2004 Nissan Titan suspension problems

SUSPENSION

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT ON TWO SEPARATE OCCASIONS, THE CV AXLE LOCATED ON THE FRONT DIFFERENTIAL DETACHED FROM THE VEHICLE WHILE DRIVING AT VARIOUS SPEEDS, WITHOUT WARNING. THE CONTACT HAD YET TO TAKE THE VEHICLE TO BE SERVICED OR DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED HIM THAT THERE WAS NO RECALL ON THE VEHICLE. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS OUT OF WARRANTY AND NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

NHTSA complaint #11352824 — an unverified report by a vehicle owner.

SUSPENSION

SHACKLE ON RIGHT SIDE PEELED OFF THE FRAME STUD AND DROVE THE SPRING AND SHACKLE ASSEMBLY THROUGH THE TRUCK BED

NHTSA complaint #11062891 — an unverified report by a vehicle owner.

SUSPENSION:REAR

WENT IN FOR A ROUTINE OIL CHANGE AND WAS INFORMED OF A REAR AXLE SEAL LEAK. I DID SOME RESEARCH ONLINE AND HAVE SEEN THAT IS A VERY COMMON ISSUE WITH NISSAN TITANS AND MORE SPECIFICALLY THE 2004 NISSAN TITANS. *BF

NHTSA complaint #11062582 — an unverified report by a vehicle owner.

SUSPENSION:REAR

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. WHILE THE VEHICLE WAS PARKED, AN OIL LEAK WAS DISCOVERED AT THE REAR OF THE VEHICLE. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 172,000.

NHTSA complaint #10785342 — an unverified report by a vehicle owner.

SUSPENSION

THIS WILL BE THE 3RD REAR DIFFERENTIAL ON THIS TRUCK. THE FIRST BLEW ON WARRANTY AT APPROX 10K MILES. NOW WITH 56K MILES THE 2ND DANA REAR AXLE HAS BLOWN. I DON'T OFF ROAD AND TOW ONLY A MOTORCYCLE TRAILER. THIS IS OBSCENE, TIME CONSUMING AND VERY COSTLY ($3,630.00) TO FIX AND DAYS WAITING AWAY FROM HOME. THIS ISN'T RIGHT.

NHTSA complaint #10630229 — an unverified report by a vehicle owner.

SUSPENSION

THIS IS THE SECOND TIME IN OVER SEVERAL MONTHS THAT MY DRIVER SIDE DRIVE AXLE FOR MY 4X4 HAS PULLED ITS SELF OUT. IT WAS FIXED ONCE ON MY DIME AND IS NOW GOING TO BE FIXED ON MY DIME AGAIN IT IS A DANGEROUS FAILURE THAT COULD CAUSE MY SUSPENSION TO LOCK UP AN RIP MY WHEEL OFF THEN LEADING TO A SERIOUS ACCIDENT. IT NEEDS TO BE ADDRESSED AND THE NHTSA HAS DONE NOTHING TO PURSUE THIS. ANOTHER PROBLEM THAT NISSAN WILL NOT COVER IS THE REAR AXLE SEALS THAT BLOW OUT DUE TO A FAULTY DESIGN WHICH MAY ALSO LEAD TO A SERIOUS ACCIDENT, THEY WILL NOT ADDRESS ANY OF THESE ISSUES UNDER A RECALL AN THERE ARE THOUSANDS OF PEOPLE THAT ARE SUFFERING FROM THESE ISSUES FROM 04-010 FOR THE AXLE SEALS AND MODEL YEARS 04-08 FOR THE AXLE SHAFT PULLING OUT FROM THE 4X4 CAUSING SERIOUS DAMAGE TO INTERNAL AND EXTERNAL PARTS. THIS NEEDS TO BE ADDRESSED AN THE NHTSA IS DOING NOTHING ABOUT IT.

NHTSA complaint #10532757 — an unverified report by a vehicle owner.

SUSPENSION

FOURTH RIGHT REAR AXLE SEAL. SECOND IN TWO WEEKS.

NHTSA complaint #10512109 — an unverified report by a vehicle owner.

SUSPENSION

CATASTROPHIC FAILURE OF THE LEAF SPRING ON DRIVER SIDE REAR OF THE VEHICLE.

NHTSA complaint #10509804 — an unverified report by a vehicle owner.

SUSPENSION

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT AND REAR DIFFERENTIAL AND AXLES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE AND CURRENT MILEAGE WAS 138,000...UPDATED 03/18/13 *BF THE CONSUMER STATED ALSO THE REAR END WAS LOCKING UP. UPDATED 04/26/2013

NHTSA complaint #10497889 — an unverified report by a vehicle owner.

SUSPENSION

WHILE REPLACING LIFETIME WARRANTIED SUSPENSION WHICH WAS NOT HONORED BY NISSAN OR TENNECO, I FOUND THE REAR PINION SEAL TO BE LEAKING SEVERELY, AND REAR AXLE SEAL LEAKING IN WHEEL ASSEMBLY. POSSIBLE SOURCE OF "TICKING" NOISE FROM DIFFERENTIAL, WHICH UNTIL THEN I THOUGHT WERE EXHAUST HEAT SHIELDS. THIS CONDITION COULD CAUSE CATASTROPHIC DRIVETRAIN FAILURE WHILE VEHICLE IS IN MOTION. THE FLUID LEAKING FROM AXLE SEAL CAN REDUCE EFFECTIVENESS OF BRAKING COMPONENTS. OTHER OWNERS HAVE DESCRIBED INADEQUATE ENGINEERING & POSSIBLE USE OF SUBSTANDARD DIFFERENTIAL MATERIALS & COMPONENTS ALONG WITH AXLE VENT ASSEMBLIES WHICH COULD CREATE INTERNAL PRESSURE CONDITIONS THAT COULD CAUSE SEALS TO FAIL.

NHTSA complaint #10474239 — an unverified report by a vehicle owner.

SUSPENSION

FAILURE OF FRONT CONTROL ARMS, ACCORDING TO NISSAN WEBSITE (MANY OTHER VEHICLES WERE RECALLED FOR SAME, NOT MINE) THIS COULD RESULT IN COLLISION. MECHANIC STATED THE WHEEL WOULD COME OFF WITH FAILURE. NISSAN DEALERSHIP DISCOVERED THE WELD WAS FAILING AND TOLD ME THEY HAD TO BE REPLACED, BUT THAT WHILE 1800+ VEHICLES WERE SHOWN TO BE AFFECTED BY THIS ISSUE, MY VIN NUMBER WAS NOT ON LIST. NISSAN NEEDS TO EXPAND THEIR RECALL.

NHTSA complaint #10440406 — an unverified report by a vehicle owner.

SUSPENSION

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED AT THE DEALER FOR AN UNRELATED ISSUE, THE DEALER NOTICED THAT BOTH FRONT LOWER CONTROL ARMS WERE DAMAGED. THE DEALER STATED TO THE CONTACT THAT THE VEHICLE WAS UNSAFE TO DRIVE DUE TO THE DAMAGE OF THE FRONT LOWER CONTROL ARMS AND THE POSSIBILITY OF A CRASH OCCURRING. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC TO HAVE THE FRONT LOWER CONTROL ARMS REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN I.D. NUMBER: 10E019000 (SUSPENSION:FRONT:CONTROL ARM:LOWER ARM) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 60,000.

NHTSA complaint #10440415 — an unverified report by a vehicle owner.

SUSPENSION

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT WAS DRIVING 35 MPH AND NOTICED AN ABNORMAL NOISE FROM THE REAR OF THE VEHICLE. THE CONTACT INSPECTED THE FAILURE AND DISCOVERED THAT THE REAR DIFFERENTIAL SEALS AND THE GEAR BOX WERE LEAKING AT THE BRAKE CYLINDER. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE ENTIRE REAL DIFFERENTIAL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO ADVISED THAT THEY WOULD RETURN HIS CALL AT A LATER DATE. THE CONTACT ATTEMPTED TO SPEAK WITH THE MANUFACTURER FOR TWO WEEKS BUT THEY WOULD NOT RETURN HIS CALL. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 53,000.

NHTSA complaint #10438704 — an unverified report by a vehicle owner.

SUSPENSION

THE REAR AXLE SEALS ARE LEAKING AND HAS CAUSED MY REAR BRAKES TO SLIP DUE TO THE DIFFERENTIAL OIL GETTING ON MY BRAKE PADS AND ROTORS. THIS IS MY SECOND ENCOUNTER OF THIS PROBLEM AND NISSAN STILL REFUSES TO DO ANYTHING ABOUT IT.

NHTSA complaint #10434396 — an unverified report by a vehicle owner.

SUSPENSION

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THE REAR AXLE SEAL LEAKED AND BEGAN SPRAYING DIFFERENTIAL FLUID ON THE BRAKES WHILE DRIVING 70 MPH. WHEN THE FAILURE OCCURRED THE BRAKING DISTANCE INCREASED ON THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A DEALER WHO STATED THE REAR AXLE SEAL LEAK WAS VERY COMMON. THE DEALER STATED THE ENTIRE REAR AXLE NEEDED TO BE REPLACED IN ORDER TO REMEDY THE FAILURE. THE CONTACT DID NOT REPLACE THE REAR AXLE. THE FAILURE MILEAGE WAS 75,000.

NHTSA complaint #10434062 — an unverified report by a vehicle owner.

SUSPENSION:REAR

REAR AXLE SEAL LEAKING AT 60,000 MILES, CAUSING REAR BRAKES & PARKING BRAKE NOT TO WORK WELL.

NHTSA complaint #10421374 — an unverified report by a vehicle owner.

SUSPENSION:REAR

LEFT REAR AXLE SEAL LEAKING.

NHTSA complaint #10411623 — an unverified report by a vehicle owner.

SUSPENSION:REAR

2004 NISSAN TITAN WITH 72,000 MILES NEEDS REAR END AXLE REPLACED. I HAVE FOUND MANY OTHER COMPLAINTS ON SAME TOPIC AND VEHICLE YEAR, MAKE MODEL.

NHTSA complaint #10410856 — an unverified report by a vehicle owner.

SUSPENSION:REAR

TL*THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE REAR DIFFERENTIAL FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE ENTIRE REAR AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 59,800.

NHTSA complaint #10379686 — an unverified report by a vehicle owner.

SUSPENSION

THE REAR UNIVERSAL JOINT HAS FAILED. I TOOK TO THE VEHICLE TO A MECHANIC FOR INSPECTION ON OR ABOUT 9/2/10 AND I WAS TOLD THAT THE U-JOINT HAD 3 BIG PIECES OF METAL LAYING IN THE BOTTOM OF THE HOUSING. I THEN HAD THE VEHICLE TOWED TO HUBLER NISSAN IN INDIANAPOLIS, IN AND THE SERVICE DEPARTMENT CONFIRMED THE PREVIOUS FINDINGS. HUBLER STATED THAT THEY WOULD HAVE TO REPLACE THE COMPLETE REAR AXLE. THE APPROX. COST WOULD BE $2,500-$3,000.

NHTSA complaint #10356791 — an unverified report by a vehicle owner.

SUSPENSION:REAR

WHILE LOADING TRUCK FOR A VACATION TRIP, I NOTICED A LARGE BULGE COMING UP THROUGH THE TRUCK BED IN THE LEFT REAR PORTION. UPON FURTHER INSPECTION, THE LEFT REAR SHACKLE HOLDING HOLDING THE LEAF SPRING TO THE FRAME SNAPPED IN HALF. THE TRUCK IS A GARAGE KEPT, 35,000 MILE LIMITED PERSONAL USE VEHICLE. IF I HAD NOT BEEN GOING AWAY, THE SPRING WOULD HAVE PUSHED ITS WAY THROUGH THE BED.

NHTSA complaint #10349747 — an unverified report by a vehicle owner.

SUSPENSION:REAR

TL*THE CONTACT OWNS A 2004 NISSAN TITAN. THE RIGHT SIDE REAR SPRING HANGER FAILED MAY 18, 2010 AND THE LEFT SIDE REAR SPRING HANGER FAILED JUNE 6, 2010. THE DEALER REPLACED THE HANGERS BUT NOT WITH A STRONGER ONE. THE CONTACT WAS AFRAID THE HANGERS MIGHT FAIL AGAIN. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT; THE MANUFACTURER ALSO ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALERSHIP BUT THAT THEY WOULD NOT ASSIST IN REPAIRS AS THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE FAILURE MILEAGE WAS 28,462. THE CURRENT MILEAGE WAS 29,168.

NHTSA complaint #10335530 — an unverified report by a vehicle owner.

SUSPENSION:REAR

THE LEAF SPRING BOLT BROKE AND CAUSED THE REAR AXEL LEAF SPRING TO SHOOT THROUGH THE BED OF THE TRUCK. ON INSPECTION THE OTHER LEAF SPRING WAS READY TO ALSO BREAK. THIS WAS DISCOVERED WHILE TURNING A CORNER ON THE ROAD. PASSENGER AND DRIVER SIDE SHACKLE, CLIPS, SPRING ASSEMBLE, BOLTS NEEDED TO BE REPLACED. ALL PARTS ON BOTH SIDES OF THE TRUCK NEEDED TO BE REPLACED SINCE THE OTHER ONE WAS FOUND TO BE DEFECTIVE ALSO. ALL PARTS WERE REPLACED WITH NEW PARTS AT OUR EXPENSE. NISSAN STATED IT WAS NORMAL WEAR AND TEAR. HOWEVER, SEVERAL MASTER MECHANICS STATED THEY HAVE NEVER SEEN THIS HAPPEN.

NHTSA complaint #10331122 — an unverified report by a vehicle owner.

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:SHACKLE

TL * THE CONTACT OWNS A 2004 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT HEARD A LOUD UNUSUAL NOISE. HE THEN MOVED THE VEHICLE FROM THE ROAD AND UPON FURTHER INSPECTION, NOTICED THAT THE LEAF SPRINGS WERE FRACTURED THROUGH THE BED OF THE VEHICLE. THE FAILURE CAUSED A DEFECT IN THE SUSPENSION AND WAS TAKEN TO THE DEALER. THE DEALER REPLACED THE LEFT AND RIGHT SHACKLES TO CORRECT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000 AND THE CURRENT MILEAGE WAS 97,200.

NHTSA complaint #10327782 — an unverified report by a vehicle owner.

SUSPENSION:REAR

NORMAL DRIVING CONDITIONS AND HABITS 2004 NISSAN TITAN CREW CAB PRE-MATURE FAILURE OF REAR AXLE SEALS BOTH LEFT HAND & RIGHT HAND REAR AXLE SEALS ARE LEAKING @ 54,000 MILES. REAR DIFFERENTIAL OIL ON INBOARD SIDES OF BRAKE DISCS DUE TO LEAK/S CAUSING REDUCED BRAKING ACTION. SEALS WILL BE REPLACED POSSIBLY DICTATING AXLE REPLACEMENT BECAUSE NISSAN HAS NO TOOLING TO REMOVE THE AXLE BEARINGS.

NHTSA complaint #10292563 — an unverified report by a vehicle owner.

SUSPENSION:REAR

PULLED SLOWLY FROM A MCDONALD'S DRIVE THROUGH INTO HALTED TRAFFIC (RED LIGHT). AS I PULLED OUT OF DRIVE THROUGH, HEARD BIG BANG AND FELT LIKE I HAD BEEN REAR-ENDED. TRIED TO ACCELERATE, TRUCK WOULD NOT MOVE, AND I COULD HEAR AN AUDIBLE CLICKING NOISE AT WHAT WOULD HAVE BEEN TIRE ROTATION SPEED. VEHICLE TOWED TO DEALER. CHARGED $3,798.22 TO REPLACE REAR DIFFERENTIAL. WAITING TO HEAR BACK FORM NISSAN TO SEE IF THEY WILL REIMBURSE FOR AT LEAST COST OF PART(3223.00.)

NHTSA complaint #10290557 — an unverified report by a vehicle owner.

SUSPENSION:REAR

2004 NISSAN TITAN REAR AXLE DIFFERENTIAL IS OUT 108, 000 MILES. WATER WAS FOUND IN CASE DUE TO SEALS GOING OUT DUE TO BREATHER HOSE CLOGGING AND NOT WORKING CORRECTLY.

NHTSA complaint #10289749 — an unverified report by a vehicle owner.

SUSPENSION

2004 NISSAN TITAN; REAR AXLE SEAL LEAKING: 1. IN SHOP FOR TIRE ROTATION, MECHANIC SAW FLUID FROM REAR AXLE ON INSIDE OF MY WHEELS. 2. NOT SURE HOW LONGS ITS BEEN LEAKING. APPEARS TO BE AN ON GOING PROBLEM FOR OTHER NISSAN TITAN OWNERS (MULTIPLE SEAL REPLACEMENTS). CONSEQUENCES ARE FLUID CAN LEAK ONTO BRAKES CAUSING A BRAKING FAILURE WHICH COULD RESULT IN A CRASH AND POSSIBLE DEATH. 3. NOTHING DONE TO CORRECT THE PROBLEM. CONTACTING MECHANIC TODAY. *NISSAN NEEDS A RECALL ON THIS*

NHTSA complaint #10283054 — an unverified report by a vehicle owner.

SUSPENSION:REAR

REAR AXLE SEAL FAILURE ON NISSAN 04 TITAN COULD CAUSE BRAKE FAILURE BY LEAKING ON PAD AND ROTOR.

NHTSA complaint #10282915 — an unverified report by a vehicle owner.

SUSPENSION:REAR

REAR SHACKLE IN 2004-2008 NISSAN TITAN IS WEAK DESIGN, PRONE TO FAILURE. I HAVE PROOF OF SEVERAL DOCUMENTED CASES IN WHICH THE REAR SHACKLE UNFOLDS AND THE LEAF SPRING SLAMS THROUGH THE BED OF THE TRUCK, WHICH CAN RESULT IN SUDDEN LOSS OF CONTROL. IT HAS HAPPENED DURING NORMAL DRIVING CONDITIONS, AS WELL AS WHEN TOWING, OFF-ROADING, ETC. TO CORRECT THE PROBLEM, BEFORE IT HAPPENS, ALL THAT NEEDS TO HAPPEN IS TO REPLACE THE SHACKLES BEFORE THEY FAIL AND BECOME A SAFETY CONCERN. IF THE SHACKLE FAILS, IT MUST BE REPLACED, AND THE ENTIRE SUSPENSION SYSTEM NEEDS TO BE INSPECTED FOR SAFETY, AND THE BED MUST BE REPLACED.

NHTSA complaint #10280177 — an unverified report by a vehicle owner.