2015 Mercedes Benz C300 problems

STRUCTURE

The contact owns a 2015 Mercedes-Benz C300. The contact stated that while driving at various speeds and depressing the brake pedal, the vehicle fishtailed on several occasions. The vehicle was taken to an independent mechanic, where it was raised on a lift, and the mechanic discovered that the rear subframe was severely corroded. The mechanic determined that the failure was associated with Manufacturer Communication Number: MC-10232321 (Structure); and referred the contact to a dealer for assistance. The vehicle was towed to the dealer, where the failure was confirmed, and it was discovered that the rear subframe had separated. The dealer informed the contact that the vehicle was unsafe to drive. The contact was provided an estimate for the repair and was informed that goodwill assistance would not be provided. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and informed the contact that the dealer was unreachable. The failure mileage was approximately 120,000.

NHTSA complaint #11754977 — an unverified report by a vehicle owner.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

The contact owns a 2015 Mercedes-Benz C300. The contact stated that while the vehicle was parked, the contact became aware that the panoramic roof failed to close as intended. The vehicle was taken to the dealer, where it was determined that the panoramic roof guide rails had failed. The contact was informed that the panoramic roof guide rails needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the mileage and age of the vehicle had exceeded the limitation. The failure mileage was approximately 110,000.

NHTSA complaint #11753779 — an unverified report by a vehicle owner.

SUSPENSION

Rear subframe rust has deemed the car unsafe to drive. Hitting a pot hole at high speed or any sudden stop could cause the subframe to collapse causing loss of control of car. Car is available for inspection upon request. Car was taken in for regular oil change and multi-point inspection when rust was noticed by mechanic at the dealership. Car is located in East TN not the snow belt. There have been recalls on similar models for the year prior, but this vin is not part of the recall and has same issue, although the number 204 which is part of the recall is stamped on the part. (Pic attached below.)

NHTSA complaint #11753660 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

The contact owns a 2015 Mercedes C300. The contact stated that the driver's side rear brakes and rotors were rusted. The contact stated that when the brakes were applied, they were slow to respond. The TPMS warning light was illuminated. The vehicle was taken to a braking center, which declined the warranty for the aftermarket parts. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 176,000.

NHTSA complaint #11740646 — an unverified report by a vehicle owner.

SERVICE BRAKES

The contact owns a 2015 Mercedes C300. The contact stated that the driver's side rear brakes and rotors were rusted. The contact stated that when the brakes were applied, they were slow to respond. The TPMS warning light was illuminated. The vehicle was taken to a braking center, which declined the warranty for the aftermarket parts. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 176,000.

NHTSA complaint #11740646 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2015 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. The vehicle was driven to the shoulder of the road. The contact inspected the exterior of the vehicle and became aware that the moon roof panel had detached, and the moon roof panel flew off the vehicle. The dealer was made aware of the failure. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V197000 (Structure) in 2021. The contact was informed that the repair was not covered under warranty. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 62,612.

NHTSA complaint #11733048 — an unverified report by a vehicle owner.

STRUCTURE:BODY

The contact owns a 2015 Mercedes-Benz C300. While driving approximately 15 MPH, the brake pedal was depressed, and the body of the vehicle shifted to one side. The vehicle was drivable after the failure. There was no warning light illuminated. The vehicle was driven to the residence and parked. The contact stated that due to the failure, the vehicle was unsafe to drive. An independent mechanic was contacted, and it was determined that the rear subframe was corroded. The vehicle was not repaired. The manufacturer was notified of the failure, and it was confirmed that the VIN was not under recall. The failure mileage was not available.

NHTSA complaint #11722220 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Failed/Malfunctioned Component: Rear subframe (structural/chassis component) exhibited advanced corrosion (perforation/rust-through), compromising structural integrity and alignment/handling. Availability for Inspection: Yes. The vehicle and the subframe are available for inspection upon request. I can provide photos, videos, and repair estimates if needed. The corroded subframe is fracture and detach suspension mounting points, which may lead to: Sudden loss of vehicle stability or control (especially during braking, cornering, or over bumps). Unpredictable alignment changes causing pulling, vibration, or abnormal tire wear that can escalate into a loss-of-control event. Increased stopping distance and potential for wheel misalignment or collapse, raising the risk of a crash involving occupants and other road users. I limited driving/use due to the risk; issue is a structural safety concern rather than cosmetic. Confirmation: Yes on multiple visits since Oct 2023 -Yes—diagnosed and documented by Mercedes-Benz of Silver Spring on Oct 2 2023, Nov 2023 and Dec 2025. Technician confirmed severe corrosion/rust perforation on the rear subframe requiring replacement. No No

NHTSA complaint #11712059 — an unverified report by a vehicle owner.

SUSPENSION

Failed/Malfunctioned Component: Rear subframe (structural/chassis component) exhibited advanced corrosion (perforation/rust-through), compromising structural integrity and alignment/handling. Availability for Inspection: Yes. The vehicle and the subframe are available for inspection upon request. I can provide photos, videos, and repair estimates if needed. The corroded subframe is fracture and detach suspension mounting points, which may lead to: Sudden loss of vehicle stability or control (especially during braking, cornering, or over bumps). Unpredictable alignment changes causing pulling, vibration, or abnormal tire wear that can escalate into a loss-of-control event. Increased stopping distance and potential for wheel misalignment or collapse, raising the risk of a crash involving occupants and other road users. I limited driving/use due to the risk; issue is a structural safety concern rather than cosmetic. Confirmation: Yes on multiple visits since Oct 2023 -Yes—diagnosed and documented by Mercedes-Benz of Silver Spring on Oct 2 2023, Nov 2023 and Dec 2025. Technician confirmed severe corrosion/rust perforation on the rear subframe requiring replacement. No No

NHTSA complaint #11712059 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Fuel hose system leaking. Inhalation of gas fumes caused headaches and nausea. Risk of vehicle fire. Yes, the problem has been confirmed by a Mercedes dealer. This is a known issue with Mercedes C300 2015 models and other years. There have been other complaints/lawsuits against Mercedes not wanting to pay for the issue. No warnings just strong gas smell.

NHTSA complaint #11707032 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Rear subframe rusted out, car is not safe to drive

NHTSA complaint #11698179 — an unverified report by a vehicle owner.

SUSPENSION

Rear subframe rusted out, car is not safe to drive

NHTSA complaint #11698179 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Rear subframe rusted out, car is not safe to drive

NHTSA complaint #11698179 — an unverified report by a vehicle owner.

POWER TRAIN

Rear subframe completely rusted out. While driving on the hwy I heard a loud noise, a couple minutes later I hit the brakes to slow down to get off my exit and after pressing the brakes the car instantly fishtailed sending me sideways across 2 lanes of traffic. Luckily no one was injured or killed. I’ve seen that the car manufacturer was replacing this issue on models 2008-2015. My vehicle is a 2015 and they are telling me my vehicle is not covered for the issue. The car is not drivable and Mercedes needs to be held accountable. A critical component such as rear subframe completely rusting out in just under 10 years is unheard of and I can’t afford to pay 10k to fix it. Please help

NHTSA complaint #11696650 — an unverified report by a vehicle owner.

SUSPENSION

Rear subframe completely rusted out. While driving on the hwy I heard a loud noise, a couple minutes later I hit the brakes to slow down to get off my exit and after pressing the brakes the car instantly fishtailed sending me sideways across 2 lanes of traffic. Luckily no one was injured or killed. I’ve seen that the car manufacturer was replacing this issue on models 2008-2015. My vehicle is a 2015 and they are telling me my vehicle is not covered for the issue. The car is not drivable and Mercedes needs to be held accountable. A critical component such as rear subframe completely rusting out in just under 10 years is unheard of and I can’t afford to pay 10k to fix it. Please help

NHTSA complaint #11696650 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I’m the owner of a Mercedes Benz C- Class Sedan 2015. My Rear Sub Frame Rusted Through at The right trailing arm - Fails state inspection. Mercedes Benz has issued a extended 20 year warranty on all vehicles from 2008 - 2015 C - Class Sedan for Rear Sub Frame that rusted out. Mercedes Benz service advisor stated that my vehicle was not under that extended warranty when he run my vehicle Vin number. My vehicle should be under that warranty, I have the same problem with the same vehicles on the list. Please help. Thank you

NHTSA complaint #11695279 — an unverified report by a vehicle owner.

SUSPENSION

The Rear Subframe on this vehicle is rusted and has hole in it. The sub frame requires replacement. The sub frame was inspected by the Mercedes-Benz Dealership, Euro Motorcars in Germantown, MD and they recommended that the sub frame should be replaced. There is an extended warranty that has been issued by Mercedes-Benz for the Model Year and Model (2008-2015 C-Class Sedan/Coupe). However, Mercedes-Benz decline to cover the cost of the repair stating that my VIN is not part of that Warranty. This is a well documented safety issue and I believe that Mercedes-Benz should include my VIN in that extended warranty and replaced the subframe on my car.

NHTSA complaint #11688397 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I took my 2015 vehicle to the Mercedes dealership and learned the rear subframe is rusted and has holes on two sides. I was warned that it is a safety hazard and could lead to a lack of control and other dangerous situations. I also learned that other 2010 through 2014 Mercedes models in the same class have been recalled for this exact concern. I am disappointed and upset to learn that those concerns are known, but not addressed in this model and put customers at risk.

NHTSA complaint #11687651 — an unverified report by a vehicle owner.

SUSPENSION

there is a recall for 2008-2015 Mercades Benz c-300 c/w204. this recall talks about the rear subframe rusting out early on this car. we have a 2015 c300 c/w205. this car is seeing the same early rust seen in the other c-300. the dealership is refusing to do right by the warranty because it is a c/w205 even thought this is a known problem for this year and type of car. I am making this because it should be extended to all c300 2008-2015 cause they all use the same subframe. they changed the subframes and the look of the c-300 starting in 2016. it also would appear that the rust is coming from the inside of the subframe making we wonder how bad it is on the inside if it is making its way to the outside of it. I believe water penetrates into the rear subframe has no drainage and begins to rust. also we take the car to the dealer every 5 Ish months and this last service is the first we have seen of this.

NHTSA complaint #11687391 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

The contact owns a 2015 Mercedes-Benz C300. The contact stated that upon taking the vehicle for the State Inspection, the contact was informed that the rear subframe was rusted, and there was a hole on each side of the rear subframe. The vehicle was taken to the dealer, where an unknown diagnosis was made, and the dealer ordered an unknown part to repair the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 60,000.

NHTSA complaint #11681594 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2015 Mercedes-Benz C300. The contact stated while driving 40 MPH, the vehicle unexpectedly veered to the left. There was no warning light illuminated. The contact stated that the steering wheel became inoperable, and the contact was unable to straighten the steering wheel. The brake pedal was also depressed. The contact attempted to depress the accelerator pedal however, the vehicle started to stall. The contact pulled over into a parking lot and was able to restart the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 82,000.

NHTSA complaint #11678756 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2015 Mercedes-Benz C300. The contact stated while driving 40 MPH, the vehicle unexpectedly veered to the left. There was no warning light illuminated. The contact stated that the steering wheel became inoperable, and the contact was unable to straighten the steering wheel. The brake pedal was also depressed. The contact attempted to depress the accelerator pedal however, the vehicle started to stall. The contact pulled over into a parking lot and was able to restart the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 82,000.

NHTSA complaint #11678756 — an unverified report by a vehicle owner.