2010 Toyota Sienna other reported problems

UNKNOWN OR OTHER

[XXX] [XXX] / [XXX] [XXX] 2010 Toyota Sienna Possible Shifter Interlock Failure: On [XXX] my [XXX] child found his way into the driver’s seat of our 2010 Toyota Sienna while the vehicle was parked in the driveway. According to my wife, there were no keys in the vehicle, and the vehicle was in park. In an instant, my wife (who was outside the van) helplessly observed the van begin to roll backward down the driveway and then across the sidewalk (on our side of the street), then across the street, and then across the sidewalk on the other side of the street and into the neighbor’s yard where it finally came to a rest. She said she heard something like grinding gears. I presume my son was trying to put it in park. Thankfully no property damage or personal injuries occurred during the incident. I [XXX] ) was not home when this happened. When I returned home, I inspected the van to see if my son was able activate the emergency shift lock release. I found the cover was intact and evidence of tampering was not observed. I then checked to see if I was able to pull the shifter out of park. Initially, I was unable to, but after a few tries and a little force, I was able to pull the shifter out of park (no keys in ignition, no brake compression, vehicle off) and the van began to roll. Our driveway is somewhat sloped. I replicated this procedure several times: a little force and a little wiggle and clunk, the shifter released and the van rolled. I discovered there was a recall for this very problem on 2010 Sienna’s (NHTSA Recall No.: 17V-657). I entered the Sienna’s VIN number on NHTSA’s website and found no active recall for the VIN number entered. I contacted Toyota of North America (1-800-331-4331) and chose to advocate and spoke to an agent and reported the problem. She was able to determine that the vehicle had been under the recall, but the van was “repaired” in 2020 which is the year we bought the van INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11733508 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

DASHBOARD HAS RECENTLY BECOME STICKY EVEN THOUGH WIINDSHIELD IS ROUTINELY COVERED.

NHTSA complaint #11363691 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

SLIDING DOOR CABLE SNAPPED UNEXPECTEDLY CAUSING DOOR TO BECOME INOPPERABLE. IT IS NOW JAMMED SHUT AND WILL NOT OPEN FROM INSIDE OR OUTSIDE, CAUSING A POTENTIAL SAFETY ISSUE. THIS IS SECOND DOOR WHERE THE CABLE HAS SNAPPED AND INOPERABILITY OF DOOR COULD BECOME A SAFETY ISSUE IF PASSENGERS NEED TO EXIT. TOYOTA WILL NOT STAND BEHIND THE DOOR AND ASKS UPWARDS OF $2K TO REPAIR.

NHTSA complaint #11277219 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

BOTH BACK SLIDING DOOR CABLES SNAPPED. HAVE BEEN ADVISED THE MOTORS SIEZED CAUSING THE CABLES TO SNAP. NEITHER DOOR WORKS. DRIVER'S SIDE DOOR CAN ONLY OPEN 6 INCHES. THIS IS A SAFETY HAZARD IN EVENT OF EMERGENCY. MY CHILDREN CAN NOT GET OUT OF THE CAR AND CAN NOT OPERATE THE ONE DOOR ABLE TO MANUALLY OPEN. FIX HAS BEEN ESTIMATED AT $1900 PER DOOR. TOYOTA KNOWS THIS IS AN ISSUE. THEY ISSUED A CUSTOMER WARRANTEE ENHANCEMENT FOR IT BUT IT HAS EXPIRED. THEY REFUSE TO REOPEN IT. THERE HAS BEEN A RECALL FOR THIS ON THE 2004-2009 MODEL YEAR AND CURRENTLY A RECALL FOR THIS FOR 2011-2018 MODELS BUT NOT THE 2010. THERE ARE HUNDREDS OF TOYOTA SIENNA'S ON THE ROAD WITH THIS ISSUE AND IT IS COMPLETELY UNSAFE AND TOTALLY UNACCEPTABLE THAT TOYOTA REFUSES TO TAKE RESPONSIBILITY FOR THE 2010'S AND COVER THE COSTS TO FIX THE PROBLEM.

NHTSA complaint #11255723 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

YEARS AGO, RESPONDING TO A RECALL ABOUT SPARE TIRE ASSEMBLY, THE DEALERSHIP SAID I WAS "FINE." ON 6 /23/2019, WHILE DRIVING AT HIGHWAY SPEED, NORTH TOWARD LAKE GEORGE, NY, JUST SOUTH OF EXIT 18, THERE WAS A LOUD THUMP UNDER THE VEHICLE, AND AS I WAS SITTING IN THE PASSENGER SEAT, SAW THE TIRE FLY OUT AND SLIDE ONTO THE GRASSY MEDIAN OF THE HIGHWAY. DRIVER ALSO SAW IT IN THE REAR VIEW MIRROR. WE WERE UNABLE TO STOP OR RETRIEVE THE TIRE. WHEN WE RETURNED FROM TRIP, I CALLED DEALER SERVICE REP. AND ASKED: WASN'T THIS DEFECTIVE SPARE TIRE ASSEMBLY PART OF AN OLD SAFETY RECALL? SERVICE REP. SAID THEY WOULD FIX SPARE TIRE ASSEMBLY. I DEMANDED THEY ALSO INCLUDE THE SPARE TIRE. AFTER CALLING TOYOTA, THEY AGREED. VEHICLE IS BEING WORKED ON.

NHTSA complaint #11233475 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

AUTOMATIC DOORS CONTINUING TO MALFUNCTION. I MADE A COMPLAINT TO DEALER ALMOST IMMEDIATLEY AFTER PURCHASE AND PROBLEM PERSISTS...I HAVE HAD MY DOORS REPAIRED SEVERAL TIMES AND I NOW HAVE 2 NON FUNCTIONING DOORS! IT HAS ALSO BEEN REPORTED TO MY CAR DEALER THAT THE REAR PASSENGER DOOR HAS OPENED WHILE I WAS DRIVING ON THE THRUWAY WITH MY CHILDREN.. I HAVE ALSO CALLED TO REPORT THE ISSUE AND TO PUT IN A COMPLAINT TO TOYOTA AND STILL HAVE THE ISSUE.

NHTSA complaint #11172680 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I AM AN ACTIVE DUTY SERVICE MEMBER TRYING TO PCS FROM GERMANY TO THE UNITED STATES. I NEVER RECEIVED NOTIFICATION OF THE RECALL. NOW THERE WILL BE A SIGNIFICANT DELAY IN SHIPPING OUR VEHICLE AND OUT OF POCKET EXPENSES IN THE FORM OF CAR RENTALS THAT COULD HAVE BEEN AVOIDED IF I WOULD HAVE BEEN NOTIFIED OF THIS RECALL.

NHTSA complaint #11089282 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

SLIDING DOOR POWER CABLE BROKEN. TOYOTA HAS ENHANCED WARRANTY FOR 2004-07 MY BUT WILL NOT FIX MINE BECAUSE IT IS 2010 MY.

NHTSA complaint #11089169 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

PASSENGER SIDE SLIDING DOOR. THE CABLE SNAPPED AND THE DOOR WOULD NOT FULLY OPEN.

NHTSA complaint #11042148 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

POWER SLIDING DOORS JAMMED IN THE CLOSED (OR PARTIALLY OPEN POSITION) AS THE DOOR CABLE GOT HUNG UP IN THE SLIDING MECHANISM. BOTH DOORS OF OUR VEHICLE ARE NOW AFFECTED. DRIVER SIDE SLIDING DOOR FAILED TO OPEN FULLY IN JAN 2017 - IT OPENED ABOUT 4 INCHES AND WOULD STOP. PASSENGER SIDE SLIDING DOOR FAILED TO OPEN AT ALL IN MAY 2017, IT WOULD MOVE A FRACTION OF AN INCH WHEN TRYING TO OPEN AND THEN GET JAMMED. THE VAN HAS SEEN MODERATE USE, AND THE DOORS WERE OPENED WITH THE AUTOMATIC MECHANISM (USED THE BUTTON) OVER 99% OF THE TIME. THE WEAR ON THE DOOR OPENING MECHANISM WAS NOT CAUSED BY INAPPROPRIATE MANUAL OPENING. AFTER THE PROBLEM, IN BOTH CASES THE ONLY WAY TO BE ABLE TO OPEN THE DOORS WAS TO PHYSICALLY BREAK THE GUIDE CABLES - WHICH WAS DONE FROM OUTSIDE OF THE VEHICLE. IT IS UNLIKELY TO BE DONE FROM INSIDE THE VEHICLE DUE TO HOW THE PERSON WOULD NEED TO STAND AND THE STRENGTH THEY COULD GENERATE, ESPECIALLY DURING AN EMERGENCY EVENT. FIX FOR THE PROBLEM IS OVER $1000 FOR EACH DOOR. REMEDY FOR ME IS THAT I CUT THE BROKEN CABLES AND WE OPEN THE DOORS MANUALLY NOW. I BELIEVE THERE IS A RECALL THAT COVERS THIS PROBLEM FOR 2004-2007 SIENNAS, BUT HAS NOT BEEN EXTENDED TO COVER THE SAME MODEL FOR YEARS 2008-2010. SNIPPET OF THIS IS: CERTAIN 2004 TO 2007 MODEL YEAR SIENNA VEHICLES EXTENSION OF WARRANTY COVERAGE FOR POWER SLIDING DOOR CABLE ASSEMBLY THIS CONCERNS THE CABLE ASSEMBLY, NOT THE LATCH ASSEMBLY.

NHTSA complaint #10984623 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

THE LATCH ON THE BACK DOOR MELTS WHEN THE WEATHER IS HOT, LEAVING A BLACK, TARRY MESS IN MY HANDS. NOW THAT THE WEATHER IS COLD, THE LATCH ON THE BACK DOOR IS FROZEN SOLID, MAKING IT EXTREMELY DIFFICULT TO OPEN THE BACK DOOR AT ALL. THIS COULD BE DANGEROUS IF I NEED TO OPEN IT QUICKLY. THE VAN IS, OF COURSE STATIONARY WHEN I TRY TO OPEN THE DOOR. THE DASHBOARD ALSO MELTS IN THE HEAT.

NHTSA complaint #10935508 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

CABLES FOR BOTH AUTOMATIC SLIDING DOORS SNAPPED. THE DOORS ARE BOTH COMPLETELY UNUSABLE, AS THEY WILL NOT OPEN AT ALL. AS MY 8 YEAR OLD WAS TRYING TO GET OUT OF THE VEHICLE, THE DOOR STOPPED WORKING AND WOULD NO LONGER WORK. THE DRIVERS' SIDE DOOR CABLE SNAPPED LAST WEEK, AND THE RIGHT ONE, TODAY.

NHTSA complaint #10901985 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

DRIVER SIDE DOOR CABLE SNAPS MAKING IT IMPOSSIBLE TO TOTALLY OPEN DOOR. WOULD BE DANGEROUS IN CASE OF EMERGENCY EXIT.

NHTSA complaint #10884889 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

BOTH POWER DOORS BROKE THE SAME WAY. THE CABLE FRAYED AND WAS PULLED INTO THE DOOR BY THE MOTOR. THE DOORS WOULD NOT OPEN AT ALL UNTIL SERVICED, WHICH CAUSED A SAFETY CONCERN! THE FIX WAS ESTIMATED AT $1,500 PER DOOR.

NHTSA complaint #10864924 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

POWER SLIDING DOOR CABLE SNAPP.

NHTSA complaint #10823961 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

POWER DOOR CABLE SNAPPED ON DRIVER SIDE REAR DOOR.

NHTSA complaint #10820671 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

CABLE SNAPPED ON REAR PASSENGER SIDE POWER DOOR NOVEMBER 2014

NHTSA complaint #10820670 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I HAVE A 2010 TOYOTA SIENNA WITH POWER DOORS. THE CABLE TO THE DRIVER'S SIDE REAR SLIDING DOOR SNAPPED WHEN I OPENED IT USING THE INTERIOR OPEN/ CLOSE BUTTON. I AM UNABLE TO OPEN THE DOOR MANUALLY MORE THAN 1 FOOT. TOYOTA ISSUED A WARRANTY POLICY BULLETIN (POL 12-02) CONCERNING POWER SLIDING DOOR CABLES FOR 2004 - 2007 SIENNA VEHICLES. UNDER THE SAME BULLETIN, THEY INCLUDED REAR SLIDING DOOR LATCH ASSEMBLIES ON CERTAIN 2004 - 2010 SIENNA VEHICLES. MY VEHICLE IS SPECIFICALLY LISTED IN THE VIN RANGE FOR 2010, BUT TOYOTA SAYS THE CABLE IS NOT COVERED. TOYOTA EXTENDED THE WARRANTY FOR 9 YEARS OR 120,000 MILES. SEEMS TO ME THERE IS SOME ISSUE RECOGNIZED BY TOYOTA CONCERNING THE DOOR CABLES AND DOORS. I HAVE NO WAY OF USING THAT DOOR AS AN EGRESS POINT.

NHTSA complaint #10762299 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

RECEIVED ANOTHER SAFETY RECALL NOTICE FOR A POTENTIAL EXCESSIVE CORROSION ON SPARE TIRE. STILL NO REMEDY. AS A TEMPORARY SOLUTION, TOYOTA WILL OFFER ROADSIDE ASSISTANCE AT NO CHARGE SHOULD THERE BE ANY TIRE ISSUES. HOWEVER, NO PHONE NUMBER/CONTACT INFORMATION IS PROVIDED FOR ROADSIDE ASSISTANCE ON THE NOTICE. I CALLED TOYOTA CUSTOMER SERVICE AND WAS TOLD THIS WAS AN OVERSIGHT AND THEY READILY PROVIDED ME WITH A NUMBER FOR A NATIONAL SERVICE. I AM NOT EXPERIENCING ANY PROBLEMS BUT AM CURIOUS AS TO THE LACK OF TRANSPARENCY BY NOT INCLUDING THE PHONE NUMBER IN THE NOTICE. IT HAS NEVER BEEN PROVIDED ON THE PAST INTERIM NOTICES THAT I WAS ABLE TO FIND. ALSO, DO THEY EVER PLAN ON FIXING OR IS IT A CALCULATED BUSINESS DECISION NOT TO FIX GIVEN COST?

NHTSA complaint #10723030 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

TRANSMISSION COVER BUSTED OPEN AT TOP WHILE I WAS DRIVING DOWN A BUSY ROAD. TRANSMISSION FLUID DRAINED CAUSING GEARS TO SEIZE.

NHTSA complaint #10690539 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

JUNE 2007 TOOK OUR SIENNA TO DEALER FOR WARRANTY REPAIR. THE PASSENGER DOOR WAS MAKING A POPPING NOISE AND WOULD NOT STAY OPEN WHEN PARKED FACING DOWNHILL. DEALER CLEANED THE LATCH MECHANISM AND THE DOOR WORKED FOR A MONTH. WE RETURNED TO THE DEALER FOR ADDITIONAL WARRANTY REPAIR IN SEPT. 2007. THEY AGAIN CLEANED MECHANISM BUT REPLACED NO PARTS. THE AUTOMATIC SLIDER DOOR CEASED WORKING SHORTLY AFTER THIS. WE CONTINUED TO USE BOTH SLIDER DOORS IN MANUAL MODE UNTIL JANUARY 2011. THE PASSENGER DOOR FAILED TO SEAL AND LATCH IN A CLOSED POSITION WITH THE BODY OF THE VAN. WE DROVE 70 MILES TO THE DEALER WHERE THEY WERE ABLE TO GET THE DOOR TO CLOSE BUT INFORMED US THAT THE DOOR HINGE AND LATCH MECHANISM NEEDED TO BE REPLACED. WE RETURNED 7 DAYS LATER TO HAVE THE REPAIRS DONE AND WE WERE TOLD THAT THE DOOR WHICH WOULD OPEN AND CLOSE, BUT NOT LATCH, 7 DAYS EARLIER WOULD NOW NOT OPEN AT ALL AND THE AUTOMATIC SLIDER DOOR CABLE WOULD NEED TO BE CUT TO PERFORM THE REPAIRS AND THEN WE WOULD NEED TO REPLACE THE AUTOMATIC DOOR MOTOR AS WELL. WE WERE ALSO INFORMED THAT THE DRIVER'S SIDE PASSENGER SLIDER DOOR WOULD ALSO NEED TO HAVE SIMILAR WORK AND THAT BY REPLACING THE HINGE WE COULD POSSIBLY SAVE THE LATCH AND AUTO SLIDER MOTOR ON THE DRIVERS SIDE. UNFORTUNATELY THERE WAS NO WARNING THAT THE SLIDER DOOR WAS GOING TO FAIL AND WE WERE SEVERAL MILES FROM A TOYOTA REPAIR SHOP WHEN THE LATCH PROBLEM OCCURRED. WE DROVE 70 MILES WITH THE DOOR UNSECURED.

NHTSA complaint #10379152 — an unverified report by a vehicle owner.