2012 Nissan Xterra problems

TIRES:TREAD/BELT

Was driving on highway with my children when a loud sound filled the cabin as if I had just runover something large. About a minute later we began hearing a thumping sounds and the car was losing momentum, and I suspected we had suffered a blow-out. The right rear passenger tire was shredded. Because no one noticed anything in the roadway, I suspect the tire had suffered a spontaneous blowout and that the sound we had heard was the tire blowing out and the rubber hitting the undercarriage. The tires were: Cooper Discoverer AT3 tires, size 265/75R16. The tires had only 15,098 miles on them and were bought from the Discount Tire located at 5931 Rufe Snow Dr, in Watauga TX 76148, on 04/12/2023, invoice # [XXX]. Because I no longer trusted these tires, I traded in the 3 remaining tires and the destroyed one to the Discount Tire located at 5541 S.Cooper St, Arlington TX 76017 for $150 credit towards new tires. Sales order# [XXX] on 06/20/26 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11745484 — an unverified report by a vehicle owner.

POWER TRAIN

1) Rubber stopper under clutch pedal has failed multiple times, preventing vehicle from starting in various locations, usually parking lots and mostly after dark which presents potential safety concerns. This is a rubber part that allows vehicle to start only when clutch is depressed. I request that several/multiple of these be provided at no cost to keep in glove compartment since the poor quality of part manufacturing will most definitely cause future failure of each in the future. In addition, an explanation and instructions for removing broken part and replacing with new part is difficult for one person since you have to crawl up under the dashboard, locate the part, remove the broken part and correctly replace with a new part. I have purchased 7 pieces which have all broken and been charged approximately $7 each. The first time was the date of purchase and there have been more than 5 additional incidents since. Rubber stopper 46512-9bp1c purchased 9 between 10/14/12 and 4/6/22. Photos of those purchased just in the last couple of years

NHTSA complaint #11567746 — an unverified report by a vehicle owner.

POWER TRAIN

Clutch burnt out with 5 min between 1st incidence of barely slipping and total failure leaving me stranded on roadside with little notice and nowhere safe to pull off.

NHTSA complaint #11567748 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Extreme smell of gas after filling gas tank while out of town. Odor was so strong it required all windows to be down to drive without feeling affected by fumes and I was terrified that someone would fluck a cigarette out of a car somewhere, especially at a stop light, and cause an explosion. Once the gas tank was only half full or less, the odor diminished. Dealership found that this issue had been reported on other vehicles but did not qualify as a recall. Dealership found faulty gasket INSIDE gas tank and required the entire tank be replaced at a cost to me of more than $2000. I can get receipts from Charlottesville Nissan Dealership.

NHTSA complaint #11567759 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Nissan states that they have no repair solution on NHTSA Recall 23E-012 as of the date of this complaint. Nissan states that this is a safety issue. The originally reported issue is allegedly >8 months old without resolution. This safety issue presents a clear and on-going danger and hazard to the vehicle driver. Please escalate.

NHTSA complaint #11544031 — an unverified report by a vehicle owner.

AIR BAGS

The contact owns a 2012 Nissan Xterra. The contact received notification of NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA complaint #11531322 — an unverified report by a vehicle owner.

AIR BAGS

The contact owns a 2012 Nissan Xterra. The contact received notification of NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA complaint #11522099 — an unverified report by a vehicle owner.

ENGINE

I recently had a diagnosis of radiator coolant mixing with transmission following my vehicle being towed bc I lost power while driving with no warning signs. I was given an estimate for repairs of $5000. I had the extended warranty but wasn't told of the radiator issues w Xterra. My vehicle mileage is 128,000. Just past the 100,000 mileage mark. I just read an article that states this is a known issue with Nissan Xterra where lawsuits were filed. I just paid $7000 loan in full. I would not have done this had I known I would need this $ to repair my vehicle.

NHTSA complaint #11454387 — an unverified report by a vehicle owner.

POWER TRAIN

PREMATURE CLUTCH FAILURE ON MY MANUAL TRANSMISSION. LESS THAN 48000 MILES ON THE ODOMETER AND THE CLUTCH IS GONE. THIS IS FAR TOO LITTLE TRAVEL FOR THE CLUTCH TO BE FAILING AT. DEGRADATION HAS ADVANCED RAPIDLY OVER A MATTER OF WEEKS AND DAYS AND NOW I FEAR HAVING MY FAMILY RIDE IN THE VEHICLE IN CASE THEY BECOMING STRANDED OR NEED TO AVOID A CRASH AND CANNOT DUE TO LOSS OF POWER. GENERAL CONSENSUS IS THAT THE CLUTCH IS TOO SMALL FOR THIS TRUCK. NISSAN CLAIMS THIS IS A WEAR ITEM AND WILL NOT COVER REPLACEMENT UNDER WARRANTY, OR ADMIT THERE IS AN ISSUE AT ALL. NISSAN IS QUICK TO BLAME DRIVER'S FOR 'RIDING THE CLUTCH' AS THE REASON FOR THE FAILURE. THIS IS A COP OUT, PARTICULARLY WHEN ONE CONSIDERS THE NUMBER OF XTERRA OWNER'S EXPERIENCING THIS ISSUE.

NHTSA complaint #11011458 — an unverified report by a vehicle owner.

AIR BAGS

I'M FILING A COMPLAINT BEFORE I HAVE AN INCIDENT. I OWN A NISSAN XTERRA. MANY OTHER NISSAN XTERRA OWNERS HAVE HAD SPONTANEOUS SIDE CURTAIN AIR BAG DEPLOYMENT WHEN TRAVELING VERY SLOWLY, GENERALLY ON DIRT ROADS. SOME OF THESE DEPLOYMENTS HAVE CAUSED INJURIES. THE PROBLEM APPEARS TO BE COMMON ON ALL 2ND GENERATION NISSAN XTERRAS (2006-2016). THE FOLLOWING LINKS ARE TO XTERRA FORUM THREADS AND PROFESSIONAL PUBLICATIONS ABOUT RANDOM AIRBAG DEPLOYMENT IN XTERRAS. THERE ARE MANY MORE DOCUMENTED CASES OF THIS ONLINE, THE LINKS BELOW ARE A TASTE. THIS ALSO MAY BE A PROBLEM WITH NISSAN FRONTIERS, WHICH ARE BASICALLY THE TRUCK VARIANT OF THE XTERRA. BASED ON ABOVE TEXT, NO INCIDENT/CRASH OCCURRED...NO INJURIES. CHANGED INJ TO 0. 2/1/2017 PCO HTTP://TINYURL.COM/HSO3ELX HTTP://TINYURL.COM/J7U9E8K HTTP://TINYURL.COM/ZJT6ZMR HTTP://TINYURL.COM/HQGGBTO

NHTSA complaint #10909867 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2012 NISSAN XTERRA. AFTER MOVING THE VEHICLE FROM A PARKING SPOT, THE CONTACT NOTICED OIL LEAKING UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING ON TWO SEPARATE OCCASIONS, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,500.

NHTSA complaint #10906374 — an unverified report by a vehicle owner.

ENGINE

VEHICLE'S ENGINE SEIZED WHILE BEING OPERATED AT A LOW RATE OF SPEED. REASON GIVEN BY DEALERSHIP WHEN TOWED IN WAS NO OIL IN THE ENGINE HOWEVER THERE WAS NO WARNING LIGHT FOR EITHER OIL OR ENGINE ISSUE DISPLAYED AT ANY TIME LEADING UP TO ENGINE FAILURE. THERE HAD BEEN A PREVIOUS OIL LEAK APPROXIMATELY 10 MONTHS EARLIER WHICH HAD BEEN REPAIRED. THERE HAD BEEN NO INCIDENTS IN THE INTERIM AND NO INDICATION OF ISSUES. THERE WAS A RECALL RELATED TO THE OIL FILTER AND ENGINE BUT ACCORDING TO NISSAN, MY VEHICLE WAS NOT SUBJECT TO THE RECALL. I WAS FORCED TO PAY IN ADVANCE OF WORK BEING STARTED FOR A FULL ENGINE REPLACEMENT DESPITE THE FACT THAT I HAD ONLY 4 MONTHS LEFT ON MY 39 MONTH LEASE.

NHTSA complaint #10693208 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2012 NISSAN XTERRA. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY LOST ACCELERATION POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE CLUTCH AND FLYWHEEL NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 23,633. THE VIN WAS UNAVAILABLE.

NHTSA complaint #10563080 — an unverified report by a vehicle owner.

POWER TRAIN

I FIRST NOTICED MY CLUTCH START TO SLIP UPON LEAVING A STOP SIGN. 15 MILES LATER I WAS STRANDED ON THE SIDE OF THE ROAD WITH NO GEARS. MY CLUTCH HAD GONE OUT ON A BRAND NEW XTERRA WITH 1800 MILES ON IT. IT WAS TOWED TO THE CONCORD, CA NISSAN DEALER WHERE I PURCHASED IT. I WAS BADGERED ON ABUSING THE CAR SINCE IT HAD SOME MUD ON THE TIRES AND THEY INSISTED I DID NOT NO HOW TO DRIVE MANUAL. I HAD TO REPLACE THE CLUTCH AND "BLUED" FLYWHEEL SINCE THEY DID NOT COVER IT WITH THE WARRANTY. THEY SAID THIS WAS THE WORST FLYWHEEL THE SHOP HAS SEEN. HERE I AM WITH 22,000 MILES ON THE CAR AND THE CLUTCH IS SEVERELY SLIPPING AGAIN. I WILL BRING MY CAR IN TO NISSAN TOMORROW. I BOUGHT A NISSAN BECAUSE I EXPECTED HIGH RELIABILITY STANDARDS BUT I WAS WRONG. THIS IS THE LAST NISSAN I WILL BUY AND I WILL CERTAINLY PASS ON THE WORD TO MY FRIENDS. THERE HAVE BEEN LOTS OF PEOPLE WITH THE SAME PROBLEMS SO I AM NOT THE ONLY ONE.

NHTSA complaint #10520055 — an unverified report by a vehicle owner.

AIR BAGS

PASSENGER SIDE AIR BAG WARNING LIGHT INTERMITTENTLY GOES ON W/ SEAT OCCUPIED (120LB ADULT), SEAT BELT FASTENED, SEAT IN NORMAL UPRIGHT POSITION - INDICATING THE AIR BAG IS DEACTIVATED. I ASKED THE DEALER I PURCHASED THE VEHICLE (NEW) FROM ABOUT THIS ANOMALY AT THE FIRST SERVICE (2220 MILES/3MOS) ON 2-20-2013 AND WAS TOLD THERE WAS NOTHING THEY COULD DO - "READ THE OWNERS MANUAL". WE DID MANY DIFFERENT EXPERIMENTS WITH SEATING POSITION, SEAT BACK ANGLE ON SUBSEQUENT TRIPS, WITH NO POSITIVE RESULTS. THE ONLY EXPERIMENT THAT PROVIDED POSITIVE RESULTS WAS FOR HER TO HOLD OUR 20 LB DOG ON HER LAP - NOT A SATISFACTORY OR PERMANENT SOLUTION. I TOOK THE VEHICLE TO ANOTHER DEALER FOR THIS SPECIFIC ISSUE ON 4-22-2013 AND WAS TOLD THEY COULD DO NOTHING, AND THAT I SHOULD CONTACT NISSAN CONSUMER AFFAIRS WHICH I HAVE DONE WITH ZERO HELP OR SATISFACTION AS OF TODAY. AS SOMEONE WHO SPENT SOME 30 YEARS IDENTIFYING PROBLEMS LIKE THIS AND OVERSEEING THE DEVELOPMENT, TESTING AND PRODUCTION OF FIXES FOR AIRCRAFT, THE ENGINEERING REQUIRED TO PROVIDE OWNERS LIKE US WITH A SUITABLE FIX TO THIS PROBLEM WOULD NOT SEEM TO ME TO BE ALL THAT LARGE OR COSTLY. GIVEN THAT THIS REOCCURRING PROBLEM IN AN IMPORTANT SAFTEY SYSTEM ON THIS AND OTHER NISSAN MODELS AS WELL AS MANY IN VEHICLES PRODUCED BY OTHER MANUFACTURERS, I AM CONFIDENT YOUR OFFICES COULD PRODUCE QUICK AND MEANINGFUL RESULTS FOR EVRYONE - OWNERS AND MANUFACTURERS BY APPLYING PRESSURE AND ESTABLISHING A MEANINGFUL CRITERION FOR THE ACTIVATION/DEACTIVATION OF THE PASSENGER SEAT AIR BAG SYSTEM.

NHTSA complaint #10513350 — an unverified report by a vehicle owner.

POWER TRAIN

VEHICLE WOULD NOT START, BECAUSE OF A BROKEN CLUTCH PEDAL STOPPER. THIS BROKEN PART PREVENTED THE DEPRESSED CLUTCH PEDAL FROM ACTIVATING THE CLUTCH SAFETY SWITCH. THIS IS A SAFETY DEFECT, BECAUSE THIS A 4WD VEHICLE INTENDED FOR OFF-ROAD USE; HAD THIS PART BROKEN "IN THE MIDDLE OF NOWHERE," A SERIOUS SAFETY-RELATED INCIDENT COULD HAVE OCCURRED. ALSO, THIS PART BROKE A JUST 1540 MILES ON A VEHICLE THAT HAS NOT BE ABUSED. VEHICLE HAD TO BE TOWED TO DEALERSHIP. PART WAS REPLACED UNDER WARRANTY.

NHTSA complaint #10507354 — an unverified report by a vehicle owner.

ENGINE

VEHICLE WOULD NOT START, BECAUSE OF A BROKEN CLUTCH PEDAL STOPPER. THIS BROKEN PART PREVENTED THE DEPRESSED CLUTCH PEDAL FROM ACTIVATING THE CLUTCH SAFETY SWITCH. THIS IS A SAFETY DEFECT, BECAUSE THIS A 4WD VEHICLE INTENDED FOR OFF-ROAD USE; HAD THIS PART BROKEN "IN THE MIDDLE OF NOWHERE," A SERIOUS SAFETY-RELATED INCIDENT COULD HAVE OCCURRED. ALSO, THIS PART BROKE A JUST 1540 MILES ON A VEHICLE THAT HAS NOT BE ABUSED. VEHICLE HAD TO BE TOWED TO DEALERSHIP. PART WAS REPLACED UNDER WARRANTY.

NHTSA complaint #10507354 — an unverified report by a vehicle owner.