2004 Nissan Titan transmission problems

POWER TRAIN

The contact owns a 2004 Nissan Titan. The contact stated that while the vehicle was parked, the vehicle rolled forward, causing the vehicle to roll into a rock, and damaging the transmission. Additionally, the air bag warning lights illuminated, and the seat beats locked. The vehicle was towed to the residence. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 180,000.

NHTSA complaint #11498556 — an unverified report by a vehicle owner.

POWER TRAIN

I purchased this truck on 04/05/18 from Harbor motors Lihue Kauai, and not even a week into having this truck it started acting up, overheating, the truck wouldn't turn over, suspensions, the four-wheel-drive wouldn't disengage, when you turn the key to start the vehicle it would make a clicking noise before starting, the AC would work when it wanted to, and the transmission and engine started knocking. The next week I went running errands and when I pulled out of my yard the truck started jerking then pressed the gas and it revved really high before slamming into drive. Since then I haven't driven the truck. And today it looks like someone just smashed into the front driver light to the side and smashed it while being parked at the place I purchased the truck from. I've continuously asked for help with little to no help at all. The truck is no longer drivable and I'm still making payments on it. The lights on the dashboard has the Check enigine light on, snd the ABS

NHTSA complaint #11421518 — an unverified report by a vehicle owner.

POWER TRAIN

I WAS DIAGNOSING A METAL ON METAL SOUND COMING FROM MY 4 WHEEL DRIVE NISSAN TITAN AND FOUND THAT THE HALF SHAFT WAS COMING OUT OF THE FRONT DIFFERENTIAL. I CALLED A NISSAN DEALERSHIP IN UTAH AND WAS INFORMED THAT THIS WAS A HUGE PROBLEM WITH EARLY MODEL TITANS. THE TECH SAID HE HAD REPAIRED MANY TITANS WITH THE SAME PROBLEM. HE SAID IT WAS DUE TO A C CLIP THAT FAILS AND ALLOWS THE GEARS TO GET CHEWED UP IN THE DIFFERENTIAL. I LOOKED ONLINE TO SEE IF THERE HAD BEEN ANY RECALLS ON THIS AND FOUND THERE HAD NOT BEEN. I THEN CALLED NISSAN TITAN AND THEY INFORMED ME OF THE SAME AND GUIDED ME TO THIS WEBSITE. THIS SEEM LIKE A HUGE ISSUE THAT EITHER NOT BEEN REPORTED. THIS SEEMS LIKE IT WOULD LEAVE PEOPLE WHO BOUGHT THIS FOR SNOWY AREAS OR OFFROADING IN AN UNSAFE SITUATION WHEN THEIR 4 WHEEL DRIVE FAILS OR LOCKS UP. IN CERTAIN AREAS IN UTAH, WE ARE REQUIRED TO HAVE CHAINS OR 4 WHEEL DRIVE IN CERTAIN AREAS. WITH THE FAILURE OF A C CLIP AND THE GEARS GETTING CHEWED TO PIECES THIS SEEMS LIKE IT WOULD CAUSE HUGE SAFETY ISSUES, NOT TO MENTION COSTS TO CONSUMERS OVER A UNSOUND DESIGN.

NHTSA complaint #11312263 — an unverified report by a vehicle owner.

POWER TRAIN

WHILST DRIVING IN BAD WEATHER I HAD MY 4 WHEEL DRIVE ENGAGED. I WAS DRIVING 5 MILES AN HOUR ON A STRAIGHT GRAVEL ROAD, WHEN I STARTED HEARING A GRINDING NOISE. BEFORE I COULD GET STOPPED SAFELY TO SEE WHAT THE ISSUE WAS THERE WAS A LARGE THUD AND MY ENTIRE TRUCK SHOOK. IT WAS THEN POURING GEAR LUBRICANT OUT OF MY FRONT DIFFERENTIAL. AFTER TAKING THE TRUCK APART TO FIND THE DAMAGE I DISCOVERED THE AXLE SHAFT (NISSAN PART NO.: 38220-8S11A) HAD BEEN STRIPPED OF ITS SPLINES ON THE END. THE PART LOOKS AS IF IT WAS MACHINES PERFECTLY CYLINDRICAL. THE METAL SHAVINGS FROM THE SHAFT SLIGHTLY MARRED UP THE SEALS SO I REPLACED THE SEALS AND SHAFT, SPIDER GEARS SEEMED OKAY TO REUSE.

NHTSA complaint #11183327 — an unverified report by a vehicle owner.

POWER TRAIN

THE DRIVERS SIDE REAR AXLE BROKE WHILE TRAVELING 70 MPH UP 75 IN KY WITH MY WHOLE FAMILY IN THE TRUCK ON THE WAY HOME FROM VACATION IT LOOKS LIKE THE AXLE SEALS STARTED LEAKING AND THEN IT LOCKED UP FOR A SPLIT SECOND AND LOST ALL ABILITY TO PULL ITSELF ALL THE AXLES AND SEALS HAVE ALREADY BEEN REPLACED MULTIPLE TIMES AND IT'S ABOUT TIME FOR NISSAN TO START TAKING THE HIT INSTEAD OF THE VEHICLE OWNERS

NHTSA complaint #11120916 — an unverified report by a vehicle owner.

POWER TRAIN

FRONT RIGHT AXLE POPS OUT OF THE DIFFERENTIAL, BAD C-CLIP. NUMEROUS COMPLAINTS NOTED HERE AND AT VARIOUS TITAN FORUMS.

NHTSA complaint #11089903 — an unverified report by a vehicle owner.

POWER TRAIN

WENT IN FOR A ROUTINE OIL CHANGE AND WAS INFORMED OF A REAR AXLE SEAL LEAK. I DID SOME RESEARCH ONLINE AND HAVE SEEN THAT IS A VERY COMMON ISSUE WITH NISSAN TITANS AND MORE SPECIFICALLY THE 2004 NISSAN TITANS. *BF

NHTSA complaint #11062582 — an unverified report by a vehicle owner.

POWER TRAIN

FROM DIFFERENTIAL FAILURE AND C CLIP FAILURE EJECTING FRONT DRIVE AXLE. LEAKING REAR AXLE SEALS AS WELL

NHTSA complaint #11048447 — an unverified report by a vehicle owner.

POWER TRAIN

2004 NISSAN TITAN PASSENGERS SIDE AXEL SHAFT IS SLIDING OUT OF DIFFERENTIAL AND MY 4WD WILL NOT WORK. DIFFERENTIAL FLUID IS LEAKING EVERYWHERE. HAVE READ MANY COMPLAINTS ABOUT THE SAME PROBLEM BY OTHER TITAN OWNERS. THIS IS UNSAFE ESPECIALLY IF THE SHAFT WORKS ITS WAY ALL THE WAY OUT. DO THE RIGHT THING NISSAN!! ISSUE A RECALL!!

NHTSA complaint #11033442 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE CHANGING THE REAR DIFFERENTIAL FLUID, THE MAGNET/DRAIN PLUG HAD A BROKEN PIECE OF METAL ATTACHED TO IT. I CAN ONLY ASSUME IT'S PART OF THE GEARS INSIDE. I HAVE NO IDEA WHEN THE PIECE BROKE BUT I HAVE READ THAT OTHER TITAN OWNERS HAVE HAD SIMILAR ISSUES. THOSE GEARS ARE A BIG PART OF THE TRUCK AND SHOULD NOT BREAK EASY. MY TRUCK IS 4X4 SO I'D ASSUME THE GEARS WOULD BE RELIABLE. I BOUGHT MY TRUCK USED WITH APROX 275K MILES SO NOT SURE WHEN PART BROKE.

NHTSA complaint #11019001 — an unverified report by a vehicle owner.

POWER TRAIN

THE FRONT AXEL SEPARATED AT 75,000 MILES. DEALER STATED IT WOULD COST $1,600 TO REPAIR. I WENT ONLINE TO CHECK PRICING AND IF OTHERS ARE HAVING THE SAME PROBLEM AND THEY ARE. HTTP://WWW.TITANTALK.COM/FORUMS/TITAN-PROBLEMS-DEALER-SERVICE/68142-FRONT-AXLE-FAILER-THREAD-14.HTML

NHTSA complaint #10981498 — an unverified report by a vehicle owner.

POWER TRAIN

DRIVING AND 4 WHEEL DRIVE KICKED OUT. TOOK TO THE SHOP AND THEY SAID PASS AXLE C CLIP CAME OFF.

NHTSA complaint #10980379 — an unverified report by a vehicle owner.

POWER TRAIN

FRONT LEFT AXLE SLID OUT FROM DIFFERENTIAL. THE RETAINING C-CLIP ON THE AXLE WAS INTACT BUT DID NOT RETAIN THE AXLE. THIS HAS THE POTENTIAL TO CAUSE A CATASTROPHIC FAILURE OF THE FRONT DIFFERENTIAL. THIS WAS FOUND WHEN THE VEHICLE WAS STATIONARY. THE VEHICLE LEAKED FLUID ON THE GARAGE FLOOR, UPON INVESTIGATING THE LEAK THE FAILURE WAS IDENTIFIED. OTHERWISE THE VEHICLE WAS OPERATING NORMALLY WITH NO INDICATION OF THE FAILURE.

NHTSA complaint #10929755 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE 2004 TITAN 100,000 MILES, BOTH BACK SEALS LEAKING, HAD TO REPLACE ENTIRE BACK OF THE TRUCK. THIS SHOULD BE COVERED BY NISSAN UNDER A RECALL BUT ISN'T.

NHTSA complaint #10928840 — an unverified report by a vehicle owner.

POWER TRAIN

WAS COMING FROM DAUGHTERS GAME AND I MADE A LEFT TURN OUTTA PARKING LOT ALL OF A SUDDEN A HEAR A NOISE AND THEN GRINDING. I INSPECTED BRAKES AND UNDERNEATH VEHICLE I NOTICED FLUID ALL OVER FRONT DIFF . I GOT UNDERNEATH GRABBED MY DRIVERS SIDE AXLE AND SHOOK IT . IT CAME APART AND WAS COMING OUT OF DIFF. A MONTH EARLIER I NOTICED REAR DIFF HAD OIL ALL OVER IT AND OIL WAS LEAKING OUT OF REAR PINION SEAL AND BOTH REAR AXLE SEALS , DUE TO AXLE BREATHER FAILURE. I HAVE NEVER WENT OFF-ROADING OR BEAT THIS TRUCK . I AM ALSO EXPERIENCING GAS SHOOTING BACK OUT OF MY FUEL TANK FILLER TUBE . I HAVE HAD MY VEHICLE TO LOCAL DEALER 2 OR 3 TIMES REGARDING THIS ISSUE AND IT SEEMS AS IF IT'S A GUESSING GAME . I HAVE SPENT OVER 300 BUCKS THERE AND MY PROBLEM STILL EXISTS . THEN THEY GUESS AGAIN AND SAYS ITS SOMETHING ELSE. I KNOW FOR SURE THIS VEHICLE HAS HAD A REAR END OR REAR DIFF ALREADY PUT IN WITH VERY VERY LOW MILES , WITH 1 ST OWNER . I AM BEING TOLD THAT MY LAST ISSUE WITH FRONT AXLE WAS C CLIP HOLDING AXLE IN FAILED AND MAY HAVE RUINED MY FRONT DIFF , I TRAVELED NO MORE THAN 2 MILES BEFORE I HEARD NOISE AND I'M LOOKING AT A 1900 PART NOT INCLUDING LABOR .

NHTSA complaint #10919736 — an unverified report by a vehicle owner.

POWER TRAIN

REAR AXLE SEAL LEAKS ARE A RECURRING PROBLEM ON THIS VEHICLE. I HAVE HAD MINE REPLACED 4 TIMES AT VARIOUS POINTS OVER THE PAST 12 YEARS AND THEY ARE LEAKING AGAIN. IT HAS BEEN 12 MONTHS SINCE THE LAST REPAIR, AT WHICH TIME I ALSO REPLACED THE REAR AXLE SHAFTS IN AN ATTEMPT TO RESOLVE THE ISSUE ONCE AND FOR ALL. FLUID LEAKING FROM THE REAR AXLES DIRECTLY ONTO THE WHEEL HUB, TIRES, BRAKE PADS AND DISCS AND ALL SURROUNDING AREAS, SATURATING THEM COMPLETELY, IS A SIGNIFICANT SAFETY CONCERN, IN MY OPINION, AND I BELIEVE IS GROUNDS FOR A SAFETY RECALL. I BELIEVE BOTH BRAKING ABILITY COMPROMISE AND FIRE HAZARD ARE POTENTIAL RESULTS OF THIS ISSUE. AS LEAKS DEVELOP, THEY BECOME BOTH STATIC AND DYNAMIC, WHICH IS TO SAY THAT FLUID LEAKS WHILE DRIVING AND WHILE PARKED. LARGE PUDDLES OF DIFF FLUID FORM UNDER REAR WHEELS AFTER BEING PARKED FOR ANY SIGNIFICANT AMOUNT OF TIME. NEARLY ALL OF MY DRIVING IS DONE ON-ROAD SO I DON'T SEE THIS ISSUE BEING RELATED TO OFF-ROAD DRIVING DAMAGE POSSIBILITY. REGARDLESS, THIS SAFETY ISSUE NEEDS TO BE ADDRESSED AND RECTIFIED BY NISSAN.

NHTSA complaint #10897060 — an unverified report by a vehicle owner.

POWER TRAIN

FRONT DIFFERENTIAL/AXLE ON MY FOUR WHEEL DRIVE NISSAN TITAN IS BROKEN AND LEAKING FLUID, TRUCK WILL NOT GO INTO FOUR WHEEL DRIVE ANY MORE. I WAS AT THE NISSAN DEALERSHIP GETTING AN INSPECTION PERFORMED WHEN THEY NOTICED THE FAILURE.

NHTSA complaint #10871116 — an unverified report by a vehicle owner.

POWER TRAIN

I'M FILING A COMPLAINT FOR THE MISSED RECALL ON THE NISSAN TITAN! THE DESIGN OF THE REAR AXLE OF THIS VEHICLE CAUSES A REAR AXLE SEAL LEAK. MANY CONSUMERS REPORTED THIS PROBLEM AND COMPLAINED AND NISSAN OR THIS GOVERNMENT HAS NOT ISSUED OR DEMANDED A RECALL BE MADE MANDATORY FOR THIS REAR AXLE SEAL ISSUE?! SEEMS A LITTLE ODD TO ME AS THIS COULD CAUSE MAJOR REPAIRS AND SERIOUS INJURY OR DEATH OF THIS FAILS WHILE OUT ON A PUBLIC ROADWAY! I UNFORTUNATELY AM A NISSAN TITAN CONSUMER AND HAVE EXPERIENCED THE SAME ISSUES AS EVERYONE ONLINE COMPLAINING ABOUT THEM LEAKING AND GOING OUT. I CONTACTED NISSAN AND WILL BE PURSUING REIMBURSEMENT FOR THIS REPAIR!

NHTSA complaint #10824733 — an unverified report by a vehicle owner.

POWER TRAIN

REAR DIFFERENTIAL FAILURE

NHTSA complaint #10790399 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE DRIVING MY 2004 TITAN, I NOTICED A BANGING AND CLANGING SOUND. I THOUGHT IT WAS A LIMB STUCK IN MY TIRE. UPON FURTHER INSPECTION, I NOTICED OIL ON THE INSIDE REAR ROTOR, PASSENGER SIDE. I WAS ALREADY MILES FROM HOME ON A HUNTING TRIP. I ONLY HAVE 79,000 MILES ON THE TRUCK. AFTER HUNTING, I LIMPED MY TRUCK ABOUT 30 MILES HOME, TRAVELLING ABOUT 35 MPH, WHILE IT IS BANGING AND CLANGING, SOUNDING AS THOUGH THE WHEEL IS ABOUT TO FALL OFF. I MADE SEVERAL STOPS ON THE WAY HOME TO MAKE SURE THE WHEEL WAS STILL SECURE. I FEEL BLESSED TO MAKE IT HOME AS THE WHEEL STARTED TO BIND WHEN I HIT THE DRIVEWAY. AFTER TALKING TO SEVERAL MECHANICS, THEY HAVE SEEN THIS ISSUE ALOT. THE REPAIR WILL COST SOMEWHERE BETWEEN $3,000 TO $4,000. APPARENTLY THE AXLE SEAL BLEW WITHOUT WARNING AND NOW THIS HAS CHEWED UP THE GEARS INSIDE AND DESTROYED THE HOUSING. THE MECHANICS SIMPLY SUGGESTED TO BUY THE ENTIRE REAR AXLE AND REPLACE. THEY ALSO STATED THE ORIGINAL DESIGN WAS PISS-POOR. OF COURSE, THIS HAPPENS AFTER PLACING $2,000 REPLACING THE EXHAUST MANIFOLDS THAT WERE UNDER WARRANTY FOR 80,000 MILES AND 10 YEARS OLD. MINE WERE 11 YEARS OLD AND THE TRUCK HAD 79,000 MILES ON IT. THE LOCAL GARAGE SAID THERE WAS NOTHING THEY COULD DO TO HELP. IT WAS MORE THAN 10 YEARS OLD. I WOULD HOPE THERE IS SOMETHING YOU COULD DO TO MAKE THE MANUFACTURER LIABLE FOR THIS EXPENSIVE REPAIR. THANKS FOR YOUR TIME.

NHTSA complaint #10778286 — an unverified report by a vehicle owner.

POWER TRAIN

TRYING TO ACCELERATE FROM A STOP AT CROSSROADS TO GO RIGHT ONTO A ROADWAY WITH HIGH SPEED VEHICLES APPROACHING. MY REAR END MADE A LOUD BANG AND BACK END SEEMED TO LOCK UP OR SKIP AND COULDN'T GET GOING - NEARLY REAR ENDED BY VEHICLES ON ROADWAY WHILE TRYING TO ENTER AS COULDN'T GET GOING. TOOK TO NISSAN DEALER AND APPARENTLY REAR END SPIDER GEARS GONE. 71K ON VEHICLE, CHANGED REAR DIFF. FLUID TO NISSAN RECOMMENDED TYPE AT 35K, NO TOWING, NO HARD DRIVING, AND LESS THAN 1 HOUR TOTAL LIFETIME USE OF 4X4.

NHTSA complaint #10761889 — an unverified report by a vehicle owner.

POWER TRAIN

WHEN DRIVING MY REAR END MAKING LOUD KNOCKING NOISES.. IT IS NOT GERNADED YET BUT IT ONLY A MATTER OF TIME. HAVENT BEEN DRIVING IT BE CAUSE OF FURTHER WARE OF SAFTEY ISSUES.

NHTSA complaint #10726640 — an unverified report by a vehicle owner.

POWER TRAIN

I HAD JUST PULLED OUT OF THE DRIVEWAY AT WORK INTO TRAFFIC.I HEARD A LOUD POP AND MY REAR END STARTED HAVING LARGE BANGS AND I LOST ALMOST ALL POWER. I WAS ALMOST HIT BY MULTIPLE CARS. I MANAGED TO GET OFF THE ROAD AND CALL TO HAVE IT TOWED. THANKFULLY I HAD 400 MILES LEFT ON MY WARRANTY COVERED THE ENTIRE NEW REAR AXLE THAT WAS REQUIRED.. THE DEALER SAID THEY WOULDN'T HAVE EVEN THOUGH THIS IS A KNOWN SAFETY ISSUE!!! MY FRONT DIFFERENTIAL IS ALSO SLOWLY GOING OUT BUT ISN'T BAD ENOUGH FOR THE WARRANTY TO COVER IT.

NHTSA complaint #10701527 — an unverified report by a vehicle owner.

POWER TRAIN

THE FRONT DRIVER SIDE AXLE IS POPPING OUT OF THE FRONT DIFFERENTIAL HOUSING. THIS SHOULD NOT BE HAPPENING ESPECIALLY AFTER IT HAS ALREADY BEEN FIXED ONCE. THERE IS AN OBVIOUS DEFECT IN THE NISSAN TITAN FRONT FINAL DRIVE ASSEMBLY STARTING FROM 2004 AS THERE ARE MANY SIMILAR COMPLAINTS ON THE INTERNET ON MANY OF THE NISSAN TITAN FORUMS. I WILL BE BRINGING THE VEHICLE IN FOR SERVERS TO THE DEALER AND HOPEFULLY THEY WILL ASSIST IN COST OF THIS MAJOR MALFUNCTION. AGAIN, THIS SHOULD NOT BE HAPPENING TO THIS VEHICLE AS IT DOES NOT GET MUCH HEAVY USE. NO TOWING AND HARDLY EVER USES THE 4 WHEEL DRIVE.

NHTSA complaint #10689853 — an unverified report by a vehicle owner.

POWER TRAIN

AT 55,000 MILES THE REAR AXLE SEALS FAILED ON MY 2004 NISSAN TITAN. THE SEAL FAILURE CAUSED A LEAK WHICH SATURATED THE REAR BRAKE APPARATUS AND REDUCED ITS HOLDING ABILITY. I REPORTED THIS TO MY LOCAL NISSAN DEALER AND IT WAS REPAIRED UNDER WARRANTY. I WAS TOLD THAT AN UPGRADED REAR AXLE WAS INSTALLED TO ADDRESS THE ROOT CAUSE OF THE PREMATURE SEAL FAILURE. AT 138,000 MILES THE REAR AXLE SEALS HAVE FAILED AGAIN DESPITE REGULAR FLUID CHANGES, AND THE REAR BRAKE APPARATUS IS ONCE AGAIN SOILED WITH GEAR LUBE. I BELIEVE THIS CONSTITUTES A SAFETY HAZARD AND SHOULD BE ADDRESSED AS A RECALL. THE DEALER REFUSES TO REPAIR UNDER WARRANTY AND STATES THAT THERE IS NO RECALL. BASED ON MY RESEARCH, THIS IS A VERY WIDESPREAD FAILURE ON THE NISSAN TITAN AND THERE ARE THOUSANDS OF OTHER TITAN OWNERS IN THE U.S. WITH THE SAME PROBLEM.

NHTSA complaint #10661864 — an unverified report by a vehicle owner.

POWER TRAIN

TRANSMISSION FLUID DILUTED WITH ANTI -FREEZE FROM FAULTY RADIATOR /TRANNY COOLER NISSAN NEEDS TO ADDRESS THIS PROBLEM IT IS A STALL ISSUE , A SAFETY ISSUE , ITS AN EXPENSIVE REPAIR ,AND NOT UNCOMMON.

NHTSA complaint #10659942 — an unverified report by a vehicle owner.

POWER TRAIN

FRONT DIFFERENTIAL FAILED. MANY REPORTS ONLINE SUGGEST A COMMON FAILURE. COST OVER $2100 TO FIX. PARTS HAVE BEEN REDESIGNED SO MANUFACTURER IS AWARE OF THE PROBLEM AND WILL ONLY GUARANTEE A FULL DIFFERENTIAL REPLACEMENT.

NHTSA complaint #10658639 — an unverified report by a vehicle owner.

POWER TRAIN

BOTH EXHAUST MANIFOLDS HAVE DEVELOPED CRACKS AND LEAKS. NISSAN REFUSED TO REPAIR IF NOT WITHIN 70K WARRANTY.

NHTSA complaint #10639674 — an unverified report by a vehicle owner.