59 of the
786 complaints about the 2014 KIA Optima are about the
electrical system — 8% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
71,500 miles.
On 7/13/26 around 0715 my son was driving our 2014 Kia optima when it caught fire and burned from the engine to the back of the car. Fire dept and law enforcement had to respond and the vehicle along with thousands of dollars of property was destroyed by the fire. This vehicle is a total loss and I’m trusting an investigation as to I believe their fire started due to the engjbe and electrical faults of Kia motors.
NHTSA complaint #11750155 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2014 Kia Optima. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 71,527. However, upon taking the vehicle to the dealer due to excessive oil consumption, the dealer informed the contact that the actual mileage was over 200,000 as per the Carfax report. The seller was contacted but did not provide assistance.
NHTSA complaint #11742000 — an unverified report by a vehicle owner.
Claymont, DEFire
ELECTRICAL SYSTEM
The car is available upon inspection, the car caught on fire after being driven for about 45 mins. Smoke started to come from under the car hood, fire starting dropping from underneath the vehicle and then fire started coming from under the hood of the car. The car started smoking while being inside vehicle and the fire could've spread. The fire was put out by the fire department, the vehicle has not been inspected as of yet. No warning signs.
NHTSA complaint #11734586 — an unverified report by a vehicle owner.
Shortsville, NY
ELECTRICAL SYSTEM
My car has a engine light on an I was told it has a recall on it It a FUEL SENDING UNIT-N and a FUEL PUMP LOCK RING -N.
NHTSA complaint #11711783 — an unverified report by a vehicle owner.
Spokane, WA
ELECTRICAL SYSTEM
My oil pressure sensor failed and is leaking oil into the electrical wire harness and all over the engine including intake and exhaust pipes which is a fire risk. It is the exact same issue as another recall affecting 2011 to 2014 kia models/years: 2019 safety recall (RCONL-19V101-0000) that involves replacing the oil pressure switch in certain 2011-2014 models if a leak is found. Additionally, a 2022 Technical Service Bulletin (MC-10210268-0001) extended the warranty for the oil pressure switch replacement to 15 years/150,000 miles for eligible vehicles. The recall addressed potential oil leaks, and the warranty extension covers the switch itself. 2019 safety recall (RCONL-19V101-0000) What it covered: The recall was for certain 2011-2014 Kia models and involved inspecting and potentially replacing the Oil Pressure Switch (OPS) and the oil pan if an oil leak was detected. Unfortunately at this time the dealership is claiming that this recall does not include my specific vehicle by Vin and I will have to cover the repair outside of warranty/recall to make the vehicle function properly/eliminate the oil leak/fire risk. It would be great if other kia optima owners could be protected and covered by the recall I mentioned above.
NHTSA complaint #11699235 — an unverified report by a vehicle owner.
Miami, FL
ELECTRICAL SYSTEM
[XXX] , [XXX] [XXX] [XXX] Email: [XXX] [XXX] [XXX] Date: October 5, 2025 Kia America, Inc. Consumer Affairs Department [XXX] Subject: Request for Goodwill Repair – Defective Paint on 2014 Kia Optima LX Dear Kia Consumer Affairs Team, I am writing to formally request assistance regarding the defective paint on my 2012 Kia Optima LX. The paint has begun to peel and flake on several areas of the vehicle, including [insert locations — e.g., the hood and roof, if you want to specify], and the problem continues to worsen over time. My vehicle details are as follows: •Year/Model: 2014 Kia Optima LX •VIN: [XXX] •Mileage: 187,000 miles •Color: silver After researching this issue, I learned that many other Kia owners with similar models and colors have experienced the same paint defects. It appears to be a known issue related to the factory paint or clear coat used on certain Kia vehicles from this period. I have always maintained my Optima properly and have not had any repainting or accident-related body work done. The paint defect significantly impacts the car’s appearance and resale value, and I respectfully request that Kia provide a goodwill repair or repaint under its customer satisfaction or defect resolution policy. Please let me know how I should proceed to have the vehicle inspected or evaluated. I have photographs of the damaged areas available for your review upon request. Thank you for your time and attention to this matter. I look forward to your response. Sincerely, [XXX] [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11691564 — an unverified report by a vehicle owner.
Pasadena, CA
ELECTRICAL SYSTEM
While driving my car I will get a sign that pops up flashing says “check hybrid system stop vehicle and turn off engine” with a HEV inside of a yellow triangle. Some times it will go off on its own but most times I have to pull over turn my car off and then once I start it back it’s fine. Some times my car will loose power but no too often. It’s very unsafe and happens randomly. I also notice that if I turn my air conditioner on high it triggers my car to do that. I changed my hybrid battery twice and my 12V battery. I’ve taken it to Kia and other mechanics but no one can figure out what’s going on.
NHTSA complaint #11684175 — an unverified report by a vehicle owner.
Crossett, AR
ELECTRICAL SYSTEM
While driving Kia Optima, unable to turn steering wheel. No notice when first starting vehicle. While driving, a traction and steering wheel light turns on without a sound(ding) to notify driver. Then once driver attempts to turn, unable due to steering wheel locked. Unsafe to drive on the road. Dangerous for all passengers. Our safety is put at risk due to unable to turn steering wheel while driving. Must turn vehicle off in middle of road, then it resets so steering wheel to turn. Code C12 60 returns for power steering sensor malfunction.
NHTSA complaint #11681739 — an unverified report by a vehicle owner.
Oxford, NC
ELECTRICAL SYSTEM
The wire that causes the car to crank start burning that in the wiring hardness. which it make the car hard to crank
NHTSA complaint #11681174 — an unverified report by a vehicle owner.
Danville, VA
ELECTRICAL SYSTEM
While driving home one day, the engine shut off while in traffic. The engine light had started to blink right before. The battery, starter, and oil levels were fine. A mechanic later confirmed the engine was locked. I see there are articles stating there were engine recalls for 2011-2014 Kia optima’s, but my 2014 Kia Optima EX was denied. Please help. I love my Kia. Thanks.
NHTSA complaint #11675671 — an unverified report by a vehicle owner.
at 147,000 milesHarwich, MAFire
ELECTRICAL SYSTEM
The contact owned a 2014 Kia Optima. The contact stated while driving at an undisclosed speed, the contact noticed smoke that exited from under the front hood of the vehicle. The contact stated the smoke was intense. In addition, the contact was informed by a nearby driver that fire was coming from underneath the front of the vehicle. The contact drove the vehicle into a nearby parking lot and exited the vehicle. In addition, the contact's disabled son was also an occupant in the vehicle making the situation very frightening. The fire department arrived and extinguished the fire. A fire report was filed. The vehicle was towed to a local tow yard and mentioned the fire was electrical. The vehicle was condemned as a total loss by the insurance company. The contact was informed that due to the vehicle fire, the local establishment sprinkler system was activated and caused damage. The VIN was not included in a recall however the contact believed the failure was an electrical short which resulted in an engine compartment fire. The manufacturer was not made aware of the failure. The failure mileage was approximately 147,000.
NHTSA complaint #11641730 — an unverified report by a vehicle owner.
Redlands, CA
ELECTRICAL SYSTEM
Brake lights only work when car has lights off when Libyans are on brake lights stay on entire time
NHTSA complaint #11641026 — an unverified report by a vehicle owner.
Al-Nhada, GA
ELECTRICAL SYSTEM
Complaint Summary: I am the current owner of a 2014 Kia Optima, which is affected by recall 23V652 related to the Hydraulic Electronic Control Unit (HECU). The vehicle was imported to the UAE, and the recall was not addressed by the previous owner. As a result, I am now facing significant safety issues. Since taking ownership, I have encountered multiple engine problems, including sudden power loss, severe vibrations, and abnormal behavior from the throttle. These symptoms align with the issues outlined in the recall notice, indicating that the vehicle may pose a safety risk to me and other road users. Despite my efforts to diagnose the problems, I have already incurred costs exceeding 13 AED on various repairs and diagnostic services, all while being unaware of the existing recall. It was only recently that I discovered the recall information online, which has heightened my concern regarding the safety of my vehicle and the potential for further complications. Given these circumstances, I am requesting assistance from the NHTSA in resolving this recall issue and guidance on how to proceed with the necessary repairs while the vehicle is registered under my name in the UAE. It is crucial for me to ensure the safety of my vehicle for my own protection and for the safety of others on the road. I appreciate your attention to this urgent matter and look forward to any support you can provide. Please let me know if further information or documentation is needed Thanks alot
NHTSA complaint #11622155 — an unverified report by a vehicle owner.
at 140,058 milesTomball, TXFire
ELECTRICAL SYSTEM
Car caught fire, parked in driveway, partially damaged the house.
NHTSA complaint #11585588 — an unverified report by a vehicle owner.
Woodbridge, VA
ELECTRICAL SYSTEM
Exact same issue happened to my 2014 Kia Optima Hybrid (NHTSA ID Number: 11556409). I was traveling on the freeway approximately 65mph and out of nowhere the engine turned off, brakes did not work and steering quality went to a manual operation. I almost got into a serious accident as I could not control my vehicle. The hybrid system warning light, to stop using the vehicle became illuminated for approximately 30 seconds. The vehicle was towed to the local dealer ( Koons Kia, 14208 Richmond Hwy, Woodbridge, VA 22191, United States). We are still awaiting diagnostics. A few years ago the standard hybrid light came on (not the same warning light) in which we took it to the same dealer to fix. It was still under warranty at the time, however took them weeks to fix the issue as I had to take it back multiple times. They eventually replaced something in the hybrid system that was worth around $5-6k, since then we have had no other issues. We conduct the routine maintenance on the vehicle, passes all inspections.
NHTSA complaint #11560302 — an unverified report by a vehicle owner.
Scranton, PA
ELECTRICAL SYSTEM
I was with my family on PA I-476. While traveling home in our 2014 Kia Optima the vehicle’s dash lights such as oil lamp, battery, etc popped on. As soon as I noticed the lights the vehicle had completely lost all drivability. Lights operable and possibly radio and accessories but I had to react so quickly as it was so unexpected. The vehicle completely lost its function and I was unable to operate it but in the capacity of steering and hardly able to break. Lost all power components. We are so thankful I was able to make a split second decision to dodge traffic while vehicle was decelerating, 18 wheelers going by 70+ mph (speed limit) and pulled off to one of the few shoulders. This scenario was so dangerous that if I didn’t believe in a higher being before, I do now! Most the lanes are sandwiched by concrete barriers and there happened to be a coned off area I was able to decisively pull over to. There was no warning this was happening. The vehicle was operating normally. The engine compartment was smoking and all I could think was to get my family away from traffic. The look on my wife and daughters face and the words my daughter asked me was life changing. The vehicle is at Kia dealership since Saturday night. It’s Wednesday and they cannot provide diagnostic yet but are charging me for a starter already? They began to inspect vehicle Monday.
NHTSA complaint #11554104 — an unverified report by a vehicle owner.
Saint Louis, MO
ELECTRICAL SYSTEM
In accordance with Kia recall SC212, client had HECU/ABS module & multi fuse kit replaced/installed on September 10, 2021. The ABS warning light began to show on 10/6/2023. Client was told by licensed Kia dealer that the HECU needed to be replaced again due to fire risk. Dealer stated since there aren’t any active recall campaigns on vehicle, repairs would need to be paid by client. Client is seeking reimbursement for having the HECU replaced the second time since the recall replacement failed.
NHTSA complaint #11549274 — an unverified report by a vehicle owner.
Jonesboro, GAFire2 injured
ELECTRICAL SYSTEM
Summer 2017 The engine failed while driving with my family. The engine seized and a fire was engulfed. I was in the interstate and we feared for our life. Out of town visiting family we were stranded in another state for a month waiting for repairs. Kia took the vehicle and replaced the engine with another faulty engine that has seized several times while commuting. I have been living in fear and anxiety since this incident. I never know if I start my engine if I will loose my life. Summer 2023 3 teenagers watched a viral tic tok challenge and learned how faulty the cylinder that Kia installed was. The teens then trespassed into my home, broke the windows and stole my vehicle. I have lived in fear since this has happened. I have lost jobs, income, and peace due to The purchase of this vehicle. Kia has never assisted or kept the promises they made to restore the vehicle. These past 10 years agave been a nightmare and as an African American woman I believe I was targeted as a purchaser for this make and model. My life had been hell since the purchase of this vehicle. I have not been able to satisfy payment due to repairs, thefts, fires, and more. Please anyone. Someone. Help. This is the most heartbreaking experience as an American. I have worked for my country 20 years and do not feel like an equal citizen. I have been homeless, jobless, unstable, and watched my life and family life flash before me in near death accidents involving this car. When I purchased this car I had a great job, credit score, and home. Now I have more anxiety, fear, bills, and no help with this Kia.
NHTSA complaint #11548045 — an unverified report by a vehicle owner.
Henrico, VAFire
ELECTRICAL SYSTEM
I was driving down the street when car caught on fire out of no where.
NHTSA complaint #11547489 — an unverified report by a vehicle owner.
Palm BAY, FL
ELECTRICAL SYSTEM
The antenna cover completely came off, nothing hit it, it just fell off. I know there is a technical bulletin SA272 for the 2016MY Optima for the exact same reason. My radio no longer works as it displays antenna error and I have lost all AM Radio usage and FM Radio is barely clear. I’m afraid this could cause an electrical issue now that the wiring and circuitry for the antenna is now exposed.
NHTSA complaint #11542827 — an unverified report by a vehicle owner.
Marquette, MI
ELECTRICAL SYSTEM
Driving from arquette, I to St. Ignace, I on Saturday, August 6, 2023 when I was passing a slower moving car on -28 Eastbound, when the engine stalled and had to be towed to idas Muffler Shop at 2192 US Hwy 41 W., arquette, i, 49855. Upon further evaluation it was discovered that the engine had seized and is frozen up. There is currently a recall for engine seizures, Reference Number 17V224000, and Kia's number for this recall is SC147.
NHTSA complaint #11537177 — an unverified report by a vehicle owner.
Durham, NC
ELECTRICAL SYSTEM
Today, 7/11/23, I was traveling on the interstate with no issue. Upon exiting the interstate up a slight hill, there was one car in front of me, I let off the gas and began to roll backwards I hit the brake and didn't think anything of it at first. The car in front of me pulled forward and I took my foot off of the brake and began to roll backwards again, I hit the gas and nothing happened, during this I also heard what sounded like a clunk noise. At this point I put my flashers on and looked at the dashboard, I saw three lights that have never appeared before. (Oil light, battery light, and check engine light) I placed the car in park and sat for a moment. The car was still on but not running, I pressed my start button and the car turned over the lights went off and I drove about 3 miles down the road to a lot. Once the car cooled I checked the oil and the level was fine no smoke nothing strange. I went to pull out and drive again and the same exact thi g happened again. However, a few hours later my fiance drove it home and had no issue. If my car had rolled back I could have hit someone or been hit. It's something unknown and is dangerous. This all just happened today and it has not been taken anywhere yet.
NHTSA complaint #11531696 — an unverified report by a vehicle owner.
Raymond, MSFire
ELECTRICAL SYSTEM
The car caught fire last night and burned up while parked.
NHTSA complaint #11514559 — an unverified report by a vehicle owner.
New Bern, NC
ELECTRICAL SYSTEM
HEV Warning light comes on and says HEV malfunction, stop car. Within seconds the car shuts off and has no brakes and then stops in road construction, blocking up an entire lane of traffic, as there was no shoulder because of barricades. I panic as I can’t get out without getting ran over. After sitting for 5 minutes, car restarts and drives away ok. Car has done this off and on for 2 years. After the first incident, I took it to Kia of New Bern who charged me $400 to “update software” according to a TSB, even though it was under warranty. After getting the car back, the next day the warning came back on. I called Kia of New Bern and they said they will charge another diagnostics fee I couldn’t afford, so I didn’t go back. There are many others who have had the same issue with their KIA Hybrids. These cars are a danger to their drivers and the unknowing public who share the roads with them. KIA Should be ashamed of the amount of cars experiencing this issue and their lack of solutions to fix it.
NHTSA complaint #11509397 — an unverified report by a vehicle owner.
Bartow, FL
ELECTRICAL SYSTEM
The hybrid system on my vehicle continues to show an error when operating the vehicle. The manual says to not operate the vehicle, but the dealership continues to deny the issue with my vehicle. Currently, I'm without my vehicle for approximately a period of two weeks with no resolution to fix my car. I have asked for information under the vehicle care act, but have not been given a current report on the repair needed.
NHTSA complaint #11502067 — an unverified report by a vehicle owner.
Warner Robins, GA
ELECTRICAL SYSTEM
I was making a right hand turn and I noticed my turn signal was flashing very fast. So I pulled over once I had the opportunity to. I turned on my signal and checked to see if they were working and found my rear to be out. Went to the parts store purchased new bulbs and drove home. My husband changed the bulbs on both sides and it still did the same thing I checked the bulbs and they were the correct ones so we swapped it and still not working. Has a electrical issue in the tail light assembly.
NHTSA complaint #11491730 — an unverified report by a vehicle owner.
at 97,484 milesPowder Springs, GA
ELECTRICAL SYSTEM
The contact owns a 2014 Kia Optima. The contact stated while his son was driving 45 MPH, the vehicle lost motive power and stalled. The contact’s son was able to pull over safely. The contact attempted to jump start the vehicle however, the vehicle would not start. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not contacted or notified of the failure. The failure mileage was 97,484.
NHTSA complaint #11480524 — an unverified report by a vehicle owner.
Lawton, OK
ELECTRICAL SYSTEM
I was driving down the interstate for my work commute apx 70 mph when HEV warning light engaged and vehicle went into limp mode. Had vehicle towed to dealership after running several tests determined the engine was knocking and needed replaced. After 2 months reman engine placed in vehicle. Vehicle function apx 6 months when the exact same problem occured on the highway traveling apx 60 mph. Vehicle is still in dealership. Thankfully, both times I was able to coast to the shoulder and avoid a collision. There is something wrong with these vehicles that need to be fixed.
NHTSA complaint #11478392 — an unverified report by a vehicle owner.
Brunswick, MO
ELECTRICAL SYSTEM
Traction control light has recently started coming on all the time and stays on. When you turn car off and it cools off then the light is off again. Another issue is when I place foot on brake the passenger side parking light comes on and the passenger brake light has had to be replaced 7 times since i bought car in February 2021
NHTSA complaint #11422079 — an unverified report by a vehicle owner.
Fairfax Station, VA
ELECTRICAL SYSTEM
FOURTH TIME THIS PROBLEM HAS OCCURRED: WHILE AT SPEED, THE ENGINE TURNS OFF AND I GET A HYBRID SYSTEM WARNING. THIS TIME I WAS TURNING INTO A PARKING LOT, SPEED ABOUT 10 MPH. CAR BARELY DRIFTED OUT OF THE DRIVING LANE. I SHUT DOWN THE VEHICLE FOR 5 MINUTES. UPON RESTART, ENGINE LIGHT IS ON. VERY DANGEROUS SITUATION WITH THESE ENGINES SHUTTING OFF. IT'S BEEN ABOUT 10 MONTHS SINCE "REPAIR" AT A KIA DEALERSHIP FOR THIS ISSUE. KIA HAS FAILED TO FIX THESE ISSUES AND THERE ARE MANY REPORTS OF THE EXACT SAME ISSUE ON VARIOUS WEBSITES.
NHTSA complaint #11400109 — an unverified report by a vehicle owner.