Owners have filed 59 complaints
about the 2021 Tesla Model X with NHTSA between 2021 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 8 of 11 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 14
Against the median year of the Tesla Model X. 50 means typical for this
model; 100 means roughly double.
Severity — 100
25.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
100% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2021peak 5May 2026
NHTSA investigations into the 2021 Tesla Model X
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
5
investigations are
still open.
EA26002Opened 18 Mar 2026Still openELECTRICAL SYSTEM:ADAS
FSD Collisions in Reduced Roadway Visibility Conditions
The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and ca...
PE25012Opened 7 Oct 2025Still openELECTRICAL SYSTEM:ADAS
Traffic safety violations while Full Self Driving ("FSD") is engaged
The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects...
AQ25002Opened 20 Aug 2025Still openELECTRICAL SYSTEM:ADAS
Compliance with Standing General Order 2021-01 Reporting Requirements
The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a si...
The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise Control (TACC) and Autosteer. In describing the safety defect, Tesla’s Defect Information Report (DIR) explained that “the prominence and scope of the...
DP23002Opened 29 Jun 2023Still openVEHICLE SPEED CONTROL
Sudden Unintended Acceleration
The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petition and related materials can be reviewed at NHTSA.gov under the following ODI number: 11528471.
PE24033Opened 6 Jan 2025Closed 3 Apr 2026ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING
Actually Smart Summon sessions resulting in low-speed impacts.
On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all Sum...
PE24031Opened 17 Oct 2024Closed 18 Mar 2026ELECTRICAL SYSTEM:ADAS
FSD Collisions in Reduced Roadway Visibility Conditions
On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SGO-reported crashes identified in the opening document, and if so, the contributing circumstances for each of those crashes; and any updates or modificatio...
DP23001Opened 7 Apr 2023Closed 18 Mar 2026UNKNOWN OR OTHER
Defect Petition Interlock Request
On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls between the subject Tesla vehicles and internal combustion engine powered vehicles promote driver pedal misapplication, leading to sudden unintended acceleration (SUA) incidents. To fix this alleged de...
Recalls on the 2021 Tesla Model X
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
26V283000
BACK OVER PREVENTION:SOFTWARE
Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Risk: A delayed rearview image reduces the driver's view behind the vehicle, increasing the risk of a crash.
25V172000
AIR BAGS
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and 2021-2025 Model X vehicles. An air bag with the incorrect horn pad may have been installed, preventing the horn from sounding.
Risk: An inoperative horn may prevent the driver from alerting other drivers, increasing the risk of a crash.
24V967000
AIR BAGS:FRONTAL:DRIVER SIDE:CUSHION
Tesla, Inc. (Tesla) is recalling certain 2021-2025 Model S and Model X vehicles. The driver's air bag could tear during deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 212, "Windshield Mounting."
Risk: A torn air bag may not adequately protect an occupant in a crash, increasing the risk of injury.
24V554000
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Risk: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
24V376000
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
24V051000
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Risk: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Risk: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2024283109,791 units in Canada
Lights And Instruments
Issue: A previous over-the-air (OTA) software update could cause the vehicle not to display the correct visual warning indicators when there are problems with the brake system or when the parking brake is applied. As a result, the BRAKE, PARK, and antilock brake system (ABS) visual indicators would display as text instead of symbols. Safety Risk: While there is a low risk to safety, Canadian regulations require visual warnings to use common symbols, instead of words, to avoid driver confusion. Corrective Actions: Tesla will notify affected owners by email. Tesla has released an over-the-air software update to fix this problem. There is no further action required if your vehicle has software release 2024.3.25, 2024.14.5, or a release later than 2024.14.5.
Recall 2023657192,769 units in Canada
Accessories
Issue: On vehicles equipped with the Autosteer advanced driver-assistance feature, when using the feature, the vehicle may not provide strong enough warnings or monitor the driver closely enough to prevent misuse of the feature. Safety Risk: A driver that doesn't pay close attention while using the Autosteer feature or who doesn't react quickly when Autosteer is canceled could have an increased risk of a crash. Corrective Actions: Tesla will notify owners by email and supply an over-the-air software update to improve driver monitoring and alerts while using the Autosteer feature. Tesla advises that you must always pay attention and be ready to take control of the vehicle at any time while using the Autosteer advanced driver-assistance feature.
Recall 20235959 units in Canada
Airbag
Issue: On a small number of vehicles, the wrong airbag may have been installed on the steering wheel after it was replaced from yoke steering to a round steering wheel, or vice versa. Safety Risk: An incorrect airbag could increase the risk of injury in a crash. Corrective Actions: Tesla will notify owners by e-mail and advise you to contact Tesla Service to arrange for an inspection and, if necessary, the replacement of the steering wheel airbag.
Recall 20235463,233 units in Canada
Lights And Instruments
Issue: On certain vehicles, the low brake fluid warning lamp may not turn on if the brake fluid level gets too low. A low brake fluid level can cause reduced braking. Safety Risk: A driver that isn't aware of a low brake fluid level could experience reduced braking and an increased risk of a crash. Corrective Actions: Tesla has released an over-the-air software update to fix this problem. There is no further action required if your vehicle has software release 2023.32.7 or a later release. Tesla will notify affected owners by email.
Recall 202306320,667 units in Canada
Accessories
Issue: In certain traffic situations, when the FSD Beta advanced driver assistance feature is engaged, the vehicle may perform maneuvers that break certain traffic laws, if the driver doesn't intervene and take control. Note: This recall only affects vehicles equipped with the FSD Beta feature. Safety Risk: Certain maneuvers performed by the FSD Beta advanced driver assistance feature may break traffic laws. This could increase the risk of a crash if the driver doesn't intervene. Corrective Actions: Tesla will notify owners by email and supply an over-the-air software update to improve how the FSD Beta feature maneuvers the vehicle in certain traffic situations. Tesla reminds that FSD Beta is only an advanced driver assistance feature, and the driver must pay attention and be ready to take control at all times when the feature is engaged.
Recall 202222811,636 units in Canada
Electrical
Issue: On certain vehicles, during fast-charging or preparation for fast-charging, the infotainment central processing unit (CPU) may overheat. This could cause the CPU to be slow or to restart. As a result, the center screen display may lag or appear blank. If this happens, the rearview camera display, windshield wiper and defroster settings, drive modes (i.e., Drive, Neutral, or Reverse), and telltales may not be available. Safety Risk: A driver who does not have access to vehicle systems and controls could have an increased risk of a crash. Corrective Actions: Tesla will email a notice to owners and provide an over-the-air firmware update to fix this problem.
Reports where the owner recorded a crash, a fire, an injury or a death.
Irvine, CACrash
LANE DEPARTURE: BLIND SPOT DETECTION
This complain is regarding the recent recall regarding FSD tesla Smart Summon failures. Incident date June 02, 2024 Car was parked in a parking lot outside a movie theater. I was less than 20 feet away from car with clear visibility, and tried smart summon. Car pulled out of the parking making an acute turn damaging driver side door, and front bumper of car parked next to it. Tesla was contacted immediately regarding this malfunction of smart summon and requested them to stop offering this service to owners as it is dangerous. They took 3 months to conduct an internal investigation but refused to share written results. Instead read a generic statement from their website. Still not received a copy of the investigation. Tesla also refused to take take financial responsibility for the damage and their false claim. Smart Summon is dangerous and Tesla should not be allowed to advertise.
NHTSA complaint #11635046 — an unverified report by a vehicle owner.
Irvine, CACrash
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
This complain is regarding the recent recall regarding FSD tesla Smart Summon failures. Incident date June 02, 2024 Car was parked in a parking lot outside a movie theater. I was less than 20 feet away from car with clear visibility, and tried smart summon. Car pulled out of the parking making an acute turn damaging driver side door, and front bumper of car parked next to it. Tesla was contacted immediately regarding this malfunction of smart summon and requested them to stop offering this service to owners as it is dangerous. They took 3 months to conduct an internal investigation but refused to share written results. Instead read a generic statement from their website. Still not received a copy of the investigation. Tesla also refused to take take financial responsibility for the damage and their false claim. Smart Summon is dangerous and Tesla should not be allowed to advertise.
NHTSA complaint #11635046 — an unverified report by a vehicle owner.
This complain is regarding the recent recall regarding FSD tesla Smart Summon failures. Incident date June 02, 2024 Car was parked in a parking lot outside a movie theater. I was less than 20 feet away from car with clear visibility, and tried smart summon. Car pulled out of the parking making an acute turn damaging driver side door, and front bumper of car parked next to it. Tesla was contacted immediately regarding this malfunction of smart summon and requested them to stop offering this service to owners as it is dangerous. They took 3 months to conduct an internal investigation but refused to share written results. Instead read a generic statement from their website. Still not received a copy of the investigation. Tesla also refused to take take financial responsibility for the damage and their false claim. Smart Summon is dangerous and Tesla should not be allowed to advertise.
NHTSA complaint #11635046 — an unverified report by a vehicle owner.
Apple Valley, CACrash1 injured
VEHICLE SPEED CONTROL
On 10-16-21 Saturday around 7:40 PM, I was going to my brother-in-law's house which is on the left side of the road I was driving. It is a single lane road in a busy residential area. I wanted to park outside of the house by the road. I took a left turn towards the gate, then slight reverse and put in drive to pull to park parallel to the road. My Tesla Model-x went into 'Sudden Unintended Acceleration' mode, went left to right to left in a violent way, picking up speed like a rocket. I applied the breaks repeatedly, but the car did not stop and continued to race on the road for about 0.3 mile where the road takes slight left turn. It went and crashed into a 40 ft tall big pine tree at probably more than 150 mph. It knocked off part of the compound wall of the owner, and passenger front tire blew away and landed in their front yard. I had the seat belt on. No other vehicle involved. I was the only occupant in the vehicle. No fire. I called 911 from my cell phone. I opened the driver side door manually and got out. Police took the report from me and took pictures. The report will be in another 3 days. Ambulance took me to hospital. Broke rt Ulna, Lumbar 2 vertebra, Pneumothorax lt lung with collapse of left lung, s/p chest tube. Also cervical muscle strain/ rupture. Discharge after 3 days. Still lot of back pain. Unable to go to work. Car is total loss. I have Tesla insurance. Reported the accident to Insurance. Adjuster still working on the claim. Requested to 'Preserve the car' for further investigation. 7-14-21: When I stop at a light, the front end of car goes up by about 4 inches. Took to Tesla service center and I was told it is adaptive suspension and it is normal. 8-10-21. When I apply break to stop at a red light, and when I turn on Left turn signal, power shuts off completely, everything blank in the middle of busy traffic, had to reset power. very scary. Happened twice. complained. Tesla remotely updated SD card. Happened again on 10-15-21.
NHTSA complaint #11438228 — an unverified report by a vehicle owner.
Apple Valley, CACrash1 injured
SUSPENSION
On 10-16-21 Saturday around 7:40 PM, I was going to my brother-in-law's house which is on the left side of the road I was driving. It is a single lane road in a busy residential area. I wanted to park outside of the house by the road. I took a left turn towards the gate, then slight reverse and put in drive to pull to park parallel to the road. My Tesla Model-x went into 'Sudden Unintended Acceleration' mode, went left to right to left in a violent way, picking up speed like a rocket. I applied the breaks repeatedly, but the car did not stop and continued to race on the road for about 0.3 mile where the road takes slight left turn. It went and crashed into a 40 ft tall big pine tree at probably more than 150 mph. It knocked off part of the compound wall of the owner, and passenger front tire blew away and landed in their front yard. I had the seat belt on. No other vehicle involved. I was the only occupant in the vehicle. No fire. I called 911 from my cell phone. I opened the driver side door manually and got out. Police took the report from me and took pictures. The report will be in another 3 days. Ambulance took me to hospital. Broke rt Ulna, Lumbar 2 vertebra, Pneumothorax lt lung with collapse of left lung, s/p chest tube. Also cervical muscle strain/ rupture. Discharge after 3 days. Still lot of back pain. Unable to go to work. Car is total loss. I have Tesla insurance. Reported the accident to Insurance. Adjuster still working on the claim. Requested to 'Preserve the car' for further investigation. 7-14-21: When I stop at a light, the front end of car goes up by about 4 inches. Took to Tesla service center and I was told it is adaptive suspension and it is normal. 8-10-21. When I apply break to stop at a red light, and when I turn on Left turn signal, power shuts off completely, everything blank in the middle of busy traffic, had to reset power. very scary. Happened twice. complained. Tesla remotely updated SD card. Happened again on 10-15-21.
NHTSA complaint #11438228 — an unverified report by a vehicle owner.
On 10-16-21 Saturday around 7:40 PM, I was going to my brother-in-law's house which is on the left side of the road I was driving. It is a single lane road in a busy residential area. I wanted to park outside of the house by the road. I took a left turn towards the gate, then slight reverse and put in drive to pull to park parallel to the road. My Tesla Model-x went into 'Sudden Unintended Acceleration' mode, went left to right to left in a violent way, picking up speed like a rocket. I applied the breaks repeatedly, but the car did not stop and continued to race on the road for about 0.3 mile where the road takes slight left turn. It went and crashed into a 40 ft tall big pine tree at probably more than 150 mph. It knocked off part of the compound wall of the owner, and passenger front tire blew away and landed in their front yard. I had the seat belt on. No other vehicle involved. I was the only occupant in the vehicle. No fire. I called 911 from my cell phone. I opened the driver side door manually and got out. Police took the report from me and took pictures. The report will be in another 3 days. Ambulance took me to hospital. Broke rt Ulna, Lumbar 2 vertebra, Pneumothorax lt lung with collapse of left lung, s/p chest tube. Also cervical muscle strain/ rupture. Discharge after 3 days. Still lot of back pain. Unable to go to work. Car is total loss. I have Tesla insurance. Reported the accident to Insurance. Adjuster still working on the claim. Requested to 'Preserve the car' for further investigation. 7-14-21: When I stop at a light, the front end of car goes up by about 4 inches. Took to Tesla service center and I was told it is adaptive suspension and it is normal. 8-10-21. When I apply break to stop at a red light, and when I turn on Left turn signal, power shuts off completely, everything blank in the middle of busy traffic, had to reset power. very scary. Happened twice. complained. Tesla remotely updated SD card. Happened again on 10-15-21.
NHTSA complaint #11438228 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Boca Rotaon, FL
STRUCTURE:BODY
Both Garnish - Fender - Front - LH Right side and Left side come loose when driving in rain. The force of wheels pushing rain water on the fender garnish causes both the left and right fender garnish 4 push clips to come loose. When this fender garnish breaks and flies off it could hit a pedestrian, another car on the road or the car it is installed on causing an accident
NHTSA complaint #11741161 — an unverified report by a vehicle owner.
Stafford, VA
STEERING
Steering got stuck on the road while driving. I couldnt move or change lanes. It was really scary. Then I slowed down and then I had tp pull out of the road to the shoulder. Then I waited for 20-30 mins and restarted the car. Then it worked. I was able to go home. I contacted Tesla and they said they need to look into the issue. At the service center, now they are saying they need to replace entire steering system and the cost is 5000. This is not fair and unprofessional. And it is very scary experience.
NHTSA complaint #11695485 — an unverified report by a vehicle owner.
Balboa Island, CA
STEERING
Heavy steering warning. Steering gear left hand drive.
NHTSA complaint #11694883 — an unverified report by a vehicle owner.
Oakland, CA
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
While driving our screen shut down, autopilot and GPS stopped working and the doors would not open. My kids were stuck on multiple occasions and had to climb through the front seats. Tesla has already confirmed that the Driver Assistance System ECU (Turbo A and Turbo B processors) is a known issue. Over 1600 cases reported. This defect disables safety-critical driver-assist functions without warning, which meets the federal definition of a safety defect under 49 U.S.C. § 30102. Provide a free remedy to owners — including replacement at no cost — as required by 49 U.S.C. § 30120. Telsa denied coverage because we are out of warranty. I asked whether the known issue has been reported and why it is not being covered as a known safety defect. Because the problem involves loss of a safety system, it should not be treated as routine maintenance or wear and tear. It is a known safety defect and therefore must be reported and remedied at Tesla’s expense. Tesla refuse to address my concern and would only let me talk to store manager. They told me I had to email business resolutions to get more information. I have not heard back. I was forced to spend $2k to get my car fixed
NHTSA complaint #11683268 — an unverified report by a vehicle owner.
Oakland, CA
ELECTRICAL SYSTEM
While driving our screen shut down, autopilot and GPS stopped working and the doors would not open. My kids were stuck on multiple occasions and had to climb through the front seats. Tesla has already confirmed that the Driver Assistance System ECU (Turbo A and Turbo B processors) is a known issue. Over 1600 cases reported. This defect disables safety-critical driver-assist functions without warning, which meets the federal definition of a safety defect under 49 U.S.C. § 30102. Provide a free remedy to owners — including replacement at no cost — as required by 49 U.S.C. § 30120. Telsa denied coverage because we are out of warranty. I asked whether the known issue has been reported and why it is not being covered as a known safety defect. Because the problem involves loss of a safety system, it should not be treated as routine maintenance or wear and tear. It is a known safety defect and therefore must be reported and remedied at Tesla’s expense. Tesla refuse to address my concern and would only let me talk to store manager. They told me I had to email business resolutions to get more information. I have not heard back. I was forced to spend $2k to get my car fixed
NHTSA complaint #11683268 — an unverified report by a vehicle owner.
Denton, TX
STEERING
After completing a 17.5-hour, ~1,000-mile non-stop road trip from Florida to Texas using Autopilot with no interventions or issues, the following week this vehicle experienced a sudden and total steering failure while slowly turning through my residential neighborhood. The steering locked up without warning and caused the car to drift partially into the opposing lane. No power steering warning was shown prior to the failure. Tesla Service diagnosed and replaced both the Front Body Controller (Part #1585663-00-C) and the Steering Gear Assembly (Part #1070801-00-F) under warranty. This is an extremely dangerous failure scenario — had it occurred at high speed, the outcome could have been catastrophic. I am reporting this to ensure it’s documented and investigated, as it appears consistent with similar steering failure complaints in 2021+ Model X vehicles.
NHTSA complaint #11674412 — an unverified report by a vehicle owner.
Olympia, WA
UNKNOWN OR OTHER
Driving speed limit of 50 miles an hour on a two lane road and went to push the accelerator pedal and the entire assembly snapped completely off and was unable to continue driving the car
NHTSA complaint #11672170 — an unverified report by a vehicle owner.
San Clemente, CA
STEERING
My car has 50,000 miles on it and is just over 4 years old. The steering column has failed causing it to not be able to steer. The service for this is a new steering column at a cost of over $5,000.00. The Y models and 3 models had a recall on this issue. Now it looks like the X models are having the issue as well. The consumer should not be responsible for this. It is dangerous. It is expensive to fix. A steering column should not fail at 50,000 miles. I am not the only person who has been faced with this issue. Tesla service even confirmed that they are seeing this on the X models. I think an investigation should be done. How many $5,000.00 repairs for safety has the consumer been saddled with?
NHTSA complaint #11668225 — an unverified report by a vehicle owner.
Tampa, FL
SUSPENSION
Summary: The front suspension defect on my 2021 Model X, confirmed by St. Petersburg Service Center (Invoice #3000S0013156326), presents a serious safety hazard. Timeline & Concern: Reported Dec 4, 2024, under ESA. Example of Tesla’s delay tactics—service was scheduled only after warranty lapsed. Issue diagnosed in May 2025 as a faulty front upper control arm. Safety risk: Failure could lead to loss of control. I request a safety investigation to prevent similar unsafe compromises.
NHTSA complaint #11668235 — an unverified report by a vehicle owner.
San Clemente, CA
LANE DEPARTURE: ASSIST
My car has 50,000 miles on it and is just over 4 years old. The steering column has failed causing it to not be able to steer. The service for this is a new steering column at a cost of over $5,000.00. The Y models and 3 models had a recall on this issue. Now it looks like the X models are having the issue as well. The consumer should not be responsible for this. It is dangerous. It is expensive to fix. A steering column should not fail at 50,000 miles. I am not the only person who has been faced with this issue. Tesla service even confirmed that they are seeing this on the X models. I think an investigation should be done. How many $5,000.00 repairs for safety has the consumer been saddled with?
NHTSA complaint #11668225 — an unverified report by a vehicle owner.
San Clemente, CA
LANE DEPARTURE: WARNING
My car has 50,000 miles on it and is just over 4 years old. The steering column has failed causing it to not be able to steer. The service for this is a new steering column at a cost of over $5,000.00. The Y models and 3 models had a recall on this issue. Now it looks like the X models are having the issue as well. The consumer should not be responsible for this. It is dangerous. It is expensive to fix. A steering column should not fail at 50,000 miles. I am not the only person who has been faced with this issue. Tesla service even confirmed that they are seeing this on the X models. I think an investigation should be done. How many $5,000.00 repairs for safety has the consumer been saddled with?
NHTSA complaint #11668225 — an unverified report by a vehicle owner.
Murrieta, CA
STEERING
Steering assist error code. Car has less than 25,000 miles and Tesla is reporting this is common and the steering rack needs to be replaced and the steering gear left hand drive. Tesla Temecula also said there was a system malfunction that caused it but they do not dig into that they just do the service for $5100. Looking online this is common.
NHTSA complaint #11664453 — an unverified report by a vehicle owner.
Berkeley, CA
STRUCTURE:BODY
My 2021 Tesla Model X has a serious safety issue with the driver’s door. When opened, the door swings freely with no support or soft-close resistance and can slam shut or fling wide open unexpectedly. This poses a danger to passengers and nearby people or property. I believe this issue may relate to a latch or hinge mechanism malfunction, and I am concerned about the lack of a safety interlock. I have reported this to Tesla, and they have not acknowledged it as a warranty or safety concern. I am submitting this complaint in the interest of safety for myself and other drivers of this model. I have videos and more detail but this site only allows static photos.
NHTSA complaint #11659206 — an unverified report by a vehicle owner.
Lynn, MA
VISIBILITY/WIPER
Windshield cracked due to defrosting; yes available for inspection upon request. If the windshield shatters due to defrosting this is serious safety risk and what can happen while driving is limited less. Vehicle was inspected by Tesla located in Peabody, Massachusetts and the representative stated they are aware, and this is why they tell customers to warm the vehicle up before turning on defrosting, in all the vehicles I've owned windshield cracking from defroster being on has never happened or been an issue. Also through research I found other Tesla owners have experienced similar. No there were no warnings of this happening outside of reading other Tesla owners experiencing this similar situation.
NHTSA complaint #11640531 — an unverified report by a vehicle owner.
Irvine, CACrash
LANE DEPARTURE: BLIND SPOT DETECTION
This complain is regarding the recent recall regarding FSD tesla Smart Summon failures. Incident date June 02, 2024 Car was parked in a parking lot outside a movie theater. I was less than 20 feet away from car with clear visibility, and tried smart summon. Car pulled out of the parking making an acute turn damaging driver side door, and front bumper of car parked next to it. Tesla was contacted immediately regarding this malfunction of smart summon and requested them to stop offering this service to owners as it is dangerous. They took 3 months to conduct an internal investigation but refused to share written results. Instead read a generic statement from their website. Still not received a copy of the investigation. Tesla also refused to take take financial responsibility for the damage and their false claim. Smart Summon is dangerous and Tesla should not be allowed to advertise.
NHTSA complaint #11635046 — an unverified report by a vehicle owner.
Irvine, CACrash
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
This complain is regarding the recent recall regarding FSD tesla Smart Summon failures. Incident date June 02, 2024 Car was parked in a parking lot outside a movie theater. I was less than 20 feet away from car with clear visibility, and tried smart summon. Car pulled out of the parking making an acute turn damaging driver side door, and front bumper of car parked next to it. Tesla was contacted immediately regarding this malfunction of smart summon and requested them to stop offering this service to owners as it is dangerous. They took 3 months to conduct an internal investigation but refused to share written results. Instead read a generic statement from their website. Still not received a copy of the investigation. Tesla also refused to take take financial responsibility for the damage and their false claim. Smart Summon is dangerous and Tesla should not be allowed to advertise.
NHTSA complaint #11635046 — an unverified report by a vehicle owner.
This complain is regarding the recent recall regarding FSD tesla Smart Summon failures. Incident date June 02, 2024 Car was parked in a parking lot outside a movie theater. I was less than 20 feet away from car with clear visibility, and tried smart summon. Car pulled out of the parking making an acute turn damaging driver side door, and front bumper of car parked next to it. Tesla was contacted immediately regarding this malfunction of smart summon and requested them to stop offering this service to owners as it is dangerous. They took 3 months to conduct an internal investigation but refused to share written results. Instead read a generic statement from their website. Still not received a copy of the investigation. Tesla also refused to take take financial responsibility for the damage and their false claim. Smart Summon is dangerous and Tesla should not be allowed to advertise.
NHTSA complaint #11635046 — an unverified report by a vehicle owner.
Denton, TX
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Unintended, unexpected opening of front frunk hood while driving slowly in a parking lot into a strong wind gust. I did not deploy frunk switch and Secondary latch apparently inoperative
NHTSA complaint #11629420 — an unverified report by a vehicle owner.
Centreville, VA
UNKNOWN OR OTHER
12v Battery is keep discharging in every two to three months. Tesla service can't find issues or not telling me what is the reason. I have got 5 replacements of 12v battery in last one year. So I think there is a issue in car or bug they are not able to fix it because of limitation. Please let me know how to handle this.
NHTSA complaint #11620318 — an unverified report by a vehicle owner.
Lincoln, NE
STEERING
Alerts: UI_a020 - Steering Assist Reduced APP_w264 - Lane Departure features unavailable This incident happened suddenly during a normal commute from work to home. It caused the steering of the vehicle to be very heavy and difficult to control which could have potentially led to an unwanted accident on the road. There root cause seems to be a failure in the steering rack component of the car. It is a very common and prevalent issue with Tesla vehicles, and complaints on various Tesla forums and Reddit threads about this same issue. There also has been NHTSA investigations in the past regarding this. The failure caused the loss of safety functionality such as Lane Keeping Assistance, Lane Departure Assistance, Autopilot and FSD. Tesla Service Center diagnosed the alerts as a steering rack hardware failure and is charging almost $5000 to replace the part. Given that this is such a prevalent issue among so many Tesla vehicles, it needs to be addressed by the manufacturer and should be a safety recall and not on the customer to pay out of pocket.
NHTSA complaint #11616404 — an unverified report by a vehicle owner.
Lincoln, NE
LANE DEPARTURE: ASSIST
Alerts: UI_a020 - Steering Assist Reduced APP_w264 - Lane Departure features unavailable This incident happened suddenly during a normal commute from work to home. It caused the steering of the vehicle to be very heavy and difficult to control which could have potentially led to an unwanted accident on the road. There root cause seems to be a failure in the steering rack component of the car. It is a very common and prevalent issue with Tesla vehicles, and complaints on various Tesla forums and Reddit threads about this same issue. There also has been NHTSA investigations in the past regarding this. The failure caused the loss of safety functionality such as Lane Keeping Assistance, Lane Departure Assistance, Autopilot and FSD. Tesla Service Center diagnosed the alerts as a steering rack hardware failure and is charging almost $5000 to replace the part. Given that this is such a prevalent issue among so many Tesla vehicles, it needs to be addressed by the manufacturer and should be a safety recall and not on the customer to pay out of pocket.
NHTSA complaint #11616404 — an unverified report by a vehicle owner.
Lincoln, NE
LANE DEPARTURE: WARNING
Alerts: UI_a020 - Steering Assist Reduced APP_w264 - Lane Departure features unavailable This incident happened suddenly during a normal commute from work to home. It caused the steering of the vehicle to be very heavy and difficult to control which could have potentially led to an unwanted accident on the road. There root cause seems to be a failure in the steering rack component of the car. It is a very common and prevalent issue with Tesla vehicles, and complaints on various Tesla forums and Reddit threads about this same issue. There also has been NHTSA investigations in the past regarding this. The failure caused the loss of safety functionality such as Lane Keeping Assistance, Lane Departure Assistance, Autopilot and FSD. Tesla Service Center diagnosed the alerts as a steering rack hardware failure and is charging almost $5000 to replace the part. Given that this is such a prevalent issue among so many Tesla vehicles, it needs to be addressed by the manufacturer and should be a safety recall and not on the customer to pay out of pocket.
NHTSA complaint #11616404 — an unverified report by a vehicle owner.
Flagstaff, AZ
STEERING
Steering rack failure: replacement needed for Model X 2021 at approximately 55K miles. From Tesla Service Center: Concern: Customer states: Alerts - Steering assist reduced/Steering may require increased effort. Repair Notes: Performed vehicle data review found alerts for steering rack assembly, inspected steering rack harness connections found good connections, inspected for any outside influence found none. Found steering rack has non-serviceable internal fault. Recommend steering rack assembly replacement and alignment check. Correction: Steering Rack (Remove & Replace) - Remove and Replace Part Quantity and Labor Hours $4,641.46 + taxes
NHTSA complaint #11612318 — an unverified report by a vehicle owner.
Villanova, PA
STEERING
I was driving and the car started changing lanes. The steering became heavy and I was barely able to move it and required extreme force. Tesla screen displayed ( steering assist reduced ). I almost died. I was facing cars on both directions and was barely able to get my self to a safe spot. There was no warning before this happened. The car is currently with dealer The steering became acutely extremely heavy and unresponsive and locked on a busy road
NHTSA complaint #11595384 — an unverified report by a vehicle owner.
Lafayette, CA
STEERING
The steering locked up and it would not move. This happened as I was driving on a road at about 35 miles per hour. I could not steer until I dropped the car speed under 10 miles an hour and using great force was able to navigate the car to safety. I had the car towed to Tesla for repair. They kept it about 4 days and returned it. Within 40 miles of driving the car gave a notification that the steering was "reduced". I was in the car with my [XXX] daughter and about to get on the freeway. I immediately pulled over and had the car towed again to Tesla for repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11591867 — an unverified report by a vehicle owner.