31 of the
480 complaints filed about the Mercedes Benz Sprinter 3500
are about the transmission —
6% of everything owners reported.
The worst model year for it is 2016.
31
Complaints
6%
Share of all complaints
2
Crashes
0
Fires
Transmission & Drivetrain complaints by model year
The contact owns a 2023 Mercedes-Benz Sprinter 3500. The contact stated that while driving 65 MPH, there was an abnormal metal grinding sound coming from the rear of the vehicle. While driving at various speeds, the vehicle went into LIMP Mode. The transmission was shifted into neutral(N) and the vehicle was restarted. The vehicle was taken to the dealer, who diagnosed the vehicle with pinion bearing failure and the LIMP Mode failure causing an Emissions issue. The rear axle, air charger GPS, turbo, and oil sensor were all replaced. The vehicle was taken to the dealer and was diagnosed with the same failure. The vehicle was repaired. The manufacturer was informed of the failure and a case was opened to discuss a buy-back offer for the failure. The failure mileage was approximately 9,600.
NHTSA complaint #11747880 — an unverified report by a vehicle owner.
Vehicle suddenly lost ability to accelerate. After driving narrow mountain roads with a lot of downshifting and upshifting, vehicle was on a long, gradual downgrade, then approached a long, slight (4%?) upgrade. Vehicle would not maintain speed and began to decelerate. Pushing the accelerator to the floor did nothing. Attempted to manually shift gears, but transmission would not downshift, or upshift. This almost resulted in being rear-ended by a semi. The speed limit was 55 and vehicle had decelerated to ~25 mph by the time I found a place to pull over. I stopped and was able to shift into Park. Revved engine and it behaved normally. I shut off engine for 1 minute and then restarted. Transmission and all other systems worked fine and continued to work normally for several hundred miles since then. There was no CEL, or other warning. There was no indication that it entered "Limp Mode." I suspected that something went wrong with the logic in the electronic transmission. Mercedes Benz dealership could NOT find any codes logged in the OBDC. The service manager told me, "It might have been some kind of computer glitch." This was a 2-lane, country road. The semi was behind me, and several cars were behind the semi. For about a mile there was no place to pull over. One impatient driver passed both the semi and my Sprinter in a "no passing" zone. We were all fortunate that there was no collision.
NHTSA complaint #11633414 — an unverified report by a vehicle owner.
I noticed there was a reall of the front hub assemblies, however my truck must not be on the list of vins affected. I’m not sure where the problem originated, but I just passed over 20k miles and im experiencing signs and symptoms of what that recall would affect, this started a few weeks ago, not getting any better. It just stars vibrating and shaking pretty violently. like a wheels coming off. My father is also experiencing similar issues in is 2022 king ranch with 40k miles. Both trucks, very low mileage shouldn’t show these sort of symptoms yet. I’m not sure if they go hand and hand but it also disengages advanced track and all the front sensors and what not when it happens. After reading a few articles I do not feel the truck is safe on the road until probably inspected.
NHTSA complaint #11611821 — an unverified report by a vehicle owner.
This is regarding a 2023 Winnebago View 24D RV on a 2022 Mercedes Sprinter chassis. While attempting to back up an incline (transmission in reverse gear) the RV will not move. Engine revs up to only approximately 1800 rpm, but the RV remains stationary. Incline is our driveway, connecting to a parking area for the RV off to the side. Climbing hills with transmission in "Drive" is no problem. I took the RV to Mercedes Benz of Knoxville, Tenn., and they stated that they could not duplicate the issue, that the vehicle performs "as designed". They further stated that they had another vehicle in the shop for service and it performed in the same manner. I have no idea how steep an incline they tried, but our driveway is fairly steep. Gross Vehicle Weight Rating is 11,030 lbs. I had the RV weighed after loading it fully, and it totaled 10,725 lbs. No warnings appeared on the dash and no telltale symptoms. Mileage on the RV is 3150. Issue first appeared at approx. 2700, after I had the parking area built, so I can only assume the issue was present since new; I had never tried to back uphill before this. Backing up on level ground presents no problem. I tried calling MB technical support, but they only told me that I had to take it to a dealer; that they had no other options. I have a copy of the service order from Mercedes of Knoxville, but currently not able to scan. Will be able to at a later date.
NHTSA complaint #11546627 — an unverified report by a vehicle owner.
After MB performed required "Campaign" #2021070027 related to transmission, CDI, VGS and SCR (emissions controls), transmission now shift erratically and sometimes unpredictably, engine in now running a higher RPMs, oil pressure is higher and fuel economy (as measured by manual calculations) has decreased by not less than 15%. Vehicle was originally taken to MB dealer related to a repeated (3 times) intermittent/unexpected power loss and dash warning. Loss of power could lead to loss of control, especially at highway speeds. The vehicle was inspected and above noted campaign was applied. Mileage on the vehicle is currently 15000. Events took place between 12k and 14.5k. Degrade of fuel economy as well as other operations degradations took place after a service visit at 14.5k.
NHTSA complaint #11480168 — an unverified report by a vehicle owner.
trucks cut speed limit 65 to 10 normal highway i do understood %35 degrees slow down but its only %2 degrees uprise there is no power at engine rpm is shows less then 1 rpm and even if press the gas pedal all the way the truck does not accelerate like truck is lock right there very dangers any one drive back of me they are not accept that much speed change they are in dangers scarr to drive truck be couse same one get git back of truck and can get kill
NHTSA complaint #11440985 — an unverified report by a vehicle owner.
Stranded and required towing due to condensation and EIS Module The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. _ Mercedes is aware of the issue as they have created a plastic bag with part number A 638 546 00 35 and they are charging $20 for it. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. They are refusing to treat this as a warranty claim even though it is clearly a manufacturer defect.
NHTSA complaint #11434117 — an unverified report by a vehicle owner.
Driver reported that vehicle started rolling while the vehicle was in Park. The parking brake was engaged. Driver was able to stop the vehicle by physically keeping their foot on the brake. Vehicle sent to dealer. Dealer confirmed issue and repaired. Repair details and video of issue available. Other related issues have been identified on other vehicles.
NHTSA complaint #11428216 — an unverified report by a vehicle owner.
It appears that driver pressed park and pulled the emergency brake. Its possible it wasn't pressed properly and dealer found no mechanical fault. Vehicle rolled forward and impacted another parked vehicle. This may be related to other issues at RemarkableFoods related to transmission being in "Park" or driver intending to put it in "Park". Video is available for review.
NHTSA complaint #11428219 — an unverified report by a vehicle owner.
The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated while the vehicle was stationary, the accelerator pedal was depressed however, the vehicle failed to respond. The contact stated that there was no warning light illuminated. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The contact stated that the failure persisted. The manufacturer was informed of the failure. The failure mileage was approximately 10,000.
NHTSA complaint #11427430 — an unverified report by a vehicle owner.
ON SEPTEMBER 30, 2019, I WAS DRIVING DOWNHILL ON A MOUNTAIN ROAD WHEN OUR RV, A 25' LTV UNITY ON A MERCEDES SPRINTER 3500 CHASSIS, SUDDENLY LURCHED AND FELT OUT OF CONTROL. THE BREAKS AND STEERING WERE UNRESPONSIVE, AND I WAS PUMPING THE BREAKS, HARD! AFTER ABOUT 10 MINUTES OF STRUGGLING TO CONTROL THE VEHICLE AROUND A CURVEY DOWNHILL ROAD, CONTROL WAS RESTORED. LUCKILY, I WAS GOING SLOW ENOUGH THAT NO ACCIDENT RESULTED, BUT IT REALLY SHOOK ME! A COUPLE OF DAYS LATER THE VEHICLE (STILL UNDER WARRANTY) WAS LOADED ONTO A FLATBED TRUCK AND HAULED 2 HOURS AWAY TO KNOXVILLE, TN; THE CLOSEST MERCEDES SPRINTER VAN SERVICE CENTER. THEY REPLACED THE RIGHT REAR WHEEL SPEED SENSOR. I WAS TOLD THE OTHER SENSORS MIGHT ALSO FAIL, BUT THEY COULD NOT BE REPLACED UNTIL THEY FAILED. SINCE THEN, WE HAVE HEARD FROM SEVERAL OTHER RVERS WITH MERCEDES SPRINTER CHASSIS THAT THIS IS A COMMON PROBLEM. FOR US, THE VEHICLE NO LONGER FEELS SAFE TO TAKE ON THE ROAD SINCE WE HAVE NO IDEA WHEN THE NEXT SENSOR WILL FAIL. (PS - I TRIED TO SUBMIT THIS FORM EARLIER, BUT ACCIDENTALLY SELECTED 'I DO NOT WISH TO RECEIVE SAFETY RECALL ALERTS' - I DO WISH TO RECEIVE THOSE ALERTS.
NHTSA complaint #11394837 — an unverified report by a vehicle owner.
WHEEL SPEED SENSORS KEEP FAILING. I HAVE HAD EIGHT SENSORS FAIL IN THREE YEARS OF OWNERSHIP. TRANSMISSION SHIFTS ERRATICALLY, SPEED SURGES, ABS, CHECK ENGINE LIGHT AND BRAKING IS IMPAIRED. THIS HAPPENS WHEN VEHICLE IS IN MOTION.
NHTSA complaint #11390889 — an unverified report by a vehicle owner.
WHEN TURNING A CORNER,ENGINE RACED TO 45 MPH WITHOUT MY FOOT ON THE THROTTLE.ALMOST LOST CONTROL.HAD TO PUT VEHICLE,MEREDES SPRINTER 3500,INTO NEUTRAL TO STOP IT.HAD PREVIOUSLY HAD THE DEALER REPAIR SPEED SENSORS THREE OTHER TIMES.WARNING LIGHTS COME ON AND I LOOSE CRUISE CONTROL.DANGEROUS CONDITION.MB SHOULD RE ENGINEER THE PART AND INSTALL IN AFFECTED VEHICLES.DEALER CONTINUES TO INSTALL DEFECTIVE PARTS.
NHTSA complaint #11390039 — an unverified report by a vehicle owner.
DRIVING ON A DRY DAY, SMOOTH ROAD, WITH CRUISE CONTROL ON 65MPH AT 7:45PM. THIS VEHICLE IS CONVERTED WITH A THOR 24HL CAMPER ON THE CHASSIS. FIVE HOURS INTO THE DAYS DRIVE THE VEHICLE FLASHED ASR/ESP TRIANGLE - AND JERKED ABRUPTLY BUT INSTANTANEOUSLY BUT REMAINED ON CRUISE CONTROL. 2 SECONDS LATER: ABS LIGHT ON, ASR/BAS LIGHT ON, ESP LIGHT ON CRUISE CONTROL STOPPED FUNCTIONING (FYI - A VERY HEAVY ACCELERATOR PEDAL SPRING MAKES DRIVING DIFFICULT, FOR HOURS ON END, WITHOUT CRUISE WORKING - ESPECIALLY FOR THE OLDER DRIVERS LIKELY TO BE DRIVING THIS RIG.) PULLED OFF THE SIDE OF THE ROAD, SET FLASHERS, AND TURNED OFF ENGINE FOR ONE MIN HOPING TO RESET THE FAULT. TURNED BACK ON - NO CHANGE OFF THEN BACK ON AND THE YELLOW CHECK ENGINE CAME ON STEADY ALONG WITH THREE PREVIOUS AUCTION LIGHTS (ABOVE) VEHICLE HAD EXPERIENCED (WITH THE PREVIOUS OWNER) A PREVIOUS 'WHEEL SPEED SENSOR FAILURE' AND IT WAS REPAIRED. . 'WHEEL SPEED SENSOR FAILURE' APPEAR AT EPIDEMIC LEVELS ON THE TWO RV FACEBOOK GROUPS ASSOCIATED WITH THIS VEHICLE. THE 5TH KEY TURN AFTER INITIAL FAULT AND FAILURE OF CRUISE CONTROL THE THREE LIGHTS WENT OUT BUT THE CHECK ENGINE LIGHT REMAINED ON. ON APPROXIMATELY THE TENTH KEY TURN THE CHECK ENGINE LIGHT WENT OUT. VEHICLE RETURNED FOR SERVICE AT MERCEDES DEALERSHIP 'UNDER WARRANTY'. MY ISSUE LAYS IN THE POTENTIAL FOR THE VEHICLE TO ENTER INTO THE LIMP MODE IF ANOTHER CENSOR SHOWS A FAULT AND I'M ON THE ALASKA HIGHWAY 200 MILES FROM THE NEAREST POSSIBLE SERVICE. DEALER REFUSES TO SHARE TECH DATA CONCERNING RESET OF FAULT CONDITION OR A MERCEDES FIX FOR THIS NOW WELL KNOWN AND DOCUMENTED VEHICLE SHORTCOMING. THIS ISSUE CAN AND WILL GET PEOPLE KILLED AS THEY 'LIMP' DOWN THE HIGHWAY TO GET SERVICED OR ARE FORCED TO PULL OVER IN HEAVY TRAFFIC TO CHECK OUT WHAT MERCEDES SHOULD BE WARNING IS ALL ABOUT PROACTIVELY.
NHTSA complaint #11386418 — an unverified report by a vehicle owner.
THIS SPRINTER IS A WINNEBAGO 170X RV CONVERSION. ON MULTIPLE OCCASIONS SINCE BUYING THE VEHICLE IN 2016 WE HAVE EXPERIENCED A SUDDEN LOSS OF POWER WHILE DRIVING. THE ENGINE REMAINS ON BUT THE TRANSMISSION IS NOT ENGAGED. STOPPING THE VEHICLE AND RESTARTING CLEARS UP THE PROBLEM TEMPORARILY BUT IT WILL CONTINUE TO HAPPEN UNTIL A FAILING REAR SPEED SENSOR IS REPLACED. THE FIRST TIME THIS OCCURRED THE LOCAL MB DEALER REPLACED BOTH REAR SENSORS FREE OF CHARGE EVEN THOUGH THE VEHICLE WAS OUT OF WARRANTY. THE SECOND TIME A WHEEL SENSOR FAILED WE WERE FAR FROM HOME AND HAD TO DELAY OUR TRIP SEVERAL DAYS BEFORE THE CORRECT PART COULD BE INSTALLED. I HAVE ALSO FOUND IN REPAIR RECEIPTS FROM THE PRIOR OWNER THAT A REAR SENSOR WAS REPLACED WHEN THEY OWNED THE VEHICLE. THIS FAILURE MODE - SUDDEN LOSS OF POWER IS EXTREMELY DANGEROUS. IT HAS HAPPENED SEVERAL TIMES ON FREEWAYS INCLUDING ONCE IN THE FAST LANE WHERE PULLING OVER TO THE RIGHT WAS IMPOSSIBLE. WE NOW CARRY A SPARE SET OF REAL WHEEL SPEED SENSORS IF WE FIND OURSELVES IN A LOCATION WHERE MERCEDES BENZ PARTS ARE NOT READILY AVAILABLE.
NHTSA complaint #11382947 — an unverified report by a vehicle owner.
THIS VEHICLE HAS HAD 4 SEPARATE WHEEL SPED SENSOR FAILURES. WHEN EACH INCIDENT OCCURRED, THE VEHICLE WILL ACCELERATE ON ITS OWN AND AT THE SAME TIME THE ABS WILL NOT ALLOW FULL BRAKING PRESSURE WHILE UNDERWAY. YOU WILL HEAR THE ABS SOUND LIKE IT'S SLIDING ON A SLIPPERY SURFACE IN ANY CONDITION. AS THE VEHICLE ACCELERATES AND BRAKING PRESSURE IS GREATLY REDUCED, IT IS SOMETIMES NECESSARY TO QUICKLY SHOVE THE VEHICLE IN NEUTRAL TO KEEP FROM HITTING ANYTHING AHEAD. WHEN THESE FAILURES OCCUR IT CAN BE AT ANY SPEED OR ON ANY SURFACE. THIS VEHICLE WAS PURCHASED NEW AND NOW HAS APPROXIMATELY 45,000 MILES. OCCASIONALLY, PRIOR TO THE DASH LIGHTS INDICATING A WHEEL SPEED SENSOR FAILURE, THE VEHICLE WILL ALSO CUT ALL POWER. THIS TYPICALLY HAS HAPPENED ON HARD ACCELERATION ONTO A HIGHWAY, BEING EQUALLY DANGEROUS TO DRIVE. THE VEHICLE IS JUST GOING OUT OF WARRANTY AND I HAVE TRIED TO WORK OUT A SOLUTION WITH MERCEDES WHO HAVE NOW STATED I HAVE NO CLAIM. A FINAL FACTOR IS THAT AT ABOUT 10,000 MILES THIS VEHICLE HAD A MASSIVE SHORT THAT LITERALLY MELTED THE BATTERY DOWN. I HAVE SUGGESTED TO MERCEDES THAT THAT INCIDENT, UNDER WARRANTY, MAY HAVE DONE SEROUS HARM TO THE ENTIRE ELECTRICAL SYSTEM/COMPUTERS.
NHTSA complaint #11374997 — an unverified report by a vehicle owner.
WHEN I WENT TO TRY THE 4 WHEEL DRIVE THE FOLLOWING THINGS HAPPENED: A CLUNKING SOUND IN THE REAR OF THE VEHICLE. NUMEROUS WARNING LIGHTS CAME ON . ABS, COLLISION AVOIDANCE, CRUISE CONTROL, CHECK ENGINE, ESC OR ESP. OVER TIME THE LIGHTS CLEARED BUT CAME BACK ON WEEKS APART. I AM A RETIRED NASA SAFETY/RELIABLY ENGINEER. IN MY OPINION ALL OF THESE LIGHTS COME ON AS A RESULT OF FAILURES OF ONE OR MORE WHEEL SPEED SENSORS. THIS IS A MAJOR SAFETY PROBLEM AS WHEN THERE IS A FAILED OR INTERMITTENT OPERATION OF A FAILED SPEED SENSOR. ALL OF THESE SAFETY SYSTEMS FAIL WHEN THE ONE SENSOR FAILS. THIS FAILURE COULD OCCUR UNEXPECTEDLY AT ANY TIME. LEADING TO LOSS OF LIVES AND VEHICLE. I HAVE NOT RECEIVED ANY WARNING LETTERS ON THIS MAJOR SAFETY FAILURE. ACCORDING TO THE DEALER MERCEDES IS AWARE OF THIS ISSUE. AFTER THE VEHICLE IS OUT OF WARRANTY MERCEDES SAYS THEY WILL CHARGE THE OWNER TO FIX IT. AT THE VERY LEAST THE ISSUE CLEARLY NECESSITATES THAT THIS ISSUE BE ELEVATED, TO CONSUMERS, AND THAT THE ISSUE BE FIXED . A WARNING THAT DESCRIBES THE ISSUE AND MERCEDES STATUS ON A FIX SHOULD GO OUT TO ALL THE APPROPRIATE PARTIES IMMEDIATELY. THE VEHICLE WAS STOPPED PUT IN NEUTRAL THEN 4 WHEEL DRIVE WAS ENGAGED, IMMEDIATELY WHEN MOVING THERE WAS A BIG CLUNK AND THE WARNING LIGHTS CAME ON. THEY WENT OUT THEN CAME BACK ON INTERMITTENTLY FOR MONTHS. ONE TIME THEY CAME ON JUST SITTING AT THE LIGHT. FAILURE OF MULTIPLE SAFETY SYSTEMS DUE TO A SENSOR FAILURE IS UNACCEPTABLE. I BELIEVE A DESIGN FIX IS URGENTLY NEEDED AND SHOULD BE PRESSED FOR HARD BY THE GOVERNMENT. CURRENTLY THERE IS NO FIX. AND MERCEDES IS NOT ADEQUATELY WARNING THE PUBLIC OF THE ISSUE. UNTIL I PRESSED MERCEDES HARD ON THIS INTERMITTENT PROBLEM I WAS NOT MADE AWARE OF WHAT EXACTLY THE PROBLEM WAS. THE FAILURE OF ONE SENSOR SPEED CAUSES MULTIPLE SAFETY SYSTEMS TO NOT WORK.
NHTSA complaint #11373892 — an unverified report by a vehicle owner.
THIS IS A SECOND OCCURANCE OF A PROBLEM REPORTED UNDER COMPLAINT NO. 11094122. THIS TIME THE VEHICLE WAS PARKED WHEN THE WARNING LIGHTS CAME ON (CEL, ABS, ESC AND ASC). DEALER DIAGNOSED IT AS A 'MALFUNCTIONNING RPM SENSOR'.
NHTSA complaint #11373656 — an unverified report by a vehicle owner.
MB SPRINTER HAS FAULT THAT GENERATES INSTRUMENTS INDICATORS OF ABS, SKIDDING AND ANOTHER. BEFORE THIS OCCURRED TRANSMISSION SHIFTING BECAME ERRATIC AND WHEN BREAKING THE ENGINE REVVED UP AND ALSO MADE BRAKES UNLESS. NO ACCIDENT OCCURRED BUT WAS ALMOST OUT OF CONTROL.
NHTSA complaint #11365059 — an unverified report by a vehicle owner.
THIS IS A WINNEBAGO VIEW 24G ON SPRINTER 3500 CHASSIS. WHILE HIGHWAY DRIVING, SUDDEN ABS AND ESP WARNING LIGHT WITH MESSAGE TO GO TO WORKSHOP. CRUISE CONTROL STOPS WORKING. LOSS OF POWER AND SHIFTING ABILITY IS INTERMITTENT. WAS ABLE TO DRIVE (WITHOUT CRUISE CONTROL AND WITH WARNING LIGHTS ON) FOR 100+ MILES TO SHOP. WHEN LOSS OF POWER OCCURED, I WOULD PULL OFF THE ROAD AND TURN OFF ENGINE, AND THIS WOULD TYPICALLY RESOLVE THE PROBLEM FOR AWHILE SPRINTER AUTHORIZED SERVICE CENTER REPLACED BOTH REAR WHEEL RPM SENSORS 7/3/20 ($581.09). SAME CONDITION RE-APPEARED DURING SIMILAR DRIVING CONDITION. SAME SPRINTER DEALER REPLACED RIGHT FRONT WHEEL SPEED SENSOR TO RESOLVE THE PROBLEM ON 8/18/20 ($507.48).
NHTSA complaint #11363787 — an unverified report by a vehicle owner.