36 of the 337 complaints about the 2004 Toyota Highlander are about the steering — 11% of everything reported for this model year. Half of the failures with a mileage on record happened before 47,778 miles.
36
Complaints
1
Crashes
0
Fires
1
Injuries
Filed with NHTSA, in their own words.
STEERING
Hello, I am the Buyer of the subject Vehicle, Upon doing my research, I found out several reports stating that The subject vehicle's 2.4L engine has manufacturing defect, that causes Head Bolts to get stripped/melt down in to oil causing Engine failures and Life threating risk in the middle of the road.
NHTSA complaint #11739508 — an unverified report by a vehicle owner.
STEERING
WHILE TRAVELING THROUGH A HIGHWAY CONSTRUCTION ZONE MY CAR SUDDENLY BECAME HARD TO STEER, AND MY SPEED BECAME GREATER, TRIED TO (BREAK) DECELERATE THE CAR BEGAN SLIDING OUT OF CONTROL-PLOWING INTO THE ROAD CONSTRUCTION BARRIERS PART LODGED IN FRONT PASSENGER WINDSHIELD. THE CAR WENT THROUGH THE DITCH BECAME AIRBORNE THROUGH A ROD IRON FENCE SHATTERED THE REAR SECOND-ROW RIGHT SIDE WINDOW SPUN OUT , AND CAME TO REST JUST FEET FROM THE SOME PILEINGS. THIS IS THE INFORMATION OF MY DAUGHTER WHOM IS AN OUT OF STATE COLLEGE SENIOR AND VERY SHAKEN UP FROM THIS ORDEAL, THIS HER STATEMENT TO THE BEST OF MY KNOWLEDGE. POSSIBLY THE PLACEMENT OF THE 🚧 COULD HAVE BEEN A CONTRIBUTOR, AND THE UNCONTROLLABLE ACCELERATION. VEHICLE WAS BOUGHT USED A YEAR AGO. CAN YOU HELP UP LEARN WHY?
NHTSA complaint #11355039 — an unverified report by a vehicle owner.
STEERING
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE REQUIRED GREATER EFFORT TO STEER. WHILE STEERING THE VEHICLE, THERE WAS AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WERE IT WAS DIAGNOSED THAT THE STEERING INTERMEDIATE STAFF ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 123,000.
NHTSA complaint #10883405 — an unverified report by a vehicle owner.
STEERING
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 45 MPH, THE BATTERY INDICATOR LIGHT ILLUMINATED AND THE POWER STEERING FAILED SUDDENLY. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE VEHICLE WAS NOT REPAIRED. THE VIN PROVIDED WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA complaint #10670096 — an unverified report by a vehicle owner.
STEERING
WITH NO WARNING OR PRIOR INDICATION OF ANY PROBLEM, THE STEERING RACK AND PINION BROKE MAKING THE VEHICLE COMPLETELY UN-STEERABLE. TOYOTA REPAIR FOUND THAT THE POWER STEERING PUMP BELT WAS BROKEN AND THE PUMP HAD LOCKED UP. THE VEHICLE WAS BEING DRIVEN ON A FREEWAY THROUGH THE MOUNTAINS AND IT WAS JUST FORTUNATE THAT THE INCIDENT OCCURRED ON ONE OF THE FEW STRAIGHT STRETCHES AND IT WAS POSSIBLE TO KEEP THE VEHICLE ON THE ROAD SURFACE.
NHTSA complaint #10479785 — an unverified report by a vehicle owner.
STEERING
THE STEERING ANGLE SENSOR WENT ON RANDOMLY DURING DRIVING, THE TRACTION CONTROL INDICATOR LIGHT WAS ON, CAUSING ENGINE SPEED SLOW DOWN AND SLUGGISH ON ROAD, IT HAPPENED A FEW TIMES. I DROVE SLOWLY TO THE DEALER, IT COSTS OVER $600.00 TO FIX THE PROBLEM, I AM VERY DISAPPOINTED AT TOYOTA.
NHTSA complaint #10434744 — an unverified report by a vehicle owner.
STEERING
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHEN THE ENGINE WAS STARTED THE STEERING ANGLE SENSOR WARNING LIGHT ILLUMINATED AND THE STEERING BECAME DIFFICULT TO HANDLE. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT WAS UNABLE TO LOCATE A FAILURE. THE VEHICLE WAS TEST DRIVEN AND THE FAILURE WAS RECREATED. THE DEALER REPLACED THE STEERING ANGLE SENSOR. THE FAILURE AND THE CURRENT MILEAGE WAS 14,000. UPDATED 5/2/11
NHTSA complaint #10393110 — an unverified report by a vehicle owner.
STEERING
2004 HIGHLANDER - STEERING FAILED ON MAJOR SHOPPING ROAD TODAY. HEARD ONLY A HISSING SOUND IN THE ENGINE COMPARTMENT WITH A LARGE PLUME OF DARK SMOKE OUT THE TAIL PIPE. ENGINE DID NOT QUIT BUT WAS LUCKY TO BE ABLE TO PULL WHEEL HARD RIGHT TO TURN INTO PARKING LOT. AI/C STAYED ON, DID NOT OVERHEAT, TIMING BELT JUST CHANGED, NO LEAKING FLUIDS BUT MOST OF ALL NO WARNING LIGHTS OR CHECK ENGINE LITE CAME ON. HAD PROBLEM LAST MONTH WITH A/C WHICH WAS FIXED. WHAT HAPPENS TO SOMEONE DRIVING AT 65 ON HIGHWAY AND LOSES ABILITY TO STEER ... INSTANT DEATH TO DRIVER AND PERHAPS MANY OTHERS. BEEN A TOYOTA FAN FOR 30 YEARS BUT THIS COUPLED WITH OTHER MAJOR RECALLS SERIOUSLY FRIGHTENS ME TO GET BEHIND THE WHEEL AGAIN. CAR WAS TOWED TO TOYOTA DEALER WHO HAS MAINTAINED THE CAR SINCE 2004. AWAITING OUTCOME OF INVESTIGATION. POSTED 8-9-10.
NHTSA complaint #10348382 — an unverified report by a vehicle owner.
STEERING
TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE DRIVING AT SPEEDS OF 5 MPH AND ATTEMPTING A TURN, THE CONTACT HEARD AN UNUSUAL CLANKING NOISE COMING FROM THE STEERING WHEEL. THE DEALER WAS UNABLE TO DUPLICATE OR DETERMINE WHERE THE NOISE HAD COME FROM. THE CONTACT STATED THE NOISE WAS HEARD ONE ADDITIONAL TIME. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 32,000 AND THE CURRENT WAS 44,000.
NHTSA complaint #10326584 — an unverified report by a vehicle owner.
STEERING
"INTERMEDIATE SHAFT FAILURES ON 04-05 TOYOTA HIGHLANDER" THERE IS A TECHNICAL SERVICE BULLETIN (ST001-06) OF SHAFT REPLACEMENT ON SOME MODELS BUT NEVER BECAME A SAFETY RECALL ISSUE. ON TOYOTA PRIUS NHW20 MODEL VEHICLES PRODUCED IN JAPAN FROM JULY 2003 TO NOV 2005 ARE BEING RECALLED. TOYOTA SAYS ON SOME VEHICLE, UNDER CERTAIN CONDITIONS, THE STEERING INTERMEDIATE SHAFT MAY BECOME LOOSE OR DEVELOP A CRACK. WHAT ABOUT THOSE PEOPLE WHO WANTS TO KEEP THEIR TOYOTA FOR A LIFETIME? MINE IS AN SUV(HIGHLANDER) WITH A HIGHER CENTER OF GRAVITY AND ROLLING FORCE. YOUR HELP ON THIS MATTER IS DEEPLY APPRECIATED.
NHTSA complaint #10313920 — an unverified report by a vehicle owner.
STEERING
TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE VEHICLE WAS STATIONARY. THE CONTACT STARTED THE IGNITION AND TURNED THE STEERING WHEEL TO THE LEFT AND THE RIGHT. THE STEERING WHEEL EXHIBITED A SLIGHT VIBRATION AND NOISE. THE FAILURE OCCURRED WHENEVER THE STEERING WHEEL WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE VEHICLE COULD BE DRIVEN AND IF THE FAILURE PROGRESSED TO RETURN IT FOR REPAIR. THE FAILURE MILEAGE WAS 45,000. UPDATED 4/22/10 *CN UPDATED 06/01/10
NHTSA complaint #10313128 — an unverified report by a vehicle owner.
STEERING
STEERING WHEEL MAKE A NOISE LIKE A BOLT IS MISSING.
NHTSA complaint #10281722 — an unverified report by a vehicle owner.
STEERING
2004 HIGHLANDER, HAVING SAME PROBLEMS AS ALL OTHER REPORTED PROBLEMS FOR THIS VEHICLE. HESITATION, STEERING SHAFT REPLACEMENT, 2 WHEEL BEARING REPLACEMENTS, LOUSY ORIGINAL TIRES, BAD SODERING OF HEAT/AIR BOARD LEADING TO NOT WORKING PROPERLY, CAN NOT HAVE BACK WINDOWS DOWN DUE TO NOISE AND VEHICLE SHAKING, HAD REAR WIPER MOTOR REPLACED WITHIN 1ST MONTH OF OWNERSHIP. WHILE I DID PURCHASE THE EXTENDED WARRANTY, WHICH DID COVER THE COST OF THE WHEEL BEARING REPLACEMENT, IT DID NOT COVER THE COST OF HAVING TO REPLACE THE TIRES DAMAGED BY THE BAD BEARING - AND TOYOTA DOES NOT CARE. IN THEIR RACE TO BECOME THE NUMBER ONE CAR MAKER, THEY HAVE GIVEN UP ON BEING THE SAFEST, MOST RELIABLE CAR MAKER - AND THEY HAVE CERTAINLY GIVEN UP ON BEING CUSTOMER FRIENDLY. ACCORDING TO SEVERAL TOYOTA DEALERS, THEY DON'T HAVE TO, SINCE THEY CONTINUE TO BE POPULAR SELLING VEHICLES. I AM GETTING NERVOUS AS THE TIME FOR MY WARRANTY COMES DUE TO EXPIRE - AND FOR THE FIRST TIME AM SERIOUSLY CONSIDERING TRADING IT IN BEFORE THAT HAPPENS. THAT WAS NOT THE INTENT WHEN I BOUGHT THE VEHICLE, BUT AFTER READING ALL THE PEOPLE HAVING ALL THE SAME PROBLEMS, I AM VERY CONCERNED.
NHTSA complaint #10273069 — an unverified report by a vehicle owner.
STEERING
STEERING. LOOSENESS WHEN TURNING LEFT OR RIGHT. DEALER REPLACED PART (45220-48150 SHAFT ASSY) @ A COST OF $387.93 (THIS WITH A 15% DISCOUNT). IN READING YOUR COMPLAINTS FILED, I NOTE THIS WASN'T T/1ST TIME THIS HAS BEEN REPORTED & AS STATED, THERE IS A DEALER SERVICE ADVISORY ON IT. I ALSO TOOK NOTE THAT THERE APPARENTLY HASN'T BEEN ANY ACTION 2 RESOLVE THE MATTER (IE, THE OWNER CONTINUES 2 PAY 4 REPAIRS). SHOULD NOT TOYOTA B REQUIRED 2 COVER THIS TYPE OF REPAIR ? LIKE WE'RE TALKING STEERING HERE. IS IT GOING TO TAKE SOMEONE WHO JUST LET'S THE PROBLEM GO TO THE POINT WHERE HE/SHE LOOSES CONTROL OF THE VEHICLE & THERE IS PHYSICAL INJURY OR DEATH? I WAS HESITANT TO WRITE THIS UP BECAUSE I DON'T SEE WHERE N INVESTIGATION HAS BEEN CONDUCTED (DID I JUST MISS IT?). MY VEHICLE HAS JUST UNDER 55K MILES ON IT (ALL OF THEM ONROAD) &S BEEN MAINTAINED BY THE DEALER. TO ME IT LOOKS LIKE A $$$ MAKER 4 THE DEALER & A CALCULATED DECISION BY TOYOTA THAT ENOUGH OF THOSE REQUIRING THE REPAIR WOULDN'T COMPLAIN; LOOKS LIKE TOYOTA WINS.
NHTSA complaint #10269450 — an unverified report by a vehicle owner.
STEERING
WIFE WAS DRIVING ON CLEAN DRY ROAD. SUDDENLY, THE VCS LIGHT AND TRACTION LIGHTS CAME ON THE DASHBOARD WHILE ALARM SOUNDING CAME ON AS WELL. CAR SUDDENLY BRAKED, BRAKES MADE A GRINDING SOUND, AND CAR JERKED TO THE RIGHT. TRIED TO DRIVE FORWARD AND IT WOULD NOT GO OVER 10MPH. IF THE CAR DID, THE ABOVE HAPPENED AGAIN. CAR WAS NOT DRIVABLE, AND WAS TOWED TO THE NEAREST TOYOTA DEALERSHIP. THE SITUATION WAS VERY DANGEROUS, AS THE BEHAVIOR OF THE CAR, NOT CONTROLLED BY MY WIFE, THE DRIVER, COULD HAVE EASILY CAUSED AN ACCIDENT. TURNS OUT, THE DEALERSHIP STATED THE STEERING ANGLE SENSOR WENT ON THE CAR. FIRST...THE CAR ONLY HAS 53K MILES ON IT. THIS IS NOT A 'WEAR AND TEAR' PART. THIS PART SHOULD NEVER GO WITH ONLY THIS MANY MILES ON IT. GARBAGE. SECOND, THE FAILURE OF THIS PART CAUSES A VERY DANGEROUS SITUATION ON THE ROAD, AS ONCE IT GOES, THE DRIVER BASICALLY HAS NO CONTROL OVER THE CAR UNTIL IT SLOWS DOWN TO UNDER 10 MILES AN HOUR. TOYOTA NEEDS TO STAND BEHIND THEIR PRODUCT, FOCUS ON THE SAFETY OF THE PUBLIC, AND ISSUE A RECALL FOR THIS PROBLEM. I'VE RESEARCHED THIS ON THE INTERNET AND THERE ARE MANY, MANY COMPLAINTS AND DOCUMENTED CASES OF THIS SAME PROBLEM HAPPENING ON TOYOTA VEHICLES. THE DEALERSHIP FIXED THE PART FOR $700. RIP OFF.
NHTSA complaint #10259942 — an unverified report by a vehicle owner.
STEERING
HEARD A CLICKING SOUND WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT.
NHTSA complaint #10250016 — an unverified report by a vehicle owner.
STEERING
WHILE DRIVING ON BUSY HIGHWAY THE STEERING OF MY TOYOTA BECAME IMPOSSIBLE I MANAGED TO GET CAR OFF OF ROAD . HAD VEHICLE TOWED TO GARAGE THE STEERING ANGLE SENSOR HAD GONE BAD THE MECHANIC ADVISED ME THAT THIS WAS A DANGEROUS SITUATION. I WAS ALSO INFORMED THAT THERE HAD BEEN A TECHNICAL SERVICE BULLETIN SENT OUT ON THIS SITUATION. I JUST FEEL THAT THE OWNERS NEED TO BE AWARE OF THIS SITUATION AND TOYOTA SHOULD TAKE SOME RESPONSIBILITY FOR THIS DANGEROUS DEFAULT.
NHTSA complaint #10247652 — an unverified report by a vehicle owner.
STEERING
AFTER STARTING MY CAR AND DRIVING IT TWO BLOCKS, THE VSC LIGHT AND AUDIBLE WARNING BUZZER WENT ON AT THE SAME TIME MY CAR LOST TRACKING AND STARTED VEERING TO THE LEFT. I WAS ABLE TO GET THE CAR HOME, BUT THE SAME THING HAPPENED AS SOON AS I DROVE IT 3 BLOCKS TO A SERVICE STATION. DIAGNOSTICS DISCOVERED THE STEERING ANGLE SENSOR WAS DEFECTIVE. THE PART WAS REPLACED FOR $630.11. I SEE THIS AS EXTREMELY DANGEROUS AS IT COULD HAVE POTENTIALLY RESULTED IN A CAR ACCIDENT.
NHTSA complaint #10247404 — an unverified report by a vehicle owner.
STEERING:RACK AND PINION:RACK
2004 TOYOTA HIGHLANDER LIMITED STEERING SYSTEM LOOSENESS, CLUNKING. THE STEERING SYSTEM EXHIBITS EXCESSIVE FREEPLAY AND CLUNKING. A DEFECTIVE PART WAS REPLACED UNDER WARRANTY BUT NEEDS TO BE REPLACED AGAIN. THE VEHICLE HAS LESS THAN 30,000 MILES ON IT.
NHTSA complaint #10220323 — an unverified report by a vehicle owner.
STEERING:COLUMN
HIGHLANDER RECENTLY RECEIVED 30K SERVICE AT TOYOTA DEALER. CAR MILEAGE WAS APPROXIMATELY 29K. THE SERVICE ADVISOR REPORTED THAT THE INTERMEDIATE SHAFT IN THE STEERING COLUMN WAS MAKING A CLUNK TYPE SOUND AND SHOULD BE REPLACED. HE BELIEVED HIGHLANDERS AND TACOMA'S HAD BEEN HAVING A PROBLEM. HE DID NOT THINK THE PART WOULD BREAK BUT THAT THE PART HAD BEEN REDESIGNED AND WILL NEED TO BE REPLACED.
NHTSA complaint #10219261 — an unverified report by a vehicle owner.
STEERING:RACK AND PINION:PINION SHAFT
I NOTICED A CLUNKING NOISE AND "SENSATION" IN THE STEERING WHEEL WHEN TRAVELING AT A SLOW SPEED ESPECIALLY WHEN TURNING CORNERS OR ON A BUMPY ROAD. IN DECEMBER, 2007 I TOOK THE HIGHLANDER TO THE DEALER AND WAS FIRST TOLD THAT IT WAS NOT A PROBLEM AND JUST NEEDED SOME LUBRICATION. WHEN I QUESTIONED THE SERVICE MANAGER FURTHER ABOUT THE POSSIBILITY OF IT BEING DANGEROUS, I WAS TOLD THAT IT "COULD BE A PROBLEM AND THAT THE STEERING SHAFT SHOULD BE CHANGED". I WAS TOLD THAT THE COLUMN COULD "LOCK UP", CAUSING LOSS OF STEERING. AFTER FURTHER QUESTIONING, THE DEALERSHIP GAVE ME A COPY OF THE TOYOTA TECHNICAL SERVICE BULLETIN DATED FEBRUARY 2006, OBVIOUSLY TOYOTA WAS WELL AWARE OF THE POSSIBLE DANGER, I WAS ALSO TOLD THAT IT WAS NOT AN UNUSUAL PROBLEM. THEY WOULD FIX THE PROBLEM AT A COST OF $450 TO ME SINCE THE CAR WAS NO LONGER UNDER WARRANTY. MY WARRANTY EXPIRED IN MAY OF 2007, ALMOST A YEAR AFTER THE TECHNICAL SERVICE BULLETIN WAS ISSUED. IT APPEARS THAT TOYOTA PURPOSELY HAS NOT ISSUED A RECALL IN ORDER TO SAVE MONEY. THOSE OF US WHO OWN A 2004 HIGHLANDER ARE NOW OUT OF WARRANTY AND OUT OF LUCK. SINCE THIS IS A POTENTIAL DANGER AND TOYOTA WAS AWARE OF THE PROBLEM FOR WELL OVER A YEAR, I BELIEVE THAT TOYOTA SHOULD BE RESPONSIBLE FOR ALL NEEDED REPAIRS AND A RECALL ISSUED.
NHTSA complaint #10213223 — an unverified report by a vehicle owner.
STEERING:COLUMN
BOUT MY 2004 HIGHLANDER 3 MONTHS AGO, USED, WITH 46K MILES ON IT. I TOOK IT TO MY MECHANIC LAST WEEK TO GET THE OIL CHANGED AND TIRES ROTATED. HE TOOK IT FOR A DRIVE AND SAID THAT IT WON'T PASS INSPECTION IN 3 MONTHS BECAUSE OF THE STEERING. THERE IS A CLUNK IN THE STEERING, WHICH I NEVER THOUGHT WAS ABNORMAL BUT HE SAID IT IS. HE ALSO SAID THERE IS A SERVICE BULLETIN OUT ON IT. I CALLED THE DEALER AND MADE AN APPOINTMENT FOR NEXT WEEK. I SERIOUSLY HAD BETTER NOT HAVE TO PAY FOR THIS.
NHTSA complaint #10212641 — an unverified report by a vehicle owner.
STEERING: STEERING WHEEL/HANDLE BAR
STEERING.
NHTSA complaint #10205189 — an unverified report by a vehicle owner.
STEERING
2004 TOYOTA HIGHLANDER BRAKES ENGAGED WHEN ACCELERATOR WAS DEPRESSED. CUSTOMER STATES THAT HE WAS IN A PARKING LOT HIT THE ACCELERATOR AND THE BRAKES APPLIED, AND THAT MADE THE ENGINE STALL. HE WAS UNABLE TO START THE VEHICLE. *KB THE DEALER FOUND THE STEERING ANGEL SENSOR WAS NOT OUT PUTTING CORRECTLY WHICH CAUSED THE VSC TO ACTIVATE.
NHTSA complaint #10203753 — an unverified report by a vehicle owner.
STEERING:GEAR BOX:SHAFT SECTOR
I BOUGHT USED 2004 TOYOTA HIGHLANDER AND NOTICED A HEARD A THUMPING SOUND THAT COULD ALSO BE FELT IN THE STEERING WHEN TURNING THE STEERING WHEEL AT SLOW SPEEDS. HAD AN ACCIDENT A FEW MONTHS LATER, WHERE ANOTHER VEHICLE HIT MY FRONT LEFT WHEEL. THE THUMPING GOT WORSE SO I MENTIONED IT TO THE BODY REPAIR SHOP. THEY HAD IT TOWED TO A TOYOTA DEALER EVEN THOUGH I HAD DRIVEN IT FOR 6 WEEKS AFTER THE ACCIDENT, WHERE THEY WERE TOLD THAT IT WAS NORMAL WEAR , 85,000 MILE,) ON THE INTERMEDIATE STEERING SHAFT, AND IT NEEDED TO BE REPLACED AT A COST OF $380 +. THE DEALER SERVICE DEPARTMENT SAID IT WAS NOT ACCIDENT RELATED. I STILL HAVE NOT HAD IT REPAIRED.
NHTSA complaint #10193839 — an unverified report by a vehicle owner.
STEERING:COLUMN
STEERING SHAFT ON THE 2004 TOYOTA HIGHLANDER DID NOT FEEL SAFE, FELT LOOSE AND NOISY WHEN TURNING. TOYOTA REFUSESD TO FIX THE PROBLEM UNDER WARRANTY, A TSB WAS ISSUED IN JANUARY 2006, WHICH INDICATED TOYOTA'S AWARENESS OF THE PROBLEM, BUT DID NOT WANT TO PUBLICLY ADMIT IT. WHILE DRIVING IT FELT LIKE THE STEERING COLUMN COUD BREAK OFF, AND IF THAT HAPPENED, IT COULD HAVE CAUSED MANY DEATHS.
NHTSA complaint #10190213 — an unverified report by a vehicle owner.
STEERING:GEAR BOX:SHAFT SECTOR
TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHEN MAKING A LEFT TURN THE CONTACT HEARD A CLICKING NOISE NEAR THE STEERING COLUMN. THE CONTACT STATED THAT UNDER NORMAL DRIVING CONDITIONS THE VEHICLE SWERVED WHILE DRIVING FORWARD. THE DEALER REPLACED THE STEERING SHAFT AND THE CLICKING STOPPED, HOWEVER, THE SWERVING CONTINUED. THE DEALER STATED THAT THE POWER STEERING RACK NEEDED TO BE REPLACED. THE CURRENT MILEAGE IS 46,000 , AND FAILURE MILEAGE WAS 41,000.
NHTSA complaint #10188944 — an unverified report by a vehicle owner.
STEERING:RACK AND PINION:RACK
TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHEN MAKING A LEFT TURN THE CONTACT HEARD A CLICKING NOISE NEAR THE STEERING COLUMN. THE CONTACT STATED THAT UNDER NORMAL DRIVING CONDITIONS THE VEHICLE SWERVED WHILE DRIVING FORWARD. THE DEALER REPLACED THE STEERING SHAFT AND THE CLICKING STOPPED, HOWEVER, THE SWERVING CONTINUED. THE DEALER STATED THAT THE POWER STEERING RACK NEEDED TO BE REPLACED. THE CURRENT MILEAGE IS 46,000 , AND FAILURE MILEAGE WAS 41,000.
NHTSA complaint #10188944 — an unverified report by a vehicle owner.
STEERING:COLUMN
NOISY STEERING SHAFT CAUSED ME TO TAKE CAR TO DEALERSHIP, WHERE I WAS TOLD THE SHAFT WAS 'WORN' (TINY BEARINGS WITHIN THE SHAFT WERE WORN) AND THE SHAFT WAS REPLACED. DEALER INFORMED ME THEY'D SEEN THIS PROBLEM ON OTHER TOYOTA HIGHLANDERS, AND ON THEIR ECONOMY TOYOTA PRISMS AS WELL, BUT MANUFACTURER HAD NOT ISSUED ANY RECALLS. I PAID THE BILL USING MY EXTENDED WARRANTY.
NHTSA complaint #10185765 — an unverified report by a vehicle owner.
STEERING
LOOSE AND NOISY STEERING SHAFT, DOES NOT FEEL SAFE TO DRIVE.
NHTSA complaint #10184188 — an unverified report by a vehicle owner.