropping your speed to zero unexpectedly on the highway.Impaired Driver Visibility: The lack of functional cabin heating prevents windshield defrosting, severely impairing the driver's ability to see the road safely.

NHTSA complaint #11755319 — an unverified report by a vehicle owner.

South Burlington, VT

ENGINE

AC not working, recall SA512 is needed, Kia wont cover the cost of replacing electrical components. Thermal Runaway / Fire Risk: The broken compressor prevents the battery thermal management system from cooling the main high-voltage lithium-ion battery package, creating an overheating hazard during driving or DC fast-charging. Sudden Loss of Power (Motive Power): Battery overheating can trigger a sudden "safe mode" or turtle mode, dropping your speed to zero unexpectedly on the highway.Impaired Driver Visibility: The lack of functional cabin heating prevents windshield defrosting, severely impairing the driver's ability to see the road safely.

NHTSA complaint #11755319 — an unverified report by a vehicle owner.

South Burlington, VT

VISIBILITY/WIPER

AC not working, recall SA512 is needed, Kia wont cover the cost of replacing electrical components. Thermal Runaway / Fire Risk: The broken compressor prevents the battery thermal management system from cooling the main high-voltage lithium-ion battery package, creating an overheating hazard during driving or DC fast-charging. Sudden Loss of Power (Motive Power): Battery overheating can trigger a sudden "safe mode" or turtle mode, dropping your speed to zero unexpectedly on the highway.Impaired Driver Visibility: The lack of functional cabin heating prevents windshield defrosting, severely impairing the driver's ability to see the road safely.

NHTSA complaint #11755319 — an unverified report by a vehicle owner.

Colorado Springs, CO

SERVICE BRAKES

This submission is supplemental information for my prior NHTSA complaint (Complaint #XXX). After filing the original report, I learned additional details from the Kia dealership that serviced my vehicle. The service department stated that they have seen the same electronic parking brake controller and actuator failure on multiple Kia Niro vehicles from model years 2018–2021. They reported that these failures were not covered under warranty for those years, even when the symptoms began during the warranty period. The dealer also explained that Kia made design improvements to the electronic parking brake system in later model years and expanded warranty coverage for the updated EPB assembly and control components. This suggests that Kia was aware of recurring issues with the earlier design, despite no formal recall or service campaign being issued for the affected 2018–2021 vehicles. I am submitting this supplemental information because it indicates a potential pattern of safety‑related failures involving the electronic parking brake system across multiple vehicles and model years. These failures affect the vehicle’s ability to hold position when parked and may interact with braking and stability control systems.”

NHTSA complaint #11749340 — an unverified report by a vehicle owner.

Colorado Springs, CO

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

This submission is supplemental information for my prior NHTSA complaint (Complaint #XXX). After filing the original report, I learned additional details from the Kia dealership that serviced my vehicle. The service department stated that they have seen the same electronic parking brake controller and actuator failure on multiple Kia Niro vehicles from model years 2018–2021. They reported that these failures were not covered under warranty for those years, even when the symptoms began during the warranty period. The dealer also explained that Kia made design improvements to the electronic parking brake system in later model years and expanded warranty coverage for the updated EPB assembly and control components. This suggests that Kia was aware of recurring issues with the earlier design, despite no formal recall or service campaign being issued for the affected 2018–2021 vehicles. I am submitting this supplemental information because it indicates a potential pattern of safety‑related failures involving the electronic parking brake system across multiple vehicles and model years. These failures affect the vehicle’s ability to hold position when parked and may interact with braking and stability control systems.”

NHTSA complaint #11749340 — an unverified report by a vehicle owner.

Sunnyvale, CA

POWER TRAIN

What's malfunctioning: coolant monitoring system shows low coolant warning when coolant level is observably fine. Problem has been ongoing for over a year. Available for inspection: yes. Safety problem: coolant monitoring is inaccurate, causing alarm when coolant levels are fine and possibly causing no alarm when coolant levels are too low. Problem reproduced: yes, by both dealer and independent service center. Vehicle inspected by manufacturer: yes. They attempted service but their repair only lasted a few months. Symptoms prior to failure: no. The problem is that the warning lights are turning on when they should not be. This matches the symptoms of Kia Technical Service Bulletin SA512, but the manufacturer's fix did not work.

NHTSA complaint #11746979 — an unverified report by a vehicle owner.

Colorado Springs, CO

SERVICE BRAKES

The electronic parking brake controller failed after intermittent warnings that began while the vehicle was still under warranty. The parking brake actuator also failed and had to be replaced. The electronic parking brake system is part of the vehicle’s safety system, and the failure caused the parking brake to malfunction unpredictably. The issue did not store persistent diagnostic codes, making it difficult to diagnose earlier. This is a safety concern because it affects the vehicle’s ability to hold position when parked and can interfere with braking and stability control. Because I am not the original owner, Kia refused to perform this as a warranty repair even though the intermittent failures began while the vehicle was under warranty.

NHTSA complaint #11744598 — an unverified report by a vehicle owner.

Colorado Springs, CO

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The electronic parking brake controller failed after intermittent warnings that began while the vehicle was still under warranty. The parking brake actuator also failed and had to be replaced. The electronic parking brake system is part of the vehicle’s safety system, and the failure caused the parking brake to malfunction unpredictably. The issue did not store persistent diagnostic codes, making it difficult to diagnose earlier. This is a safety concern because it affects the vehicle’s ability to hold position when parked and can interfere with braking and stability control. Because I am not the original owner, Kia refused to perform this as a warranty repair even though the intermittent failures began while the vehicle was under warranty.

NHTSA complaint #11744598 — an unverified report by a vehicle owner.

Colorado Springs, CO

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The electronic parking brake controller failed after intermittent warnings that began while the vehicle was still under warranty. The parking brake actuator also failed and had to be replaced. The electronic parking brake system is part of the vehicle’s safety system, and the failure caused the parking brake to malfunction unpredictably. The issue did not store persistent diagnostic codes, making it difficult to diagnose earlier. This is a safety concern because it affects the vehicle’s ability to hold position when parked and can interfere with braking and stability control. Because I am not the original owner, Kia refused to perform this as a warranty repair even though the intermittent failures began while the vehicle was under warranty.

NHTSA complaint #11744598 — an unverified report by a vehicle owner.

Mesa, AZ

UNKNOWN OR OTHER

The AC compressor failed due to an isolation resistance failure at the high voltage inverter. Freon leaked from the AC system into the battery chiller coolant loop, causing crystallization and blockages in the inverter coolant circuit. This is a battery thermal management system failure. The failure was confirmed and diagnosed by an authorized Kia dealer. Warning lights appeared on the dashboard including an inverter coolant warning. The vehicle was driven in ambient temperatures exceeding 108 degrees Fahrenheit in Arizona with no cabin cooling and a compromised battery thermal management system, creating a safety risk to the driver. The dealer quoted repair including AC compressor replacement, battery chiller replacement, and inverter coolant flush. Kia Consumer Affairs denied warranty coverage under the federal emissions warranty despite the vehicle being within the 8 year/80,000 mile coverage window at approximately 58,309 miles. No written explanation for the denial was provided. This failure appears to be a known pattern on this platform based on owner reports. The battery chiller and inverter coolant system are integral to battery thermal management and should be covered under the federal emissions warranty. The vehicle is currently unsafe to operate in extreme Arizona heat without functioning thermal management.

NHTSA complaint #11741696 — an unverified report by a vehicle owner.

New Albany, OH

ELECTRICAL SYSTEM

10.25" audio head unit. UVO no longer connects so that 911 and roadside assistance can not be reached. This is a known problem with 2019 and early 2020 Kia Niro's part# 96160-Q4210. I spoke to the Kia UVO Call Center and they confirmed that my unit is not communicating and has not since Dec. 2021. As I usually drive just around town I have not used UVO, but now that I'm on the road I need to be able to use this feature. I'm attaching a quote for a replacement unit

NHTSA complaint #11734752 — an unverified report by a vehicle owner.

Wynantskill, NY

ENGINE

I had my oil changed in Dec. 2025. I drove 1000+ miles w/no issue. Engine suddenly seized w/no engine light warning. Oil dumped all at once. Kia refuses to cover under warranty. THIS HAPPENED TO MY CAR: NTSA announced it had launched an investigation into Hyundai Motor Company and Kia Motor Company for problems with their oil pans and oil drain plugs... consumers have filed complaints their engine’s oil drain plug falls out, causing all the oil to drain out of their engine while driving. In multiple tests the oil drain plug was tightened according to factory torque specifications and the tightening was well documented. Yet, testing shows in multiple cases that while driving, the oil drain plug falls within a few thousand miles after the service. In those cases, the crankcase drained completely. The Hyundai and Kia drain plug falls out due to inferior oil pan material and the drain plug gasket. The testing and investigations appear to show that the oil drain plans are made with THIN METAL AND THE DRAIN PLUG MOUNTING IS POORLY REINFORCED. In addition, the oil pan is coated with a thick paint coating the bonds the gasket to the pan, so the gasket does not come off when the drain plug is removed. That gasket issue alone is not why the oil drain plug falls out, but it is a factor in the chain of events. The oil pan is the biggest problem Apparently, the thin metal, along with engine vibrations and expansion/contraction tend to loosen the drain plug without any other intervention. NHTSA is investigating this as a factory defect ... The problem is two-fold. First, even if the repair shop properly torques the drain plug, the oil drain plug falls out on its own. The customer then blames the shop for shoddy workmanship. Second, Hyundai and Kia dealers are telling customers that servicing their vehicle at an aftermarket shop automatically voids their factory warranty. This is totally false & actually illegal under the terms of the Magnuson-Moss Warranty Act.

NHTSA complaint #11733521 — an unverified report by a vehicle owner.

Fredericksburg, VA

ELECTRICAL SYSTEM

I own a 2020 Kia Niro PHEV. In October 2024, my dealership performed Technical Service Bulletin SA512 on my vehicle addressing the inverter coolant system. I was not informed at that time that the issue was likely to recur or that periodic maintenance would be required. In March 2026, the inverter coolant warning light returned. I brought the vehicle back to the dealership, where I was told the coolant had crystallized. The dealer confirmed this is a known recurring issue with this vehicle and stated it would need to be flushed approximately every two years since we drive relatively low miles per year (despite driving every day). I was not warned of this at any point. Furthermore, many owners likely drive it short distances every day since it is a plug-in electric vehicle. Kia denied goodwill coverage and I paid out of pocket for the repair. When I contacted Kia Customer Care, representatives gave conflicting information. One confirmed SA512 was performed as a service campaign, another stated it was only a TSB and declined coverage since my car is out of warranty (even though the warranty should still cover the battery and this is an electrical issue). A total case specialist I was assigned to said she would talk to the dealer and call me back but never did. The inverter cooling system is safety-relevant as it prevents the battery from overheating. The problem was confirmed and repaired by the dealership. The component is no longer available for inspection as the repair has been completed. Kia's issuance of SA512 suggests this is a known design issue affecting multiple owners of this model, and they informed the dealership that they could not cover the cost because if they did so, they would have to cover everyone with the same problem (again implying that the issue is quite widespread.)

NHTSA complaint #11727309 — an unverified report by a vehicle owner.

Fredericksburg, VA

FUEL/PROPULSION SYSTEM

I own a 2020 Kia Niro PHEV. In October 2024, my dealership performed Technical Service Bulletin SA512 on my vehicle addressing the inverter coolant system. I was not informed at that time that the issue was likely to recur or that periodic maintenance would be required. In March 2026, the inverter coolant warning light returned. I brought the vehicle back to the dealership, where I was told the coolant had crystallized. The dealer confirmed this is a known recurring issue with this vehicle and stated it would need to be flushed approximately every two years since we drive relatively low miles per year (despite driving every day). I was not warned of this at any point. Furthermore, many owners likely drive it short distances every day since it is a plug-in electric vehicle. Kia denied goodwill coverage and I paid out of pocket for the repair. When I contacted Kia Customer Care, representatives gave conflicting information. One confirmed SA512 was performed as a service campaign, another stated it was only a TSB and declined coverage since my car is out of warranty (even though the warranty should still cover the battery and this is an electrical issue). A total case specialist I was assigned to said she would talk to the dealer and call me back but never did. The inverter cooling system is safety-relevant as it prevents the battery from overheating. The problem was confirmed and repaired by the dealership. The component is no longer available for inspection as the repair has been completed. Kia's issuance of SA512 suggests this is a known design issue affecting multiple owners of this model, and they informed the dealership that they could not cover the cost because if they did so, they would have to cover everyone with the same problem (again implying that the issue is quite widespread.)

NHTSA complaint #11727309 — an unverified report by a vehicle owner.

Wynantskill, NY

ENGINE

Engine Seized at 79,000 miles on Kia Niro Hybrid on 3/8/2025. Oil was changed at 78,225 miles on 12/16/2025. No issues with vehicle until approx. 1,000 miles later and just a month and a half later when car suddenly lost power on a highway forcing me to try to safely and quickly navigate off the road. This could have caused risk to my life and other lives. The car could not be restarted. Kia said the drain plug was not screwed on and is refusing to honor warranty despite no issues with the oil change. Notably, in October 2022, the National Highway Traffic Safety Administration (NHTSA) announced it had launched an investigation into Hyundai Motor Company and Kia Motor Company for problems with their oil pans and oil drain plugs. Specifically, consumers and aftermarket service facilities have filed complaints their engine’s oil drain plug falls out, causing all the oil to drain out of their engine while driving. In multiple tests the oil drain plug was tightened according to factory torque specifications and the tightening was well documented. Yet, testing shows in multiple cases that while driving, the oil drain plug falls within a few thousand miles after the service. In those cases, the crankcase drained completely. [XXX] This issue should be investigated for potential recall to keep drivers, passengers safe on our highways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11726377 — an unverified report by a vehicle owner.

Houston, TX

ELECTRICAL SYSTEM

One night the tailgate latch began clicking, locking and unlocking itself and then not latching closed, causing the inside light to remain on and the tailgate open indicator to display on the display panel. Then it just went dead and would not open at all, even if using the specific tailgate open key on the key fob. Then a few weeks later while driving on an empty street very slowly as I was turning a corner, with no warning the back windshield suddenly made a loud noise and then spontaneously shattered. I got out and looked around and there was no one else around or any other cars driving by. I did not hear any impact and also had my driver window down and did not hear any shots, and was not able to recover anything from the inside the back of the vehicle or on the ground that could have hit it. Kia will not cover the cost of the back windshield even though I still have 5 years left on the manufacturer warranty, and purchased the dealership warranty. There is a class-action lawsuit against Kia that is for the Telluride model windshields but according to Google my affect some Niros (Sanchez Vs Kia).

NHTSA complaint #11720581 — an unverified report by a vehicle owner.

Houston, TX

VISIBILITY/WIPER

One night the tailgate latch began clicking, locking and unlocking itself and then not latching closed, causing the inside light to remain on and the tailgate open indicator to display on the display panel. Then it just went dead and would not open at all, even if using the specific tailgate open key on the key fob. Then a few weeks later while driving on an empty street very slowly as I was turning a corner, with no warning the back windshield suddenly made a loud noise and then spontaneously shattered. I got out and looked around and there was no one else around or any other cars driving by. I did not hear any impact and also had my driver window down and did not hear any shots, and was not able to recover anything from the inside the back of the vehicle or on the ground that could have hit it. Kia will not cover the cost of the back windshield even though I still have 5 years left on the manufacturer warranty, and purchased the dealership warranty. There is a class-action lawsuit against Kia that is for the Telluride model windshields but according to Google my affect some Niros (Sanchez Vs Kia).

NHTSA complaint #11720581 — an unverified report by a vehicle owner.

San Diego, CA

SERVICE BRAKES

When I’m braking at slow speeds, 10mph or less the front left tire braking system locks and makes the car skid. This happens randomly. There’s also a clicking sound made from the regen braking to switching to regular braking. The mechanic replaced the hca assembly and wiring kit from a recall but the car is still having the same issues. This also brings up the codes EBS and AUTO HOLD on my dash.

NHTSA complaint #11719210 — an unverified report by a vehicle owner.

New Albany, OH

ELECTRICAL SYSTEM

There were no symptoms prior to the warning message and warning symbol on the dash. Warning message was "Check EV System". I took my car to the dealer immediately. The dealer has had my car for 3 1/2 months, since Sept 12, 2025. Now the field tech from Kia, on 12/22/25, says that the Electric Power Control Unit (EPCU) needs to be replaced. This could have cause the vehicle to stop in the middle of traffic and cause an accident.

NHTSA complaint #11706924 — an unverified report by a vehicle owner.

Bakersfield, CA

UNKNOWN OR OTHER

AS AT 11/07/2023 KIA AMERICA KNEW OF HCV/HYDRAULIC CLUTCH ACTUATOR -HEV/HYBRID ELECTRIC VEHICLE CAUSED TRANMSISSION PROBLEM IN KIA NIRO HYBRID 2020 AND KIA AMERICA REFUSED TO REPAIR IT. RECALL COMPLETED 5/27/2025 AFTER POWER TRAIN WARRANTY EXPIRED.

NHTSA complaint #11697442 — an unverified report by a vehicle owner.

Bakersfield, CA

ENGINE

AS AT 11/07/2023 KIA AMERICA KNEW OF HCV/HYDRAULIC CLUTCH ACTUATOR -HEV/HYBRID ELECTRIC VEHICLE CAUSED TRANMSISSION PROBLEM IN KIA NIRO HYBRID 2020 AND KIA AMERICA REFUSED TO REPAIR IT. RECALL COMPLETED 5/27/2025 AFTER POWER TRAIN WARRANTY EXPIRED.

NHTSA complaint #11697442 — an unverified report by a vehicle owner.

San Bernardino, CA

BACK OVER PREVENTION

The contact owns a 2020 Kia Niro. The contact received notification of NHTSA Campaign Number: 25V426000 (BACK OVER PREVENTION). However, the part to do the recall repair was not yet available. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R) or the image was frozen. The failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was not provided.

NHTSA complaint #11695034 — an unverified report by a vehicle owner.

at 110,000 miles Bakersfield, CA

HYBRID PROPULSION SYSTEM

The contact owns a 2020 Kia Niro. The contact stated that while driving at an undisclosed speed, the HEV Hybrid System warning light illuminated, prompting the contact to discontinue driving the vehicle. The vehicle was towed to the dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 110,000.

NHTSA complaint #11679423 — an unverified report by a vehicle owner.

at 70,500 miles Northfield, OH

ENGINE AND ENGINE COOLING

The contact owns a 2020 Kia Niro. The contact stated that the oil change due in 700 miles message was displayed. The contact stated while driving 55 MPH to have an oil change performed, oil change service at 55 MPH, the contact heard an abnormal popping sound. The contact stated that the low oil pressure warning light became illuminated. The contact stated while approaching the Auto Shop for the oil change, the vehicle lost motive power and made another abnormal sound. The independent mechanic informed the contact that the engine might have failed and referred the contact to the dealer for assistance. The vehicle was towed to the dealer, where the contact was informed that the oil plug had separated, causing a significant oil leak and engine damage. The dealer determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 70,500.

NHTSA complaint #11665324 — an unverified report by a vehicle owner.

Daly City, CA

ELECTRICAL SYSTEM

What component or system failed or malfunctioned, and is it available for inspection upon request? The component that failed was the Hydraulic Clutch Actuator, which is part of the hybrid transmission system. This component was already replaced in May 2024 under recall SC276, but it failed again. The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? The failure significantly affects the vehicle’s drivability. The most noticeable issue is a loud, explosive-like sound during operation and a slipping sensation, especially when braking at low speeds on city streets. The vehicle feels unstable and difficult to control during these episodes. This creates a serious safety risk for me and for others on the road. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, it was inspected by a Kia dealership authorized by the manufacturer as part of recall SC276 in Colorado. It was later inspected again in February by Kia Serramonte in California for the same issue, but the problem still persists. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there are currently no warning lights illuminated. However, the vehicle shows abnormal behavior such as jerking, loss of power, and a noise similar to an explosion. These symptoms first appeared before the recall in 2024, and then reappeared in August 2024, just a few months after the repair until now. Due to financial limitations, I was only able to take the vehicle in for service in November 2024, and finally left it at the dealership in February 2025. The so-called “repair” lasted two months, but the dealership refused to take responsibility. I had to pay $3,188 out of pocket, and even after that, nothing was fixed — the vehicle remains defective.

NHTSA complaint #11657864 — an unverified report by a vehicle owner.