2020 Porsche Cayenne problems

ELECTRICAL SYSTEM

Nearly 25% of the total time I have owned this Certified Pre-Owned vehicle (146 out of 564 days), it has been non-functional and in the shop — roughly 1 out of every 4 days of ownership. I am a [XXX} with a [XXX] child, and I purchased this vehicle as a Certified Pre-Owned (CPO) Porsche — expecting the manufacturer's rigorous inspection and warranty to ensure reliability and safety. Instead, the first breakdown occurred within just 1 month of purchase, and the vehicle has since failed six separate times over 18 months (Feb 2025–Aug 2026), totaling 60+ days out of service, despite extensive component replacement: [XXX] (≈1 month after CPO purchase) – Battery failure; car would not start; towed at 2–3 AM. [XXX] – No-start; fuel tank drained/refueled ("improper additive"). [XXX] – Low fuel pump replaced. [XXX] – High fuel pump, all 6 fuel injectors, DME system replaced. [XXX] – Recurring no-start; repurchase denied May 7, 2025; Porsche later claimed root cause found (mechanical part) and replaced it. Aug 1, 2026–ongoing – Check engine light returned; misfire on cylinder 4 and coolant leak into vacuum system found. Dealer replaced coolant pump/vacuum components, updated DME software — check engine light reappeared on the dealer's own test drive. Why This Is Especially Dangerous: A CPO vehicle should not fail this quickly or repeatedly. It raised serious concern that either the inspection was inadequate or a pre-existing defect was never disclosed. My child rides in this vehicle regularly. A sudden stall or power loss at highway speed, at an intersection, or during school pickup/drop-off could cause a serious collision, endangering my child's life and my own. As a [XXX] with no backup driver/vehicle, an unexpected breakdown have cost lost work time, unreimbursed Uber expenses, and childcare disruptions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11756293 — an unverified report by a vehicle owner.

ENGINE

Nearly 25% of the total time I have owned this Certified Pre-Owned vehicle (146 out of 564 days), it has been non-functional and in the shop — roughly 1 out of every 4 days of ownership. I am a [XXX} with a [XXX] child, and I purchased this vehicle as a Certified Pre-Owned (CPO) Porsche — expecting the manufacturer's rigorous inspection and warranty to ensure reliability and safety. Instead, the first breakdown occurred within just 1 month of purchase, and the vehicle has since failed six separate times over 18 months (Feb 2025–Aug 2026), totaling 60+ days out of service, despite extensive component replacement: [XXX] (≈1 month after CPO purchase) – Battery failure; car would not start; towed at 2–3 AM. [XXX] – No-start; fuel tank drained/refueled ("improper additive"). [XXX] – Low fuel pump replaced. [XXX] – High fuel pump, all 6 fuel injectors, DME system replaced. [XXX] – Recurring no-start; repurchase denied May 7, 2025; Porsche later claimed root cause found (mechanical part) and replaced it. Aug 1, 2026–ongoing – Check engine light returned; misfire on cylinder 4 and coolant leak into vacuum system found. Dealer replaced coolant pump/vacuum components, updated DME software — check engine light reappeared on the dealer's own test drive. Why This Is Especially Dangerous: A CPO vehicle should not fail this quickly or repeatedly. It raised serious concern that either the inspection was inadequate or a pre-existing defect was never disclosed. My child rides in this vehicle regularly. A sudden stall or power loss at highway speed, at an intersection, or during school pickup/drop-off could cause a serious collision, endangering my child's life and my own. As a [XXX] with no backup driver/vehicle, an unexpected breakdown have cost lost work time, unreimbursed Uber expenses, and childcare disruptions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11756293 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Nearly 25% of the total time I have owned this Certified Pre-Owned vehicle (146 out of 564 days), it has been non-functional and in the shop — roughly 1 out of every 4 days of ownership. I am a [XXX} with a [XXX] child, and I purchased this vehicle as a Certified Pre-Owned (CPO) Porsche — expecting the manufacturer's rigorous inspection and warranty to ensure reliability and safety. Instead, the first breakdown occurred within just 1 month of purchase, and the vehicle has since failed six separate times over 18 months (Feb 2025–Aug 2026), totaling 60+ days out of service, despite extensive component replacement: [XXX] (≈1 month after CPO purchase) – Battery failure; car would not start; towed at 2–3 AM. [XXX] – No-start; fuel tank drained/refueled ("improper additive"). [XXX] – Low fuel pump replaced. [XXX] – High fuel pump, all 6 fuel injectors, DME system replaced. [XXX] – Recurring no-start; repurchase denied May 7, 2025; Porsche later claimed root cause found (mechanical part) and replaced it. Aug 1, 2026–ongoing – Check engine light returned; misfire on cylinder 4 and coolant leak into vacuum system found. Dealer replaced coolant pump/vacuum components, updated DME software — check engine light reappeared on the dealer's own test drive. Why This Is Especially Dangerous: A CPO vehicle should not fail this quickly or repeatedly. It raised serious concern that either the inspection was inadequate or a pre-existing defect was never disclosed. My child rides in this vehicle regularly. A sudden stall or power loss at highway speed, at an intersection, or during school pickup/drop-off could cause a serious collision, endangering my child's life and my own. As a [XXX] with no backup driver/vehicle, an unexpected breakdown have cost lost work time, unreimbursed Uber expenses, and childcare disruptions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11756293 — an unverified report by a vehicle owner.

BACK OVER PREVENTION

The contact owns a 2020 Porsche Cayenne. The contact received notification of NHTSA Campaign Number: 25V896000 (Back Over Prevention). The contact stated that the rear-view camera became inoperable while reversing and then turned on. There were no warning lights illuminated. The contact was unable to trade the vehicle due to the open recall. The local dealer was contacted and confirmed that the software update was not available. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

NHTSA complaint #11754655 — an unverified report by a vehicle owner.

AIR BAGS

Porsche dashboard leather shrunk and is bubbling on the entire top where the Airbag sits. I was told that if the vehicle was in an accident the airbag might not deploy correctly. The Porsche dealer looked at it and recommended replacing the entire dashboard! This is a very common issue with Porsche, and a safety concern which seems due to the fact that Porsche did not use the correct adhesive on all most of cars build in the last 10 years. The dashboard is not withstanding normal sun light and this causes a safety issue.

NHTSA complaint #11749717 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Porsche dashboard leather shrunk and is bubbling on the entire top where the Airbag sits. I was told that if the vehicle was in an accident the airbag might not deploy correctly. The Porsche dealer looked at it and recommended replacing the entire dashboard! This is a very common issue with Porsche, and a safety concern which seems due to the fact that Porsche did not use the correct adhesive on all most of cars build in the last 10 years. The dashboard is not withstanding normal sun light and this causes a safety issue.

NHTSA complaint #11749717 — an unverified report by a vehicle owner.

AIR BAGS

My 2020 Porsche Cayenne has experienced leather dashboard delamination, with the leather separating, shrinking, and lifting from the dashboard substrate on both the driver and passenger sides. The delamination extends across the upper dashboard, including areas adjacent to the passenger airbag deployment zone. I am concerned that loose or detached dashboard material could interfere with, delay, or alter the proper deployment of the passenger airbag during a collision, increasing the risk of injury. The continued deterioration also raises concerns about the integrity of the dashboard structure over time. Porsche inspected the vehicle and determined that the repair requires replacement of the entire dashboard assembly at an estimated cost of approximately $8,000 to $10,000. This indicates the condition is not a cosmetic issue but requires replacement of a major dashboard component. I have identified numerous reports from other Porsche owners describing the same leather dashboard delamination on late model Cayenne vehicles, suggesting this is a recurring manufacturing defect rather than an isolated occurrence. Porsche is part of the Volkswagen Group. Audi, another Volkswagen Group brand, issued Technical Service Bulletin 2071698/1 (NHTSA TSB MC-10245529-0001) addressing leather dashboard delamination caused by adhesive failure. The bulletin describes bubbling, wrinkling, loose leather, and delamination and instructs dealers to replace the dashboard. Audi also issued a limited warranty extension for affected vehicles. While Audi's bulletin does not apply to Porsche vehicles, it demonstrates that Volkswagen Group has recognized this type of dashboard adhesive failure. I request that NHTSA investigate whether Porsche Cayenne dashboard delamination constitutes a safety defect with the potential to affect passenger airbag deployment and occupant protection.

NHTSA complaint #11746995 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My 2020 Porsche Cayenne has experienced leather dashboard delamination, with the leather separating, shrinking, and lifting from the dashboard substrate on both the driver and passenger sides. The delamination extends across the upper dashboard, including areas adjacent to the passenger airbag deployment zone. I am concerned that loose or detached dashboard material could interfere with, delay, or alter the proper deployment of the passenger airbag during a collision, increasing the risk of injury. The continued deterioration also raises concerns about the integrity of the dashboard structure over time. Porsche inspected the vehicle and determined that the repair requires replacement of the entire dashboard assembly at an estimated cost of approximately $8,000 to $10,000. This indicates the condition is not a cosmetic issue but requires replacement of a major dashboard component. I have identified numerous reports from other Porsche owners describing the same leather dashboard delamination on late model Cayenne vehicles, suggesting this is a recurring manufacturing defect rather than an isolated occurrence. Porsche is part of the Volkswagen Group. Audi, another Volkswagen Group brand, issued Technical Service Bulletin 2071698/1 (NHTSA TSB MC-10245529-0001) addressing leather dashboard delamination caused by adhesive failure. The bulletin describes bubbling, wrinkling, loose leather, and delamination and instructs dealers to replace the dashboard. Audi also issued a limited warranty extension for affected vehicles. While Audi's bulletin does not apply to Porsche vehicles, it demonstrates that Volkswagen Group has recognized this type of dashboard adhesive failure. I request that NHTSA investigate whether Porsche Cayenne dashboard delamination constitutes a safety defect with the potential to affect passenger airbag deployment and occupant protection.

NHTSA complaint #11746995 — an unverified report by a vehicle owner.

ENGINE

"Engine temperature too high. Park vehicle and allow engine to cool". warning at 50,000 miles which the mechanic says this is a huge problem with all Porsche, Audi and VW due to water coolant changeover valve which fails and also stated that Porsche is aware and should have a "bulletin" open on this issue?

NHTSA complaint #11740164 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 Porsche Cayenne. The contact stated that an abnormal tapping noise was coming from the engine compartment. No warning lights were illuminated at the time of the failure. The vehicle was initially taken to an independent mechanic, who confirmed the tapping noise and referred the contact to an authorized dealer for further inspection. The vehicle was then taken to local dealers, who acknowledged the noise but advised that the vehicle was operating as designed and that the condition was considered normal. The vehicle was not diagnosed or repaired. The vehicle was later taken to New Country Porsche Greenwich Service Center, 241 West Putnam Avenue, Greenwich, CT 06830, but the vehicle was not diagnosed or repaired. The tapping noise continued to persist over time. The manufacturer was contacted and confirmed that there was no warranty coverage. The failure mileage was approximately 40,000.

NHTSA complaint #11738004 — an unverified report by a vehicle owner.

SEAT BELTS

Seat belt and airbag indication lights and sound alarms remain on and notifying on the dashboard regardless of buckling. It will intermittently stop and start as the car is in motion. In the beginning, notification was present then resolved day-to-day. More recently, the alarm is present every drive. Driver was unsure whether or not the notifications were valid or not as the pattern of notification had little consistency. Dealership service later admitted that it was a faulty seat belt buckle and that part had failed internally, but refused to remedy it unless paid for. Car is essentially inoperable and unsafe until faulty buckle is replaced, as a faulty seat belt buckle can be fatal, with faulty implying a manufacturing issue and not of user misuse or abuse of systems. Manufacturer will not provide warranty and dealership continues to demand vehicle owner to pay.

NHTSA complaint #11734672 — an unverified report by a vehicle owner.

AIR BAGS

Seat belt and airbag indication lights and sound alarms remain on and notifying on the dashboard regardless of buckling. It will intermittently stop and start as the car is in motion. In the beginning, notification was present then resolved day-to-day. More recently, the alarm is present every drive. Driver was unsure whether or not the notifications were valid or not as the pattern of notification had little consistency. Dealership service later admitted that it was a faulty seat belt buckle and that part had failed internally, but refused to remedy it unless paid for. Car is essentially inoperable and unsafe until faulty buckle is replaced, as a faulty seat belt buckle can be fatal, with faulty implying a manufacturing issue and not of user misuse or abuse of systems. Manufacturer will not provide warranty and dealership continues to demand vehicle owner to pay.

NHTSA complaint #11734672 — an unverified report by a vehicle owner.

SEAT BELTS

The contact owns a 2020 Porsche Cayenne. The contact stated that the front driver’s side seat belt failed to buckle and became unusable. The dealer and the manufacturer were notified of the failure. The contact was advised to schedule an appointment for the vehicle to be repaired at the owner's expense. The vehicle was not diagnosed or repaired. The contact related the failure to an unknown recall. The failure mileage was approximately 68,000.

NHTSA complaint #11731520 — an unverified report by a vehicle owner.

SERVICE BRAKES

Vehicle: 2020 Porsche Cayenne VIN: [XXX] Mileage: 41,918 Complaint: My 2020 Porsche Cayenne exhibits a significant and repeatable lurching and abnormal braking pattern each time the vehicle decelerates to a stop. The behavior is consistent and pronounced enough to cause me physical motion sickness on every drive. I brought the vehicle to Porsche Bellevue (Bellevue, WA) for diagnosis. The service manager personally rode in the vehicle with me, experienced the lurching behavior firsthand, and acknowledged feeling it. He then stated the vehicle could not be repaired because this is simply how the car behaves — no repair order was written and no fix was attempted. I am filing this complaint because: (1) the behavior involves abnormal braking and deceleration which I believe constitutes a safety concern, (2) the authorized dealership confirmed the issue exists but refused to document or repair it, and (3) I am concerned other owners of this vehicle may be experiencing the same issue without recourse. I am requesting NHTSA investigate whether this is a known issue across the 2020 Porsche Cayenne platform and whether it meets the threshold for a safety investigation or recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11729733 — an unverified report by a vehicle owner.

ENGINE

A coolant hose located on the top of the engine developed a leak that caused the engine to overheat. It was necessary to remove several components of the engine to reach and replace the leaking hose. This repair cost over 5000 dollars with the associated labor cost. Vehicle had less than 6000 miles on it at the time of the incident. It took several weeks to get the needed parts.

NHTSA complaint #11721832 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

A coolant hose located on the top of the engine developed a leak that caused the engine to overheat. It was necessary to remove several components of the engine to reach and replace the leaking hose. This repair cost over 5000 dollars with the associated labor cost. Vehicle had less than 6000 miles on it at the time of the incident. It took several weeks to get the needed parts.

NHTSA complaint #11721832 — an unverified report by a vehicle owner.

ENGINE

There is a major issue with the coolant pump/water pump on the V8 4.0L engine. Every 30,000ish miles I’ve had to have a water pump replaced in my vehicle, Porsche NA claims they redesigned the pump and it fails in the same amount of time. Rennlist Porsche worldwide forums there are 28 threads of people having water pumps/coolant pumps replaced at the tune of $9,000-$12,000 because 70-80% of the front end of the Cayenne has to be removed to get to the water pump. The pump needs to be made out of more durable materials for durability and longevity. Expecting customers to replace water pumps every 30K miles is ridiculous. My 3rd water pump in 95K miles is being replaced as I type this right now. The dealership Porsche of Wallingford, CT, has 3 other customer Cayennes now that also need water pumps. Porsche USA and AG/Germany need to issue a 15 year/unlimited miles warranty on this water pump, like they’ve had to do with window switches, emissions valves, and other parts they have gotten sued for and now have 15 year warranties.

NHTSA complaint #11668197 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Rearview- back up camera works intermittently. Took it to my mechanic replaced battery and camera, back up camera still works intermittently. Took it to Porsche of Spokane, they said that it was not a safety issue and all cameras would have to be replaced for $16,951.81. I have the receipts.

NHTSA complaint #11660019 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Rear camera and surround views cameras not working intermittently.

NHTSA complaint #11651850 — an unverified report by a vehicle owner.

POWER TRAIN

Everytime when vehicle coming to a stop car lurches forward few feets. It just happens when car downshifts from second to first gear transmission pushes you forward few feets, You just need to be very carefull because it can push you into another vehicle or pedastrian. Porsche is aware of it and have a software update in Europe only but not in USA

NHTSA complaint #11626672 — an unverified report by a vehicle owner.

POWER TRAIN

The car is very jerky, I bought in for engine or transmission mount because the idle shakes the whole car. They said its normal. Which I don't think it's normal.

NHTSA complaint #11621314 — an unverified report by a vehicle owner.

ENGINE

The car is very jerky, I bought in for engine or transmission mount because the idle shakes the whole car. They said its normal. Which I don't think it's normal.

NHTSA complaint #11621314 — an unverified report by a vehicle owner.

SERVICE BRAKES

The car is very jerky, I bought in for engine or transmission mount because the idle shakes the whole car. They said its normal. Which I don't think it's normal.

NHTSA complaint #11621314 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

hello i have cayenne 2020. this car has 360 surround view camera but its not working correctly. sometime its working sometimes some comeras not working maybe front maybe rear meybe both. as i read rennlist this is porshe forum everyone has same problem porshe in warranty replace modules or cameras but its not working i think its recall issue please help us.

NHTSA complaint #11591116 — an unverified report by a vehicle owner.

POWER TRAIN

When downshifting and just before Coming to a complete stop and vehicle lurches/surges forward even though my foot is on the brake pedal. This happens in every drive mode with or without Autostart/stop engaged. It is Significantly challenging in stop and go traffic because it’s difficult to gage when the car will come to a complete stop. I have to make accommodation for the car lunging forward which is unpredictable because sometimes it’s a subtle surge forward and other times I have no control or idea how far forward the car is going to move. This makes this is especially dangerous when cars are quickly changing lanes in front of me in stop and go traffic during rush hour. Emergency braking DOES not help this! I have experience this. The collision warning Went off in the car and emergency braking was engaged just at the Knick of time! Adverse weather conditions could have easily made that a very bad accident. I should be able to Do normal every day driving And stopping, for example stopping to a red light, or stop and go traffic without having to activate emergency functions in my car and putting myself at unnecessary risk because of a “glitch” with Porsche. This normal every day driving. I returned my car to the dealership who told me it’s normal performance for this car along with. I along with many other owners have researched this and found out that software upgrades have been done to correct this problem which are not available yet in the United States. This issue needs to be resolved immediately to prevent potential accidents.

NHTSA complaint #11500459 — an unverified report by a vehicle owner.