89 of the 1,046 complaints filed about the Mercedes Benz GLK350 are about the fuel system — 9% of everything owners reported. The worst model year for it is 2010.
89
Complaints
9%
Share of all complaints
3
Crashes
3
Fires
FUEL SYSTEM, GASOLINE
The contact owns a 2014 Mercedes-Benz GLK350. The contact stated that there was an abnormal fuel odor inside and outside vehicle. The check engine, TPMS, and several other unknown warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
NHTSA complaint #11750586 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I noticed fuel / gas smell from my vehicle. I looked up cause for this type of occurrence. I was referred to a recall bulletin for this particular cause - Recall Campaign #2013020002. My vehicle (VIN #) is not on the recall list. Both MB dealerships in my area state I would have to cover the cost to replace the Fuel Filter Flange. I am certain the Fuel Filter Flange is defective and should be listed in the recall. I pulled up the rear seat and removed the cover to expose the Fuel Filter Flange. There was gasoline on top of the Fuel Filter Flange. (I have documented with pictures).
NHTSA complaint #11721172 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
See attached document for complaint.
NHTSA complaint #11693897 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I am writing to express a serious safety concern regarding the Mercedes-Benz GLK 350, particularly related to the fuel pump system under the rear passenger area. It has come to my attention that the fuel pumps in these vehicles emit a strong, unpleasant odor every time the car is refueled. This poses a significant risk to both the driver and passengers. I have personally experienced a similar issue with a 2013 Mercedes-Benz GLK350, where the pumps were constructed with a substandard plastic material that, over time, will melt and start dripping from the top of the pump. This degradation of materials significantly compromises the integrity of the system, creating a serious hazard that could, in the worst case, lead to catastrophic outcomes, including fire or explosion. I strongly urge Mercedes-Benz to investigate and address this issue as a matter of priority. The potential consequences of ignoring this matter are severe, and a permanent solution must be found before any further risk is posed to the safety of vehicle occupants. Thank you for your immediate attention to this critical safety concern. I look forward to your prompt response and the implementation of necessary corrective actions. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11692024 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I am writing to express a serious safety concern regarding the Mercedes-Benz GLK 350, particularly related to the fuel pump system under the rear passenger area. It has come to my attention that the fuel pumps in these vehicles emit a strong, unpleasant odor every time the car is refueled. As a safety engineer, I can confirm that this poses a significant risk to both the driver and passengers. I have personally experienced a similar issue with a 2010 Mercedes-Benz C300, where the pumps were constructed with a substandard plastic material that, over time, will melt and start dripping from the top of the pump. This degradation of materials significantly compromises the integrity of the system, creating a serious hazard that could, in the worst case, lead to catastrophic outcomes, including fire or explosion. I strongly urge Mercedes-Benz to investigate and address this issue as a matter of priority. The potential consequences of ignoring this matter are severe, and a permanent solution must be found before any further risk is posed to the safety of vehicle occupants. Thank you for your immediate attention to this critical safety concern. I look forward to your prompt response and the implementation of necessary corrective actions. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11634148 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
My truck has been smelling like gas for a while. I replaced the gas cap and still smelled gas when I was driving. Recently I started smelling it inside the car. It was leaking from two places under the car when I would drive it or just have it running. The mechanic took the plastic piece off the bottom and gas started pouring down. He took the back seats out and there was a pool of gas sitting on the fuel pump. He had me start the car and it immediately started spewing from the fuel pump inside the car. I did not know I could report a complaint so I did not take pictures. The car has been sitting since Saturday without being turned on and the gas spot on the ground remains wet. It’s very dangerous and right now I cannot fix it due to finances.
NHTSA complaint #11627422 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Extremely Urgent Safety Warning! Similar to the the passenger fuel filter extended warranty on the passenger side, the driver's side plastic fuel filter pump is obviously visably defective and forming a large crack, thereby leaking a significant amount gasoline into the back seat, with much also draining out the bottom of the vehicle. Additionally, the metal studs securing the filter are painted, making removal of the filter difficult without breaking the studs. No warning lamps or messages.
NHTSA complaint #11616548 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I smelled gasoline in my car didn’t think of anything . Till today when i pumped gas it smelled very strong got home parked my car i notice a leak i look closer under and it’s leaking gas .just got this car 2 months ago There was a safety recall about this issue back in 2013 and I was not sure if this issue was corrected before on my vehicle and think this needs to be recalled again. Please investigate
NHTSA complaint #11615868 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
After a fuel fill-up, I smell fuel inside the cabin and outside by the gas tank opening. This causes a constant stress..., what if there is a fire? I heard and read so many similar complains and concerns. This should constitute for a RECALL. What is the responsibility of NHTSA to the consumer's safety.
NHTSA complaint #11607580 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
When we fill up the SUV with gas, there is a very strong odor of gas outside of the passenger door & some odor "inside the SUV. We looked online Motortrend.com said Certain 2011-2012 MB CLK 350 4matic are being recalled for a potential fuel leak caused by a crack in the fuel filter flange, Dec 15, 2012.' We stopped by MBenz of Lynnwood, Wa and spoke Garrett, a service rep. Garrett said that this was not a safety issue and we can continue to safely drive the SUV. We disagreed! We are very concerned because we believe there is a safety issue, our SUV has a crack fuel line could catch on fire while we are driving and potentially anyone around us could be affected. We did not get a malfunction or error message.
NHTSA complaint #11607422 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Gasoline smell around the car when parked in the garage. An inspection underneath the car and in the engine, bay failed to locate the leak. A [XXX] search for fuel leak on Mercedes Benz (MB) returned a number of hits for problems with leaks around fuel tank components on the GLK and other MB models. Upon removal of the rear seat and a check under the two fuel tank covers, I found gasoline pooled on a concave area on top of the Fuel Suction Pump Assembly, MB, part 2184700994 (see attached photos). This plastic part has cracks in it that allow fuel to escape. I contacted MB U.S. headquarters support as I thought that they may have been a campaign to replace this component since the 2012 GLK had a recall for fuel flange cracks but the MB customer support team indicated that a campaign did not exist for this issue on the 2015 MB GLK. Since the car is out of warranty, I purchased a replacement part 2184700994 and installed it which fixed the problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11607406 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Vaporized gasoline fuel odor emanating from the back seat area due to fuel filter flange crack
NHTSA complaint #11595654 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2013 Mercedes-Benz GLK350. The contact stated that the odor of fuel was present inside and outside of the vehicle. While the vehicle was parked fuel leaked underneath the vehicle. The vehicle was taken to the local mechanic who diagnosed that the driver's side fuel tank housing had cracked causing fuel to leak. The vehicle was not yet repaired. The manufacturer was contacted and informed that the VIN was not included in the Manufacturer's Extended coverage for the failure. The local dealer was not contacted. The failure mileage was 66,300.
NHTSA complaint #11574920 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2013 Mercedes-Benz GLK350. The contact stated that while driving at an undisclosed speed, there was a gasoline odor in the interior of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who determined there was a gasoline leak however, the location of the leak was unknown. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 12V557000 (Fuel System, Gasoline) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 130,000.
NHTSA complaint #11570907 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I smell gasoline every time I fill up the gas tank and don't smell it when not quite full. I haven't check yet but I think that the fuel pump flange has deteriorated. My co-worker has the same exact issue and he found out that it was the fuel pump flange. There was a safety recall about this issue back in 2013 and I was not sure if this issue was corrected before on my vehicle and think this needs to be recalled again. Please investigate. Thank you. Sincerely,
NHTSA complaint #11568914 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Evap small leak P0456 Car cabin smells strong gas odor check engine light is on
NHTSA complaint #11557044 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2013 Mercedes-Benz GLK350. The contact stated that while the vehicle was parked in the garage, there was a strong gasoline odor coming from the vehicle. Additionally, the contact stated while driving at various speeds, there was a strong gasoline odor inside and outside of the vehicle. The dealer was notified of the failure and informed the contact that a fee would be charged for a diagnostic test. The vehicle was taken to an independent mechanic for an oil change, and the contact was informed that the fuel pump and the sending unit were leaking. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.
NHTSA complaint #11554946 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
My mercedes GLK 350 4matic has a strong gas smell every time I fill up and I am afraid to park in my garage because of the very strong gas smell, and I am afraid of a fire.
NHTSA complaint #11535252 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Feul leaks from the tank when the vehcle is on idling. I understand its feul pump leaking the feul. This is a gushing leak under the tank whne the car is idling no obvious leak when parked the engine is off.
NHTSA complaint #11532658 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I noticed the smell of fuel coming from my vehicle, specifically when I top off at the gas station. This is dangerous as fuel can combust if ignited. I took the vehicle to be service, to find out about the fuel odor and was advised of the NHTSA recall. Upon researching I see that although the NHTSA recall #12V557000 specifically covers this issue, when entering my VIN, the recall does not appear for MY specific vehicle, which is a 2011 GLK-350. It appears there are several affected vehicles not included in the recall. This is a failure on behalf of Mercedes Benz as it is simple to conclude that the issue includes more vehicles than initially recalled. These vehicles need to be included as well.
NHTSA complaint #11529496 — an unverified report by a vehicle owner.