77 of the
421 complaints about the 2003 KIA Sorento are about the
fuel system — 18% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
95,000 miles.
WHEN PUMPING GAS THERE IS A SUDDEN SPEWING OF GASOLINE OUT OF THE TANK AND ALL OVER ME. I MANAGED SEVERAL TIMES TO GET A FEW GALLONS IN BY PUMPING SLOWLY BUT THE NEXT DAY THE GAS GAGE READS EMPTY AND HAS ACTUALLY RUN OUT OF GAS SEVERAL TIMES! SO NOT ONLY AM I HAVING A PROBLEM PUTTING GAS IN, IT IS IMMEDIATELY DRAINING OR LEAKING OUT!
NHTSA complaint #11149624 — an unverified report by a vehicle owner.
at 155,000 milesPuyallup, WA1 injured
FUEL/PROPULSION SYSTEM
AFTER PURCHASING CAR FROM PRIVATE SELLER I DISCOVERED THAT WHEN TRYING TO PUMP GAS, MY FUEL SPRAYS BACK OUT ALL OVER MYSELF, MY VEHICLE, AND THE GROUND. HAVE EVEN HAD IT SPRAY INTO MY EYES. DID RESEARCH AND SAW THAT THIS IS A VERY COMMON OCCURRENCE FOR THIS YEAR/MAKE/MODEL. I BELIEVE ITS A FIRE AND SAFETY HAZARD AND SHOULD HAVE BEEN RECALLED YEARS AGO!
NHTSA complaint #11094097 — an unverified report by a vehicle owner.
at 93,632 milesYpsilanti, MI
FUEL/PROPULSION SYSTEM
MY 2003 KIA SORENTO DRIVES FOR 15 MINUTES AND STALLS OUT. I WAIT 5 MIN AND IT'LL START AND DRIVE FOR A BLOCK OR 2AND CONTINUES TO THAT UNTIL I GET IT TOWED HOME
NHTSA complaint #11043741 — an unverified report by a vehicle owner.
at 165,000 milesPortsmouth, NH
FUEL/PROPULSION SYSTEM
THE 2003 KIA SORENTO HAS A PROBLEM WITH EXTENSIVE FRAME RUSTING, TO THE POINT WHERE SOME OWNERS HAVE HAD THE SUSPENSION DETACH FROM THE FRAME. ONE OWNER IN PARTICULAR HAS HAD ISSUES WITH THE GAS TANK NEEDING TO BE REPLACED, AND KIA MOTORS REFUSES TO DO ANYTHING ABOUT THE PROBLEM. THEY BUILT THE CAR, SOLD IT TO PEOPLE, AND WHEN CONSUMERS HAVE COMPLAINTS ABOUT THEIR VEHICLE, THEY (KIA) SAYS THAT THEY'RE NOT RESPONSIBLE. YOU NEED TO EXAMINE THIS, BECAUSE PEOPLE COULD GET KILLED BY OPERATING AN UNSAFE VEHICLE. DO SOMETHING ABOUT THIS NOW, BEFORE IT BECOMES THE NEXT PINTO. MAKE KIA FIX THE [XXX] VEHICLES NOW!!! PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #10967402 — an unverified report by a vehicle owner.
at 33,000 milesWeaverville, NC
FUEL/PROPULSION SYSTEM
WHILE FUELING UP THE SORENTO, THE FUEL SPIT OUT EVERY TIME EVEN WHILE FUELING AT SLOW SPEEDS. VERY FRUSTRATING , AND DANGEROUS, ESPECIALLY WHEN THE FUEL GETS ON MY SKIN & CLOTHES, THE VEHICLE, AND AT TIMES LEAVES A HUGE PUDDLE ON THE GROUND WHICH COULD BE A FIRE HAZARD. THE DEALERSHIP WAS CONTACTED AND WILL NOT HELP ME EVEN THOUGH THERE WAS A RECALL ISSUED FOR THE FUEL FILTER, WHICH I MENTIONED.
NHTSA complaint #10960423 — an unverified report by a vehicle owner.
at 128,800 milesBristol, CT
FUEL/PROPULSION SYSTEM
WHEN I PUMP GAS INTO MY CAR, THE FUEL SPITS BACK OUT AT ME. I HAVE TO PUMP REAL SLOW FOR THIS NOT TO HAPPEN. THIS IS DANGEROUS, GAS GETS ON MY HANDS AND CAR,I HAVE TO CARRY SOAP AND WATER TO WASH THIS OFF OF MY CAR. I CALLED ABOUT THIS AND WAS TOLD BECAUSE MY CAR VIN # WAS NOT ON THE THEIR LIST THERE WAS NOTHING THEY COULD DO FOR ME
NHTSA complaint #10954291 — an unverified report by a vehicle owner.
at 116,000 milesLouisville, KY
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE DECELERATED AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. IN ADDITION, WHEN THE CONTACT INSERTED FUEL IN THE VEHICLE, FUEL SPEWED OUT THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
NHTSA complaint #10947627 — an unverified report by a vehicle owner.
at 101,300 milesSAN Juan, PR
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHEN REFUELING THE VEHICLE, FUEL EJECTED OUT OF THE REFUELING HOLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 101,300.
NHTSA complaint #10887431 — an unverified report by a vehicle owner.
SAN Juan, PR
FUEL/PROPULSION SYSTEM
EVERY TIME I HAVE TO FILL THE GAS TANK ON MY KIA SORENTO 2003 IT SHOOTS BACK THE GASOLINE LIKE A PROYECTILE. IT TAKES AN ETERNITY TO FILL THE GAS TANK IF YOU DON'T WANT TO HAVE GAS ALL OVER YOU. I HAVE EVEN BEING KICKED OUT OF SOME SERVICE STATIONS BECAUSE SPILING SO MUCH GAS IS A HAZARD. IS THERE ANY SAFETY RECALL FOR THIS PROBLEM? I HAVE NOT HEARD A WORD FROM KIA.
NHTSA complaint #10876553 — an unverified report by a vehicle owner.
at 185,000 milesPensacola, FL
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE STATIONARY, THE VEHICLE SPEWED FUEL ONTO THE GROUND WHEN FUEL WAS BEING ADDED. THIS ISSUE RECURRED REGARDLESS OF THE AMOUNT OF FUEL BEING ADDED TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 185,000.
NHTSA complaint #10871521 — an unverified report by a vehicle owner.
at 146,000 milesBiddeford, ME1 injured
FUEL SYSTEM, GASOLINE
IT IS BEYOND ME HOW KIA MOTORS CAN GET AWAY WITH TELLING A BUNCH OF AUTOMOBILE ENGINEERS, THAT THE PROBLEM WITH THERE VEHICLES SPITTING BACK GASOLINE ONTO A PERSON AND KIA MOTORS TELLING THEM IT'S AN AIR FILTER. I TOOK MY2003 KIA SORENTO BACK TO THE DEALERS THINKING I WAS GOING TO GET A NEW CHARCOAL FILTER WHEN ALL WAS SAID AND DONE I RECEIVED A $20 AIR FILTER FOR THE CHARCOAL CHAMBER WHICH HAD NO PROBLEM TO BEGIN WITH. I STILL HAVE A 2003 KIA SORENTO THAT SPITS FUEL BACK ON TO ME AND I"M WAITING FOR THE DAY SOMEONE THROWS A CIGARETTE BUTT AT ME AND I CATCH FIRE< BECAUSE I WILL OWN KIA OF AMERICA AND A WEALTHY LAWSUIT AGAINST THE NATIONAL TRAFIC SAFETY PANEL. DO YOU KNOW I HAD A SHORT ACCESS TO A KIA SITE RECENTLY AND SEEN OVER 100 SERVICE BULLETINS, NOT JUST 8 THAT ARE ON THIS SITE I GUESS YOU PEOPLE FORGOT WHO YOU WORK FOR THE UNITED STSTES PEOPLE/NOT KIA MOTORS AND YOU CAN BET YOUR ASS I'M NOT DONE UNTIL EVERYONE OF MY SERVICE BULLETINS IS ADDRESSED SO YOU BEAN COUNTERS BETTER START FIGURING BLAME BECAUSE AS I SAID WHEN I'M DONE YOU'LL SEE THIS IS BULLSHIT IF THIS WERE FORD, CHEVY OR CHRYSLER YOU WOULD HAVE DRAGGED THEY'RE ASS ACROSS THE COALS WELL YOU BETTER START WITH THE SLANTY EYE KOREANS TOO. I KNEW THEIR WAS A REASON MY MOTHER DIDN'T WANT ME GOING INTO THEIR BOSTON STORES WHEN I WAS A KID. GOT HELP YOU IF THIS THING CATCHES FIRE WITH MY KIDS IN IT, BECAUSE MY 2 YEAR OLD IS STRAPPED RIGHT ABOVE YOUR NO PROBLEM WHATSOEVER I MADE BETTER GO KARTS WHEN I WAS 10 YEARS OLD I DONT KNOW WHAT THE GOVERNMENTS PROBLEM IS BUT IT BETTER BE TAKEN CARE OF OR YOU MAY FIND IT ON YOUR LAWN ON FIRE !!!
NHTSA complaint #10822953 — an unverified report by a vehicle owner.
at 126,000 milesBiddeford, ME1 injured
FUEL/PROPULSION SYSTEM
I HAVE FUEL STILL SPITTING OUT OF THE FUEL TANK, EVEN AFTER THE SUPPOSED TANK AIR FILTER REPLACEMENT BY BILL DODGE KIA, SACO, ME. I CAN ONLY TRICKLE FUEL IN THE VEHICLE WITHOUT IT SPITTING BACK OUT ON ME AND THE GROUND. I HAVE ALREADY HAD A BAD RASH DUE TO FUEL SPILLING ON ME WITH SHORTS ON LAST SUMMER. THE VEHICLE IS NOT REPAIRED AS STATED. I REFUSE TO START TRYING TO JUST THROW MONEY AT IT AND NOT KNOWING IF IT WILL FIX THE PROBLEM OR NOT. I SEEN A LOT OF OTHER COMPLAINTS EVEN AFTER THE TANK AIR FILTER REPLACEMENT, THE EVAP SYSTEM SHOULD NOT BE LOCATED UNDER THE VEHICLE TO BEGIN WITH, DUE TO MOISTURE GETTING INTO THE AIR FILTER THEN THE CHARCOAL CANISTER AND EVERYTHING ELSE. I HAVE ALSO REPLACED THE CLOSED VALVE WHICH IS LOCATED BEFORE THE TANK AIR FILTER TO NO AVAIL THIS VEHICLE IS A HEALTH AND FIRE HAZARD PERIOD !
NHTSA complaint #10821177 — an unverified report by a vehicle owner.
at 102,000 milesCollegeville, PA
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE REFUELING, FUEL SPEWED BACK OUT OF THE FILLER NECK WITHOUT WARNING. THE CONTACT MENTIONED THAT FUEL SPLASHED ALL OVER THE FLOOR AND HIS CLOTHES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 102,000.
NHTSA complaint #10811636 — an unverified report by a vehicle owner.
Decatur, AL
FUEL/PROPULSION SYSTEM
WHEN FUELING, AFTER ABOUT 45 SECONDS, GAS SPRAYS BACK UP AND OUT ALL OVER ME AND THE CAR AND THE GROUND. IF THE FUEL PUMP HANDLE IS BARELY DEPRESSED, WHICH PUMPS THE GAS VERY VERY SLOWLY, FUEL WILL BE ACCEPTED. TAKES FOREVER - TIRED OF GAS-SOAKED CLOTHES AND GAS-SOAKED SHOES; TIRED OF SPILLING GAS ALL OVER THE CAR AND WASTING ON THE CONCRETE; - TIRED OF DANGEROUS SITUATION!! NEED KIA TO ISSUE A RECALL ON WHATEVER IS CAUSING THE FUEL REJECTION.
NHTSA complaint #10811408 — an unverified report by a vehicle owner.
at 100,000 milesPinellas Park, FL
FUEL/PROPULSION SYSTEM
FULE IS SHOOTING BACK OF GAS TANK WHILE PUTTING IN GAS.THIS IS VERY DANGEROUS. PLEAS TELL ME A FIX FOR THIS. CAR IS STATIONARY.
NHTSA complaint #10782188 — an unverified report by a vehicle owner.
at 88,425 milesEllenwood, GA
FUEL/PROPULSION SYSTEM
I ATTEMPTED TO FILL MY 2003 KIA SOENTO EX AND AFTER PUMPMING ABOUT $2.75 WORTH OF GAS, THE FUEL BEGAN TO SPIT BACK UP THROUGH THE FILLER HOSE AND SPURTED/ GUSH BACK OUT ON TO ME. IT GIVES YOU A FALSE SENSE THAT THE TANK IS FULL BUT IT'S NOT. I ATTEMPTED TO RE-FUEL AND AGAIN, THE GAS SPURT/ GUSH BACK OUT. I COULD GET NO MORE THAN $5.00 DOLLARS IN THE CAR. I SPOKE WITH THE KIA DEALERSHIP IN LITHONIA, GEORGIA AND THEY TOLD ME THAT THEY HAVE NEVER HEARD OF SUCH A MATTER. I WAS INSTRUCTED TO BRING THE VEHICLE BACK. HOWEVER, I BEGAN TO RESEARCH THIS MATTER AND IT WAS INVESTIGATED BY YOU ALL. KIA DID STATE THAT THEY WOULD LOOK INTO THE MATTER. I'M NOT CONFIDENT THAT WILL HAPPEN. THERE ARE THOUSANDS OF COMPLAINTS OUT THERE AMONG CONSUMERS ABOUT THIS SAME VEHICLE BETWEEN THE 2003 THROUGH 2006. PLEASE INVESTIGATE! I DO BELIEVE THAT THIS IS A RECALL ITEM. THE 2003 KIA SORENTO WAS THE FIRST VEHICLE MADE BY KIA CORPORATION.
NHTSA complaint #10777780 — an unverified report by a vehicle owner.
at 113,000 milesValley Stream, NY
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE FUEL WAS NOT GOING INTO THE FUEL TANK PROPERLY UPON REFUELING THE VEHICLE AND THERE WAS A CLICKING NOISE AS IF IT WERE FULL. THE CONTACT HAD TO TAKE AN EXTENDED PERIOD OF TIME TO ENSURE THE FUEL TANK WAS ACTUALLY FULL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DID NOT DIAGNOSE THE FAILURE. THE VEHICLE WAS TO BE TAKEN TO AN INDEPENDENT MECHANIC TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V353000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.
NHTSA complaint #10732070 — an unverified report by a vehicle owner.
at 209,000 milesEastman, GA
FUEL/PROPULSION SYSTEM
TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND WITH THE FUEL TANK GAUGE AT 3/4 OR BELOW, THE VEHICLE BEGAN TO SPUTTER AND VIBRATE BEFORE STALLING. THE CONTACT INDICATED THAT THE FUEL TANK NEEDED TO BE AT LEAST 75 PERCENT FULL TO PREVENT THE FAILURE FROM OCCURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 209,000.
NHTSA complaint #10690328 — an unverified report by a vehicle owner.
at 114,000 milesWeedsport, NY
FUEL/PROPULSION SYSTEM
I BOUGHT MY KIA SORENTO 2003 IN NOVEMBER 2013. IN JANUARY OF THE FOLLOWING YEAR I NOTICED A GAS SMELL. I LOOKED UNDER THE VEHICLE AND FOUND A FEW DRIPS ON THE GROUND UNDERNEATH, WHICH WAS GAS. I HAD THE LINE UNDER THE CAB ALONG SIDE DOOR REPLACED. I AM NOTICING A STRONG GAS SMELL COMING FROM THE SIDE TOWARD FRONT AND CAN'T SEE ANYTHING LEAKING. I SAW THAT THERE WAS A RECALL FOR THIS YEAR AND MAKE SO I CALLED KIA AND ASKED THEM IS MY VEHICLE COVERED UNDER THE RECALL AND THEY SAID NO AFTER GIVING THEM MY VIN NUMBER. I SEE THAT ITS NOT JUST THE 2003 VEHICLES WITH THIS ISSUE. JUST BECAUSE I DON'T HAVE THE RIGHT VIN NUMBER THEY SHOULD STILL HONOR MY COMPLAINT. REGARDLESS I'M STILL HAVING THE SAME FUEL ISSUES AS THE ONES ON RECALL.
NHTSA complaint #10663495 — an unverified report by a vehicle owner.
at 137,000 milesPeoria, AZ
FUEL/PROPULSION SYSTEM
WHEN FUELING THE VEHICLE THE GAS PUMP AUTOMATICALLY SHUTS OFF CONSTANTLY. THE TANK CAN BE EMPTY AND THE PUMP WILL SHUT OFF AS SOON AS YOU START FILLING IT AND CONTINUE TO DO SO AS YOU FILL IT. IT WILL ALSO SPIT GAS OUT OF THE TANK WHILE YOU ARE FILLING IT. THERE SHOULD BE PLENTY OF ROOM FOR GAS AS THE GAS INDICATOR SHOWS EMPTY BUT EVEN AFTER PUTTING ONE GALLON IN THE TANK, THE PUMP WILL SHUT OFF AND/OR GAS WILL SPILL/SPLASH OUT. I HAVE TO STAND BACK WHEN FILLING THE TANK SO THAT I DON'T GET IT ALL OVER ME. THE DATE LISTED FOR INCIDENT IS WHEN IT FIRST STARTED HAPPENING BUT IT CONTINUES TO DO SO EVERY TIME I PUT GAS IN THE VEHICLE.
NHTSA complaint #10641275 — an unverified report by a vehicle owner.
at 88,676 milesPinellas Park, FL
FUEL/PROPULSION SYSTEM
WE WERE ATTEMPTING TO FILL THE SORENTO UP WITH GAS WHEN IT SUDDENLY SPIT GAS OUT OF THE TANK WHEN WE HAD ONLY PUT $11 INTO TO. IT WAS CLOSE TO EMPTY WHEN WE GOT TO THE GAS STATION. WE TRIED A COUPLE TIMES WITH THE SAME RESULT. THE CAR WOULD NOT TAKE ANYMORE GAS.
NHTSA complaint #10629630 — an unverified report by a vehicle owner.
at 80,000 milesMyrtle Beach, SC
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT EXPERIENCED DIFFICULTY PLACING FUEL IN THE VEHICLE. THE FUEL WOULD NOT ENTER THE TANK AND LEAKED OUT WHILE THE CONTACT ATTEMPTED TO INSERT FUEL. AN INDEPENDENT MECHANIC STATED THAT THE VEHICLE NEEDED A NEW CANISTER FILTER, FUEL CAP, AND FILLER PIPE. THE VEHICLE HAD NOT BEEN REPAIRED AND THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 10/8/14*CN THE CONSUMER STATED THE MANUFACTURER WAS CONTACTED. THE MANUFACTURER STATED THE VEHICLE WAS OUT OF WARRANTY. THE CONSUMER WAS NOT NOTIFIED OF ANY RECALLS DUE TO BEING THE SECOND OWNER. THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. UPDATED 3/24/2015
NHTSA complaint #10628094 — an unverified report by a vehicle owner.
at 118,892 milesWeedsport, NY
FUEL SYSTEM, GASOLINE
FUEL LINE LEAKING. FIXED AND NOW LEAKING AGAIN SOMEPLACE ELSE.
NHTSA complaint #10616152 — an unverified report by a vehicle owner.
at 133,000 milesWaipahu, HI
FUEL/PROPULSION SYSTEM
WHILE PUMPING, THE FUEL SPITS BACK OUT FROM THE TANK. IT IS RATHER ANNOYING AS I LOSE MONEY FUELING AND IT TAKES FOREVER TO FUEL. NORMALLY WHEN I REACH ABOUT $15.00 IN GAS IT BEGINS REGURGITATING. THIS HAPPENS EVERY TIME I ATTEMPT TO FUEL.
NHTSA complaint #10615429 — an unverified report by a vehicle owner.
at 150,000 milesP.sl., FL
FUEL SYSTEM, GASOLINE
I AM SINGLE OLD LADY, LATE JAN.2014 , DRIVING BACK FROM ORLANDO,FL. TO MY HOME<2 HRS AWAY> ON I-95 CAR SLOWS DOWN, ALL LIGHTS GO ON DASHBOARD. GET HOME AT 40 MILES AN HOUR.NEXT DAY GO TO TIRE PLUS, CAN NOT FIX CAR, ENGINE TROUBLE..GO TO DEALER BEV SMITH KIA, FT.PIERCE, FL, I AM A REGULAR THERE,WITH CAR PROBLEMSELL ME CAN NEEDS NEW LOWER ENGINE, $7000 I ALMOST FAINT, , CAR NOT SAFE, I LEFT ANYWAY, THEY WOULD NOT EXACTLY TELL ME WHAT WRONG WITH CAR...COWORKER AT WALMART, TELLS ME OF MECHANIC,CAN FIX IT...TAKE IT THERE, HE TELLS ME WHAT REALLY IS WRONG WITH CAR..SCREW THAT HOLD HARMONY PART, HAD BROKEN OFF, HALF OF IT WAS STILL STUCK INTO LOWERE ENGINE< BY THE WAY, THIS WAS A RECALL BACK 3 YEARS AGO, IN WHICH I HAD COMPLYED WITH KIA AND THEY HAD REPLACED NEW HARMONY SCREW>...THIS HONEST MECHANIC, TOLD ME LEAVE KIA OVER THE WEEKEND, WILLPUT PUT SCREW SOFTENER ON SCREW STILL IN ENGINE, SEE IF IT COMES OUT...IT DID, THEY PUT NEW SCREW, GIVE ME ALL NEW BELTS, I PAID $1,800 OF MY OWN MONEY, ..I GO AHEAD AND DRIVE TO MIAMI, FLL< 2 HRS AWAY> DAY LATTER I DRIVE TO ORLANDO ,FL.< 3 HRS AWAY>...IN I 95....NEXT DAY,TRY TO GET OUT OF MY DRIVEWAY, SAME THING HAPPENED...GOOD MECHANIC COMES OVER TO MY HOUSE, SAID SAME SCREW CAME OFF...HE FIXES IT AGAIN, $1,500, ...HE TELLS ME, GET NEW CAR, DO NOT KEEP THIS KIA SORENTO 2003, CAR HAS FLAW, CAN NOT BE FIXED....IF KEEP IT, JUST FOR AROUND TOWN DRIVE, UNDER 50 MILES AN HOUR, DO NOT TAKE TURNPIKE OR INTERSTATE HIGHWAYS...I CONTACTED KIA MOTORS, BEV SMITH KIA, TOLD THEM ABOUT RECALL SCREW REPLACEMENT , TELL ME OUT OF WARRANTY, NEITHER WILL REALLY ANSWER BACK...NO MONEY, NO NEW CAR....KIA MOTORS IS A CROOK,...TELL ME CAR OUT OF WARRANTY, THAT WHAT DO I WANT WITH OLD CAR...CAN NOT FIND ANY OTHER PRIOR COMPLAINTS I MADE WITH CAR, SINCE FIRST YEAR I BOUGHT IT...
NHTSA complaint #10609501 — an unverified report by a vehicle owner.
at 58,000 milesBronx, NY
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE CHECK ENGINE LIGHT ILLUMINATED BEFORE THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT ALSO INDICATED THAT WHILE REFUELING, FUEL SPILLED FROM THE FILLER NECK. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 58,000.
NHTSA complaint #10587220 — an unverified report by a vehicle owner.
Jacksonville, AR
FUEL/PROPULSION SYSTEM
MY FUEL PUMP WAS REPLACED IN AUGUST 2013; NOT LONG AFTER I BEGAN HAVING FUELING PROBLEMS THAT HAVE INCREASED IN SEVERITY. ANY TIME I TRY TO PUT GAS IN MY TANK, IT EXPLODES BACK OUT AT ME LIKE A VOLCANO ERUPTING. I CAN'T PUT GAS IN MY CAR UNLESS I LET IT TRICKLE IN AND STOP FUELING IN INTERVALS...IT TAKES ABOUT 30 MINUTES AT LEAST TO FILL MY CAR. I'M TIRED OF SMELLING LIKE GAS. THIS IS DANGEROUS AND RIDICULOUS AND APPARENTLY A LOT OF OTHER PEOPLE HAVE HAD THIS PROBLEM, YET KIA HAS DONE NOTHING. SOMETHING NEEDS TO BE DONE BY KIA TO CORRECT THIS ISSUE. I TOOK MY VEHICLE TO A KIA DEALERSHIP AND THEY WEREN'T REALLY SURE WHAT TO DO (LOTS OF HELP THERE) AND WANTED TO CHARGE ME ABOUT $2000 TO TRY AND FIGURE IT OUT (THE SAME AMOUNT THEY CHARGED ME TO REPLACE MY FUEL PUMP). I'M TIRED OF BEING RIPPED OFF....CAN'T ANYONE DO ANYTHING TO HELP ALL OF US CONSUMERS HAVING THIS ISSUE??
NHTSA complaint #10561305 — an unverified report by a vehicle owner.
at 1,000 milesPort St.lucie., FL
FUEL/PROPULSION SYSTEM
THE CAR BEEN A PROBLEM SINCE FIRST YEAR , I CALLED DISTRICT MANAGER FOR KIA BACK IN 2004,TOLD HIM CAR WAS SKIPPING BEAT, AND SHAKING...HE TOLD ME IS WAS MY IMAGINATION...THE 2ND BIG PROBLEM<WHICH I HAD TO SOLVE THROUGH COMPUTER INVESTIGATION> CAR WOULD JUST START LOSING POWER IN I-95 OR FL.TURNPIKE AND COME TO STAND STILL, NO MATTER HOW MUCH I PRESSED THE GAS PEDAL, NO GO, ALMOST GOT IN SEVERAL ACCIDENTS IN I-95,FLORIDA LATE AT NITE...SPEND $800 AT KIA OF KENDALL IN FLORIDA, IN MIAMI, TOLD ME WAS FUEL PROBLEM...WAY BACK HOME THAT SAME DAY, CAR DID SAME THING SLOWED DOWN IN RUSHING TRAFFIC IN I-95 FLOIRDA,ALMOST GOT DEADLY ACCIDENT FROM CAR BEHIND ME, TOOK IT TO KIA OF FT.PIERCE , KEPT CAR 1 WEEK, MECHANIC COULD NOT FIGURE OUT PROBLEM, ...I FOUND ON LINE,PROBLEM WAS AT THE FUELING ENTRANCE,SOMETHING DISSOLVED AND PARTICLES WENT TO FUELING INJECTORS,CLOGGING IT AND CAUSING PROBLEMS, TOLD MECHANICS ,REPLACED THIS PART ,CAR GOT FIXED....LAST INCIDENT,MAJOR ONE, BACK 3 YEARS AGO TOOK CAR TO KIA DEALER, DUE TO LETTER FROM KIA CORPORATION, MAJOR RECALL ON SCREW THAT HOLD HARMONEY BLANCER TO LOWER ENGINE CASE...THEY REPLACED IT...1/9/2004.DRIVING BACK FROM ORLANDO,FL,AT NITE, CAR JUST SLOWS DOWN, SHAKES, BATTERY LIGHT AND BRAKE LITE COME ONE...MIRACLE , 1 HOUR I DROVE CAR SLOWLY BACK HOME...FRIDAY I TAKE TO SHOP,FIND OUT SAME RECALL ,REPLACED SCREW,RUSTED OFF ,SHEARED OFF, HALF OF IT STILL IN ENGINE,HARMONEY FELL OFF,..MIRACLE I DID NOT GER MAJOR FIRE IN CAR,LATE AT NITE,ON I95..TOOK IT FRI.TO FT.PIERCE KIA,MECHANIC SAID CAN NOT BE REPAIRED, NEED SPEND$79000ON NEW ENGINE...NOTHING WAS MENTIONED SAME SCREW ,RECALL, THEY REPLACED BACK 3 YEARS AGO...CAR HAS HISTORY OF MY COMPLAINTS TO CORPORATE KIA..NOTHING EVER DONE.
NHTSA complaint #10559543 — an unverified report by a vehicle owner.
at 26,000 milesNEW York, NY
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 70 MPH, THE VEHICLE FAILED TO ACCELERATE. THE CONTACT MOVED THE VEHICLE OFF THE ROADWAY AND THE ENGINE RPMS INCREASED AS THE VEHICLE BEGAN TO PERFORM NORMALLY. THE CONTACT ALSO STATED THAT ONCE THE FUEL TANK WAS BELOW 3/4 FULL, THE ENGINE WOULD LOSE POWER AND BEGAN TO IDLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS INSPECTED BUT WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE BUT PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 26,000.
NHTSA complaint #10544006 — an unverified report by a vehicle owner.
at 170,000 milesNorth Augusta, SC
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, FUEL WOULD SPEW FROM THE FILLER NECK WHEN REFUELING AND THE INTERIOR LIGHTS WOULD FLICKER ON AND OFF SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED, WHO WAS UNABLE TO GENERATE A FAILURE CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000 AND THE CURRENT MILEAGE WAS 180,000.
NHTSA complaint #10504675 — an unverified report by a vehicle owner.