56 of the
1,629 complaints about the 2016 KIA Sorento are about the
fuel system — 3% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
67,000 miles.
I took my 2016 Kia Sorento to the dealership for an emissions service update as a result of a service bulliten (SC340) After recieving the car back, the transmission acts unpredictably and the throttle is erratic. This happens when started cold and continues until the engine reaches temperature. It did not do this previous to the update. It is a safetey hazard and almost caused a collision. The throttle response was sluggish, it hunted for gears and as a result I was unable to safely merge into traffic endangering myself and other drivers.
NHTSA complaint #11749807 — an unverified report by a vehicle owner.
Rumford, RI
FUEL/PROPULSION SYSTEM
(Transmission and motor) I had taken my car to the dealership on XXX for recalls and all the signal were fine before going there. They took my car back to do the recalls and my son and I waited . Once they were done we left closer to closing time is noticed there was a burn mark on my dash board that wasn’t there before the recalls. Going forward on the way home. We were waved down by a man stating that my signal and brake light weren’t working . So that next day we took my car back to the dealership to see what happen, why all the sudden different alerts were coming up. They had the same mechanic relook at the car and a when finish 31/2 hour latter was told I needed a new transmission, costing $7384.94 which I don’t have . They charge me $179.00 just to confirm what they said about needing a new transmission. I was devastated and confused why I wasn’t told that the day before. So a few days later I took it to another machanic to see if the could see why the lights weren’t working and he ended up putting new bulbs in and got them working but also he put it in a diagnosis machine 2 of them and couldn’t get a reading at all and said I should take it back to find out why he couldn’t get a reading. I was so frustrated at that point I just was upset! I then had a friend of the family mechanic look at it and he said it wasn’t the transmission it was a knock sensor that I needed so I ordered it. When I called him to install the knock sensor he was too busy to do it and it had already been a whole month of waiting so I reached out to a place in Cumberland RI to see if he could install the knock sensor had it towed there and he kept it for three days and said it was a transmission computer and he tried two of them and neither of them worked and charged me $150 for that I was humiliated and crying , I went there to have my car towed home seen him while waiting for the tow truck to come he said I needed a new transmission and now a motor, crying again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)
NHTSA complaint #11748819 — an unverified report by a vehicle owner.
Smithfield, NC
FUEL/PROPULSION SYSTEM
Hello. I just started smelling gas fumes when my car has been running. I see no drips , etc. It happens everytime I drive it to the point where someone pointed it out to me. I had a new engine put in by KIA for my old engine "going to sleep" about 4 years ago. I have been told that this is a on going problem with the Model I have. I want to know what I should do at this point. Im [XXX] and [XXX] so I dont have the money to take it all over the place if this engine issue is covered. Could you please let me know and how to proceed? [XXX] [XXX] Cell [XXX] THANK YOU FOR ANY HELP ps....You should have record of KIA replacing the engine on file??? Is this a warranty issue since I do have a newer engine? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11747800 — an unverified report by a vehicle owner.
North Hollywood, CA
FUEL/PROPULSION SYSTEM
Car completely stalled while on the freeway with no warning, no engine lights, nothing….luckily we were going downhill and were able to pull over to the side safely. Still owe 6k to the finance company but mechanic claimed I needed a new waterpump…after being changed and charged the car still wouldn’t turn on despite the new waterpump….and a bunch of new obd codes showed up & now I need a new engine. After a lot of research I’ve learned this car is notoriously known for many recalls and overall complains…..I wish I had done research before buying it, now I’m in debt for a car I can’t even drive
NHTSA complaint #11741029 — an unverified report by a vehicle owner.
Saint Francis, MN
FUEL/PROPULSION SYSTEM
The vehicle is a 2016 Kia Sorento equipped with a 2.0L Turbo Theta II engine subject to the KSDS (Knock Sensor Detection System) safety recall. The original engine was replaced at approximately 70,000 miles under Kia’s engine service program. The replacement engine currently has approximately 32,000 miles. The vehicle developed internal engine damage diagnosed by a Kia dealership as a burnt exhaust valve. A burnt exhaust valve indicates abnormal combustion conditions such as lean operation, pre-ignition, detonation, timing deviation, injector malfunction, or lubrication failure. These are conditions the KSDS recall was intended to detect and mitigate. Kia Consumer Affairs denied warranty coverage, stating that the extended warranty applies only to rod bearing failure and that no further escalation would be pursued. Kia Consumer Affairs declined to escalate the matter for District Parts & Service Manager review and directed the owner back to the dealership. During the prior engine replacement, the dipstick was observed to be glued in place, raising concerns regarding oil level accuracy and lubrication integrity on the replacement engine. This complaint is submitted due to concern that a KSDS safety recall-related engine failure involving abnormal combustion was not properly reviewed or escalated, and that recall procedures were not administered in accordance with their intent.
NHTSA complaint #11706961 — an unverified report by a vehicle owner.
Durham, NCFire
FUEL/PROPULSION SYSTEM
Vehicle: 2016 Kia Sorento, VIN [XXX] Incident Date: November 13, 2025 Incident Location: Durham, NC (3828 Guess Rd) Cause of Loss: Engine Fire, confirmed by Durham Fire Department Report (Incident #253663) as "originated from under the hood." TECHNICAL NARRATIVE & SYMPTOMS (CRITICAL FOR LIABILITY): I am filing this complaint to report a catastrophic vehicle fire that I believe is directly linked to multiple acknowledged manufacturing defects that create a fire risk in Kia vehicles. ABS/Traction Control Light Warning (Direct Fire Risk Symptom): Immediately prior to the loss, the ABS and Traction Control warning lights were constantly illuminated. This is a known precursor symptom for the defective Hydraulic Electronic Control Unit (HECU) or ABS Module short-circuit, which has been cited in numerous Kia fire recalls (e.g., NHTSA 20V019, 20V519). The fire's origin under the hood is consistent with this component failure. Prior Engine Failures (Systemic Defect History): This vehicle has a history of catastrophic manufacturing defects: The engine assembly was replaced in 2023 due to the known Theta II Rod Bearing Failure. The knock sensor was replaced in September 2025 as part of the KSDS Product Improvement Campaign, demonstrating the vehicle was still under active service for critical engine monitoring defects just weeks before the fire. Potential Tow Hitch Wiring Fire Risk: The vehicle was fully engulfed, but the fire may also be linked to the defect cited in NHTSA Recall 22V703 (tow hitch wiring harness short circuit, which also poses a fire risk). I require a full investigation into this defect leading to compensation for the total loss of the vehicle and consequential damages. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11703758 — an unverified report by a vehicle owner.
Richfield, MN
FUEL/PROPULSION SYSTEM
The safety hazard began with a pattern of ignored warnings by the authorized dealer network. On Aug 15, 2025, I brought the vehicle to Luther Kia of Bloomington for a Check Engine Light. The dealer simply cleared the code without diagnosis, failing to catch early signs of engine trouble. On Sept 22, 2025, the engine failed again. I drove the vehicle in unsafe "limp mode" to Luther Nissan Kia [XXX] ). They found the engine was "4 quarts low on oil" (severe starvation just 37 days after a dealer oil change). Despite this catastrophic finding, they failed to diagnose the root cause and released the unsafe vehicle to me after selling only a spark plug replacement. On Sept 26, when I attempted to pick up the vehicle, the Check Engine Light was flashing immediately at handover. I refused to take the unsafe vehicle. The dealer then replaced an Oil Control Valve (OCV) and released the vehicle to me again later that day. After this second "repair," I drove the vehicle for only a few miles before the engine failed again with a Check Engine Light. The dealer has since admitted in writing (BBB complaint #XXX) that the engine was "deprived of lubrication" due to the initial low oil condition. By ignoring early warnings and releasing a vehicle with a dying engine twice, the dealer put me and other motorists at risk of a sudden loss of power at highway speeds. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11703833 — an unverified report by a vehicle owner.
Elizabethton, TN
FUEL/PROPULSION SYSTEM
Engine failed. Took car to Johnson City Kia dealership as advised by Kia of north America. The dealership said the engine failed due to carbon build up which is a problem with the engines, that it was not covered under warranty. I paid over $6,400 to have the engine replaced. When I was driving the car home the engine light came on and I lost power on the interstate causing me to almost get hit by a semi-truck. I took the car back to Kia of Johnson City Tn. the next day. Kia stated that the high-pressure fuel pump had went bad from the time I left the dealership and got home. I paid over $1,350 to replace a High-Pressure Fuel Pump. On the way home engine light and loss of power. I returned to Kia. They stated that gas had gotten into my oil. They changed the oil and I headed home, same issue engine light and loss of power. I told Kia of Johnson City I wanted a refund, and they could put the old part back on. Kia of Johnson City told me to take the car to another dealership that I was not getting a refund, and they would not fix my car. The engine codes and problems were the same as when I picked the car up from Kia. I have tried twice to have Kia of North America buy the car back due to it not being fixed and I do not feel safe in the car. I have taken the car to a Hyundai dealership in Johnson City Tn. and asked them to check the engine code and loss of power. Another $223.05. They stated the high-pressure fuel pump was defective. Fixing same issue multiple times.
NHTSA complaint #11702388 — an unverified report by a vehicle owner.
Coral Springs, FL
FUEL/PROPULSION SYSTEM
Fuel pump leaking gas from a crack around electrical connections on top of it. Fire hazard.
NHTSA complaint #11687042 — an unverified report by a vehicle owner.
Surprise, AZFire
FUEL/PROPULSION SYSTEM
This scenerio happened and fire resulted with total loss. Fuel system, gasoline: Delivery: Hoses, lines/piping, and fittings Recall date 2018-12-18 Recall no. 18V907000 Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak. Hide details Recall consequence A fuel leak in the presence of an ignition source can increase the risk of a fire. Recall action Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
NHTSA complaint #11679556 — an unverified report by a vehicle owner.
Marana, AZ
FUEL/PROPULSION SYSTEM
Fuel pump is leaking, unsafe to drive vehicle, no check engine light just really bad smell of gas
NHTSA complaint #11670204 — an unverified report by a vehicle owner.
Tucson, AZ
FUEL/PROPULSION SYSTEM
1) I bought this car in October 2021, when it had ~79,000 miles on it. After ~2,000 miles, it showed a low engine oil sign, and it has been showing this issue since then, i.e., I have to change my oil/filter after every ~2000 miles. It has incurred a huge cost. I talked to the dealers, but they did nothing to solve this problem and charged me ~$1200. Funny part. Whenever I go for an oil change, they say that KIA/HYUNDAI cars have this engine problem. It's a joke to this system that the Govt still allows them to roll on the USA roads. 2) Today, this car had a flashing engine light. I will go to a mechanic tomorrow, but afraid of how much they will charge.
NHTSA complaint #11663304 — an unverified report by a vehicle owner.
at 75,000 milesSaint Louis, MO
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Kia Sorento. The contact stated that after coming to a complete stop, the brake pedal was released, and the "check oil" warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the engine was consuming an excessive amount of engine oil. The failure persisted, and the contact took the vehicle to the dealer. The dealer diagnosed that the spark plugs, and the piston rings had failed. The contact was informed by the dealer to add oil every 1,500 miles driven. The manufacturer was made aware of the failure and informed the contact that since the piston rings and the engine had failed, NHTSA Campaign Number: 18V907000 (FUEL SYSTEM, GASOLINE, ENGINE) would not apply. The failure mileage was approximately 75,000.
NHTSA complaint #11655946 — an unverified report by a vehicle owner.
Milton, NH
FUEL/PROPULSION SYSTEM
Check engine light came on again after recall for engine bearing failure and engine block was determined to qualify for replacement by home Kia dealer , est July / August 2024 in North Hampton NH . After motor block changes the engine light came on and off while in Florida vacationing . Today’s date is February 17 , 2025 and my vehicle is presently in the hands of a local independent service center here in Florida . Other indicators recently noticeable were rough idle starting in the morning . The service center initially suggested problem might be injectors , and gasoline was noticeably in the oil pan . I’m presently waiting for a further / complete diagnosis from the service center . Relative to myself and my spouses safety further research on my own fire could be a potential with injectors causing a garage to be ignited and life threatening to us .
NHTSA complaint #11643166 — an unverified report by a vehicle owner.
Maryland Heights, MO
FUEL/PROPULSION SYSTEM
UNKNOWN
NHTSA complaint #11638858 — an unverified report by a vehicle owner.
Fairfax, VA
FUEL/PROPULSION SYSTEM
Unknown component or system failed. My car suddenly stalled while on the highway, not allowing me to increase speed (over 40 mpg) and then stopped. I was scared to death when that happened on the highway as we could have been hit by other vehicles. I was able to restart it but it kept doing it, gradually reducing my speed to 20mpg then a lamp warning sign appeared. The car only has 50,000 miles on it and no warning light or prior failure before this happened on 11/29/2024. I took it to Kia for inspection and they told me if the engine will have to be replaced, it will take 3 months. They took my car in for inspection and I am now 10 days without a car and I have not yet heard from Kia.
NHTSA complaint #11629478 — an unverified report by a vehicle owner.
at 110,000 milesFitchburg, MA
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Kia Sorento. The contact stated while driving approximately 5 MPH, the vehicle stalled and failed to return to normal operation. No warning light was illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the rear sway bar link needed to be replaced. The vehicle was repaired; however, the failure occurred. The contact researched and became aware of NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000.
NHTSA complaint #11609928 — an unverified report by a vehicle owner.
Lexington, KY
FUEL/PROPULSION SYSTEM
While driving on the parkway, the vehicle would not accelerate and would stall. After pulling over, vehicle would restart but repeated the pattern. Made it to Advanced Auto who ran codes and had the camshaft modulator changed. Vehicle made it back onto parkway. 40 miles from home, the vehicle began to shake, loose power, made loud sound and died. Towed home. Mechanic said out of oil but I had oil changed less than 1000 miles ago when vehicle purchased. New codes showed crankshaft position sensor. Changed part. Replaced starter and a new battery. Still nothing. Stating probable engine failure. I've only owned this vehicle for 2 months!
NHTSA complaint #11600653 — an unverified report by a vehicle owner.
Moore, OK
FUEL/PROPULSION SYSTEM
Car when into a low power mode,could not keep it running ,took 5 times to go thru a very busy intersection and motor was making a knocking noise,smells like burnt oil-motor ,misses out..The car was towed into a KIA dealership,3 weeks later they said it was fixed,drove off and didn’t even make it a mile until it started knocking and having the same smell like burnt motor,went into a reduce power.now it’s been 3 more weeks or more and still nothing is getting resolved. Yes the dealership knows about this issue. Yes warning messages came on when it went into low power mode. This is motor number two as the motor was replaced less than 12 months ago.
NHTSA complaint #11560803 — an unverified report by a vehicle owner.
Rochester, NY
FUEL/PROPULSION SYSTEM
Knock sensor goes bad. Car does not receive fuel to engine. Cuts off while driving and will not accelerate over 20 mph
NHTSA complaint #11559249 — an unverified report by a vehicle owner.
Corinth, NY
FUEL/PROPULSION SYSTEM
Car ran fine until we stopped for gas, went to get back on the highway when the car wouldn't accelerate >25mphs,almost got hit from this. The car was then towed to the near by Kia dealership and they found that it was a compression issue with a known issue in the engine and now we need a new engine or scrap the car. Kia is not willing to fix their horrible product and has told us to just suffer.
NHTSA complaint #11547231 — an unverified report by a vehicle owner.
Jacksonville, FL
FUEL/PROPULSION SYSTEM
this vehicle is a match box waiting to kill someone. I've been reporting these problems an nobody has follow up. on 08/20/2023 fuel pump had to be replaced after fumes coming into vents report one on 06/03/2023 issue happened again, 0n 09/04/2023 engine went out. after getting vehicle back catalytic converter and manifold was burnt out do to engine .had it inspected by a muffler shop. kia will not replace anything even if they are told it was caused on behalf of there produce
NHTSA complaint #11546630 — an unverified report by a vehicle owner.
North Fort Myers, FL
FUEL/PROPULSION SYSTEM
3.3 liter engine - no warning not part of recall or knock sensor per Kia - driving slow ( thank God ) just died . Towed to the dealer - hearing 3 different story’s ? Diagnosis ? Manifold or Rod Bearing issue - whole engine needs replaced over 15k cost . Doing research on this issue snd see many complaints on all makes and models / expect a recall on this vehicle in time as well - it’s only a matter of time till someone is hurt or killed due to Kias repeated negligence in regards to engine failure - the dealer and corporate are ignoring this and that is not acceptable .
NHTSA complaint #11539898 — an unverified report by a vehicle owner.
Jacksonville, FLFire3 injured
FUEL/PROPULSION SYSTEM
Fire from fuel pump engine failure catalytic converter issues from engine
NHTSA complaint #11535533 — an unverified report by a vehicle owner.
Jacksonville, FL
FUEL/PROPULSION SYSTEM
was driving at 11mph and car would not Accelerate almost causing and accident issues with engine sparking flames fuel system problems, transmission issues when putting the vehicle into park. Engine problems check engine light keeps blinking on an off system says park vehicle do to diagnosed problems. suspension issues afraid to drive vehicle do to so many safety problems.
NHTSA complaint #11531286 — an unverified report by a vehicle owner.
Jacksonville, FLFire
FUEL/PROPULSION SYSTEM
automatic transmission shift lever assembly components, fuel pipe exhaust causing fumes to come through the vent area causing fire and smoke. accelerator assembly issues when driving
NHTSA complaint #11529055 — an unverified report by a vehicle owner.
Jacksonville, FLFire
FUEL/PROPULSION SYSTEM
Recently, while driving on a busy multi-lane highway my 2016 Kia Sorento suddenly lost power, started shaking and slowed down causing traffic safety hazard. The engine stalled after slowing down. The car needed to be towed at my expense.my check engine light came on for my KSDS, the engine went limp mode and unable to accelerate over 50 miles and hour on the highway. My engine is blown. gasoline smell fumes came through vent causing me to have an attack car started to catch fire.
NHTSA complaint #11528170 — an unverified report by a vehicle owner.
Fort Wayne, IN
FUEL/PROPULSION SYSTEM
This is the second very similar incident with the engine of this vehicle. On Monday, May 29, 2023, the engine failed at a stop light in Fort Wayne Indiana. A few miles before it failed, it suddenly got very noisy and wouldn’t go over about 15 mph. It wouldn’t really react to the accelerator pedal. At the stop light it just quit at a major intersection leaving me stranded in the middle of the road. It has been towed to the Kia dealer in Fort Wayne. They have not diagnosed the problem yet but I have read many reports on line and my experience was similar: vehicular just quit, engine lost oil, accelerator pedal not responsive, and loud ticking sound. I’m afraid the repair will be thousands of dollars and I’m a senior citizen on Social Security. This is a second incident. On October 20, 2022, my daughter in law drove my car to IU Health Hospital in Indianapolis to visit me in the hospital (major surgery). In an hour and a half she used a full tank of gas and 3 quarts of oil — the car slowed to 40 mph, accelerator pedal didn’t work and she was on Route 69 a 4 lane major highway and was very scared. She pulled off at the next exit. The car had to be towed from Indianapolis to Fort Wayne. My mechanic worked on it, got it running ok but it had a major oil leak. I was recovering from my surgery so drove it little. I now find out that the engine in my car has major problems just like what I have experienced and that Kia is refusing to fix them unless people pay in excess of $6000. This is a safety issue!!!! Having the car fail and just quit while on local or interstate roads leads to accidents and injuries. This engine needs to be recalled. Kia knows it and has settled claims out of court so they don’t have to admit responsibility. This is a serious safety hazard. The recent date of May 29, 2023 is provided but the previous date this happened is October 20, 2022. So there were two incidents.
NHTSA complaint #11524599 — an unverified report by a vehicle owner.
Oceanside, CA
FUEL/PROPULSION SYSTEM
The engine was going through over 5 quarts of oil about once a month. There were no visible leaks. For months, there was no check engine light illuminated so the dealership couldn't help determine and fix the problem without charging over $10,000 to open the engine, which I couldn't afford. A Service Advisor, in their words, told me to, "Run it until it dies," so that they can start using the warranty. This to me was very unsafe, especially for my infant who was there when she said this. Months later, the car started shaking intensely and the check engine light finally came on. The car stopped working in the middle of the freeway but I was able to exit and take it to the nearest dealership. They were able to run a diagnosis and said it was an engine misfire and they replaced it (I was able to use my warranty for some of the repairs but still had to pay about $4000). It didn't take long for the car to stop working again. They then said there was a problem with the fuel pump so I had them replace it. I had barely just left the dealership when the car stopped working again. They replaced the catalytic converter, which was a part of a voluntary recall. For months after, they've been trying to figure out the issue with no success. It has been sitting at their service center since November 2022 with no solution.
NHTSA complaint #11516307 — an unverified report by a vehicle owner.
Gardner, KS
FUEL/PROPULSION SYSTEM
Twice now my 2016 Kia GDI has had the same problem as many others. I had my oil changes made and they said there was no oil in the car. the oil light never came on. I am afraid to drive my car. Has there been a recall on this. or for a engine recall. My car is under warranty. Is
NHTSA complaint #11500694 — an unverified report by a vehicle owner.