2023 Nissan Rogue engine problems

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and the vehicle eventually stalled. The vehicle was towed to the local dealer to be diagnosed. The vehicle was diagnosed with turbo charger assembly failure. The contact was informed that the turbo charger assembly needed to be replaced. No further information was available. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 60,000.

NHTSA complaint #11757718 — an unverified report by a vehicle owner.

ENGINE

While driving my 2023 Nissan Rogue at approximately 65 mph, the vehicle suddenly lost power while in motion, creating a serious risk of a crash and placing my safety and the safety of other motorists at risk. There were no oil warning lights, malfunction indicator lights, or other warnings indicating an impending engine failure. After losing power, the vehicle would not restart and was completely undriveable. It had to be towed to an authorized Nissan dealership. The dealership initially advised that the no-start condition was related to the battery cable and required me to pay for a battery cable repair. My battery was only a few months old and independently tested as good. The vehicle remained inoperable after the battery cable repair, and I was subsequently informed that the engine had failed. During the oil-pan inspection, the Nissan technician documented the inspection by video and specifically identified metallic debris in the oil pan. The dealership also reported sludge. I retained the dealership’s video documentation. My vehicle is subject to a Nissan safety recall involving engine bearing degradation that can result in engine failure and loss of motive power. The recall remedy includes inspection of the oil pan for metallic debris and engine replacement when necessary. Despite the loss of power at approximately 65 mph, engine failure, and metallic debris identified by its own technician, Nissan denied the recall repair based on sludge. Nissan Consumer Affairs also denied my escalation. I am requesting NHTSA review Nissan’s refusal to perform the safety recall remedy and determine whether the recalled bearing condition caused or contributed to this failure. The vehicle remains at the Nissan dealership and is available for inspection.

NHTSA complaint #11757091 — an unverified report by a vehicle owner.

ENGINE

The vehicle experienced a catastrophic engine/motor failure. The engine became extremely loud/rattled and subsequently locked up, causing the vehicle to lose the ability to operate. The vehicle is currently being held for diagnosis/repair and should be available for inspection upon request. The vehicle experienced the failure while I was driving and left me stranded on a mountain. The vehicle lost its ability to operate, creating a significant safety risk because I was left stopped and without reliable transportation. A sudden engine failure while driving could also create a traffic hazard for the occupants and other motorists. Yes. The vehicle has been taken to a Nissan dealership for diagnosis following the failure. The vehicle experienced a catastrophic engine failure/lock-up. I am requesting the dealership’s written diagnostic report and confirmation of the exact failed component. The vehicle has been presented to Nissan for inspection and diagnosis. Nissan is currently involved in determining the cause of the engine failure. There has not been a police inspection that I am aware of. I am requesting that Nissan preserve and provide all diagnostic findings, photographs, technician notes, and repair records. Prior to the failure, the vehicle began exhibiting abnormal engine symptoms, including a loud/rattling engine noise and difficulty operating normally. The symptoms occurred shortly before the catastrophic failure on August 14, 2026. The vehicle subsequently became inoperable when the engine locked up. I am requesting the dealer’s diagnostic scan to determine whether any warning codes or messages were stored before or during the failure.

NHTSA complaint #11757135 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact stated that while driving out of town, the vehicle suddenly went into LIMP Mode. The accelerator pedal was depressed; however, the vehicle failed to exceed 70 MPH and decelerated unintendedly. The vehicle was driven approximately 30 MPH to the residence. The message “Engine Malfunction” was displayed, and the temperature gauge rose to HOT. The 4WD message was displayed. The vehicle was pulled over and inspected, and the contact became aware that one of the coolant reservoirs was empty, and coolant was added to the coolant reservoir. The odometer and infotainment screen also repeatedly turned on and off. The vehicle was towed to a local Nissan dealer, where it was diagnosed with a coolant leak in the engine, which caused the engine failure and turbocharger failure. The vehicle was not repaired. The vehicle was previously repaired under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling). The manufacturer opened a case regarding the failure but offered to cover only 30 percent of the cost of the repair. The failure mileage was approximately 95,600.

NHTSA complaint #11756881 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed variable compression ratio (VCR) actuator. The contact was informed that the VCR ratio actuator needed to be replaced. The vehicle was not repaired. The contact was informed that the repair was not covered under warranty or any unknown recall repair. The contact stated that the vehicle was used to transport her minor children. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 78,000.

NHTSA complaint #11755259 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the vehicle jerked with the temperature gauge level becoming elevated. The check engine warning light was illuminated. The vehicle was driven to the residence. The contact researched NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling); which was associated with the VIN. The dealer was not made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 63,296.

NHTSA complaint #11754907 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact stated that while the vehicle was at an independent mechanic for an oil change, the contact was informed of an engine oil leak, and the oil drain plug was replaced. The contact stated that while driving 65 MPH and depressing the accelerator pedal, the vehicle failed to accelerate as intended, with significant white smoke coming from the exhaust pipe. No warning light was illuminated. The contact pulled into a gas station and parked the vehicle. The vehicle was towed to a dealer, where it was diagnosed and determined that the engine had failed and needed to be replaced. The contact requested that the dealer perform the repair under NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling); however, the dealer declined to cover the repair under the recall due to insufficient oil change service records. The manufacturer was notified of the failure. The failure mileage was approximately 89,000.

NHTSA complaint #11754984 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2023 Nissan Rogue. The contact stated that upon starting the vehicle, the message “Power Low” was displayed, and the vehicle went into LIMP Mode. The vehicle was taken to a Walmart, and metal shavings were found in the oil. The vehicle was towed to the local dealer, and the contact was informed that the recall repair was declined. The oil light had not been reset within 18,000 miles. The contact stated that the oil was changed in May 2026. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 77,000.

NHTSA complaint #11755020 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact stated that upon starting the vehicle, the message “Power Low” was displayed, and the vehicle went into LIMP Mode. The vehicle was taken to a Walmart, and metal shavings were found in the oil. The vehicle was towed to the local dealer, and the contact was informed that the recall repair was declined. The oil light had not been reset within 18,000 miles. The contact stated that the oil was changed in May 2026. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 77,000.

NHTSA complaint #11755020 — an unverified report by a vehicle owner.

ENGINE

Transmission/ motor mount went out at 80k, the issue was going on before hand where my car would shake violently. I had been complaining about it for months they kept telling me it was normal, come to find out my transmission mount is going bad. Now they want to charge me 2k to replace it, after the engine was replaced.

NHTSA complaint #11754018 — an unverified report by a vehicle owner.

ENGINE

The vehicle was running when it overheated and started smoking from the gasket area, with no warning lights appearing on the dashboard; the car will not start now.

NHTSA complaint #11753194 — an unverified report by a vehicle owner.

ENGINE

Warning lights keep popping up then something will go wrong with the car. A CVT malfunction came up and wouldn’t allow me to put the car in park then after I turned the car off it went back to normal. More random lights will come up they will all be different problems with the engine or system then once car has been off for a few it would go back to normal

NHTSA complaint #11752921 — an unverified report by a vehicle owner.

ENGINE

Bought this car brand new from Nissan dealership 7/2023. Had issues with battery, sensor (causing car to go into low mode), and now complete engine failure all in a span of 7 months. Towed to dealership, told need new engine/turbo cost: $9,462. Reached out to Nissan Consumer Affairs for support as this car has less than 100k miles on it. Told nothing they can do-not on recall. Did online research and realized the same exact problems I had, was the same problems that was in the other recall cars. My car should have been on the recall list-not sure why not. Did Nissan just pick and choose which cars to add because it is ironic my car experienced the same problems. I had 3 major issues happen to the car in a span of 7 months this year. I was sold a bogus car from the dealership.

NHTSA complaint #11752778 — an unverified report by a vehicle owner.

ENGINE

Engine failure while driving, causing Engine Warning lights to come on as well as loss of acceleration. Safely was a concern due to incident occurred while on the interstate during rush hour traffic. Vehicle was towed to a Nissan dealership, who ran a diagnostic test and confirmed that the engine needs to be replaced. There were no Warning lights or messages prior to incident.

NHTSA complaint #11752846 — an unverified report by a vehicle owner.

ENGINE

Since purchasing my 2023 Nissan Rogue brand new, I have experienced severe drowsiness and an inability to breathe when driving in start-and-stop traffic. The issue peaked after a recent refueling stop, where raw gas fumes or exhaust heavily infiltrated the cabin. Immediately after driving away from the gas pump, I suffered acute chemical suffocation, gasping for air, experiencing body tremors, and nearly passing out. The symptoms instantly resolved when I switched to driving a different vehicle. This is a severe cabin fume infiltration defect that causes physical incapacitation while driving.

NHTSA complaint #11752516 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the message "Engine Malfunction - Power Reduced Service Now" was displayed and the vehicle stalled. The failure was a recurring failure. The vehicle was towed to the dealer. The dealer was contacted and diagnosed a failure with the EGR valve, EGR sensor, TC Boost Control Position Sensor, External USB Communication Dispense Sensor, air bags, and ISC system. The dealer repaired the EGR valve, but the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 5,000.

NHTSA complaint #11751778 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact stated that the vehicle stalled after idling and then attempting to accelerate. The failure was intermittent but became more frequent over time. While pulling out of a parking lot and turning into oncoming traffic, the transmission failed to shift gears properly or accelerate. The contact was able to coast into the next parking lot, shifted to park, activated the hazard lights, shifted to drive, and then waited until traffic cleared to continue driving. The contact stated that one mile later, while making a right turn, the vehicle stalled and failed to accelerate. The contact was able to coast off the road, shifted into park, and waited before shifting into drive and continuing driving. The failure had occurred on one occasion after refueling the vehicle. The vehicle was taken to the dealer three times. The vehicle was not diagnosed. The vehicle was not repaired. The contact stated that the vehicle was started, and the engine made a loud cranking sound. The vehicle was previously included in NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling), and the remedy, reprogramming the engine control module software, was completed. The manufacturer was not informed of the failure. The failure mileage was 38,759.

NHTSA complaint #11750500 — an unverified report by a vehicle owner.

ENGINE

My vehicle experienced severe stalling, rough idling, and a strong burning smell, which match the exact defect characteristics outlined in NHTSA Campaign 26V080 for Nissan main bearing failure (The year 2026 campaign is active). The vehicle was towed to a Nissan dealership, where technicians confirmed the engine requires complete replacement. However, the dealership is currently attempting to attribute the engine failure to 'coil intrusion' rather than the active bearing recall. The vehicle was purchased used in February 2026, just days after the official recall notification was sent to dealers. I am filing this complaint because the manufacturer is actively reviewing the claim and potentially bypassing a federally mandated safety remedy by blaming a consequential symptom of the engine failure. To specifically answer the above questions: The engine's main bearings failed/malfunctioned internally, causing catastrophic damage requiring a total engine replacement. The vehicle and its components are currently intact and available for inspection at the Nissan dealership service center. The vehicle suffered sudden, unexpected engine stalling while actively driving. This caused an immediate loss of motive power on a public roadway, creating a severe crash hazard and putting myself and surrounding drivers at risk of a rear-end collision. Yes. An authorized Nissan dealership service department has inspected the vehicle and confirmed that the engine has suffered a total mechanical failure and needs to be completely replaced. The vehicle is currently being inspected by an authorized Nissan dealership service center, and the case has been officially escalated to Nissan Corporate for a technical and warranty review. A strong burning smell and severe rough idling appeared a couple days prior to the incident. However, the check engine light did not illuminate or provide any warning until the moment the engine completely stalled on the highway.

NHTSA complaint #11750669 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2023 Nissan Rogue. The contact stated that while driving approximately 75 MPH, the vehicle was driving sluggishly and decelerated unintendedly. The vehicle failed to exceed 50 MPH while driving with the check engine warning light illuminated. The vehicle was taken to a certified mechanic, who diagnosed the vehicle with variable valve timing failure with DTC: P0012 displayed. The vehicle was not repaired. The failure reoccurred and the vehicle was taken to the dealer. The contact was informed that the VIN was not under recall. The vehicle was not diagnosed by the dealer; however, the Electromagnetic Compatibility (EMC) was reprogrammed, and the check engine warning light was no longer illuminated. The manufacturer was not made aware of the failure. The failure mileage was 76,000.

NHTSA complaint #11750198 — an unverified report by a vehicle owner.

ENGINE

Engine loss of power, exhaust producing white/gray smoke from tail pipe. Was stopped at stop light, pressed accelerator when light turned green. As I proceeded through the busy intersection, without warning, the engine lost power. As traffic was speeding up I was decelerating in front of a large tractor-trailer that nearly rear-ended me. Have not taken SUV to dealership or service center yet. No inspection has been completed. No warning, messages, or other symptoms appeared prior to the failure. The ADAS would shut off by itself.

NHTSA complaint #11750019 — an unverified report by a vehicle owner.

ENGINE

In XXX my engine turned off while I was on the highway. I went to star nissan in [XXX] and they changed the turbo hose. On XXX I got a check engine light. After 3 days the dealership said I needed a new turbocharger and the repair would cost $4100. I was told I was 9000 miles over my warranty. I currently have 69000 miles on my 2023 nissan rogue. According to the incomplete recall, engine bearings and low oil pressure could have caused my turbocharger to fail. The extended 10 year 120k mile warranty is not being honored by star nissan in bayside new york. I am not being told the diagnostics codes. I was told to either pay the $4100 or pick the car up. This engine almost killed me on the highway. Now that the engine fails again i'm being denied the repair. I am being told the turbocharger is not part of the long block, eventhough the recall clearly afects the turbocharged engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11749699 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact stated that while driving at an undisclosed speed, the check engine and CVT malfunction warning lights illuminated. The contact pulled over, and the vehicle was towed to the dealer, where it was determined that the electric oil pump had failed and needed to be replaced. The dealer replaced the electric oil pump; however, the contact was informed that the engine was potentially damaged due to the electric oil pump failure. The contact related the failure to NHTSA Campaign Number: 26V080000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure, and a case was filed. The vehicle was repaired. The failure mileage was approximately 32,000.

NHTSA complaint #11749494 — an unverified report by a vehicle owner.

ENGINE

"I am reporting federal safety recall non-compliance and fraudulent remedy execution by an authorized manufacturer franchise, Bella Nissan of Union City ([XXX]), regarding NHTSA Campaign 26V-080 (Nissan Recall Code R25E2) on my 2023 Nissan Rogue SL FWD.I am the original owner of this vehicle, which has an exceptionally low odometer reading of 12,142 miles. The vehicle is used as primary medical transport for my [XXX] special needs son, who has a severe traumatic brain injury, cerebral palsy, and partial paralysis.On July 1st, 2026, I brought the vehicle to the dealership explicitly to resolve the critical engine bearing seizure and fire-risk recall. The dealership quoted a 3-hour repair window. Instead, the dealer rushed the vehicle through in 43 minutes total (Start: 12:52, End: 13:35) and recorded an impossible 1-mile odometer difference (Mileage In: 12,142, Mileage Out: 12,143). A single-mile drive is physically incapable of heating the engine oil to the high operating temperatures required by Nissan’s official engineering service bulletin to diagnose defective engine bearings.The dealership falsely certified to federal databases that this fire-risk vehicle was legally remedied, cleared the active safety flag on my consumer app, and billed the manufacturer's warranty department for work never performed. They also billed for a multi-point inspection and complimentary detail that were completely falsified, returning the car with an untouched, dirty windshield. The service advisor then actively withheld the paperwork I physically initialed at pickup, forcing me to take an internal 'Pre-Invoice Audit Copy' to conceal the non-compliant metrics.By rubber-stamping this safety recall on paper without executing the mandatory high-temperature diagnostic drive loop, this dealership has left an unverified fire-risk asset on the road, actively endangering a medically fragile family. I am refusing any future repair loops i want a buyback INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)

NHTSA complaint #11748287 — an unverified report by a vehicle owner.

ENGINE

All of a sudden, while driving, the car was not picking up speed. I parked and noticed the car was idling very roughly. It was though the car was going to just stop when I did start driving again. The check engine light came on while I was driving in the car would not pick up speed. It was still really a rough idle to the car when I turned corners it was like the car was going to stop and it would not go past 35 mph. I immediately drove into the Nissan dealership near me. A week later after dropping it off, I was told the engine had failed.

NHTSA complaint #11747591 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Nissan Rogue. The contact received notification of NHTSA Campaign Number: 25V437000 (Engine and Engine Cooling); and the vehicle was taken to a dealer to be repaired. The contact stated that on several occasions when the vehicle was started, there was a rumbling sound coming from the engine compartment. Additionally, while driving on several occasions at undisclosed speeds, the vehicle lost power. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 68,000.

NHTSA complaint #11746200 — an unverified report by a vehicle owner.

ENGINE

Recalls addressed yet engine continued to have ongoing problems. As of today Nissan service said the transmission needs full replacement yet takes zero responsibility for the problem. Car and Engine has continually had problems of cutting out and lagging. Now they are denying this has any correlation to their existing engine problems. This is a major ongoing safety problem due to the fact that when driving the engine stalls and cuts out. There is no consistency of the problem. It just happens. Nissan needs to take responsibility telling an owner to replace a transmission in hopes that this will address an engine problem that has gone on for two years straight is not the answer. They need to understand the dangers of any driving situation where an engine stalls/stops. It’s amazing with this existing problem that nobody has been injured on record yet! This needs to change!

NHTSA complaint #11746342 — an unverified report by a vehicle owner.

ENGINE

I am filing this formal complaint to request immediate NHTSA intervention regarding Nissan North America’s bad-faith denial of critical safety recall repairs on my 2023 Nissan Rogue. Both Nissan Consumer Affairs and my local Nissan dealership service department are actively misdiagnosing a severe, well-documented engine defect as a "secondary issue" to avoid their legal obligations under NHTSA Recall Campaigns 26V-080 and 26V-081. By forcing me to drive a vehicle that exhibits violent engine shaking and severe, abnormal mechanical noise, Nissan is placing my safety and the safety of the motoring public at immediate risk. They are insisting that I continue operating a compromised vehicle until a catastrophic, total engine failure occurs on the highway. Detailed Timeline of Events and Defect Manifestation June 2025 (Vehicle Under Factory Warranty): The vehicle began exhibiting abnormal, excessively loud engine noises. I presented the vehicle to the authorized Nissan dealership for diagnosis. The service department dismissed the issue, claiming they "could not replicate" the noise, and released the vehicle back to me without repair. I captured digital video and audio recordings of the defect at this time to preserve empirical evidence. February 2026: NHTSA and Nissan announced recalls 26V-080 and 26V-081 specifically targeting the 1.5L and 2.0L VC-Turbo engines for main bearing failure, which causes violent engine shaking, severe noise, knocking, and sudden loss of motive power. [XXX]: As the engine noises worsened and progressed into violent engine shaking, I brought the Rogue back to the dealership service department. They admitted the vehicle was shaking excessively but claimed it was a "secondary issue" caused by a failing Exhaust Gas Recirculation (EGR) valve. Manufactured/dealership explicitly stated that because they did not yet find metal shavings in the oil pan, they would not authorize the recall remedy. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11745297 — an unverified report by a vehicle owner.

ENGINE

After taking my 2023.5 Rogue S in for the recall repair (replace sensor and update ECM) I noticed soon after that a knock has started to appear. It is happening any time the engine is under load, especially at lower RPMs. I have changed where I get fuel and that has not resolved the issue, I got my oil change done about 2 weeks ago and the knock is still there

NHTSA complaint #11744087 — an unverified report by a vehicle owner.