72 of the
2,855 complaints filed about the Mercedes Benz C300
are about the braking system —
3% of everything owners reported.
The worst model year for it is 2013.
The contact owns a 2013 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, the vehicle felt like it had shifted sideways. The contact stated that it seemed as if the steering wheel and the front driver's seat had shifted. In addition, the contact stated that while the vehicle was parked, the trunk latch was enabled; however the trunk failed to open or close. The dealer was made aware of the failure. The vehicle was taken to the dealer, where it was diagnosed with a failed subframe and brake line. The contact was informed that the vehicle was not being released because the vehicle was deemed unsafe. The contact was informed that the subframe repair was covered under an unknown recall repair. The contact requested a quote for the additional repair. The dealer then requested that the contact remove the vehicle from the dealer lot. The vehicle was towed to an alternative dealer. The contact was disabled and was without transportation. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 47,574.
NHTSA complaint #11757525 — an unverified report by a vehicle owner.
The contact owns a 2015 Mercedes C300. The contact stated that the driver's side rear brakes and rotors were rusted. The contact stated that when the brakes were applied, they were slow to respond. The TPMS warning light was illuminated. The vehicle was taken to a braking center, which declined the warranty for the aftermarket parts. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 176,000.
NHTSA complaint #11740646 — an unverified report by a vehicle owner.
Rear brakes backing plates rotted prematurely despite garage kept and well maintained status. While driving, noticed loud scraping and grinding noises from the rear left wheel. Took to mechanic and he found severe rust, with deep corrosion and flaking "rotted". He said I was lucky because this was very close to causing the entire brake assembly to fail, which would lead to serious braking problems or "locked out wheel" and loss of control on a highway which would have put me and others at risk. Had similar rust issues with this car that were fixed in the recent past including rusted brake lines and rusted rear subframe. There is definitely something wrong with the manufacturing as the rear subframe had been recalled and got it fixed that way less than a year ago.
NHTSA complaint #11711917 — an unverified report by a vehicle owner.
Car was Off and parked when brake line failed. Further inspection was able to identify that brake pipes was slowly corroded thought entire lower part of the brake system causing critical failure of brakes. Extreme safety issue due to the material of metal/coating and position of brake pipping. If operator was not observant, operator/driver would not have any braking and could cause harm.
NHTSA complaint #11695579 — an unverified report by a vehicle owner.
Rear subframe rust out and rear passenger brake line corrosion. The entire subframe has to be taken apart in order to reach the brake line. The vehicle is due to get the rear subframe replaced as part of the warranty extension. The brake lines are not covered. Took it into Mercedes Benz Dealership in Santa Fe, NM. They will not even touch it because they don't even know how repair it.Also they never done this type of work.
NHTSA complaint #11618710 — an unverified report by a vehicle owner.
The right rear brake line had rusted out and caused complete brake failure while driving. If this occured at highway speeds it could have resulted in serious injuries. A search has shown this is widespread with the C300 and other mercedes vehicles and although mercedes has acknowledged this in other vehicles it has not done so for the C300. This is a potential for serious bodily injury and should be addressed.
NHTSA complaint #11615115 — an unverified report by a vehicle owner.
On several instances of breaking, my 2013 Mercedes Benz C300 pulls hard to the right and becomes very unstable. I assumed it was a brake problem by the way the car drove. I took it to my mechanic, who immediately identified the rear subframe had rusted so much that a control arm had broken loose from the subframe. The rear subframe acts as a foundation for the rear suspension and holds the backend together. Fortunately I was able to get this diagnosed prior to a serious accident. The car gets very unstable, especially at higher speeds, when braking. There are no warning lights that will catch this. This problem absolutely places both passengers and other cars on the road at risk of a collision when braking, especially on the highway at higher speeds. I am going to contact a local Mercedes Benz dealer to evaluate replacement of the damaged parts to ensure the car is safe to drive following repair. Based on the links below, it sounds like a known issue at Mercedes Benz. I was never notified of any issues or from prior service visits, or via mail notice from the manufacturer. My mechanic was shocked, to say the least. Hoping MB will take care of this dangerous problem without hassle. See: [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11614928 — an unverified report by a vehicle owner.
The subframe has developed extensive rust and corrosion, which I believe is a result of faulty manufacturing. This corrosion has severely compromised the structural integrity of the subframe, posing a serious safety risk. The corrosion appears to be inherent to the materials or design used in the manufacturing process, leading to the rapid deterioration of the subframe. There are also no warning lights or failure indicators for this issue. As a result, the subframe is at risk of collapsing, which could cause catastrophic failure of the vehicle's suspension and steering systems. This situation creates an immediate danger to both the occupants of the vehicle and others on the road.
NHTSA complaint #11612045 — an unverified report by a vehicle owner.
The contact owns a 2011 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed and almost went all the way to the floorboard, and the vehicle failed to stop as needed, requiring an increased effort to bring the vehicle to a complete stop. No warning lights were illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11611686 — an unverified report by a vehicle owner.
Rear brake line rusted through land leaked all the break fluid rendering the vehicle unsafe to drive due to the complete failure of the breaking system. The location of the break line corrosion is above the rear differential and next to a retainer clip.
NHTSA complaint #11604234 — an unverified report by a vehicle owner.
The Brake lines in this car rot very early in life span. This is a severe issue as no one would know unless car is brought in for repair. There is already a extended warranty for subframe rotting for my c300 and several other models and years . Both of these should be repaired due to poor manufacturing not just the subframe. Both of these issues even independently put everyone on the road at risk of potential failure. Car has been brought in for repair and has been pointed out to me both by independent party and Mercedes Benz dealership in my area. There are NO WARNINGS also multiple claims for both rusting and rotting
NHTSA complaint #11596919 — an unverified report by a vehicle owner.
Took my car for a doorknob repair and was told the whole subframe is rotted. They told me not to drive the car on the highway. The car brakes very hard to the right and always goes right while making cranking noises. Car feels very unsafe. I paid a lot of money for this and own a 2012 c300 4matic.
NHTSA complaint #11592433 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
The contact owns a 2011 Mercedes-Benz C300. The contact stated while driving at an undisclosed speed, he became aware that the brakes were not functioning properly. The contact had to pump the brake pedal to bring the vehicle to a complete stop. The cruise control, ABS, and traction control warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic; however, the vehicle was diagnosed with a failure with the electronic stabilizing program control unit. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 84,000.
NHTSA complaint #11590636 — an unverified report by a vehicle owner.
The brake lines have corroded in multiple places causing brake fluid to leak, potentially creating a safety risk had the problem not been immediately observed and corrected. An independent service center confirmed the problem and replaced all the brake lines and hoses. There were no warning lamps or signals. A puddle of brake fluid under the car was the first indication of a problem.
NHTSA complaint #11589855 — an unverified report by a vehicle owner.
This is a low mileage car with odometer reading of 25668 (less than 2000 miles per year), used sparingly and always parked in the garage. On 05/07/2024 I noticed brake fluid flowing from the left rear side of the car; on examination this seemed to come from the flexible hose that connects the brake fluid line to the brake caliper. I called my Mercedes-Benz (MB) dealer and arranged for further inspection and service. The technician identified that the brake fluid lines to the rear were both totally corroded and in need of immediate replacement. Since the lines were embedded behind the subframe it necissated lowering the subframe to access. Other parts were also severely corroded and required replacement. (see attached PDF of Invoice) The total cost of the repair was $4,592.93. The dealership applied a discount of $150.00 to this for an amount due of $4,442.93. As an engineer, I believe the material used for the brake fluid lines were unsuitable and furthermore were unprotected for the harsh environment experienced under the car, and I believe MB with all their experience in automobiles manufacturing over the years clearly should have known and forseen this fact; I do believe that MB is responsible for this premature failure of the brake lines of my car aven driven only 25,666 miles to date. I am therefore requesting NHTSA to require MB to reimburse me for the unnecessary expense of the costly repairs. It is only fortunate that this failure was identified in my garage and not on the highway. Please advise me of your resolution. Thank you.
NHTSA complaint #11589443 — an unverified report by a vehicle owner.
The contact owns a 2013 Mercedes-Benz C300. The contact stated while pulling into a parking space and depressing the brake pedal, the vehicle accelerated unintendedly. There was no warning light illuminated. The contact stated that she depressed the brake pedal but the vehicle failed to respond. The contact stated that while the vehicle was approaching a building ahead, she veered to the right and hit the front bumper of an occupied vehicle. The vehicle then drove over the sidewalk. The contact stated that while approaching the end of the sidewalk, she veered to the right and the vehicle stopped after approximately 200 feet. The air bags did not deploy. There was no injury sustained. A police report was filed. The vehicle was towed to an auto collision repair shop. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 23,032.
NHTSA complaint #11578340 — an unverified report by a vehicle owner.
While I was driving my 2012 MB C300 4Matic Sport Sedan in Nov', 2023 with history of regular maintenance, noticed a pretty load knocking noise, shudder and drifting to left a bit when it brakes from the driver's rear side especially on the highways. I took it to our local mechanic who was horrified to report that the sub frame was broken and completely rotten out too specifically rust issue with the rear suspension-rear subframe. He gets other German Cars like BMW & Audi even older and more miles in Chicago but none have rusted so much as these MB C-Class cars. Knowing the Dealers wont accept it a manufacturing defect, he was planning to repair it (no chance of wielding that thin metal sheet as the likelihood of breaking it is high). I was surprised to see 2010 Chevy Impala having a much more robust under the cover protection and no rusting with 115k miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11573402 — an unverified report by a vehicle owner.
The ESP®, or Electronic Stability Control system can put the car into limp mode unexpectedly. Say you are driving on route 66 going 50 mph. The ESP system can turn off if a wheel speed sensor or yaw sensor is on the way out. This causes the car to suddenly dramatically brake and limit speed to 5 mph on the highway. Risk of high speed rear end collision and mortality to the driver.
NHTSA complaint #11561434 — an unverified report by a vehicle owner.
My brake line is corroded and needs replacing at a cost of $3500.00. I have an extended warranty on the rear subframe due to a recall; however, Mercedes will not cover this costly repair. I was informed by service advisor that I could still drive car with extra caution, as there are no leaks.
NHTSA complaint #11560808 — an unverified report by a vehicle owner.