Owners have filed 26 complaints
about the 2017 RAM 5500 with NHTSA between 2018 and 2026.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 6 of 8 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 53
Against the median year of the RAM 5500. 50 means typical for this
model; 100 means roughly double.
Severity — 60
11.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 43
25% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2017 RAM 5500
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Transmission & Drivetrain
830.8%
0 crashes, 1 fires · median 136,500 mi
Brakes
519.2%
Median failure at 140,500 miles
Tires
311.5%
Median failure at 22,000 miles
Fuel & Propulsion
27.7%
0 crashes, 1 fires · median 88,000 mi
Steering
27.7%
Median failure at 24,950 miles
Engine & Cooling
27.7%
0 crashes, 1 fires · median 85,000 mi
Wheels
13.8%
Acceleration & Cruise Control
13.8%
Suspension
13.8%
Median failure at 8,000 miles
Electrical System
13.8%
Median failure at 85,000 miles
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
210.0%
10,000 – 24,999 miles
210.0%
25,000 – 49,999 miles
420.0%
50,000 – 74,999 miles
15.0%
75,000 – 99,999 miles
315.0%
100,000 – 149,999 miles
420.0%
150,000+ miles
420.0%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jun 2018peak 5May 2026
NHTSA investigations into the 2017 RAM 5500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
Post Recall Remedy Brake Transmission Shift Interlock (BTSI) Failure
The Office of Defects Investigation (ODI) has received 14 Vehicle Owner Questionnaire (VOQ) reports and 6 EWR Death & Injury (D&I) reports describing post recall remedy failures of the brake transmission shift interlock (BTSI) system in certain Model Year (MY) 2013-2018 RAM pickup trucks.The subject vehicle models include 1500, 2500, 3500, 4500, and 5500 trucks equipped with a column mounted shift lever.The failures of the BTSI described in the VOQs occurred on vehicles that had all previously been repaired under recall 17V-821 or 18V-100.Both recalls address a potential condition which can ca...
PE19017Opened 12 Dec 2019Closed 22 Oct 2023POWER TRAIN
Front Driveshaft Failure
On December 12, 2019, NHTSA's Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 19-017 after receiving three Vehicle Owner Questionnaire (VOQ) reports alleging failures of the front driveshaft and/or transfer case, resulting in conditions of 1) a loss of engine power, 2) loss of steering assist, 3) loss of foundation brakes, 4) unintended air bag deployment and 5) engine/cab fires from combustible fluids striking hot exhaust components. The VOQs involved model year (MY) 2015 through 2017 RAM 4500 and 5500 vehicles. ODI received information from the vehicle manufacturer [...
Recalls on the 2017 RAM 5500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
24V896000
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Ram 2500 Pickup, Ram 3500 Pickup, 3500 Cab Chassis, 4500 and 5500 Cab Chassis vehicles. The hydraulic control unit (HCU) may fail, which can cause the anti-lock brake (ABS), electronic stability control (ESC), and traction control systems to fail.
Risk: A loss of anti-lock brakes, electronic stability control, or traction control can increase the risk of a crash.
21V398000
WHEELS:LUGS/NUTS/BOLTS/STUDS
Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.
Risk: Wheel separation can cause a vehicle crash.
18V332000
ELECTRICAL SYSTEM:WIRING
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Risk: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
18V100000
POWER TRAIN:AUTOMATIC TRANSMISSION
Chrysler (FCA US LLC) is recalling certain 2017-2018 RAM 1500, 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.
Risk: Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
17V824000
EQUIPMENT
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Risk: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
17V821000
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.
Risk: Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
17V562000
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.
Risk: The leaking water pump can increase the risk of an engine compartment fire.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202472722,119 units in Canada
Brakes
Issue: On certain trucks, the brake hydraulic control unit could fail. Over time, this could cause the antilock braking system (ABS), electronic stability control (ESC) system and/or traction control not to work. Note: This recall also affects certain RAM 3500, 4500 and 5500 chassis cab incomplete vehicles. Safety Risk: An antilock braking system, electronic stability control system and/or traction control system that doesn't work could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners in writing and advise you to take your truck to a dealership to replace the brake hydraulic control unit.
Recall 2024548314,717 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
Recall 202133630,899 units in Canada
Wheels
Issue: On certain pickup and chassis-cab trucks, the owner's manual and service manual list the wrong torque specification for the wheel nuts. As a result, some trucks may have had the lug nuts over-tightened during servicing. This can damage the wheel studs and, over time, they could break. If this happens, a wheel could separate from the truck. Note: This recall only affects trucks equipped with dual rear wheels and flanged lug nuts. Safety Risk: A wheel separation could cause a loss of control and increase the risk of a crash. A wheel that separates could also hit another person or vehicle. Corrective Action: FCA Canada will contact owners by mail and instruct you to take your truck to a dealer to inspect and replace the wheel studs, as necessary. They will also provide an update for the torque specification listed in the owner's manual.
Recall 2018269635,880 units in Canada
Engine
On certain vehicles, an electronic fault may create a situation where the cruise control cannot be deactivated. If this occurs and the driver does not apply the brakes or shift the transmission to neutral, the vehicle could maintain speed or accelerate without warning, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect the Powertrain Control Module (PCM) software and perform an update as necessary. Note: In the interim, owners are advised not to use the cruise control until the vehicle is repaired.
Recall 201808141,903 units in Canada
Powertrain
On certain vehicles equipped with a steering column gear shifter, the brake transmission shift interlock (BTSI) may become inoperative. This could allow the steering column gear shifter lever to be shifted out of the PARK (P) position without depressing the service brake pedal or having the key in the ignition, which could result in unintended vehicle movement, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect and replace the BTSI as necessary. The Body Control Module (BCM) will also be updated.
Recall 20176637,391 units in Canada
Accessories
On certain vehicles equipped with the Roadside Emergency Kit containing a Kidde fire extinguishers with black plastic handles and valves, the fire extinguishers may become clogged or require excessive force to activate. Also, the nozzle may detach from the valve assembly with enough force that it could cause injury, and fail to discharge. In case of fire, failure of the extinguisher to function could result in injury and/or property damage. Correction: Dealers will replace the suspect Kidde fire extinguisher with a new Kidde fire extinguisher with a steel nozzle. For more information about recalled fire extinguishers, please visit <a href="https://inmarmarketaction.com/kidde/Kidde284CA/">www.kidde.com</a>.
Recall 2017659290,200 units in Canada
Powertrain
On certain vehicles equipped with a steering column gear shifter, the brake transmission shift interlock (BTSI) may become inoperative. This could allow the steering column gear shifter lever to be shifted out of the PARK (P) position without depressing the service brake pedal or having the key in the ignition, which could result in unintended vehicle movement, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect and replace the BTSI as necessary. The Body Control Module (BCM) will also be updated.
Recall 201744149,697 units in Canada
Engine
On certain vehicles equipped with 6.7 litre diesel engines, the water pump could fail. This could result in an underhood fire causing injury and/or property damage. Correction: Dealers will replace the water pump with a new one.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 139,000 milesBrandon, MSFire
POWER TRAIN
ON I-40 EASTBOUND MILE MARKER 121 VEHICLE STARTS TO SHAKE AND VIBRATE VIOLENTLY. I HEAR AN EXPLOSION UNDER THE TRUCK WHICH CAUSE A LOSS OF POWER AND HAD TO FIGHT WITH TRUCK TO GET IT OFF THE ROAD ALL WHY AT A SPEED OF 65 MPH. TRANSFER CASE EXPLODED CUTTING WIRE HARNESS IN HALF AND RUPTURING THE FUEL LINE. TRUCK WAS SMOKING BAD AS OIL AND FUEL WAS LEAKING EVERYWHERE. TRUCK IS INOP AT THIS POINT. PLEASE HELP WITH THIS MATTER IN AN EFFORT TO HELP OTHERS FROM THIS EXPERIENCE. I ALMOST WRECKED TRYING TO GET THE VEHICLE OFF THE ROAD AFTER THE TRANSFER CASE EXPLODED
NHTSA complaint #11288429 — an unverified report by a vehicle owner.
at 139,000 milesBrandon, MSFire
FUEL/PROPULSION SYSTEM
ON I-40 EASTBOUND MILE MARKER 121 VEHICLE STARTS TO SHAKE AND VIBRATE VIOLENTLY. I HEAR AN EXPLOSION UNDER THE TRUCK WHICH CAUSE A LOSS OF POWER AND HAD TO FIGHT WITH TRUCK TO GET IT OFF THE ROAD ALL WHY AT A SPEED OF 65 MPH. TRANSFER CASE EXPLODED CUTTING WIRE HARNESS IN HALF AND RUPTURING THE FUEL LINE. TRUCK WAS SMOKING BAD AS OIL AND FUEL WAS LEAKING EVERYWHERE. TRUCK IS INOP AT THIS POINT. PLEASE HELP WITH THIS MATTER IN AN EFFORT TO HELP OTHERS FROM THIS EXPERIENCE. I ALMOST WRECKED TRYING TO GET THE VEHICLE OFF THE ROAD AFTER THE TRANSFER CASE EXPLODED
NHTSA complaint #11288429 — an unverified report by a vehicle owner.
Fayette, MSFire
ENGINE
TL* THE CONTACT OWNS A 2017 RAM 5500. WHILE THE CONTACT'S HUSBAND WAS DRIVING 50-55 MPH, SMOKE EMERGED FROM UNDER THE HOOD AND THE ENGINE CAUGHT FIRE. THE DRIVER EXTINGUISHED THE FIRE. THE SERVICE ENGINE AND OIL WARNING INDICATORS WERE ILLUMINATED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT AND THEN TOWED TO MAC HAIK CHRYSLER DODGE JEEP RAM FLOWOOD (4000 LAKELAND DR, FLOWOOD, MS 39232, (855) 223-8958) WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 35490335. THE MANUFACTURER DID NOT ASSIST. THE WARRANTY AND INSURANCE COMPANIES STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11256464 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 88,000 milesGrandville, MI
SERVICE BRAKES, HYDRAULIC
The contact owns a 2017 Ram 5500. The contact stated that an unknown warning light appeared on the instrument panel which stated that the ABS function was not available and that the 4WD was disabled. The vehicle was taken a dealer where they kept the vehicle for over a week where they eventually replaced the brake hydraulic control unit ("HCU"). The contact then received notification of NHTSA Campaign Number: 24V896000 (Service Brakes, Hydraulics) however, the part to do the recall repair was not yet available. Two local dealers were made aware of the issue and confirmed that parts were not yet available. Additionally, the contact was informed that the part that was used to repair the vehicle was a defective part and that it would need to be replaced once parts were available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 88,000.
NHTSA complaint #11735796 — an unverified report by a vehicle owner.
Tampa, FL
SERVICE BRAKES, HYDRAULIC
The contact owns a 2017 Ram 5500. The contact received notification of NHTSA Campaign Number: 24V896000 (Service Brakes, Hydraulics); however, the part to do the recall repair was not yet available. Several local dealers were made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11720686 — an unverified report by a vehicle owner.
Elizabethton, TN
SERVICE BRAKES
ABS Pump Faulty and needed replacement at 10, 866 miles in 2022 when vehicle was just 5 years old. Cost at this time was $1459. Now just 2 years later and only 3000 additional miles ABS Pump is again faulty and unable to replace but no module is available at this time.
NHTSA complaint #11609644 — an unverified report by a vehicle owner.
at 85,000 milesPhenix City, AL
ELECTRICAL SYSTEM
The contact owns a 2017 Ram 5500. The contact stated that on several occasions while turned on the vehicle shut off and would not restart. The contact stated that the fuel fuse was replaced at the residence by an independent mechanic but the failure reoccurred. The vehicle was taken to a dealer where it was diagnosed that the TIPM needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 85,000.
NHTSA complaint #11606760 — an unverified report by a vehicle owner.
at 85,000 milesPhenix City, AL
ENGINE
The contact owns a 2017 Ram 5500. The contact stated that on several occasions while turned on the vehicle shut off and would not restart. The contact stated that the fuel fuse was replaced at the residence by an independent mechanic but the failure reoccurred. The vehicle was taken to a dealer where it was diagnosed that the TIPM needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 85,000.
NHTSA complaint #11606760 — an unverified report by a vehicle owner.
Osceola, IA
WHEELS
The contact owns a 2017 Ram 5500. The contact received notification of NHTSA Campaign Number: 21V398000 (Wheels) however, the part to do the recall repair was unavailable. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11486725 — an unverified report by a vehicle owner.
at 292,000 milesSalt Lake City, UT
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
The contact owns a 2017 Ram 5500. The contact stated while driving approximately 70-75 MPH, there was a loud banging sound coming from the vehicle. The contact stated that the transfer case had fractured and the front driveshaft had failed. The vehicle was towed and remained at the towing lot. The dealer was contacted and informed of the failure however, the vehicle was not towed to the dealer. The dealer stated that the failure was a known failure however, the vehicle was not under recall for the failure. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 292,000.
NHTSA complaint #11485412 — an unverified report by a vehicle owner.
at 310,000 milesSalt Lake City, UT
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
The contact owns a 2017 Ram 5500. The contact stated that while driving approximately 70-75 MPH, there was an abnormally loud banging sound coming from the vehicle. The driver pulled to the side of the roadway and became aware that the transfer case had fractured into several pieces, and the front driveshaft had also fractured in several pieces. The contact stated that the fuel lines and the exhaust pipe were severely damaged. The vehicle was towed to the dealer where the fuel lines, brake line, electrical wiring, transfer case, front driveshaft and the entire exhaust system were replaced. The manufacturer was not made aware of the failure. The approximate failure mileage 310,000.
NHTSA complaint #11485413 — an unverified report by a vehicle owner.
at 193,000 milesGwynn Oak, MD
POWER TRAIN
The contact owns a 2017 Ram 5500. The contact stated that after shifting into park(P), the vehicle rolled away and the parking brake failed to stop the vehicle. The contact used rocks to chock the front tires to stop the vehicle from rolling. The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 193,000.
NHTSA complaint #11482367 — an unverified report by a vehicle owner.
at 193,000 milesGwynn Oak, MD
PARKING BRAKE
The contact owns a 2017 Ram 5500. The contact stated that after shifting into park(P), the vehicle rolled away and the parking brake failed to stop the vehicle. The contact used rocks to chock the front tires to stop the vehicle from rolling. The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 193,000.
NHTSA complaint #11482367 — an unverified report by a vehicle owner.
Fayette, ME
VEHICLE SPEED CONTROL
ABS and traction control light comes on intermittently when driving. Cruise control does not work and chime and warning lights come on as lights come on.
NHTSA complaint #11453621 — an unverified report by a vehicle owner.
Fayette, ME
SERVICE BRAKES
ABS and traction control light comes on intermittently when driving. Cruise control does not work and chime and warning lights come on as lights come on.
NHTSA complaint #11453621 — an unverified report by a vehicle owner.
at 103,180 milesSalem, VA
POWER TRAIN
VEHICLE WAS DRIVING ON INTERSTATE AT 70MPH AND STARTED VIBRATING VIOLENTLY, A FEW SECONDS LATER THERE WAS A LOUD BANG THAT TURNED INTO MULTIPLE BANGS THAT COULD BE FELT AT THE DRIVERS FEET AND THE TRUCK STALLED. WE HAD IT TOWED BACK TO OUR SHOP AND FOUND THAT THE TRANSFER CASE HAD EXPLODED CAUSING THE FRONT DRIVESHAFT TO COME APART WHICH ENDED UP TEARING THROUGH THE DRIVERS FLOORBOARD, DESTROYED THE ENGINE AND TRANSMISSION WIRING HARNESSES, CRACKED THE TRANSMISSION CASING, AND SEVERED THE BRAKE AND FUEL LINES. LUCKILY THERE WERE NO INJURIES. THE TRUCK HAS 103,180 MILES AND IS REGULARLY MAINTAINED PER CHRYSLER SPECIFICATIONS.
NHTSA complaint #11387121 — an unverified report by a vehicle owner.
at 12,900 milesLancaster, NH
STEERING
RIGHT FRONT STEERING TIRE EXPERIENCED UNUSUAL WEAR ON THE OUTSIDE CORD ONLY. LEFT SIDE OK. HAD THE ALIGNMENT CHECKED BY DODGE UP TO SPEC. HAD MY MECHANIC ON A $50,000 RACK CHECK THE ALIGNMENT AT MY EXPENSE. RIGHT FRONT OK LEFT FRONT .7DEGREES OUT. ONLY ADJUSTMENT IS TO REPLACE THE NON ADJUSTABLE BALL JOINTS WITH OFFSET ADJUSTABLE BALL JOINTS AS WELL AS THE TIRES. FCA RESPONSE WAS YOU KNOW WE ONLY HAVE A 12000 MILE 12 MONTH WARRANTY ON THE ALIGNMENT. TRUCK IS ALMOST TWO YEARS OLD WITH 12900 MILES. FIRST THE DODGE DEALERSHIP WAS UNABLE TO DO THE ALIGNMENT AND THE TECH WAS UPFRONT ON NOT BEING COMFORTABLE WORKING ON THIS LARGE TRUCK. SO I AM LEFT TO MANAGE THIS CRITICAL SAFETY ISSUE ON MY OWN. FCA REP ADMITTED MOST DODGE DEALERSHIPS ARE UNABLE TO REPAIR THE 5500 SO THEY HAVE TO OUTSOURCE THE JOB. THE OUTSIDE OF THE TIRE HAS LITERALLY WORN OFF THE TREAD PATTERN. I BELIEVE THIS PRESENTS A POTENTIAL BLOWOUT HAZARD AND AM QUITE CONCERNED. ACCORDINGLY I HAVE NOT DRIVEN THE VEHICLE EVEN THOUGH IT IS MY ONLY WELDING RIG I HAVE FOR MY SIDE BUSINESS. THIS IS A SAFETY CONCERN AS WELL AS A SUBSTANTIAL LOSS OF REVENUE FOR ME. I HAVE SPOKEN WITH THE DEALERSHIP THAT I PURCHASED THE VEHICLE FROM IN COLUMBIANA OHIO. THE COMMERCIAL MANAGER ADMITTED THAT THIS IS NOT AN UNCOMMON PROBLEM AND REQUIRES REPLACING THE BALL JOINTS. I AM AWAITING A RESPONSE FROM FCA IN REGARDS FIXING THE PROBLEM. I HAVE MADE ARRANGEMENTS ON MY OWN TO HAVE THE VEHICLE REPAIRED AND THE TIRES REPLACED. IN VIEW OF THE FACT THAT MY PURCHASING DEALERSHIP ACKNOWLEDGES THIS AS A PROBLEM, YET CHRYSLER MAKES NO EFFORT TO FIX IT IS QUITE DISCONCERTING. A BLOWOUT ON A VEHICLE RATED TO TOW 30,000 LBS WOULD BE DISASTROUS. THANK YOU FOR YOUR TIME.
NHTSA complaint #11331308 — an unverified report by a vehicle owner.
at 8,000 milesRogersville, AL
SUSPENSION
TL* THE CONTACT OWNS 2017 RAM 5500 EQUIPPED WITH CONTINENTAL TIRES, TIRE LINE: HDR, TIRE SIZE: 225/70R/19.5, DOT NUMBER WAS A39YLA4V0217. THE CONTACT STATED BOTH FRONT TIRES WERE ROTATED AND REPLACED 6 TIMES WITHIN 48,000 MILES. THE CONTACT STATED THE OUTSIDE EDGE OF THE TIRE WERE WORN-OUT. THE CONTACT STATED FRONT SUSPENSION REPAIRS WERE NEEDED BUT HAD NOT BEEN PERFORMED. THE VEHICLE WAS TAKEN TO LANDERS MCLARTY DODGE CHRYSLER JEEP RAM LOCATED AT (6533 UNIVERSITY DR NW, HUNTSVILLE, AL 35806) AND WERE UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 8,000.
NHTSA complaint #11316387 — an unverified report by a vehicle owner.
at 8,000 milesRogersville, AL
TIRES
TL* THE CONTACT OWNS 2017 RAM 5500 EQUIPPED WITH CONTINENTAL TIRES, TIRE LINE: HDR, TIRE SIZE: 225/70R/19.5, DOT NUMBER WAS A39YLA4V0217. THE CONTACT STATED BOTH FRONT TIRES WERE ROTATED AND REPLACED 6 TIMES WITHIN 48,000 MILES. THE CONTACT STATED THE OUTSIDE EDGE OF THE TIRE WERE WORN-OUT. THE CONTACT STATED FRONT SUSPENSION REPAIRS WERE NEEDED BUT HAD NOT BEEN PERFORMED. THE VEHICLE WAS TAKEN TO LANDERS MCLARTY DODGE CHRYSLER JEEP RAM LOCATED AT (6533 UNIVERSITY DR NW, HUNTSVILLE, AL 35806) AND WERE UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 8,000.
NHTSA complaint #11316387 — an unverified report by a vehicle owner.
at 22,000 milesBandera, TX
TIRES
LEFT HAND FRONT TIRE BLEW OUT TRAVELING ON A STRAIGHT HWY NO WARNING THERE WAS A PROBLEM WITH THE TIRE. WAS DRIVING AT THE LEGAL SPEED LIMIT OF 75 MPH. I WAS LUCKY THERE WERE NO OTHER VEHICLES NEXT TO ME OR TRAVELING IN MY DIRECTION AT THE TIME. IT DAMAGED THE FENDER AND INNER LINER, THE TIRE WAS SENT TO GOODYEAR AND THEY SAID IT WAS MY FAULT THE TIRE BLEW OUT. THAT I HAD HIT SOMETHING AND CAUSED DAMAGE TO THE BELT. THAT IS NOT TRUE. I DID NOT HIT ANYTHING AND THERE WAS NOTHING ON THE ROAD TO CAUSE ANY DAMAGE TO THE TIRE.
NHTSA complaint #11310844 — an unverified report by a vehicle owner.
at 139,000 milesBrandon, MSFire
POWER TRAIN
ON I-40 EASTBOUND MILE MARKER 121 VEHICLE STARTS TO SHAKE AND VIBRATE VIOLENTLY. I HEAR AN EXPLOSION UNDER THE TRUCK WHICH CAUSE A LOSS OF POWER AND HAD TO FIGHT WITH TRUCK TO GET IT OFF THE ROAD ALL WHY AT A SPEED OF 65 MPH. TRANSFER CASE EXPLODED CUTTING WIRE HARNESS IN HALF AND RUPTURING THE FUEL LINE. TRUCK WAS SMOKING BAD AS OIL AND FUEL WAS LEAKING EVERYWHERE. TRUCK IS INOP AT THIS POINT. PLEASE HELP WITH THIS MATTER IN AN EFFORT TO HELP OTHERS FROM THIS EXPERIENCE. I ALMOST WRECKED TRYING TO GET THE VEHICLE OFF THE ROAD AFTER THE TRANSFER CASE EXPLODED
NHTSA complaint #11288429 — an unverified report by a vehicle owner.
at 139,000 milesBrandon, MSFire
FUEL/PROPULSION SYSTEM
ON I-40 EASTBOUND MILE MARKER 121 VEHICLE STARTS TO SHAKE AND VIBRATE VIOLENTLY. I HEAR AN EXPLOSION UNDER THE TRUCK WHICH CAUSE A LOSS OF POWER AND HAD TO FIGHT WITH TRUCK TO GET IT OFF THE ROAD ALL WHY AT A SPEED OF 65 MPH. TRANSFER CASE EXPLODED CUTTING WIRE HARNESS IN HALF AND RUPTURING THE FUEL LINE. TRUCK WAS SMOKING BAD AS OIL AND FUEL WAS LEAKING EVERYWHERE. TRUCK IS INOP AT THIS POINT. PLEASE HELP WITH THIS MATTER IN AN EFFORT TO HELP OTHERS FROM THIS EXPERIENCE. I ALMOST WRECKED TRYING TO GET THE VEHICLE OFF THE ROAD AFTER THE TRANSFER CASE EXPLODED
NHTSA complaint #11288429 — an unverified report by a vehicle owner.
at 134,000 milesWaco, TX
POWER TRAIN
WHILE DRIVING A VIBRATION WAS NOTICED AT SPEEDS ABOVE 45 MPH. DURING TRANSIT THE TRANSFER CASE EXPLODED CAUSING A MAJOR FAILURE OF MULTIPLE SYSTEMS. THIS FAILURE OCCURRED ON A STATE HIGHWAY LEAVING WACO TX AT 445 A.M. POLICE WERE DISPATCHED TO BLOCK TRAFFIC FROM FURTHER ACCIDENTS UNTIL A TOW VEHICLE WAS DISPATCHED TO THE SCENE. UPON FURTHER INVESTIGATION IT WAS VERY NOTICEABLE THAT THE TRANSFER SYSTEM IN THE POWERTRAIN SYSTEM HAD EXPLODED. THIS FAILURE HAS CAUSED MULTIPLE COLLATERAL DAMAGES TO SYSTEMS IN THE VICINITY OF THE FAILURE.
NHTSA complaint #11282469 — an unverified report by a vehicle owner.
at 37,000 milesHouston, TX
POWER TRAIN
TL* THE CONTACT OWNS A 2017 RAM 5500. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SHIFTED OUT OF GEAR AND WENT INTO NEUTRAL. WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO SOUTHFORK CHRYSLER DODGE JEEP RAM (844-350-9615, LOCATED AT 17725 S FREEWAY, MANVEL, TX 77578) WHERE IT WAS DIAGNOSED THAT THE SHIFTER CABLE NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE FUSE IN THE FUEL PUMP OVERHEATED WITHOUT WARNING. THE FAILURE CAUSED THE FUEL PUMP TO SEIZE AND THE VEHICLE TO SHUT OFF. THE VEHICLE WAS TAKEN TO THE SAME DEALER AND THE CONTACT WAS INFORMED THAT THE FAILURE WAS NOT COVERED BY THE WARRANTY. THE CONTACT ALSO STATED THAT THE IDLER PULLEY BELT FRACTURED, WHICH CAUSED THE STEERING TO LOSE POWER AND THE AIR CONDITIONING TO LOSE ITS COOLING CAPABILITY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURES WERE NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.
NHTSA complaint #11268481 — an unverified report by a vehicle owner.
at 37,000 milesHouston, TX
STEERING
TL* THE CONTACT OWNS A 2017 RAM 5500. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SHIFTED OUT OF GEAR AND WENT INTO NEUTRAL. WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO SOUTHFORK CHRYSLER DODGE JEEP RAM (844-350-9615, LOCATED AT 17725 S FREEWAY, MANVEL, TX 77578) WHERE IT WAS DIAGNOSED THAT THE SHIFTER CABLE NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE FUSE IN THE FUEL PUMP OVERHEATED WITHOUT WARNING. THE FAILURE CAUSED THE FUEL PUMP TO SEIZE AND THE VEHICLE TO SHUT OFF. THE VEHICLE WAS TAKEN TO THE SAME DEALER AND THE CONTACT WAS INFORMED THAT THE FAILURE WAS NOT COVERED BY THE WARRANTY. THE CONTACT ALSO STATED THAT THE IDLER PULLEY BELT FRACTURED, WHICH CAUSED THE STEERING TO LOSE POWER AND THE AIR CONDITIONING TO LOSE ITS COOLING CAPABILITY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURES WERE NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.
NHTSA complaint #11268481 — an unverified report by a vehicle owner.
at 37,000 milesHouston, TX
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2017 RAM 5500. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE SHIFTED OUT OF GEAR AND WENT INTO NEUTRAL. WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO SOUTHFORK CHRYSLER DODGE JEEP RAM (844-350-9615, LOCATED AT 17725 S FREEWAY, MANVEL, TX 77578) WHERE IT WAS DIAGNOSED THAT THE SHIFTER CABLE NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE FUSE IN THE FUEL PUMP OVERHEATED WITHOUT WARNING. THE FAILURE CAUSED THE FUEL PUMP TO SEIZE AND THE VEHICLE TO SHUT OFF. THE VEHICLE WAS TAKEN TO THE SAME DEALER AND THE CONTACT WAS INFORMED THAT THE FAILURE WAS NOT COVERED BY THE WARRANTY. THE CONTACT ALSO STATED THAT THE IDLER PULLEY BELT FRACTURED, WHICH CAUSED THE STEERING TO LOSE POWER AND THE AIR CONDITIONING TO LOSE ITS COOLING CAPABILITY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURES WERE NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.
NHTSA complaint #11268481 — an unverified report by a vehicle owner.
Fayette, MSFire
ENGINE
TL* THE CONTACT OWNS A 2017 RAM 5500. WHILE THE CONTACT'S HUSBAND WAS DRIVING 50-55 MPH, SMOKE EMERGED FROM UNDER THE HOOD AND THE ENGINE CAUGHT FIRE. THE DRIVER EXTINGUISHED THE FIRE. THE SERVICE ENGINE AND OIL WARNING INDICATORS WERE ILLUMINATED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT AND THEN TOWED TO MAC HAIK CHRYSLER DODGE JEEP RAM FLOWOOD (4000 LAKELAND DR, FLOWOOD, MS 39232, (855) 223-8958) WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 35490335. THE MANUFACTURER DID NOT ASSIST. THE WARRANTY AND INSURANCE COMPANIES STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11256464 — an unverified report by a vehicle owner.
at 28,000 milesCarlsbad, NM
TIRES
TL* THE CONTACT OWNS A 2017 RAM 5500 EQUIPPED WITH NEXEN RODIAN TIRES, SIZE: LT235/80R17 (NA). TWO MONTHS AGO, THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE DEATH WOBBLE. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER, BUT IT WAS NOT DIAGNOSED. LATER, THE CONTACT TOOK THE VEHICLE TO TATE BRANCH ARTESI CHRYSLER DODGE JEEP RAM (919 S 1ST ST, ARTESIA, NM 88210) FOR A MINOR REPAIR. THE DEALER CALLED THE CONTACT AND STATED THAT THE VEHICLE HAD TWO SPLIT TIRES. THE MECHANIC DID NOT EXPLAIN WHICH TIRES WERE SPLIT. THE CONTACT PLANNED TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN AND DOT NUMBER WERE UNKNOWN. THE TIRE AND FAILURE MILEAGE WAS 28,000.
NHTSA complaint #11197187 — an unverified report by a vehicle owner.