10 of the
376 complaints about the 2016 KIA Sedona are about the
fuel system — 3% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
25,964 miles.
While driving car gas tank blew a hole and started on fire. Car then lost power while on fire while I was in traffic, luckily I was able to cut into a parking lot and people that were in traffic with me call 911. Fire department confirmed there was a hole in gas tank which sits right underneath driver side. Fire was only contained to where the gas tank and lines are. I have pictures.
NHTSA complaint #11735273 — an unverified report by a vehicle owner.
Norco, CA
FUEL/PROPULSION SYSTEM
Kia service dealer diagnosed high oil consumption on my car with heavy sounds. They recommend to replace whole engine but it's out of warranty. It has only 106k miles on it. I am afraid the car is posing safety issue as well and it has less miles on it. I filed complain with kia consumer corporate a case has been generated on their system [XXX] but no one had contacted me yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11707644 — an unverified report by a vehicle owner.
Arp, TX
FUEL/PROPULSION SYSTEM
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
NHTSA complaint #11667762 — an unverified report by a vehicle owner.
Carrollton, VA
FUEL/PROPULSION SYSTEM
On June 6th 2024 My 2016 Kia Sedona experienced sudden power loss accompanied by thick smoke out of the exhaust and a loud ticking while on a busy main intersection. Kia's Gross negligence to recall its known troubled engines is causing needless highway incidents. From stolen cars, engine failures and now fires, this is the second Kia I have had fail.
NHTSA complaint #11594935 — an unverified report by a vehicle owner.
Car has a strong gas smell coming from front area through vents, when opened hood strong gas is smelled. Car is now stalling when starting. Afraid that car will burst into flames and explode. I have read that there was a recall due to cracked fuel rail but my 2016 does not fall within the model years. This is ridiculous that it’s the exact same thing happening to my 2016 sedona. The smell of gas is excessive and I had to take all of my kids out of the car and now do not trust to drive it. My car was completely fine and how can something randomly crack and cause this. No light or warning indicates this issue.
NHTSA complaint #11491851 — an unverified report by a vehicle owner.
at 38,727 milesNewport Beach, CAFire
FUEL/PROPULSION SYSTEM
THE VEHICLE CAUGHT ON FIRE WHILE PARKED IN THE DRIVEWAY AND BURNED TO THE GROUND. WE CONTACTED KIA MOTORS REGARDING THIS. IT TOOK THEM WEEKS BEFORE THEY SENT OUT A REPRESENTATIVE TO INSPECT THE VEHICLE. UPON INCEPTION OF THE VEHICLE THEY SIMPLY DENIED THAT THE ENGINE FIRE WAS CAUSED BY FAULTY PARTS AND DECLINED RESPONSIBLY FOR THE IT!
NHTSA complaint #11322039 — an unverified report by a vehicle owner.
at 55,657 milesMonroe, GA
FUEL/PROPULSION SYSTEM
10-26-19 DRIVING ON HWY AT 60 MPH ON SAT. NIGHT AND I COULD TELL THE CAR HAD LOST POWER TO THE ENGINE. COASTED TO AN EMPTY PARKING LOT. TRIED TO CRANK. IT WOULD CRANK AND THEN DIE. LIGHTS STILL WORKED. THERE WAS A STRONG SMELL OF GASOLINE WHEN TRYING TO CRANK. HAD TO HAVE IT TOWED 60 MILES TO HOME. TRIED TO CRANK THE FOLLOWING DAY AND SMOKE BILLOWED OUT OF THE EXHAUST. GASOLINE SMELL EXTREMELY STRONG.
NHTSA complaint #11277054 — an unverified report by a vehicle owner.
at 20,000 milesMilton, NYCrashFire
FUEL/PROPULSION SYSTEM
I WAS DRIVING GOING WESTBOUND ON HIGHWAY 84 IN PENNSYLVANIA AND HIT A DEER GOING 65MPH. I PULLED OVER TO THE SIDE OF THE HIGHWAY. I WALKED OUT TO THE MILE MARKER AND WHEN I TURNED AROUND MY CAR WAS ON FULLY ENGULFED IN FLAMES. EVENTUALLY MY CAR BLEW UP AND I LOST EVERYTHING.
NHTSA complaint #11129664 — an unverified report by a vehicle owner.
at 25,964 milesSpring Hill, FLCrash
FUEL/PROPULSION SYSTEM
WHILE PULLING INTO MY DRIVEWAY GOING BETWEEN 5-10 MPH I APPLIED THE BRAKE AND THE VEHICLE LUNGED FORWARD INTO MY GARAGE DOOR WHICH WAS CLOSED AND DAMAGED ANOTHER CAR PARKED IN THE GARAGE. IF THE OTHER CAR WAS NOT THERE TO STOP IT I MAY HAVE BEEN KILLED. I REPORTED THIS TO KIA AND THE INVESTIGATION ONLY SHOWED A BLOWN FUSE WHEN THEY CONNECTED IT TO THE TESTER. THERE ARE TWO OTHER ACCIDENTS THAT I KNOW OF WITH SIMILAR CIRCUMSTANCES, PLEASE CHECK INTO THIS BEFORE SOMEONE IS KILLED OR LOSES MONEY DUE TO SOMETHING THAT WAS NOT THEIR FAULT. BY THE WAY I WAS TURNING RIGHT INTO MY DRIVEWAY AND MY HUSBAND WAS BACKING OUT IN HIS CAR WHEN THIS TOOK PLACE AND HE SAW THE WHOLE THING.
NHTSA complaint #11046496 — an unverified report by a vehicle owner.
at 460 milesBlythewood, SC
FUEL/PROPULSION SYSTEM
WHEN FILLING THE GAS TANK TO FULL. STARTING THE CAR AND DRIVING IT, THE RPM'S FLUCTUATE DRASTICALLY, AND THE CAR "BUCKS" AT ANY SPEED (NO PARTICULAR SPEED, OBSERVED AT A STOP, ACCELERATING, CRUISE CONTROL, 45 MPH). ONCE THE GAS LEVEL IS LESS THAN FULL - AROUND 7/8 OF A TANK, THE VAN SEEMS TO DRIVE OK. THIS HAS HAPPENED ON 2 OCCASIONS. (2 FILL UPS TO FULL, 1 ADDITIONAL FILL UP TO 7/8 OF A TANK HAD NO ISSUE). THE SECOND FILL UP WAS THE WORST - THE CAR COMPLETELY SHUT OFF WHILE MAKING A TURN AT AN INTERSECTION. HAPPENED AGAIN THE SAME DAY, FROM A STOP, ACCELERATING TO TURN THE CAR SHUT OFF.
NHTSA complaint #10896348 — an unverified report by a vehicle owner.