40 of the
784 complaints filed about the Land Rover Discovery
are about the fuel system —
5% of everything owners reported.
The worst model year for it is 1996.
Supplement / update to prior NHTSA complaints regarding my 2021 Land Rover Discovery MHEV (VIN: [XXX] y prior complaints, Jaguar Land Rover has issued Recall 26V248 for DC/DC converter failure leading to loss of propulsion in 2021–2024 Land Rover Discovery MHEV vehicles. My vehicle experienced the same real-world failure condition: sudden loss of propulsion in traffic with my children in the vehicle. Jaguar Land Rover corporate has stated my VIN is not included in the recall population despite my vehicle being a 2021 Discovery MHEV and experiencing the same defect condition. I am submitting additional documentary evidence from Jaguar Land Rover Portland showing that during the repair process: * I was advised the vehicle would only run while connected to external jumper power and would shut off once that external power was removed. * Two days later, I was advised the installed battery would only charge to 6 volts and that another battery was needed to continue testing. These communications raise concern that this failure event involved broader electrical consequences and further support that my vehicle experienced the same defect condition described in Recall 26V248. The dealership ultimately completed repairs and charged me for the failure, while JLR maintains my VIN is excluded. I am requesting NHTSA review whether my VIN was improperly excluded from the recall population and whether the affected vehicle population should be expanded. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11737455 — an unverified report by a vehicle owner.
The contact owns a 2004 Land Rover Discovery. The contact stated that the check engine warning light was illuminated. While driving approximately 35 MPH and depressing the brake pedal, the brakes failed to immediately stop the vehicle. The contact aggressively slammed on the brake pedal to stop the vehicle. Additionally, while driving at various speeds, the vehicle was slightly drifting to the left. The vehicle was taken to a certified mechanic, who diagnosed that the EVAP was leaking and needed to be replaced. The EVAP was replaced. The mechanic had not diagnosed the brake failure. The vehicle was picked up, and the dealer informed the contact to drive the vehicle for another 25 miles to see if the check engine warning light would illuminate again. The contact stated that after leaving the dealer, 48 miles later, the check engine warning light illuminated again. The contact called the mechanic, who decided not to inspect the vehicle again, but instead refunded the cost for the previous repair. The manufacturer was not informed of the failure. The failure mileage was approximately 106,683.
NHTSA complaint #11680950 — an unverified report by a vehicle owner.
NO RECALL IN PLACE 1. Seat harness airbag light sensor (LEFT SIDE AIRBAG DEPLOYMENT OPEN, Sensors in the front seat make sure that the airbag deploys). NO RECALL IN PLACE 2. Fuel Vapor Purge and PCV diaphragm valve cover
NHTSA complaint #11642375 — an unverified report by a vehicle owner.
The contact owns a 1995 Land Rover Discovery. The contact stated that while refueling the vehicle, the contact observed gasoline leaking from the rear of the vehicle where the fuel tank was located. The check engine warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 04V203000 (Fuel System, Gasoline); the VIN was included, but the vehicle had never been repaired. The manufacturer was notified of the failure, and a case was opened. The contact was informed that he could schedule the recall repair with the nearest dealer; however, the nearest dealer was 6 hours away, and the manufacturer had refused to cover the cost of towing the vehicle. The failure mileage was unknown.
NHTSA complaint #11624791 — an unverified report by a vehicle owner.
The contact owns a 2018 Land Rover Discovery. The contact stated that while the vehicle was idling, and during the initial start-up there was an abnormally strong fuel odor entering into the cabin of the vehicle. The contact lowered the windows to eliminate the odor from inside the vehicle. There were no warning lights illuminated. The contact became aware of NHTSA Campaign Number: 18V087000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 81,000.
NHTSA complaint #11613719 — an unverified report by a vehicle owner.
Driving down the highway, the vehicle all the sudden started smoking, forcing me to pull over. Upon pulling over, I found it was a fire under the left front hood based on the smoke pouring out. I called 911 immediately. I attempted to save some belongings, including my $200K boat, but failed to save anything as the fire rapidly grew forcing me to step far away. I then watched my car, boat and belongings all perish to nearly nothing before the fire department arrived and put out the fire. While I am lucky to be safe and have adequate insurance, others may not fair so well when their Land Rover Discovery 5 petrol catches fire.
NHTSA complaint #11537799 — an unverified report by a vehicle owner.
I HAVE A 2006 LANDROVER DISCOVERY THAT IS HAVING FUEL LEAKING FROM THE GAS TANK AND DOWN TO THE PAVEMENT AND I CAN SMELL IT IN MY CAR WHEN I DIVE SINCE MY VIN NUMBER IS DIFFERENT THEY WON'T FIX IT THE SAME YEAR AND MODEL JUST A DIFFERENT COLOR CAR I'M HAVING THIS SAME PROBLEM NHTSA CAMPAIGN NUMBER: 07V011000 WHEN I START THE CARE IT DOSENT TURN OVER AND WHEN I DRIVE IT I SMELLS AND REAKS OF FULL I CAN SEE THE FULL DRIPPING DOWN THE SIDE OF THE FUEL TANK THIS CAR IS THE SAME YEAR AND MODEL BUT JUST A DIFFERENT COLOR THE PRICE TO FIX THIS WOULD BE CLOSE TO 2 GRAND
NHTSA complaint #11390019 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2006 LAND ROVER DISCOVERY. THE CONTACT STATED AFTER DRIVING THE VEHICLE FOR A WHILE, THERE WAS AN ABNORMAL ODOR OF FUMES THROUGHOUT THE ENTIRE CABIN OF THE VEHICLE. THE CONTACT STATED SHE PLACED CARDBOARD UNDERNEATH THE VEHICLE TO DETECT THE LEAK. THE VEHICLE WAS TAKEN TO AN AUTO BODY SHOP FOR A DIAGNOSIS. THE DIAGNOSIS WAS A FUEL RAIL LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER STATED THE PARTS ARE ON BACK ORDER FOR 3-4 MONTHS. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.
NHTSA complaint #11316046 — an unverified report by a vehicle owner.
I WAS DRIVING ON MAIN ROAD AT THE SPEED LIMIT (45 MPH). I HAD SLOWED DOWN AS I OBSERVED A CAR PULLING OUT AHEAD OF ME ONTO THE ROAD. AS I GAVE MY VEHICLE GAS IN ORDER TO GET BACK UP TO SPEED, I FELT A PAUSE IN THE ENGINE AND THEN THE CAR COMPLETELY LOST POWER- THE ENGINE STOPPED, THE RED BATTERY ICON APPEARED ON THE DASH, AND MESSAGE APPEARED ON THE SCREEN WITH THE HEADING "SPECIAL PROGRAM SUSPENDED" OR SOMETHING TO THAT EFFECT-- I HAD NO TIME TO READ THAT MESSAGE AS I HAD TO STEER MY CAR AS FAR TO THE RIGHT AS I WAS ABLE TO. I TRIED TO RESTART THE VEHICLE, IT WOULD NOT START AND THE MESSAGE DISAPPEARED-- I HAD NO CHANCE TO READ IT AS I WAS ON A BUSY AND HEAVY TRAVELED ROAD AND HAD TO ENSURE I WAS SAFELY PULLED OVER. UNKNOWN AT THIS TIME AS TO WHAT CAUSED THIS MALFUNCTION. THIS CREATED AN UNSAFE CONDITION AS THE CAR LOST POWER WITH NO FOREWARNING. I AM LUCKY THAT IT DID NOT HAPPEN ON THE HIGHWAY ON WHICH I TRAVEL MOST OF THE TIME. I CONTACTED LAND ROVER ROADSIDE ASSISTANCE AND THE CAR WAS PUT ON A FLATBED AND BROUGHT TO THE DEALER.
NHTSA complaint #11209915 — an unverified report by a vehicle owner.
FIRST THREE DAYS BEFORE 5/14/2019 THE SEATBELTS LIGHTS WERE ON AND OFF, AND ON MAY14/2019 I WAS ON MY WAY TO WORK THE CAR JUST STOP IN THE MIDDLE OF THE ROAD. .. THE BREAK WERE LOCKED.
NHTSA complaint #11208546 — an unverified report by a vehicle owner.
ACCELERATOR HAS A SIGNIFICANT "LAG" WHEN GOING FROM A MOVING "STOP". AS IF WHEN YOUR TURNING AND WANT TO ACCELERATE. THIS IS A KNOWN PROBLEM WITH LR AND THEY HAVE BEEN WORKING ON A SOFTWARE FIX FOR MONTHS. IT IS DANGEROUS!!
NHTSA complaint #11172964 — an unverified report by a vehicle owner.
I NOTICED THE PROBLEM FIRST WHEN I WAS REFUELING AT THE GAS STATION. WHEN THE PUMPS "GALLON" GAUGE REACHED ABOUT 14 GALLONS I HEARD A SHOP PLAYING SOUND AND LOOKED DOWN TO FIND THAT ALL THE GAS I WAS PUMPING IN WAS SPILLING ON THE GROUND.I LATER REALIZED AFTER INSPECTING IT, THERE'S A STRESS CRACK THAT LEAKS FUEL WHILE FILLING TANK OR WHILEDRIVING IF TANK IS CLOSE TO FULL. THIS RESULTS IN HORRIBLE HEAD ACHES FROM THREE CONSTANT SMELL OF GASOLINE INSIDE MY LAND ROVER WHILE DRIVING.
NHTSA complaint #11156949 — an unverified report by a vehicle owner.
LANDROVER NEVER NOTIFIED ME OF MULTIPLE RECALLS AS 1ST AND ONLY OWNER MULTIPLE REPAIRS DEALER WON'T HONOR RECALL REPAIRS PASS RIGHT DOOR HINGE FAILURE. REAR CARO DOOR LOOK FAILURE. GAS TANK CRACK LEAKING. CRUISE CONTROL PROB AND AIR BAG LIGHT ON. EXTERIOR LIGHT FAILURE. WINDOW FAILURE 3X TO OPENFRONT/ REAR REGULATOR AND OR MOTOR MULTIPLE TIMES. BRAKES FAILURE MULTIPLE TIMES REPLACED MASTER CYLANDER 2X& BOOSTER. OIL LEAKING G OIL COOLING HOSES FAIL. PLUS... STARTER. ALTERNATOR. IGNITION SYSTEM .BELTS AND MULTIPLE HOSE REPLACED. THIS IS A PARTS BLACK HOLE VEHICLE COSTNG THOUSANDS IN REPAIRS. ONCE OUT OF WARRANTY DEALERS RIPPED ME OFF ALWAYS STATING UNRELATED ISSUES. NO ONE ELSE. AN OR WILL WORK ON THE CAR. SAME THINGS CONTINUE TO FAIL. MANUFACTUER WON'T ADDRESS ISSUES OR HONOR RECALL'S. CAR HAS 101K MILES. ORIGINAL OWNER STUCK REPAIRING UNRELIABLE CAR I CAN'T AFFORD NEW CAR AND WON'T SELL LEMON TO SOMEONE ELSE . IT'S NOT RIGHT. RIPPED OFF. Y MECHANIC. FILLED MULTIPLE BUEARU OF AUTOMOTIVE REPAIRS COMPLAINTS AGAINST DISHONEST ESTIMATE SHOPS. PLEASE HELP DO SOMETHING REPLACED FUEL PUMP FOR STEALING NON START AND WAS RIPPED OFF DOOR OPENS WHEN LOCKED AND DRIVING. FUEL LEAKS FILLING TANK. OIL EVERYWHERE A FIRE HAZARD NO ONE WILL HELP. CONTACT ME FOR DETAILS AND DATES. ITS NOT JUST ONE INCIDENT. LAND ROVER DID NOT NOTIFY ME OR ACCEPTS ANY RESPONSIBILITY FOR ISSUES THAT CONTINUE A CAR BUILT TO FAIL AND COST A FORTUNE FOR PARTS AND SERVICE THAT'S WHY IT WAS BUILT IN 95 AND CHANGED IN 1996 TOO .ANY ISSUES
NHTSA complaint #11072497 — an unverified report by a vehicle owner.
VEHICLE HAS SEVERE DEFECTS RELATING TO THE CLIMATE CONTROL FUNCTIONS. 1) IN HOT WEATHER, IT CANNOT COOL DOWN THE CAR, 2) DUE TO HAVING TO KEEP THE CLIMATE AT LO/MAX, I AM GETTING 9-10 MPG (16 CITY IS STATED), 3) INDEPENDENT CLIMATE CONTROL FUNCTIONS DO NOT WORK, 4) NO VENTILATION IN 2/3 OF CAR.
NHTSA complaint #11002969 — an unverified report by a vehicle owner.
THE 2017 DISCOVERY HAS BEEN DESIGNED WITH ONLY 4 AIR VENTS IN THE FRONT DASH AND 2 VERY WEAK AIR VENTS IN THE 2ND ROW. THIS IS A 3 ROW PASSENGER VEHICLE WITH NO VENTS IN THE 3RD ROW. THE CAR IS MISSING AT LEAST 4 VENTS AND IS CREATING A SAFETY HAZARD IN HOT AND COLD ENVIRONMENTS. I CANNOT HAVE PASSENGERS OR ANIMALS IN THE REAR OF THE CAR DUE TO THE LACK OF VENTILATION IN THE VEHICLE. IN ADDITION, DUE TO ATTEMPTING TO COOL THE CAR DOWN, RUNNING THE CAR WITH MAX AC IS GIVING ME ONLY 9-10 MPG. CAR IS ADVERTISED AS 16 MPG CITY. THIS IS A BLATANT DESIGN AND SAFETY ISSUE FOR CLIMATE CONTROL AND FALSE MPG STANDARDS.
NHTSA complaint #11002620 — an unverified report by a vehicle owner.
GAS TANK RECALL DONE IN SAN FRANCISCO BUT THEY FAILED TO CHECK THE FUEL FILLER NECK PROBLEM. I HAVE HAD MULTIPLE MYSTERY ISSUES EVER SINCE, RULING OUT THE FUEL TANK AND PUMP AS THEY WERE BOTH NEW. I HAVE SINCE TRACKED THE PROBLEM TO THE FUEL FILLER NECK THAT THE DEALER FAILED TO FIX. I BELIEVE MY VEHICLE TO HAVE BEEN MANUFACTURED INCORRECTLY AND REPAIRED IN THE SAME MANNER. MY VEHICLE DOES NOT COME UP IN A RECALL SEARCH FOR THE FILLER NECK AND I BELIEVE THE RECALL SHOULD BE AMENDED TO INCLUDE MINE. I HAVE READ ALL 80 OF THE COMPLAINTS RELATIVE TO THIS PROBLEM AND MINE IS LESS THAN 40 UNITS AWAY FROM THE COMPLAINT VEHICLES. I ALSO HAVE BEEN BATTLING THE ABS PROBLEMS OF NOT STOPPING AND THE ABS ACTIVATION FOR NO REASON. I ALMOST WRECKED A FEW TIMES BECAUSE OF THE ABS KICKING ON FOR NO REASON- LOW SPEED, DRY PAVEMENT, EASY SOFT BRAKE PRESSURE. I CLIPPED THE FRONT WHEEL ABS SENSORS AND I HAVE HAD NO PROBLEMS WITH ABS SINCE. FAULTY SOFTWARE IN THE ABS ECU IS PROBABLY TO BLAME BUT IT WOULD DO NO GOOD TO BLAME THE COMPUTER WITH BODIERS LYING IN THE STREET.
NHTSA complaint #10895775 — an unverified report by a vehicle owner.
ABS SYSTEM IS FAULTY. ACTIVATION AT LOW SPEEDS,DRY PAVEMENT, AND LOW OR HIGH PRESSURE ON PEDAL. I CAN HEAR THE PUMP ACTIVATE FOR NO REASON. I ALSO FEEL THE PEDAL VIBRATE AND THE TRUCK CONTINUES TO ROLL. ALMOST KILLED A PEDESTRIAN ONCE OR TWICE. AFTER IT DID THE SAME TO MY WIFE I CLIPPED THE SENSORS AND TOOK OUT THE LIGHT BULB IN THE DASHBOARD. I DRIVE BETTER THAN THE ABS ECU COMPUTES. NO PROBLEMS SINCE COMPLETELY DEACTIVATING AND UNPLUGGING SYSTEM. PLEASE INCLUDE NEW RANGES OF VEHICLES IN THESE RECALLS. I WILL BE POWERLESS TO HAVE THIS REIMBURSED OTHERWISE. ALSO NEED TO RE-EVALUATE RECALL RANGE FOR THE FUEL NECK FILLER PROBLEM. MY TRUCK WAS IN FOR THE TANK RECALL BUT THEY FAILED TO DO THE FILLER NECK AND I HAVE SPENT YEARS TRADING OUT IAC, THROTTLE SENSORS, AND MAF SENSORS TRYING TO FIGURE OUT THE PROBLEM. THANK YOU SANFRANCISCO LAND ROVER. SARCASM INTENDED.
NHTSA complaint #10895778 — an unverified report by a vehicle owner.
TECHNICAL SERVICE REPORT FROM INDEPENDENT BRITISH LAND ROVER SPECIALISTS, BETHESDA MD: CUSTOMER STATES ENGINE MAKES A TAPPING NOISE, MOSTLY AT IDLE. DIAGNOSIS - VERIFIED NOISE. OIL LIGHT ON DUE TO LOW OIL PRESSURE, VEHICLE IN VIN RANGE FOR OIL PUMP FAILURE DUE TO MISALIGNED FRONT COVER FROM THE MANUFACTURER. OIL PUMP DAMAGE HAS OCCURRED, AND NEEDS TO BE CHANGED. CORRECT REPAIR IS ENGINE REPLACEMENT, AS DAMAGE TO BEARINGS CAN OCCUR. FAILURE ALSO CAUSED BY BLOCK ALIGNMENT POSITIONING. AT THIS POINT, NO NOTICEABLE ENGINE DAMAGE HAS OCCURRED, AND TO AVOID ENGINE REPLACEMENT CAN REPLACE OIL PUMP ASSEMBLY. OIL PUMP REPLACEMENT WOULD ONLY BE TEMPORARY X, AS PROBLEM WILL MOST LIKELY ARISE YEARS DOWN THE LINE. WILL NEED TO CHECK FRONT COVER FOR DAMAGE DURING REPAIR. ADDITIONALLY, LARGE OIL LEAK FROM INTAKE END SEALS DETECTED. RECOMMEND REPLACE OIL PUMP, ALIGN FRONT COVER, REPLACE INTAKE GASKET WHILE NOTING THERE MAY BE CHANCES OF ENGINE FAILURE, BEARING DAMAGE & DAMAGE TO FRONT COVER DETECTED DURING SERVICE. NOTES: TO AVOID ENGINE FAILURE, REPLACED OIL PUMP AT A COST OF $2,600 DUE TO MISALIGNED FRONT COVER FROM THE LAND ROVER MANUFACTURER. WILL LIKELY NEED TO REPLACE ENGINE IN THE FUTURE AT AN EXPECTED COST OF $10,000 DUE TO BLOCK ALIGNMENT POSITIONING MANUFACTURING ERRORS FROM LAND ROVER. CUSTOMER WILL HAVE TO PAY FOR THESE REPAIRS IN THEIR ENTIRETY, DESPITE THE FACT THAT THEY ARE CAUSED BY ORIGINAL MANUFACTURING DEFECTS, AS LAND ROVER HAS NOT ISSUED A RECALL. PLEASE ASSIST - THERE ARE THOUSANDS OF VERY SIMILAR COMPLAINTS POSTED ON MULTIPLE LAND ROVER FORUMS ONLINE.
NHTSA complaint #10544783 — an unverified report by a vehicle owner.
TWO YEARS AGO I REPLACED A FUEL TANK ON MY LAND ROVER DISCOVERY 1997 AT THE DEALERSHIP IN SAN DIEGO AS A RESULT OF THE SAFETY RECALL ACTION B156 - FUEL TANK CRACKING. THE REPLACEMENT TANK IS EXHIBITING THE SAME PROBLEM AS FOR THE INITIAL RECALL. IT LEAKS WHEN FULL AND NOTICEABLE FUEL ODOR CAN BE SMELLED. THE DEALERSHIP TOLD ME AFTER I NOTIFIED THEM WITH THE RECENT PROBLEM, THAT THE REPLACEMENT TANK HAS ONLY ONE YEAR WARRANTY. I TOLD THEM THE PROBLEM IS THE SAME AS WAS RECALLED AND THEY SHOULD REPLACE THE TANK AT THEIR COST. WHAT DO YOU ADVICE I TELL THEM NEXT FRIDAY WHEN I TAKE THE VEHICLE IN.
NHTSA complaint #10239653 — an unverified report by a vehicle owner.
RECENTLY FOUND OUT THOUGH NHTSA THAT LAND ROVER HAD A RECALL ON MY VEHICLE FOR FUEL SYSTEM , GASOLINE : STORAGE (FUEL TANK) IT SEEMS A STRESS CRACK CAN DEVELOP IN THE PLASTIC FUEL TANKS WHICH MAY RESULT IN A FIRE . THE REMEDY ACCORDING TO THE REPORT IS FUEL TANK REPLACEMENT. I CONTACTED LAND ROVER THEY REFUSED TO HONOR THE RECALL STATING IT DOSE NOT EFFECT MY VEHICLE WHEN THE REPORT CLEARLY SAYS THAT IT DOES. PLEASE HELP ME CHILDREN RIDE IN THIS VEHICLE. THE NHTSA CAMPAIGN ID NUMBER IS 4V203000. THE VEHICLE IS A 1997 LAND ROVER DISCOVERY. THANK YOU JAMES FOWLER
NHTSA complaint #10224469 — an unverified report by a vehicle owner.