2012 Mercedes Benz C300 problems

FUEL/PROPULSION SYSTEM

Vehicle: 2012 Mercedes-Benz C300 4Matic Sport Problem Component: Fuel / Propulsion System Safety Issue Description: My 2012 Mercedes-Benz C300 developed a serious fuel tank leak at approximately 106,460 miles which created overwhelming gasoline fumes and rendered the vehicle unsafe to operate. The gasoline fumes were extremely strong and entered the passenger area. The fumes were severe enough that I became physically overwhelmed from the gasoline exposure and discarded clothing due to gasoline contamination and odor. A local repair facility identified the leaking fuel tank. I was informed the replacement fuel tank was allegedly on extended backorder through Mercedes-Benz channels. Because the vehicle was unsafe to drive and replacement parts were allegedly unavailable for several months, I was forced to tow the vehicle from [XXX] to [XXX] at my own expense in order to locate a repair facility that could obtain a replacement fuel tank and safely repair the vehicle. The repair invoice states: “Installed used lt fuel tank incl switchover fuel pumps replace section of steel fuel line front of tank from lower braided line.” I am submitting this complaint due to: serious gasoline leak safety concerns, severe gasoline fume exposure, potential fire hazard, and the alleged extended unavailability of replacement fuel tanks. Mercedes-Benz USA Case Number: 22302114 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11738871 — an unverified report by a vehicle owner.

SUSPENSION

I have a rust free, relatively lower mileage car I bought for my teen daughter. Despite being such a clean car the rear subframe has rusted and rear suspension has broke off while driving, hitting the fuel tank and is unstable. We avoided an accident but the car is not drivable.

NHTSA complaint #11732281 — an unverified report by a vehicle owner.

SUSPENSION

Mercedes of Danbury replaced the rear sub frame CODE 3441 47, since my mechanic (Newtown Auto Repair) told me that the Front subframe is in real bad shape, rotten/rusted, that it is dangerous to drive the car in this condition since the wheel and steering components are part and attached to it, the car would be out of control and all over the road any of these components fail and pull / brake away from the rusted out Sub Frame. When I brought the car in was under the impression that Mercedes Benz would replace front and back Sub Frames. But now they informed me of only recall on rear subframe, rear subframe will let go wheels will collapse, front controls the car and failing could kill people and total the car. frames.

NHTSA complaint #11701264 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Mercedes of Danbury replaced the rear sub frame CODE 3441 47, since my mechanic (Newtown Auto Repair) told me that the Front subframe is in real bad shape, rotten/rusted, that it is dangerous to drive the car in this condition since the wheel and steering components are part and attached to it, the car would be out of control and all over the road any of these components fail and pull / brake away from the rusted out Sub Frame. When I brought the car in was under the impression that Mercedes Benz would replace front and back Sub Frames. But now they informed me of only recall on rear subframe, rear subframe will let go wheels will collapse, front controls the car and failing could kill people and total the car. frames.

NHTSA complaint #11701264 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2012 Mercedes-Benz C300. The contact stated the fuel tank was emitting a fuel odor. The contact stated that the fuel odor was extremely strong and could be smelled inside the residence while the vehicle was parked in the garage. There were no warning lights illuminated. The vehicle was taken to a Certified Mechanic, who diagnosed that the leak was coming from the top of the fuel tank; however, the mechanic was unable to specify the cause. The vehicle was towed to the dealer, but the vehicle was not diagnosed. The vehicle was not repaired. The contact became aware of NHTSA Campaign Number: 12V557000 ( Fuel System, Gasoline) online; however, the VIN was not included. The manufacturer was informed of the failure and informed the contact that the VIN was not under recall. The failure mileage was approximately 98,000.

NHTSA complaint #11696118 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Rear subframe rotted out and broke due to corrosion. Rear crossmember is broken and needs replaced. My safety as well as the safely of other was put at risk. Loss of control at high speed could have been deadly. Luckily, I wasn’t going very fast at the time of incident or else who knows what would have happened to me or bystanders. Independent service center inspected and confirmed that incident was due to corrosion in the rear. They informed me of the extended warranty (20 years, unlimited miles) on 2008-2015 C300 models for this particular issue as my safety and the safety of others was put at risk. There were some symptoms leading up to the incident. At the time of braking the car would become unstable and feel skittish in the rear. It felt as if the rear was sliding to one side. The vehicle would also make some metal clinking noises at sharper turns. The symptoms had been more frequent in the prior 2-3 months of incident. The vehicle has been inspected and diagnosed by one shop and is currently getting a second opinion from another independent service center.

NHTSA complaint #11682005 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Rear subframe rotted out and broke due to corrosion. Rear crossmember is broken and needs replaced. My safety as well as the safely of other was put at risk. Loss of control at high speed could have been deadly. Luckily, I wasn’t going very fast at the time of incident or else who knows what would have happened to me or bystanders. Independent service center inspected and confirmed that incident was due to corrosion in the rear. They informed me of the extended warranty (20 years, unlimited miles) on 2008-2015 C300 models for this particular issue as my safety and the safety of others was put at risk. There were some symptoms leading up to the incident. At the time of braking the car would become unstable and feel skittish in the rear. It felt as if the rear was sliding to one side. The vehicle would also make some metal clinking noises at sharper turns. The symptoms had been more frequent in the prior 2-3 months of incident. The vehicle has been inspected and diagnosed by one shop and is currently getting a second opinion from another independent service center.

NHTSA complaint #11682005 — an unverified report by a vehicle owner.

SUSPENSION

Rear subframe crossmember rotting, needs replacement. It seems to be a common problem with this vehicle and the assumption by most professional is that it a faulty part supplied by a third party to Mercedes. The rest of the cars undercarriage is pristine, making me wonder why just this one part would rust out.

NHTSA complaint #11674095 — an unverified report by a vehicle owner.

AIR BAGS

I was driving normally last week when the driver's head restraint system (known by Mercedes as Neck Pro) unexpectedly and without warning blew at my head. The noise was very loud, and the headrest slammed against my head. Luckily, I was driving approximately 20-25 miles per hour, daytime, on a residential street without too many other vehicles. I was able to pull over to investigate what happened and ensure I wasn't injured and did not collide with any objects in the road. If this had happened on the highway at highway speeds with a less attentive driver, I could see this potentially resulting in a major collision. The road was fat, no bumps, weather was clear. There is no reason why this happened. From what I can tell, the system looks like it failed (plastic clips broke off) and the system did not intentionally deploy. It has not been repaired and is available for inspection. I have not taken it to the dealership for review. The vehicle is in perfect condition with no warnings. It very recently passed Maryland state inspection.

NHTSA complaint #11673323 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I was replacing rear tail light bulb. Now I'm getting an error message on instrument cluster. I tried to fix the issue but couldn't do to the fact the wiring harness has melted. Mercedes Benz had a recall back in 2013 saying this is a safety issue. No recall for our car.

NHTSA complaint #11661547 — an unverified report by a vehicle owner.

SUSPENSION

Took the car in for an oil change and asked them to look at the brakes and rear as there was a strange noise. Vehicle was inspected and found the entire subframe is rotted. Was advised this is a common problem with Mercedes and there were some recalls. Unfortunately no open recall on this vehicle and it is now not driveable as this is a safety risk. Car has been driven 60 miles/day for the past 3 months and could have had serious consequences.

NHTSA complaint #11639290 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2012 Mercedes Benz C300. The contact stated that while driving at various speeds, the vehicle would shake without warning. The vehicle was taken to an independent mechanic for a tire rotation; while there, the mechanic discovered severe corrosion on the vehicle's subframe and the contact was advised to no longer drive the vehicle. The manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 160,000. The VIN was not available.

NHTSA complaint #11635199 — an unverified report by a vehicle owner.

SUSPENSION

The subframe has developed extensive rust and corrosion, which I believe is a result of faulty manufacturing. This corrosion has severely compromised the structural integrity of the subframe, posing a serious safety risk. The corrosion appears to be inherent to the materials or design used in the manufacturing process, leading to the rapid deterioration of the subframe. There are also no warning lights or failure indicators for this issue. As a result, the subframe is at risk of collapsing, which could cause catastrophic failure of the vehicle's suspension and steering systems. This situation creates an immediate danger to both the occupants of the vehicle and others on the road.

NHTSA complaint #11612045 — an unverified report by a vehicle owner.

SERVICE BRAKES

The subframe has developed extensive rust and corrosion, which I believe is a result of faulty manufacturing. This corrosion has severely compromised the structural integrity of the subframe, posing a serious safety risk. The corrosion appears to be inherent to the materials or design used in the manufacturing process, leading to the rapid deterioration of the subframe. There are also no warning lights or failure indicators for this issue. As a result, the subframe is at risk of collapsing, which could cause catastrophic failure of the vehicle's suspension and steering systems. This situation creates an immediate danger to both the occupants of the vehicle and others on the road.

NHTSA complaint #11612045 — an unverified report by a vehicle owner.

SERVICE BRAKES

Brake line corrosion

NHTSA complaint #11604605 — an unverified report by a vehicle owner.

WHEELS

My 2012 c300 has a rotted rear subframe making the car not able to be driven. It has major ,life threatening, costly damage and this issue already has a recall all over the world but not in the United States. If I can get the assistance to pay this repair, it will be gladly appreciated.

NHTSA complaint #11602805 — an unverified report by a vehicle owner.

STEERING

My 2012 c300 has a rotted rear subframe making the car not able to be driven. It has major ,life threatening, costly damage and this issue already has a recall all over the world but not in the United States. If I can get the assistance to pay this repair, it will be gladly appreciated.

NHTSA complaint #11602805 — an unverified report by a vehicle owner.

SUSPENSION

My 2012 c300 has a rotted rear subframe making the car not able to be driven. It has major ,life threatening, costly damage and this issue already has a recall all over the world but not in the United States. If I can get the assistance to pay this repair, it will be gladly appreciated.

NHTSA complaint #11602805 — an unverified report by a vehicle owner.

STRUCTURE:BODY

We are having issues when braking. The backend of the car wiggles when braking hard. Shop advised that the subframe on the passenger side completely broke away and on the driver side it is very rotted. They advised this is a safety issue since the broken side could pierce the gas tank. I googled this and found that there was a warranty extension for the same year and make car (document MC-10233796-0001) Spoke to the service department and they advised this did not apply to our VIN. I called the corporate number on the warranty extension letter and they advised the same. My complaint is that several other Mercedes models and makes have this issues and are covered. Why isn't ours? Based on images I found online it looks to be the exact failure mode. My son was supposed to drive the car 4.5 hours on the 4th and could have gotten into an accident or been stranded. I also read that in Germany they are fixing all vehicles with this issue.

NHTSA complaint #11600131 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2012 Mercedes-Benz C300. The contact stated that while the vehicle was parked, the passenger’s side rear taillight was inoperable. The vehicle was taken to a local dealer but was not diagnosed or repaired since the VIN nor the model year was not included in NHTSA Campaign Number: 14V177000 (Exterior Lighting). The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.

NHTSA complaint #11597459 — an unverified report by a vehicle owner.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

The contact owns a 2012 Mercedes-Benz C300. The contact stated that after opening the sunroof and then attempting to close the sunroof, the sunroof failed to fully close. The contact had to open and close the sunroof several times before the sunroof closed. Additionally, the contact stated that there was water entering the vehicle from the sunroof which caused electrical failures. The contact stated that the vehicle was drivable, but the "Anti-Theft" warning light illuminated. The contact stated that several other warning lights were later illuminated, and the vehicle would not start. The contact had the vehicle towed to a dealer who diagnosed the vehicle and determined that water had damaged the driver’s side electrical wiring harness. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 169,000.

NHTSA complaint #11594372 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2012 Mercedes-Benz C300. The contact stated that after opening the sunroof and then attempting to close the sunroof, the sunroof failed to fully close. The contact had to open and close the sunroof several times before the sunroof closed. Additionally, the contact stated that there was water entering the vehicle from the sunroof which caused electrical failures. The contact stated that the vehicle was drivable, but the "Anti-Theft" warning light illuminated. The contact stated that several other warning lights were later illuminated, and the vehicle would not start. The contact had the vehicle towed to a dealer who diagnosed the vehicle and determined that water had damaged the driver’s side electrical wiring harness. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 169,000.

NHTSA complaint #11594372 — an unverified report by a vehicle owner.

SUSPENSION

Took my car for a doorknob repair and was told the whole subframe is rotted. They told me not to drive the car on the highway. The car brakes very hard to the right and always goes right while making cranking noises. Car feels very unsafe. I paid a lot of money for this and own a 2012 c300 4matic.

NHTSA complaint #11592433 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Took my car for a doorknob repair and was told the whole subframe is rotted. They told me not to drive the car on the highway. The car brakes very hard to the right and always goes right while making cranking noises. Car feels very unsafe. I paid a lot of money for this and own a 2012 c300 4matic.

NHTSA complaint #11592433 — an unverified report by a vehicle owner.

SERVICE BRAKES

Took my car for a doorknob repair and was told the whole subframe is rotted. They told me not to drive the car on the highway. The car brakes very hard to the right and always goes right while making cranking noises. Car feels very unsafe. I paid a lot of money for this and own a 2012 c300 4matic.

NHTSA complaint #11592433 — an unverified report by a vehicle owner.