2008 Mini Cooper engine problems

ENGINE

While driving the car at aproximately 25mph, the engine and the car stopped running. All dashboard warning lamps were off prior to the engine failure The car rolled to the side of the road to get out of the way of other traffic. The service engine warning lamp was on after the engine shut off and stopped running. The car was towed to a service station, and they too could not get the car to start. The mechanic's troubleshooting ultimately found the engine's internal timing chain had broken, causing multiple of other internal engine components to become damaged. The engine required detailed repair to replace the damaged engine parts to get it to start operating again. The costs for the repairs were over $5000.00.

NHTSA complaint #11527586 — an unverified report by a vehicle owner.

ENGINE

Timing Chain and tensioner rattle. Known recall issue but not showing recall

NHTSA complaint #11520811 — an unverified report by a vehicle owner.

ENGINE

TIMING CHAIN DEFECTIVE.

NHTSA complaint #11320723 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2008 MINI COOPER. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN TO STALL WITHOUT WARNING. THE CONTACT PULLED INTO A LEFT TURN LANE AS THE VEHICLE COMPLETELY FAILED. THE VEHICLE WAS TOWED TO MINI OF THE WOODLANDS (16675 I-45, CONROE, TX 77385, (936) 344-1258) WHERE IT WAS DIAGNOSED THAT THE DME (ENGINE COMPUTER) FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 58,000.

NHTSA complaint #11241368 — an unverified report by a vehicle owner.

ENGINE

ENGINE HAS DEVELOPED THE "DEATH RATTLE" AT LOW REV AND LOW TEMPERATURE , INDICATING A FAILING, DEFECTIVE TIMING CHAIN AND TENSIONE

NHTSA complaint #11205727 — an unverified report by a vehicle owner.

ENGINE

PURCHASED FROM CARMAX (11/18/17), NEVER INFORMED OF CLASS ACTION LAWSUIT INVOLVING THE TIMING CHAIN WITH THIS VEHICLE. AFTER ONLY 4 MONTHS AND ONLY A FEW HUNDRED MILES, THE PROBLEMS BEGAN. FIRST TRIP TO MECHANIC, THE ENGINE VALVE COVER WAS FOUND TO BE CRACKED. REPLACED FOR JUST OVER $700. LESS THAN 10 MONTHS LATER AND WELL UNDER 2000 MILES, I WAS IN TRANSIT TO WORK, ON THE HIGHWAY OFF RAMP AND THE MINI SHUT DOWN COMPLETELY, WOULD NOT START BACK UP. HAD TO BE PUSHED OFF THE ROAD. TOWED BACK TO AUTO MECHANIC AND ANOTHER $200 TO FIND THE GUIDE TO TIMING CHAIN BROKE OFF, CAUSING ENGINE FAILURE. MINI WAS TOWED BACK TO CARMAX TO FIND THE ENGINE NEEDS REPLACED, BUT WILL HAVE TO BE REPLACED WITH THE SAME TYPE OF ENGINE, WHICH CAN CAUSE THE SAME PROBLEM TO HAPPEN AGAIN AND AGAIN. SENIOR TEAM AT CARMAX IS CURRENTLY EVALUATING MY CASE. POSSIBLE BUY BACK OF VEHICLE, STILL AWAITING A VERDICT.

NHTSA complaint #11132071 — an unverified report by a vehicle owner.

ENGINE

ENGINE MAKE A KNOCKING SOUND WHEN COLD AND GETS LAUGHTER

NHTSA complaint #11114224 — an unverified report by a vehicle owner.

ENGINE

TIMING CHAIN FAILURE (WHICH LED TO CLASS ACTION LAWSUIT) CAUSED ENGINE FAILURE WHILE DRIVING ON HIGHWAY. CAR STOPPED ACCELERATING. 18 YEAR OLD DAUGHTER WAS DRIVING. OWNERS THAT WERE NOT AWARE OF THIS LAWSUIT OR DID NOT VEHICLE AT THE TIME STILL AFFECTED BY THIS DEFECTIVE PART PUTTING DRIVERS IN DANGER YET COMPANY HAS NEVER ISSUED RECALL.

NHTSA complaint #11091996 — an unverified report by a vehicle owner.

ENGINE

TIMING CHAIN TENSIONER FAILURE. I HAD TO REPLACE CHAIN, TENSIONERS AND CRANK GEAR ON MY 2008 MINI WITH 81,000 MILES.

NHTSA complaint #11045320 — an unverified report by a vehicle owner.

ENGINE

CVT TRANSMISSION STICKING IN 2ND GEAR.

NHTSA complaint #11002662 — an unverified report by a vehicle owner.

ENGINE

TIMING CHAIN & TENSIONER MY VEHICLE ONLY HAS 85,000 MILES AND I HAVE HAD TO SPEND $3500.00 TO CHANGE THE TIMING CHAIN THAT IS SUPPOSED TO BE MAINTENANCE FREE, AND LAST TEN YEARS AS PER THE OWNERS MANUAL AND SERVICE MANUAL. CAR STOPPED SUDDENLY ON THE NEW JERSEY TURNPIKE, VERY DANGEROUS SITUATION. THIS IS NOT RIGHT THAT I HAD TO PAY OUT OF POCKET FOR A CAR THAT ONLY HAS 85,000 MILES, AND WAS SERVICED REGULARLY. HUGE SAFETY ISSUE

NHTSA complaint #10972143 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2008 MINI COOPER. WHILE DRIVING 40 MPH, THE VEHICLE LOST ALL POWER AND ALL THE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT SOMETHING WAS LOOSE IN THE ENGINE AND THAT THE ENGINE NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

NHTSA complaint #10948642 — an unverified report by a vehicle owner.

ENGINE

IN SEPTEMBER, 2013, MY 2008 MINI COOPER HARDTOP, WITH THE N12 ENGINE, HAD THE TIMING CHAIN FAIL UNDER OPERATION. THIS CAUSED THE ENGINE TO STOP, AT HIGHWAY SPEED, AFFECTING STEERING, BRAKING AND ALL ABILITY TO MANEUVER THE VEHICLE OUT OF TRAFFIC. TWO VEHICLES BARELY AVOIDED MY DISABLED VEHICLE. I CONTACTED MINI USA AND THEY REFUSED TO ACKNOWLEDGE THE FACTORY DEFECT IN THE TIMING-CHAIN TENSIONER THAT CAUSES THE TIMING CHAIN TO FAIL. I PAID OVER $8000 FOR A REPLACEMENT N12 ENGINE. WITH LESS THAN 10,000 MILES ON THE REPLACEMENT ENGINE, IN JULY, 2016, THE TIMING CHAIN FAILED AGAIN. THIS TIME THE VEHICLE WAS CROSSING A BRIDGE AND THERE WAS NO PLACE TO TRY TO PULL OFF. THE SITUATION WAS VERY DANGEROUS AND LEFT MY FAMILY VULNERABLE TO ONCOMING TRAFFIC. I CONTACTED MINI USA AGAIN, AND ALTHOUGH THEY HAVE ADMITTED TO THE TIMING CHAIN DEFECT ON THEIR N14 ENGINE, IN THE S SERIES VEHICLE, THEY STILL REFUSE TO ISSUE A RECALL FOR THE N12 ENGINES IN WHICH THE TIMING CHAIN FAILURES ARE MORE NUMEROUS. THIS DEFECT CAUSES THE VEHICLE TO BECOME INOPERABLE AT SPEED WHICH IS UNSAFE IN THE EXTREME. MINI USA NEEDS TO ISSUE A SAFETY RECALL FOR EVERY VEHICLE EQUIPPED WITH THE N12 ENGINES.

NHTSA complaint #10927273 — an unverified report by a vehicle owner.

ENGINE

"TAMARA RECALL" TIMING CHAIN.

NHTSA complaint #10907340 — an unverified report by a vehicle owner.

ENGINE

AT 55000 MILES STARTED TO HEAR ENGINE RATTLE AND ROUGH RUNNING AT IDLE. TOOK TO DEALER FOR SERVICE AND THEY SAID THE ENGINE HAS MULTIPLE OIL LEAKS, A FAULTY CAMSHAFT ADJUSTMENT SOLENOID AND FAULTY TIMING BELT. THE TIMING BELT HAS CAUSED THE OIL LEAKS AND FAULTY SOLENOID. THIS WILL CAUSE CATASTROPHIC ENGINE FAILURE. MINI WILL NOT COVER EVEN THOUGH THIS HAS BEEN REPORTED AND IS AN OBVIOUS DEFECT.

NHTSA complaint #10873551 — an unverified report by a vehicle owner.

ENGINE

I PURCHASED MY 2008 MINI COOPER 3 YEARS AGO AND IT'S CURRENTLY AROUND 78K MY CAR WAS DIAGNOSED WITH TIMING CHAIN STRETCHED AND POSSIBLY ENGINE DAMAGE. HOWEVER MINI COOPER USA DOESN'T WANT TO REIMBURSE THE MONEY I'D PAY OUT OF POCKET MYSELF.

NHTSA complaint #10852158 — an unverified report by a vehicle owner.

ENGINE

I PURCHASED A NEW 2008 MINI COOPER FROM AUTOHAUS WEST/MINI OF ST LOUIS. THE MINI COOPER WAS DESIGNED, MANUFACTURED, ASSEMBLED, DISTRIBUTED AND SOLD BY BMW OF NORTH AMERICA, BMW (U.S.) HOLDING CORP., AND BAYERISCHE MOTOREN WERKE AKTIENGELLSCHAFT. I EXPERIENCED A PROGRESSIVE FAILURE OF THE TIMING CHAIN, TIMING CHAIN TENSIONER AND RELATED TENSIONER RAIL, GUIDE RAIL AND SUPPORT RAIL. THE TIMING CHAIN HAD PREVIOUSLY BEEN REPRESENTED TO HAVE A USEFUL LIFE EQUAL TO THE LIFE OF THE CAR. THE TIMING CHAIN IS LOCATED WITHIN THE ENGINE, CONSISTS OF A METAL CHAIN, AND IS NOT SUBJECT TO ADJUSTMENT OR ROUTINE MAINTENANCE. I EXPERIENCED A PROGRESSIVE FAILURE OF THE TIMING CHAIN AS FOLLOWS: (A) DEATH RATTLE OR DIESEL NOISE FROM ENGINE UPON START UP & AT LOW SPEEDS, (B) ROUGH IDLING AFTER HIGHWAY DRIVING, (C) POWER LOSS & ENGINE STALLS ON HIGHWAY EXIT RAMPS, (D) POWER LOSS & ENGINE STALLS ON HIGHWAY, & (E) CATASTROPHIC ENGINE FAILURE. THE MINI COOPER WAS SERVICED BY AUTOHAUS WEST ON THREE SEPARATE OCCASIONS WITH REPAIRS//REPLACEMENT OF SPARK PLUGS, BATTERY, IGNITER COILS, THERMOSTAT COVER AND OTHER ITEMS TOTALING OVER $3,000. AUTOHAUS WEST FAILED TO IDENTIFY THE TIMING CHANGE AS A PROBLEM. AUTOHAUS WEST, BMW OF NORTH AMERICA, LLC, BMW (U.S.) HOLDING CORP., AND BAYERISCHE MOTOREN WERKE AKTIENGELLSCHAFT HAVE KNOWN ABOUT THE TIMING CHAIN TENSIONER DEFECT SINCE 2007 AND HAVE FAILED TO WARN CONSUMERS, ISSUE A RECALL OR PROVIDE EXTENDED WARRANTY COVERAGE.THE LOSS OF POWER & ENGINE STALLS ARE SERIOUS SAFETY HAZARDS & WILL EVENTUALLY LEAD TO ACCIDENTS, INJURIES & EVEN DEATH. TECHNICAL SERVICE BULLETIN M110207 WAS ISSUED IN JANUARY, 2008. HOWEVER, IT IS NOT WIDELY KNOWN TO CONSUMERS AND FAILS TO GIVE CONSUMERS ADEQUATE WARNING. BMW SETTLED CLASS ACTION RE N14 ENGINE USED IN MINI COOPER S. HOWEVER, IT HAS IGNORED SAME PROBLEM WITH N12 ENGINE USED IN MINI COOPER. SAME ISSUES.

NHTSA complaint #10851815 — an unverified report by a vehicle owner.

ENGINE

IN THE SPRING 2014 I PURCHASED A 2008 MINI COOPER 2D HATCH WITH AROUND 98,0000 MILES FOR $14,000 WITH WARRANTY IN IVRINGTON, NJ FROM SPRINGFIELD AUTO GROUP AUTO SALES. IN JANUARY 2015 I HAD A TUNE UP DONE AND THE MECHANIC REPORTED TO ME AFTER DOING A ENGINE DIAGNOSTIC TEST THAT THERE WAS A PROBLEM WITH MY IMMEDIATELY REPORTED THE PROBLEM TO MY WARRANTY COMPANY THAT WAS PROVIDED THROUGH MY THE CAR LOAN COMPANY CREDIT ACCEPTANCE. THE WARRANTY COMPANY REFUSED TO PAY FOR ENGINE TO BE DROPPED OUT OF THE CAR TO FIND OUT WHAT THE PROBLEM WAS. THEY ADVISE ME THAT I WOULD HAVE TO PAY FOR THE ENGINE TO BE DROPPED OUT OF THE CAR TO BE AND CHECKED OUT BEFORE THEY PAY FOR ANYTHING. IN OCTOBER 2015 THE MINI COOPER ENGINE FINALLY BROKE DOWN WHILE DRIVING I HAD TO PULLED IT OVER WHILE DRIVING UP ROUTE 280. THE WRECKER SERVICE TOOK THE MINI TO A MECHANIC. THE MECHANIC STATED THE TIMING CHAIN HAD BROKE AND THERE WAS MAJOR ENGINE DAMAGE AND THE REPAIR BILL WILL BE FROM 2K TO REBUILD THE ENGINE AND 8K FOR A NEW ONE AND I STILL OWN 11K TO BANK FOR THE CAR. THE CAR HAS APPROXIMATELY 106K MILES ON IT. I'VE HEARD OF A LOT OF COMPLAINTS WITH THOSE MINIS WITH THOSE SAME ISSUES HAPPENING ANYWHERE FROM 30K MILES TO OVER 100K MILES FROM 2007-2010 MODELS. NOTHING ELSE HAS BEEN SPENT ON THE CAR FOR REPAIR. I'M NOT WASTING ANYMORE MONEY ON THAT JUNK MINI COOPER. IT'S TO LATE FOR THE LEMON LAW TO BE APPLIED. CAN ANYTHING GET DONE SO THAT I CAN IMPLEMENT A LAWSUIT AND RECEIVE ANY MONEY FOR THAT FROM BMW OR AND THE DEALER OR IS IT A WASTE OF TIME? THANK YOU IN ADVANCE.

NHTSA complaint #10810834 — an unverified report by a vehicle owner.

ENGINE

ON 15 AUG 2015 I PURCHASED A 2008 MINI COOPER 2D HATC WITH 122,629 MILES FOR $6,325 WITH NO WARRANTY IN STANFORD, NC FROM KARAS AUTO SALES, INC. ON 27 OCT 2015 THE MINI COOPER BROKE DOWN WHILE DRIVING AND PULLED IT OVER BESIDE THE ROAD. THE WRECKER SERVICE TOOK THE MINI TO A MECHANIC. THE MECHANIC STATED THE TIMING CHAIN HAD BROKE AND THERE WAS MAJOR ENGINE DAMAGE AND THE REPAIR BILL WILL BE FROM 8K TO 10K IN REPAIR COST. MINI HAD APPROXIMATELY 125K MILES ON IT. I'VE HEARD OF A LOT OF COMPLAINTS WITH THOSE MINIS WITH THOSE SAME ISSUES HAPPENING ANYWHERE FROM 30K MILES TO OVER 100K MILES FROM 2007-2010 MODELS. NOTHING ELSE HAS BEEN SPENT ON THE CAR FOR REPAIR. I'M NOT WASTING ANYMORE MONEY ON THAT JUNK MINI COOPER. IT'S TO LATE FOR THE LEMON LAW TO BE APPLIED. CAN ANYTHING GET DONE SO THAT I CAN IMPLEMENT A LAWSUIT AND RECEIVE ANY MONEY FOR THAT FROM BMW OR AND THE DEALER OR IS IT A WASTE OF TIME? THANK YOU IN ADVANCE.

NHTSA complaint #10807768 — an unverified report by a vehicle owner.

ENGINE

WHILE SITTING AT A RED LIGHT THE ENGINE SHUT OFF AND WOULD NOT START, CAR HAD TO BE TOWED. A FEW DAYS LATER IT WAS FOUND THAT THE TIMING CHAIN HAD BROKE. WITH ONLY 69,000 MILES IT IS UNHEARD OF THAT A TIMING CHAIN BREAKS. THE REPAIR COST WAS $5159.60.

NHTSA complaint #10763831 — an unverified report by a vehicle owner.

ENGINE

WHILE TRAVELING ON THE HIGHWAY IN DICKSON, TN MY 2008 MINI COOPER LOST ALL POWER WITHOUT WARNING. I WAS ABLE TO MAKE IT TO THE SIDE OF THE HIGHWAY. THIS WAS DURING AN ICE STORM. WE HAD TO WAIT HOURS ON THE SIDE OF A HIGHWAY WITH NO HEAT, AND VEHICLES STRUGGLING TO STAY ON THE ROAD, UNTIL A TOW TRUCK DRIVER FROM AAA WAS ABLE TO PICK US UP, SAYING HOW LUCKY WE WERE TO HAVE NOT BEEN HIT. WHEN BRINGING THE VEHICLE TO A CERTIFIED MINI DEALERSHIP I WAS TOLD THAT IT WAS DUE TO LOW OIL LEVEL. THE INCIDENT OCCURED IN FEBRUARY, MY OIL WAS CHANGED ON DECEMBER. UPON REPAIR FROM MY INDEPENDENT MECHANIC, THE CAUSE OF FAILURE WAS DETERMINED TO BE A CATASTROPHIC ENGINE FAILURE DUE TO A FAULTY TIMING CHAIN THAT COLLAPSED. I HAVE BEEN MADE AWARE THAT MINI COOPER IS AWARE OF THE TIMING CHAIN DEFECT, AND IN FACT SENT OUT A SERVICE BULLETIN BUT HAS DONE NOTHING TO FIX THIS PROBLEM. ON BEHALF OF CURRENT MINI DRIVERS AND POTENTIAL BUYERS I URGE YOU TO LOOK AT THIS ISSUE IN HOPES OF PREVENTING POTENTIAL INJURIES OR DEATHS.

NHTSA complaint #10758801 — an unverified report by a vehicle owner.

ENGINE

LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT RE 2008 MINI COOPER (ATTN: JOSIAH MANZO) DOCUMENT IS HARD TO READ. *SMD THE CONSUMER STATED THE TIMING CHAIN. AS A RESULT, THE ENGINE TO FAIL.

NHTSA complaint #10731100 — an unverified report by a vehicle owner.

ENGINE

"DEATH RATTLE" NOISE COMING FROM ENGINE COMPARTMENT AS REPORTED BY MANY OTHERS ON ONLINE FORUMS. NOW ENGINE IS THROWING CODES INDICATING CRANKSHAFT OUT OF POSITION. OBVIOUS RELATED ISSUE TO A DEFECTIVE TIMING BELT OR TENSIONER. TOLD BY DEALERSHIP NOT A COVERED REPAIR, ALTHOUGH I'VE READ THAT SIMILAR REPAIR HAS BEEN COVERED BY MANUFACTURER FOR OTHERS AND FOR OTHER MODELS. AS THIS VEHICLE IS BEING DRIVEN BY MY YOUNG DAUGHTER, OUT OF STATE, I AM VERY CONCERNED ABOUT A COMPLETE ENGINE FAILURE WHILST SHE IS ON THE HIGHWAYS IN THE MOUNTAINS WHERE SHE LIVES, WITH THE POTENTIAL FOR TRAGIC CONSEQUENCES. PLEASE CONSIDER THIS ISSUE AS A SERIOUS POTENTIAL LIFE SAFETY ISSUE, AS A FAILURE AT HIGHWAYS SPEEDS COULD CERTAINLY ENDANGER NOT ONLY MY DAUGHTER, BUT THE LIVES OF OTHERS ON THE HIGHWAY. THANK YOU.

NHTSA complaint #10670355 — an unverified report by a vehicle owner.

ENGINE

LOW MILEAGE 2008 VEHICLE BEGAN MAKING LOUD NOISES FROM ENGINE COMPARTMENT. DIAGNOSED AS TIMING CHAIN/TENSIONER FAILURE. APPEARS TO A COMMON PROBLEM WITH THIS MODEL. ESTIMATED REPAIR COST OVER $2000. MECHANICS SAY NOT "IF" BUT "WHEN" THIS WILL HAPPEN TO ALL 2008 MCS. I BELIEVE THIS SHOULD BE REPAIRED ON A RECALL. VEHICLE CANNOT BE DRIVEN SAFELY UNTIL REPAIRED; DELAY WILL RESULT IN TOTAL ENGINE FAILURE.

NHTSA complaint #10669825 — an unverified report by a vehicle owner.

ENGINE

THE DEALER INFORMED ME MY OIL FEED LINES TO THE TURBO WERE LEAKING AND WOULD NEED TO BE REPLACED SOON. AFTER DOING SOME RESEARCH FOUND THE COUPLINGS THAT ATTACHES THESE LINES TO THE TURBO ARE DEFECTIVE. THERE ARE HUNDREDS OF COMPLAINTS ABOUT THIS ISSUE. THE DEALER SAYS THERE IS NOT A RECALL AND WILL COST APPROX: $1500.00. THE DEALER INSTALLED A TURBO SHIELD TO HELP WITH THE HEAT THAT IS CAUSING THE LINE TO PREMATURELY FAIL. WITH SO MANY EFFECTIVE SHOULDN'T MINI BE FIXING THIS ISSUE.

NHTSA complaint #10609322 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWN A 2008 MINI COOPER. THE CONTACT STATED THAT SHE STARTED THE ENGINE AND BEFORE SHE COULD SHIFT INTO GEAR, THE ENGINE MADE A LOUD TAPPING NOISE BEFORE IT STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 37,000. UPDATED 10/18/16*LJ UPDATED 10/27/16.

NHTSA complaint #10574656 — an unverified report by a vehicle owner.

ENGINE

STRETCHED TIMING CHAIN SEEMS TO BE A COMMON ISSUE WITH THIS MODEL, BUT RECALL IS ONLY ON THE TYPE S MODELS.

NHTSA complaint #10564066 — an unverified report by a vehicle owner.