2011 Toyota Sienna door lock problems

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The contact owns a 2011 Toyota Sienna. The contact had received notification of NHTSA Campaign Number: 16V858000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the repair was not completed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated the power sliding door unexpectedly opened while driving on a local roadway. The vehicle was not repaired. The approximate failure mileage was 200,000. VIN tool showed no open recall.

NHTSA complaint #11732940 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The contact owns a 2011 Toyota Sienna. The contact stated that the air bag warning light was intermittently illuminated while driving. The contact stated that the warning light turned off while restarting the vehicle. Additionally, the contact stated that the sliding doors failed to function automatically and required to be opened or closed manually. The contact stated that while attempting to open the front driver's side door in icy and snowy weather, the door made an abnormal cracking sound and failed to open. The contact stated that the passenger's side door made an abnormal cracking sound but opened as intended. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 9,999.

NHTSA complaint #11715483 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The contact owns a 2011 Toyota Sienna. The contact stated that while driving 55 MPH, the rear driver's and passenger's power sliding doors failed to latch securely and opened while driving. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 16V858000 (Structure), but the failure persisted. The vehicle was taken to the dealer, who determined that the power sliding door motor, cable, and door lock actuators needed to be replaced. The dealer had to zip-tie the power sliding doors to keep the doors closed. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 135,000.

NHTSA complaint #11649207 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Passenger slidding door opens while driving . My child was in the back seat & could have been thrown out of the minivan Contacted Toyota recall was fixed Sept 6, 2017. Happened last week again 10/17/23, contacted Toyota and dealership will not do anything customer support program extension ended . This is a Toyota issue should be covered , there was a recall on this issue . Toyota says my responsibility to fix , this is unacceptable, the slidding doors are an issue with Toyota .

NHTSA complaint #11551621 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE PASSENGER'S SIDE SLIDING DOOR OPENED UNINTENTIONALLY. THE CONTACT CONTACTED DON JOSEPH TOYOTA (1111 W MAIN ST, KENT, OH 44240; (330) 673-2200) WHO INFORMMED THE CONTACT THAT THE DOOR HINGES AS WELL AS THE DOOR LATCH FOR THE PASSENGER'S SIDE SLIDING DOOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY OR RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

NHTSA complaint #11360748 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE DRIVING 30 MPH, THE PASSENGER SIDE SLIDING DOOR OPENED INDEPENDENTLY AND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO FALMOUTH TOYOTA (290 MACARTHUR BLVD, BOURNE, MA 02532) WHERE IT WAS DIAGNOSED THAT THE DOOR LATCHES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ORIGINALLY STATED THAT THE FAILURE WAS DUE TO THE ISSUE DESCRIBED IN NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE). THE DEALER LATER STATED THAT THE FAILURE WAS DUE TO A SEPARATE ISSUE. THE MANUFACTURER WAS IN THE PROCESS OF SPEAKING TO THE DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 146,000.

NHTSA complaint #11003074 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. WHILE TURNING A CORNER AT 15 MPH, THE PASSENGER SIDE SLIDING DOOR OPENED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT A SPRING IN THE DOOR FAILED AND THE DOORS NEEDED TO BE RECALIBRATED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS INCLUDED IN A RECALL REGARDING THE DOORS. THE NHTSA CAMPAIGN NUMBER WAS NOT PROVIDED. THE PARTS TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.

NHTSA complaint #10958885 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V340000 (AIR BAGS) FOR THE FRONTAL PASSENGER INFLATOR AND 16V858000 (LATCHES/LOCKS/LINKAGES). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA complaint #10958026 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V340000 (AIR BAGS), 16V643000 (LATCHES/LOCKS/LINKAGES), AND 11V560000 (EQUIPMENT). THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA complaint #10946534 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

I BELIEVE THERE POTENTIALLY MAY BE A SERIOUS DESIGN CONCERN WITH THE POWER DOORS. DUE TO HAVING THREE SMALL CHILDREN, I HAVE THE CHILD LOCKS ENGAGED ON THE REAR SLIDING DOORS, WHICH ALSO DISABLES THE REAR DOOR BUTTONS FROM OPENING (BUT NOT FROM CLOSING) THE POWER DOORS. THE BUTTONS IN THE FRONT OF THE VEHICLE TO OPERATE THE POWER DOORS ARE NOT AFFECTED BY THE CHILD LOCKS, BUT ARE LOCATED ON THE CENTER ROOF CONSOLE, IN EASY REACH OF A CHILD STANDING IN THE SECOND ROW. TONIGHT, IN MATTER OF SECONDS BETWEEN ME EXITING THE DRIVERS SEAT AND WALKING AROUND THE VEHICLE TO THE PASSENGER SIDE SLIDING DOOR, ONE OF MY SONS PRESSED THE BUTTON TO OPEN THE SLIDING POWER DOOR, WHILE MY DAUGHTER STARTED TO EXIT THE VEHICLE. MY THIRD CHILD THEN PRESSED A BUTTON AGAIN, CAUSING THE POWER DOOR TO SHUT ON MY DAUGHTER'S NECK. FORTUNATELY, THE SAFETY SYSTEM REVERSED THE DOOR, BUT IT INFLICTED PAIN AND TEARS AND LEFT REDNESS ON MY DAUGHTER'S NECK; THERE IS NO APPARENT LASTING INJURY, BUT I AM CONCERNED THE INJURIES COULD HAVE BEEN MUCH MORE SERIOUS. I AM ALSO CONCERNED THAT THE PLACEMENT OF FUNCTIONAL ELECTRONIC CONTROLS FOR THE REAR DOORS IN EASY REACH OF CHILDREN IN THE REAR COMPLETELY DEFEATS THE PURPOSE OF HAVING CHILD LOCKS ON THE REAR DOORS. ALSO RELATED TO THE REAR DOORS, WE HAVE REPEATEDLY EXPERIENCED THE PROBLEM REPORTED BY OTHERS OF THE POWER DOORS JAMMING IN A PARTIALLY OPEN POSITION AND HAVING TO BE SLOWLY PUSHED CLOSED MANUALLY (WITH GREAT RESISTANCE), BEFORE THEY WILL FUNCTION AGAIN NORMALLY IN EITHER POWER OR MANUAL MODE. THIS COULD BE A SAFETY CONCERN THAT COULD IMPEDE THE ABILITY TO EXIT THE VEHICLE IN AN EMERGENCY.

NHTSA complaint #10433085 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

MY NEW 2011 TOYOTA SIENNA LE AUTOMATIC POWER SLIDING DOOR ON THE DRIVER SIDE STOPPED WORKING. IT WON'T OPEN OR CLOSE USING REMOTE CONTROL AS WELL AS TOP CONSOLE/PILLAR SWITCHES. IF I TRY TO OPEN USING REMOTE CONTROL OR SWITCHES THEN IT WILL TRY TO OPEN BUT CLOSE IMMEDIATELY AND MAKE BEEPING SOUNDS. I TOOK THE VEHICLE TO THE LOCAL TOYOTA DEALER COUPLE OF TIMES BUT THEY SIMPLY SAID THERE IS NO PROBLEM. FINALLY, WHEN I CALLED TOYOTA DIRECTLY THEN THE SAME DEALER DIAGNOSED IT FURTHER AND FOUND A FAULT CODE C224 IN THE SYSTEM. TOYOTA REFUSED TO FIX THE ISSUE PROMPTLY UNTIL WE FILED FOR ARBITRATION TO REPLACE THE CAR OR REFUND VEHICLE PURCHASE PRICE. TOYOTA FINALLY REPLACED POWER SLIDING DOOR MOTORS FOR BOTH LEFT AND RIGHT SIDE TO ADDRESS THE ISSUE.

NHTSA complaint #10392924 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

2011 TOYOTA SIENNA LE POWER SLIDING DOORS HAVE JAMMED MULTIPLE TIMES. HAS HAPPENED 4-5 TIMES NOW WITH ONLY 285 MILES ON IT. THIS IS POTENTIALLY A VERY SERIOUS MALFUNCTION THAT COULD COST A LIFE. ALL PASSENGERS SHOULD BE ABLE TO EVACUATE IF NEEDED. CALLED TOYOTA BUT THEY SAY THEY HAVE NOT GOTTEN ANY COMPLAINTS? WILL TAKE IT IN AND SEE WHAT THEY SAY.

NHTSA complaint #10386513 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

LATCHES ON THE REAR SLIDING DOORS OF OUR 2011 TOYOTA SIENNA LTD. ARE NOT RELEASING PROPERLY. WHEN THE DOORS ARE OPENED FROM THE HANDLES, THE MOTOR PULLS THE DOORS OPEN BUT THE LATCHES DO NOT RELEASE. YOU HEAR A POPPING SOUND AND THE DOORS POP OPEN. DEALER "REPROGRAMMED" THE DOORS TO NO AVAIL. AFTER DEALER CLAIMED TO HAVE CONTACTED TOYOTA, THEY ACKNOWLEDGED THE PROBLEM BUT SAID THERE IS NO KNOW FIX, AS THIS IS A NEW VEHICLE.

NHTSA complaint #10379987 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

IN NOVEMBER OF 2010, WE PURCHASED 2011 TOYOTA SIENNA XLE. WITHIN A MONTH, ON TWO SEPARATE OCCASIONS- THE AUTOMATIC SLIDING DOORS GOT STUCK MIDWAY. THEY WOULD NOT MOVE BACK OR FORWARD. WE TOOK IT TO THE ORIGINAL DEALERSHIP. WE WERE TOLD THAT TOYOTA HAD THEM CLEAR SOME "CODES" FOR THE AUTOMATIC DOORS AND THE PROBLEM WAS FIXED. TWO WEEKS LATER, THE SAME PROBLEM IS HAPPENING ON BOTH DOORS. WE TOOK THE CAR BACK AND THE SERVICE MANAGER INFORMED US THAT TOYOTA WOULD NOT AUTHORIZE NEW MOTORS IN THE CAR, ALTHOUGH IT IS A BRAND NEW CAR AND UNDER WARRANTY. THIS IS A TOYOTA MANUFACTURING PROBLEM AND NEEDS TO GET RESOLVED!

NHTSA complaint #10378177 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT STATED THAT THE DRIVER AND PASSENGER AUTOMATIC SLIDING DOORS WOULD FAIL INTERMITTENTLY. THE DRIVER SIDE SLIDING DOOR WOULD OFTEN CLOSE INDEPENDENTLY WHILE THE CONTACT WAS STANDING IN THE DOORWAY. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT THE VEHICLE WOULD NEED TO BE FURTHER INSPECTED BY AN ENGINEER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 900. UPDATED 03/29/11 *BF UPDATED 05/02/11

NHTSA complaint #10377190 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL*THE CONTACT OWNS A 2011 TOYOTA SIENNA. THE CONTACT OBSERVED DURING THE OPENING OF EITHER ONE OF THE TWO PASSENGER SIDE POWER DOORS THERE WOULD BE AN UNUSUAL POPPING NOISE. ALSO, THE POWER DOORS FAILED TO LATCH PROPERLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE TECHNICIAN INFORMED THAT THE POWER DOORS FUNCTIONED AS DESIGNED. THE FAILURE MILEAGE WAS 3,000.

NHTSA complaint #10353291 — an unverified report by a vehicle owner.